260062_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2019.
Please do not leave any question unanswered. Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Farm Number: 26-0062 Certificate Of Coverage Number: AWS260062
2. Facility Name: Ric♦. \ Hall Farm
3. Landowner's Name (same as on the Waste Management Plan): Ricky N Hall
4. Landowner's Mailing Address: 3468 Barbwire Rd
City: Roseboro State: NC Zip: 28382
Telephone Number: 910-531-4476 Ext. E-mail:
5. Facility's Physical Address: 3146 Barbwire Rd
City: Roseboro State: NC Zip: 28382
6. County where Facility is located: Cumberland
7. Farm Manager's Name (if different from Landowner):
8. Farm Manager's telephone number (include area code):
9. Integrator's Name (if there is not an Integrator, write "None"): Prestaae Farms Inc
10. Operator Name (OIC): Rick) N. Hall Phone No.: 910-531-4476 OIC #: 18682
11. Lessee's Name (if there is not a Lessee, write "None"):
12. Indicate animal operation type and number:
Current Permit: Operations Type Allowable Count
Swine - Wean to Feeder 6,080
Operation Types:
Swine Cattle Dry Poultry Other Types
Wean to Finish Dairy Calf Non Laying Chickens Horses - Horses
Wean to Feeder Dairy Heifer Laying Chickens Horses - Other
Farrow to Finish Milk Cow Pullets Sheep - Sheep
Feeder to Finish Dry Cow Turkeys Sheep - Other
Farrow to Wean Beef Stocker Calf Turkey Pullet
Farrow to Feeder Beef Feeder
Boar/Stud Beef Broad Cow Wet Poultry
Gilts Other Non Laying Pullet
Other Layers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Fes-"
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(Inches)
1
/—) 6 -` _r
14 kezi -/
I .573 ?,j,'
/5-33,:e
-S3)1p o
19.00
2
I-.a1--sr
e IR-I
;3 ilvc
19.00
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d) to the address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan (WUP), signed b► the owner and a certified technical specialist, containing:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: [e-mail]

1 attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation, signature should be by a principal executive officer of the corporation):
Name: l � �t ■1��lf Title: CL"Ne/4-
Signature:
Name:
Signature:
Name:
Signature:
Date: /f /
le, / fl . 794J' / Title: 6 G✓A-/Z
ate: — /4(9 4,
Title:
Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
E-mail: [e-mail]
FORM: RENEWAL -STATE GENERAL 02/2019

ROY COOPER
Governor
MICHAEL S. REGAN
Secretory
LINDA CULPEPPER
Director
Ricky N Hall
Ricky Hall Farm
3468 Barbwire Rd
Roseboro, NC 28382
�I rr
NORTH CARQLINA
Environmental Quality
February 27, 2019
MAR 2 6 2O !c
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at hups://deq.nc.gov/about/divisions/water-resources/water-quality -regional-operations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure your continued coverage under the State Non -Discharge General Permits- you must submit an application for
permit coverage to the Division. Enclosed you will find a "Request for Certificate of Coverage Facility Currently Covered b+ an
Expiring State Non -Discharge General Permit." The application form must be completed- signed and returned by April 3, 2019.
Please note that you must include one .(1) copy of the Certified Animal Waste Management Plan {CAWMP} with the
completed and signed application form. A list of items included in the CAWMP can be found on page 2 of the renewal
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please_ feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Enclosures
cc (w/o enclosures):
Sincerely,
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Fay etteville Regional Office, Water Quality Regional Operations Section
Cumberland County Soil and Watexkensezwatian District
AFOG Section Central Files: AWS260062
Prestage Farms Inc \ ____--------
/
r_.,,_ „ 1&3
North Camino Department of Environmental Quality 1 Divisionof'. e.e =e ^Es
512 N. Sassbary St 16 Nail Service Center I Raleig14, Norton Cs: • i <- c 33-1636
...9318.7df7 9L)Off

Version —November 26, 2018
Mortality Management Methods
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location map and plan.
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
Rendering at a rendering plant licensed under G.S. 106-168.7.
I T1 EI Complete incineration according to 02 NCAC 52C .0102.
El ❑ A composting system approved and permitted by the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
0 ❑ In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
El El Any method which, in the professional opiniongof the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
•
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be: done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
Signature of Farm Owner/Manager
ila.p/tiLe2
12/J
Signature of Technical Specialist
Date
Date

g•
1/11/2019
NUTRIENT UTILIZATION PLAN
Grower(s):
Farm Name:
County:
Ricky Hall
Ricky Hall Farm; AWS260062
Cumberland
Farm Capacity:
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish
6080
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
>180 days
irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor -
problems.
6. To maximize the value of the nutrients for crop production and to reduce the p
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 11

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft3, tons, etc.):
Capacity Type Waste Produced per Animal Total
Farrow to Wean
Farrow to Feeder
Farrow to Finish
6080 Wean to Feeder
Feeder to Finish
3212 gal/yr
4015 gal/yr
10585 gal/yr
223 gal/yr
986 gal/yr
gal/yr
gal/yr
gal/yr
1,355,840 gal/yr
gal/yr
Total 1,355,840 gal/yr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs):
Capacity Type Nitrogen Produced per Animal Total
6080
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish
5.4 Ibs/yr
6.5 Ibs/yr
26 Ibs/yr
0.48 lbs/yr
2.3 Ibs/yr
Ibs/yr
Ibs/yr
Ibslyr
2,918 lbs/yr
Ibslyr
Total 2,918 Ibs/yr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage:
Total N Required 1st Year:
Total N Required 2nd Year:
Average Annual Nitrogen Requirement of Crops:
Total Nitrogen Produced by Farm:
Nitrogen Balance for Crops:
20.29
4565.25
2840.6
3,702.93
2,918.40
(784.53)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility
2 of 11

