090152_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2019.
Please do not leave any question unanswered. Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Fann Number: 09-0152 Certificate Of Coverage Number: AWS090152
2. Facility Name: Twisted Hickon
3. Landowner's Name (same as on the Waste Management Plan): Charlene Carroll Gooden
4. Landowner's Mailing Address: PO Box 1242
City: Elizabethtown State: NC Zip: 28337
Telephone Number: 910-862-3008 Ext. E-mail:
5. Facility's Physical Address: 1520 Tar Kiln Neck Trl
City: Elizabethtown State: NC Zip: 28337
6. County where Facility is located: Bladen
7. Farm Manager's Name (if different from Landowner): Ronald V Gooden
8. Farm Manager's telephone number (include area code): 910-876-2041 Ext.
9. Integrator's Name (if there is not an Integrator, write "None"): Murphy -Brown LLC
10. Operator Name (OIC): Ronald V. Gooden Phone No.: 910-876-2041 OIC #: 17956
11. Lessee's Name (if there is not a Lessee, write "None"):
12. Indicate animal operation type and number:
Current Permit: Operations Type Allowable Count
Swine - Wean to Feeder 2,600
Operation Types:
Swine Cattle Dry Poultry Other Types
Wean to Finish Dairy Calf Non Laying Chickens Horses - Horses
Wean to Feeder Dairy Heifer Laying Chickens Horses - Other
Farrow to Finish Milk Cow Pullets Sheep - Sheep
Feeder to Finish Dry Cow Turkeys Sheep - Other
Farrow to Wean Beef Stocker Calf Turkey Pullet
Farrow to Feeder Beef Feeder
Boar/Stud Beef Broad Cow Wet Poultry
Gilts Other Non Laying Pullet
Other Layers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(Inches)
1
10/21IRq
c1e.,,
r87,o/1
.28,bat'
19.00
0
`
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d) to the address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan (WUP), sinned bthe owner and a certified technical specialist, containing:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: [e-mail]

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25.000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation, signature should be by a principal executive officer of the corporation):
Name: /.¢ Id 6:0 de�J Title: 07.4"re.44/s•-t, ,�rr1L -
Signature: f -},� LJ Date: 3 "2 O_ / 9
Name: Title:
Signature: Date:
Name: Title:
Signature: Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
E-mail: [e-mail]
FORM: RENEWAL -STATE GENERAL 02/2019

ROY COOPER
Governor
MICHAEL $. REGAN
Secretary
LINDA CULPEPPER
Director
NORTH CAROLINA.
Environmental Quality
February 27, 2019
Charlene Carroll Gooden
Twisted Hickory
PO Box 1242
Elizabethtown, NC 28337
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
RECEIVED/NCDEQIDWR
MAR 2 5 2019
Water Quality
Regional operations Section
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at https://deq.nc.cov/about/divisions/water-resources/water-Qualm-reaional-operations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure your continued coverage under the State Non -Discharge General Permits, \ ou must submit an application for
permit coverage to the Division. Enclosed you will fmd a "Request for Certificate of Coverage Facility Currently Covered b\ an
Expiring State Non -Discharge General Permit." The application form must be completed signed and returned by April 3. 2019.
Please note that vou must include one 1) coin of the Certified Animal Waste Management Plan iCAWMPI with the
completed and signed application form. A list of items included in the CAWMP can be found on pagve 2 of the renewal
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Enclosures
cc (w/o enclosures):
Sincerely,
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Fa\ etteville Regional Office, Water Quality Regional Operations Section
Bladen County Soil and Water Conservation District
AFOG Section Central Files - AWS090152
Murphy -Brown LLC
Nora Cara` re Department of£ro annanta-4'ua7 p I DiVeon of Water Resol000s
512 N. Salsbury St. 1 163€ Ma:. Secv oe Custer I Rear, North Carona 27E9e-163S
919.707 :9-DD4

Nutrient Management Plan For Animal Waste Utilization
11-07-2001
This plan has been prepared for:
Twisted Hickory Farm
Ronald Gooden
340 Johnson Rd.
Elizabethtown, NC 28337
Type of Plan:
This plan has been developed by:
Chris W. Bordeaux
NRCS/Bladen SWCD
122 Agriculture Service Center
Elizabethtown, NC 28337
910-862-3179 Ext. 3
. 4_4(2
Developer ignature
Nitrogen Only with Manure Only
Owner/Manager/Producer Agreement
I (we) understand and agree to the specifications and the operation and maintenance
procedures established in this nutrient management plan which includes an animal waste
utilization plan for the farm named above. I have read and understand the Required
Specifications concerning animal waste management that are included with this plan.
-:.tz%�- .cL C: i t
/ 2 -//- a /
Signature (owner) Date
/2 -//-D/
Signature (manager or producer) Date
This plan meets the minimum standards and specifications of the U.S. Department of
Agriculture - Natural Resources Conservation Service or the standard of practices
adopted by the Soil and Water Conservation Commission.
Plan Approved By:
Technical Specialist Signature Date
694920 Database Version 1.06 Date Printed: 11-07-2001 Cover Page 1

