090184_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2019.
Please do not leave any question unanswered. Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Farm Number: 09-0184 Certificate Of Coverage Number: AWS090184
2. Facility Name: A & A Farm
3. Landowner's Name (same as on the Waste Management Plan): Albert C Beath
4. Landowner's Mailing Address: 6089 H\\ \ 210 E
City: Harrells State: NC Zip: 28444-7705
Telephone Number: 910-532-4974 Ext. E-mail:
5. Facility's Physical Address: 6114 NC Hw v 210 E
City: Harrells State: NC Zip: 28444
6. County where Facility is located: Bladen
7. Farm Manager's Name (if different from Landowner): Albert C Beam
8. Farm Manager's telephone number (include area code): 910-532-4974 Ext.
9. Integrator's Name (if there is not an Integrator, write "None"): Prestaee Farms Inc
10. Operator Name (OIC): Albert C. Beau Phone No.: 910-874-3137 OIC #: 19910
1. Lessee's Name (if there is not a Lessee, write "None"):
12. Indicate animal operation type and number:
Current Permit:
Operation Types:
Operations Type Allowable Count
Swine - Wean to Feeder 3,040
Swine Cattle Dry Poultry Other Types
Wean to Finish Dairy Calf Non Laying Chickens Horses - Horses
Wean to Feeder Dairy Heifer Laying Chickens Horses - Other
Farrow to Finish Milk Cow Pullets Sheep - Sheep
Feeder to Finish Dry Cow Turkeys Sheep - Other
Farrow to Wean Beef Stocker Calf Turkey Pullet
Farrow to Feeder Beef Feeder
Boar/Stud Beef Broad Cow Wet Poultry
Gilts Other Non Laying Pullet
Other Layers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
✓
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(Inches)
09-184-1
?. .#9,,4.
Cii617
38,010
1
2p00-,/Cez-
35
19.00
/
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d) to the address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan (WUP), signed b. the owner and a certified technical specialistcontaining:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: [e-mail]

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation, signature should be by a principal executiv officer of the corporation):
Name: /1^' 6 6 X r 'Oit Z-- Title: 0 "}/'/ s
`" F Signature: , Date: 3 2 Z -
Name: Title:
Signature: Date:
Name: Title:
Signature: Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
E-mail: [e-mail]
FORM: RENEWAL -STATE GENERAL 02/2019

ROY COOPER
Governor
MICHAEL 5. REGAN
secretary
LINDA CULPEPPER
Dfeccor
Albert C Beatty
A & A Farm
6089 Hwy 210 E
Harrells, NC 28444-7705
NORTH CAROLINA
Envirvamentai Quality
February 27, 2019
MAR 2 6 2019
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Pennittee:
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at https://deq.nc.gov/about/divisions/water-resources/water-qualit■ -regional-operations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure your continued coverage under the State Non -Discharge General Permits. you must submit an application for
permit coverage to the Division. Enclosed you will find a "Request for Certificate of Coverage Facility Currentiv Covered b■ an
Expiring State Non -Discharge General Permit." The application form must be completed. signed and returned by April 3. 2019.
Please note that v ou must include one (1) copy of the Certified Animal Waste Manaeement Plan (CAWMP) with the
completed and sianed application form. A list of items included in the CAWMP can be found on page 2 of the renewal
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Enclosures
cc (w/o enclosures):
Sincerely,
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Fat etteville Regional Office, Water Quality Regional Operations Section
Bladen County Soil and Water Conservation District
AFOG Section Central Files - AWS090184
Prestage Fanns Inc
Noah Cato 11ea Depaftnt t of:Envaron r er.te Qaa } 1 D3Y5:?ra of War ne o 'oe5
512 N. aro. ry St. 1 163E Mai Se-.v'a: Ce.ater 1 Ree;gF dart%a Ce"o]'.te 27E-5.5-SS3£
913.707.80OC

Waste Utilization Plan
Producer:
Name of Farm:
Location:
Phone:
Type of Operation:
Number of Animal:
Storage Structure:
Method of Application:
Albert C. Beatty
A & A Farm
689 NC 210 Hwy East
Harrells NC 28444
910-532-4974
Wean -Feeder
3040
Anaerobic Lagoon
Irrigation
Amount of waste produced per year:
Amount of plant available N (PAN) produced/year:
County: Bladen
1284 ton/year
1459 lbs./year
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface water and/or groundwater. The plant nutrients in the animal waste
should be used to reduce the amount of commercial fertilizer required for the crops in the
fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in the implementing your waste utilization plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an environmentally
safe manner.
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall not be applied to land eroding at more than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are
established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is
frozen. Either of these conditions may in runoff to the surface waters which is not
allowed under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor problems.
6. To maximize the value of the nutrients for crops production and to reduce the potential for
pollution, the waste should be applied to a growing crop or applied not more than 30 days
prior to planting a crop or forages breaking dormancy. Injecting the waste or disking will
conserve nutrients and reduce odor problems.
This plan is based on the waste application method shown above. If you choose to change methods
in the future, you need to revise this plan. Nutrient levels for different applications methods are
not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. In some cases you may want to have plant analysis made, which