Reception Area Specifications Year 1 of a 2 year crop rotation
Tract Field Irrigated Soil 1st Crop Time to 1st Crop 1st Crop Lbs N/Ac Lbs N Total lbs N
Hyd Acreage Type Code Apply Yield lbs N/Unit Residual IAc Utilized
2nd Crop Time to 2nd Crop 2nd Crop Lbs N/Ac Lbs N Total Ibs N
Code Apply Yield lbs N/Unit Residual /Ac Utilized
Total
Lbs N/Ac
Total lbs N
Utilized
Butters
105.00
2130.45
Sept -Mar
50
120.00
2434.80
225.00
4565.25
r
r.
Totals: 20.29 2130.45 2434.80
4565.25
3(a) of 11

Reception Area Specifications Year 2 of a 2 year crop rotation
Tract Field Irrigated Soil 1st Crop
Acreage Type Code
Time to
Apply
1st Crop 1st Crop Lbs N/Ac Lbs N Total Ibs N
Yield Ibs NIUnit Residual /Ac Utilized
2nd Crop Time to 2nd Crop 2nd Crop Lbs NIAc Lbs N Total Ibs N
Code Apply Yield Ibs N/Unit Residual IAc Utilized
Total
Lbs NIAc_
Total Ibs N
Utilized
140.00
2840.60
0.00
0.00
140.00
2840.60
(
Totals: 20.29 2840.60 0.00
2840.60
3(b) of 11

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
A
B
C
D
E
F
G
H
J
K
L
M
N
0
P
Crop
Barley
Hybrid Bermudagrass - Grazed
Hybrid Bermudagrass - Hay
Corn - Grain
Corn - Silage
Cotton
Fescue - Grazed
Fescue - Hay
Oats
Rye
Small Grain - Grazed
Small Grain - Hay
Grain Sorghum
Wheat
Soybean
Pine Trees
Lbs N utilized / unit yield
1.6 lbs N / bushel
50 Ibs N / ton
50 Ibs N / ton
1.25 Ibs N / bushel
12lbs N/ton
0.12 lbs N / Ibs lint
50 lbs N / ton
50 lbs N / ton
1.3 Ibs N / bushel
2.4 Ibs N / bushel
50 Ibs N / acre
50 Ibs N / acre
2.5 Ibs N / cwt
2.4 Ibs N / bushel
4.0 lbs N / bushel
40 Ibs N / acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4 of 11

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PAN/yr/animal Farm Total/yr
Farrow to Wean 0.84
Farrow to Feeder 1
Farrow to Finish 4.1
6080 Wean to Feeder 0.072 437.76
Feeder to Finish 0.36
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 437.76 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 2188.8 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 7 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 17.5104 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 11

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil Application Rate Application Amount
Tract Hydrant Type Crop in/hr * inches
4232&4237 P1 Butters D 0.6 1
6 of 11

Additional Comments:
This plan revised to reflect the pivot acres instead of the pulls. The crop
yields, application rates and windows remained the same as in the previous
plan written by David Faircloth dated 5/1/2001.
The pivot acres may be split into sections P1A and P1B as shown on the
irrigation map if desired and planted to different crops, so long as the current
rotation is maintained (i.e. P1A planted in soybeans and P1B planted in corn).
7 of 11

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm:
Owner:
Manager:
Ricky Hall Farm; AWS260062
Ricky Hall
Owner/Manager Agreement:
Uwe understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
Uwe understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Ricky Hall
Signature:
/5 y -1(
Name of Manager (if different from owner):
Signature:
Date
Name of Technical Specialist: M. Kevin Weston
Affiliation: Private
Address: 237 A.I. Taylor Road
Richlands, NC 28574
Telephone: [phone]
Signature:
8 of 11
"/,/f7
Date

1
2
3
NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recieving crop type, or available land.
Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic
crop yields based upon soil type, available moisture, historical data, climatic conditions,
and level of management, unless there are regulations that restrict the rate of applications
for other nutrients.
4 Animal waste shall be applied to land eroding Tess than 5 tons per acre per year. WastO
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons;
per acre per year provided grass filter strips are installed where runoff leaves the field.
(See USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and
flies.
Animal waste shall not be applied to saturated soils, during rainfall events, or when the
9 of 11

9
NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted craps on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11
12
13
14
15
16
Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property
boundary and canal. Animal waste, other than swine waste from facilities sited on or after
October 1, 1995, shall not be applied closer than 25 feet to perennial waters.
Animal waste shall not be applied closer than 100 feet to wells.
Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
Waste shall be applied in a manner not to reach other property and public right-of-ways.
Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
10 of 11

17
18
19
NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21
Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
23
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
Dead animals will be disposed of in a manner that meets North Carolina regulations.
11 of 11

19
Rice y Hall Far
AWS260062
Pivot Add't.
Specifications: Pivot
Valley Standard Pivot 7000
Machine Length — 582.3' (228.2 GPM)
End Gun Radius — 85.5' (71.8 GPM)
® 55 PSI; 300 GPM Total
Ricky Hall Farm
Pivot P1
3/4 Circle (270 Degrees)
18.04 Ac. w/o End Gun
20.29 Ac. w/End Gun
End Gun Runs 106 Degrees
Pivot P1A_
1/4 Circle (90 Degrees)
6.11 Ac. w/o End Gun
7.30 Ac. w/End Gun
End Gun Runs 56 Degrees
GRAPHIC SCALE
200
400
( IN FEET )
1 inch = 400 ft.
800
James Ray Hall Farm
AWS260008
®
Well
,w/too'
Setback
Pivot P1A
Pivot P1
Pivot P1B
Pivot P16
1/2 Circle (180 Degrees)
11.93 Ac. w/o End Gun
12.99 Ac. w/End Gun
End Gun Runs 50 Degrees
Well
iw/100'
Setback
Wells
/100'
Setbacks
Ricky Hall Farm
AWS260062
Y