Nutrients applied in accordance with this plan will be supplied from the
following source(s):
Commercial Fertilizer is not included in this plan.
S5
Swine Nursery Lagoon Liquid waste generated 496,600 gals/year by a
2,600 animal Swine Nursery Lagoon Liquid operation. This production
facility has waste storage capacities of approximately 180 days.
Estimated Pounds of Plant Available Nitrogen Generated per Year
Broadcast
1144
Incorporated
1965
Injected
2165
Irrigated
1244
Actual PAN Applied
Year 1
1526
Notes:
In source ID, S means standard source, U means user defined source.
694920 Database Version 1.06 Date Printed: 11-07-2001 Source Page 1

Narrative
Nitrogen rate based on NRCS Standard which requires reducing nitrogen rate by 25% when grazing.
Nitrogen rate for bermuda hay is 50 lbs/ton 50 lbs X 75% = 37.5 lbs/ton for grazing.
694920 Database Version 1.06 Date Printed: 11-07-2001 Narrative Page 1

The.Waste Utilization table shown below summarizes the waste utilization plan for this operation. This plan provides an estimate of the number of acres of
cropland needed to use the nutrients being produced. The plan requires consideration of the realistic yields of the crops to be grown, their nutrient requirements,
and proper timing of applications to maximize nutrient uptake.
This table provides an estimate of the amount of nitrogen required by the crop being grown and an estimate of the nitrogen amount being supplied by manure or
other by-products, commercial fertilizer and residual from previous crops. An estimate of the quantity of solid and liquid waste that will be applied on each field in
order to supply the indicated quantity of nitrogen from each source is also included.
A balance of the total manure produced and the total manure applied is included in the table to ensure that the plan adequately provides for the utilization of the
manure generated by the operation. Animal operations that generate liquid waste and utilize waste storage facilities (lagoons or holding ponds) may apply more or
less waste in any given year than is annually generated by the facility. In order to determine whether the plan adequately utilizes the waste produced by the facility,
the storage capacity table included in this plan should be reviewed to ensure that the design capacity of the storage facility is not exceeded during the planning
period.
Depending on the requirements of the crop and the nutrient content of the waste, some nutrients will likely be over or under applied if animal waste is being
utilized. Waste should be analyzed before each application cycle and annual soil tests are required if animal waste is being applied. Soil tests should be used to
balance the nutrient application amounts with the realistic yields of the crop to be grown. Nutrient management plans may require that the application of animal
waste be limited so as to prevent over application of phosphorous when excessive levels of this nutrient are detected in a field.
Year 1
Tract
Field
Source
I.D.
Soil Series
Total
Acre
Use.
Acres
Crop
RYE
RYE
Unit
Applic.
Period
Nitrogen
PA
Nutrient
Req'd
flbs/A)
Comm.
Fert.
Nutrient
Applied
fibs/Al
Res.
(lbs/A)
, N
Applic.
Method
Manure
PA
Nutrient
Applied
Liquid
Manure
Applied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
N
N
Ibs/A
1000
gal/A
tons
1000 gals
tons
I8190002
2A1
S5
Butters
8.2
2.8
Small Grain Overseed
1.0
Tons
10/1-3/31
50
0
0
Irrig.
50
_. 20.0
0.0
55.9
0.0
18190002
2A1
S5
Butters
8.2
2.8
I13ermudagrass Pasture
5.5
Tons
3/1-9/30
* 206
0
0
lrrig.
206
82.2
0.0
230.3
0.0
18190002
2A2
S5
Foreston
8.2
0.8
Grain Overseed
1.0
Tons
10/1-3/31
50
0
0
Irrig.
50
20.0
0.0
16.0
0.0
18190002
2A2
S5
Foreston
8.2
.,Small
0.8
Bermudagrass Pasture
6.0
Tons
3/1-9/30
* 225
0
0
Irrig.
225
89.8
0.0
71.9
0.0
18190002
2B1
S5
Butters
8.2
2.3
Small Grain Overseed
1.0
Tons
10/1-3/31
50
0
0
Irrig.
50
20.0
0.0
45.9
0.0
permanent per ►0)10)17 arcidcl.nee - e aiIkp d. IbsN/�.ctc.
►2Y� 14p
i ct0002 2.AI 5m cbr os -=`S t IoJ1-33 %5"
2A2 2.$ + 75
1 1 �.g ,
694920 13� Database Verst`oiiir06 i- %5 Date Printed: 11-07-2001
r2.5
2)0
�e O
a6/62/
Grow,
2-/3- /d'
,ec��sJ'c
Q2i7-cQ/A--• d /OM
WUT Page 1

Waste Utilization Table Year 1
Tract
18190002
Field
2BI
Source
I.D.
S5
Soil Series
Butters
Total
Acre
8.2
Use.
Acres Crop
2.3 13ermudagrass'Pasture
RYE
5.5
RYE
Unit
Tons
Applic.
Period
3/1-9/30
Nitrogen Comm.
PA Fert.
Nutrient Nutrient
Req'd Applied
I1hs/A1 flbs/A I
N N
206 C
Res.
(lbs/A)
Applic.
N Method
0 Irrie.
Manure Liquid Solid Liquid Solid I�
PA Manure Manure Manure _ Manure
Nutrient Applied Applied Applied Applied :1
Applied_ (acre) (acre) (Field) (Field)
lbs/A
206
1000
alg /A tons
82.2 0.0
1000 gals
189.1
tons
0.0
Lagoon Liquids
Total Applied, 1000 gallons
Total Produced, 1000 gallons
Manure Solids
Balance, 1000 gallons
Total Applied, tons
Total Produced, tons
609
497
-112
0
Notes: 1. In the tract column, symbol — means leased, otherwise, owned. 2. Symbol * means user entered data.
Balance, tons
694920 Database Version 1.06 Date Printed: 11-07-2001 WUT Page 2

