090101_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2019.
Please do not leave any ` question unanswered. Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Farm Number: 09-0101 Certificate Of Coverage Number: AWS090101
2. Facility Name: Fletcher McDuffie Farms
3. Landowner's Name (same as on the Waste Management Plan): Fletcher McDuffie
4. Landowner's Mailing Address: PO Box 261
City: Elizabethtown State: NC Zip: 28337-0261
Telephone Number: 910-876-0620 Ext. E-mail: fmcduffie a ec.rr.com
5. Facility's Physical Address: 2735 Sweet Home CH Rd
City: Elizabethtown State: NC Zip: 28337
6. County where Facility is located: Bladen
7. Farm Manager's Name (if different from Landowner):
8. Farm Manager's telephone number (include area code):
9. Integrator's Name (if there is not an Integrator, write "None"): Presta,_ e Farms Inc
10. Operator Name (OIC): Fletcher McDuffie Phone No.: 910-876-0620 OIC #: 16295
11. Lessee's Name (if there is not a Lessee, write 'None"):
12. Indicate animal operation type and number:
Current Permit:
Operation Types:
Operations Type
Swine - Feeder to Finish
Allowable Count
2,205
Swine Cattle Dry Poultry Other Types
Wean to Finish Dairy Calf Non Laying Chickens Horses - Horses
Wean to Feeder Dairy Heifer Laying Chickens Horses - Other
Farrow to Finish Milk Cow Pullets Sheep - Sheep
Feeder to Finish Dry Cow Turkeys Sheep - Other
Farrow to Wean Beef Stocker Calf Turkey Pullet
Farrow to Feeder Beef Feeder
Boar/Stud Beef Broad Cow Wet Poultry
Gilts Other Non Laying Pullet
Other Layers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
1
1
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(Inches)
3 - 2-13 c cLA-1 1f S 7, 8 ' 1 _ 118� Doc 19.00
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d) to the address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan (WUP), sieved by the owner and a certified technical sirecialistcontaining:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your subrnittal.
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: [e-mail]

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation, signature should be by a principal executive officer of the corporation):
Name:
L ate I{ R 15T3j r
Signature: /1711
Title:
Date:
Name: Title:
Signature: Date:
Name: Title:
Signature: Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
E-mail: [e-mail]
FORM: RENEWAL -STATE GENERAL 02/2019

ROY COOPER
Governor
MICHAEL S. REGAN
Secrrrary
LINDA CULPEPPER
Director
v�sv-cam
NORTH CAROLINA
Environmental Quality
February 27, 2019
Fletcher McDuffie
Fletcher McDuffie Farms
PO Box 261
Elizabethtown, NC 28337-0261
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
MAR 2 7 2019
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at https://dect.nc.aov/about/divisions/water-resources/water-quajity-regional-operations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure your continued coverage under the State Non -Discharge General Permits. you must _submit an application for
permit coverage to the Division. Enclosed you will find a "Request for Certificate of Coverage Facility Currently Covered b‘ an
Expiring State Non -Discharge General Permit." The application form must be completed. signed and returned by April 3. 2019.
Please note that F ou must include one i11 copy of the Certified Animal Waste Manaeement Plan (CAWMPI with the
completed and signed application form. A list of items included in the CAWMP can be found on page 2 of the renewal
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Enclosures
cc (w/o enclosures):
Sincerely,
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Fa% etteville Regional Office, Water Quality Regional Operations Section
Bladen County Soil and Water Conservation District
AFOG Section Central Files - AWS090101
Prestaae Farms Inc
Not!, Cam r a Dapsn.rr_ent of E � v arrr:erta Qua :_ j D s � , of Y• a er Reso.;,xs
�. 51.t.S t .rSt.1163reNa 3:voeC.e^terjRaa.gt !i rt%,Ca.,.^a27E"s�a-1ESS
.... .-.. ..\9
919.7C7 90DZ

Temporary Plan Waste Utilization Plan
Producer: Fletcher McDuffie
County: Bladen
Name of Farm: Fletcher McDuffie (Temporary Plan)
Location: P.O. Box 261
Elizabethtown NC 28337
Phone: [phone]
Type of Operation: Feed -Finish
2205
Number of Animal: anaerobic Lagoon
Storage Structure:
Method of Application: Irrigation.
4190 ton/year
Amount of waste produced per year: 19lbs./year
Amount of plant available N (PAN) produced/year:
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface water and/or groundwater. The plant nutrients in the animal waste
should be used to reduce the amount of commercial fertilizer required for the crops in the
fields where the waste is to be applied.
This waste utilization plan uses nitrogen as tests the
arlimiting
e strongly encouraged so that alle plantplantanalyzed
before each application cycle. Annual soil
nutrients can be balanced for realistic yields of the crop o be gr wnzation plan in to
Several factors are important in the implementing your in an in orderonmtotally
maximize the fertilizer value of the waste and to ensure that it is applied
safe manner.
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
'cation exchange capacities, and available water holding
to land eroding tmop
3. Normally waste shall not be appliede than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are
established. or when the surface is
4. Do not apply waste on saturated soils , when it is raining,
frozen. Either of these conditions may in runoff to the surface waters which is not
allowed under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor problems.
6. To maximize the value of the nutrients for crops production andto reduce
dt more thanpotential
30 for
pollution, the waste should be applied to a growing crop or applied
ys
prior to planting a crop or forages breaking dormancy. Injecting the waste or disking will
conserve nutrients and reduce odor problems.
This plan is based on the waste application method shown above. If you choose to change methods
in the future, you need to revise this plan. Nutrient levels for different applications methods are
not the same. nutrient content for
The estimated acres needed to apply the animal waste is based on typical
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. In some cases you may want to have plant analysis made, which