Type of Operation:
Size of Operation:
Volume Required
Volume Designed
Hall Brothers Farms
Animal Waste Lagoon
Fayetteville Field Office
Cumberland County, N.C.
Design Approval Sheet
Swine Wean to Feeder
3040 pigs
144,505 cu. ft.
153,378 cu. ft.
Excavation
Not calculated by Natural Resources Conservation Service
personnel, see design sheets beginning on page 25 for volume
estimates.
Job Approval
Job Classification II
Designed By: Glenn Clifton, Prestage Farms Date 1 /20/1995
Checked By : 7c-.2Q,1,4 Date 1 /25/1995
Approved By: �t �. -- Date / / a S / i 95

U. S. Department of Agriculture NC-ENG-34
Soil Conservation Service September 1980
File Code: 210
Landowner
HAZARD CLASSIFICATION DATA SHEET FOR DAMS
�.R• County
Community or Group No. Conservation Plan No.
Estimated Depth of Water to Top of Dam lb Ft. Length of Flood Pool \c D Ft.
Date of Field Hazard Investigation \— 5
Evaluation by reach of flood plain downstream to the point of estimated minor effect
from sudden dam failure.
Est. El ev. :Est. evati on
•
• Kind of :Improvements: of Breach
Reach: Length: Width: Slope:. ▪ Land Use : Improvements : Above :Floodwater Above
•
Flood Plain: Flood Plain
Ft. Ft. % •
Ft.' Ft.
_S '--,c.•,r o-r-2-._ : -
1 l
:D., a D ,•
2
•
•
•
3
•
•
•
•
•
•
Describe potential for loss of life and dams a to existng or pre future ownstream
improvements from a sudden breach Ja
k.•-•-•ts•-•-,- v...1,-4)-4,....A -kk.b-v•-) .....--..... &4:,-,....----, g.•••:+-4--• (..•-riv••••,-, t ci. fl.".4-i- 11 fr:434-•
.:-A----"'C1.w• c,..a-1/4_ -,., c1/4. %Q4 N .0 . apt a '1
kH
Hazard Classification of Dam (a, b, c) (see NEM-Part 520.21) Q o,r;•
Dam Classification0!) II, III, IV, V)
•
8y �13.+� S.L•S \ Qc.L Date \ 1S - `i S
(name (title)
Concurred By
NOTE: 1. Instructions on reverse side.
2. Attach additional sheets as needed.
Date 1 z0)----

;IA
ND
0
co
Y
Beaverdam
FAS Sch.
Peters
Creek
Ch. ,
-0
co,
2048 o
0 GS !
-‘•o
ti0 NOTE: MAP INCLUDES ONLY STATE MAINTAINED ROADS
OR IMPORTANT NON -SYSTEM ROADS.
MILEAGE NOT SHOWN ON FRONTAGE ROADS.
ROADS SHOWN AS OF JAN. 1, 1974.
• 53
KEY TO COUNTY ROAD NUM1
ALSO NUMBERS 1001 , 1002 , 1003 ,
1 005 , 1006

UNITED STATES SOIL
DEPARTMENT OF CONSERVATION
AGRICULTURE SERVICE
WASTE MANAGEMENT FACILITY SITE EVALUATION
GENERAL INFORMATION
NAME
T ELEPHONE q` 5 3 1- 5 `t3
LOCATIO°A
SIZE OPERATION- `}-g--►----
LOCATION DATA
DISTANCE FROM NEAREST RESIDENCE NOT OWNED BY
PRODUCER VS ° �-'-FT .
IS SITE WITHIN 100-YEAR FLOOD PLAIN? YES
If yes, SCS cannot provide assistance.
IS SITE AT LEAST 100 FT. FROM A "BLUE LINE"
PERENNIAL STREAM? YES
If no, site must be relocated.
NO-Y-
NO----
IS SITE WITHIN 1 MILE ZONING JURISDICTION /
OF A MUNICIPALITY? YES NO---
If yes, landowner should consult with local zoning board
about required permits. Permits must be obtained prior
to design approval.
Are utilities in construction area? YES NO ----
If yes, see Part 503 of the National Engineering Manual
and follow policy.
(Copies of maps or other reference materials may be
attached to site evaluation.)
Page 1

WETLANDS
WILL SITE INVOLVE CLEARING WOODLAND OR ANY
NON -CROPLAND? YES-L - NO ----
If yes, producer must complete a Form AD-102k.
WILL ACTION RESULT IN SWAMPBUSTING? YES- NO -
IF WETLANDS ARE INVOLVED, IT IS THE RESPONSIBILITY OF THE
PRODUCER TO CONTACT THE US ARMY CORP OF ENGINEERS AND THE
DIVISION OF ENVIRONMENTAL MANAGEMENT TO DETERMINE IF
ADDITIONAL PERMITS ARE REQUIRED. NO WETLANDS SHOULD BE
ALTERED UNTIL PRODUCER RECEIVES WRITTEN APPROVAL FROM SCS,
US ARMY CORP OF ENGINEERS AND NC DIVISION OF ENVIRONMENTAL
MANAGEMENT.
(A copy of AD-1026 and CPA-026 should be attached to
site evaluation.)
OTHER ENVIRONMENTAL FACTORS
IS ENDANGERED AND/OR THREATENED SPECIES HABITAT
PRESENT? YES---- NO ----
IS A DESIGNATED NATURAL SCENIC AREA INCLUDED IN THE
PLANNING AREA OR WILL PLANNED ACTIONS IMPACT ON AN J
ADJACENT NATURAL SCENIC AREA? YES---- NO- ✓ -
IS AN ARCHAEOLOGICAL OR HISTORICAL SITE LOCATED IN THE
PLANNED AREA? YES---- NO— -
ARE THERE PRIME, UNIQUE, STATE OR LOCALLY IMPORTANT
FARMLANDS IN THE OPERATING UNIT? YES---- NO--✓ -
WILL THE ACTION RESULT IN SODBUSTING? YES---- NO- --
If yes to any of these questions, refer to form NC-CPA-16
for policy sources. The form does not need to be
completed.
ODOR CONTROL
HAS ODOR CONTROL BEEN DISCUSSED WITH PRODUCER
PREDOMINANT WIND DIRECTION? NO ----
POSSIBLE EXPANSION OF TREATMENT
VOLUME FROM 1 CU.FT. UPWARDS TO
3 CU. FT./LB. OF ANIMAL? YES- NO----
PRECHARGING LAGOON WITH FRESH
WATER TO AT LEAST 1/2 OF THE
CAPACITY? YES- -- NO ----
USING GOOD SOUND JUDGMENT IN
LAND APPLICATION OF WASTE? YES- NO ----
Page 2

