090132_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2019.
Please do not leave any question unanswered. Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Farm Number: 09-0132 Certificate Of Coverage Number: AWS090132
2. Facility Name: Terra Nova
3. Landowner's Name (same as on the Waste Management Plan): Willie L Beard
4. Landowner's Mailing Address: 3281 Rosindale Rd
City: Clarkton State: NC Zip: 28433
Telephone Number: 910-520-3749 Ext. E-mail:
5. Facility's Physical Address: 580 Rosindale Rd
City: Clarkton State: NC Zip: 28433
6. County where Facility is located: Bladen
7. Farm Manager's Name (if different from Landowner):
8. Farm Manager's telephone number (include area code):
9. Integrator's Name (if there is not an Integrator, write "None"): Murphy -Brown LLC
10. Operator Name (OIC): Willie L. Beard Phone No.: 910-520-3749 OIC #: 16271
11. Lessee's Name (if there is not a Lessee, write "None"):
12. Indicate animal operation type and number:
Current Permit: Operations Type Allowable Count
Swine - Feeder to Finish 3,672
Operation Types:
Swine Cattle Dry Poultry Other Types
Wean to Finish Dairy Calf Non Laying Chickens Horses - Horses
Wean to Feeder Dairy Heifer Laying Chickens Horses - Other
Farrow to Finish Milk Cow Pullets Sheep - Sheep
Feeder to Finish Dry Cow Turkeys . Sheep - Other
Farrow to Wean Beef Stocker Calf Turkey Pullet
Farrow to Feeder Beef Feeder
Boar/Stud Beef Broad Cow Wet Poultry
Gilts Other Non Laying Pullet
Other Layers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(Inches)
1
7j28142
(I:.:!
�(Cuubic
Li7f(ta3
-7)too
19.00
1
I9.00
2
q ju/e 4
('_iti-
ZQtia�)1 7
14,,;2D
19.00
I
V
6.4390,7
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d) to the address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan (WUP) signed bs the owner and a certified technical specialistcontaining:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal.
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: [e-mail]

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation, signature should be byi,a principal executive officer of the corporation):
Name: J C) r��i3r JQV J4 9V 1 I 1 t P Title: �W
}}f�
Signature: IN1-' 1- 1 Date: 3 ,as 19
Name: Title:
Signature: Date:
Name: Title:
Signature: Date:
THE COMPLETED APPLICATION SHOULD BE SENT.TO.THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
E-mail: [e-mail]
FORM: RENEWAL -STATE GENERAL 02/2019

ROY COOPER
Gaaernot
MICHAEL S. REGAN
Secretary
L1NDA CULPEPPER
Oirettor
NORTH CAROLINA
Envfronntentaf Quality
February 27, 2019
Willie L Beard
Terra Nova
3281 Rosindale Rd
Clarkton, NC 28433
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
APR 0' 12019
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at https://den.nc.gov/about/divisions/water-resources/water-qualit'-rezional-operations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure ►our continued coverage under the State Non -Discharge General Permits. you must submit an application for
permit coverage to the Division. Enclosed you will find a "Reouest for Certificate of Coverage Facility Currently Covered b■ an
Expiring State Non -Discharge General Permit." The application form must be completed, siened and returned by April 3, 2019.
Please note that you must include one i11 con of the Certified Animal Waste Management Plan (CAWMP) with the
completed and siened application form. A list of items included in the CAWMP can be found on page 2 of the renewal
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Enclosures
cc (w/o enclosures):
Sincerely,
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Fay etteville Regional Office, Water Quality Regional Operations Section
Bladen County Soil and Water Conservation District
AFOG Section Central Files - AWS090132
Murph' -Brown LLC
North. Caro ra Depa trnert of Env roarrenta qua ty I D-vs or of Water Resorraes
0.41• 512 N. Ss abury St. 11e'3e Na Sery as Cents, I Ra ash, North Caro, -pa 2789E-1S3S
919.737.9MC