Fletcher McDuffie (Temporary Plan)
Page 2
could allow additional waste to be applied. Provisions shall be made for the area receiving
waste to be flexible so as to accommodate changing waste analysis content and the crop type.
Lime must be applied to maintain pH in the optimum range for specific crop production. This
waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract No.
Field No.
Soil Type
Crop
Code
Yield/Ac
Lbs. N
unit
Acres
Lbs N
Used
Month to
Apply
Lbs. N
Per Ac.
10995
4
Johns
CB -HAY
8
50
7.48
2992
MAR-OCT
400
* 10995
4
Johns
SG -OS
1
50
7.48
374
OCT-MAR
50
10995
1
WgB
CB -HAY
8
50
5.98
2392
MAR-OCT
400
* 10995
1
WgB
SG -OS
1
50
5.98
299
OCT-MAR
50
Total 13.46
Available Nitrogen
Surplus or deficit
6057 lbs.
5072 lbs.
-986 lbs.
Applying the above amount of waste is a big job. You should plan time and have appropriate equipment to apply
the waste in a timely manner.
* This is a temporary plan to allow the producer to plant small grain overseeded for winter months waste
application on the above fields. This small grain overseed will be planted for harvest.

Fletcher McDuffie (Temporary Plan) Page 3
The applicator is cautioned that P and K may be over applied while meeting the N requirements. In the future,
regulations may require farmers in some parts of North Carolina to have a nutrient management plan that
addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields (i.e. small grain, etc. interseeded in bermudagrass), forage must be removed through
grazing, hay and /or silage. Where grazing, plants should be grazed when they reach a height of six to nine
inches. Cattle should be removed when plants are grazed to a height of four inches. In fields where small grain
etc. is to be removed for hay or silage, care should be exercised not to let small grain to reach materity,
especially late in the season ( i.e. April or May) Shading may result if small grain gets too high and this will
definitely interfere with the stand of bermudagrass. This loss of stand will result in reduced yields and less
nitrogen being utilized. Rather than cutting small grain for hay or silage just before heading as is the normal
situation, you are encouraged to cut the small grain earlier. You may want to consider harvesting hay or silage
two to three times during the season, depending on the time small grain is planted in the fall.
The ideal time to interplant small grain, etc. is late September or early October . Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a height of about two inches before drilling for best
results.
Caution must be exercised in grazing or haying summer annuals under stressed conditions. Nitrate poisoning
may occur in livestock. Sampling forage or hay for nitrate levels is recommended.
Acres shown in the tables are considered to be the usable acres excluding required buffers, filters strips along
ditches, odd areas unable to be irrigated, and perimeter areas not receiving full application rates due to
equipment limitations. Actual total acres in the field listed may, and most likely will be, more than the acres
shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land application of sludge at agronomic rates.
The sludge will be nutrient rich and will require precautionary measures to prevent over application of nutrients
or other elements. Your production facility will produce approximately 794 lbs. of plant available
nitrogen per year in the sludge.
If you remove sludge every 5 years you will have approximately 3969 lbs. of PAN to utilize. Assuming
you apply this PAN to hybrid bermudagrass hayland at the rate of 300 Ibs/acre you will need
acres of land. If you apply the sludge to corn at the rate of 125 Ibs. of nitrogen per acre you will need
acres of land. Please be aware that these are only estmates of the PAN and the land needed. Actual
requirements could vary by 25% depending on the sludge waste analysis, soil types, realistic yields, and
application methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation such that
runoff or ponding occurs. This rate is limited by initial soil moisture content, soil structure, soil texture, water
droplet size, and organic solids. The application amount should not exceed the available water holding capacity
13
32

Fletcher McDuffie (Temporary Plan) Page 4
of the soil at the time of irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of
the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the producer and
irrigation designer to ensure that an irrigation system is installed to properly irrrigate the acres shown in tables.
Failure to apply the recommended rates and amounts of nitrogen shown in the tables may make this plan
invalid.
The following table is provided as a guide for establishing application rates and amounts.
Tract No.
Field No.
Soil Type
Crop
Code
Applic.
Rate(in/hr)
Applic.
Amount
10995
4
Johns
CB -HAY
0.75
0.75
10995
4
Johns
SG -OS
0.75
0.75
10995
1
WgB
CB -HAY
0.75
0.75
10995
1
WgB
SG -OS
0.75
0.75