WASTE MANAGEMENT
DOES PRODUCER OWN ENOUGH LAND TO PROPERLY LAND
APPLY WASTE? YES---- NO ----
IF NO, DOES PRODUCER HAVE ACCESS TO �a
MORE LAND? YES-`- NO ----
IF LAND IS NOT OWNED BY PRODUCER,
CAN PRODUCER GET AGREEMENT ON LAND
ON WHICH TO APPLY WASTE? YES- '- NO ----
(Attach Waste Utilization Plan to site evaluation.)
SOIL INVESTIGATION -- VALID ONLY IF SOIL INVESTIGATION
SHEET ATTACHED
IS SOIL SUITABLE FOR LAGOON? YES NO
IS A CLAY LINER REQUIRED? YES--- - NO
IF YES, IS CLAY AVAILABLE ONSITE? YES NO
QUESTIONABLE--
IS A CORE TRENCH REQUIRED? YES NO `�
(Attach soil investigation sheet to site evaluation.)
SITE APPROVED YES---- NO CONDITIONAL
COMMENTS
THIS SITE INVESTIGATION IS VALID AS LONG AS THE DESIGN AND
CONSTRUCTION OF LAGOON CONTINUES IN REASONABLE TIME
PERIOD. UNDUE DELAYS Q7 HESITANCY IN CONSTRUCTION MAY
REQUIRE THAT S Ar L:: LTION BE k*IVALIDATED.
SIGNAT
- DATE 3 -
MAR 2 6 2019
Page 3
A
7

9
Operator:RICKY HALL
County: CUMBERLAND Date: 01/05/95
Distance to nearest residence (other than owner): 1500.0 feet
1.
2.
AVERAGE LIVE WEIGHT (ALW)
0 sows (farrow to finish) x 1417 lbs. = 0 lbs
0 sows (farrow to feeder) x 522 lbs. = 0 lbs
0 head (finishing only) x 135 lbs. = 0 lbs
0 sows (farrow to wean) x 433 lbs. = 0 lbs
3040 head (wean to feeder) x 30 lbs. = 91200 bs
Describe other
Total Average Live Weight = 91200 lns
MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 91200 lbs. ALW x Treatment Volume(CF)/lb. ALW
Treatment Volume(CF)/lb. ALW = 1 CF/lb. ALW
Volume - 91200 cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 cubic feet
TOTAL DESIGNED VOLUME
SLUDGE ACCUMULATION NOT CCMPUTED
AT OWNERS REQUEST. REMOVE SLUDGE
AS NEEDED --
inside top length (feet) ---------------------
Inside top width (feet) ------------------------
Top of dike elevation (feet) -------------------
Bottom of lagoon elevation (feet)------------
Freeboard^(feet)-----------------------------
Side slopes (inside lagoon) ----------------
Total design volume using prismoidal formula
140.0
39.5
1.0
3.0
SS/END1 SS/END2 SS/SIDE! SS/SIDE2 LENGTH WIDTH
3.0 3.0 3.0 134.0 184.0
AREA OF TOP
LENGTH * WIDTH =
134.0 184.0
AREA OF BOTTOM
LENGTH A WIDTH =
130.0
AREA OF MIDSECTI]N
LENGTH * WIDTH A 1
107.0 157.0
2465a (AREA OF TJP
0400 (AREA OF BOTTYM
17196 AREA OF wIDSETT
CU. FT. = [AREA TOP + 14*AREA MIDSECTI ) + AREA BOTTON3
24656.0 10400.�
DEP0 1
90
A4
^
Total Designed z ume 'valab e = ZK 8 C�
F-

5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
140.0 190.0 26600.0 square fee
Buildings (roof and lot water)
0.0 square feet
TOTAL DA 26600.0 square feet
Design temporary storage period to be 180 days,
5A. Volume of waste produced
Feces & urine production in gal./day per 135 lb. ALW
Describe this area.
37
19
Volume = 91200 lbs. ALW/135 lbs. ALW A 1.37 gal/day 180 days
Volume = 166592 gals. or 22271.7 cubic feet
5B. Volume of wash water
This is the amount of fresh water used for washing floors or volame
of fresh water used for a flush system Flush systems nhat recirculal
the lagoon water are accounted for in 50.
Volume =
0.0 gallons/day 180 cays storage/7 48 gallons
oer CF
Volume = 0.0 cubic feet
Volume of rainfall in excess of evaporati-'
Use period of time when rainfall exceeds ev.poration by argent amo.'n
180 days excess rainfall = 7.0 Inches
Volume = 7.0 in V DA / 12 inches ner f �!.:
Volume = 15516.7 cubic feet