The Irrigation Application Factors for each field in this plan are shown in the following table.
.Infiltration rate varies with soils. If applying waste nutrients through an irrigation system, you must apply
at a rate that will not result in runoff. This table provides the maximum application rate per hour that may
be applied to each field selected to receive wastewater. It also lists themaximum application amount that
each field may receive in any one application event.
Irrigation Annlication Factors
Tract
Field
t -
Soil Series
Application Rate
(inches/hour)
Application Amount
(inches)
18190002
2A1
Butters
0.50
0.96
18190002' 2A2
Foreston
0.50
0.96
18190002, 2B1
Butters
0.50
0.96
694920 Database Version 1.06 Date Printed: 11-07-2001 IAF Page 1

The following Lagoon Sludge Nitrogen Utilization table provides an estimate of the number of acres needed for
sludge utilization for the indicated accumulation period. These estimates are based on average nitrogen
concentrations for each source, the number of animals in the facility and the plant available nitrogen application
rates shown in the second column.
Lagoon sludge contains nutrients and organic matter remaining after treatment and application of the effluent. At
clean out, this material must be utilized for crop production and applied at agronomic rates. In most cases, the
priority nutrient is nitrogen but other nutrients including phosphorous, copper and zinc can also be limiting. Since
nutrient levels are generally very high, application of sludge must be carefully applied.
Sites must first be evaluated for their suitability for sludge application. Ideally, effluent spray fields should not be
used for sludge application. If this is not possible, care should be taken not to load effluent application fields with
high amounts of copper and zinc so that additional effluent cannot be applied. On sites vulnerable to surface water
moving to streams and lakes, phosphorous is a concern. Soils containing very high phosphorous levels may also be
a concern.
Lagoon Sludge Nitrogen Utilization Table
Crop
Maximum
PA-N Rate
lb/ac
Maximum Sludge
Application Rate
1000 gal/ac
Minimum Acres
5 Years Accumulation
Minimum Acres
10 Years Accumulation
Minimum Acres
15 Years Accumulation
Swine Nursery Lagoon Sludge - Standard
Corn 120 bu
150
13.16
6.62
13.24
19.85
Hay 6 ton R.Y.E.
300
26.32
3.31
6.62 I 9.93
Soybean 40 bu
160
14.04
6.20
12.41
18.61
694920 Database Version 1.06 Date Printed: 11-07-2001 Sludge Page 1

The Available Waste Storage Capacity table provides an estimate of the number of days of storage
capacity available at the end of each month of the plan. Available storage capacity is calculated as the
design storage capacity in days minus the number of days of net storage volume accumulated. The start
date is a value entered by the user and is defined as the date prior to applying nutrients to the first crop in
the plan at which storage volume in the lagoon or holding pond is equal to zero.
Available storage capacity should be greater than or equal to zero and less than or equal to the design
storage capacity of the facility. If the available storage capacity is greater than the design storage
capacity, this indicates that the plan calls for the application of nutrients that have not yet accumulated. If
available storage capacity is negative, the estimated volume of accumulated waste exceeds the design
storage volume of the structure. Either of these situations indicates that the planned application interval
in the waste utilization plan is inconsistent with the structure's temporary storage capacity.
Available Waste Storage Capacity
Source Name
Swine Nursery Lagoon Liquid
Design Storage Capacity (Days)
Start Date
9/15
180
Plan Year
Month
Available Storage Capacity (Days) *
1
1
102
1
2
83
1
3
105
1
4
147
1
5
152
1
6
180
_
1
7
180
1
8
180
1
9
180
1
10
158
1
11
145
1
12
131
* Available Storage Capacity is calculated as of the end of each month.
694920 Database Version 1.06 Date Printed: 11-07-2001 Capacity Page 1

Required Specifications For Animal Waste Management
1. Animal waste shall not reach surface waters of the state by runoff, drift,
manmade conveyances, direct application, or direct discharge during
operation or land application. Any discharge of waste that reaches
surface water is prohibited.
2. There must be documentation in the design folder that the producer
either owns or has an agreement for use of adequate land on which to
properly apply the waste. 'If the producer does not own adequate land to
properly dispose of the waste, he/she shall provide evidence of an
agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the
responsibility of the owner of the waste production facility to secure an
update of the Nutrient Management Plan when there is a change in the
operation, increase in the number of animals, method of application,
receiving crop type, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs
for realistic crop yields based upon soil type, available moisture, historical
data, climatic conditions, and level of management, unless there are
regulations that restrict the rate of applications for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre
per year. Waste may be applied to land eroding at more than 5 tons per
acre per year but less than 10 tons per acre per year provided grass filter
strips are installed where runoff leaves the field (see USDA, NRCS Field
Office Technical Guide Standard 393 - Filter Strips).
5. Odors can be reduced by injecting the waste or by disking after waste
application. Waste should not be applied when there is danger of drift
from the land application field.
6. When animal waste is to be applied on acres subject to flooding, waste
will be soil incorporated on conventionally tilled cropland. When waste is
applied to conservation tilled crops or grassland, the waste may be
broadcast provided the application does not occur during a season prone
to flooding (see "Weather and Climate in North Carolina" for guidance).
7. Liquid waste shall be applied at rates not to exceed the soil infiltration
694920 Database Version 1.06 Date Printed: 11-07-2001 Specification Page 1