Fletcher McDuffie (Temporary Plan) Page 5
This is the maximum application amount allowed for the soil assuming the amount of nitrogen allowed for the
crop is not over applied. In many situations the application amount shown cannot be applied because of the
nitrogen limitations. The maximum application amount shown can be applied under optimum soil conditions.
Your facility is designed for 180 days of temporary storage and the temporary storage must be removed on the
average of once every 6 months. In no instances should the volume of the waste be stored in your structure
be within the 25 year 24 hour storm storage or one foot of freeboard except in the event of the 25 year 24 hour
storm.
It is the responsibility of the producer and the waste applicator to ensure that the spreader equipment is operated
properly to apply the correct rates shown in the tables. Failure to apply the recommended rates and amounts of
nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you have receive the waste analysis report for assistance in determining the
amount of waste per acre and the proper application rate prior to appling the waste.
NARRATIVE OF OPERATION
You can apply a total of 673 lbs. PAN on small grain in fields 1 & 4.

WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: Fletcher McDuffie (Temporary Plan)
Owner/Manager Agreement Fletcher McDuffie
Page 6
I (we) understand and will follow and implement the specifications and the operation and maintenance proce-
dures established in the approved animal waste utilization plan for the farm named above. I (we) know that any
expansion to the existing design capacity of the waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the North Carolina Division of Water Quality
before the new animals are stocked. I (we) also understand that there must be no discharge of animal waste
from this system to the surface waters of the state from a storm event Tess severe than the 25-year, 24 hour
storm.The approved plan will be filed on -site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner:
Signature:
Fletcher McDuffie
Name of Manager (If different from owner)
Signature:
Name of Person Preparing Plan: G. Glenn Clifton
Affiliation: Prestage Farms, Inc.
Address: P.O. Box 438
Clinton, NC 28329
Signature: 4.
Phone: [phone]
MAR 272019
Date:
Date: J2.fisjc9

Temporary Plan Waste Utilization Plan
Producer: Fletcher McDuffie
Name of Farm: Fletcher McDuffie (Temporary Plan)
Location: P.O. Box 261
Elizabethtown NC 28337
Phone: [phone]
Type of Operation: Feed -Finish
Number of Animal: 2205
Storage Structure: Anaerobic Lagoon
Method of Application: Irrigation
Amount of waste produced per year:
Amount of plant available N (PAN) produced/year:
County: Bladen
4190 ton/year
5072 lbs./year
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface water and/or groundwater. The plant nutrients in the animal waste
should be used to reduce the amount of commercial fertilizer required for the crops in the
fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in the implementing your waste utilization plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an environmentally
safe manner.
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall not be applied to land eroding at more than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are
established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is
frozen. Either of these conditions may in runoff to the surface waters which is not
allowed under DWO regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor problems.
6. To maximize the value of the nutrients for crops production and to reduce the potential for
pollution, the waste should be applied to a growing crop or applied not more than 30 days
prior to planting a crop or forages breaking dormancy. Injecting the waste or disking will
conserve nutrients and reduce odor problems.
This plan is based on the waste application method shown above. If you choose to change methods
in the future, you need to revise this plan. Nutrient levels for different applications methods are
not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. In some cases you may want to have plant analysis made, which

Fletcher McDuffie (Temporary Plan) Page 2
could allow additional waste to be applied. Provisions shall be made for the area receiving
waste to be flexible so as to accommodate changing waste analysis content and the crop type.
Lime must be applied to maintain pH in the optimum range for specific crop production. This
waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract No. Field No.
* 10995
* 10995
2
1
Soil Type
Johns
WgB
Crop
Code
SG -OS
SG -OS
Yield/Ac
1
1
Lbs. N
unit
Acres
6.0
9.0
Total 15.0
Available Nitrogen
50
50
Lbs N
Used
300
450
Month to
Apply
SEP-MAR
SEP-MAR
750 lbs.
5072 lbs.
Applying the above amount of waste is a big job. You should plan time and have appropriate equipment to apply
the waste in a timely manner.
Lbs. N
Per Ac.
50
50
* This is a temporary plan to allow the producer to plant small grain overseeded for winter months waste
application on the above fields. This small grain overseed will be planted for harvest.