WASTE UTILIZATION PLAN
PRODUCER: Terrallova
LOCATION: 3281 Rosindale Rd.
Clarkton, NC 28433
TELEPHONE: [phone]
TYPE OPERATION: Feeder - Finish
NUMBER OF ANIMALS: 3672
(Design Capacity)
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface and/or groundwater. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops in the fields where the waste is
to be applied. This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle. Annual soil tests are strongly encouraged so that all
plant nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and available water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special precautions, waste may be
applied to land eroding at up to 10 tons per year. Do not apply waste on saturated soils, when it
is raining, or when the surface is frozen. Either of these conditions may result in runoff to
surface waters which is not allowed under DEM regulations. Wind conditions should also be
considered to avoid drift and downwind odor problems. To maximize the value of nutrients for
crop production and to reduce the potential for pollution, the waste should be applied to a
growing crop or applied to bare ground not more than 30 days prior to planting. Injecting the
waste or disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H.0217 adopted by the Environmental Management Commission.
Page 1

...... ....
WASTE UTILIZATION PLAN
Amount of Waste Produced Per Year (gallons. ft. tons. etc.)
3,672 animals X 1,2
(tons) waste/animal/year = 6,977 (tons) waste/year.
Amount of Plant Available Nitrogen (PAN) Produced Per Year
3,672 animals X 2.3 lbs. PAN/animal/year = 8,446 lbs. PAN/year. (PAN from N.C.
Guide Std. 633) Tech
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner
The following acreage will be needed for waste application based on the crop to be grown and
surface application:
Tract Field* Soil
# No. Type
T8197
T8197
T8197
T8197
1
1
2
2
ExA
ExA
ExA/AyB
ExA/AyB
Table 1: ACRES OWNED BY PRODUCER
Crop Lbs. N Acres Lbs. N Month of
Per Acre Utilized Application
Bermuda(G)
Matua(G)
Bermuda(G)
Matua(G)
Total
275
155
270
150
14.61
14.61
5.25
5.25
4018.85
2264.55
1417.5
787.5
April - Sept.
Oct. - March
April - Sept.
Oct. - March
19.86
8,488.40
*This N is from animal waste only. If nutrients from other sources such as commercial fertilizer are
applied, they must be accounted for. LV must be based on realistic yield expectation.
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirements. Beginning in 1996 the Coastal Zone Management Act will require farmers in some
eastern counties of North Caroline to have a nutrient management plan that addresses all nutrients.
This plan only addresses Nitrogen.
Page 2

-WASTE1JTILI14TION .PLAN.
Table 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner must be attached)
(Required only if operator does not own adequate land [see
Required Specification 2])
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Type Per Acre* Utilized Application
* See footnote for Table 1.
Total
Totals from above Tables
Acres
Lbs. N
Utilized
Table 1 19.86
Table 2 0.00
Total 19.86
Amount of N Produced
Surplus or Deficit
8,488
8,488
8,446
(43)
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to prevent over
application of nutrient or other elements.
Page 3

WASTE UTILIZATION PLAN
See attached map showing the fields to be used for the utilization of waste water.
Application of Waste by Irrigation
Crop
Field
No.
Soil Type
Application
Rate (In/Hr.
Application
Amount (In.
1
ExA
Bermuda
0.35
0.75
2
ExA/AyB
Bermuda
THIS TABLE IS NOT NEEDED IF WASTE IS NOT BEING APPLIED BY IRRIGATION, HOWEVER A SIMILAR TABLE
WILL BE NEEDED FOR DRY LITTER OR SLURRY.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every E MONTHS. In no instance should the volume of
waste being stored in your structure exceed Elevation *see lagoon des'grl.
Call the local Natural Resources Conservation Service (formerly Soil Conservation Service) or Soil
and Water Conservation District office after you receive the waste analysis report for assistance in
determining the amount per acre to apply and the proper application rate prior to applying the
waste.
Narrative of operation:
Acres shown are 'wetted' acres of fields shown. For matua overseeded into bermuda, the
management guidelines supplied should be followed by the grower. All land may be grazed.
Page 4

. WASTE UTILIZATION:: PLAN ,
REQUIRED SPECIFICATIONS
1 Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of waste, he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
4 Animal waste shall be applied to land eroding Tess than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre per
year providing grass filter strips are installed where runoff leaves the field. (See FOTG
Standard 393 - Filter Strip).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6 When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor or flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
Page 5

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and from any perennial stream or river (other than an irrigation ditch or canal. Animal
waste other than swine waste from facilities sited on or after October 1, 1995), shall not be
applied closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips).
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist".
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that courses no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
Page 6

WASTE UTILIZATIONPLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, Teaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications animal waste
during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
23
Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 7

