240006_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2019.
Please do not leave any question unanswered. Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Fann Number: 24-0006 Certificate Of Coverage Number: AWS240006
2. Facility Name: Anders Farm
3. Landowner's Name (same as on the Waste Management Plan): Bra Cole Anders
4. Landowner's Mailing Address: 1138 Bavbridse Dr
City: Dillon State: SC Zip: 29536
Telephone Number: 843-845-8829 Ext. E-mail: rcandersl a,, mail.com
5. Facility's Physical Address: 12559 Swamn Fox Hwv E
City: Tabor Cit State: NC Zip: 28463
6. County where Facility is located: Columbus
7. Farm Manager's Name (if different from Landowner):
8. Farm Manager's telephone number (include area code):
9. Integrator's Name (if there is not an Integrator, write "None"): Murnhv-Brown LLC
10. Operator Name (OIC): Rhonda Coleman Anders
11. Lessee's Name (if there is not a Lessee, write 'None"):
12. Indicate animal operation type and number:
Current Permit:
Operation Types:
Phone No.: OIC #: 1004872
Operations Type Allowable Count
Swine - Feeder to Finish 4,896
Swine Cattle Dry Poultry Other Types
Wean to Finish Dairy Calf Non Laying Chickens Horses - Horses
Wean to Feeder Dairy Heifer Laying Chickens Horses - Other
Farrow to Finish Milk Cow Pullets Sheep - Sheep
Feeder to Finish Dry Cow Turkeys Sheep - Other
Farrow to Wean Beef Stocker Calf Turkey Pullet
Farrow to Feeder Beef Feeder
Boar/Stud Beef Broad Cow Wet Poultrr-
Gilts Other Non Laying Pullet
Other Layers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square(Square Feet)
Design Freeboard
'Redline"
(Inches)
1
/9 7 /
() Qi.)
-2V D 6 QA
174,240.00
]—.
1 61
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d) to the address below.
The CAWMP must include the following components:
..F the most recent Waste Utilization Plan (WUP), sinned bthe owner and a certified technical svecialistcontaining:
a. The method by which waste is applied to the disposal fields (e.. ungat10 injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
. A site map/schematic
iiY Emergency Action Plan
aA!' Insect Control Checklist with chosen best management practices noted
15^ Odor Control Checklist with chosen best management practices noted
r.6� Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
1.7!"-Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: [e-mail]
APR 0 2 2019

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge
if all required parts of this application are not completed and that if all required supporting information and
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes
representation, or certification in any application may be subject to civil penalties up to $25,000 per vi
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign.
corporation, signature should be by a principal executive officer of the corporation):
Name: "� `� �Lf�._.(,-.Q, e-Ae,
�
-ti tle:
Signature: C_ +lJ
Name: Title:
Signature: Date:
-A-- .-
Name:
Signature:
Date:
3- a c9-1
Title:
Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
E-mail: [e-mail]
FORM: RENEWAL -STATE GENERAL 02/2019
. I understand that,
attachments are not
any false statement,
olation. (18 U.S.C.
5 years, or both for
If Landowner is a

ROY COOPER
GavCrnor
MICHAEL 5. REGAN
SeCrefary
LINDA CULPEPPER
Director
Bray Cole Anders
Anders Farm
1138 Baybridge Dr
Dillon, SC 29536
0 In
ydpj
APd 022019
NORTH CAROLINA
Enrtroamentat Quality
February 27, 2019
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits.
which expire on September �30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at httos://deq.nc.eov/about/divisions/water-resources/water-quality -regional-operations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure \ our continued coverage under the State Non -Discharge General Permits, ► ou must submit an application for
permit coverage to the Division. Enclosed you will fmd a "Request for Certificate of Coverage Facility Currently Covered by an
Expiring State Non -Discharge General Permit." The application form must be completed. signed and returned by April 3, 2019,
Please note that_3ou must include one (11 cop►of the Certified Animal Waste Management Plan CAWMP) with the
completed and signed application form. A list of items included in the CAWMP can be found on page 2 of the renewal
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Enclosures
cc (w/o enclosures):
Sincerely,
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Wilminzion Regional Office, Water Quality Regional Operations Section
Columbus County Soil and Water Conservation District
AFOG Section Central Files - AWS240006
Murphy -Brown LLC
No h Cerot' pa Department of Erevi-onreets' Q;ally I Dhis'ss of Water Resa:;raes
512 tt. Salshary St j 1€3£ mei Cester j Fa&egtr, Nert°; Cs^c7F.sa.27655-1636
9i9.707 5nO

SWINE LAGOONDESIGN
Operator:i County:_CDf< 1 v.z s Date: /2-2-9/
Distance to nearest residence (other than owner): / o © o feet -�
1. STEADY STATE LIVE WEIGHT
sows (farrow to finish) x 1417 lbs. _ _ _ lbs
sows (farrow to feeder) x 522 lbs. = lbs
3 head (finishing only) x 135 lbs. _ '(fs7.(9ibs
sows (farrow to wean) x 433 lbs. _ _ lbs
head (wean to feeder) x 30 lbs. = lbs
TOTAL STEADY STATE LIVE WEIGHT (SSLW) _ if- % s 7z ° lbs
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = ' 7.5 7 ZO1bs. SSLW x Treatment Volume(CF)/lb. SSLW
Treatment Volume(CF)/lb. SSLW= •1 _ CF/lb. SSLW
Volume = cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = cubic feet