5P. Volume of 25 year r - 24 hour storm
Volume = 7.0 inches / 12 inches per foot * DA
Volume = 1551 A.7 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5' t 22272 cubic feet
5F?. 0 cubic feet
5C. 15517 cubic teed
5D. 15517 cubic feet
TOTAL 53=05 c ib7,ir_ feet
6. SUMMARY
Temrpor. ry storage period====================> 1 i t days
f.. n� a 1 �excessof ee- V:_e !'Y ti i i ..0 inches
_._. f_. in ,_.el �_. r!_���.=��_ :-.-,�.-,:•
25 year - 24 hour rainfall7.0 inches
Fee7 oarr= =:-===== _.==_:=-'-------_==__..__..==..._=._=_...._=•.. 1.0 feet
side r-i J �_5 j ^-[_-- _-_:__. - __C=.= _ .': _. _.- �: r 1
Tfeet
...t; !e;i rie fop1 ejir''r_F7=�::��-. _ �•�-::y.��'.�.:_ _ -:_ -._ -:=r=� � +.:�_:.-.�7" i. =tt � :, � � ! 7.-' := �._
Insides top 1_90_i ''_....
Top !-Y of dike 7- el e a a" - s J_. '.
r , _... _. _._ -- -_. _... 5
i"; rjT "f�C!!! 7J !=+_!r-i r�.�7_�j-E ?=' 1 t: b'T_';F CT'i ._...--._--..... __-._-.-__�' •_:••-i' - :F feet
Total equ red volume=======================> 144505 cL7 . 1' i- *
....r '7 -i v,'r i 1 iTY F'•=____".--___.__::::_._:.._:-. _.':_::_.=__:_._=_.: -'-__•..: _5.3... R :h
8 _lI : a . �i 41 t__tab1 Celevation ( SWT)==: 45.4 feet
Stop pumping e ev _.._..-•------_..._....__._.__ _._....___._.. =7 feet
MI_tst be > or = to the SHWT ele-,•a -__.._=-___._..:-=-• 45.4 feet
Must be > or - to min. req . treatment el==> 45.5 feet
_ ,•�
Required iTlir?_CiTi!I,jf! treatment JL�1Lir?'!!:-��-.-_=:_-_��.--_-:--:;�• 91200 r1_'sa it.
Volume at stop pumping ''`._�_'_.. cuf ...c
start pumpina Z -v____.-.____.._-_..--__._-.__._.____.___-___.___-_._ •.
feet
47
-
Must be et bottom of freeboard & 25 yr. rainfall
Actual volume lass :5•r,- 24
hr., ra.in!f21l.=• . 137861 ft.
Volume at start pumpino e1ev._•tti or-!-c.a_..._...___._.... . 136582 -_ _5;8, =Li ..ft.
Required vol L mr i.o be p71_tmped r__:_c_. =..__.._.._ ==..._==--• . 37788 _ t
�'- - i _ �.._. - ' -- - -- - '7 5 r}; I;Fi V7_J �. !-t Cl!_�_ rjl.�{j"}r;_s��'! %!7 %T w�•_}It!fIC1(i:•i..i-...._-.___.._.: _._.�.•.:":��:: s.`_Y �•_3.__� ._t!
Min, thickness of soil liner when }'.. r•q11 _r ed _'_'. 1.5 fee ..
DF=. I GNEI:,
DATES 112.095
Al '='ROY=S B•y „ �G�� \• Q,...
DAT °E
N! fE_ SEE ATTACH`'1•! WASTE. .T!. j_ 1_`!; T i_N FLAN
CDMMi NITS

a
112
2035
er Dam
Cem
fps
/ -- •Th,
J `
C
'2036,
f1
__---_,�
j
7 OS
722 (AMMON) 1 PETERS CREEK 2.5
5253 1 SE
SCALE 1:24 000
.5
" _ 0
MILES
10002000 _ 3000 4000
5000 6000
5 FEET
— 0 KILOMETERS
0 - 1
METERS 1000
CONTOUR INTERVAL 5 FEET
NATIONAL GEODETIC VERTICAL DATUM OF 1929
THIS MAP
r U. S. GEOLOGICAL COMPLIES
SURVEY. WITH 'NATIONAL MAP ACCURACY STANDARDS
OLDER DESCRIBING TOPOGRAPHIC VEY. D NVER, COLORADO 80225, OR RESTON, VIRGINIA 22092
RAPHIC MAPS AND SYABOIS IS AVAILABLE ON REQUEST
-es
100,L
•
--�� , •.
,\ —
n � `\\ �� @ \1Cem
•
'24 30" 72c
70•
00 8000 9000 10 000.--
2
2000
N. C.
■
QUADRANGLE LOCATION

o o ,
ZONE C
/ 0 )/t-Alle- -15 1-06
:26.

NC-ENG-538
Rev. 1-93
-SOIL- INVESTIGATION OF HASTE MANAGEiENT•SYST5M SITE
U. 5. DEPARTMENT OF AGRICULTURE
SOIL CONSERVATION SERVICE
___.,AME r+-_L.3-?„ ' 4 SHOD C u.m 3,s�..j1 C -.•a
DATE t7 - \ - S `I COUNTY C� �.�.. &0....�'1
FIELD OFFICc t•5•'•+ —
imormimmi
f I
j
Im
+ Al
I
Titrcloati--,-tt1.!
i
1
I:l
i5la
ir?1
rai
5
E
I4o
C S,o
-fluff 442.0
`,--, 0
Location Sk tcjl
Lk.
y'`AL4 a ,'.._1. �< �r>✓
-.
Depth
� ti ,-.: % 4 2, 0
J'
,1i 1'
J ,
��Y1' - V!� .
(ft)
•1
2
3 ,,,n
4
5 s le
b
0-1
1 Sm
m
5M
Sy
-
- - 2
S rn - S c.
5►4
sNt
Sr�1
3M
2'3
SC _
5M p
SC
Sm 0SI;w
" 5M- P
- 4
5 L
vu
S C,
5c_
Sn - 5�
.SPI- SP
4
S C
SG
S-sc-
3C.L
i,m - Se
1 5 - 6
5m -`5c
Si1-5G
Snil -5f
JAM-5P
k, _ b - 7
ti
sim - SC
.S /I/l`s C
5 M -,5p
1 7 - 8
SM.-5.
_
sr kn1AT`
4Sf/
8-9
5.m`549
SP
--
_5P
SPi- SP
9 - 10
w\-5p
CP
C 51
io-1_.5m-5P
SP
Sm-�P
11 - 12 II
5m ` 5P
SP
- jF
12 - 13
13 - 14
.:St Method
Name and Title
4 i