Fletcher McDuffie (Temporary Plan) Page 3
The applicator is cautioned that P and K may be over applied while meeting the N requirements. In the future,
regulations may require farmers in some parts of North Carolina to have a nutrient management plan that
addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields (Le. small grain, etc. interseeded in bermudagrass), forage must be removed through
grazing, hay and /or silage. Where grazing, plants should be grazed when they reach a height of six to nine
inches. Cattle should be removed when plants are grazed to a height of four inches. In fields where small grain
etc. is to be removed for hay or silage, care should be exercised not to let small grain to reach materity,
especially late in the season ( i.e. April or May) Shading may result if small grain gets too high and this will
definitely interfere with the stand of bermudagrass. This loss of stand will result in reduced yields and less
nitrogen being utilized. Rather than cutting small grain for hay'or silage just before heading as is the normal
situation, you are encouraged to cut the small grain earlier. You may want to consider harvesting hay or silage
two to three times during the season, depending on the time small grain is planted in the fall.
The ideal time to interplant small grain, etc. is late September or early October . Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a height of about two inches before drilling for best
results.
Caution must be exercised in grazing or haying summer annuals under stressed conditions. Nitrate poisoning
may occur in livestock. Sampling forage or hay for nitrate levels is recommended.
Acres shown in the tables are considered to be the usable acres excluding required buffers, filters strips along
ditches, odd areas unable to be irrigated, and perimeter areas not receiving full application rates due to
equipment limitations. Actual total acres in the field listed may, and most likely will be, more than the acres
shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land application of sludge at agronomic rates.
The sludge will be nutrient rich and will require precautionary measures to prevent over application of nutrients
or other elements. Your production facility will produce approximately 794 lbs. of plant available
nitrogen per year in the sludge.
If you remove sludge every 5 years you will have approximately 3969 lbs. of PAN to utilize. Assuming
you apply this PAN to hybrid bermudagrass hayland at the rate of 300 lbs/acre you will need
acres of land. If you apply the sludge to corn at the rate of 125 Ibs. of nitrogen per acre you will need
acres of land. Please be aware that these are only estmates of the PAN and the land needed. Actual
requirements could vary by 25% depending on the sludge waste analysis, soil types, realistic yields, and
application methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation such that
runoff or ponding occurs. This rate is limited by initial soil moisture content, soil structure, soil texture, water
droplet size, and organic solids. The application amount should not exceed the available water holding capacity
13
32

Fletcher McDuffie (Temporary Plan) Page 4
of the soil at the time of irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of
the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the producer and
irrigation designer to ensure that an irrigation system is installed to properly irrrigate the acres shown in tables.
Failure to apply the recommended rates and amounts of nitrogen shown in the tables may make this plan
invalid.
The following table is provided as a guide for establishing application rates and amounts.
Tract No.
Field No.
Soil Type
Crop
Code
Applic.
Rate(in/hr)
I Applic.
Amount
* 10995
2
Johns
SG -OS
0.5
1.0
* 10995
1
WgB
SG -OS
0.5
1.0

Fletcher McDuffie (Temporary Plan) Page 5
This is the maximum application amount allowed for the soil assuming the amount of nitrogen allowed for the
crop is not over applied. In many situations the application amount shown cannot be applied because of the
nitrogen limitations. The maximum application amount shown can be applied under optimum soil conditions.
Your facility is designed for 180 days of temporary storage and the temporary storage must be removed on the
average of once every 6 months. In no instances should the volume of the waste be stored in your structure
be within the 25 year 24 hour storm storage or one foot of freeboard except in the event of the 25 year 24 hour
storm.
It is the responsibility of the producer and the waste applicator to ensure that the spreader equipment is operated
properly to apply the correct rates shown in the tables. Failure to apply the recommended rates and amounts of
nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you have receive the waste analysis report for assistance in determining the
amount of waste per acre and the proper application rate prior to appling the waste.
NARRATIVE OF OPERATION
You can apply a total of 750 lbs. PAN on small grain in fields 1 & 2

Fletcher McDuffie (Temporary Plan) Page 6
1.
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply waste. If the producer
does not own adequate land to properly dispose of waste , he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre per
year providing grass filter strips are installed where runoff leaves the field. (See FOTG
standard 393 - Filter Strip).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate that runoff
does not occur offsite or to the surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potentual for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residenrial property boundary
and from any perennial stream or river (other than an irrigation ditch or canal. Animal
waste other than swine waste from facilities sited on or after October 1, 1995), shall not be
applied closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips).

Fletcher McDuffie (Temporary Plan) Page 6
REQUIRED SPECIFICATIONS
(continued)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those owned
by he landowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist".
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
17. A protective cover of appropriate vegtation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidences of
erosion, leakage or discharge.
18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illigal discharge, pollution and erosion.
19. Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20. Animal waste can be used in a rotation that includes vegetation and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications of animal waste
during the crop season.
21. Highly visible markers shall be installed to mark the top and the bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five (5) years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina regulations.

