240066_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quanty
Division of Water Reseasees
Animal Waste Management S 4t
Refit forcer tifteatisrt of -Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Waste Management Systems w,w
expire. As required by these permits, facilities that have been issued Cortifirsom- Ceammge to Axperate under these Star
Non -Discharge General Permits must apply for renewal at least 180 days per to their mtpiration date. Therefore, all application
must be received by the Division of Water Resources urces by no later than April, 20>9.
Please do not leave any question unanswered Please verify al! information .area make any necessary corrections below
,4pplication must be signed and dated by tke Pere miittee
3. Fann Number: 24-0066
Certificate0tCrneszege Number AWS240066
2. Facility Name: re.,.:, tytef-Fenn ct r+er e' ,- R-afj Wt -) L,C �"
3. Landowner's Name (same as no the Waste Management Plan): SIle(h er't C2 r` e r- -C4
t c4e4'1 GAY
4. Landowner's Mailing Address: rr 1_ 1-1 atterf* S 3 b S o 1 Q. l k W A y 7
City: Ever ef' G �1a[ Q {,) 0 tl State: NC / Zip: 48430-%45 2-9 t'i3
Telephone Number; 910-654-3053 Fact E-mail: cclAr rLchel Carier-�. kJ e yaikoo, Co,vt
5. Facility's Physical Address: 116 Carter Dr
City: Evergreen State: NC Zip: 28438
6, County where Facility is located: Columbus
7. Farm Manager's Name -(if,different from Landowner):
8. Farm Manager's telephone number (include area code):
9. Integrator's Name (if there is not an Integrator, write 'None"): Muphy-Brown LLC
1a. Operator Name (OIC). Sat Vl Phone No.: Via— OIC #: 2 -
Car q lq—ta'J2,-o019 too -2.(01c
11. Lessee's Name (if there is not a Lessee, write "None"): f\i>e\
12. Indicate anunal operation type and number:
Current Permit: Operations Type Allotrable
5,280
Swine - Feeder to Finish
Operation Types:
Swint Cattle Dry rosary der Types
Wean to Finish Dairy Calf Non Laying Cttc= Horses - Horses
Wean to Feeder Dairy Heifer LayingChickens horses -Other
Farrow to Finish Milk Cow Pullets Sheep - Sheep
Feeder. to Finish Dry Cow Tutkeys Sheep Other
-
Fatrow to Wean Beef Stocker Calf Turkey Pullet
Farrow to Feeder Beef Feeder
Roar/Stud Beef Broad Cow Vet poiam
Gilts Other Non Laying Pant
Other Layers
APR 022019

13, Waste Treaunent and Storage La (Ver*ibe &Mowing information is accurate and complete. Make all necessary
sections and provide missing data)
Structure
Name
Banned
Dane
Beadt
Type
(Clay. Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(SquareFeet)
Design Freeboard
"Redline"
(Inches)
1
1 qq1-/
c la)
'got/ y r J
261,360.00
19.00
Mall one (1) copy of the Certified Aribaal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC Generantatates;s321a s , he the address_ lbw.
The CAWMP must Imhof. the_ Mowing
The most recent Waste Utilization- (d'sib by the ew-tte>• and a certiled teehnica saecialist, containing:
a. The method by which waste is applied to the &Tose fields (e.g. inigation, injection. etc.)
b: A nap of every field used for land appfecatiou (for example: irrigation -map)
c. The soii series present to away land application field
d. The crops grown en every " field
e. The Realistic Yield YE) tar every crop shown in the WUP
f The manimum PAN lsrbe applied ts-ever,F land applieation field
g. The waste application whadows for celery crisp utilized in the WUP
h: The requ edNRL S Standanispecifseations
gar A site map/schematic
Emergency ActionPlan
i insect Control Checklist Ishii chosen t practices noted
(yr OdorControt Cher:Mist with chosen bra sarmagenerea practicenu ed
the -Mortality Control Checklist with sew method noted - Use the enclosed updated Mortality Control Checklist
L agoonlstorage pond- (dew calculations; etc.)1 Please be sure the above table is accurate and
complete. Also provide any site wand determinations, or hazard classifications that may be applicable to
your facility.
..$r Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, waste trams, etc
As a second option to maims paper espies ad the application package, you can scan and email one signed copy of the
application and all the CAWMP brats abase tar 2SISPerraidtenewaltiencdenr.gov

I attest that this application has been reviewed by me and is accurate and comps alt the best of my knowledge. I understand that
if all required parts of this application are not completed and that if all information and attachments are not
included. this application package will be returned to me as incomplete.
Note; In accordance with NC General Statutes 143-215.6A and 143-215.61'3.. oar .pia who fly makes any false staters
representation, or certification in any application may be .subject to cirri peraides up to $25.000 per violation. (18 U.S.C.,
Section 10a1 provides a punishment by a fine of not more than S10000 or ins" of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner; or if multiple . Landowners alllandowners should
corporation, signature should be by a principal executive officer of the corporation):
Name: ,A1I11 (� { f Title: Othi Cf
Signature
Name:
Signature: Date:
Date:
Title: ()G[/l?e✓
2S,7—or9
Date: /fl'i C4i 2r r 2,O r .1
Title:
sign -
THE COMPLETED APPLICATION SHOULD BE SENT TO ME l ;UWINOADDRESS:
NCDEQ-DWR
Animal -Feeding Operalions-Prugraur
1636 Mail Service Center
Raleigh, North Carolina 27499-1434
Telephone number: 919) 7O7-9140
E-mail: [e-mail]
If Landowner is a
FORM RENEWAL -STATE -GENERAL ev2.19