4 I U i FaL Uk.51 b N V'ULUPIL
_r
/4-0x2.Qo _ 4 ,5,s2o p' v
psix3 6=Ylf7--14' Pr
Inside top length feet ; Inside top width feet
Top of dike at elevation '5 0,0 feet
Freeboard / o " feet ; Side slopes +5" : 1 (Inside lagoon)
Total design lagoon liquid level at elevation _�' 9.O feet
Bottom of lagoon elevation 3 r�5' feet
Seasonal high water table elevation 3 feet
Total design volume using pr.ismoidal formula
SS/END1 SS/END2 SS/SIDEI SS/SIDE2 LENGTH WIDTH DEPTH
- .5 2. 5— � , .5' a " 5 a 8 G / 6-/ /o,
AREA OF TOP
LENGTH * WIDTH =
AREA OF BOTTOM
LENGTH * WIDTH =
(AREA OF TOP)
(AREA OF BOTTOM)
AREA OF MIDSECTION
LENGTH *WIDTH * 4 3, _ 0 9m = 3 �9 ? - 5/p 6-0
x 32/.67_ = k17.2, - - 37a = (AR r-
CU. FT. _ [AREA TOP + (4*AREA MIDSECTION) +AREA. BOTTOM] * DEPTH/6
VOLUME OF LAGOON AT TOTAL DESIGN LIQUID LEVEL = 7`g 6-0 0 CU. FT.
r,,vc ii D -5 c. i, a14/ ors
et A., Z' ,4 "„ (71 f 4r -1 i ory 4-i ' 1,4
n. .;_r 7"; ,v i G'. n.G;
S1;2a/46-11 2 g 7.
, , "ice �✓, r / d .5'4.:0

5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
= /ozs,Y_square feet
Buildings (roof and lot water)
Length * Width =
square feet
TOTAL DA = square feet
Design temporary storage period to be /be, days.
5A. Volume of waste produced
Approximate daily production of manure in CF/LB SSLW 0.00136
Volume = 9S- 7aQ Lbs. SSLW * CF of Waste/Lb./Day * / eo _ days
Volume = /2 /.? z cubic feet

This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume =
gallons/day * days storage/7.48 gallons
per CF
Volume = -- cubic feet
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
days excess rainfall = % o inches
/ o 2 3-34-
in * DA / 12 inches per foot
Volume = 7
Volume = .s 9 /2 c ubic feet
5D. Volume of 25 year - 24 hour storm
/o z?4 fr.;..
Volume = 7, inches / 12 inches per foot * DA
Volume = 6 4z ,ys cubic feet
TOTAL REQUIRED - TEMPORARY STORAGE
/35 1- cubic feet
58, cubic feet
j5C. 5- / a. cubic feet
,j5D. a,Fcubic feet
TOTAL ,I5-23-'4> cubic feet

6. SUMMARY
Total required volume 7 1c 572o cubic feet
Total design volume avai 1. 7(a6-ocubic feet 6s", Avor, A>/;5-1/e-,07-
Min. req. treatment volume plus sludge accumulation 9 72cubic fee
At elev, feet ; Volume is 1gS 7 o cubic feet (end pumping)
Total design volume less 25yr-24hr storm is ?ee5-cubic feet
At elev. 8, 3 feet ; Volume is67788i°"cubic feet (start pumping)
Seasonal high water table elevation 3 feet
7. DESIGNED BY; M ,h,'ers APPROVED BY: 4
DATE: J2-.0-9/ DATE: ,./-ie2- 9/
/g/I�y>3= / ass✓''
2

OPERATION AND MAINTENANCE PLAN
This lagoon is designed for waste treatment with minimum odor
control. The time required for the planned fluid level to be
reached may vary due to soil conditions,flushing operations, and
the amount of fresh water added to the system.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent runoff from the field or damage
to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre -
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see Attachment B)
before land application.
3. Begin pump -out of the lagoon when fluid level reaches eleva-
tion 448,3. as marked by permanent markers. Stop pump -out when
the fluid level reaches elevation`''or before fluid depth is
less than 6 feet deep (this prevents the loss of favorable
bacteria) .
4. The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0.4
inch per hour.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. A11 surface runoff is to be diverted from the lagoon to stable
outlets.
8. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.

EMERGENCY ACTION PLAN
PHONE NUMBERS
DWQ 910-.
EMERGENCY MANAGEMENT SYSTEM 911
SWCD 910-
NRCS .'910-
1
1-800- 858-03(08
c 0-442-3.1'ic
This plan will be implemented in the event that wastes from
your operation are leaking, overflowing, or running off
site.- You should not wait until wastes reach surface waters
or leave your property to consider that you have a problem..
You should make every effort to ensure that this does not
happen. This plan should be posted in an accessible
location for all employees at the facility. The following
are some action items you should take.
1. Stop the release of wastes. Depending on the
situation, this may or may not be possible. Suggested
responses to some possible problems are listed below.
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields.at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B: Runoff from waste application field -actions
include: - -
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to -reduce runoff.
d. Evaluate and eliminate the reason(s) that
caused the runoff.
e. Evaluate the application rates for the fields
where runoff occurred.
C: Leakage from the waste pipes and sprinklers -action
include:
a. Stop recycle pump.
b. Stop irrigation pump.
c.. Close valves to eliminate further discharge.

d. Repair all leaks prior to restarting pumps.
D: Leakage from flush systems, houses, solid
separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure no siphon occurs.
d. Stop all flows in the house, flush systems, or
solid separators.
e. Repair all leaks prior to restarting pumps.
E: Leakage from base or sidewall of lagoon. Often
this is seepage as opposed to flowing leaks -
possible action:
a. Dig a small well or ditch to catch all seepage,
put in a submersible pump, and pump back to
lagoon.
b. If holes are caused by burrowing animals, trap
or remove animals and fill holes and compact
with a clay type soil.
c. Have a professional evaluate the condition of
the side walls and lagoon bottom as soon as
possible.
2. Assess the extent of the spill and note any obvious
damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what
duration?
c. Any damage noted, such as employee injury, fish
kills, or property damage?
d. Did the spill leave the property?
e. Does the spill- have the potential to reach surface
waters?
f. Could a future rain event cause the spill to reach
surface waters?
g. Are potable water wells in danger (either on or off
of the property) ?
h: How much reached surface waters?
3: Contact appropriate agencies.
a. During normal business hours, call your DWQ
(Division of Water Quality) regional office; Phone
910-486-1541• After hours, emergency number: 919-
733-3942. Your phone call should include: your
name, facility, telephone number, the details of

