090089_Permit Renewal Application 2019_20190410

State of North Carolina
Department of Environmental Quality
Division of Water Resources
Animal Waste Management Systems
Request for Certification of Coverage
Facility Currently covered by an Expiring Sate Non -Discharge General Permit
On September 30, 2019, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State
Non -Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore, all applications
must be received by the Division of Water Resources by no later than April 3, 2019.
Please do not leave any question unanswered. Please verify all information and make any necessary corrections below.
Application must be signed and dated by the Permittee.
1. Farm Number: 09-0089 Certificate Of Coverage Number: AWS090089
2. Facility Name: P-17 A &B
3. Landowner's Name (same as on the Waste Management Plan): Prestage Farms Inc
4. Landowner's Mailing Address: PO Box 438
City: Clinton State: NC Zip: 28329
Telephone Number: 910-596-5749 Ext. E-mail: glenncnaprestagefarms.com
5. Facility's Physical Address: 8067 NC 87 E
City: Clarkton State: NC Zip: 28433
6. County where Facility is located: Bladen
7. Farm Manager's Name (if different from Landowner):
8. Farm Manager's telephone number (include area code):
9. Integrator's Name (if there is not an Integrator, write "None"): Prestage Farms Inc
10. Operator Name (OIC): Jacob Nv e Kin- Phone No.: 910-876-1514 OIC #: 1005954
11. Lessee's Name (if there is not a Lessee, write 'None"):
12. Indicate animal operation type and number:
Current Permit:
Operation Types:
Operations Type Allowable Count
Swine - Farrow to Wean 4,000
Swine Cattle Dry Poultry Other Types
Wean to Finish Dairy Calf Non Laying Chickens Horses - Horses
Wean to Feeder Dairy Heifer Laying Chickens Horses - Other
Farrow to Finish Milk Cow Pullets Sheep - Sheep
Feeder to Finish Dry Cow Turkeys Sheep - Other
Farrow to Wean Beef Stocker Calf Turkey Pullet
Farrow to Feeder Beef Feeder
Boar/Stud Beef Broad Cow Wet Poultry
Gilts Other Non Laying Pullet
Other Layers

13. Waste Treatment and Storage Lagoons (Verify the following information is accurate and complete. Make all necessary
corrections and provide missing data.)
Structure
Name
Estimated
Date
Built
Liner Type
(Clay, Synthetic,
Unknown)
Capacity
(Cubic Feet)
Estimated
Surface Area
(Square Feet)
Design Freeboard
"Redline"
(Inches)
A
19.00
B
19.00
P-17A
149 3
Cl4y
Q
JAW SJ l t4
148,104.00
P-17B
/ 9 9 3
C f,g.y,
j a r] K 3 9 L
152,460.00
Mail one (1) copy of the Certified Animal Waste Management Plan (CAWMP) with this completed and signed application
as required by NC General Statutes 143-215.10C(d) to the address below.
The CAWMP must include the following components:
1. The most recent Waste Utilization Plan (WUP), signed bthe owner and a certified technical specialistcontaining:
a. The method by which waste is applied to the disposal fields (e.g. irrigation, injection, etc.)
b. A map of every field used for land application (for example: irrigation map)
c. The soil series present on every land application field
d. The crops grown on every land application field
e. The Realistic Yield Expectation (RYE) for every crop shown in the WUP
f. The maximum PAN to be applied to every land application field
g. The waste application windows for every crop utilized in the WUP
h. The required NRCS Standard specifications
2. A site map/schematic
3. Emergency Action Plan
4. Insect Control Checklist with chosen best management practices noted
5. Odor Control Checklist with chosen best management practices noted
6. Mortality Control Checklist with selected method noted - Use the enclosed updated Mortality Control Checklist
7. Lagoon/storage pond capacity documentation (design, calculations, etc.) Please be sure the above table is accurate and
complete. Also provide any site evaluations, wetland determinations, or hazard classifications that may be applicable to
your facility.
8. Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the additional components with your submittal
(e.g. composting, digesters, waste transfers, etc.)
As a second option to mailing paper copies of the application package, you can scan and email one signed copy of the
application and all the CAWMP items above to: 2019PermitRenewal®ncdenr.gov

I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that,
if all required parts of this application are not completed and that if all required supporting information and attachments are not
included, this application package will be returned to me as incomplete.
Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false statement,
representation, or certification in any application may be subject to civil penalties up to $25,000 per violation. (18 U.S.C.
Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment of not more than 5 years, or both for
a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign. If Landowner is a
corporation, signature should be by a principal executive officer of the corporation):
Name: iL / h k1 - C Ii Lt / 1(L
Title:
Signature: Date:
Name: Title:
Signature: Date:
Name: Title:
Signature: Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
E-mail: [e-mail]
FORM: RENEWAL -STATE GENERAL 02/2019

ROY COOPER
Governor
MICHAEL S. REGAN
Secrefory
LINDA CULPEPPER
Director
NORTH CAROLINA
Environmental' Quality
February 27, 2019
Prestage Farms Inc
P-17 A &B
PO Box 438
Clinton, NC 28329
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
APR Q Z019
water mar
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General Permits,
which expire on September 30, 2019. Copies of the new animal waste operation State Non -Discharge General Permits are available
at hops://den.nc.eov/about/divisions/water-resources/water-qualin -regional-operations/afo or by writing or calling:
NCDEQ-DWR
Animal Feeding Operations Program
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure v our continued coverage under the State Non -Discharge General Permitsou must submit an application for
permit coverage to the Division. Enclosed ) ou will find a "Request for Certificate of Coverage FacilitN Currently Covered b' an
Expiring State Non -Discharge General Permit." The application form must be completed. signed and returned by April 3, 2019.
Please note that I, ou must include one 111 corn of the Certified Animal Waste Management Plan ICAWMPI with the
completed and signed application form. A list of items included in the CAWMP can be found on page 2 of the renewal
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Branch staff at 919-707-9100.
Enclosures
cc (w/o enclosures):
Sincerely,
Jon Risgaard, Section Chief
Animal Feeding Operations and Groundwater Section
Fa etteville Regional Office, Water Quality Regional Operations Section
Bladen County Soil and Water Conservation District
AFOG Section Central Files - AWS090089
Prestage Farms Inc
,—� Nor.nes. rolrt3De�artraimtafEays•atvrneate'QuraiT 1 DivspnofWaterResaerces
512 N. Setsb rry St. 11636 M s ry o Center 1 Ra gh, North Cero7`ns 27 39-1835
919.7072000