Nutineatinn of Change of Ownership
Anbusti aste Management Facility
(Plea type wrist an infixmation that does not require a signature)
In accordance with the requirements of ISA NCAC 2T .1304(c) and 15A NCAC 2T .1305(d) this form is official notification
to the Division of Water Resources (DWR) of the transfer of ownership of an Animal Waste Management Facility. This
form must be submitted to DWIL no later than 68 days following the transfer of ownership_
General Information:
Previous Name of Farm: C �( IC-LU2VY1 Facility No: Li.- CO (0 6
Previous Owner(s) Name: L_ _o t,irl , 0 C�a�55 C r Phone No: 1(0 - Co 2- S- 1 I v2 7
New flwner(s) Name: V et- 321"'�� Z Phone No: al `9' ` (o 3 2. " Ot I Lf
New Farm. Nate (if applicable);applicable);CO_'p! O `:-y �Co f xr o& s LL IC
Mailing Address: S 3 IDS OI U S. L 11 o Irk VkiQ 1 -74-,,/ /C,p /l u Yju , 1 J C' �'3 `
2-ii
Farm Location: Latitude and Longitude: 5'i' Z‘ 1/ " F 9 I a 66 g I i minty_ C 0 I U \ VJU 5'
Please attach a copy ofa county maintop with location identified, and provide the Iocation address and driving directions
below (Be specific: road namrsofilections, nile .etc.): 1 -'I S 5,0 04.4 , to r] I-+ So()`h ; tat ke
cif- Gal 1'1 i' .x.t^r 2,4 Z -towctic .S L v-etct ,newt ` r is Kt vim, G Id:
1---u A tiiir-v, ' ,� • r 1'01 lid O-e-• 5 ► � a' g21 la Ed • Y Cj kt a\ 5 r) ve r Ss cart g
Operation Description:
Type of Swine No. of Animals Type of Swine No. of Animals Type of Cattle No. of' Animals
f3 Wean to Feeder a Gies D Dairy
Q Wean to Finish f3 Boars ❑ Beef
A Feeder to Finish ca S d
O Farrow to Wean Type ofPoultry No. ofAnimirls
0 Farrow to Feeder Q Layer
13 Farrow to Finish 0 Pullets
Other Type of Livestock: Number ofAnimals:
Acreage Available for Application: Co 2 i caS Required Acreage: 5}i,,-
Sur cr CQa
Number of Lagoons 1 Storage Ponds: I Total Capacity: 1 a u '' C 3.7 Cubic Feet (ft3) ;L.(Q 1 , 3 0 5t�1.re -e
******************************** ***sex***********************************es**
Owner / Manager Agreement
1 (we) verify that all the above information is correct and will be updated upon changing. 1 (we) understand the operation and
maintenance procedures established in the Certified Animal Waste Management Plan (CAWMP) for the farm named above
and will implement these procedures. 1 (we) know that any modification or expansion to the existing design capacity of the
waste treatment and storage system or cction of new facilities will require a permit modification before the new
animals are stocked. L(we) understand drat there must be no discharge of animal waste from the storage or application
system to surface waters of the state either directly throw a man-made conveyance or from a storm event less severe than
the 25-year, 24-hour storm and them nit not be mo-of from the application of animal waste. I (we) understand that this
facility may be covered by a Slate Non --Dice Permit or a NPDES Permit and completion of this form authorizes the
Division of Water. Resources -to issue the rewired
A �Tp ..
it to the new land owner
Name of Previous Land Owner: Le', 8Co , CA55 �J r
eke CeOl eJ }
Signature:
Name of Ne
Signature:
Owner:
Name of Manager (if different from e
Signature:
Please sign and return this forma ta; Animal Feeding Operations
N. C. Division of Water Resources
WaterQuality Regional Operations Section
163611faff Service Center
Raleigh, NC 27699-1636
1j1Cneol,r/Altifjf rrC% (i e
Date:
r
Date: I S l /
Date:
June 12, 2015

Pro Ag Appraisals
Columbus County Pro
Columbus County, North CaroNos
Lomond
+1,013Q t-43.T3¢5tt5
+ 3;b1bom - f1Ap®
0199S-2017 AgWare. Inc. All Rights Rom_
Rosie
rr��ir
aro1107minato .--,-14tftlie
reCrrw4Cabo& -- NIikRM�aiti�tt
jCounly Biellarp
a1
File S CarterirEstLC
13
i T+a
Page 10 of 9E

Pro Ag Appraisals
Swine facility Location
Fite f CarterJrEstLC
Page 15 of 96

7 Ye.
9 4 .41.F a4, 1164,
-• ,
•
• •
•.„
STATE OF NORTH CAROLINA
ROBESON COUNTY
REGISTER OF DEEDS
VICKI L LOCKLEAR
Bask 2017 Paga 953
1133571SIVOR 07640
adififfolt =on. m3
egilmOMIXIMMEPAMINEWISHOLVii.smo.KMAXSIERWES
riC
CERBFICATFAUDEATH
sou
ossrrrac,,,,,„,
111Mi1. _PI"Lm."..1 e-=,-f — - — -Ni lar -- - — - -- — -- TWA." ..• ... .i.17 .....4 MoZ.Lro ;'•hl
1.••=111..• .1 6141..;(
1 a=4:417 ipir. Lcaulat Casa Cart a r I Jr.
.,..,...... — .3r, ........ 341114 • ON 4 1dr• 1114.1.1.r.M.~/1 sprr.4.1ira 11 SCE OF NON 01.44114~
Isi is !.--1--"ff--r-i'ebrsiary
10.1441111111/1.41
11,194 Do/usbuat;ri October 15, 2817
_
nalf.eiw c.v. ' 4.(.1•PW,ft ••'11_...4..s...,MC • moo 0 ;lac ffloolk
4,=••
..
c,.g
smalieirszein 7....0.,..S1 2fedital Canter [ lattaberton E.D..IF.:r.aa..trt.ma,in
-
p Rt.IuMPOft.s3w.1,aamr
e m.0in0.s.i.a1..a0n5n611.
i2-6-538
Rr.vr.
mr
R..0111 P"-..s..,k....'.0.t.
I1noth 6,... .....,Evergen
...l
1
'ca gm MT ,41•I'S slle ‘41 hy
1 DV. 31;162 USAIIIED-1071CFS.
116 4•111-ottot Whim2808 crw. in..1
anais.......amanmir.-im.-1.s r1-112=11•Crall.11. C11.2•Fle4.01.
g. la
.1 114:10( 1k1•01 •11.0,1•11,4f MINK .COS Ilb•MLWa .•••• OW
iinglinIMMOil~111tillipinebteStIgli. • Isislortiosallos..~Sri Olcsa.
.I. 444411/41.M..1,34/K i
14.144.441140.11.42-.1.44
r
.1.4104.1.......Erelmerdisbn
ppv.•rot IS,!..,..s.,•4*.
--*4 L1111.4.1.44. ,
1:11144...........
t.,, 0114,311111041.164114 ! 11.41.11.1•4214.4.41. Ille.C.W.INI.I...... M9111.14.4.
"1"••••••••.11..".•••••,°'1.1
*pc 111.A.41•11.4.1•111.1=4.4~ ' 1 1,44....4 alaimeem.1.4 efileamMia,p*.asa.
1211....141110.14.1.4.44p. 131.414alelban CI 9.11.
,...4,., I way/ 41.9
' 3.. ..E. ...Mir a% .41414. il C.10,1441‘44.1.:44.4)
a_ .......... .., a.. 4 S114...4.44.44444....A.010 ,........ ...w....
-v ZN•wor ....we 414 VA•11Esi41144M. 411.., 130441. 110.-,..3 t131.114.4.
"1=j04.0,ery 1.!: '1111.11.4.0114/911 Wiles 13.44,..•
• - 11W12112:r. .• ". 0 :La.... • T 1 .. "....173,1Clarrlil:3142--alii---
Landau ,..asa CariDar, Sr. i Edna Juanita rhempaee
=E. isi
•••• pp
• .....,-›..-t....e. -e-.e.,e.-....•7 ..Frt.Tr, ,1 gr ....Efge AZOW4 57....14.4.6414. f.--...
Talky It Carter j Ville -
1.1.1.6 Carter Dr., Evergreen, 11C 28438
el-,
. : ....1..-..;-....—p......7...esee-lx ..,.....r, -.,-,. Fe ......-xi-:..-,---....r..:
.
'—
.-II..
BZ...- 51,141.4... •=11.4.1/14.11414E 11.1A=1 e-
.!
**aerial
4..
LL±.-: _ - • - Ma:Name: Camezery ,Cti . NC:
2
aft
1,11--of :el:Naftali& :-.. - Wig arear.-10
TVs 5074 j FSL 1090
• - . 70. Al *rise. 4115 Z. Etrawterry Elva., Dbadbeura, SC 28431-0352
E0
_ -- ...11.41.11.14,44r ...1.1.1•1 lki.01.•....c14.0,..h.44.1.4.4.
14.........-
CIE=
rAr r,L=.•gfir-
Oe Wm.. 44431.71.1
••• _I_ • fs..,1 . . se.,•.: ow..--A•ila-5'....
I
.
. -
icw)
r
/
.
•-•• .
4
1
''''''T"..ft" '''PkIt4.-*--;
I
'
.
...--.*
1
tileCIAM
4.4•11,,...F=1,4 Ws .0-emp.MIE•ree..Pir MN 0 ar.+04 In *nap!
Winn: 14...... CLIMMIIMIKUllr"1
ninon =Poona ,
Ira. DJ
C Palma al emstamt•
1:14.......1111.41.•
......,, 3,,.......,. ,
1 C9.14 .1.7i•Ole 1.0 itNeli 4004, Cie .0......
0.1.60101.1*40.1114411111
Om.
. E1,114140.4111•11.
Wow aft114.1111114.11411•11.11.-r11.
i f°11.1.111111111;r•
-Z, "'.72'7eirmilmit". PuME ef .1.411•-.1LC1114
l' 1.1..e.M 11.E311i11.1?. -
1.14.:
.........."',. !
J ;I I
Minsepoln,
W.p.m..
IllonmEn
. ....P1Mcerwa.r...
3. x L0,-,. O.,. n.r.- rn.o.m...4v4.1..
01464.•4•
a01111.4.4•Ii
iii=1,,,,, trefiakeal.,4441.6f......0•111s Una OK OKA ae140/111.1.1.1......r. OMNI
••••••• ...a... .1 'ay.. I..
. a114"F"ot .4
.-W-M-Si Nc 3-0t1(
.21.0.
Agose-- 2S.--Jr
15.1TTEMAI.1-~mq
la i . r
41MCara•10.4.,
I HEREBY CERTIFY THikT THIS IS A TRUE AND ACCURATE COPY WHICH APPEARS ON RECORD IN
THE OFFICE OF REGISTER OF DEEDS, ROBESON COUNTY, N.C. IN BOOK 2017 PAGE 953.
WITNESS MY HAND AND SEAL THIS 25th OF OCTOBER, 2017.
,•4
•••
A.,- g