the incident from item 2 above, the exact location
of the facility, the location or direction of
movement of the spill, weather and wind conditions.
The corrective measures that have been under taken,
and the seriousness of the situation.
b. If spill leaves property or enters surface waters,
call local EMS Phone number .911.
c. Instruct EMS to contact local Health Department.
d. Contact CES, phone number 910-862-4591, local SWCD
office phone number 910-862-6936, and local NRCS
office for advice/technical assistance phone number
910-862-6936_
4: If none of the above works call 911 or the Sheriff's
Department and explain your problem to them and ask
that person to contact the proper agencies for you.
5: Contact the contractor of your choice to begin repair
of problem to minimize off -site damage.
a. Contractors Name:
b. Contractors Address:
c. Contractors. Phone:
6: Contact the technical specialist who.certified the
lagoon (NRCS, Consulting Engineer, etc.)
r
a. Name:
b. Phone:
7: Implement procedures as advised by DWQ and technical
assistance agencies to rectify the damage, repair the
system, and reassess the waste management plan to keep
problems with release of wastes from happening again.
claudelneahlwordiemgeetpien.dcx
wept 12,96

OPERATION & MAINTENANCE PLAN
Proper lagoon liquid management should be a year-round priority. It is especially important to
manage levels so that you do not have problems during extended rainy and wet periods.
Maximum storage capacity should be available in the lagoon for periods when the receiving crop
is dormant such as wintertime for bermudagrass or when there are extended rainy spells such as
the thunderstorm season in the summertime. This mean c that at thefirst signs of plant growth in
the later winter/early spring, irrigation according to a farm waste management plan should be
done whenever the land is dry enough to receive. lagoon liquid.. This will make storage space
available in the lagoon for future wet periods. In the late summer/early fall the lagoon should be
pumped down to the low marker to allow for winter storage_ Every effort should be made to
maintain the lagoon close to the minimum liquid level as long as the weather and waste utilization
plan will allow it.
Waiting until the lagoon has reached its maxximum storage capacity before starting to irrigate does
not leave room for storing excess water during extended wet periods. Overflow from the lagoon
for any reason except a 25-year, 24-hour storm is a violation of state law and subject to penalty
action.
LAGOON MAINTENANCE
The routine maintenance of a lagoon involves the following:
✓ Maintenance of a vegetative cover for the dam. Fescue or common bermudagrass are the
most common vegetative covers. The vegetation should be fertilized each year, if needed,
to maintain a vigorous stand. The amount of fertilizer applied should be based on a sods
test, but in the event that it is not practical to obtain a soils test each year, the lagoon
embankment and surrounding areas should be fertilized with 800 pounds per acre of
10-10-10, or equivalent.
✓ Brush and trees on the embankment must be controlled. This may be done by mowing,
spraying, grazing, chopping, or a combination of these practices. This should be done at
least once a year and possibly twice in years that weather conditions are favorable for
heavy vegetative growth.
NOTE:Ifvegetation is controlled by spraying, the herbicide must not be allowed to enter the
lagoon water. Such chemicals could harm the bacteria in the lagoon that are treatingthe waste

Maintenance inspections of the entire lagoon should be made during the initial filling of the lagoon
and at least monthly and after major rainfall and storm events. Items to be checked should
include, as a minimum, the following:
✓ Waste Inlet Pipes, Recycling Pipes, and Overflow Pipes --- look for:
1 . separation of joints
2. cracks or breaks
3. accumulation of salts or minerals
4. overall condition of pipes
d Lagoon surface --- look for:
1. undesirable vegetative growth
2. floating or lodged debris
1 Embankment --- look for:
1. settlement, cracking, or "jug" holes
2. side slope stability --- skimps or bulges
3. wet or damp areas on the back slope
4. erosion due to lack of vegetation or as a result of wave action
5. rodent damage
Larger lagoons may be subject to liner damagedue to wave action caused by strong winds.
These waves can erode the lagoon side walls, thereby weakening the lagoon dam. A good stand
of vegetation will reduce the potential damagecaused by wave action. If wave action causes
serious damage to a lagoon side wall, baffles in the lagoon may be used to reduce the wave
impacts.
Any of these features could lead to erosion and weakening. of the dam. If your lagoon has any of
these features, you should call an appropriate expert -familiar with design and construction of
waste lagoons. You may need to provide a temporary fix if there is a threat of a waste discharge.
However, a permanent solution should be reviewed by the technical expert. Any digging into a
lagoon dam with heavy equipment is a serious undertaking with potentially serious consequences
and should not be conducted unless recommended by an appropriate technical expert.
Transfer Pumps --- check for proper operation of
1 . recycling pumps
2. irrigation pumps
Check for leaks, loose fittings, and overall pump operation. An unusually loud or grinding noise,
or a large amount of vibration, may indicate that the pump is in need or repair or replacement.
NOTE: Pumping systems should be inspected and operated frequently enough so that
you are not completely "surprised" by equipment failure. You should perform your pumping
system maintenance at a time when your lagoon is at its low level. This will allow some safety
time should major repairs be required. Having.a nearly.fiill lagoon is not the time. to think about.

switching, repairing, or borrowing pumps. Probably, if your lagoon is full, your neighbor's lagoon
is full also. You should consider maintaining an inventory of spare parts or pumps.
Surface water diversion features are designed to carry all surface drainage waters
(such as rainfall runoff roof drainage,.. gutterr outlets,. and parking lot runoff away
from your lagoon and other waste treatment or storage structures. The only water
that should be coming into your lagoonis that which comes from your flushing
(washing) system pipes and the rainfall that hits the lagoon directly. You should
inspect your diversion system for the following:
1. adequate vegetation
2. diversion capacity
3. ridge berm height
Identified problems should be corrected promptly.. It is advisable to inspect your system during or
immediately following a heavy ram. If technical assistance is needed to determine proper
solutions, consult with appropriate experts.
You should record the level ofthe lagoon just prior to when ram is predicted, and then record the
level again 4 to 6 hours after the ram (assumes.there.is.no pumping)_ This will give you an idea of
how much your lagoon level will rise with a certain rainfall amount (you must also be recording
your rainfall for this to work). Knowing this should help in_planning irrigation applications and
storage. If your lagoon rises excessively, you may have an inflow problem from a surface water
diversion or there may be seepage into the lagoon from the surrounding land.
Lagoon Operation
Startup:
1. Immediately after construction establish a complete sod cover on. bare soil surfaces
to avoid erosion.
2. Fill new lagoon design treatment volume at least half full of water before waste
loading begins, taking care not to erode lining or -bank slopes.
3. Drainpipes into the lagoon should have.a_flexmle pipe extender on the end ofthe
pipe to discharge near the bottom of the lagoon during initial filling or another
means of slowing the incoming water to avoid erosion ofthe lining.
4. When possible, begin loading new lagoons in the spring to maximize bacterial
establishment (due to warmer weather).