TASTE UTILIZATION PLAN
Producer- :Preatage Farms, Inc. County:Bladen
Name of Farm- : P-17A&8
Location :P.O. Box 438
Clinton NC 28329
Phone :[phone]
Type Operation :FAR -WEAN
Number of Animal 4000
Storage Structure :Anaerobic Lagoon
Method of application :Irrigation
Amount of waste produced per year : 24376 tons/year
Amount of plant available N (PAN) produced/year-: 7371 lbs./year
D,J• FARM. RECORbS
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrienta in the animal waste should be use
to reduce the amount of commercial fertilizer required for the
crops in the fields where the waste is to be applied.
mis waste utilization plan uses nitrogen as the limiting
nutrient. Waste should be analyzed before each application cycle.
Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for• realistic yields of the crop to be
grown.
Several factors are important in implementing your waste
utilization plan in order to maximize the fertilizer value of the
waste and to ensure that it is applied in an environmentally safe
manner:
1. Always apply waste based on the needs of the crop to be grown
and the nutrient content of the waste. Do not apply more
nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall not be applied to land eroding at more
than 5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tone per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining, or
when the surface is frozen. Either of these conditions may
in runoff to the surface waters which is not allowed under DWQ
regulations.
5. Wind conditions should also be considered to avoild drift and
downwind odor problems.
6. To maximize the value of the nutrienta for crop production and
to reduce the potential for pollution, the waste should be
applied to a growing crop or applied not more than 30 days
prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise
this plan. Nutrient levels for different application methods are
not the same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from
your waste management facility. In some cases you may want to have

P-17A&B Page 2
plant analysis made, which could allow additional waste to be
applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content
and the crop type. Lime must be applied to maintain pH in the
optimum range for specific crop production.
This waste utilization plan, if carried out, meets the
requirements for compliance with 15A NCAC 2H .0217 adopted by the
Environmental Management Commission.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract Field Soil Crop
No. No. Type Code
Yield Lbs. N Acres Lbs. N Month to
/Acre /Unit Used Apply
10945 1A Gr C 5 50.00 6.4
10945 1A Gr L N/A 50.00 * 6.4
10945 2A Gr C 5 50.00 1.8
10945 2A Gr• L N/A 50.00 * 1.8
10945 3A WaB C 5.5 50.00 4.8
10945 3A WeB L N/A 50.00 * 4.8
10945 4A-H NoA B 4.6 50.00 38.0
10945 4A-H NoA K N/A 50.00 * 38.0
10945 5A Gr C 5 50.00 4.1
10945 5A Gr L N/A 50.00 * 4.1
10945 641 Gr C 5 50.00 4.0
10945 6A$ Gr L N/A 50.00 * 4.0
10945 6 Gr C 5 50.00 3.5
10945 61114, Gr L N/A 50.00 * 3.5
1600
320
450
90
1320
240
8740
1900
1025
205
1000
200
875
175
Total 62.6 18140
Available Nitrogen (includes commercial) 7371
Surplus Or Deficit-10769
Crop codes: Crop -unit
A=Barley-bu.
B=Bermudagrass(graze)-tons
C=Bermudagrass(hay)-tons
D=Corn(grain)-bu.
E_ Corn (silage) -tons
F=Cotton-lbs. lint
G=Fescue(graze)-tons
H=Fescue(hay)-tons
MAR-OCT
SEP-MAY
MAR-OCT
SEP-MAY
MAR-OCT
SEP-MAY
MAR-OCT
SEP-MAY
MAR-OCT
SEP-MAY
MAR-OCT
SEP-MAY
MAR-OCT
SEP-MAY
I=Oats-bu.
J=Rye-bu.
K=Small grain(graze)-acre
L=Small grain(hay)-acre
M=Sorghum(grain)-cwt.
W=Wheat-bu.
Y=Fescue(pasture)-tons
Z=SBDC Soybeans DC-bu.
Applying the above amount of waste is a big job. You should plan
time and have appropriate equipment to apply the waste in a timely
manner.

Field
IA
2A
3A
4A
4B
4C
4D
4E
4F
4G
4H
5A
6A
68
Total
On -Farm Records for Modifying a Certified Animal Waste Management Plan
Name: Prestage Farms, Inc.
P-17A & 17B
Cumulative wastewater application
Yearly gallons applied
1999 2000
2001
1259208 451836 410760
324566 156480 93888
544257 130074 266994
264250 514500 556500
162750 483000 `231000
31500 241500 147000
94500
152250
21000
257250
84000
821520
719808
651347
5388206
278250
378000
225750
341250
173250
342300
258192
171639
4146021
Average annual volume applied
Total Ib PAN =
year
Total Ib PAN =
year
199500
231000
84000
346500
84000
273840
258192
290466
3473640
4335956
Summa of waste analysis records
Lagoon 1 Lagoon2
Year PAN
1.7 1.7
7 . / pounds per 1000 gallons
Standard deviation for waste analysis = .48 x ave PAN
Standard deviation = 0.8 Ib/1000 gal
Range of values to include in average =
0.9 to 2.5 Ib/1000 gal
4,335,956 gal x 1.70 Ib PAN
year 1000 gal
7,371