A & A Farm
could allow additional waste to be applied. Provisions shall be made for the area receiving
waste to be flexible so as to accommodate changing waste analysis content and the crop type.
Lime must be applied to maintain pH in the optimum range for specific crop production. This
waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Page 2
Tract No.
Field No.
Soil Type
Crop
Code
Yield/Ac
Lbs. N
unit
Acres
Lbs N
Used
Month to
Apply
Lbs. N
Per Ac.
2075
1
AyB
SA
1.0
110
2.38
262
MAR15-AUG
110
2075
1
AyB
WA
1.0
100
2.38
238
SEP-MAR
_.
100
2075
2
AyB
SA
1.0
110
2.34
257
MAR15-AUG.
110
2075
2
AyB
WA
1.0
100
2.34
234
SEP-MAR'
100
2075
3
AyB
Fescue(G)
3.0
50
1.77
266
AUG-JUL
150
2075
4
AyB
Fescue(G)
3.0
50
1.39
209
AUG-JUL
150
2075
5
AyB
Fescue(G)
3.0
50
0.73
110
AUG-JUL
150
10733
6
Ce
CB -Graze
4.1
50
2.12
435
MAR-SEP
205
10733
6
Ce
SG -OS
1.0
50
2.12
106
OCT-MAR
50
10733
7
Ce
CB -Graze
4.1
50
1.73
355
MAR-SEP
205
10733
7
Ce
SG -OS
1.0
50
1.73
87
OCT-MAR
50 .
10733
8
Ce
CB -Graze
4.1
50
0.52
106
MAR-SEP
205
10733
8
Ce
SG -OS
1.0
50
0.52
26
OCT-MAR
50
1977
9
Ce
SA
1.0
110
1.45
160
MAR15-AUG
110
1977
9
Ce
WA
1.0
100
1.45
145
SEP-MAR
100
1977
10
Ce
SA
1.0
110
0.90
99
MAR15-AUG
110
1977
10
Ce
WA
1.0
100
0.90
90
SEP-MAR
100
1977
11
Ce
SA
1.0
110
0.73
80
MAR15-AUG
110
1977
11
Ce
WA
1.0
100
0.73
73
SEP-MAR
100
Total 16.06
Available Nitrogen
Surplus or deficit
Use when planting Corn
3334 lbs.
1459 lbs.
-1875 lbs.
Tract No.
Field No.
Soil Type
Crop
Code
Yield/Ac
Lbs. N
unit
Acres
Lbs N
Used
Month to
Apply
Lbs. N
Per Ac.
-2075
1
AyB
Corn
120.0
1.25
2.38
357
FEB15-JUN
150
2075
1
AyB
WA
1.0
75
2.38
179
SEP-MAR
75
2075
2
AyB
Corn
120.0
1.25
2.34
351
FEB15-JUN
150
2075
2
AyB
WA
1.0
75
2.34
176
SEP-MAR
75
2075
3
AyB
Fescue(G)
3.0
50
1.77
266
AUG-JUL
150
2075
4
AyB
Fescue(G)
3.0
50
1.39
209
AUG-JUL
150
2075
5
AyB
Fescue(G)
3.0
50
0.73
110
AUG-JUL
150
10733
6
Ce
CB -Graze
4.1
50 _
2.12
435
MAR-SEP
205
10733
6
Ce
SG -OS
1.0
50
2.12
106
OCT-MAR
50
10733
7
Ce
CB -Graze
4.1
50
1.73
355
MAR-SEP
205
10733
7
Ce
SG -OS
1.0
50
1.73
-87
OCT-MAR
50
10733
8
Ce
CB -Graze
4.1
50
0.52
106
MAR-SEP
205
10733
8
Ce
SG -OS
1.0
50
0.52
26
OCT-MAR
50
1977
9
Ce
Corn
65.0
1.25
1.45
117
FEB15-JUN
81
1977
9
Ce
WA
1.0
75
1.45
109
SEP-MAR
75
1977
10
Ce
Corn
65.0
1.25
0.90
73
FEB15-JUN
81
1977
10.
Ce
WA
1..0
75
0.90
68
- SEP-MAR
75
1977
11
Ce
Corn
65.0
1.25
0.73
59
FEB15-JUN
81
1977
11
Ce
WA
1.0
75
0.73
55
SEP-MAR
75
Total 16.06 3239 Ibs.
Available Nitrogen 1459 lbs.
Surplus or deficit -1780 lbs.
Applying the above amount of waste is a big job. You should plan time and have appropriate equipment to apply
the waste in a timely manner.

