WQ0044259_More Information Received_20240112

Initial Review
Reviewer
nathaniel.thornburg
Is this submittal an application? (Excluding additional information.) *
Yes No
If not an application what is the submittal type?* Annual Report
Residual Annual Report
Additional Information
Other
Permit Number (IR) * W00044259
Applicant/Permittee Carolina Poultry Power RG2, LLC
Email Notifications
Does this need review by the hydrogeologist? * Yes No
Regional Office
CO Reviewer
Admin Reviewer

Submittal Form
Project Contact Information
Please provide information on the person to be contacted by NDB Staff regarding electronic submittal, confirmation of receipt, and other correspondence.
Name* Kim Melvin
Email Address*
[e-mail]
Project Information
.........................
Application/Document Type*
New (Fee Required)
Modification - Major (Fee Required)
Renewal with Major Modification (Fee
Required)
Annual Report
Additional Information
Other
Phone Number*
8644143059
Modification - Minor
Renewal
GW-59, NDMR, NDMLR, NDAR-1,
N DAR-2
Residual Annual Report
Change of Ownership
We no longer accept these monitoring reports through this portal. Please click on the link below and it will take you to the correct form.
https://edoes.deq.nc.gov/Forms/NonDischarge_Monitoring_Report
Permit Type:*
Wastewater Irrigation
High -Rate Infiltration
Other Wastewater
Reclaimed Water
Closed -Loop Recycle
Residuals
Single -Family Residence Wastewater
Other
Irrigation
Permit Number:*
WQ0044259
Has Current Existing permit number
Applicant/Permittee Address*
Wilson, North Carolina
Facility Name*
Carolina Poultry Power- Wilson CUS
Please provide comments/notes on your current submittal below.
Attn: Erick Saunders
At this time, paper copies are no longer required. If you have any questions about what is required, please contact Nathaniel Thornburg
at [e-mail].
Please attach all information required or requested for this submittal to be reviewed here.
(Application Form, Engineering Plans, Specifications, Calculations, Etc.)
CPP RG2 Evaporation pond permit responses January
1.36MB
2024.pdf
Upload only 1 PDF document (less than 250 MB). Multiple documents must be combined into one PDF file unless file is larger
than upload limit.
* By checking this box, I acknowledge that I understand the application will not be accepted for pre -review until the fee (if required) has
been received by the Non -Discharge Branch. Application fees must be submitted by check or money order and made payable to the
North Carolina Department of Environmental Quality (NCDEQ). I also confirm that the uploaded document is a single PDF with all parts
of the application in correct order (as specified by the application).
Mail payment to:
NCDEQ — Division of Water Resources
Attn: Non -Discharge Branch
1617 Mail Service Center
Raleigh, NC 27699-1617
Signature
C )l 1/111114p t'
Submission Date 1/12/2024

Carolina
Poultry
Power
January 11, 2024
Erick Saunders, Engineer
NCDEQ, Division of Water Resources
1617 Mail Service Center
Raleigh, NC 27699-16217
Subject: Application No. WQ0044259
Carolina Poultry Power RG2 - Wilson
Dear Mr. Saunders:
The information provided herein is based on our Teams Meeting from December 19, 2023. In
addition to the proposed beneficial uses of the reclaimed water listed on RWCU 06-16, CPP
plans to use reclaim water for some cooling and make-up water, which are covered under 02U
.0113 Permitting By Regulation (PBR). These water uses are shown on Drawing 1030, identified
below, are collected and routed back to the City of Wilson WTP via an oil/water separator.
• Make-up water (7 gpm)
• Cooling water (2 gpm to sample coolers; 2 gpm to pump coolers; 1 gpm to other)
CPP will meet the requirements of the PBR, including the development of a Spill Control Plan
to prevent unintended discharge of reclaim water.
Section
Application Form RWCU 06-16
D
1
Section II #3 has been updated to include all uses of reclaimed water. Added are
industrial process water makeup for the 3 gpm going to dilute the lime injection
system (evaporated from boiler stack). Please note, reclaim water is not to be used
for fire protection. The sprinklers and fire hydrants will be served by a separate
city water supply line.
2
Section II #4 has been updated to show that the estimated amount of reclaimed
water includes both the pond 223,676 gpd plus 4,320 gpd dilution water.
3
Section VII #2 has been updated to include utilization area 005 for the boiler stack.
[001 through 004 from the original submittal represent the four corners of the
pond.]