P-17A&B Page 3
The applicator is cautioned that P and K may be over applied while
meeting the N requirements. In the future, regulations may require
farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only
addresses nitrogen.
In interplanted fields (i.e. small grain, etc, interseeded in
bermudagraas), forage must be removed through grazing, hay and/or
silage. Where grazing, plants should be grazed when they reach a
height of six to nine inches. Cattle should be removed when plants
are grazed to a height of four inches. In fields where small grain
etc, is to be removed for hay or silage, care should be exercised
not to to let small grain to reach maturity, especially late in
the season (i.e. April or May). Shading may result if small grain
gets too high and this will definitely interfere with -stand of
bermudagraaa. This loaa of stand will result in reduced yields and
less nitrogen being utilized. Rather than cutting small grain for
hay or silage just before heading as is the normal situation, you
are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the
season, depending on time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September
or early October. Drilling is recommended over broadcasting.
F ermudagrass should be grazed or mowed to a height of about two
inches before drilling for beat results.
Caution must be exercised in grazing or haying summer annuals
under str€saed conditions. Nitrate poisoning may occur in
livestock. Sampling forage or hay for nitrate levels is
recommended.
Acres shown in the tables are considered to be the usable acres
excluding required buffers , filter strips along ditches, odd
areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the field listed may, and most likely will be, more than
the acres shown in the tables.
See attached map showing the fields to be used for the utilization
of animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provision for periodic
land application of sludge at agronomic rates. The sludge will be
nutrient rich and will require precautionary measures to prevent
over application of nutrients or other elements. Your production
facility will produce approximately 3360 lbs. of plant available
nitrogen per year in the sludge.
If you remove sludge every 5 years, you will have approximately
16800 lbs. of PAN to utilize. assuming you apply this PAN to
hybrid bermudagrass hayland at the rate of 300 lbs. of nitrogen
per acre, you will need 56 acres of land. If you apply the
sludge to corn at the rate of 125 lbs. of nitrogen per acre, you
will need 134 acres of land. Please be aware that these are
only estimates of the PAN and land needed. Actual requirements
could vary by 25.E depending on your sludge waste analysis, soil
types, realistic yields, and application methods.

P-17 &B Page 4
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate
of the soil at the time of irrigation such that runoff or ponding
occurs. This rate is limited by initial soil moisture content,
soil structure, soil texture, water droplet size, and organic
solids. The application, amount should not exceed the available
water holding capacity of the soil at the time of irrigation nor
should the plant available nitrogen applied exceed the nitrogen
needs of the crop.
If surface irrigation is the method of land application for this
plan, it is the responsibility of the producer and irrigation
designer to ensure that an irrigation system is installed to
properly irrigate the acres shown in tables. Failure to apply the
recommended rates and amounts of nitrogen shown in the table may
make this plan invalid.
The following table is provided as a guide for establishing
application, rates and amounts.
Tract Field Soil Crop Applic
No. No. Type Rate
(in/hr)
10945
10945
10945
10945
10945
10945
10945
10945
10945
10945
10945
10945
10945
10945
1A
1A
2A
2A
3A
3A
4A-H
4A-H
5A
5A
6A
6A
6B
6B
Gr
Gr
Gr
Gr
WaB
WaB
NoA
NoA
Gr
Gr
Gr
Gr
Gr
Gr
c
L
c
L
c
L
B
H
c
L
c
L
c
L
0.4
0.4
0.4
0.4
0.6
0.6
0.5
0.5
0.4
0.4
0.4
0.4
0.4
0.4
This is the maximum application
assuming the amount of nitrogen
applied. In many situations the
applied because of the nitrogen
application amount shown can be
conditions.
Applic
Amount
(in(s))
1.0
1.0
1.0
1.0
1.0
1.0
1.0
1.0
1.0
1.0
1.0
1.0
1.0
1.0
IRR-2
PAN
LBS/AC
250
50
250
50
275
50
230
50
250
50
250
50
250
50
amount allowed for the soil
allowed for the crop is not over
application amount shown cannot be
limitation. The maximum
applied under optimum soil

P-17A&B Page 5
Your facility is designed for 180 days of temporary storage and
the temporary storage must be removed on the average of once every
6 months. In no instances should the volume of the waste be stored
in your structure be within the 25 year 24 hour storm storage or
one foot of freeboard except in the event of the 25 year 24 hour
storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply
the correct rates to the acres shown in the tables. Failure to
apply the recommended rates and amounts of nitrogen shown in the
tables may make this plan invalid.
Call your technical specialist after you receive the waste
analysis report for assistance in determining the amount of waste
per acre and the proper application rate prior to applying the
waste.
NARRATIVE OF OPERATION

Page 6
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: P-17A&B
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of
the waste treatment and storage system or construction of new
facilities will require e new certification to be submitted to the
North Carolina Division of Water duality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to the surface waters
of the state from a storm event leas severe than the 25-year, 24-
hour storm. The approved plat, will be filed on -site at the farm
office and at the office of the local Soil and Water Conservation
District and will be available for review by NCDWQ upon request.
Name of FacilityOwner: Prey tage Farms, Inc.
(Please print)
Signature : Pewlia panmM. Jr+c /1. B ti., 1, •C.. Date: _ 31111 o L
Name of ?1. neger(If different from owner) :
Signature: Date:
Name of Person Preparing Plan: G. Glenn Clifton
(Please print:)
Affiliation: Prestage Farms, Inc.
Address: P 0 Box 438
Clinton NC 28329
Phone: [phone]
Ext. 249
Signature!: , c1(3.t...,,. Date: 3 1111
6 Z

•
Foe- :Ahem
avastieii!*:'
• • . .
rot
. ••-ibi*V011ig: Aix : ••:.
*WO
.44 , . •,.......,,..i. ,,,..i...,rti
*"10'
; ftlasheigravyfehist.h'sd r.1 . '
...i.v --004 : .historical
$.. -z..„„:•...,...,...,,. • .. ••• *TM.- .
oastdsimaia]rdleirej.,of. . 7. asks* ,are,
-.. atMeitt&
... .
' restitelihettat*Ofitt#1110440* _.:
,.: ,..•
if, 4:: 41,0V
gliUtft
wost
— ilWASO
• !:,••
114401
17/101MEO be.*410•01:::.
WaikAint
tinotc itwOose-
waste istc
0ormattitom 00**144w,._
a'pphed to corservation 444.: !:**01:44-
North
• 4#0::: 00100000,
.00-410-ro.
Ttoe
tatiseziaso
or_sittpd.
(sell
.-rztr_ig`n
APR 0 S
wevii* Ditattolyasteltfizt _ fr*ed; 01,40$4 SO.ext*Voti.Pago