A & A Farm Page 3
The applicator is cautioned that P and K may be over applied while meeting the N requirements. In the future,
regulations may require farmers in some parts of North Carolina to have a nutrient management plan that
addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields (i.e. small grain, etc. interseeded in bermudagrass), forage must be removed through
grazing, hay and /or silage. Where grazing, plants should be grazed when they reach a height of six to nine
inches. Cattle should be removed when plants are grazed to a height of four inches. In fields where small grain
etc. is to be removed for hay or silage, care should be exercised not to let small grain to reach materity,
especially late in the season ( i.e. April or May) Shading may result if small grain gets too high and this will
definitely )nterfere with the stand of bermudagrass. This loss of stand will result in reduced yields and less
nitrogen being utilized. Rather than cutting small grain for hay or silage just before heading as is the normal
situation, you are encouraged to cut the small grain earlier. You may want to consider harvesting hay or silage
two to three times during the season, depending on the time small grain is planted in the fall.
The ideal time to interplant small grain, etc. is late September or early October . Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a height of about two inches before drilling for best
results.
Caution must be exercised in grazing or haying summer annuals under stressed conditions. Nitrate poisoning
may occur in livestock. Sampling forage or hay for nitrate levels is recommended.
Acres shown in the tables are considered to be the usable acres excluding required buffers, filters strips along
ditches, odd areas unable to be irrigated, and perimeter areas not receiving full application rates due to
equipment limitations. Actual total acres in the field listed may, and most likely will be, more than the acres
shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land application of sludge at agronomic rates. The
sludge will be nutrient rich and will require precautionary measures to prevent over application of nutrients or
other elements. Your production facility will produce approximately 219 lbs. of plant available
nitrogen per year in the sludge.
If you remove sludge every 5 years you will have approximately 1094 lbs. of PAN to utilize. Assuming you
apply this PAN to hybrid bermudagrass hayland at the rate of 300 lbs/acre you will need 4
acres of land. If you apply the sludge to corn at the rate of 125 lbs. of nitrogen per acre you will need
acres of land. Please be aware that these are only estmates of the PAN and the land needed. Actual
requirements could vary by 25% depending on the sludge waste analysis, soil types, realistic yields, and
application methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation such that
runoff or ponding occurs. This rate is limited by initial soil moisture content, soil structure, soil texture, water
droplet size, and organic solids. The application amount should not exceed the available water holding capacity

A & A Farm
Page 4
of the soil at the time of irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of
the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the producer and
irrigation designer to ensure that an irrigation system is installed to properly irrrigate the acres shown in tables.
Failure to apply the recommended rates and amounts of nitrogen shown in the tables may make this plan
invalid.
The following table is provided as a guide for establishing application rates and amounts.
Tract No.
Field No.
Soil Type
Crop
Code
Applic.
Rate(in/hr)
Applic.
Amount
2075
1
AyB
SA
0.35
1.0
2075
1
AyB
WA
0.35
1.0
2075
2
AyB
SA
0.35
1.0
2075
2
AyB
WA
0.35
1.0
2075
3
AyB
Fescue(G)
0.35
1.0
2075
4
AyB
Fescue(G)
0.35
1.0
2075
5
AyB
Fescue(G)
0.35
1.0
10733
6
Ce
CB -Graze
0.35
1.0
10733
6
Ce
SG -OS
0.35
1.0
10733
7
Ce
CB -Graze
0.35
1.0
10733
7
Ce
SG -OS
0.5
1.0
10733
8
Ce
CB -Graze
0.5
1.0
10733
8
Ce
SG -OS
0.5
1.0
1977
9
Ce
SA
0.5
1.0
1977
9
Ce
WA
0.5
1.0
1977
10
Ce
SA
0.5
1.0
1977
10
Ce
WA
0.5
1.0
1977
11
Ce
SA
0.5
1.0
1977
11
Ce
WA
0.5
1.0
Use when planting Corn
Tract No.
Field No.
Soil Type
Crop
Code
Applic.
Rate(in/hr)
Applic.
Amount
2075
1
AyB
Corn
0.35
1.0
2075
1
AyB
WA
0.35
1.0
2075
2
AyB
Corn
0.35
1.0
2075
2
AyB
WA
0.35
1.0
2075
3
AyB
Fescue(G)
0.35
1.0
2075
4
AyB
Fescue(G)
0.35
1.0
2075
5
AyB
Fescue(G)
0.35
1.0
10733
6
Ce
CB -Graze
0.35
1.0
10733
6
Ce
SG -OS
0.35
1.0
10733
7
Ce
CB -Graze
0.35
1.0
10733
7
Ce
SG -OS
0.5
1.0
10733
8
Ce
CB -Graze
0.5
1.0
10733
8
Ce
SG -OS
0.5
1.0
1977
'9
Ce
Corn
0.5
1.0
1977
9
Ce
WA
0.5
1.0
1977
10
Ce
Corn
0.5
1.0
1977
10
Ce
WA
0.5
1.0
1977
11
Ce
Corn
0.5
1.0
1977
11
Ce
WA
0.5
1.0