Mr. Erick Saunders
January 11, 2024
Should you have any questions regarding this submittal please contact me at 252-800-1969
(richCeastenergyllc.com) or Kim Melvin of Project Integration, Inc. at 864-414-3059.
Sincerely,
Rich Deming, Principal
Carolina Poultry Power, RG2 LLC
2

State of North Carolina
DWR
Department of Environmental Quality
Division of Water Resources
Division of Water Resources 15A NCAC 02U — RECLAIMED WATER SYSTEMS — CONJUNCTIVE UTILIZATION
FORM: RWCU 06-16
L CONTACT INFORMATION:
1. Applicant's name: Carolina Poultry Power RG2, LLC
Mailing address: 3730 North Main Street
City: Farmville State: NC Zip: 27828-
Telephone number: 2( 52) 253-3300 Email Address: richkeastenerevllc.com
2. Signature authority's name: Rich Deming (per 15A NCAC 2T .0106) Title: CEO
3. Consulting Engineer's name: Kim Melvin License Number: NC 025853 Firm: Project Integration, Inc.
Mailing address: 116 Hidden Hill Road
City: Spartanburg State: SC Zip: 29301-
Telephone number: [phone] Email Address: kmelvinA—pintegration.com
4. Consulting Soil Scientist's name: License Number: Firm:
Mailing address:
City: State: Zip: ---
Telephone number: (_) _- Email Address:
5. Consulting Agronomist's name: Firm:.
Mailing address:
City: State: Zip: -_
Telephone number: (_) _- Email Address:
IL USER INFORMATION
1. Reclaimed water user name(s): Carolina Poultry Power
User facility physical address: 3150 Stantonsburg Road SE
City: Wilson State: NC Zip: 27893- County: Wilson
2. Facility status: Proposed
3. What is the proposed beneficial use(s) of the reclaimed water in accordance with 15A NCAC 02U .0101(a)?
(Check all that apply)
❑ Irrigation (non food crop) ❑ Irrigation (food chain crops) ® Industrial process water make up
❑ Cooling towers ❑ Chiller/Boiler makeup ❑ Urinal/Toilet flushing (non-residential)
❑ Fire protection (non-residential)
® Other (specify): Utility boiler cooling water
4. Estimated amount of reclaimed water to be used: 227,996 gallons per day
5. Does the reclaimed water source facility already have a permit for generation of reclaimed water? ® Yes or ❑ No
✓ If Yes, list permit number: WO0018709
✓ If No, then the Reclaimed Water Generation application (FORM: RWG) must also be included in this package.
6. In accordance with 15A NCAC 02U .0501(a)(2) and (b)(2), how will the public and/or employees be notified about the use of
reclaimed water? Piping labels and plant signage will be used to notify the public and employees.
7. Specify the location within the application package where examples of notification materials can be found: Next page
FORM: RWCU 06-16 Page 1 of 7