NORTH CAROLINA
Department al the Secretary of State
1, El
is shall Come, Greetings:
of the State of North Carolina, do hereby certify
the following and hereto attached to be a true copy of
ARTICLES OF ORGANIZATION
OF
CARTER & CARTER FARMS, LLC
of which was filed in this office on the 12th day of March, 2019
-}.;.;
07
i • r ~ i��,N00e
Scan to verify
Document Id: C201906600641
verify this certificate online at http-1www.s ttovfverifcation
IN WITNESS WHEREOF, I have hereunto set
my hand and affixed my official seal at the City
of Raleigh, this I2th day of March, 2019.
Secretary of State

NC Water Pollution Control S
Operators Certification
Sandra Carter
Type Grade cert# Type Grade *
iw a 108S266
isadu* &AlfredOperatorundrerT afActie e4 -a
of the General Statutes ofpharaino
W. Carey Basinger
f=hairttrne
2019

Insect Control Checklist for Animal Operations
Source Cause BMPs to Control Insects Site Specific Practices
Liquid Systems
Flush gutters • Accumulation of solids
Lagoons and pits • Crusted solids
O Flush system is designed and operated sufficiently
to remove accumulated solids from gutters as
designed
O Remove bridging of accumulated solids at
discharge
I Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the crusting
of solids to a depth of no more than 6 to 8 inches
over more than 30 percent of surface
Excessive vegetative • Decaying vegetation
growth
Maintain vegetative control along banks of
lagoons and other impoundments to prevent
accumulation of decaying vegetative matter along
water's edge on impoundment's perimeter.
Dry Systems
Feeders • Feed spillage 1N Design, operate, and maintain feed systems
(e.g., bunkers and troughs) to minimize the
accumulation of decaying wastage
`® Clean up spillage on a routine basis (e.g., 7- to 10-
day interval during summer; 15- to 30-day interval
during winter)
AMIC - November 11, 1996, page 1

Insect Control Checklist for Animal Operations
Source
Feed storage
Cause
• Accumulations of feed
residues
BMPs to Control Insects
gl Reduce moisture accumulation within and around
immediate perimeter of feed storage areas by
ensuring drainage is away from site and/or providing
adequate containment (e.g., covered bin for
brewer's grain and similar high moisture grain
products)
Inspect for and remove or break up accumulated
solids in filter strips around feed storage as needed
Site Specific Practices
Animal holding areas • Accumulations of animal El Eliminate low areas that trap moisture along fences
wastes and feed wastage and other locations where waste accumulates and
disturbance by animals is minimal
Maintain fence rows and filter strips around animal
holding areas to minimize accumulations of wastes
(i.e., inspect for and remove or break up
accumulated solids as needed)
Dry manure handling • Accumulations of animal 51 Remove spillage on a routine basis (e.g.,
systems wastes 7- to 10-day interval during summer; 15- to 30-day
interval during winter) where manure is loaded for
land application or disposal
Provide for adequate drainage around manure
stockpiles
O Inspect for and remove or break up accumulated
wastes in filter strips around stockpiles and manure
handling areas as needed
For more information contact:
Cooperative Extension Service, Department of Entomology, Box 7613, North Carolina State University, Raleigh, NC 27695-7613.
AMIC - November 11, 1996, page 2

Swine Farm Waste Management Odor Control Checklist
Source
Farmstead
Cause
• Swine production
Animal body
surfaces
BMPs to Minimize Odor
O Vegetative or wooded buffers
gi Recommended best management practices
Good judgment and common sense
Site Specific Practices
• Dirty manure -covered
animals
O Dry floors
Floor surfaces
• Wet manure -covered floors
® Slotted floors
Waterers located over slotted floors
lR Feeders at high end of solid floors
® Scrape manure buildup from floors
O Underfloor ventilation for drying
Manure collection • Urine
pits
• Partial microbial
decomposition
la Frequent manure removal by flush, pit recharge,
or scrape
0 Underfloor ventilation
Ventilation exhaust • Volatile gases
fans
• Dust
17 Fan maintenance
® Efficient air movement
Indoor surfaces
• Dust
Washdown between groups of animals
O Feed additives
O Feeder covers
Feed delivery downspout extenders to feeder
covers
Flush tanks
Flush alleys
• Agitation of recycled lagoon
liquid while tanks are filling
• • Agitation during wastewater
conveyance
O Flush tank covers
O Extend fill lines to near bottom of tanks with
anti -siphon vents
13 Underfloor flush with underfloor ventilation
AMOC - November 11, 1996, page 1