A & A Farm Page 5
This is the maximum application amount allowed for the soil assuming the amount of nitrogen allowed for the
crop is not over applied. in many situations the application amount shown cannot be applied because of the
nitrogen limitations. The maximum application amount shown can be applied under optimum soil conditions.
Your facility is designed for 180 days of temporary storage and the temporary storage must be removed on the
average of once every 6 months. In no instances should the volume of the waste be stored in your structure
be within the 25 year 24 hour storm storage or one foot of freeboard except in the event of the 25 year 24 hour
storm.
It is the responsibility of the producer and the waste applicator to ensure that the spreader equipment is operated
properly to apply the correct rates shown in the tables. Failure to apply the recommended rates and amounts of
nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you have receive the waste analysis report for assistance in determining the
amount of waste per acre and the proper application rate prior to appling the waste.
NARRATIVE OF OPERATION

Page 6
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: A & A Farm
Owner/Manager Agreement Albert C. Beatty
I (we) understand and will follow and implement the specifications and the operation and maintenance procedures
established in the approved animal waste utilization plan for the farm named above. I (we) know that any
expansion to the existing design capacity of the waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the North Carolina Division of Water Quality (NCDWQ)
before the new animals are stocked. I (we) also understand that there must be no discharge of animal waste from
this system to the surface waters of the state from a storm event less severe than the 25-year, 24 hour storm.
The approved plan will be filed on -site at the farm office and at the office of the local Soil and Water Conservation
District and will be available for review by NCDWQ upon request.
Name of Facility Owner:
Signature:
Albert C. Beatty
Name of Manager (If different from owner)
Signature:
Name of Person Preparing Plan: G. Glenn Clifton
Affiliation: Prestage Farms, Inc.
Address P.O. Box 438
Clinton, NC 28329
Signature:
Phone: [phone]
Date: P Z-v 11..
Date:
Date: 5Oghti

BLADEN COUNTY
EMERGENCY ACTION PLAN
DIVISION OF WATER QUALITY (DWQ) 910-486-1541
EMERGENCY MANAGEMENT SERVICES (EMS) 910-862-6760
SOIL & WATER CONSERVATION DISTRICT (SWCD) 910-862-6936
NATURAL RESOURCES CONSERVATION SERVICE (MRCS) 910-862-6936
COOPERATIVE EXTENSION SERVICE (CES) 910-862-4591
This plan will be implemented in the event that wastes from your
operation are leaking, overflowing, or running off the site. You should
NOT wait until wastes reach surface waters or leave your property to
consider that you have a problem. You should make every effort to
ensure that this does not happen. This plan should be posted in an
accessible location for all employees et the facility. The following
are some action items you should take.
1. Stop the release of wastes. Depending on the situation, this may
or may not be possible. Suggested responses to problems are
listed below:
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam, any
permanent alteration of the dam should be approved by a
qualified technical specialist.
b. Pump wastes to field at an acceptable rate.
c. Stop all additional flow to the lagoon -hold waste in the
house if possible.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
8. Runoff from waste application field -action include:
a. Immediately stop waste application.
b. Create a temporary diversion or berm to contain the
waste.
c. Incorporate waste to reduce further runoff.
d. Evaluate and eliminate the reason(a) that caused the
runoff.
e. Evaluate the application rates for the fields where
runoff occurred.
C. Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
e. Repair all leaks prior to restarting pumps.
D. Leakage from flush system, houses, solids separators -actions
include:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pump.
c. Make sure rio siphon effect has been created.
d. Stop all flows in the house, flush systems, or solid
separators.
e. Repair all leaks prior to restarting pumps.

E. Leakage from base or sidewall of lagoon. Often this is seepage
as opposed to flowing leaks -possible action:
a. Dig a small sump or ditch to catch all seepage, put in a
submersible pump, and pump back into lagoon.
b. If holea are caused by burrowing animals, trap or remove
animals and fill holea and compact with a clay type soil.
Have a professional evaluate the condition of the side
walla and the lagoon bottom as soon as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what
duration?
c. Any damage noted, such as employee injury, fish kills, or
property damage?
d. Did the spill leave the property?
a. Does the spill have the potential to reach surface
waters?
f. Could a future rain event cause the spill to reach
surface waters?
g. Are potable water wells in danger (either on or off of
the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
e. During normal business hours, call your DWQ (Division of
Water Quality) regional office, at 910-486-1541, after
hours, emergency number: 1-800-S5B-0368. Your phone call
should include: YOUR NAME, FACILITY, TELEPHONE NUMBER,
THE DETAILS OF THE INCIDENT FROM ITEM #2 ABOVE, THE
EXACT LOCATION OF THE FACILITY, AND THE LOCATION OR
DIRECTION OF MOVEMENT OF THE SPILL, WEATHER AND WIND
CONDITIONS. THE CORRECTIVE MEASURES THAT HAVE BEEN UNDER
TAKEN, AND THE SERIOUSNESS OF THE SITUATION.
b. If spill leaves property or enters surface waters, call
local (EMS) Emergency Management Services at
910-862-6760.
c. Inatruct ENS to contact local Health Department.
d. Contact local Soil and Water Conservation District
(SWCD), Natural Resources Conservation Service
(NRCS) office at 910-862-6936 and Cooperative Extension
Service (CES) at 910-862-4591 for advice/technical
aasi stance .
4. If none of the above works call 911 or the sheriffs Department
and explain your problem to them and ask that person to contact
the proper agenciea for you.