Date: 9_ /S -O
Date:
Kraig A. Westerbeek
WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: Terrallova Farm
Owner / Manager Agreement
I (we) understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a new
certification to be submitted to the Division of Environment Management (DEM) before the
new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface waters of the state from a storm event less
severe than the 25-year, 24-hour storm. The approved plan will be filed on -site at the farm
office and at the office of the local Soil and Water Conservation District and will be
available for review by DEM upon request.
Name of Facility Owner: Willie Beard
(Please print)
Signature: ki dies .c)
Name of Manager (If different from owner):
Signature:
Name of Technical Specialist: (Please print)
Affiliation: Murphy Family Farms
Address (Agency): P.O. Box 759
Rose H'i,NC2: 58
Signature: Date: -IOA
Page 8

Go gle Maps 1194 Rosindale Rd
- e'wc1 vc(.
Imagery ©2019 Google, Map data ©2019 Google 200 ft

EMERGENCY ACTION PLAfsj
PHONE NUMBERS
DW
EMERGENCY MANAGEMENT SYSTEM 4I
SWCD 910-862-693611
NRCS 910-8622-6936
This plan will be
your plan w on are implemented in the event that
site. You should leaking, overflowing,in off from
ot wait until wastereach
surfaceg
or leave your Property toreach waters
You should make ever Y o consider that
happen. This y effort to ensure you have a problem.•
happe lan should be osted that this does
ion for all em in an accessible
not_
are some action 1° ees at the facilit ssible
items you should take. The following
1.
Stop the release of wastes. situation, this may or ma situ
to some y not be possible.Dependingon Suggested
problems are listed below.
A. Lagoon overflow -
possible solutions are:
a. Add soil to berm to
Addwastes btincrease elevation of
b.- Pumpop was flows fields at an acceptable dam.
Call a the lagoon immediately.
d. pumping contractor.
Make sure no surface water is entering lagoon.
g on.
B: Runoff from waste application field -actions
include:
a. Immediately stop waste a
b. Create a temporary dzvppl2cation.
c. Incorporate wastetoersion to contain waste.
d. Evaluate and eliminate educe
runoff.
caused the runoff, reason(s) that
e. Evaluate the application rates for the fie
where runoff occurred. Ids
C: Leakage from the waste pipes and sprinkle -
include:
sprinklers -action
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further dischar e.
5

2.
air all leaks prior to restarting pumps.
d. Re p
D; Leakage from flush systems, houses, solid
separators -action include:
a. Stop recycle pumpump.
b. Stop irrigation hon occurs.
d.c. Stop
sure no sip or
in the house, flush systems,
p all flows um s.
solid separators• rior to restarting pump
e. Repair all leaks P
E; Leakage
or sidewalof lagoon. often
this is seepage as opposedl
base flowing leaks -
possible action: to catch all seepage,
p
a. Dig
a small well or ditch and pump back to
put in a submersible pum trap
animals an
lagoon.
b burrowing animals,
If holes are caused byfill holes and compact
or remove with a clay type soil.evaluate the condition o
rof essiandllagoon soon as
f
c. Havea professional
walls bottom as
theheside w
possible.
Assess the extent of
damages.
a
each any surface waters?
b. D.
the waste r how much was released and for
b. Approximately injury,
duration'
e noted, such as employee
c. Any dam or property damage?
killsDithe
, spill leave the property?
d.
e. Does the spill have the potential to
waters?
f. Could a future rain
surface waterse '• wells
g• Arotable water
ofhe property)?
h.
How much reached surface waters?
the spill and note any obvious
what
fish
reach surface
event cause the spill to reach
in danger (either on or off
o riate agencies.
3: contact aPPr p call your DWQ Phone
normal business hours, call y office; g19-
a. During . Water Quality) aloffice;
(Division of After hours, emergency
910-486-1541• hone call should include:
lu e: yourf
name, 42. Your P number,
name, facility, telephone