Page 6
Signature:
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: Fletcher McDuffie (Temporary Plan)
Owner/Manager Agreement Fletcher McDuffie
I (we) understand and will follow and implement the specifications and the operation and maintenance proce-
dures established in the approved animal waste utilization plan for the farm named above. I (we) know that any
expansion to the existing design capacity of the waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the North Carolina Division of Water Quality
before the new animals are stocked. I (we) also understand that there must be no discharge of animal waste
from this system to the surface waters of the state from a storm event less severe than the 25-year, 24 hour
storm.The approved plan will be filed on -site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Fletcher McDuffie
Fl
/// LLL
Name of Manager (If different from owner)
Signature:
Name of Person Preparing Plan: G. Glenn Clifton
Affiliation: Prestage Farms, Inc.
Address: P.O. Box 438
Clinton, NC 28329
Signature:
Phone: [phone]
Date:// li
Date:
Date: i/ /0//8

3i.
- I •
r-
"
:2-
.4 2N-4
•
. ' • ;
. .„
: • 1. ! . •
! I ? •I
• `
! •
. • ; !
• • ! !• I
• I • •
. : •
. . '
;
: f .
;' ' .. 1: .'-'' • 1 I " a' . ., .: „, i : ; : . 1 i . ' ., : .1. • a . : , • .
a 01 :: ..- . . • i . ; ' : • a ;
0:: • i ' ..: I tek '4-4,-;1--\) r: ! 7( ' ' ' V: P 1 S 1 ...--i- - i
• I .1 . , ' ' I .1.1 - T! 1 : .
-- ..- k - -,--:—..-!....1-‘ 1..3 - EA- :•.P.- '• '
' a ' I • k i L ; • -I .i 4-4-, y •; :.• • :. !:- ,.
, : { i.. , . -: • :_ 1 !. i, . - 4. 1 , i ..t -; •... , 1 • •-• L- 1 • -. •g• .. :•
'. ; .1 ; 1 :1- ' , 1 : *: 1

EMERGENCY ACTION PLAN
PHONE NUMBERS
DIVISION OF WATER QUALITY (DWQ)
EMERGENCY MANAGEMENT SERVICES (EMS)
SOIL AND WATER CONSERVATION DISTRICT (SWCD)
NATURAL RESOURCES CONSERVATION SERVICE (NRCS)
COOPERATIVE EXTENSION SERVICE (CES)
9/0-1133-'v
`]!!
910 - 8672- 3/7?et,* 3
9/0 - $6 2 - 3/ 7? ems. 3
910- 8 4.'-41591
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing or running off site. You should not wait until wastes reach surface waters or
leave your property to consider that you have a problem. You should make every effort to
ensure that this does not happen. This plan should be posted in an accessible location
for all employees at the facility. The following are some action items you should take.
1.
A.
Stop the release of wastes. Depending on the situation, this may or may not be possible. Suggested
responses to some possible problems are listed below.
Lagoon overflow - possible solutions are:
a) Add soil to berm to increase elevation of dam.
b) Pump wastes to fields at an acceptable rate.
c) Stop all flow to the lagoon immediately.
d) Call a pumping contractor.
e) Make sure no surface water is entering lagoon.
B. Runoff from waste application field -actions include:
a) Immediately stop waste application. .
b) Create a temporary diversionrto contain waste.
c) Incorporate waste to reduce runoff.
d) Evaluate and eliminate the reason(s) that cause the runoff.
e) Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinklers - action include:
a) Stop recycle pump.
b) Stop irrigation pump.
c) Close valves to eliminate further discharge.
d) Repair all leaks prior to restarting pumps.
D. Leakage from flush systems, houses, solid separators - action include:
a) Stop recycle pump.
b) Stop irrigation pump.
c) Make sure siphon occurs.
d) Stop all flow in the house, flush systems, or solid separators.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed to flowing leaks -
possible action:
a) Dig a small sump or ditch from the embankment to catch all seepage, put in a submersible
pump, and pump back to lagoon.
b) If holes are caused by burrowing animals, trap or remove animals and fill holes and
compact with a clay type soil.
c) Have a professional evaluate the condition of the side walls and the lagoon bottom as soon
as possible.
8

2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach surface waters?
b. Approximately how much was released and for what duration?
c. Any damage notes, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours call your DWQ regional office; Phone f, After hours,
emergency number. [phone]. Your phone call should include: your name, facility
number, telephone number, the details of the incident from item 2 above, the exact
location of the facility, the location or direction of the movement of the spill, weather and
wind conditions. The corrective measures that have been under taken, and the
seriousness of the situation.
b. If the spill leaves property or enters surface waters, call local EMS phone number.
c. Instruct EMS to contact local Health Department.
d. Contact CE's phone number, local SWCD office phone number and the local NRCS
office for advice / technical assistance phone number.
4. If none of the above works call 911 or the Sheriffs Department and explain your problem to
them and ask the person to contact the proper agencies for you.
5. Contact the contractor of your choice to begin repair or problem to minimize offsite damage.
a. Contractors Name:
b. Contractors Address:
c . Contractors Phone:
6. Contact the technical specialist who certified the lagoon (NRCS, Consulting Engineer, etc.)
a. Name:
b. Phone:
7. Implement procedures as advised by DWQ and technical assistance agencies to rectify the
damage, repair the system, and reassess the waste management plan to keep problems
with release of wastes from happening again.
9