5. Contact the contractor of your choice to begin repair of the
problem to minimize off -site damage.
a. Contractors Name: 4JGH HeIREELL
b. Contractors Address: 6 AR LA nD N .
c. Contractors Phone:
G. Contact the technical specialist who certified the lagoon (NRCS,
Consulting Engineer, etc.)
a. Name: 6. 6LEt. J CLtFTo,
b. Phone: [phone]
7. Implement procedures as advised by WO and technical assistance
agencies to rectify the damage, repair the system, and reassess
the waste management plan to keep problems with release of wastes
from happening again.
8. If you are a contract swine grower associated with a swine
company integrator, contact the company representative at
1-910-592-5771

Source
Farmstead •
Swine Farm Waste Management Odor Control Checklist
Cause
• Swine production
Animal body surfaces • DIrty manure -covered animals
Floor surfaces • Wet manure -covered floors
Manure collection pits • Urine;
•,BMPs to Minimize Odor
Er'--Vegctativc or wooded buffers;
2 ecommended best management practices;
Good judgment and common sense
Site Specific Practices
❑ Dry' floors
• Partial microbial dccompositlon
Ventilation exhaust fans • Volatile gases;
Dust
Indoor surfaces • Dust
Flush tanks • Agitation of recycled lagoon
liquid while tanks are filing
t3 Slotted floors;
Waterers located over slotted floors;
FFeeders at high end ofsolid•floors;
la' Scrape manure buildup from floors;
❑ Underfloor ventilation fordrying
EY-Frequent tnanure'removal by flush, pit recharge,
or scrape;
O Underfloor ventilation
Or -Fan maintenance;
Pr -Efficient air movement
}a -Washdown between groups of animals;
O_ Teed additives;
8 Feeder covers;
2 Fecd delivery downspout extenders to feeder
• covers
Fluslt alleys • Agitation during wastewater •
conveyance
Pit recharge points • Agitation of recycled lagoon
liquid whilo,pits arc filling
Lilt stations
• Agitation during sump lank
filling and drawdown
O Flush tank covers;
extend fill lines to near bottom of tanks with
anti -siphon vents
B•-lindcrfloor flush with underfloor ventilation
2--Extend recharge lines to near bottom of pits
with antl-siphon vents
Outside drain collection • Agitation during wastewater
or junction boxes conveyance
O Sump tank covers
O Box covers
AMOC - November 11, 1996, Page 3

•
Source Cause BMPs to Minimize Odor
End of drainpipes at • Agitation during wastewater ❑ Extend discharge point of pipes underneath
lagoon conveyance lagoon liquid level
Lagoon surfaces
Site Specific Practices
Irrigation sprinkler
nozzles
• Volatile gas emissions;
• Biological mixing;
• Agitation
0. Proper lagoon liquid capacity;
'orrcct lagoon•slartup procedures;
Cr Minimum surface area -to -volume ratio;
. Gr.-Minimum agitation when.pumping;
❑ Mechanical aeration;
❑ Proven biological additives
Storage tank or basin
surface
Settling basin surface
• High pressure agitation; Irrigate on dry days with little or nu wind;
• Wind drift
ICJ, Minimum recommended operating pressure;
17 Pump intake near lagoon liquid surface;
O Pump from second -stage lagoon
• Partial microbial decomposition; 0 Bottom or midlevel loading;
• Mixing while filling; 0 Tank covers;
• Agitation when emptying 0 Basin surface mats of solids;
O Proven biological additives or oxidants
• Partial microbial decomposition; 0 Extend drainpipe outlets underneath liquid
• Mixing while filling; level;
• Agitation when emptying 0 Remove settled solids regularly
Manure, slurry or sludge • Agitation when spreading;
spreader outlets • Volatile gas emissions
Uncovered manure,
slurry or sludge on field
surfaces
❑ Soil Injection of slurry/sludges;
O Wash residual manure from spreader after use;
❑ Proven biological additives or oxidants
0 Soil injection ofslurry/sludges •
❑ Soil incorporation within 48 hrs.;
O Spread In thin uniform layers for rapid drying;
O Proven biological additives or oxidants
Dead animals • Carcass decomposition 23'Proper disposition of carcasses
Dead animal disposal
pits
Incinerators
• Volatile gas emissions while
drying
• Carcass decomposition 0 Complete covering of carcasses in burial pits;
0 Proper location/construction of disposal pits
• incomplete combustion 0 Secondary stack burners
AMOC - November 11, 1996, Page 4