the incident from item 2 above, the exact location
of the facility, the location or direction of
movement of the spill, weather and wind conditions.
The corrective treasures that have been under taken,
and the seriousness of the situation.
b. If spill leaves property or enters surface waters,
call local EMS Phone number •911-.
c. Instruct EMS to contact local Health Department.
d. Contact CES, phone number 910-862-4591, local SWCD
office phone number 920-862-6936, and local NRCS
office for advice/technical assistance phone number
910-862-6936_
4: If none of the above works call 911 or the Sheriff's
Department and explain your problem to them and ask
that person to contact the proper agencies for you.
5: Contact the contractor of your choice to begin repair
of problem to minimize off-site
damage.
a. Contractors Name: Did' J. -cICSo V))
b. Contractors Address: r-u-- ) Lox' 3 a 1
c. Contractors Phone: G,-d..,51,„"0001 J }F}, c. -9 /0— 69ci—
6: Contact the technical specialist who certified the
lagoon (NRCS, Consulting Engineer, etc.)
-
a . Name: (5- Pi (iJ 9-rr e &)
b. Phone: Cfi 6 — - L cl3 Lo
7: Implement procedures as advised by DWQ and technical
assistance agencies to rectify the damage, repair the
system, and reassess the waste management plan to keep
problems with release of wastes from happening again.
c audelnash/wordlempactplen.dc:
sot 12.96

c as f.Y 0cc.AS'�v ..' ... •: � : .. ..,_ ;...
• ii:1'A\v'C�}11.. :.. -,..x a�.c ,•"or.:nSWwvc.Aw.�Y,..;:a h:..xLSac.i?a...ntsa. E..�:.,ca.. aowawb�aar
This plan will be implemented in the event that animal manure or lagoon effluent from your
operation is leaking, overflowing, or running off the site:
Step (1) Stop the release or flow of manure/effluent.
Step (2) Assess the extent of the spill and note any obvious -damages.
Step (3) Contact appropriate personnel and agencies.
Murphy Family Farms: 800-311-9458 or 910-289-6439 (See Land & Nutrient Management
phone list attached)
Department of Environmental Management (DEM) Regional Office:
cr/ - FG - )v1+1
DEM after hours emergency: 919-733-3942
Local Emergency Management System: / / 1
Local Natural Resource Conservation Service: 9 0 -" a Ce a- —
(0 3
(Qa--- - 5 9 I
Local Cooperative Extension Service: I Q ..
Local Soil and Water Conservation District:
9) a- S'4 a-- 6 9 3 6
Local dirt-moving/heavy equipment companies:
Name
1. , /Z., roc,- c. (C. so ?N1
2. r 11 ,t:e,11Lh
3. G—r c t
Local contract pumping/urigation equipment companies:
Name Phone #
1. E-1,75-(_c.)..ro f)=5r; SS-1-erg 9/a- a93 (200
3_ Joh»T•-‘nclr-)1 •.c71.0 -(5 ,&7 `0,5
Step (4) Implement procedures as advised by MFF, DEM, and technical assistance
agencies to rectify the damage, repair the system, and reassess the nutrient
management plan to prevent future problems.
Phone #
9(0- 62,9'
9 o- 8"6 -393S
q 0 -- -s (1-- VS
Note 1: See MFF Environmental Emergency Procedures Flowchart attached
Note 2: See pages 89-91 of the Certification Training Manual for more details.

Flush Clutters • Accumulation of solids
Lagoons ;and fits • Crusted Solids
-Excessive Vegetative • Decoying vegetation
(iromit
Mortality Management Methods
(check which method(s) are being. implemented)
'J Burial three feet beneath the surface of the ground within 24 hours after
knowledge of the death. The burial must be at. least 300 feet from any flowing.
_stream or public body of water.
�Y Rendering at a rendering plant licensed under G.S. 106-163.7
❑ Complete incineration
In the case of dead poultry only, piacine in a disposal pit of a size and desi;n
approved by the Department of Agriculture
Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian must be
attached)
J
Insect Control Checklist for Animal Operations
Source cnusc IIA11's lu Coulrol Llsecls Sitc Sl,ceiGc l'racliccs
Liquid Systems —"
C?'Flush system is designed and operated
sufficiently to remove accumulated solids from
Antlers as designed.
£Y. Remove bridging of accumulated solids at
discharge
CLACiaintain lagoons, settling basins and piis wlicrc
pest breeding is apparent to minimize the
crusting of solids to a depth of no more than 6 -
8 inches over more than 30% of surface.
11..-- itintain vegetative control along banks of
lagoons and other impoundments to Prevent
accumulation of decaying vegetative matter
along water's edge on impoundment's perinieler.