III. UTILIZATION AREA SETBACKS (15A NCAC 02U .0701)
1. Provide the actual minimum distance in feet from the storage units and utilization areas to each item listed (distances greater
than 500 feet may be marked N/A):
Utilization Areas
Final Effluent Storage
Setback Parameter
Units
Required Actual
Required
Actual
Any private or public water supply source
100
>500
Any property line
50
200
Any well with exception of monitoring wells
100 >500
100
>500
Surface waters (streams — intermittent and perennial,
100 >500
50
>500
perennial waterbodies, and wetlands) classified as SA
Surface waters (streams — intermittent and perennial,
25 >500
50
>500
perennial waterbodies, and wetlands) not classified as SA
2. Do the utilization areas and storage units comply with all setbacks found in the river basin rules (15A NCAC 213 .0200)?
®Yes or❑No
✓ If no, list non -compliant setbacks:
3. Are any setback waivers required in order to comply with 15A NCAC 02U .0701? ❑ Yes or ® No
✓ If yes, have these waivers been written, notarized signed by all parties involved and recorded with the County Register
of Deeds? ❑ Yes or ❑ No
✓ If yes, has allon-Discharge Wastewater System Waiver (FORM: NDWSW) been included with this application package?
❑Yes or❑No
IV. DESIGN CRITERIA FOR DISTRIBUTION SYSTEMS (15A NCAC 02U .0403)
1. Fill in the table below to indicate the location in the plans and specifications where the following items can be located:
Distribution System Design Element
Plan Sheet
Specification Page
Number
Number
Labeling of valves, storage facilities, and outlets to warn the public or
employees that reclaimed water is not intended for drinking in
accordance with 15A NCAC 02U .0403 b
Identification of piping, valves, and outlets as reclaimed water
(i.e., color coding purple, labeling, taping, etc.) in accordance with 15A
NCAC 02U .0403 c a
Method of securing valves and outlets the permits operation by
authorized personnel only in accordance with 15A NCAC 02U .0403 d
Hose bibs locked for use by authorized personnel only in accordance
with 15A NCAC 02U .0403 Ue
a. Identification of existing underground distributions systems shall be incorporated within 10 feet of crossing any water
line or sanitary sewer line.
2. Will potable water be used to supplement the reclaimed water system? ❑ Yes or ® No
✓ If yes, what cross connection control measures will betaken in accordance with 15A NCAC 02U .0403(f)?
Plan Sheet Number Specification Page Number
✓ If yes, is documentation that the proposed cross -connection control measures have been approved by the Division of
Environmental Health's Public Water Supply Section included in this application package? ❑ Yes or ❑ No
3. Has each utilization area been equipped with a flow meter to accurately determine the volume of reclaimed water utilized?
❑Yes or❑No
FORM: RWCU 06-16 Page 2 of 7

V. DESIGN INFORMATION FOR EARTHEN STORAGE IMPOUNDMENTS: 15A NCAC 02U .0401
IF MORE THAN ONE IMPOUNDMENT, PROVIDE ADDITIONAL COPIES OF THIS PAGE AS NECESSARY.
1. Are there any earthen reclaimed water operational storage impoundments located at the utilization site(s)? ® Yes or ❑ No
✓ If no, then skip this Section V.
2. Storage Impoundment Coordinates (Decimal Degrees): Latitude: 35.6853' Longitude:-77.8963'
3. Do any impoundments include a discharge point (pipe, spillway, etc)? ❑ Yes or ® No
✓ If Yes, has the required NPDES permit been obtained to authorize the discharge of reclaimed water? ❑ Yes or ❑ No
➢ Provide the NPDES permit number , or the date when NPDES application was submitted:
4. Are subsurface drains present beneath or around the impoundment to control groundwater elevation? ❑ Yes or ® No
5. Is the impoundment designed to receive surface runoff? ❑ Yes or ® No
If yes, what is the drainage area? ft2
6. Is a liner provided with a hydraulic conductivity no greater than 1 X 10 -6 cm/s? ® Yes or ❑ No
✓ If No, has the Applicant provided data to show that the reclaimed water source is protective of the groundwater standard
for nitrates (10 mg/1)? ❑ Yes or ❑ No
7. What is the depth to bedrock from the earthen impoundment bottom elevation? >55 ft
✓ If the depth to bedrock is less than four feet, has the Applicant provided a liner with a hydraulic conductivity no greater
than 1 x 10-' cm/s? ECYes, ❑ No or ® N/A
Has the Applicant provided predictive calculations or modeling demonstrating that surface water
or groundwater standards will not be contravened? ❑ Yes or ❑ No
✓ If the earthen impoundment is excavated into bedrock, has the Applicant provided predictive calculations or modeling
demonstrating that surface water or groundwater standards will not be contravened? ❑ Yes, ❑ No or ® N/A
8. If the earthen impoundment is lined and the mean seasonal high water table is higher than the impoundment bottom elevation,
how will the liner be protected (e.g., bubbling, groundwater infiltration, etc.)? N/A
9. If applicable, provide the specification page references for the liner installation and testing requirements: N/A
10. If the earthen impoundment is located within the 100-year flood plain, has a minimum of two feet of protection (i.e., top of
embankment elevation to 100-year flood plain elevation) been provided? ® Yes or ❑ No
11. Provide the requested earthen impoundment design elements and dimensions:
Earthen Impoundment Design Elements
Earthen Impoundment Dimensions
Liner type:
❑ Cla
®Synthetic
Top of embankment elevation:
92.3 ft
® Other
I ❑ Unlined
Liner hydraulic conductivity:
gunite <<IXIOE-6 cm/s
Freeboard elevation:
90.3 ft
Hazard class:
Not Applicable
Toe of slope elevation:
88.4 ft
Designed freeboard:
2 ft
Impoundment bottom elevation:
88.4 ft
Total volume:
306,066 ft3
2,289,680
allons
Mean seasonal high water table depth:
85.3 ft
Effective volume:
140,657 ft3
11052,255
gallons
Embankment slope:
3 : 1
Effective storage time:
n/a days
Top of dam water surface area:
86,100 ft2
Plan Sheet Reference:
Appendix E
Freeboard elevation water surface area:
78,185 ft2
Specification Section:
Appendix E
Bottom of impoundment surface area:
71,040 ft2
FORM: RWCU 06-16 Page 3 of 7