rate such that runoff does not occur offsite or to surface waters and in a
method which does not cause drift from the site during application. No
ponding should occur in order to control odor and flies.
8. Animal waste shall not be applied to saturated soils, during rainfall
events, or when the soil surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner
that the crop is not covered with waste to a depth that would inhibit
growth. The potential for salt damage from animal waste should also be
considered.
10. Nutrients from waste shall not be applied in fall or winter for spring
planted crops on soils with a high potential for leaching. Waste/nutrient
loading rates on these soils should be held to a minimum and a suitable
winter cover crop planted to take up released nutrients. Waste shall not
be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with
the following: The outer perimeter of the land area onto which waste is
applied from a lagoon that is a component of a swine farm shall be at
least 50 feet from any residential property boundary and canal. Animal
waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer that 25 feet to perennial waters.
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other
than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and
public right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways,
or wetlands by a discharge or by over -spraying. Animal waste may be
applied to prior convertedcropland provided the fields have been
approved as a land application site by a "technical specialist"..Animal
waste shall not be applied on grassed waterways that discharge directly
into water courses, and on other grassed waterways, waste shall be
694920 Database Version 1.06 Date Printed: 11-07-2001 Specification Page 2

applied at agronomic rates in a manner that causes no runoff or drift
from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets,
sinks, etc., shall not be discharged into the animal waste management
system.
17. A protective cover of appropriate vegetation will be established on all
disturbed areas (lagoon embankments, berms, pipe runs, etc.). Areas
shall be fenced, as necessary, to protect the vegetation. Vegetation such
as trees, shrubs, and other woody species, etc., are limited to areas where
considered appropriate. Lagoon areas should be kept mowed and
accessible. Berms and structures should be inspected regularly for
evidence of erosion, leakage, or discharge.
18. If animal production at the facility is to be suspended or terminated, the
owner is responsible for obtaining and implementing a "closure plan"
which will eliminate the possibility of an illegal discharge, pollution, and
erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected
on a regular basis to prevent breakdowns, leaks, and spills. A regular
maintenance checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other
crops for direct human consumption. However, if animal waste is used
on crops for direct human consumption, it should only be applied
pre -plant with no further applications of animal waste during the crop
season.
21. Highly visible markers shall be installed to mark the top and bottom
elevations of the temporary storage (pumping volume) of all waste
treatment lagoons. Pumping shall be managed to maintain the liquid
level between the markers. A marker will be required to mark the
maximum storage volume for waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested
at least annually at crop sites where waste products are applied. Nitrogen
shall be the rate -determining nutrient, unless other restrictions require
694920 Database Version 1.06 Date Printed: 11-07-2001 • Specification Page 3

waste to be applied based on other nutrients, resulting in a lower
application rate than a nitrogen based rate. Zinc and copper levels in the
soils shall be monitored and alternative crop sites shall be used when
these metals approach excessive levels. pH shall be adjusted and
maintained for optimum crop production. Soil and waste analysis
records shall be kept for a minimum of five years. Poultry dry waste
application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a
minimum of five years.
23. Dead animals will be disposed of in a manner that meets North Carolina
regulations.
694920 Database Version 1.06 Date Printed: 11-07-2001 Specification Page 4