Swine Farm Waste Management Odor Control Checklist
Source
Pit recharge points
Cause
• Agitation of recycled lagoon
liquid while pits are filling
BMPs to Minimize Odor
O Extend recharge lines to near bottom of pits with
anti -siphon vents
Lift stations
• Agitation during sump tank
filling and drawdown
O Sump tank covers
Outside drain •
collection or junction
boxes
Agitation during wastewater
conveyance
O Box covers
End of drainpipes
at lagoon
• Agitation during wastewater
conveyance
Site S pecific Practices
O Extend discharge point of pipes underneath
lagoon liquid level
Lagoon surfaces
• Volatile gas emissions
• Biological mixing
• Agitation
12 Proper lagoon liquid capacity
El Correct lagoon startup procedures
PI Minimum surface area -to -volume ratio
131 Minimum agitation when pumping
0 Mechanical aeration
O Proven biological additives
Irrigation sprinkler
nozzles
• High pressure agitation
• Wind drift
II Irrigate on dry days with little or no wind
)71 Minimum recommended operating pressure
I Pump intake near lagoon liquid surface
O Pump from second -stage lagoon
Storage tank or
basin surface
• Partial microbial
decomposition
• Mixing while filling
• Agitation when emptying
O Bottom or midlevel loading
O Tank covers
O Basin surface mats of solids
O Proven biological additives or oxidants
AMOC - November 11, 1996, page 2

Swine Farm Waste Management Odor Control Checklist
Source
Settling basin surface •
•
•
Cause
Partial microbial
decomposition
Mixing while filling
Agitation when emptying
BMPs to Minimize Odor
O Extend drainpipe outlets underneath liquid level
`0 Remove settled solids regularly
Site Specific Practices
Manure, slurry, or
sludge spreader
outlets
• Agitation when spreading
• Volatile gas emissions
O Soil injection of slurry/sludges
1RI Wash residual manure from spreader after use
O Proven biological additives or oxidants
Uncovered manure,
slurry, or sludge on
field surfaces
• Volatile gas emissions while
drying
O Soil injection of slurry/sludges
O Soil incorporation within 48 hours
1 Spread in thin uniform layers for rapid drying
O Proven biological additives or oxidants
Dead animals • Carcass decomposition
:® Proper disposition of carcasses
Dead animal disposal • Carcass decomposition
pits
O Complete covering of carcasses in burial pits
O Proper location/construction of disposal pits
Incinerators
• Incomplete combustion
0 Secondary stack burners
Standing water
around facilities
• Improper drainage
• Microbial decomposition of
organic matter
Grade and landscape such that water drains away
from facilities
Manure tracked onto
public roads from
farm access
• Poorly maintained access
roads
.0 Farm access road maintenance
AMOC - November 11, 1996, page 3

Additional Information:
Available From:
Swine Manure Management; .0200 Rule/BMP Packet
Swine Production Farm Potential Odor Sources and Remedies; EBAE Fact Sheet
Swine Production Facility Manure Management: Pit Recharge —Lagoon Treatment; EBAE 128-88
Swine Production Facility Manure Management: Underfloor Flush —Lagoon Treatment; EBAE 129-88
Lagoon Design and Management for Livestock Manure Treatment and Storage; EBAE 103-83
Calibration of Manure and Wastewater Application Equipment; EBAE Fact Sheet
Controlling Odors from Swine Buildings; PIH-33
Environmental Assurance Program; NPPC Manual
Options for Managing Odor; a report from the Swine Odor Task Force
Nuisance Concerns in Animal Manure Management: Odors and Flies; PRO107, 1995 Conference Proceedings
NCSU, County Extension Center
NCSU—BAE
NCSU—BAE
NCSU—BAE
NCSU—BAE
NCSU—BAE
NCSU—Swine Extension
N.C. Pork Producers Assoc.
NCSU Agricultural Communications
Florida Cooperative Extension
AMOC - November 11, 1996, page 4

•
Operator:L.C. CARTER County: COLUMBUS
Distance to nearest residence (other than
AVERAGE LIVE WEIGHT (ALW)
0 sows (farrow to finish) x
0 sows (farrow to feeder)
5280 head (finishing only) x
0 sows (farrow to wean) x
0 head (wean to feeder) x
Describe other :
1417 lbs : ° _
522 lbs. _
433 lbs. _
30 lbs. _
euk,E1.)
o u ricT P p e c cee,cc
1
Lowey'e.41 LoWe(` TF
Date: 12-29-94 Cr4:1:ra
1 t a vN y?
!1-21-1
0 lbs
0 lbs
712800 lbs
0 lbs
0 lbs
0 lbs
2000 feet
Total Average Live Weight =
2 MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 712800 lbs. ALW x Treatment
Treatment Volume (CF) /lb. ALW =
Volume = 712800 cubic feet
3 STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0 cubic feet
4 TOTAL DESIGNED VOLUME
Inside top length (feet)
Inside top width (feet)
Top of dike elevation (feet)
Bottom of lagoon elevation (feet)
Freeboard (feet)
Side slopes (inside lagoon)
712800 lbs
Volume(CF)/lb. ALW
1 CF/lb. ALW
Total design volume using prismoidal
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2
2.8 2.8 2.8 2.8
AREA OF TOP
LENGTH * WIDTH =
560.9 244.4
AREA OF BOTTOM
LENGTH * WIDTH =
502.6 186.1
AREA OF MIDSECTION
LENGTH-* WIDTH * 4
531.8 215.3
CU. FT. = [AREA TOP
137116.2
formula
LENGTH
560.9
566.5
250.0
52.8
41.3
1.0
2.8 : 1
WIDTH DEPTH
244.4 10.5
137116.17 (AREA OF TOP)
93506.314 (AREA OF BOTTOM)
457836.75 (AREA
OF MIDSECTION * 4)
+ (4*AREA MIDSECTION) + AREA BOTTOM]
457836.8 93506.3
* DEPTH/6
1.8
Total Designed Volume Available =1204803.7 CU. F

,TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
566.5 250.0 141625.0 square feet
Buildings (roof and lot water)
0.0 square feet Describe this area.
TOTAL DA 141625.0 square feet
Design temporary storage period to be 180 days.
Volume of waste produced
Feces & urine production in gal./day per 135 lb. ALW 1.37
Volume = 712800 lbs. ALW/135 lbs ALW * 1.37 gal/day 180 days
Volume = 1302048 gals. or 174070.6 cubic feet
Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system or excess water. Flush systems
that recirculate the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/day * 180 days storage/7.48 ggallon
Volume = 0.0 cubic feet
Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount
180 days excess rainfall = 7.0 inches
Volume = 7.0 inches * DA / 12 inches per foot
Volume = 82614.6 cubic feet
5D. Volume of 25 year - 24 hour storm
Volume = 7.5 inches / 12 inches per foot * DA
Volume = 88515.6 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 174071 cubic feet
5B. 0 cubic feet
5C. 82615 cubic feet
5D. 88516 cubic feet
TOTAL 345201 cubic feet