TES OF MATERIAL ECOINITERED IN BORINGS
Gil - well graded gravels; gravel, sand mix
GP - Poorly graded gravels
611 - Silty gravels; gravel -sand -silt mix
GC - Clayey gravels;. gravel -sand -clay mix
Sit - Well graded sands; sand -gravel mix
SP - Poorly graded sands
Sig - Silty sands .
OtO:FIEEL CLASSIFICAiION-
•
•- ";SC - Clayey sands;' sand -clay mixtures
-:.. ML - Silts;. silty,.v_.fine .sands;:sandy or clayey silt
CL - Claysof low. to medium plasticity _
- CH - Inorganic clays of high plasticity.
MN - Elastic. silts-- '-:-.
OL - Organic silts and silty clays, -low plasticity
OH - Organic clays, mediae to high plasticity '
1. Suitable material for waste treatment lagoon available ? Yes ' No
REMARKS C �. L �.. Rc S� . .y',+�•: ps S L
l�-1r` •10 D ak 0.0 1r•, h. ('ia_3 --, _? r obG.b\5 • o'\ Qrio C v,,a
C • • L.5r -a. _
41-E S Q, o1r. o e _ L\eLk. Q2k�.r o_ - '�• v b dC L' -f^. 11 r, �. _ � L.,
Depth
(ft)
v.,e- . vti n-• 0Z4k. �r _ .. C-\ S 1 T , ca S .. S.C.. - e c,v t
7
8
9
10
11 12
0-
2-3
3-4
4-5
- 6
6-7
7-8
8 - 9
- 10
12- 13
13- 14

U. S. DEPART".E11T Of AGRICULTURE
Soil Conservation Sarvies
PLAN OF EXCAVATED WASTE STORAGE PIT
NAME: lcALi-
County: CvmgEeLi nTj
Address: Pis a Bo e
* SEE To Po SuRue y
I!Nam / 7o
EC-ENG-40
Rev. 7/91
Date: t- 1 2.0 1,-5
i
slog SLaPE - ro 1
AVE. 1 P ELEV.
r10 SECTION
-._ _..... GIN. ... _______17
39.5 ° AYE. &MT1011 ELEY.
/ /
L ERGTI4
�t
•
(Sas boot for volue calculations)
Ilse of facility: /(1n; tvt AL WASic
Capacity: i .4-7 �6.7 Gatllons / 53 -7S Ft3
Soil Type:
Bench Mark Description ►') A,L Vila 1 5 " /' i,2 E � a 0- .z. A c A TE J Ak PPRo x .
?b' SW OF 57.c7 or► A - 3 +oo
T2EATw.znT LA6cor.
EN =
Bottom Elev. 39.5
Normal Liquid Level Elev. c4 7. a
Storage for normal Precip. (+) — Ft.
Maxims Liquid Level Elev. 4-7.8
25 yr. Storm Storage (+) .`7 Ft.
Crest ESW Elev. ._
Max.Flow Depth (+) — Ft.
Freeboard (+) /.a Ft.
Top of Dam Elev. 49•5

Confinment Building
sue• 3
50.0
1
Pit
RIucy 4 (
Curbi6e L nr Co.
TYPICAL VIEW OF A ONE -STAGY LAGOON SYSTEM
'e. S NO L`\� \a 2— 4 y,-k -2 rA'Z e�
e4 11
Top width
Pipe (Needs to. he adequately
supported)
Bottom elevation 39.5\
NOTE:
12'
I
Settled Top Elevation 49.5
e Invert Elevation
47.8
ss 3 e
RIP -RAP, FLEXIBLE PIPE.:
PLACED AT PIPE OUTLETS 10
ss 3 e
TREATMENT
LAGOON
Depth C 8.3
p'F c o& S.C. or 11�gvIQr
IYl
a 1 % .ram 0.A\ Qr
Po r•,a} 54,ow; n gods
ss 3 e I
\\\/
�cc12 s611
bpri,nS�,'or lr�'So. mos'`'
OTHER SUITABLE MATERIAL WITL�LLHE '"�`�41'r��� W'1
PREVENT EROSION OF CLAY LINER `�'��" fra rY.

R,Ky HA(
CuAir5 QLAnD Co .
AVERAGE GROUND
SANDY MATERIAL
NO CLAY
r
SANDY CLAY -CLAY
VARIABLE
1.5 FEET THIC
CLAY LINER
ADDITIONAL` EXCAVATION DUE TO LINER:
AVERAGE DEPTH TO CLAY
TYPICAL CROSS-SECTION OF
LAGOON CONSTRUCTION WITH
PARTIAL•CLAY LINER
1.5FEIT THICK CLAY LINER
(MINIMUM) ------
EXCAVATE THIS AREA AND
BACKFILL WITII CLAY
EXCAVATE
455.S
VARIABLE
.5 FEET THICK
CLAY LINER
39.0
AVERAGE GROUND
SANDY MATERIAL
NO CLAY
SANDY CLAY -CLAY
X 1.5 FEET THICK X DISTANCE /6,3 3
_CUBIC FEET -= 1010 LUQIC YARDS
NOTE: WHEN AREAS OF UNSUITABLE MATERIAL ARE ENCOUNTERED, THEY WILL NEED TOIDE EXCAVATFEET/3ED A MINIMUM OF 1.5
FEET DELOW GRADE, DACKFILLED AND COMPACTED WITH A SCS APPROVED MATERIAL (SC, CL, CH).