Crop Notes
Small Grain: CP, Mineral Soil, low -leachable
The following crop note applies to field(s): 2A2
In the Coastal Plain, oats and barley should be planted from October 15-October 30; and rye from
October 15-November 20. For barley, plant 22 seed/drill row foot and increase the seeding rate by 5% for
each week seeding is delayed beyond the optimum time. See the seeding rates table for applicable seeding
rate modifications in the current NCSU "Small Grain Production Guide". Also, increase the initial
seeding rate by at least 10% when planting no -till. Oats should be planted at 2 bushels/acre and rye at 1-1
1/2 bushels/acre. Plant all these small grains at 1-1 1/2" deep. Adequate depth control is essential. Review
the NCSU Official Variety "green book" and information from private companies to select a high yielding
variety with the characteristics needed for your area and conditions. Apply no more than 30 lbs/acre N at
planting. Phosphorus and potash recommended by a soil test can also be applied at this time. The
remaining N should be applied during the months of February -March.
The following crop note applies to field(s): 2A2
Bermudagrass CP, Mineral Soil, Poorly Drained to Somewhat Poorly Drained.
Adaptation: Effective artificial drainage MUST be in place to achieve Realistic Yield Expectations
provided for these soils.
In the Coastal Plain, hybrid bermudagrass sprigs can be planted Mar. 1 to Mar. 31. Cover sprigs 1" to 3"
deep (1.5" optimal). Sprigs should be planted quickly after digging and not allowed to dry in sun and
wind. For Coastal and Tifton 78 plant at least 10 bu/ac in 3' rows, spaced 2' to 3' in the row. Generally a
rate of 30 bu/ac is satisfactory to produce full groundcover in one or two years under good growing
conditions. Tifton 44 spreads slowly, so use at least 40 bu/ac in 1.5' to 2' rows spaced 1' to 1.5' in row.
For broadcast/disked-in sprigs use about 60 bu/ac. Soil test for the amounts of lime, phosphorus,
potassium and micronutrients to apply preplant and for annual maintenance. Apply 60 to 100 lb/ac N in
the establishment year in split applications in April and July. For established stands apply 180 to 240
lb/ac N annually in split applications, usually in April and following the first and second hay cuts.
Reduce N rates by 25% for grazing. Refer to NCSU Technical Bulletin 305 Production and Utilization of
Pastures and Forages in North Carolina for more information or consult your regional agronomist or
extension agent for assistance.
Small Grain: CP, Mineral Soil, medium leachable
The following crop note applies to field(s): 2A1, 2B1
In the Coastal Plain, oats and barley should be planted from October 15-October 30; and rye from
October 15-November 20. For barley, plant 22 seed/drill row foot and increase the seeding rate by 5% for
each week seeding is delayed beyond the optimum time. See the seeding rates table for applicable seeding
rate modifications in the current NCSU "Small Grain Production Guide". Also, increase the initial
seeding rate by at least 10% when planting no -till. Oats should be planted at 2 bushels/acre and rye at 1-1
1/2 bushels/acre. Plant all these small grains at 1-1 1/2" deep. Adequate depth control is essential. Review
the NCSU Official Variety "green book" and information from private companies to select a high yielding
variety with the characteristics needed for your area and conditions. Apply no more than 30 lbs/acre N at
694920 Database Version 1.06 Date Printed: 11-07-2001 Crop NotePage 1

planting. Phosphorus and potash recommended by a soil test can also be applied at this time. The
remaining N should be applied during the months of February -March.
The following crop note applies to field(s): 2A1, 2B1
Bermudagrass: CP, Mineral Soil, Moderately Well Drained.
Adaptation: Well -adapted.
In the Coastal Plain, hybrid bermudagrass sprigs can be planted Mar. 1 to Mar. 31. Cover sprigs 1" to 3"
deep (1.5" optimal). Sprigs should be planted quickly after digging and not allowed to dry in sun and
wind. For Coastal and Tifton 78 plant at least 10 bu/ac in 3' rows, spaced 2' to 3' in the row. Generally a
rate of 30 bu/ac is satisfactory to produce full groundcover in one or two years under good growing
conditions. Tifton 44 spreads slowly, so use at least 40 bu/ac in 1.5' to 2' rows spaced 1' to 1.5' in row.
For broadcast/disked-in sprigs use about 60 bu/ac. Soil test for the amounts of lime, phosphorus,
potassium and micronutrients to apply preplant and for annual maintenance. Apply 60 to 100 lb/ac N in
the establishment year in split applications in April and July. For established stands apply 180 to 240
lb/ac N annually in split applications, usually in April and following the first and second hay cuts.
Reduce N rates by 25% for grazing. Refer to NCSU Technical Bulletin 305 Production and Utilization of
Pastures and Forages in North Carolina for more information or consult your regional agronomist or
extension agent for assistance.
694920 Database Version 1.06 Date Printed: 11-07-2001 Crop Note Page 2

Swine Farm Waste Management Odor Control Checklist
Source.
Farmstead
Cause
• Swine production
MIN to 11I1nImizc Odor
71 Vegetative or wooded buffers;
Cl'Recommended best management practices;
0/Good judgment and common sense
Animal body surfaces
Floor surfaces
• Dirty manure -covered animals)ry floors
• Wet manure. -covered flours
Site Specific Practices
[ S i ed floors;
rYWuterers located over slotted floors;
C1 -free ers at high end of solid floors;
frape manure buildup Irani floors;
I - Cliidcrfloor ventilation for drying
Manure collection pits
• Urine;
• Partial microbial decomposition
requenl manure removal by flush, pit recharge,
or scrape;
13/Underfloor ventilation
Ventilation exhaust Eons • Volatile gases;
Dust
I71--"I an maintenance;
[f if icicnl air movement
Indoor surfaces
• Dust
CI-"Washdown between groups of animals;
El Feed additives;
0 Feeder covers;
Lh/1 cd delivery dotvnspnul extenders to feeler
seue-rs. •
Flush tanks
• Agitation of recycled lagoon
liquid while tanks are tilling
Cl Flush tank covers;
CI Extend fill lines 1d near bottom nflanks with
anti -siphon vents
Flush alleys
Pit leclwrgc points
• Agitation during wastewater
conveyance.
EL -Underfloor flush with underfloor ventilation
• Agitation of recycled lagoon
liquid while pits are filling
Cl Extend recharge lines to near hollow of pits
with anti -siphon vents
Lill stilli1111S
• Agitation during sump tuck
filling and drawdowu
tlulsidc drain cullcc1iui
• Agitation during wastewater
or junction boxes N R.„„ conveyance
CI Suup tuck covers
Cl ❑ox covers
AlvlC)C; - November I I, 1996, Page