Source
Standing water around
facilities
Cause
• Improper drainage;
• Microbial decomposition of
organic matter
BMPs to Minimize Odor
Grade and landscape such that water drains
away from facilities
Site Specific Practices
Manuro tracked onto
public roads from farm
access
• Poorly maintained access roads Farm access.road maintenance
Additional Information :
Available From :
Swine Manure Management ; 0200 Rule/BMP Packet
Swine Production Farm Potential Odor Sources and Remedies ; EBAE Fact Sheet
Swine Production Facility Manure Management: Pit Recharge - Lagoon Treatment ; EBAE 128-88
Swine Production Facility Manure Management: Underfloor. Flush - Lagoon Treatment ; EBAE 129-88
Lagoon Design and Management for Livestock Manure Treatment and Storage ; . EBAE 103-83
Calibration of Manure and Wastewater Application Equipment ; EBAE Fact Sheet
Controlling Odors from Swine Buildings ; P11i-33
Environmental Assurance Program ; NPPC Manual
Options for Managing Odor ; a report from the Swine Odor Task Force
Nuisance Concerns in Animal Manure Management: Odors and Flies ; PR0107, 1995 Conference Proceedings
NCSU, County Extension Center
NCSU -BAE
NCSU - BAE
NCSU - BAE
NCSU - BAE
NCSU - BAE
NCSU - Swine Extension
NC Pork Producers Assoc
NCSU Agri Communications
Florida Cooperative Extension
AMOC - November 11, 1996, Page 5

Source
Insect Control Checklist for Animal Operations
Cause HMI's to Control Insects
Flush Gutters • Accumulation of solids
Lagoons and Pits • Crusted Solids
Liquid Systems
11 flush system is designed and operated
sufficiently to remove accumulated solids from
gutters as designed.
fit Remove bridging of accumulated solids at
discharge
Sile Specific Practices
Excessive Vegetative • Dicuying vegetation
( iruwth
j Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the
crusting of solids to a depth of no more Than 6 -
8 inches over more than 30% of surface.
PI Maintain vegetative control along banks of
lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along water's edge on impoundment's perimeter.
Freda, • Need Spillage
Feed Storage • Accumulations of feed residues
AMIC - November 11, 1996, Page 1
Dry Systems
171 Design, operate and maintain feed systems (e.g.,
bunkers and troughs) to minimize the
accumulation of decaying wastage.
1 ] Clean up spillage on a routine basis (e.g., 7 - 10
day interval during summer; 15-30 day interval
during winter).
ri Reduce moisture accumulation within and
around immediate perimeter of feed storage
cu-eas by insuring drainage away limn site
and/or providing adequate containment (e.g.,
covered bin for brewer's grain and similar high
moisture grain products).
ci Inspect Iitr and remove or break up accumulated
solids in filter strips around Iced storage as
needed.

S"��'cc Cause HMPs to Control Insects. Site Specific Practices _—
Animal 1 folding Areas • Accumulations of animal wastes O Eliminate low areas that trap moisture along
and feed wastage fences and other locations where waste
accumulates and disturbance by animals is
minimal.
0 Maintain fence rows and filter strips around
animal holding areas to minimize
accumulations of wastes (i.e., inspect for and
remove or break up accumulated solids as
needed).
Dry hlaiuire I landling
Systems
• Accumulations of animal wastes O Remove spillage on a routine basis (e.g., 7 - IO
day interval during summer; 15-30 day interval
during winter) where manure is loaded for land
application or disposal.
0 Provide for adequate drainage around manure
stockpiles.
l7 Inspect for and remove or break up accumulated
wastes in filter strips around stockpiles and
manure handling areas as needed.
For more information contact the Cooperative Extension Service, Department of Entomology, Box 7613, North Carolina Stale I lniversity,
Raleigh, NC, 27695-7613.
ANIIC - Nov, :r I I, 1996, l'age 2

-SHEET i OF 2
OPERATION AND MAINTENANCE PLAN
This lagoon is designed for waste treatment (permanent storage) and
180 days of temporary storage. The time required for the planned
fluid level (permanent and temporary storage) to be reached may vary
due to site conditionss weather, flushing operations, and the amount
of fresh water added to the system.
The designed temporary storage consists of 180 days storage fors
(1) waste -from animals and (2) excess rainfall after evaporation. Also
included. is storage for the 25 year - 24 hour storm for the location.
The volume of waste 'generated from a given number .of animals will be
fairly constant rthroughout the year and from year to years but excess
rainfall will vary from 'year to year. The 25 .year rainfall will not
be a factor to cortsider in an annual pumping cycle, but -this storage
valuate must always be available.
A maximum .elevation is determined in each design tc' begin
pumping and this is usually the outlet invert of pipe(s) from
building(s). If the outlet pipe is not installed at the elevation.to
begin pumping, a permanent marker must be installed at this elevation
toindicate when pumping should begin. An elevation must be established
to stop pumping to maintain lagoon treatment depth.
Pumping can be started or stopped at any time between these two
elevations for operating convenience as site conditions permit, such as
weathers soils, crop, and equipment in order to apply waste. without
runoff or leaching.
Land application of waste water is recognized as an acceptable
method. of .disposal . Methods of application include solid set;
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent damage to crops.
The following items are to be carried out:
1. -It is strongly recommended that the treatment lagoon be pre -
charged to . 1/2 'its capacity to prevent excessive odors during
start-up : Pre -charging reduces -the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
co`►ered--.witheffluent at all times. When precharging is complete,
flush buildings With recycled lagoon liquid. Fresh water should not
be used.for flushing after initial filling
2. The.attached waste utilization plan shall be followed. This
plan recommends .sampling and testing of waste (see attachment)
before land application-..
:+. Begin.temporary storage pump -out of the lagoon when fluid level
reaches the elevation 48.3 as marked by permanent marker. Stop pump -
out when the fluidlevel reaches elevation 48.3 . This temporary
storage, -less 25 yr-`24 hr storm, contains 44322 cubic feet or
331524 gallons.