.01, '144 '010-
-exiattlato
frtkiijeite
9., Aiiiinatimoitetsbe
titokiterievis
rifettlat
#faitatastotok.da fttintlf
144443004010.*trosof
4:41411Witirg#,i
tiOWTs::-!:-ilOiOffOrgill •
'100 -ititorviliiptop
>...:•••• • 4
ieoax;diii
bar
loira—itoeigiwitottiots;.
u. • . :....., • :Alt •,
Vatswir, plaktrag,
*OW' liter+ ACIAher
juktottervionew area
swinebnos
littfrom...A60 ' „
.•
Itedidostittkant
Attinititote:$144401 WO- itager
•
anctaitit An.40;119
914
mkaat ft-ApPted ,:1041k-
,opelutmed.br
weiht;v:/7 :
nitaattiVeMdiolpt
ihyAe01* othet
lit(Itto reo,A, PertY
• r• . •-•
Petat0:-31102014 S*Ortgatift154t0:

brik aestiko apott1f
poi•
aetessars ie.
tree* .ativer.vamdixspegeg$
.-itgategeoploptiate., Lagoa *oat,
OW*
Ittiastr
.ortorganaindl the
bra#, ,lata55,0! "40aare'
fla
Io
t***„0,4#nOtrspinre.ni,***ionips,otee 411,z..lf_
t- ilte. ,01001.,
, • nw.ns,Oie an qapals. '
t 044in' twasteoadietiasadba~oiar'.
.,s.-r keJtn2ll.F., nentOin., Ro*.eileii :atitiiiitiiiitaeikiiiedoi
it!ittMiid *Old
, „ , , :::$4104,m0040, liviiivaste4te ' itrapi/szasen.,
oar
keinstalndlanzatlhe and hal**
eevati�nsothe.terporary'at:),rAV'', 47.4,4001
_„
Oftlitlo rump*,g shall be managed in marntaxi tbe Hquidlemel
marker.. erequh*O/o ma
sk VOW0WiiIii '
_ . . ....
latittibOsie. VOsiiva1 Th(ttat-litikk 3124/2614. ItedfitidthlitAktla

• a
it
shttelliCrAf
o000 bt
00.40141111U
-1411:1461ra
•
7410#1:,7-
tilqicregesi,
ft*w tbas- Veritono4. I
te,
' • •
thio
Ana
flwasnafysis
OA*: 004.- tatincity.
aukettui,tottokofeeea
s_,Itasitstadi -
thatIONS-
, 1410441194,P4**

3/29/2'019
0.2mi
-12
go
=}
Prestige Farms Swine Locations App
https://pfi.maps.arcgis.com/aPps/webappviewer/index.html?id=bcd31 c72d7d04bceac9388b38ba316e6

BLADEN COUNTY
EMERGENCY ACTION PLAN
DIVISION OF WATER QUALITY (DWQ) 910-433-3300
EMERGENCY MANAGEMENT SERVICES (EMS) 910-862-6760
SOIL & WATER CONSERVATION DISTRICT (SWCD) 910-862-3179
NATURAL RESOURCES CONSERVATION SERVICE (NRCS) 910-862-3179
COOPERATIVE EXTENSION SERVICE (CES) 910-862-4591
This plan will be implemented in the event that waste from your operation are leaking,
overflowing, or running off the site. You should NOT wait until wastes reach surface
waters or leave your property to consider that you have a problem. You should make
every effort to ensure that this does not happen. This plan should be posted in an
accessible location for all employees at the facility. The following are some action items
you should take.
1. Stop the release of wastes. Depending on the situation, this may or may not be
possible. Suggested response to problems are listed below:
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam, any permanent alteration of the
dam should be approved by a qualified technical specialist.
b. Pump wastes to field at an acceptable rate.
c. Stop all additional flow to the lagoon, hold wastes in the house if possible.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B. Runoff from wastes application field -action include:
a. Immediately stop wastes application.
b. Create a temporary diversion or berm to contain the waste.
c. Incorporate waste to reduce further runoff.
d. Evaluate and eliminate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinkler -action includes:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pump.
c. Close values to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
D. Leakage from flush system, houses, solids separators -action includes:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pump.
c. Make sure no siphon effect has been created.
d. Stop all flows in the house, flush systems, or solid separators.
e. Repair all leaks prior to restarting pumps.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed to
flowing leaks -possible action:

a. Dig a small sump or ditch to catch all seepage, put in a submersible pump, and
pump back into lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill holes
and compact with a clay type soil.
c. Have a professional evaluate the condition of the sidewalls and the lagoon
bottom as soon as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and what duration?
c. Any damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours, call your DWQ (Division of Water Quality)
regional office, at 910-433-3300, after hours, emergency number: 1-800-858-
0368. Your phone call should include: YOUR NAME , FACILITY
NUMBER, TELEPHONE NUMBER, THE DETAILS OF TE INCIDENT
FROM ITEM #2 ABOVE, THE EXACT LOCATION OF THE FACILITY,
AND THE LOCATION OR DIRECTION OF MOVEMENT OF THE
SPILL, WEATHER AND WIND CONDITIONS, THE CORRECTIVE
MEASURES THAT HAVE BEEN UNDER TAKEN, AND THE
SERIOUSNESS OF THE SITUATION.
b. If the spill leaves the property or enters surface waters, call local (EMS)
Emergency Management Services at 910-862-6760.
c. Instruct EMS to contact local Health Department.
d. Contact local Soil and Water Conservation District, Natural Resources
Conservation Service office at 910-862-3179 and Cooperative Extension
Service at 910-862-4591 for advice/technical assistance.
4. If none of the above works call 911 or the sheriffs Department and explain your
problem to them and ask that person to contact the proper agencies for you.
5. Contact the contractor of your choice to begin repair of the problem to minimize off -
site damage.
a. Contractors Name: ?RAMC AR015, Zql c .
b. Contractors Address:
c. Contractors Phone: 9/0 . SIR • 5'77 /
Page 2