N v•
Source Cause
End of drainpipes at
lagoon
• Agitation during wastewater
conveyance
Lagoon surfaces
• Volatile gas emissions;
• Biological mixing;
• Agitation
Irrigation sprinkler
nozzles
Sturaget;nrk or basin
surface
Ail
HMI's 10 Minimize Odor
CI'I:xlcud discharge point of pipes underneath
Zia -goon liquid level
CI Proper lagoon liquid capacity;
ce
orrcct lagoon startup procedures;
airnum surface area -to -volume ratio;
Minimum agitation wltcn.pumping;
❑ Mechanical aeration;
O Proven biological additives
• Iligh pressure agitation;
• Wind drift
• Partial microbial decomposition;
• Mixing while filling;
• Agitation when emptying
Settling basin surface
Iv1anure, slurry or sludge
spreader outlets
• Partial microbial decomposition;
• Mixing while filling;
• Agitation when emptying
❑' Irrigate on dry days with little or no wind;
li�Minimum recommended operating pressure;
1 --1 ump intake near lagoon liquid surface;
❑ Pump from second -stage lagoon
❑ llottow or midlevel loading;
❑ Tank covers;
❑ Basin surface mats of solids;
Cl Proven biological additives or oxidants
"
Site Specific Practices
CI Extend drainpipe outlets underneath liquid
level;
❑ Remove settled solids regularly
• Agiiatiou when spreading;
• Volatile gas emissions
Uncovered manure,•
slurry or sludge on field
surfaces
• Volatile gas emissions while
drying
Cl Soil injection ofslurry/sludges;
0 Wash.residual manure from spreader after use;
Proven biological additives or oxidants
O Suit injection ofslury/sludges
❑ Soil incorporation within 48 hrs.;
El Spread in thin uniform layers fur rapid drying;
❑ Proven biological additives or oxidants
Dead animals
• Carcass decomposition
aLZFroper disposition of carcasses
Dead animal disposal r •
pits (f
incinerators
Carcass decomposition
Incomplete combustion
❑ Complete covering of carcasses in burial pits;
❑ Proper location/construction of disposal pits
Cl Secondary stack burners
AIvMC)C - November 11, 1996, Page 4

Mortality Management Methods
(check which method(s) are being. implemented)
�I Burial three feet beneath the surface of the around within 24 hours after
knowledge of the death. The burial must be at least 300 feet from any flowing
stream or public body of water.
Rzndering. at a rendering plant licensed under G.S. 106-168.7
O Complete incineration
O In the case of dead poultry only, piacing in a disposal pit of a size and' design
approved by the Department of Agriculture
O Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endangering
human or animal health. (Written approval of the State. Veterinarian must be
attached)
Insect Control Checklist for Animal Operations
Source
I11141's Co Control Insects Site Specific Practices
Flush Gutters
• Accumulation ofsolids
Liquid Systems
t3• Flush system is designed and operated
sufficiently to remove accumulated solids from
mutters as designed.
E Remove bridging of accumulated solids at
discharge
Lagoons and Pits • Crusted Solids
t3- 11 iintain lagoons, settling basins and flits where
pest breeding is apparent to minimize the
crusting of solids to a depth of no more than 6 -
8 inches over more than 30% of surface.
Excessive Vegetative
Growth
• 1)ccuying vegetation
IYPninlain vegetative control along banks of
lagoons and other impoundments to Prevent
accumulation of decaying vegetative matter
;long water's edge on impoundment's perinieter,

Updated Crop Management Practices for Bermuda Winter Overseed
This document, as approved by the Interagency Nutrient Management Committee on
October 10, 2017, hereby modified the July 13, 1998 Memorandum "Crop Management
Practices for Select Forages Used in Waste Management". This modification updates
the application window protocol for the 100 lb Nitrogen PAN rate for both Cereal Rye
and Annual Ryegrass, as well as winter small grains.
• Farms utilizing the 100 lbs./ac PAN rate for the overseed are allowed to apply no
more than 50 lbs./ac PAN from October 1 through December 31 and no more than
50 lbs./ac PAN from January 1 through March 31.
• Applications made during the months of December and January cannot exceed the
combined total of 25 lbs./ac PAN for the two -month period.
• The last application of animal waste is to be applied to the bermuda crop prior to
September 30.
• The PAN rate for grazed systems must be reduced by 25%.
All other requirements of the July 13, 1998 Memorandum continue to apply. Those
requirements include but are not limited to:
• Cereal rye and annual ryegrass should be planted by October 15 to provide the best
opportunity to get winter growth.
• A harvest is required prior to heading or April 7, whichever comes first, for both
cereal rye and annual ryegrass. This is necessary to minimize the potential for
shading of emerging bermuda and reducing its yield. To favor the production of
bermuda, additional harvest of annual ryegrass will be required when the ryegrass
canopy reaches 12-15 inches height.
•
These management requirements shall also apply to overseeded winter small grain.
Nov 16, 2017