SUMMARY
Temporary storage period > 180 days
Rainfall in excess of evaporation > 7.0 inches
25 year - 24 hour rainfall > 7.5 inches
Freeboard > 1.0 feet
Side slopes > 2.8 : 1
Inside top length > 566.5 feet
Inside top width > 250.0 feet
Top of dike elevation > 52.8 feet
Bottom of lagoon elevation =__> 41.3 feet
Total required volume > 1058001 cu. ft.
Actual design volume >1204803.7 cu. ft.
Seasonal high watertable elevation (SHWT)===> 48.8 feet
Stop pumping elev. > 48.9 feet
Must be > or = to the SHWT elev. > 48.8 feet
Must be > or = to min. req. treatment el.=> 47.3 feet
Required minimum treatment volume > 712800 cu. ft.
Volume at stop pumping elevation > 825745 cu. ft.
Start pumping elev. > 50.9 feet
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume less 25 yr - 24 hr rainfall===> 1116288 cu. ft.
Volume at start pumping elevation > 1083205 cu. ft.
Required volume to be pumped > 256685 cu. ft.
Actual volume to be pumped > 257460 cu. ft.
Min. thickness of soil liner when required==> 1.7 feet
7. DESIGNED BY: APPROVED BY:
DATE: DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
COMMENTS:

SHEET 1 (_ii-
OPERATION AND MAINTENANCE PI_.iAIJ
This lagoon is designed for waste l:r. ,-atrnerat (permanent storage) and
180 days of temporary storage. The time required for the planned
fluid level (permanent and temporary storage) to be reach=:::d may nary,
due to sit.e conditions, weathc:r, flushing operations, and the amount
of fresh water added to the system.
The designed temporary storage consists of 180 days storage for:
(1) waste from animals and (2) excess rainfall after evaporation. Also
25 24 hour storm for the location.
included i s storage fir the yL��;r-. -_
' :animals will be
The volume of waste generated from a gi �,�en number
fairly constant throughout the year and from year to year, but excess
rainfall will vary from year to year. The 25 year rainfall will not
be a factor to consider in an .annual pumping cycle, br..rt this storage
volume must always be available.
A maximum elevation is determined in each design to begin
pumping and this is usually tho outlet invert of pipe(s) from
building(s). If the outlet pipe is not installed at the elevation to
begin pumping, a permanent marker roust be installed at this elevation
to indicate when pumping should begin. An elevation must be established
to stop pumping to maintain lagoon treatment depth.
Pumping can be started or stopped at any time between these two
elevations for operating convenience as site conditions permit, such
weather, soils, crop, and equ i proem in order to apply waste without
runoff or leaching.
Land application of waste water is r'ecogniLed as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent damage to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre -
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre --charging reducees the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at aa11 i:1ries. Vihera precharging is complete,
flush buildings with recycled lagoon liquid. Fresh water should not
be used for flushing after Initial filling.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and i.,.;:&ring of waste (see attachment)
before land application.
3. Begin temporary storage pump -out of the 1,igoori when fluid level
reaches r!_..
the elevation 51.0 as marked by permanent marker. Stop pump -
out when the fluid level reaches elevation 43.9 . This temporary
storage, less 25 yr-- 24 hr storm, m, contains 252182 cubic feet or
1886320 gallons.

SHEET 2 OF 2
4. The recommended maximum .amount to apply per irrigation is
one (1) inch and the recommended maximum application rate i= 0.3
I r I
inch per}lol_Ji'" Refer to thelM2:aFi'Ce utilization plan for further details.
5. Keep vegetation on the embankmcnt and areas ad,jac::nt to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation. .
7. All surface runoff is to be divested from the lagoon to stable
outlets.
8. Keep a minimum of 25 feet of grass vegetated buffer around
waste utilizi.ion fields adjacent to perennial streams. Waste will
not be applied in open ditches. Do not pump within 200 feet of a
residence or within 100 feet of a well. Waste shall be applied in a
manner not to reach other property and public right-of-ways.
9. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the Unitud States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law

Emergency Action Plan
This plan will be implemented in the event that wastes from your operations are leaking, overflowing, or
running off the site. You should NOT wait until wastes reach surface waters or leave your property to
consider that you have a problem. You should make every effort to ensure that this does not happen. This
plan should be available to all employees at the facility, as accidents, leaks, and breaks can happen at any
time.
1) Stop the release of wastes. Depending on the situation, this may or may not be possible. Suggested
responses to problems are listed below:
a) Lagoon overflow:
• add soil to the berm to increase the elevation of the dam
• pump wastes to fields at an acceptable rate
• stop all additional flow to the lagoon (waterers)
• call a pumping contractor
• make sure no surface water is entering the lagoon
Note: These activities should be started when your lagoon level has exceeded the temporary storage level.
b) Runoff from waste application field:
• immediately stop waste application
• create a temporary diversion or berm to contain the waste on the field
• incorporate waste to reduce further runoff
c) Leaking from the waste distribution system:
• pipes and sprinklers:
© stop recycle (flushing system) pump
© stop irrigation pump
© close valves to eliminate further discharge
rJ separate pipes to create an air gap and stop flow
• flush system, houses, solids separators:
O stop recycle (flushing system) pump
© stop irrigation pump
O make sure no siphon effect has been created
® separate pipes to create an air gap and stop flow
d) Leakage from base or sidewall of the lagoon. Often these are seepage as opposed to flowing
leaks:
• dig a small well or ditch to catch all seepage, put in a submersible pump, and pump back
into the lagoon

O if holes are caused by burrowing animals, trap or remove animals
and fill holes and compact with a clay type soil.
+� other holes may be likewise temporarily plugged with clay soil.
Note: For permanent repair measures, lagoon problems require the
consultation of an individual experienced in their design and installation.
2) Assess the extent of the spill and note any obvious damages.
a) Did the waste reach any surface waters?
b) Approximately how much was released and for what duration?
c) Any damage noted, such as employee injury, fish kills, or property damage?
3) Contact appropriate agencies.
a) During normal business hours, call your DWQ regional office: 910/395-3900 after
hours, emergency number: 1/800-662-7956 Your phone call should include: your
name, facility, telephone number, the details of the incident, the exact location of the
facility, and the location or direction of movement of the spill, weather and wind
conditions, what corrective measures have been taken, and the seriousness of the situation.
b) If the spill leaves the property or enters surface waters, call the local EMS:
640-6610
c) Instruct EMS to contact the local Health Department: 6 4 0 - 6 6 1 7
d) Contact CES: 6 4 0- 6 6 0 6
local NRCS office: 6 4 2- 2 3 4 8
and your integrator:
4) Implement procedures as advised by DWQ and technical assistance agencies to rectify the
damage, repair the system, and reassess the waste management plan to keep problems with
release of wastes from happening again.
5) Contact contract pumping and/or irrigation equipment companies:
a)
b)
c)
6) Contact dirt moving and/or heavy equipment companies:
a)
b)