6. Contact the technical specialist who certified the lagoon.
a. Name: RANA4-u- iL F42& or
b. Phone: `'0. 5-94- 5'77/
7. Implement procedures as advised by DWQ and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste management plan to
keep problems with release of wastes from happening again.
8. If you are a contract swine grower associated with a swine company integrator,
contact the company representative at 910-592-5771.
Page 3

Son rcc
Flush Gutters
Lagoons and fits
Insect Control Checklist for Animal Operations
Cause HMI's to Control Insects —
• Accumulation of solids
• Crusted Solids
"1, cessivc Vegetative • Decaying vc
•'Gro►slh f,claliun
("ceders
Feed Storage
• fccd Spillage
• Accumulations of fccd residues
AMIC - November I I, 1996, Page 1
O Mush syslcm.is designed and operated
sufficiently to remove accumulated solids from
gutters as designed.
O Remove bridging of accumulated solids at
discharge
a Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the
crusting of solids to a depth of no more than 6 -
3 inches over more than 30% of surface.
L Maintain vegetative control along banks of
lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along waters edge on impoundment's perimeter.
N Design, operate and maintain fccd systems (c.g.,
bunkers and troughs) to minimize the
accumulation of decaying wastage.
■ Clean tlP spillage on a routine basis (c.g., 7 - 10
day interval during summer; 15-30 day interval
during winter).
O Reduce moisture accumulation wiIhin and
around immediate perimeter of fccd storage
areas by insuring drainage away from site
and/or providing adequate containment (e.g.,.
covered bin for brewers grain and similar high
moisture grain products).
0 Inspect for and reinove or break up accumulated
solids in filter strips around fecdstorage as
needed.
Site Specific Practices

Source
Animal I -biding_ ,Areas
Dry Manure Handling
Systems
Cause •
• Accumulations of animal wastes
and feed wastage
• Accumulates
For more information contact the Cooperative .
Raleigh, NC, 27695-7613. P Fact
AMIC - November 11, 1996, Page 2
BIV/ps to Control Insects. -.
Eliminate low areas that,
fences an .. P moisture along
tl other locatkma where waste
accumulate and disturbance by animals is
minimal.
17 Maintain fence rows and filter strips animal holding areas to minimizep Found
accumulations of •
removeumula b wastes (i.e., inspect for and
reak up accumulated solids as
of animal wastes needed
® Remove spillage on a routine basis e , r
day interval during� g ► 7 -10
during winter summer; 15-30 day interval
where manure is loaded for land
application or disposal.
.0 Provide for adequate drainage around manure
stockpiles. .
® Inspect for and remove or break up
wastes in filter strips around accumulated
manure handling. p stockpiles and
areas as needed.
ension Service, Department of Entomology, _
Box 7613, North Carolina State. University,
Site Specific Practices

Source
Farmstead
Animal body surfaces
Floor surfaces
Swine Faron Waste Management ®do
r Control Chedkiist
Cause
• Swine production
Wet manuCe-covered floors
Manure collection pits ® U ixite;
Ventilation exhaust fans
Indoor surfaces
Flush tanks
Flush alleys
Pit recharge points
L'ifl stations
Outside drain collection
or junction boxes
AMQC - November 11,1
• Partial microbial decomposition
4 Dry floors
a
Volatile gases;
Dust
Dust
Agitation of recycled lagoon
liquid while tanks are filling
• Agitation during wastewater
conveyance •
• ' Agitation of recycled lagoon-
liquid while pits are filling.
• pmsuAgitation—duringk
filling and drawdown
• Agitation during wastewater
conveyance
996, Page 3
•
181 /Ps to Minimize Odor
® Vegetative Or wooded buffers;
® Recommended best management practices;
Good judgment and ,common sense
Washdown between groups of animals;
Feed additives; ' -
Feeder covers;
Feed delivery downspout extenders to feeder
covers
Flush tank covers;
Extend fill lines to near bottom of tanks with
anti -siphon vents
. ® Underfloor flush with underfloor ventilation
Slotted floors;
Et Waterers located over slotted -floors;
!] Feeders at high end of solid floors;
0 Scrape manure buildup from floors;
® Underfloor ventilation for drying
v Frequent manure removal by Bush, pit recharge,
or scrape;
Underfloor. ventilation
Fan maintenance;
■ Efficient air movement
Mil
lli
0
r; Extend recharge lines to neat, bottom of pits
with anti -siphon vents
O Sump tank covers
O Box covers
Site S ecitic Practices

�w•aa�s.•
ilINIIM
Source _ Cause •
End of drainpipes at •. Agitation during wastewater
lagoon .. cOnveyanco:.: :...:..,
Lagoon surfaces
Irrigation sprinkler
nozzles
• Volatile gas emissions;
• Biological mixing;'
Agitation
Bir+M s to Minimize Odor
CI Extend discharge point of pipes underneath
lagoon liquid level` .. .
•• Highpressure agitation;
o Wind diift
Storage tank or basin
surface
0
•
Settling basin surface
Manure, slurry or sludge
spreader outlets
Partial microbial decomposition;
Mixing while filling;
Agitation when emptying O B
O P
Proper lagoon liquid capacity;
0 Correct lagoon startup procedures; .
O
L'Ig.
ci
6 Partial microbial decomposition;
• Mixing while filling;
o Agitation when emptying
• Agitation a �:vhen spreading;
• Volatile gas emissions
Uncovered manure, • Volatile gas emissions while
slurry or sludge on field drying
surfaces
Dead. animals
Dead animal disposal
pits.
incinerators.
• Carcass decomposition
• Carcass decomposition.
Incomplete combustion
Minimum surface area -to -volume ratio;
Minimum agitation when.pumping;
Mechanical aeration;
Proven biological additives
Irrigate on dry days with little or no wind;
Minimum recommended operating pressure;
Pump intake near lagoon liquid surface;
Pump from second -stage lagoon
Bottom or midlevel loading;
Tank covers;
asin surface mats of solids;
coven biological additives or oxidants
® Extend drainpipe outlets underneath liquid
level;
CI Remove settled solids regularly
Cl Soil injection of slurry/sludges;
0 Wash residual manure from spreader after use;
® Proven biological additives or oxidants
0 Soil injection of slurry/sludges
O Soil incorporation within 48 hrs.;
0 Spread in thin uniform layers for rapid drying;
® Provenbiologicai additives or oxidants
M Proper disposition of carcasses
Site Specific Practices
O Complete covering of carcasses in burial pits;
0 Proper location/coaistruction of disposal pits
O Secondary stack burners
November 1l, 1996, Page 4
1,74