Go gle Maps
—1--boskd Hickovt
Imagery ©2019 Google, Map data ©2019 Google 200 ft

EMERGENCY ACTION PLAN
PHONE NUMBERS •
DWQ 910-486-1541
EMERGENCY MANAGEMENT SYSTEM 911
SWCD 910-862-6936
NRCS 9,10-862-6936
i •
This plan will be implemented in the event that wastes from
your operation are leaking, overflowing, or running off
site.- You should not wait until wastes reach surface waters
or leave your property to consider that you have a problem.
You should make every effort to ensure that this does not
happen. This plan should be posted in an accessible
location for all employees at the facility. The following
are some action items you should take.
1. Stop the release of wastes.1 Depending on the
situation, this may or may not be possible. Suggested
responses to some possible problems are listed below.
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B: Runoff from waste application field -actions
include: •
a. Immediately stop waste application.
b. Create.a temporary diversion to contaih waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that
caused the runoff.'
e. Evaluate the application rates, for the fields
where runoff occurred.
Leakage from the waste pipes and sprinklers -action
include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate; further; discharge.

D:
d.
Repair all leaks prior to restarting pumps.
Leakage from flush systems, houses, solid
separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure no siphon occurs.
d. Stop all flows in the.house, flush systems, or
solid separators.
e. Repair all leaks prior to restarting pumps.
E: Leakage from base or sidewall of lagoon. Often
this is seepage as opposed to flowing leaks -
possible action:
a. Dig a small well or ditch to catch all seepage,
put in a submersible pump, and pump back to
lagoon.
b. If holes are caused by burrowing
or remove animals and fill holes
with a clay type soil.
c. Have a professional evaluate the
the side walls and lagoon bottom
possible.
animals, trap
and compact
condition of
as soon as
2. Assess the extent of the spill and note any.obVious
damages.
i
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what
duration?
c. Any damage noted, such as employee injury, fish
kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface
waters?
f. Could a future rain
surface waters?'
Are potable water wells
of the property)?
h. How much reached surface; waters?
g-
event cause the spill to reach
in danger (either on or off
3: Contact appropriate agencies.
a. During normal business hours, call your DWQ
(Division of Water Quality) regional office;' Phone.
910-486-1541• After hours, emergency number: 919-
733-3942. Your1phone call should include: your
name, facility, telephone number, the ;;details of
• i

the incident from item2'above,'the exact locati.Qri
of:the facility; the location or direction of
movement of the spill, weather and wind conditions:
The corrective measurt,s_that have been under taken,
and the seriousness of the situation'.
b. If spill leaves property or enters surface waters,
call local EMS Phone number •911..
c. Instruct EMS to contact local Health Department..
d. Contact CES, phone number 910-862-4591, local SWCD
office phone number 91Q-8.62-6936, and local NRCS
office for advice%technical assistance phone number
910-862-6936_
4: If none of the above works call 911 or the Sheriff's
Department and explain your problem to them and ask
that person to contact the proper agencies for you.
•
5: Contact the contractor of your choice to begin repair
of problem to minimize off -site damage.
a. Contractors Name:
b. Contractors Address:
c. Contractors Phone:
6: Contact the technical specialist who certified the
lagoon (NRCS, Consulting Engineei., etc.)
a. Name:
.b. Phone:
7: Implement procedures as advised by DWQ and technical
assistance agencies to rectify the damage, repair the
system, and reassess the waste management plan to keep
problems with release of wastes from happening again.'
claude/neah/word/em pae tplen.dcx
aept 12,96
1

Version —November 26, 2018
Mc rtaiity Management et ds
1 Indicate which method(s) will be implemented;
S Cn When selecting multiple methods indicate a primary versus secondary option.
t� 1 Methods other than those listed must be approved by the State Veterinarian.
i COT
Primary SecondAry Routine Mortality
RECr= VSDINCDta!Dwa
52.019
Regional:section
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location map and plan.
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
Rendering at a rendering plant licensed under G.S. 106-168.7.
Complete incineration according to 02 NCAC 52C .0102.
A composting system approved and permitted by the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
Any method which, in the professional opinion of the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
3-2o-/
Signature of Farm Owner/Manager Date
6rIV OVA67/1
Snature of Technical5 Specialist g p Date

perator:CHARLENE GOODEN County: BLADEN
istance to nearest residence (other
AVERAGE LIVE WEIGHT (ALW)
0 sows (farrow to finish)
O sow, (farrow to feeder)
O head (finishing only)
0 sows (farrow to wean)
2600 head (wean to feeder)
Describe other :
than owner):.
x 1417 lbs.
x 522 lbs.
x 135 lbs.
x 433 lbs.
x 30 lbs.
Date:
1-7c15-
1 we5 � vkicicc
10/21/94
0.0 feet
Total Average Live Weight =
MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume 78000 lbs. ALLJJ x Treatment Volume(CF)/lb. ALW
Treatment Volume(CF)/1b. ALW = 1 CF/lb. ALW
Volume = 78000 cubic feet
STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 39000.0 cubic feet
TOTAL DESIGNED VOLUME
Inside top length (feet)
Inside top width (feet) —
Top of dike elevation (feet)
Bottom of lagoon elevation (feet)
Freeboard (feet)
Side slopes (inside lagoon) --
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH
3.0 3.0 3.0 3.0 194.0
AREA OF TOP
LENGTH * WIDTH =
194.0 134.0
AREA OF BOTTOM
LENGTH * WIDTH =
125.0 65.0
AREA OF MIDSECTION
LENGTH * WIDTH * 4
159.5 99.5
200.0
140.0
101.0
88.5
1.0
3.0 . 1
O lbs
O lbs
0 lbs
0 lbs
78000 lbs
0
78000 lbs
RECEIVED/NCDEQ, ,
VVR
MAR 2 5 2019
Water quality
Regional Operations Section
WIDTH DEPTH
134.0 11.5
25996 (AREA OF TOP)
8125 (AREA OF BOTTOM)
63481 (AREA OF MIDSECTION * 4)
CU. FT. = [AREA TOP -+- (4*AREA MIDSECTION) -1- AREA BOTTOM] *
25996.0 63481.0 8125.0
DEPTH/6
1.9

. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
200.0 140.0 28000.0 square feet
Buildings (roof and lot water)
0.0 square feet
TOTAL DA 28000.0 square feet
Design temporary storage period to be 180 days.
1. Volume of waste produced
Feces & urine production in gal./day per 135 lb. ALW 1.37
Describe this area.
Volume = 78000 lbs. ALW/135 lbs. ALW * 1.37 gal/day 180 days
Volume = 142480 gals. or 19048.1 cubic feet
3. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water- used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in SA.
Volume =
0.0 gallons/day * 180 days storage/7.48 gallons
per CF
Volume = 0.0 cubic feet
Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall
Volume = 7.0 in * DA / 12 inches per foot
Volume = 16333.3 cubic feet
7.0 inches

D. Volume of 25 year — 24 hour storm
Volume =
Volume =
7.0 inches / 12 inches per foot * DA
16333.3 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
. SUMMARY
5A..
58.
5C.
5D.
19048 cubic feet
0 cubic feet
16333 cubic feet
16333 cubic feet
TOTAL 51715 cubic feet
Temporary storage period )
Rainfall in excess of evaporation
25 year — 24 hour rainfall
Freeboard
Side slopes
)
Inside top length
Inside top width >
Top of dike elevation -----
Bottom of lagoon elevation
Total required volume
Actual design volume
Seasonalhigh watertable elevation
Stop pumping elev. )
Must be > or = to the SHWT elev.-----•)
Must be > or = to min. req. treatment el.=)
Required minimum treatment volume > 117000
Volume at stop pumping elevation > 128043
> 99.3
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume less 25 yr.— 24 hr. rainfall=-)
Volume at start pumping elevation)
Required volume to be
Actual volume planned to be pumped)
Min. thickness of soil liner when required==).
Start pumping elev.
-)
)
)
(SHWT)===>
. DESIGNED BY:
DA
2/q G-7
APPROVED BY
DATE: 41ii
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
180
7.0
7.0
1.0
3.0
200.0
140.0
101.0
88.5
168715
187071
95.0
97.5
95.0
94.5
170737
169351
35381
41308
1.8
days
inches.- a _ 5+Ca
inches j--
feet _r
: 1
feet
feet
feet
feet
cu. ft.
cu. ft. *
feet
feet *
feet
feet
cu. ft.
cu. ft.
feet *
cu.
cu.
cu.
cu.
feet
ft.
ft.
ft.
ft.
*
*
1Ce
qq
13
IOI-o
94.5
1.1
COMMENTS:

SHEET..-1-:OF 2
OPERATION AND MAINTENANCE PLAN
This lagoon is designed for waste treatment (permanent storage) and
180 'days .of_temporary storage. The time required for the planned
.uid-r-level (permanent and ;temporary storage) to be reached may vary
uite conditions: weather, flushing operations, and the amount
resh :water;:added to the system
The designed temporary storage consists of 180 days storage for:
(1) waste from animals and (2) excess rainfall after evaporation. Also
included is storage for the 25 year - 24 hour storm for the location.
The volume of waste generated from a given number of animals will be
fairly constant throughout the year and from year to year, but excess
rainfall will vary from year to year. The 25 year rainfall will not
be a factor to consider in an annual pumping cycle, but this storage
volume must always be available.
A maximum elevation is determined in each design to begin
pumping and this is usually the outlet invert of pipe(s) from
building(s). If the outlet pipe is nod, installed at the elevation to
begin pumping, a permanent marker must be installed at this elevation
to indicate when pumping should begin. An elevation must be established
to stop pumping to maintain lagoon treatment depth.
Pumping can be started or stopped at any time between these two
elevations for operating convenience as site conditions permit, such as
weather, soils, crop, and equipment in order to apply waste without
runoff or leaching.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent damage to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre -
charged to 1/2 its capacity to, prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times. When precharging is complete,
flush buildings with recycled lagoon liquid. Fresh water should not
be used for flushing after initial filling.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see attachment)
before land application.
3. Begin temporary storage pump -out of the lagoon when fluid level
reaches the elevation 100.7 as marked by permanent marker. Stop pump -
out when the fluid level reaches elevation 98.7 . This temporary
storage, less 25 yr- 24 hr storm, contains 31848 cubic feet or
238222 gallons.