N
A
12.280
1 I
5 tL dos
L
m I
t.._
•
I
itaiLL
-
tCY-
4 rO ,:h
v1
iosr-
49lo. 4417 4� s
Q
too _ — I 1�- _6.8 4 7_ 4
,- 2 i o -_ (EiSb.l
•� 3t4o . 3.t5o/1
C�;
,7or�9.5 ! t7o/
i Vt:
r
- r 0 48 I
TAM_ Soo_
nA.lt- _in_1.51 'Prf E TREE"._'
[-DC/i r 3o}.5-e
42; 1
„RIPE !N/ RAV-$Paa-P
�/�A R .
R1cIcy ,ALL
oq-a WFA.rI-FEeAeR.
ToPO \v/LAGOOII E 8011-/?tn65
CuM+SERLAnt) Co.
be-5/6n = G. Ct-rt4n
_ ♦oo
•

OPERATION AND MAINTENANCE PLAN
1 5
SHEET t-W-2
----------------------
This lagoon is designed for waste treatment (permanent storage) and
180 days of temporary storage. The time required for the planned
fluid level (permanent and temporary storage) to be reached may vary
due to site conditions, weather, flushing operations, and the amount
of fresh water added to the system.
The designed temporary storage consists of 180 days storage for:
(1) waste from animals and (2) excess rainfall after evaporation. Als
included is storage for the 25 year - 24 hour storm for the location.
The volume of waste generated from a given number of animals will be
fairly constant throughout the year and from year to year, but excess
rainfall will vary from year to year. The 25 year rainfall will not
be a factor to consider in an annual pumping cycle, but this storage
volume must always be available.
A maximum elevation is determined in each design to begin
pumping and this is usually the outlet invert of pipe(s) from
building(s). If the outlet pipe is not installed at the elevation to
begin pumping, a permanent marker must be installed at this eIevatio�
to indicate when pumping should begin. An elevation must be established
to stop pumping to maintain lagoon treatment depth.
Pumping can be started or stopped at any time between these �wo
elevations for operating convenience as site conditions permit, such as
weather, soils, crop, and equipment in order to apply waste without
runoff or leaching.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. CarE should be
taken when applying waste to prevent damage to crops.
The following� items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre -
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the inimal
waste entering the lagoon thereby reducing odors. Solids snould be
covered with effluent at all times. When precharging is complete,
flush buildings with recycled lagoon liquid. Fresh water shocld not
be used for flushing after initial filling.
2. The attached waste utilization plan shall me followea. 7 his
plan recommends sampling and testing of waste (see atnacnment/
before land application.
3. Begin temporary storege pump -out of the lagoon when fluid �e�e
reaches the elevation .47;3.as marked by permanent mar/er. Stop pump -
act when the Uuid level reaches ele`/aiion 4517 . ThLs temporary
storage, less 25 yr- 24 hr storm, contains 37798 cubic fset or
282657 gallons.

SHEET 2 OF 2
4. The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0.3
inch per hour. Refer to the waste utilization plan for further details.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
B. Keep a minimum of 25 feet of grass vegetated buffer around
waste utilization fields adjacent to perennial streams. Waste will
not be applied in open ditches. Do not pump within 200 feet of a
residence or within 100 feet of a well. Waste shall be applied in a
manner not to reach other property and public right-of-ways.
9. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.
`

EMERGENCY ACTION PLAN
PHONE NUMBERS
DWQ 910-486-1541
EMERGENCY MANAGEMENT SYSTEM 910-678-7688
SWCD 910-484-8479
NRCS 910-484-8939
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing. or running off site. You should not wait until wastes reach surface waters or
leave your property to consider that you have a problem. You should make every effort to
ensure that this does not happen. This plan should be posted in an accessible location for
ail employees at the facility. The following are some action items you should take.
L. Stop the release of wastes. Depending. on the situation. this may or may not be
possible. Suggested responses to some possible problems are listed below.
A. Lagoon overflow -possible solutions are:
a. Add soil to been to increase elevation of darn.
b. Pump wastes to fields at an acceptable rate.
c. Stop all tiow.ws to the lagoon immediately.
d. Ca11 a pumping contractor.
e. Make sure no surface water is entering lagoon.
B: Runoff from waste application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C: Leakage from the waste pipes and sprinklers -action include -
a. Stop recycle pump.
b. Stop irigation pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
D: Leakage from flush systems. houses, solid separators -action include:
•
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure no siphon occurs.
d. Stop all flows in the house. flush systems. or solid separators.
as
IV
O
CSD
1 S. 1996

e. Repair all leaks prior to restarting pumps.
E: Leakac,e from base or side,.vall of lagoon. Often this is seepage as opposed to
flowing leaks- possible action:
a. Dig a small sump or ditch away from the embankment co catch all seepage.
put in a submersible pump. and pump back to lagoon.
b. If holes are caused by burrowing animals. trap or remove animals and :ill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side wails and lagoon
bottom as soon as possible.
2. Assess the extent of the spill and note anv obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any -damage noted_ such as employee injury, fish kills. or propeav damac,e.'
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
Could a future rain event cause the spill to reach surface waters?
Are potable water wells in danger (either on or off of the property)'
h. How much reached surface waters?
Contact appropriate agencies.
a. During normal. business hours, call your DWQ (Division of Water Quality)
regional office; Phone - - . After hours. emergency number: 919- -'9-'-.
Your phone call should include: your name. facility, telephone number. the details
of the incident from item 2 above, the exact location of the facility, the location or
direction of movement of the spill. weather and wind conditions. The corrective
measures that have been under taken, and the seriousness of the situation.
P. If spill leaves property or enters surface waters, call local EMS Phone number
c:—.Iris-uqict EMS to contact local Health Department.
d. Contact 6ES. phone number - - , local SWCD office phone number -
and local NRCS office for advice/technical assistance phone number - -
': If none of the above works call 911 or the Sheriffs Department and explain your
problem to them and ask that person to contact the proper agencies for you.
Contact the contractor of your choice to begin repair of problem to minimize off -site
damage.
a. Contractors Name: ld) ELds arps-
b. Contractors Address: I s�e.K. NL
c. Contrac:ors Phone: e}Ia-S h,—eit4

6: Contact the technical specialist who certified the lagoon (MRCS. Consulting
Ene,ineer. etc.) - -
>1�` C - d /''_'
a. Name:
b. Phor.e: E ; !y -
7: Implement procedures as advised by. DWQ and technical assistance agencies to
rectify the damage. repair the system. and reassess the waste management plan to
keen prooieins with release of wastes from happening again.