Swine Farm Waste Management Odor Control Checklist
Source Cause BMPs to Minimize Odor Site Specific Practices
Farmstead • Swine production Olegetative or wooded buffers
t —1 ecommended best management practices
Good judgment and common sense
Animal body
surfaces
• Dirty manure -covered O Dry floors
animals
Floor surfaces
• Wet manure -covered floors CTotted floors
O Waterers located over slotted floors
Z.-Feeders at high end of solid floors
0--Serape manure buildup from floors
O Underfloor ventilation for drying
Manure collection • Urine EP—Frequent manure removal by flush, pit recharge,
pits • Partial microbial or scrape
decomposition O Underfloor ventilation
Ventilation exhaust • Volatile gases
fans • Dust
0--Fan maintenance
O Efficient air movement
Indoor surfaces • Dust
—Washdown between groups of animals
O Feed additives
C7 Feeder covers
eed delivery downspout extenders to feeder
covers
Flush tanks
• Agitation of recycled lagoon Cl Flush tank covers
liquid while tanks are filling CYExtend fill lines to near bottom of tanks with
anti -siphon vents

Swine Farm Waste Management Odor Control Checklist
Source
Flush alleys
Pit recharge points
"(4
Lift stations
44
Cause
• Agitation during wastewater
conveyance
• Agitation of recycled lagoon
liquid while pits are filling
BMPs to Minimize Odor
O Underfloor flush with underfloor ventilation
Site Specific Practices
O Extend recharge lines to near bottom of pits with
anti -siphon vents
Outside drain
collection or 416.junction boxes
End of drainpipes
at lagoon
Lagoon surfaces
• Agitation during sump tank
filling and drawdown
O Sump tank covers
• Agitation during wastewater
conveyance
El Box covers
• Agitation during wastewater
conveyance
O Extend discharge point of pipes underneath
lagoon liquid level
• Volatile gas emissions
• Biological mixing
• Agitation
Irrigation sprinkler
nozzles
• High pressure agitation
• Wind drift
Doper lagoon liquid capacity
C Correct lagoon startup procedures
1p2ilinimum surface area -to -volume ratio
CLlvfinimum agitation when pumping
O Mechanical aeration
O Proven biological additives
CL-t r`igate on dry days with little or no wind
LIinimum recommended operating pressure
Ct1-I tnnp intake near lagoon liquid surface
O Pump from second -stage lagoon

Swine Farm Waste Management Odor Control Checklist
Source
Cause
Storage tank or
basin surface
�'�
Settling basin
surface
• Partial microbial
decomposition
• Mixing while filling
• Agitation when emptying
BMPs to Minimize Odor
Site Specific Practices
❑ Bottom or midlevel loading
❑ Tank covers
❑ Basin surface mats of solids
❑ Proven biological additives or oxidants
• Partial microbial
decomposition
• Mixing while filling
• Agitation when emptying
Manure, slurry, or
sludge spreader
outlets
Uncovered manure,
slurry, or sludge on
field surfaces
Dead animals
❑ Extend drainpipe outlets underneath liquid level
❑ Remove settled solids regularly
• Agitation when spreading
• Volatile gas emissions
El Soil injection of slurry/sludges
❑ Wash residual manure from spreader after use
O Proven biological additives or oxidants
• Volatile gas emissions while
drying
❑ Soil injection of slurry/sludges
O Soil incorporation within 48 hours
O Spread in thin uniform layers for rapid drying
O Proven biological additives or oxidants
• Carcass decomposition
IYY Proper disposition of carcasses
Dead animal
disposal pits
• Carcass decomposition
Incinerators N ( �' •
Standing water •
around facilities
O Complete covering of carcasses in burial pits
O Proper location/construction of disposal pits
Incomplete combustion
Improper drainage
El Secondary stack burners
• Microbial decomposition of
organic matter
fa --Grade and landscape such that water drains away
from facilities.