5. It is recommended that a new lagoon be seeded with sludge from a healthy
working swine lagoon in the amount of 0.25 percent of the full lagoon liquid
volume. This seeding should occur at least two weeks prior to the addition of
wastewater.
6. Maintain a periodic check on the lagoon liquid pH_ If the pH falls below 7.0, add
agricultural lime at the rate of 1 pound per 1000 cubic feet of lagoon liquid volume
until the pH rises above 7.0. Optimum lagoon liquid pH is between 7.5 and 8.0.
7. A dark color, lack of bubbling, and excessive odor signals inadequate biological
activity. Consultation with a technical specialist is recommended if these
conditions occur for prolonged periods, especially during the warm season.
Loading:
The more frequently and regularly that wastewater isadded to a_ lagoon, the better the lagoon will
function. Flush systems that wash waste into the lagoon several times daily are optimum for
treatment Pit recharge systems, in which one or more buildings are drained and recharged each
day, also work well.
Practice water conservation --- minimize buildingwater usage and spillage from
leaking waterers, broken pipes and wash down through proper maintenance and
water conservation.
Minimize feed wastage and spillage by keeping feeders adjusted. This will reduce
the amount of solids entering the lagoon
Management:
✓ Maintain lagoon liquid level between the permanent storage level and the full temporary
storage level.
1 Place visible markers or stakes on the lagoon bank to show the
minimum liquid. level and the maximum liquid lever (Figure 2- 1).
✓ Start irrigating at the earliest possible date in the spring based on nutrient requirements
and soil moisture so that temporary storagewill be maximized for the summer
thunderstorm season. Similarly, irrigate in the late summer/early fall, to provide maximum
lagoon storage for the winter.
✓ The lagoon liquid level should never be closer than 1 foot to the lowest point of the dam
or embankment.

✓ Do not pump the lagoon liquid level lower that the permanent storage level unless you are
removing sludge.
✓ Locate float pump intakes approximately 18 inches underneath the liquid surface and as
far away from the drainpipe inlets as possible.
✓ Prevent additions of bedding materials, long-stemmed forage or vegetation, molded feed,
plastic syringes, or other foreign materials into the lagoon.
✓ Frequently remove solids from catch basins at end of confinement houses or wherever they
are installed.
✓ Maintain strict vegetation, rodent, and varmint control near lagoon edges. Do not allow
trees or large bushes to grow on lagoon dam or embankment.
✓ Remove sludge from the lagoon either when the sludge storage capacity is full or before it
fills 50 percent of the permanent storage volume.
1 if animal production is to be terminated, the owner is responsible for obtaining and
implementing a closure plan to eliminate the possibility of a pollutant discharge.
Sludge Removal:
Rate of lagoon sludge buildup can be reduced by:
• proper lagoon sizing,
• mechanical solids separation of flushed waste,.. gravity settling of flushed waste solids in an
appropriately designed basin, or
• minimizing feed wastage and spillage.
Lagoon sludge that is removed annually rather than stored long term will:
• have more nutrients,
• have more odor, and
• require more land to properly use the nutrients.
Removal techniques:
• Hire a custom applicator.
• Mix the sludge and lagoon liquid with a chopper -agitator impeller pump through
large -bore sprinkler irrigation system onto nearby cropland; and soil incorporate.

'4
• Dewater the upper part of lagoon by irrigation onto nearby cropland or forage land; mix
remaining sludge; pump into liquid sludge applicator;. haul and spread onto cropland or
forage land; and soil incorporate.
• Dewater the upper part of lagoon by irrigation onto nearby cropland or forage land;
dredge sludge from lagoon with drag line or sludge barge; berm an area beside lagoon to
receive the sludge so that liquids can drain back into lagoon; allow sludge to dewater; haul
and spread with manure spreader onto cropland or forage land; and soil incorporate.
Regardless of the method, you must have the sludge material analyzed for waste constituents just
as you would your lagoon water. The sludge will contain different nutrient and metal values from
the liquid. The application of the sludge to fields will be limited by these nutrients as well as any
previous waste applications to that field and crop requirement.
When removing sludge, you must also pay attention to the liner to prevent damage. Close
attention by the pumper or drag -Tine operator will ensure that the lagoon liner remains intact. If
you see soil material or the synthetic liner material being.. disturbed, you should stop the activity
immediately and not resume until you are sure that the sludge can be removed without liner injury.
If the liner is damaged it must be repaired as soon as possible.
Sludge removed from the lagoon has a much higher phosphorus and heavy metal content than
liquid. Because of this it should probably be applied toland with low phosphorus and metal
levels, as indicated by a soil test, and incorporated to reduce the chance of erosion. Note that if
the sludge is applied to fields with very high soil -test phosphorus, it should be applied only at
rates equal to the crop removal of phosphorus. As with other wastes, always have your lagoon
sludge analyzed for its nutrient value.
The application of sludge will increase the amount of odor atthe waste application site. Extra
precaution should be used to observe the wind direction and other conditions which could
increase the concern of neighbors.
Possible Causes of Lagoon Failure
Lagoon failures result in the unplanned dischargeof wastewater from the structure. Types of
failures include leakage through the bottom or sides, overtopping, and breach of the dam.
Assuming proper design and construction, the owner has the responsibility for ensuring structure
safety. Items which may lead to lagoon failures include:
Modification of the lagoon structure..--- an example is the placement of a pipe in
the dam without proper design and construction. (Consult an expert in lagoon
design before placing any pipes in dams )
Lagoon liquid levels --- high levels are a. safety risk.