Source
Standing water around •
facilities
Manure tracked onto
public roads from farm
access
Additional' Information :
Swine Manure Managemen 200t ; 0 Rule/BMP Packet -
Swine Production Farm Potential Odor Sources and Remedies ; EBAE Fact Sheet���
Swine Production'Facility Manure' Management: Pit Recharge - Lagoon Treatment ; EBAE 128-88
Swine Production Facility Manure Management:'Underfloor Flush,. Lagoon Treatment; EBAE 129-88
Lagoon Design and Management for Livestodk Manure
e
Calibrati1. of Manure. and Wastewater Application Equipmennent and Storage ;EBAE 103-83
Controlling Odors from Swine Buildings ; PIH-33 t' EBAE Fact Sheet
Environmental Assurance Program ; NPPC Manual
Options for Managing Odor ; a report from the Swine Odor Task Force
•
Nuisance Concerns in Animal Manure Manaagement: Odors and Flies ; PRO107,1995 Conference Proceedin s
g
Cause.
Improper drainage;
'Microbial decomposition of
'organi miattnr
• Poorly maintainett access roads
Grade and landscape such that waterdrains -Site S ecitic Practices
away from facilities•
.
ills to Muiimize.Odor
C Farm access road maintenance
•
AMOC - November 11, 1996, Page 5
•
Available From :
NCSU, CountyExtension Center--
NCSU BAE
NCSU-BAE
NCSU - BAB
NCSU-BAR
NCSU - BAR
NCSU - Swine Extension
NC Pork Producers Assoc
NCSU Agri Communications
Florida Cooperative Extension

Version —November 26, 2018
AUortallty Management ods
Indicate which method(s) will be implemented.
When selecting multiple methods indicate a primary versus secondary option.
Methods other than those listed must be approved by the State Veterinarian.
Primary Secondary Routine Mortality
Burial three feet beneath the surface of the ground within 24 hours of knowledge of animal
death. The burial must be at least 300 feet from any flowing stream or public body of water
(G.S.106-403). The bottom of the burial pit should be at least one foot above the seasonal
high water table. Attach burial location map and plan.
II Landfill at municipal solid waste facility permitted by NC DEQ under GS 15A NCAC
I I 13B .0200.
ElEl Rendering at a rendering plant licensed under G.S. 106-168.7.
I I Complete incineration according to 02 NCAC 52C .0102.
CI El A composting system approved and permitted by the NC Department of Agriculture & Con-
sumer Services Veterinary Division (attach copy of permit). If compost is distributed off -farm,
additional requirements must be met and a permit is required from NC DEQ.
CI In the case of dead poultry only, placing in a disposal pit of a size and design approved by the
NC Department of Agriculture & Consumer Services (G.S. 106-549.70).
El El Any method which, in the professional opinion of the State Veterinarian, would make possible
the salvage of part of a dead animal's value without endangering human or animal health.
(Written approval by the State Veterinarian must be attached).
ElMass Mortality Plan
Mass mortality plans are required for farms covered by an NPDES permit. These plans are
also recommended for all animal operations. This plan outlines farm -specific mortality man-
agement methods to be used for mass mortality. The NCDA&CS Veterinary Division sup-
ports a variety of emergency mortality disposal options; contact the Division for guidance.
• A catastrophic mortality disposal plan is part of the facility's CAWMP and is activated
when numbers of dead animals exceed normal mortality rates as specified by the State
Veterinarian.
• Burial must be done in accordance with NC General Statutes and NCDA&CS Veterinary
Division regulations and guidance.
• Mass burial sites are subject to additional permit conditions (refer to facility's animal
waste management system permit).
• In the event of imminent threat of a disease emergency, the State Veterinarian may enact
additional temporary procedures or measures for disposal according to G.S. 106-399.4.
Signature of Farm Owner/Manager
Signature of Technical Specialist
Date
3Jas%ao/ 9
Date

ator: PRESTAGE FARMS BLADEN : Count
F'-17A County: Date: 06/22/93 '1
:stance to nearest residence (other than owner): 2000.0
STEADY STATE LIVE WEIGHT
0 sows (farrow to finish) x 1417 lbs. = 0 lbs
0 sows (farrow to feeder) x 522 lbs. = 0 lbs
0 head (finishing only) x 135 lbs. — 0 lbs
2000 sows (farrow to wean) x 433 lbs. = 866000 lbs
0 head (wean to feeder) x 30 lbs. = 0 lbs
TOTAL STEADY STATE LIVE WEIGHT (SSLW) =
MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 866000 lbs. SSLW x Treatment Volume(CF)/lb. SSLW
Treatment Volume(CF)/lb. SSLW= 1 CF/lb. SSLW
Volume = 866000 cubic feet.
STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 cubic feet
TOTAL DESIGN VOLUME
SLUDGE ACCUMULATION NOT COMPUTED
AT OWNERS REQUEST. REMOVE SLUDGE
AS NEEDED.
Inside top length 500.0 feet s Inside top width 290.0 feet
Top` of dike .at elevation 51.5 feet
Freeboard 1.0 feet ; Side slopes 3.-0 : 1 (Inside lagoon)
Total design lagoon liquid level at elevation 50.5 feet
Bottom of lagoon elevation 39.5 feet
Seasonal high water table elevation 44.3 feet
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
3.0 3.0 3.0 3.0 494.0 284.0 11.00
AREA OF TOP
LENGTH * WIDTH =
494.0 284.0
AREA OF BOTTOM
LENGTH * WIDTH =
428.0 218.0
AREA OF MIDSECTION
LENGTH * WIDTH * 4
461.0 251.0
140296 (AREA OF TOG)
93304 (AREA OF BOTTOM)
866000 lbs
462844 (AREA OF MIDSECTION * 4)
CU. FT. = [AREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM] * DEPTH/6
140296.0 462844.0 93304.0 1.8
VOLUME OF LAGOON AT TOTAL DESIGN LIQUID LEVEL =
1276814 CU. FT.