Swine Farm Waste Management Odor Control Checklist
Source
Cause BMPs to Minimize Odor
Manure tracked onto • Poorly maintained access
public roads from roads
farm access
{ arm access road maintenance
Site Specific Practices
Additional Information:
Available From:
Swine Manure Management; .0200 Rule/BMP Packet
Swine Production Farm Potential Odor Sources and Remedies; EBAE Fact Sheet
Swine Production Facility Manure Management: Pit Recharge —Lagoon Treatment; EBAE 128-88
Swine Production Facility Manure Management: Underfloor Flush —Lagoon Treatment; EBAE 129-88
Lagoon Design and Management for Livestock Manure Treatment and Storage; EBAE 103-83
Calibration of Manure and Wastewater Application Equipment; EBAE Fact Sheet
Controlling Odors from Swine Buildings; PII-1-33
Environmental Assurance Program; NPPC Manual
Options for Managing Odor; a report from the Swine Odor Task Force
Nuisance Concerns in Animal Manure Management: Odors and Flies; PRO107, 1995 Conference Proceedings
NCSU, County Extension Center
NCSU—BAG
NCSU—BAE
NCSU—BAE
NCSU—BAE
NCSU—BAE
NCSU—Swine Extension
N.C. Pork Producers Assoc.
NCSU Agricultural Communications
Florida Cooperative Extension

e (rr O v
9-132
Mortality Management Methods
indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
El El
El El
-71
as
00
El
Version —November 26, 2018
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location map and plan.
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
Rendering at a rendering plant licensed under G.S. 106-168.7.
Complete incineration according to 02 NCAC 52C .0102.
A composting system approved and permitted by the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
Any method which, in the professional opinion of the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
Signature of Farm Owner/Manager
60/V Signat re of Technical Specialist
Date
c icleci
Date

^
,�:��
| Te \� u�--. �V��
/erator:Bi||y Mc8avock County: BLADEN Date: 07/28/92
-
Distance to nearest residence (other than ownei): I200.0 feet
1
STEADY STATE LIVE WEIGHT
0 sows (farrow to finish) x 1417 |bs. = 0 1ns
O sOws (farrow to feeder) x 522 !bs. = 0 |bs
2448 head (finishing only) x 135 lbs. = 330480 ibs
0 sews (farrow to wean) x 433 /bs. = 0 /bs
0 nead (wean to feeder) x 30 lbs. = 0 ibs
TOTAL STEADY STATE LIVE WEIGHT (SSLN) = 330480 !'bs
2. NINIMUM REQUIRED TREATMENT VOLUME OF LAGOON.
Volume = 330480 !bs. SSLW x Trearment Vo|ume(CF)/|o, SSLN
Treatment Volume(CF)//b. SSLN= 1 CF//b. SSLW
Ve.ume = 330480 cubic feet
3. STORAGE VOLUmE FOR SLUDGE ACCUMULATION
Volume = 0.0 cubic feet
4. TOTAL DESIGN VOLUME
Inside top !endth 300.0 feet ; Inside top w/dtn 240.0 feet
Top of dike at elevation 48.0 feet
Freeboara 1.0 feet ; Side slopes 3.0 : 1 (inside lagoon)
Total design lagoon liquid level at elevation 47.0 feet
Bottom of lagoon elevation 38.0 feet
Seasonal high water table elevation 41.0 feet
Total design volume using prismoida! formula
SS/END1
3.0
SS/END2 SS/SIDE1 S8/SIDE2
3.0
3.0 3.0
LENGTH
294.0
WIDTH
234.0
AREA OF TOP
LENGTH * WIDTH =
294.0 234.0 68796.0 (AREA OF TOP)
AREA OF BOTTOM
LENGTH * WIDTH =
240.0 180.0 43200.0 (AREA OF BOTTOM)
DEPTH
9.0
AREA OF MIDSECTION
LENGTH * WIDTH * 4
267.0 207.0 221076.0 (AREA OF MIDSECTION * 4)
CU. FT. = [AREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM] * DEPTH/6
68796.0 221076.0 43200.0 1.
VOLUME OF LAGOON AT TOTAL DESIGN LIQUID LEVEL = 499608 CO. F7.

^
58.
TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
300.0 240.0
� ' ,_w
72000.0 square feet
Buildings (roof and lot water)
Len8th * Width =
0.0 0.0 0.0 square feet
TOTAL DA 72000.0 square feet
Design temporary storage period to be 180 days.
5A. Volume of waste proouced
Approximate daily production of manure in CF/L8 SSi-N 0.00136
Volume
o ume = 330480 Lss. SSLW * CF of Waste/Lb./Day * 180 days
Volume = 80705 cubic feet
Volume of wash water
This is the amount of fresh water useo for washing fioors or volume
of fresh water used for a flush system. Flush systems that rccircu\at
the lagoon water are accounted for in 5A.
Vo|ume =
Volume = 0.0 cubic feet
0.0 gallons/day * 180 days stora3e/(.48 gallons
per CF
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount
-�
, 180 days excess rainfall = T.O'inches
Vo|ume = 7.0 in * DA / 12 inches per foot r /%m
Volume = 42000.0 cubic feet