•
Failure to inspect and maintain the dam.
Excess surface water flowing into the lagoon.
Liner integrity --- protect from inlet pipe scouring, damage during- sludge
removal, or rupture from lowering.lagoon liquid level below groundwater table.
NOTE: If lagoon water is allowed to overtop the dam, the moving water will soon cause
gullies to form in the dam. Once this damage starts, it. canquickly cause a large discharge of
wastewater and possible dam failure

Flush tanks • Agitation of recycled lagoon
liquid while tanks are filling
Flush alleys • Agitation during wastewater
Pit recharge points
Lift stations
conveyance
Source
Farmstead
Swine Farm Waste Management Odor Control Checklist
Animal body surfaces
Cause
• Swine production
BMPs to Minimize Odor
'Vegetative or wooded buffers;
O Recommended best management practices;
LW' Good judgment and common sense
• Dirty manure -covered animals O' Dry floors
Site Specific Practices
Floor surfaces • Wet manure -covered floors t Slotted floors;
Gib Waterers located over slotted floors;
O Feeders at high end of solid floors;
O Scrape manure buildup from floors;'
O Underfloor ventilation for drying
Manure collection pits • Urine; ®' Frequent manure removal by flush, pit recharge,
• Partial microbial decomposition or scrape;
O Underfloor ventilation
Ventilation exhaust fans • Volatile gases; B' Fan maintenance;
Dust B' Efficient air movement
Indoor surfaces • Dust iTY Washdown between groups of animals;
O Feed additives;
O Feeder covers;
EeFeed delivery downspout extenders to feeder
covers
O Flush tank covers;
O Extend fill lines to near bottom of tanks with
anti -siphon vents
O Underfloor flush with underfloor ventilation
• Agitation of recycled lagoon C'Extend recharge lines to near bottom of pits
liquid while pits are filling with anti -siphon vents
• Agitation during sump tank O Sump tank covers
filling and drawdown
Outside drain collection • Agitation during wastewater 0 Box covers
or junction boxes conveyance
AMOC - November 11, 1996, Page 3

Source
End of drainpipes at
lagoon
Lagoon surfaces
Irrigation sprinkler
nozzles
Storage tank or basin
surface
Settling basin surface
Manure, slurry or sludg
spreader outlets
Uncovered manure,
slurry or sludge on field
surfaces
Dead animals
Dead animal disposal
'pits
Incinerators
Cause
• Agitation during wastewater
conveyance
• Volatile gas emissions;
• Biological mixing;
• Agitation
• High pressure agitation;
• Wind drift
• Partial microbial decomposition;
• Mixing while filling;
• Agitation when emptying
• Partial microbial decomposition;
• Mixing while filling;
• Agitation when emptying
e • Agitation when spreading;
• Volatile gas emissions
• Volatile gas emissions while
drying
• Carcass decomposition
• Carcass decomposition
BMPs to Minimize Odor
Extend discharge point of pipes underneath
lagoon liquid level
IV Proper lagoon liquid capacity;
EVCorrect lagoon startup procedures;
O Minimum surface area -to -volume ratio;
"Minimum agitation when,pumping;
O Mechanical aeration;
O Proven biological additives
Si -Irrigate on dry days with little or no wind;
O Minimum recommended operating pressure;
LW'Pump intake near lagoon liquid surface;
O Pump from second -stage lagoon
O Bottom or midlevel loading;
O Tank covers;
O Basin surface mats of solids;
O Proven biological additives or oxidants
O Extend drainpipe outlets underneath liquid
level;
O Remove settled solids regularly
O Soil injection of slurry/sludges;
O Wash residual manure from spreader after use;
O Proven biological additives or oxidants
O Soil injection of slurry/sludges
O Soil incorporation within 48 hrs.;
O Spread in thin uniform layers for rapid drying;
O Proven biological additives or oxidants
C� Proper disposition of carcasses
Site Specific Practices
•e;
• Incomplete combustion
O Complete covering of carcasses in burial pits;
O Proper location/construction of disposal pits
0 Secondary stack burners
AMOC - November 11, 1996, Page 4

Source
Standing water around
facilities
Manure tracked onto
public roads from farm
access
Cause
• Improper drainage;
• Microbial decomposition of
organic matter
• Poorly maintained access roads
BMPs to Minimize. Odor
Pr -Grade and landscape such that water drains
away from facilities
1'Farm access road maintenance
Additional Information :
Site Specific Practices
Swine Manure Management ; 0200 RuleBMP Packet
'Swine Production Farm Potential Odor Sources and Remedies ; EBAE Fact Sheet
Swine Production Facility Manure Management: Pit Recharge - Lagoon Treatment ; EBAE 128-88
Swine Production Facility Manure Management: Underfloor Flush - Lagoon Treatment ; EBAE 129-88
Lagoon Design and Management for Livestock Manure Treatment and Storage ; EBAE 103-83
Calibration of Manure and Wastewater Application Equipment ; EBAE Fact Sheet
Controlling Odors from Swine Buildings ; PIH-33
Environmental Assurance Program ; NPPC Manual
Options for Managing Odor ; a report from the Swine Odor Task Force
Nuisance Concems inAnimalManure Management: Odors and Flies ; PRO107, 1995 Conference Proceedings
Available From :
NCSU, County Extension Center
NCSU -BAE
NCSU - BAE
NCSU BAE
NCSU BAE
NCSU -BAE
NCSU - Swine Extension
NC Pork Producers Assoc
NCSU Agri Communications
Florida Cooperative Extension
AMOC - November 11, 1996, Page 5