Version --November 26, 2018
Mortality Management Methods
Indicate which .method(s) mil bshoptementect
When selecting multiple methods indicate a primmy verses secondary option.
Methods other than those listed must be approved by the Sty Veterinarian.
Primary Secondary Routine Mortality
❑ 11 -Burial three feet beneath the surface of the 24 Isom of lm owledge of animal
death. The burial must be at least 300 feet from any Sowing stream or public body of water
(a.S_ 10-4031. The bottom of the _b iria l pit shouldbeat one foot -above the seasonal
high water table. Attach burial location map and I
El El Landfill at municipal solid waste facility permkted by 6 C DEQ under CS 15A NCAC
138 .0200.
ElRendering at a rendering plant licensed under G.S..106-168.1.
u
Complete incineration according to 02 NCAC 52C .OtO2.
❑ fl A composting system approved and permiiied by the feDepartment of Agriculture & Con-
sumer Services Veterinary Division (attach copy of paw_ iif c mpost is distributed off -farm,
additional requirements truest be met and atom is 14C DEO_
❑ r} In the case of dead poultry only, placing in a cfisposal pit € f a size and design approved by Mee
NC Department of Agriculture & Consumer Services (G S_ 106-549 0).
Any method which, in the professional opiniontotftwe Siam Veterinarian, would make possible
the salvage of part of a dead animal's value without erodangering human or animal health.
(Witten approval by the State Veterinarian Met be
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan ouSries farm -specific mortality man-
agement methods to be used for mass may. The NC CS Veterinary Division sup-
ports a variety of emergency mortality dispersal ors;, the Division for guidance.
• A -catastrophic mortality disposal plan is paw off CAWMP and is activated
when numbers of dead animals exceed normal rates as specified by the State
Veterinarian.
▪ Burial must bedone in accordance with NC and NCOA&CS Veterinary
Division regulations and -guidance.
• Mass burial sites are subject to additional permit condeliors (refer to facility's animal
waste management system .permit)
• In the event of imminent threat of a disease emergency, the ate Veterinarian may enact
addition temporary procedures or measureswing to G.S. 106-99 A.
Owner/Manager
Signature of Technical specialist
Date
5-12— /9
Date

Murphy -Brown, LLC
4/13/2016 RO. Box 856
Warsaw, NC 288
NUTRIENT UTILIZATION PLAN
Grower(s): London C. Caber
Farm Name: L C. Cam Farm
Coun Columbia
Farm Ca•aci
Farrow to Wean V -
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Wean to Finish
Feeder to Finish 5,2801
Storage Structure: Anaerobic Lagoon
Storage Period: >180 days
Application Method: Irrigation
The waste from your animal facility must be land applied at a speared rate to prewnt pollution
of surface water and/or groundwater. The plant nutrients in the mania waste shoukt be used
th reduce the amount of commercial fertilizer required for the aops in the where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient Waste shorWd be anatyzed
before each .application circle, Annual soil tests are strongly encouraged so not an plant
nutrients can be balanced for realistic yields of the crop to be _
Several factors are important in implementing your waste utilization plan order to maximize
the fert er value of the waste and to ensure that it is applied in an environmentally safe manner
1. Always apply waste based on the needs of the crop babe grown and the nutrient
content of the waste. Do not apply more nitrogen than the cep can u6T¢e.
2. Soil types are important as they have different infehatinn rates, teaching potentials,
cation exchange capacities, and available water .
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at5 8mm-tamper acre annually, but
less than 10 flans per acre per year providing that adequate fillerstrips are established.
4. Do not apply waste on saturated soils, when it is raining„ or when the surface is frozen.
Either of these conditions may result in runoff to sure waters which is not allowed
under DWQ regulations,
5.. Wind conditions should also be considered to avoid .dyad downwind odor
problems.
6. To maximize the value of the nutrients for crop pmduction and to reduce the potential
for pollution, the waste should be applied to a growing at* or applied not more than
30 days prior to planting a crop or forages breaking dormancy.. Injacbng the waste or
disking will conserve nutrients and reduce odor problems_
1 of 8

This plan is based on the „ate application .method shown .above, Myna &meet) change
methods in the future, you need to revise this plan. Nutrient levees
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nf curtest
for this type of facility. In some cases you may want to have plant analysis made, rya could
allow additional waste to be applied. Provisions shall be made forte area receiving waste to
be flexible so as to accommodate changing waste analysis contents per. Lice nwst
be applied to maintain pH in the optimum range for specific crop Via.
This waste utilization plan, if carried out, meets the requirements for coneitamce a h 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, if, tons, etc.):
t, Capacity
5280
Type
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Wean to Finish
Feeder to Finish
Waste Produced per Anima Total
3203 gallkr gal/yr
3861 r atiyr ga
10478 gagyr gatlyr
191 gallIyr gai/yr
776 gallyr' gal-Yr
927 9at''1T 4„894„560 ,9alln
Tote 4,894,560 pallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (
Capacity
5280
Type Nitrogen Produced per Aoiefed Teta
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Wean to Finish
Feeder to Finish
3.84 fstyr
6.9498
18.8604 Ibslyr
0.3438thew ibsfyr
1.3968 lyr ibsiyr
1.6686 tslyr 8,810 lbsty f
Total 8,810 lbsly
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for Mit facility
Note that the Nitrogen Balance for Crops indicates the ratio of the Hof ntimigen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total irrigated At leave:
Total N Required 4st Year: 10403.428
Total N Required 2nd Year: 13
Average Annual Nitrogen Requirement of Crops: 10,403.93
Total Nitrogen -Produced by Farm: 6,818.21
Nitrogen Balance for Crops: (1,593.72)
The following table describes the specifications of the hydrants and t ' the crops
-designated flu utilization of the nitrogen produced on this fir T sue,
soil characteristics, and uptake rate for each crop in the sped clop rota= schadtie forts is
facility
2 of 8