Volume of 25 year - 24 hour storm
Volume = 7.0 inches / 12 inches per foot * DA
Volume = 42000.0 cubic feet
TOTAL REQUIRED TPMPORARY STORA8E
5A. 80705 cubic feet
5B. 0 cubic feet
5C. 42000 cubic feet
5D. 42000 cubic feet
TOTAL 164705 cubic feet
6. SUMMARY
Total required voiume 495185 cubic feet
Total design volume avai |. cubic feet
Min. req. treatment volume plus s/udSe accumunnon 330480 cubic f
At elev. 44.5 feet ; Volume is
337331 cubic feet (end pumping)
Total design volume less 25yr-24hr storm is 45760S cubic feet
At elev. 46.3 feet ; Volume is 452223 cubic feet (start pumping
Seasonaj high water table e!evat/on 41.0 feet
7. DESIGNED BY: �=� ~W '' ^� APPROVED BY:
DATE: �_�3-q7_ DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN

Jperato�� E County: BLADEN Date: 09/16/94
Distinc'e to n/^rest residence (other than owner)
: 0.0 feet
I. AVERAGE LIVE WEIGHT (ALW)
0 sows (farrow to finish) x 1417 lbs = 0 lb
0 sows (farrow to feeder) x 522 lbs.
s
1224 head (finishing only) : 135 lbs.
= 0 lbs
0 sows (farrow to wean) x 433 lbs^ = 165240 lbs
0 head (wean to feeder).x 30 lbs,. = 0 lbs
Describe other : = 0 lbs
.................................... 0
____ _________________________ -------
Total Average Live Weight = 165240 lbs
Z. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 165240 lbs. ALW x Treatment Volume(CF)/lb ALW
Treatment Volume(CF)/lb. ALW = 1 CF/lb ^LW
Volume = 165240 cubic feet ^ �
1. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 cubic feet
4. TOTAL DESIGNED VOLUME
APR 012019
Inside top length (feet) ----- ..................... 365 0
---
Inside top width (feet) ------- ^
------------ 128.0
----
Top of dike elevation (feet) --- ^
---------- 51.3
Bottom of lagoon elevation (feet)------------ 41^3
Freeboard (feet)--------------__ ^
------------- 1 0
Side slopes (inside lagoon) ------------------ 3^0 : 1
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
3.0 NO 3.0 3.0 359.0 122.0 9.0
AREA OF TOP
LENGTH * WIDTH =
359.0 122.0
AREA OF BOTTOM
LENGTH * WIDTH =
305.0 68.0
AREA OF MIDSECTION
LENGTH * WIDTH * 4
332.0 95.0
/
43798 (AREA OF TOP)
20740 (AREA OF BOTTOM)
126160 (AREA OF MIDSECTION * 4)
CU. FT. = [AREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM]
43798.0 126160.0 20740.0
*
DEPTH/6
1.5
Total Designed Volume Avai1able = 286047 CU. F7'

TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
365.0 128.0 46720.0 square feet
Buildings (roof and lot water)
0.0 square feet Describe this area.
TOTAL DA 46720.0 square feet
Design temporary storage period to be 180 days.
Volume of waste produced
Feces & urine production in gal./day per 135 lb. ALW 1.37
Volume = 165240 lbs. ALW/135 lbs. ALW * 1.37 gal/day 180 days
Volume = 301838 gals. or 40352.7 cubic feet
Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume =
0.0 gallons/day * 180 days storage/7.48 gallons
per CF
Volume = 0.0 cubic feet'
Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall
Volume =
= 7'0 inches
��.
7.0 in * DA / 12 inches per foot := 410
Volume = 27253.3 cubic feet