Swine Farm Waste Management Odor Control Checklist
Suaara:e cuusc _
Farmstead l0 111dnfmfcc [
Fanuslea
• Swine production Sile Spa ciCc l'raicliccs
Animal body surfaces
Flour surfaces
• Dirty manure -covered animals
• Wet manure -covered flours
hhuuu•e collection Ails • IJrine;
Ventilation eshaus! fans
• Partial microbial decomposition
Volatile gases;
Dust
Indoor surfaces • Dust
Flush tanks
Flush :alleys
aechargc points
Lill alaliuns
• Agitation of recycled lagoon
liquid ivltile tanks are filling
1A
•
•
Outside drain collection •
or junction boxes 1J1
Agitation during wastewater
conveyance
Agitation ofrecycled.lagonn
liquid while pits are Tilling
Agitation during sump lank
Tilling and drawdown
Agitation during wastewater
conveyance
W Vegetative or wooded buffers;
CY Recommended best management practices;
tY Gontl judgment and common sense
f? Dry oorsfl
alr Slotted floors;
fa. Waterers located over slotted floors;
Feeders at ltiglt cnd of solid floors;
C4' Scrape manure buildup from floors;
CI Underfloor ventilation for drying
fA• Frequent manure removal by flush, pit recharge,
or scrape;
O Underfloor ventilation •
1 Ian maintenance;
17.11 Efficient air movement
Washdown between groups of animals;
Feed additives;
17 Feeder covers;
el heed delivery downspout extenders to feeder
sos—
L7 Flush lank covers;
CI Extend fill lines to hear bottom of tanks with
anti -siphon vents
21 Underfloor flush with underfloor ventilation
f_7 Extend recharge Tines to near button of pits
will anti -siphon vents
o Sump took covers
CI !lox covers
a
AMCiC: - November II, 1996,
Page
•e

Source
End of drainpipes at
lagoon
Lagoon surfaces
te Specific Practices
Cause 'Mrs to Minimize Odor
• Agitation during wastewater Cl Extend discharge point of pipes underneath ,,/ofi f� u�nc�
conveyance lagoon liquid level /v 9
• Volatile gas emissions; t31 Proper lagoon liquid capacity;
• Biological mixing; d Correct lagoon startup procedures;
• Agitation C4 Minimum surface area-to-voluutc ratio;
. It. Minimum agitation whcn.pumping;
0 Mechanical aeration;
Irrigation sprinkler
nuzzles
Cl Provenbialogical additives
• high pressure agitation; P9 Irrigate on dry days with little or no wind;
• Wind drift (X Minimum recommended operating pressure;
t Pump intake near lagoon liquid surface;
CI Pump from second -stage lagoon
StoragL tank or basin
surface
• Partial microbial decomposition;
• Mixing while tilling;
• Agitation when emptying
Cl Bottom ur midlevel loading;
Cl 'Tank covers;
CI Basin surface mats of solids;
Cl Proven biological additives or oxidants
Settling basic surface • Partial microbial decomposition;
• Mixing while filling;
e. t1RN • Agitation when emptying
lvlanurc, slurry ur sludge • Agitation when spreading;
spreader outlets • Volatile gas emissions
Uncovered manure, •
slurry or sludge on field
surfaces
O Extend drainpipe outlets underneath liquid
level;
O Remove settled solids regularly
Cl Soil injection of slurry/sludges;
CI Wash.residual manure from spreader after use;
[ 1 Proven biological additives or oxidants
Volatile gas emissions while
drying
t
Dead animals • Carcass decomposition
D- ead animal disposal Carcass decomposition
114:
pits
luciucr;aus
O Soil injection of slurry/sludges
O Soil incorporation within 48 hrs.;
I:] Spread in thin uniform layers fur rapid drying;
O Proven biological additives or oxidants
.94 Proper disposition of carcasses
O Complete covering of carcasses in burial pits;
O Proper location/construction ol'dispusal pits
lucuniptetc cumlmstiott Ct Secondary stack burners
Alv1OC - November 11, 1996, Page 4

Controlling
Environmental Assurance frog,,,,,. ,
Options fur Managing Odor ; a report I
Nuisance Concerns in Animal Manure
AM(IC - November I I, 199(1, Page 5
HMI's to Minimize Odor
181 Grade and landscape such that water drains
►n of away front facilities
css roads 9.9 farm access road maintenance
:ket
Site Specific Practices
d Remedies ; CiMAE Fact Sheet
'it Recharge - Lagoon Treatment ; l flAC 128-88
Uuderlloor flush - Lagoon Treatment ; 1 flAI's 129-88
4anurc Treatment and Storage ; EBAE 103-83
ion Equipment ; I:DAE Pact Sheet
L33
lima!
Tom the Swine Odor Tusk Force
Management: Odors and Flies ; 1410107, 1995 Conference Proceedings
Available From :
NCS11, County Extension Censer
NCSU - 11A1:
NCSU - I1AP
NCSIJ- IIA1i
NCSIJ- BAH
NCSIJ - IIAIZ
NCSU - Swine Extension
NC Pork Producers Assoc
NCSU Agri Communications
Florida Cooperative Extension