Reception Ares Spocifleatiottla
Tract Meld Irrigated $o1I 1st Crop Time to 1st Crop tat Crop Lb1 N/Ac Lbe N Total Ibe N
Acrebge Type Code Appt Yield lb* N1Unit Reaidusl Ms Utilised
2nd Crop Time to 2nd Crap 2nd Crop Lbe MAC Lb* N 'Tom Iba N
Code Apply .Yield Ids NlUnit Residual Me Utilized
Total
Lb! NIAc
'Total 'at N
Utilized
T1844
1
$.5
GOA
;,,
March -Sep
6.50
40.25
262
1438.938
K
S0pt-Ap111
1
50
275
311.626
1713 936
T1844
1A
2.7
GoA
t3H
, Aug -July
4.00
40.2$
181
434,7
+'
_
0
0
161
4347
r. '1844
2
3.84-
GoA
BC '
March -Sept
.6- 0..
... 40.25,.._.
,.. __
2}82
952.315
iC
Sepl-April
1
50
1 50
_
182
311,825
1134 315
T1844
3
4.
Re-CoA
GH
,Aug -July
4.00
38.94
' 158
623.04
. • *
.+W..+i.w
11
0
0
156.78
623 04
T1844
4
5.2
GoA
GH
Aug -July
4.00
40.25
f ]p1
837,2
*
0
0
161
837.2
11644
5
2.4
GoA
aH
Aug -July
4.00.
40.25
161
368,4
*
0
0
161
366.4
T1844
6
2.7
Ly
OH
Au9-JUly
4.50
37.63
169
457,2045
*
0
0
169.335
4572046
T1844
7
2.5
Ly-Re
GH
Aug -July
4.50.
37.63
169
423.3375
*
0
0
988.335
423.3375
T1644
8
4.6
Lso-Re
GH
Aug -July
4.50
37.63
.169
778.941
*
0
0
169.335
776.941
T1647
9
10
NaA
OH
Aug-Ju1y
3.50
40.25
141
1406.75
*
a
0
140.875
1408.75
71851
10
6.11
NoA .
Gil
Au9-July
3.50.
40.25
141
804,3183
*
0
0
140.875
004.3963
71851
11
5.45
NoA .
OH
• Aug -July
3.50
40.25
141
767.7688
*
0
p
140.875
767 7680
71651
12
4.5
NoA
GH
Aug-Ju1y
3.50
40.26
141
833.9375
*
o
0
140.876
833.9375'
T1847
13
3.98
NoA-Ra,
GM
Aug -July
0
0
*
0
0
0
0
tee.
1
- a
-
��
-
- - ,
- ---�.-
--�
--
--
-•.a
,...,.,...��
w.-.�..
-�
n'atalc: 0181 910128 467 10403.13

Reception Area Specifications
Tryst
Field
Irrigated
Acr$attle
Soli lst Crop Time to let Crop 1st Crop
Tkpe Code Apt Yield Ube Nlunit
Lbs NIAc
.ResIdua�
Lhs N
Ac
Total Ib* N
Unfixed
2nd Crop Time to end Crop 2nd Crop
Code Avplr Yield lb* NItinit
Lha le/AC
Residual
Lba N TbtaI list H
/AC mitred:
Total
Lb$ NIAG,t}tlllzed
meal tbs N
0
0
"
0
0
---
0.
0
"
0
0
0
0
"
0
0
"
0
0
0
0
-
r
0.
0
0
0
0
0
'
0
0
0
0
{
: _
_ . ,..,n»m:�+:
,.__,..--..
_...�.
*
Totnisl

22503

22493

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1 Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prole.
2
3
There must be daaae- kyr the design folder that the producer either owns or has art
agreement for use of adequate tad on which to properly apply the waste. If the producer
does not own adequate Wirt to pfoperly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
aging hint' the use of the lid for waste application-. It is the responsibility of the
owner of the waste -'-; ,;.... facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recieving crop hoe, or available land.
Animal waste shalt be applied to meet, but not exceed, the nitrogen needs for realistic
crop yields sod- type available moisture, historical data, climatic conditions,
and level of management imless there are regulations that +reatru. t the rate of applications
for other nutrients.
4 Animal waste shalt be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land erodingall more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field
(See USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be n3duced by ` ` the waste or disking after waste application. Waste
should not be appbed when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated an c mod. When waste is applied to conservation tilled
crops or find,, the waste may be broadcast provided the application does not occur
during a season- prone to bootfeng (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shag be applied at ryes not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site dui application. No omitting should occur in order to control odor and
flies.
& Animal waste shalt not be embed to saturated sow, during rainfall events, or when the
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied en actively growing -crams in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should -also be considered_
10 Nutrients from waste shall not be applied in fall or winter for spring plantxlcrops on soils
with a nigh potential for leaching. Waste/nutrient loading rates on use soils should be
held to a minimum and a suitable winter cover crop planted to take up reed nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11
12
Any new swine facility sited on or after October 1, 1995 sly comply with the following:
The outer perimeter of the land area onto which waste is 2ppried from a lagoon that is a
component of a swim farm shall be at least 50 feet frern any residential property
boundary and canal. Animal waste, other than swine waste from facilities sited on or after
October 1, 1995, shall not be applied closer than 25 feet to perennial wags.
Animal waste shall not be applied closer than 100 feet to wed.
Animal waste shall not be applied closer than 200 feet of chipeektgs other than those
13 owned by the landowner.
Waste shall be applied in a manner not to reach other property and public right-of-ways.
14
Animal waste shall not be disohar-ged into sthrfao a waters, itrainsgeways, or wetlands by
discharge or by over -spraying. Animal waste may be appked to prior converted cropland
15 provided the fields have been approved as a -lend appication site by a "technical
specialist'. Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16
Domestic and industrial waste from washdown facilities, ems„ toNets, Sinks, etc., shall
not be discharged into the animal waste management system_
2of3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
Magoon embank, b, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where actisidered appropriate. Lagoon areas should be kept mowed
and accessible. Banns and structures should be inspected regularly for evidence of
erosion, leakage, or age.
4$ If animal produces al the � is to be suspended or terminated. the owner is
responsible for onus and implementing a "closure plan" which will eliminate the
possibility of an illegal pc thou and erosion_
Waste handing structwes, ping, pumps, reels, etc., should be inspected on a regular
19 basis to prevent breakdowns teaks and spits. A regular maintenance checklist should be
kept on site_
Animal waste can be used - a< rotation that includes vegetables and other hops for direct
20 human c onsumpton_ tin if admit waste is used on crops for direct human
consumption, it should ordy be pre -plant with no further applications of animal
waste during the crop season.
Highly vim markers al& be instalied to mark the top and bottom elevations of the
21 temporary storage I of all waste treatment lagoons. Pumping shall be
managed to maintain the revel between the markers. A marker will be required to
mark the maxim n storage volume for waste storage ponds_
Waste shall be tested wile 60 days of utilization and soil shall be tested at least annually
at crop sites where waste pry are applied. Nitrogen shall be the rate -determining
22 nutrient, unless oar restrictions require waste to beapplied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Ziinc and copper levels in
the soil shall be monitored and ire crop sites shall be used when these metals
approach excessive lam_ pH sty be adjusted and maintained for optimum crop
production. Sore and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste appication records shall be maintained for a minimum of three years.
Waste application records for an other waste shall be maintained for a minimum of five
years.
Dead animals will be disposed of in a manner that meets North Carolina regulations.
3of3