Flush Gutters
Insect Control Checklist for Animal Operations •
Source Cause BMPs to Control Insects
Liquid Systems
• Accumulation of solids cVFlush system is designed and operated
sufficiently to remove accumulated solids from
,gutters as designed.
Gal Remove bridging of accumulated solids at
discharge
Lagoons and Pits • Crusted Solids
Excessive Vegetative • Decaying vegetation
Growth
Cie Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the
crusting of solids to a depth of no more than 6 -
8 inches over more than 30% of surface.
-Maintain vegetative control along banks of
lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along water's edge on impoundment's perimeter.
Site Specific Practices
Dry Systems
Feeders • Feed Spillage Design, operate and maintain feed systems (e.g.,
bunkers and troughs) to minimize the
accumulation of decaying wastage.
See Clean up spillage on a routine basis (e.g., 7 - 10
day interval during summer; 15-30 day interval
during winter).
Feed Storage
• Accumulations of feed residues lia. Reduce moisture accumulation within and
around immediate perimeter of feed storage
areas by insuring drainage away from site
andlor providing adequate containment (e.g.,
covered bin for brewer's grain and similar high
moisture grain products).
0 Inspect for and remove or break up accumulated
solids in filter strips around feed storage as
needed.
AMIC - November 11, 1996, Page 1

Source Cause BMPs to Control Insects. Site Specific Practices
Animal Holding Areas
• Accumulations of animal wastes 0 Eliminate low areas that trap moisture along
and feed wastage fences and other locations where waste
accumulates and disturbance by animals is
minimal.
O Maintain fence rows and filter strips around
animal holding areas to minimize
accumulations of wastes (Le., inspect for and
remove or break up accumulated solids as
needed).
Dry Manure Handling • Accumulations of animal wastes 0 Remove spillage on a routine basis (e.g., 7 - 10
Systems day interval during summer; 15-30 day interval
during winter) where manure is loaded for land
application or disposal.
O Provide for adequate drainage around manure
stockpiles,
O Inspect for and remove or break up accumulated
wastes in filter strips around stockpiles and
manure handling areas as needed.
For more information contact the Cooperative Extension Service, Department of Entomology, Box 7613, North Carolina State University,
Raleigh, NC, 27695.7613.
AMIC • November 11, 1996, Page 2

Version —November 26, 2018
Mortality Management Methods
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
El Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location map and plan.
El Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
aO Rendering at a rendering plant licensed under G.S. 106-168.7.
ElEl Complete incineration according to 02 NCAC 52C .0102.
Q A composting system approved and permitted by the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
El In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
Any method which, in the professional opiniomof the State Veterinarian, wouldmake possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
DMass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be.done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
Date
3-0?9-/9
Signature of Technical Specialist Date

Mortality Management Methods
(check which method(s) are being implemented)
Burial three feet beneath the .surface of the ground within 24 hours after
knowledge of the death. The burial must be at least 300 feet from any flowing
stream or public body of water.
Rendering at a rendering plant licensed under G.S. 106-168.7
Complete incineration
❑ In the case of dead poultry only, placing in a disposal pit of a size and design
approved by the Department of Agriculture
Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of -part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian must be
attached)
December I8, I996

Murphy -Brown, LLC 12/20/2013 2822 Hwy 24 West
P.O. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Grower(s):
Farm Name:
County:
Farm Capacity
Darrell Stocks
Stocks Farm
Columbus
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish
a•
4896
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
>180 days
Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant.
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner-
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 11

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft3, tons, etc.):
Capacity Type Waste Produced per Animal Total
4896
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish
3212 gal/yr
4015 gal/yr
10585 gallyr
223 gal/yr
986 gal/yr
gallyr
gal/yr
gal/yr
gallyr
4,827,456 gal/yr
Total 4,827,456 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs):
Capacity Type Nitrogen Produced per Animal Total
4896
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish
5.4 lbs/yr
6.5 lbs/yr
26 lbs/yr
0.48 lbs/yr
2.3 Ibs/yr
lbs/yr
Ibs/yr
lbs/yr
lbs/yr
11,261 Ibs/yr
Total 11,261 lbs/yr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 44.54
Total N Required lst Year: 12023.69
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops:
Total Nitrogen Produced by Farm:
Nitrogen Balance for Crops:
12,023.69
11,260.80
(762.89)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 11