ir
TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
500.0 290.0 145000.0 square feet
Buildings (roof and lot water)
Length * Width =
0.0 0.0 0.0 square feet
TOTAL DA 145000.0 square feet
Design temporary storage period to be 180 days.
4. Volume of waste produced
Approximate daily production of manure in CF/LB SSLW 0.00136
Volume = 866000 Lbs. SSLW * CF of Waste/Lb./Day * 180 days
Volume = 211997 cubic feet
Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume =
Volume = 0.0 cubic feet
Volume of rainfall in excess of evaporation
0.0 gallons/day * 180 days storage/7.48 gallons
per CF
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall
Volume = 7.0 in * DA / 12 inches per foot
Volume = 84583.3 cubic feet
7.0 inches

Volume of 25 year - 24 hour storm
Volume = 7.0 inches / 12 inches per foot * DA
Volume = 84583.3 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 211997 cubic feet
5B. 0 cubic feet
5C. 84583 cubic feet
5D. 84583 cubic feet
TOTAL 381163 cubic feet
SUMMARY
Total required volume 1247163 cubic feet
Total design volume avail. 1276814 cubic feet
Min. req. treatment volume plus sludge accumulation 866000 cubic ft
At elev.
47.5 feet ; Volume is 8766% cubic feet (end pumping)
Total design volume less 25yr-24hr storm is 1192231 cubic feet
At elev.
49.8 feet ; Volume is 1179746 cubic feet (start pumping)
Seasonal high water table elevation 44.3 feet
DESIGNED BY: mC' �_ APPROVED BY:
,
DATE: G/LL19X DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
-
�/, )0,�Ipw
�
_

OPERATION AND MAINTENANCE PLAN
This lagoon is designed for waste treatment (permanent storage) with
min. odor control. The time required for the planned fluid level to be
reached (permanent + temporary storage) may vary due to soil conditions
flushing operations, and the amount of fresh water added to the system.
The designed 6 months temporary storage is an estimated volume
based on: 1) waste from animals; 2) excess rainfall after evaporation;
and 3) the largest 24 hour (one day) rainfall that occurs on the
average of once every 25 years. The volume of waste generated from
a given number of animals will be fairly constant throughout the year
and from year to year. This estimate is based on 7 inches of excess
rainfall which is equal to or exceeds the highest 6 months excess in
a year. The average annual excess rainfall is approximately 8 inches.
Therefore, an average of 8 inches of excess rainfall will need to be
pumped each year. The 25 year rainfall will not be a factor to consider,
in an annual pumping cycle, but this storage volume must always be
available. A maximum elevation is determined in each design to begin
pumping and this is usually the outlet invert of pipe(s) from
building(s). If the outlet pipe is not installed on the elevation to
begin pumping, a permanent marker must be installed on this elevation
to indicate when pumping should begin. An elevation must be established
to stop pumping tomaintain minimum treatment depth (6 feet).
Pumping can be started or stopped at any time between these two
elevations for operating convenience as site conditions permit, such as
weather, soils, crop,-, and equipment in order to apply waste without
runoff or: leaching;
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent damage to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre —
charged to 1/2 its capacity to prevent excessive odors during
start—up. Pre —charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times. When precharging is complete,
flush buildings with recycled lagoon liquid. Fresh water should not
be used for flushing after initial filling.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see attachment)
before land application.
3. Begin pump —out of the lagoon when fluid level reaches eleva—
tion 49.8 as marked by permanent marker. Stop pump —out when
the fluid level reaches elevation 47.5 or before the fluid depth is
less than 6 feet deep (this prevents the loss of favorable
bacteria). The design temporary storage, less 25 year storm
is 296580 cubic feet or 2218419 gallons. As stated before, this
volume will vary considerably from year to year.

4. The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0.3
inch per hour.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
8. Keep a minimum of 25 feet of grass vegetated buffer around
waste utilization fields adjacent to perennial streams. Waste will
not be applied in open ditches. Do not pump within 200 feet of a
residence or within 100 feet of a well.
9. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ—
mental Management, has the responsibility for enforcing this law.

FARMS
��onearest
_� �-- �
,
*
�
°
County.t. BLADEN
residence� ):
~.
sowsAfarrow ~ 'to� �
sows (farrow to >
head (finis-h1ng- onl>')
sows (farrow to wean)
head (*nean to feeder)
�
x
x
x
x
TOTAL STEADY STATE LIVE WEIGHT (SS_W)
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Treatment
Volume �= ^
~ .
�
- ~ ,
STORAGE VOLUME FOR SLUDGE AqC�MWLAT I[N
~
..�
^`
�
-^
w"-
=
~ ~ .��
= 0 lb��
= E46000 1ps`
= n zos
«
= 8660001bs
Voluwne(CF)/Ib~ ,SSLW
^
�Volume = 0.0 cubic fiedt SLUDGE ACCUMULATION NOT COMPU_ ..
AT QWWRS REQUEST. --REMOVE SLUDSE
'5"
' ����������D.DES I ON VOLUME
inside top l�ngth 45�.0 feet � inside /�* top width 328.0 feet
Top of dike at elevation 48^0 feet 1 (Inside 14goon)
Freeboard 1.8 feet ; Side slopes .
Total design lagoon liquid level at elevation 47.0 feet
Bottom of lagoon elevation 36.0 feet OK
Seasonal high water table elevation A47_r e e t
Total design volume using prismoidal formula
SS/END! SS/END2 SS/SIDE1 SS/SIDE2
3.0 3.0
AREA OF TOP
LENGTH * WIDTH =
444.0 314.0
AREA OF BOTTOM
LENGTH * WIDTH =
378.0 248.0
AREA OF MIDSECTION
LENGTH * WIDTH * 4
411.0 281.0
139416.0
LENGTH
444.0
WIDTH DEPTH
314.0 11.00
139416 (AREA OF TOP)
�
93744 (AREA OF DOTI
461964 (AREA 8F MID�ECTION * 4)
461964.0 93/44.0
VOLUME OF IL-AGOON AT TOTAL DESIGN LIQUID LEVEL
1274394 CU. FT.