This plan does not inclaide. The farm should produce adequate- plant
available to satisfy the retpubemerds of the crops listed above.
The applicator is cautioned clot P and K may be over applied while meeting the N requirements.
€n the future, regulations may require farmers in some path of North Carolina to have a nutrient
management plan that addresses al nubients. This plan only addresses nitrogen.
In interptanted Wilds (Le. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, andfOr sue- Where grazing, plants should be grazed when they
reach a height of six to sane inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields wfeere small grain, etc, is to be removed for hay or silage, care
should be exercised not to let WM grin reach maturity, especially late in the season (Le.
brit or May). Ong may read if engin grain gets too high and this will definately interfere
with stand of be€mudagra ss. This toss of stand will result in reduced yields and less nitrogen
being utilized. Rather than crittkag smart grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or sage two to three times during the season, depending on the
time small grain is planted the fat
The ideal time to inter small grain,. etc,. is late September or early bobber. Drilling is
recommended over broadcasting_ Brass should be grazed or cut to a height of
about two inches before dfilingfor bestresults-
CROP CODE LEGEND
Crop- Code € Lbs N utilized / unit yield
A Barley 1.6- tbs N- / bushel
B Hybrid Dennudagrass - Grazed 50 lbs N / ton
C Hybrid morass - Hay 50 tbs N / ton
D Com - Grain 1.25 tbs N / bushel
E Can- Stage 't2 tbs N 1 ton
F Cotbm 0.l2 lbs N / tbs lint
G Fescue - Grazed 50" lbs N t ton
H Feecue - Hay 50 lbs N / ton
F Oats 1.3 lbs N !bushel
J RYe 2.4 tbs N / bushel
K S G - Grazed 50 tbs Nacre
L S -Hay 50tbsN/acre
M G Sorghum 2.5 lbs N 1 cwt
N Wheat 2.4 lbs N / bushel
O Soybean 4.0 lbs N / bushel
P tie Trees 40 tbs N / acre / yr
Acres shown in the prig tab a are considered to be the usable acres excluding
required buffers, filter sty eking ditches,. odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely red be, more than the acres shown in the tables.
See attached map shoeing libe fields to be used for the c tilb ation of animal waste.
4of8-

SLUDGE A.UCAT>
The following table domes the annual nigger accinnulation rate per animal
in the lagoon sludge
t=arm Specifications PANlyrfanimal FarmTotaVyr
Fairer to Wean 1184
Farrow to Feeder 1
FanTow to Fmish 4.1
Wears to Feeder 0.072
Wean 10 Finish 0.306
5280 Feeder to I=iarisb 0.36 19€ 0-.8
The waste utilization plan rm provisions for periodiciand application of sludge at
agronomic rates. The skidge ad be nutrient rich and will require precautionary measures to
prevent over application of niutitentscrollax emits. Your prods facility will produce
approximately 1900.8 pouf of phut evadable nitrogen per year will accumulate in the lagoon
serge based on the ratesof acciemitakonkstedabove.
If you remove the sludge eve Speam yens* have approximately 9504 pounds of plant
available nitrogen to utirnm Assuming you apply this PAN to hybrid Ada grass hayland at the
rate of 300 pounds of nihogen per a e< you -will -need 3 - acreas of land. If yotr apply the sludge
to com at a rate of 125 pounds per , a will need 76.032 acres of land. Please note that these
are only estimates of the PAN anl-tand required to utilize that PAN. Actual values
may only be determined by sarraihng the sludge for plant available nitrogen content prior to application
Actualutilization rates wN vary w+i s type crop-, and realistic -yield r.Aptrdatior.- fortire specific
application fields designated for stodge appfication at time of removal.
APPLICATION OF WASTE Bl'I1tRIGOiTION:
The irrigation application rale shoidd riot exceed the intake rate of the soil at the time of irrigation
such that runoff or ponclerg cowls. This rate is- Wiled by initial soil- moisture content, soil
structiwe, soil texture, organic solids. The application amount should not
exceed the ofthe soil atthe time of irrigation nor should the
plant available nitrogen exceed lie nthogen needs of the crop.
If surface irrigation is the method o1 land appication for this plan, it is the responsibility of the
producer and irrigation clesitner to ensure Cretan irrigation system is installed to properly
math the acres shown in the precedhreg table. Failure to apply the recommended rates and
amounts of nibuyet-e shown inthetablies may make this plan invalid.
*This is the marthnurn appricalion amount allowed for the soil' assuming the amount
of nib allowed kx Mae crop is not over applied. In many sue, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount ahown can be applied under optimum soil conditions.
Your facility is designed for >O ciao of teary storage and the temporary storage must
be removed on the average of ors array 6 months. En no instance should the volume of the
waste stored in your structure be *i ete 25 year 24 hour storm storage or one foot of
freeboard- except in the eves oldie 25year 24 hour storm.
It is the responds/Illy of the pw andrwaste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates andamounts of -nitrogen shown in the tables may make this plan invalid.
Call your technical spectakst afteryou t the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of8

Application Rate Guide
The following is provided as a guide for establishing application tales and amounts_
Soil Application Rate Application Amount
Tract Hydrant Type Crop inthr inches
T1644 1 GoA BC 0.4 1
T1644 1A 3oA GH 0.4 1
T1644 2 GoA BC 0.4 1
T1644 3 Ra oA GH # a.4 1
T1644 4 GoA GH 04 1
T1644 5 GoA GH 114 1
T1644 6 Ly GH Q,66 1
T1644 7 Ly-Ra GH 0.66 1
T1647 8 Lys GH 0.65 1
T1651 9 NoA GH 0_5 1
T1651 10 NoA GH 0.5 1
T1651 11 NoA GH 0.5 1
T1647 12 NoA GH 0.5 1
13 NoA-Ra GH 0_5 1
6of8

Additional Cow:
This is a revision of the NIP and irrigation design previously prepared by
Edward E. Davis with the Cokunbus County Soli; & Water Conservation. Service,
in March 200t_ Kos Weston, our irrzaat on Specialist with Murphy Brown,
made the necessary to pull 2 near the well and added putt 13 to
Tract 1647 Field 1 as weff as officially signing off on the irrigation design.
Revised 4/13120/6 - Gramm. has changed pulls in row crop rotation to Fescue.
Fescue and bennuda is in a hay/graze rate. 1/2 of the yield produced must
be removed with hay pry
7of8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Fay L. C. Carter Farm
Owner: London C. Carter
Owner/Manager Age:
Uwe understand and will fol ow aid implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above.. Uwe know that any expansion to the existing design capacity
of the waste treatment antVor StriVagesplem,_ or construction of new facilities; will require a
new nutrient management p and a new certification to be submitted to DWG before the new
animals are stocked,
Uwe understand that t must own or ha#a artcPA-s to equipment, primarily irrigation equipment,
to land apply the animal waste desaixed in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. 1 also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff
This plan will be filed on site at the faun office and at the office of the local Soli and Water
Conservation- District and veg be avaRable far review by NCDWQ upon request.
Marne of Facility Owner:
fignature:
Name of Manager (if different from owner):
Signature:
Date
Name of Technical
Anion:
Address:
Telephone:
Signature:
Date
Toni W. King
Murphy -Brown, LLC_
2822 Hwy 2.4 West, PO Drawer 858
Warsaw, NC 28398
0910) 293-3434 —___
Lop
Sof-8
r
14— a —701 (0
Date