'Rece
ption ion Area Specifications
\\401/
J
Tract Field Irrigated Soil 1st Crop Time to 1st Crop 1st Crop Lbs N/A Lbs N Total ibs 2nd Crop
Pull Acreage Type Code Apply Yield Ibs N/Unit Residua /Ac Utilized Code
T6506 243.75
T6506
T6506
T6506
T6504
T6504
T6504
T6504
T6504
T6504
T6504
T6504
T6504
T6504
T6504
1
2
3
4
5
6
7
8
9
10
13
15
22
23
2.78
2.39
2.13
2.18
2.75
1.93
1.81
2.21
2.92
1.93
NoB
NoB
NoB
NoB
NoB/Ly
NoB/Ly
NoB/Ly
NoB/Ly
FoA
4.36
5.51
1.97
5.52
4.15
Ly
Ly
Ly
Ly/NoA
Ly
Ly
Bermuda (G)
Bermuda (G)
Bermuda (G)
Bermuda (G)
Bermuda (G)
Bermuda (G)_
Bermuda (G)..
Bermuda(G)
Bermuda (G)
Bermuda (G)
Bermuda (G)
Bermuda (G)..
Bermuda (G)
Bermuda (G)
,Bermuda (G)
Mar -Sept
Mar -Sept
Mar -Sept -
Mar -Sept
Mar -Sept
Mar -Sept
Mar -Sept
Mar -Sept
Mar -Sept
Mar -Sept
Mar -Sept
Mar -Sept
Mar -Sept
6.5
6.5 _
6.5
6.5
6.0
6.0
6.0
6.0
6.0
5.5
5.5
5.5
6.0
37.5
37.5
37.5
37.5
37.5
37.5
37.5
37.5
__ 37.5
37.5
37.5
37.5
37.5
243.75
243.75
243:75
225.00
225.00
225.00
677.63
582.56
519.19
531.38
618.75
434.25
407.25
_ 225.00 497.25
657.00
225.00
_ 206.25 398.06
206.25 899.25
206.25
225.00
1136.44
443.25
Mar -Sept
Mar -Sept
5.5
5.5
37.5
37.5
206.25
206.25
1138.50
855.94
Overseed (G
Overseed (G
Overseed (G
Overseed (G
Overseed (G
Overseed (G
Overseed (G
Overseed (G
Overseed (G
Overseed {G
Overseed (G
Overseed (G
Overseed {G
Overseed (G
Overseed (G
Optional Fields 8 Crops
T6504
T6504
T6504
T6504
T6504
_ 16
T6504
T6507
T6507
T6507
T6507
T6507
17
18
19
20
21
24
25
26
27
28
2.89
2.95
3.51
277
6.24
4.51
Ly _
Ly
GoA
GoA
GoA
2.33
3.05
2.05
1.6
1.72
Ly
NoA
NoA
NoA
NoA
NoA
Additiona Crops for Optional Fields
T6504 16,17,21 10.35 Ly
T6504 16,17,21 10.35 Ly
T6504
T6504
T6504
T6504
T6504
T6504
T6504
T6504
16,17,21
16,17,21
16,17 21
18,19,20
18,19 20
18,19,20
18,19,20
18,19,20
10.35
10.35
10.35
12.52
12.52
12.52
12.52
12.52
Ly
Ly
Ly
Corn
Com
Corn
Com
Corn
Com
Bermuda (G)
Bermuda (G)
Bermuda (G)
Bermuda (G)
Bermuda (G)
GoA
GoA
GoA
GoA
GoA
Wheat
Soybeans
Feb15-June
Feb15-June
Feb15-June
Feb15-June
Feb15-June
Feb15-June
Mar -Sept
Mar -Sept
Mar -Sept
Mar -Sept
130.0
1.25
162.50
469.63
130.0
130.0
130.0
130.0
1.25
1.25
1.25
1.25
162.50
162.50
162.50
162.50
479.38
570.38
450.13
1014.00
130.0
Mar -Sept
Sm Grain {G)
Millet (G)
Oats
Wheat
Sepl-Apr
6.5
6.5
6.5
6.5
6.5
1.25
37.5
37.5
37.5
162.50
243.75
243.75
243.75
732.88
567.94
743.44
499.69
37.5
37.5
243.75
_ 243.75
390.00
419.25
Overseed {G)
_Overseed(G)
Overseed(G)
Overseed (G)
Overseed (G
Apr-Sept15
Sept -Apr
Apr-Sept15
Sept -Apr 15
Soybeans
Sm Grain (G)
Millet (G)
Oats
Sept -Apr
Apr-Sept15
Sept -Apr
Apr-Sept15
55.0
39.0
1.0
4.7
94.0
65.0
38.0
Sept -Apr 15
1.0
5.5
2.4
4
75
41.25
1.3
2.4
4
75
132.00
15`6.00
75.00
193.68
122.20
156,00
152.00
75.00
1366.20
1614.60
776.25
2006.61
1264.77
1953.12
1903.04
939.00
110.0
41.25
1.3
226.88
143.00
2840.48
1790.36
Note: Deduct 15 lbs N/ac from starting PAN rate of any crop that follows soybeans
to account for residual N.
Note: PAN rates shown above for corn, wheat, soybeans and oafs are for crops harvested asrain.
If these crops are harvested bytgrazing, the maximum PAN rate shall be 75 !bs N/ac.
Totals: 44.54
9796.69
3(a) of 11
Time to nd Crop 2nd Crop Lbs N! Lbs N
Apply Yield Ibs N/Unit Resid !Ac
Total Ibs N
Utilized
Total
Lbs N1Ac
Total Ibs N
Utilized
1 Sept -Apr
1
50
50.00
139.00
293.75
816.63
Sept -Apr
1
50
50.00
r 119.50
_
293.75
702.06
Sept -Apr
1
50
50.00
106.50
293.75
625.69
Sept -Apr
1
50
50.00
109.00
293.75
640.38
Sept -Apr
1
50
50.00
137.50
275.00
756.25
Sept -Apr
1
50
50.00
96.50
275.00
530.75
Sept -Apr
1
_
50
50.00
90.50
275.00
_
497.75
Sept -Apr
1
50
50.00
110.50
275.00
607.75
Sept -Apr
1
50
_
50.00
146.00
2
275.00
_
803.00
Sept -Apr
1
50
50.00
96.50
256.25
' 494.56
Sept -Apr
1
50
50.00
218.00
256.25
1117.25
Sept -Apr
1
50
50.00
275.50
256.25
Sept -Apr
1
50
50.00
98.50
275.00
1411.94
Sept -Apr
_
1
50
50.00
276.00
256.25
541.75
1414.50
Sept -Apr
1
50
50.00
207.50
256.25
1063.44
0_00
0.00
162.50
1
0.00
0.00
162.50
469.63
479.38
0.00
0.00
162.50
0.00
0.00
162.50
570.38
450.13
0.00
0.00
162.50
Sept -Apr
1
,
0.00
0.00
162.50
1014.00
732.88
50
50.00
116.50
293.75
684.44
Sept -Apr
1
50
50.00
152.50
293.75
895.94
Sept -Apr
1
50
_
50.00
102.50
293.75
Sept -Apr
1
50
50.00
80.00
602.19
Sept -Apr
1 -
50
50.00
86.00
293.75
293.75
470.00
505.25
_
0.00
0.00
132.00
1366.20
0.00
'
0.00
156.00
1614.60
0.00
0.00
75.00
776.25
0.00
0.00
193.88
2006.61
0.00
0.00
122.20 _,
1264.77
0.00
0.00
156.00
1953.12
0.00
0.00
152.00
1903.04
0.00
0.00
75.00
939.00
_
0.00
0.00
226.88
2840.48
0.00
0.00
143.00
1790.36
2227.00 12023.69

Reception Area Specifications
Tract Field Irrigated Soil 1st Crop Time to 1st Crop 1st Crop Lbs N!Ac Lbs N Total Ibs N 2nd Crop Time to 2nd Crop 2nd Crop Lbs NIAc Lbs N Total Ibs N Total I Total Ibs N
Acreage Type Code Apply Yield Ibs N!Unit Residual !Ac Utilized Code A..I Yield Ibs N/Unit Residual !Ac Utilized Lbs N!Ac Utilized
Totals:
0
0
3(b) of 11