SHEET 2 OF 2
4. The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0.3
inch per hour. Refer to the waste utilization plan for further details.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
S. Keep a minimum of 25 feet of grass vegetated buffer around
.waste utilization fields adjacent to perennial streams. Waste will
not be applied in open ditches. Do not pump' within 200 feet'of a
residence or within 100 feet of a. well.- Waste shall be applied in a
manner not to reach other property and public right-of-ways.
9. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources,. Division of Environ-
mental Management, has the responsibility for enforcing this law.

C� - 1 611 Mortality Management Methods
Indicate which method(s) will be implemented.
f 4 .-..(,ti � When selecting multiple methods indicate a primary versus secondary option.
I Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location map and plan.
CI El
❑o
El El
El
d❑
Version —November 26, 2018
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
Rendering at a rendering plant licensed under G.S. 106-168.7.
Complete incineration according to 02 NCAC 52C .0102.
A composting system approved and permitted by the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
a a In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
El El Any method which, in the professional opinion of the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
i additional temporary procedu;essor measures for disposal according to G.S. 106-399.4.
4 -22
Signature of Farm Owner/Manager
Date
3/t.;72///
Signature of Technical Specialist Date

SCS-CONS-I6
OCTOBER 1974
CONSERVATION PLAN MAP
Operator
County Ali d ( State Ai C Date 98
Approximate scale / `
_ Conservation District
Plan identification , Photo number z
Assisted by 5, "aR- r r f C - USDA Soil Conservation Service
U. S. DEPARTMENT OF AGRICULTURE
SOIL CONSERVATION SERVICE
Owner Q-d b- L 3 /�
Approximate acres i`6.�
Cooperating with _47Grii
y Aqv
r4.
47:
f�l
Ns

yay- yK,r..
Y`1 ti.
•
•
aSjr.4
•
MAR•i6 2019
1
sit'•
1 _ 1r,`1rx41
rt:
•
•
La

■ • ♦h, • i•
I luY% 1II1J. mg I lJa LIV11' LI11 VG LLI 11yJ l 2-r•zeq.
All
Make, Model and Type of Equipment:
Field Not
and
Hydrant No2
3 4-
Travel
Speed
(ftlmin)
Application
Rate
(inlhr)
TRAVEL LANE
Effective Effective
Width (ft) Length (ft)
Wetted
Diameter
(feet)
EQUIPMENT SETTINGS
Nozzle Operating Operating
Diameter Pressure Pressure Arc
(inches) @ Gun (psi) Reel (psi) Pattern'
Comments
1
41 1
2
3
q
• 3.3
.33
•35
3?
3 4'a"
EGG 578 i P/.0
,`aSI
cO
Co
`IS"-
Sao
l�o Gy$ = g,33-
7oC., ?c 37 ° - 1•.3,
304, 144Kcn geI2
K
7_•Zn
7.3y
3.3ir
,31
11
110
sd 72- I Zkn
317
3?2
3
Pio
5b
�8f7
s$r7
5-0
5 U
5-a
9,
95
95
9r-
a 1 9 ti
'34c, la.opc Y7z /,73
-3‘d I /Zu J.03
3a I lea xC 39? = I•Ys
L1-0 1 josh 3.? 2� = + 9'4,
1-i-0 3D hr • Z - '3•
1See attached map provided by the SWCD Field Office for field location(s).
2Show separate entries for each hydrant location in each field.
'Use the following abbreviations for various arc pattems: F (full circle), TQ (three quarters), TT (two thirds), H (half circle), T (one third), Q (one quarter).
May also use degree of arc in degrees. •
Irrigation- Parameters
USDA-NRCS
October 1995 • . page-2 North Carolina