5D. Volume of 25 year - 24 hour storm
Volume = 7.3 inches / 12 inches per foot * DA
Volume - 28421.3 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 40353 cubic feet
SB • 0 cubic feet
5C. 27253
cubic feet
5D. 28421 cubic feet
TOTAL. 96027 cubic feet
. SUMMARY
Temporary storage peri. od =•-•-'---------- -__:____::_-__ . 180 days
Rainfall in excess of evaporation============__'::. 7.0 inches
25 year - 24 hour rainfall ----•--•--__ _•_ = __=:__ ___''> -- -
inches
Fr-eehoard= _:__.•=====:= _:_-___-_:--_---•-_._:__= :_:_•_____-:•• ...
Side slopes.._.. - =--•-
1.0 feet
inside top length----- --=---•--•--===___--•---. 365.0 feet.
inside top width=====__-_ _:___:__=_________;___ _'_ ` 128. 0 feet
Top of dike e.leverti on==____ _____ =_.-.• _====•:> 51.3 feet
Bottom of lagoon elevation--------- -------- :.• 41.3 feet
Total required vo.l ume==-==========:__•=•=_ _:___=:-:'> 26:1267 cu. ft.
Actual design volume--------- ___._.-_._________-•. 286047 cu. ft.
Seasonal high water•tab l e elevation (SHWT) === 45.8 feet
Stop pumping el ev. =_-=-_ �--------•--•------- ____ _ __-•----':> 47.5 •feet
Must be > or = to the SHWT el ev. __--•- .__-=_> 45.8 feet
Must be ::> or = to min. req. treatment el . _:• 47.3 feet
Required minimum treatment volume=======___-_ > 165240 cu. ft.
Volume at stop pumping elevation=====____ __== :> 174462 cu. f t .
Start pumping elev.- -----.__.___.----__-•-. 49.5 feet. *
Must be at bottom of freeboard &. 25 yr. . -rainfall.
Actual .volume less 25 yr.- 24 hr. rainfall==> 257626 cu. ft.
Vol ume at start pumping elevation=======:__= == => 2_ ,
_.�19�6 cu. ft.
Required vol ume to be pumped =•____-----.-.-_=_ _=:> 67606 cu. f t .
Actual volume planned to be pumped--•-----___--.. 77464 cu. ft.
Min. thickness of soil liner when required== > 1.5 feet.
- DESIGNED BY:
DATE
APPROVED BY:
DATE: p514/14
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
COMMENT :
fir

rt
OPERATION AND MAINTENANCE PLAN
SHEET 1 OF 2
This lagoon is designed for waste treatment (permanent storage) and
180 days of temporary storage. The time required for the planned
fluid level (permanent and temporary storage) to be reached may vary
due to site conditions, weather, flushing operations, and the amount
of fresh water added to the system.
The designed temporary storage consists of 180 days storage for:
(1) waste from animals and (2) excess rainfall after evaporation. Also
included is storage for the 25 year - 24 hour storm for the location.
The volume of waste generated from a given number of animals will be
fairly constant throughout the year and from year to year, but excess
rainfall will vary from year to year. The 25 year rainfall will not
be a factor to consider in an annual pumping cycle, but this storage
volume must always be available.
A maximum elevation is determined in each design to begin
pumping and this is usually the outlet invert of pipe(s) from
building(s). If the outlet pipe is not installed at the elevation to
begin pumping, a permanent marker must be installed at this elevation
to indicate when pumping should begin. An elevation must be established
to stop pumping to maintain lagoon treatment depth.
Pumping can be started or stopped at any time between these two
elevations for operating convenience as site conditions permit, such as
weather, soils, crop, and equipment in order to apply waste without
runoff or leaching.
Land application of
method of disposal.
center pivot, guns,
taken when applying
waste water is recognized as an acceptable
Methods of application include solid set,
and traveling gun irrigation. Care should be
waste to prevent damage to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre -
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times. When precharging is complete,
flush buildings with recycled lagoon liquid. Fresh water should not
be used for flushing after initial filling.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see attachment)
before land application.
3. Begin temporary storage pump -out of the lagoon when fluid level
reaches the elevation 98.0 as marked by permanent marker. Stop pump -
out when the fluid level reaches elevation 95.6 . This temporary
storage, less 25 yr- 24 hr storm, contains 172100 cubic feet or
1287307 gallons.

SHEET 2 OF 2
4. The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0.3
inch per hour. Refer to the waste utilization plan for further details.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
8. Keep a minimum of 25 feet of grass vegetated buffer around
waste utilization fields adjacent to perennial streams. Waste will
not be applied in open ditches. Do not pump within 200 feet of a
residence or within 100 feet of a well. Waste shall be applied in a
manner not to reach other property and public right-of-ways.
9. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.