-
^
4 gidth
450- 144000-i0 square. feet
��
Buildings (roof and lot water)
Length * Width =
0,0 0.0 (Y.g square feet
TOTAL DA 144000.0 square feet
[,esign temporary storage ` period to be
.'
.-
=
�� '
r_ T�MPORARY REQUIRED
`
.1
If
160 days.
Volume = 8660-00 Lbs. SGLW * CF of Waste/Lb./Day, *
21191,77 cubic feet
K
='-
� ——^ ^ of wash water
�—�. -*o�—uoue wa r
`
,
"
0.00l36
180 days
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush System. Flush systems that recirculat«
the lagoon water are accounted for in 5A,
Volume =
0.0 gallons/day * 180 days storage gallons
per CF
Volume = 0.0 cubic feet
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount
180 days excess rainfall = 7.0 inches
Volume = 7.0 in * DA / 12 inches per foot
Volume = 84000.0 cubic feet
�^�

Volume of 25 year - 24 hour storm
Volume = 84000.0 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 211997 cubic feet
5B. 0 cubic feet
5C. 84000 cubic feet
5D. 84000 cubic feet
TOTAL 379997 cubic feet
AK-
6. SUMMARY
*'
Total required volume 1245997 cubic feet
~~. Total design volume avail. 1274394 cubic feet °�^
Min. req. treatment volume plus sludge accumulation 866000 cubic ft
44.0 feet ; Volume is 876288 cubic feet (end pumping)L--
At elev.
Total design volume less 25yr-24hr storm is 1190394 cubic feet wt-~~
At elev. 46.3 feet ; Volume is 1177913 cubic feet (start Pumping)
^/ 3�a']�� 8/e-
Se al high water table e1evation 40T3 feet /
ason . ^
_- BYAPPROVED BY:
DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
DATE: ����
^ ~
-r�-
COMMENTS:__�����
|
.

or-
~
OPERATION AND MAINTENANCE PLAN
'- ` ^ � ������xz�'�
- - .,° ~. ,' �-"~`_ "I^^°
' . ' .
lagoon is designed for waste.treatment�(pe4- 1 �
^�u+�, �w.^`,`,^. ...~Tke .~.�time . -�--� _- _' . _
-"' � . . �----_---. -+` ==" �ow= +�s�i§ `�''
.' reacMed (permanent � cempo,"^'r =`"'ay=' ~_, `~`~ --- -- --
1,;`flushing operations, arid the amount of fresh water added to tbe'`%SYS64eM-,,
-~`
�~^VolUmte
The designed-6monthstempo,storag 1 am es
based on �) waste from animals; 2) excess rainfall *�fzer e^+°�,
: ~`
`andt 24 hour� (oned�y �rainf��� that occurs o�3) the -the
`
�
�
�v='��� ~' riin—~~`~- -'-'� -- yea'-- s. The volume Of waste genera e ro
i be fairly constant t the year
�� given number o� animals vw��� ^^.~~�.__
and from year to year. This estimate is based on 7 inches of excess
rainfall which is equal to or exceeds the highest 6 months excess in'
a year. The average annual excess rainfall is approximately 8 inchei%.
=" ="=��np` of 8 inches of excess rainfall will need to be
~'' ~'-'-=- -� - inches i fall will not to consider
pumped
each year. The 25 year' rainfall be a factor t
n ^
storage volume must always be
annual pumping cycle, but this
in an
available. A maximum elevation is determinedi n each design to begin
pumping and this is usually the outlet invert of pipe(s) from
building.(s). If the outlet pipe is not installed on the elevation to
~-*~~^ pumping, a permanent marker must be installed
stalled on this elevati-On
� t�cwn must kn� l�m���
*v�e� begin. An va e�v�� ����"
�- -'--.---- pumping � �~ minimum treatment depth {6 f�et� �
-�� s�ts�» pumping to maintain m�m .
bestarted st��ped at any time between these two
Pumping can or .
--�'i as site conditions permit, suLh as
elevations for operating convenience
weather, soils, crop, and equipment in order to apply waste without
^runmff or leaching.
Land application of
method of disposal.
center pivot, guns,
taken when applying
waste water is recognized as an acceptable
Methods of app1icaticm include solid set,
and traveling gun irrigation. Care should be
waste to prevent damage to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre -
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times. When precharging i� complete,
flush buildings with recycled lagoon liquid. Fresh water should t
no
be used for flushing after iniIt: ia] filling.
2 The attached waste utilization plan shall be followed. This
^an recommends sampling and testing of waste (see attachment>
pl
before land application.
3 Begin pump -out of the lagoon when fluid level reaches eleva-
^ rker. Stop pump -out when
tion 46.3 as marked by permanentma ~
the fluid level reaches elevation 44.0 or before the fluid depth is
- loss
less than 6 feet deep (this prevents the of favorable
bacteria). The design temporary storage, less 25 year storm
is 295997 cubic feet or 2214056 gallons. As stated before, this
volume will vary considerably from year to year.

r-4cOmaend+ d anaxi as
:.. ttci the ‘!r-eta: ertde
pr.`.
Ltn�t pp l i. ce
tai.ren,t a
agt n1.mawe r ua1 y V etation she u
0 intain a ,A40r0us stand-.' ..
ro ed area
a- inn._
uttface runoff :-s t
-ts'a
", .gattof"`
n•rrate
as ad:)e" t t #
d ,.be fertilized. as needed.
d by rodents and
arm' the Lagoon to stable
Keep a '#t ininum of 25 feet of grass Vegetated buffer around
waste utilization fields adjacent to perennial streams. Waste will
not be applied in open ditches.` pia not pump within 200 feet of a
,.residence or within 100 feet of a well. -
9. he Clean Water Act Of ,1977. prohibi- the discharge of
pollutants into Waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental M nag t has the responsibility- far enforcing this law.