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (Le.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
A
B
C
D
E
F
G
H
J
K
L
M
N
0
P
Crop
Lbs N utilized / unit yield
1.6 Ibs N / bushel
37.5 lbs N / ton
50 lbs N / ton
1.25 Ibs N / bushel
12 Ibs N / ton
0.12 Ibs N / Ibs lint
37.5 Ibs N / ton
50 lbs N / ton
1.3 Ibs N / bushel
2.4 Ibs N / bushel
50 Ibs N / acre
50 Ibs N / acre
2.5lbs N/cwt
2.4 Ibs N / bushel
4.0 Ibs N / bushel
40 Ibs N / acre / yr
Q Millet Grazed 41.25 lbs N / ton
S Small Grain - Grazed 75 Ibs N / ac
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
Barley
Hybrid Bermudagrass - Grazed
Hybrid Bermudagrass - Hay
Com - Grain
Com - Silage
Cotton
Fescue - Grazed
Fescue - Hay
Oats
Rye
Grazed Overseed
Overseed Hay
Grain Sorghum
Wheat
Soybean
Pine Trees
See attached map showing the fields to be used for the utilization of animal waste.
4 of 11

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PAN/yr/animal Farm Total/yr
Farrow to Wean 0.84
Farrow to Feeder 1
Farrow to Finish 4.1
Wean to Feeder 0.072
4896 Feeder to Finish 0.36 1762.56
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 1762.56 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 8812.8 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 29 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 70.5024 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 11

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil Application Rate Application Amount
Tract Hydrant Type Crop in/hr * inches
T6506 1 NoB 3ermuda (G 0.5 1
T6506 2 NoB 3ermuda (G 0.5 1
T6506 3 NoB 3ermuda (G 0.5 1
T6506 4 NoB 3ermuda (G 0.5 1
T6504 5 NoB/Ly 3ermuda (G 0.5 1
T6504 6 NoB/Ly 3ermuda (G 0.5 1
T6504 7 NoB/Ly 3ermuda (G 0.5 1
T6504 8 NoB/Ly 3ermuda (G 0.5 1
T6504 9 FoA 3ermuda (G 0.5 1
T6504 10 Ly 3ermuda (G 0.65 1
T6504 11 Ly 3ermuda (G 0.65 1
T6504 13 Ly 3ermuda (G 0.65 1
T6504 15 Ly/NoA 3ermuda (G 0.65 1
T6504 22 Ly 3ermuda (G 0.65 1
T6504 23 Ly 3ermuda (G 0.65 1
Optional Fields &
T6504 16 Ly Corn 0.65 1
T6504 17 Ly Corn 0.65 1
T6504 18 GoA Corn 0.4 1
T6504 19 GoA Corn 0.4 1
T6504 20 GoA Corn 0.4 1
T6504 21 Ly Corn 0.65 1
T6507 24 NoA 3ermuda (G 0.5 1
T6507 25 NoA 3ermuda (G 0.5 1
T6507 26 NoA 3ermuda (G 0.5 1
T6507 27 NoA 3ermuda (G 0.5 1
T6507 28 NoA 3ermuda (G 0.5 1
additional Crops for Op
T6504 16,17,21 Ly Wheat 0.65 1
T6504 16,17,21 Ly Soybeans 0.65 1
T6504 16,17,21 Ly ►m Grain (G 0.65 1
T6504 16,17,21 Ly Millet (G) 0.65 1
T6504 16,17,21 Ly Oats 0.65 1
T6504 18,19,20 GoA Wheat 0.4 1
T6504 18,19,20 GoA Soybeans 0.4 1
T6504 18,19,20 GoA ;m Grain (G 0.4 1
T6504 18,19,20 GoA Millet (G) 0.4 1
T6504 18,19,20 GoA Oats 0.4 1
c from starting PAN rai
to account for resi
)r corn, wheat, soybear
Led by grazing, the ma)
6 of 11

Additional Comments:
This plan revised to show the addition of pulls 27-28 in the optional fields.
All other parameters remained the same.
7 of 11

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: Stocks Farm
Owner: Darrell Stocks
Manager
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Darrell Stocks
Signature:
n.
Date
Name of Manager (if different from owner):
Signature:
Name of Technical Specialist:
Affiliation:
Address:
Signature:
Date
M. Kevin Weston
Murphy -Brown, LLC.
2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone: [phone]
8 of 11
/ 2o/2a/3
Date

1
2
3
NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recieving crop type, or available land.
Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic
crop yields based upon soil type, available moisture, historical data, climatic conditions,
and level of management, unless there are regulations that restrict the rate of applications
for other nutrients.
4 Animal waste shall be applied to land eroding Tess than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field
(See USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and
flies.
Animal waste shall not be applied to saturated soils, during rainfall events, or when the
9 of 11

9
NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11
12
13
14
15
16
Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property
boundary and canal. Animal waste, other than swine waste from facilities sited on or after
October 1, 1995, shall not be applied closer than 25 feet to perennial waters.
Animal waste shall not be applied closer than 100 feet to wells.
Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
Waste shall be applied in a manner not to reach other property and public right-of-ways.
Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
10 of 11

17
18
19
NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, Teaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21
Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23
Dead animals will be disposed of in a manner that meets North Carolina regulations.
11 of 11

Stocks Form
Irrigation Addition (27 6 28)
T6507 Fide 1-3
Scalar 1'-200'
Specifications: (Pipe)
TB Thrust Block
AV Air Vent
2 Existing Hydrant
New Hydrants (2)
New 4" Class 200 PVC
(Approx. 400')
Specifications: (Pulls)
3" Traveler w/965' Hose
w/Nelson 150 Big Gun
w/1.08" Nozzle 0 60 PSI
182 GPM; 270' WD (300x.9)
180' Lane Spacings
Tie into existing
main line here
40Y.HY N
Pull # Acres
24 2.33
25 3.05
26 2.05
27 1.60
28 1.72
Total 10.75
Residence
w/200'
offset
12/20/2013