Source
Swine Farm Waste Management Odor Control Checklist
Cause BMPs to Minimize Odor
Manure tracked onto • Poorly maintained access (' Farm access road maintenance
public roads from roads
farm access
Additional Information:
Site Specific Practices
Available From:
Swine Manure Management; .0200 RuleBMP Packet
Swine Production Farm Potential Odor Sources and Remedies; EBAE Fact Sheet
Swine Production Facility Manure Management: Pit Recharge —Lagoon Treatment; EBAE 128-88
Swine Production Facility Manure Management: Underfloor Flush —Lagoon Treatment; EBAE 129-88
Lagoon Design and Management for Livestock Manure Treatment and Storage; EBAE 103-83
Calibration of Manure and Wastewater Application Equipment; EBAE Fact Sheet
Controlling Odors from Swine Buildings; PIH-33
Environmental Assurance Program; NPPC Manual
Options for Managing Odor; a report from the Swine Odor Task Force
Nuisance Concerns in Animal Manure Management: Odors and Flies; PRO107, 1995 Conference Proceedings
NCSU, County Extension Center
NCSU—BAE
NCSU—BAE
NCSU—BAE
NCSU—BAE
NCSU—BAE
NCSU—Swine Extension
N.C. Pork Producers Assoc.
NCSU Agricultural Communications
Florida Cooperative Extension

Swine Farm Waste Management Odor Control Checklist
Source
Cause
BMPs to Minimize Odor
Site Specific Practices
Flush -alleys
• Agitation during wastewater C] Underfloor flush with underfloor ventilation
conveyance
Pit recharge points
• Agitation of recycled lagoon Cg' Extend recharge lines to near bottom of pits with
liquid while pits are filling anti -siphon vents
Lift stations
• Agitation during sump tank 0 Sump tank covers
filling and drawdown
Outside drain
collection or
junction boxes
• Agitation during,wastewater
conveyance
CI Box covers
End of drainpipes
at lagoon
• Agitation during wastewater
conveyance
O Extend discharge point of pipes underneath
lagoon liquid level
Lagoon surfaces
• Volatile gas emissions
• Biological mixing
• Agitation
1' Proper lagoon liquid capacity
a4 Correct lagoon startup procedures
a' Minimum surface area -to -volume ratio
CY Minimum agitation when pumping
O Mechanical aeration
1 Proven biological additives
Irrigation sprinkler
nozzles
• High pressure agitation
• Wind drift
CYIrrigate on dry days with little or no wind
O Minimum recommended operating pressure
O Pump intake near lagoon liquid surface
O Pump from second -stage lagoon

Swine Farm Waste Management Odor Control Checklist
Source
Cause
BMPs to Minimize Odor
Site Specific Practices
Storage tank or
basin surface
• Partial microbial
decomposition
• Mixing while filling
• Agitation when emptying
'El Bottom or midlevel loading
0 Tank dyers
O Basin surface mats of solids
CI Proven biological additives or oxidants
Settling basin
surface
• Partial microbial
decomposition
• Mixing while filling
• Agitation when emptying
Extend drainpipe outlets underneath liquid level
O Remove settled solids regularly
Manure, slurry, or
sludge spreader
outlets
• Agitation when spreading
• Volatile gas emissions
O Soil injection of slurry/sludges
O Wash residual manure from spreader after use
O Proven biological additives or oxidants
Uncovered manure,
slurry, or sludge on
field surfaces
• Volatile gas emissions while
drying
O Soil injection of slurry/sludges
O Soil incorporation within 48 hours
O Spread in thin uniform layers for rapid drying
Cl Proven biological additives or oxidants
Dead animals
• Carcass decomposition
La' Proper disposition of carcasses
Dead animal
disposal pits
• Carcass decomposition
Complete covering of carcasses in burial pits
0 Proper location/construction of disposal pits
Incinerators
• Incomplete combustion
O Secondary stack burners
Standing water
around facilities
• Improper drainage
• Microbial decomposition of
organic matter
171' Grade and landscape such that water drains away
from facilities

Swine Farm Waste Management Odor Control Checklist
_ Source Cause
Farmstead • Swine production
BMPs to Minimize Odor Site Specific Practices
CY Vegetative or wooded buffers
Ca' Recommended best management practices
CY Good judgment and common sense
Animal body
surfaces
Floor surfaces
• Dirty manure -covered CDry floors
animals
• Wet manure -covered floors Ca' Slotted floors
Cir Waterers located over slotted floors
C] Feeders at high end of solid floors
O Scrape manure buildup from floors
1 Underfloor ventilation for drying
Manure collection • Urine
pits _ • Partial microbial
decomposition
CirFrequent manure removal by flush, pit recharge,
or scrape
O Underfloor ventilation
Ventilation exhaust • Volatile gases Er Fan maintenance
fans • Dust
Ca' Efficient air movement
Indoor surfaces
• Dust
E1'Washdown between groups of animals
D' Feed additives
C] Feeder covers
C] Feed delivery downspout extenders to feeder
covers
Flush tanks
• Agitation of recycled lagoon O Flush tank covers
liquid while tanks are filling Cl Extend fill lines to near bottom of tanks with
anti -siphon vents

Insect Control Checklist for Animal Operations
Source Cause BMPs to Control Insects Site Specific Practices
Liquid Systems
Flush gutters
• Accumulation of solids gl Flush system is designed and operated
sufficiently to remove accumulated solids from
gutters as designed
Er Remove bridging of accumulated solids at
discharge
Lagoons and pits • Crusted solids
I ' Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the crusting
of solids to a depth of no more than 6 to 8 inches
over more than 30 percent of surface
Excessive vegetative • Decaying vegetation
growth
Cr Maintain vegetative control along banks of
lagoons and other impoundments to prevent
accumulation of decaying vegetative matter along
water's edge on impoundment's perimeter.
Dry Systems
Feeders • Feed spillage O Design, operate, and maintain feed systems
(e.g., bunkers and troughs) to minimize the
accumulation of decaying wastage
El Clean up spillage on a routine basis (e.g., 7- to 10-
day interval during summer; 15- to 30-day interval
during winter)