USDA Natural Resource Coaservattoa Service
FINAL CONSTRUCTION CHECK AND CERTIFICATION
FOR ANIMAL WASTE TREATMENT LAGOON (359)
NAME AL8EkT -5E4 iT
LOCATION 1.0 %1 iL6 SOUTR.! nt= 5n4$7-14
CRe SSR0,11
N-..2
SIZE OF OPERATION 30540
CONTRACTING COMPANY %�/1P. S, c.
FARROW TO FEEDER
FARROW TO FINISH
FARROW TO WEAN
FEEDER TO FINISH
v WEAN TO FEEDER
OTHER
DESIGN DATA AND CONSTRUCTION CHECK DATA
TBM ELEVATION 5o - FEET
%G'M rno'EC FRCM Z -" PL/GN7 Pot-'E
L,CA7'E A Fl, ti . 3 o FEE r <.AGoarl
5,se P/.3/9C GG_ ELCv. Sa•o
INSIDE TOP DIMENSION
DIKE TOP WIDTH
TOP OF DIKE
BOTTOM OF LAGOON
INSIDE SIDESLOPE
OUTSIDE SIDESLOPE
PIPE INVERT
CLAY LINER/CORE TRENCH
AS DESIGNED AS BUILT
2 Jo. x IBD
5o. o
3:1
3:f
¢8.3
1.5
zlo �x /811
3'
311
LAn c-svEL-
6AuGinG e-1e0e-
SET(g) 48•.
/•5
HAS A LAGOON BEEN SEEDED TO PERMANENT VEGETATION YES ✓ NO
DOES LAGOON MEET NRCS MINIMUM STANDARDS AND SPECIFICATIONS FOR
WASTE TREATMENT LAGOONS AS OUTLINED IN PRACTICE CODE 359?
YES ✓ NO
COMMENTS L '0c.t -1)Arn 5�Cc7c D
L/Mr.I3 C fFQ7,t,'2E'70,
CUE e
SIGNATURE gl24,,✓ 114;w TITLE LJ. i . 5PEc►»L is T DATE 10/3 1 ,1 9G

Operator AL BERT BEATTY - County: DLADEN Date; 07/08/96
Distance to nearest residence (other than owner): lnba feet
1. AVERAGE LIVE WEIGHT (ALW)
O sows (farrow to finish) x 1417 lbs. = 0 lbs
O sows (farrow to feeder) .: 522 lbs. = 0 lb-
O head (finishing only) x . 135 lbs. = 0 lbs
O sows (farrow to wean) x 433 lbs._ = 0 lbs
3040 head (wean to feeder) x 30 lbs. = 91200 lbs -
Describe other : 0
Total Average Live Weight = 91200 lbs
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 91200 lbs. ALW > Treatment Volume(CF)/lb. ALW
Treatment Volume(CF)/lb. ALW = 1.60 CF/lb. ALW
Volume = 145920 cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = '0.0 cubic feet
4. TOTAL DESIGNED VOLUME
SLUDGE ACCUMULATION NOT COMPUTED
AT OWNERS REQUEST. REMOVE SLUDGE
AS NEEDED.
Inside top length (feet) _.� _ 180.0
Inside top width (feet) 210.0
Top. of dike elevation (feet) 50.0
Bottom of lagoon elevation (feet) 40.0
Freeboard (feet) 1.0
Side slopes (inside lagoon) - 3.0 a 1
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
3.0 3.0 3.0 3.0 174.0 204.0 9.0
AREA OF TOP
LENGTH * WIDTH =
174.0 .204.0
AREA OF BOTTOM
LENGTH * WIDTH =
120.0 150.0
AREA -OF MIDSECTION
LENGTH * WIDTH . 4
147.0 177.0
35496 (AREA OF TOP).
18000 (AREA OF BOTTOM)
104076 (AREA OF MIDSECTION * 4)
CU. FT. = C AREA TOP + (4 * AREA MIDSECTION) + AREA BOTTOM ]
35496.0 104076.0 18000.0
DEPTH/6
' 1:5
.Total Designed Volume Available .= 236358 CU. FT.

5D. Volume of 25 year - 24 hour storm
Volume =
7.0 inches / 12 inches per foot * DA
Volume = 22050.0 cubic feet
TOTAL REQUIRED TEMPORARY. STORAGE
5A. 22272 cubic feet
5B. 0 cubic feet
SC. 22050 cubic -feet
5D. 22050 cubic feet
TOTAL 66 372 cubic feet
6. SUMMARY
Temporary storage period
Rainfall in excess of evaporation
25 year - 24 hour rainfall
Freeboard
Side slopes
Inside top length
Inside top width
Top of dike elevation
Bottom of lagoon elevation
Total required volume
Actual design volume
+' 'V %." of V
Seasonal high wa ter table elevation (SHWT) ===>
Stop pumping elev. -- ?
Must be > or = to the SHWT elev. >
Must be > or = to min. reg. treatment .el.=>
Required minimum treatment volume
Volume at stop pumping elevation
Start pumping elev. }
180_
7.0
7.0
1.0
3.0
180.0
210.0
50.0
40.0
21.22 2
236358
46.0
46.3
46.0
46.0
145920
146549
48.3
Must be at bottom of freeboard & 25 yr, rainfall
Actual volume less 25 yr.- 24 hr. rainfall==> 214308
Volume at start pumping elevation .; 212062
Required volume to- be pumped ---- > 44322
Actual volume planned to be pumped 63513
Min. thickness of soil liner when required==> 1.5
7. DESIGNED BY: A
DATE 7/ior9•fe
APPROVED BY: �o.
DATE; ri-1 s-R c.
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
COMMENTS: ci ti P r•-inr i4, r 5 - % - q 5)_
days
inches
inches
feet
i
feet
feet
feet
feet
cu. ft. +h
cu. ft.
feet
feet
feet
feet
cu. ft.
cu. ft.
feet
cu. ft.
cu. ft.
c!!. ft.
cu. ft.
feet
1.s2cS
e. eu&sZC