Mortality Management Methods
(check which method(s) arc being implemented)
�I Burial three feet beneath the surface of the around within 24 hours after
knowledge of the death. The burial must be at 1—cast 300 feet from any flowing
stream or public body of water.
Rendering at. a rendering plant licensed under G.S. 106-16S.7
rJ Complete incineration
Q In the case of dead poultry only, placing in a disposal pit of a size and'desi?n
approved by the Department of Agriculture
• Anv method which in thc professional opinion of thc State Veterinarian would
make possible the salvacc of part of a dead animal's value without endangering
human or animal health. (Written approval of the State. Veterinarian must be
attached)
Insect Control Checklist for Anirnal Operations
SOltree
Cuusc•'IMPS to COulrul Insects
Site Specific Practices
Liquid Systems
• Flush cutters • Accumulation of solids
Lagoons and fits • Crusted Solids
Flush system is designed and operated
sufficiently to remove accumulated solids from
gutters as designed.
Remove bridging of accumulated solids tit
discharge
IA' Maintain lagoons, settling basics and pits ‘vbere
pest breeding is apparent to minimize the
crusting ofsolids to a depth of no more than 6 -
It inches over more than 30% of surface.
lsacessive Vegetative • Decaying vegetation IX Maintain vegetative control along banks of
Growth lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along ‘vatcr's edge on impoundment's perinieter.

Version —November 26, 2018
Primary Secondary
as
ao
as
Mortality Management Methods
indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Routine Mortality
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location map and plan.
Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
13B .0200.
Rendering at a rendering plant licensed under G.S. 106-168.7.
Complete incineration according to 02 NCAC 52C .0102.
A composting system approved and permitted by the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
Any method which, in the professional opinion of the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
Mass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
Signature of Farm Owner►Aanager
Date
6e011, irtriZe—f clia6117
Signat re of Technical Specialist Date

/
3,
4.
Operatnr:F/etcher McDuffie County: BLADE!,,!
-'"^^,ce t« nearest residence.(other th Date: 92
z, STEADY STATE LIVE WEIGHT a»T6� 0������ 3-2-
. reet
0 sows (farrow to finish)
0 s»wy (""ow to feeder) 1417
x
head (finishing)os^ =
2ca�/ s»ws (farrow to wean) »»/Y) .
x 522 /bs= 0 /b
0 head (wean to x 135 /bs, = 0-lb
feeder) x 433 /bs, = b
2^ MINIMUM REQUIRED TOTAL STEADY STATE LIVE WEIGHT
30( /bs^) = �9��7�� /b/
Vo//.=, _�Eu TREATMENT VOLUME (}F LAGOON ~�`-'' = 198450 /bs
T- ~~= - 298�50 /b
Volume
yn/ume(CF)s�bS8LW » Treatment y /
= � cu'/ ^ �SLW= « ume(CF)//b SSLW
STORAGE VOL' ��� -��.�v,/c feet 1 CF//b, S^ WL__�
_.E ,ux 5LUD8E AC
CUMULATION
Volume =
0.0 Cubic P.-�
TOTAL DESIGN VOLUME
inside top ]en8th
Top of d/ke at elevation
feet ; Ins/de t
� '= :»ard 1 0 f 49 O f »P width
Tot a/ design /a^ eet ; S�de s/o^ Feet 150^0 feet
B»ttom of /a3oo3»«» liquid level slope, 3^0 : 1 (inside
Seasonal h�3h w»te/e«at�«n 3p�� e�e«at/on 48,0 feet
/a8»on)
-��s'�e Water tab/e e/evat/^v feet ^ eet
Tot a/ design
vo/�"`=^� �� "�o' 7-uf"e»» 4q45^0 feet
ume --''
- '~' using pr/smolda/ ' ''s '/� ~ -�.| s-
SS/END1 SS/END2 formula
GS/SIDE2 � ' 'ue sL�
���� 3.0 ",v 3.0 LENGTH
'` 3^0 314,0 1NIDTH DEPTH
AREA OF TOp ���.c` 44^0 9.0
LENGTH
� WIDTH = '
314.0 . 144.0
AREA OF OM 45216^0 (AREA OF TOP)
LENGTH * WIDTH =
260 0
, 9O.O
AREA OF MIDSECTION 23400^0 (AREA OF BOTTOM)
LENGTH * WIDTH * 4
287 0
. 117.0
CO" FT. = [AREA TOP + (4*/\ 134316.0 (AREA OF MIDSECTION * 4)
45216^0 «�A4MIDSECTION) + AREA48OTTOM] * DE/6
VOLUME OF
L"ouum AT TOTAL DESIGN LIQUID LEVELZ~ v»~« in
304398 CU. FT
^
-f 2zm«, Vjor
4sT�--.�"��6�
10

TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width = 48000 0 square feet
.
320 0 150.0
^ �o ����'so
�\�� ���
8u\\d\o3s (roof and \ot water/
Length * Width = 0 0 square feet
0.0 0.0
0 square feet
TOTAL DA �u 180 days^
period to be
Design temporary storage P
5A, Volume of waste produced ure in CF/LB SSLW 0~00136
Approximate daily production »f man * 180 days
��\°� �\qZ�l5 SSLW * CF of Waste/Lb,/Day
' = 198450 Lbs.
Volume cubic feet
Volume = 4-0
115,3
58 Vo|ume of wash w�Wer d for wash\nS f\o»rs or volume
\at`
^ h water use stems that rec''`"
This is the am«unt »f fresh
system, Flush sY
of fresh water used forcaunted for in 5A.
the lagoon water are ac v on �p�s stora3e/T.48 3a\\»ns
* �"" .-' P�' ^`
0.0 Sa\\ons/day
volume =
= 0.0 cubic feet
volume
of evaporation
5C. Volume of rainfall in excessexceeds evaporat\on by \arSest am«u»t
period «f time when ra\nfa»c
�\ exc inches
Use per 7.0
180 days excess rainfall =
= T.0 in * DA / a\nches per foot
Vo|ume
= 28000.0 cubic feet
Vo<ume
�
�
�

5D. Volume of 25 year - 24 hour storm
Volume = 7.0 inches / 12 inches per foot * DA
Volume =28000.0 cubic feet
1404
5A.
5B.
5C.
5D.
TOTAL
48463 cubic
0 cubic
28000 cubic
28000 cubic
feet
feet
feet
feet
104463 cubic feet
6. SUMMARY
Total required volume
Total design volume avail,
/42,6 -7q
Min. req. treatment volume plus sludge accumulation
At elev. 45.6 feet ; Volume isc ubic
�B''yza + MEW&
_ . . = ,�� 0*/+,^
fo�a/ np�/on ""l"=e '... ,=.. .����.�
� ---".. ,'=�� r'-As,'�U�~
".
At e|ev. 47.3 feet ; Volume is � L- t cubic
+ >1S�5'67 +24el 4/3063'
Seasonal 'i�. ~..~.wave^�"^=
7. DESIGNED
By:
DATE:
APPROVED
DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
�
isemo-lubic
217175
f-dt (end pumping
oX-
(start pumpir

OPERATION AND MAINTENANCE PLAN
------------------------------
This lagoon is designed for waste treatment (permanent storage) with
min/mum odor control. The time required for the planned fluid level t
be reached (permanent + temporary storage) may vary due to soil »
conditions, flushing operations and the amount of fresh water added t
be added to the system. e »
The designed 6 months temporary storage is an estimated volume based
on: 1) waste from animals; 2> excess rainfall after evaporation d
3) the largest 24 hour (one day) rainfall that occurs on the ; a»
once every 25 years. The volume of waste generated from given
»f
of animals will be fairly constant throughout the a 8 «e» number
year. The excess rainfall will vary greatly during
and from year t»
year to year. This estimate /s based on 7 inches 3f�»e year and fr«m
which /s equal to or exceeds the highest 6 month » excess rainfall
The average a»nua/ excess rainfall is approximately
i» a year^
There-
fore, an average of 8 inches of excess rainfall �i;�u inches. There -
each year. The 25 year rainfall will not b factor
/ need t« be Pumped
an annual Pumpin8 cyc)e but this t e a to consider in
available. A maximum elevation � storage volume must always be
pumping and this is usually t»» outlet invert
in each design to begin
i»S(s) If the out/et a� is
u en in«ert of Pipe(s) from build-
. pipe s not installed on the elevation to be �
pumping, a permanent marker must be installed on this elevation t 8 »
to
to indicate when Pumping should begin. An elevation must be established
to stop pumping to maintain minimum treatment depth (6 feet).P i
can be started or stopped any time between these two elevations umP »8
operating convenience as site conditions permit (weatherfor
wea
and equipment to apply waste without runoff or /eacniner' soils, cr»P'
8/^
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set
center piyot, guns, and traveling gun irrigation.Care should b
taken when applying waste to prevent runoff from the field ordae
to crops. ma8e
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre-
cnargeu to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. So/ids should be
covered yith effluent at all times. When pre -charging is completed
flush buildings with recycled lagoon liquid. Fresh water should '
not be used for flushing after initial fi//ipS.
2. The attached waste utilization plan shall be followed.This
plan recommends sampling and testing of waste (see Attachment 8)
before land application.
m

3. Begin pump -out of the lagoon when fluid level reaches e<eva-
tion 47.30 as marked by permanent markers. Stop pump -out
when the fluid level reaches elevation 45.60 or before fluid
depth is less than 6 feet deep (this prevents the loss of favorable
bacteria). The design temporary storage, less 25 year storm is
VeTW cubic feet or 8al|ons. As stated before,
4. The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0.4
inches per hour.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stab}e
out |ets.
G. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.
`
III