FORM: RWCU 06-16 Page 4 of 7

VI. DESIGN INFORMATION FOR CONJUNCTIVE USE IRRIGATION SYSTEMS
1. Will reclaimed water be used for irrigation? ❑ Yes or ® No
✓ If no, then skip this Section.
2. The irrigation system is: ❑ existing ❑ proposed
3. The irrigation system is: Select
4. Does the irrigation area contain any subsurface drainage structures? ❑ Yes or ❑ No
✓ If yes, where does the drainage system discharge?
5. Provide the equipment information below for spray and/or drip systems:
Spray Utilization Design Element
Plan Sheet
Number
Specification
Page Number
Wetted area of nozzles
78,185 ft'
App D
SPEC-1
Nozzle capacity
1250 gpm
App D
SPEC-2
Nozzle manufacturer / model
BETE /
App D
SPEC-2
Drip Utilization Design Element
Plan Sheet
Number
Specification
Page Number
Wetted area of emitters
ft2
Emitter capacity
gpm
Emitter manufacturer / model
/
6. If applicable, provide the location of each design element in the specifications and engineering plans for irrigation dosing
systems:
Utilization Pump Tank
Plan Sheet
Number
Specification
Page Number
Internal dimensions (L x W x H or (p x H)
ft
ft
ft
Total volume
ft3
gallons
Dosing volume
ft3
gallons
Audible & visual alarms
Equipment to prevent utilization during rain events
FORM: RWCU 06-16 Page 5 of 7

VI. DESIGN INFORMATION FOR CONJUNCTIVE USE IRRIGATION SYSTEMS (Continued)
7. Provide the following information for each irrigation site:
Site
ID
Latitude a
Longitude a
Area
(ft)
Recommended
Precipiation Rate b
(in/hr)
Design
Precipitation
Rate b(in/hr)
Crop
Type
Waterbody
Stream
Index No.
Classification °
O , „
O , „
O , „
O , „
O , „
O , „
O , „
O , „
O , „
O , „
a. Level of accuracy? Select Method of measurement? Select Datum? Select
b. For seasonal loading rates, list appropriate months.
Instructions for determining the waterbody stream index number and its associated classification can be found at the following web address:
https://ncdenr. s3.amazonaws.com/s3 fs-public/Water%2OQualiiy/Aquifer%2OProtection/LAU/Agreements/W SCA%2008-13.pdf
VIL INFORMATION FOR OTHER CONJUNCTIVE UTILIZATION AREAS (other than irrigation)
1. Will reclaimed water be utilized for purposes other than irrigation? ® Yes or ❑ No If No, skip this Section.
2. Provide the following information for all other reclaimed water utilization sites (non -irrigation):
Site ID
Latitude a
Longitude a
Allowable Use
Waterbody/Stream Index No. b
Classification n
001
35°41'07"
-77°53'48"
Evap Pond
Hominy Swamp/27-86-8
C; Sw, NSW
002
35°41'10"
-77°53'49"
Evap Pond
Hominy Swamp/27-86-8
C; Sw, NSW
003
35°41'10"
-77°53'48"
Evap Pond
Hominy Swamp/27-86-8
C; Sw, NSW
004
35°41'07"
-77°53'47"
Evap Pond
Hominy Swamp/27-86-8
C; Sw, NSW
005
35°41'08"
-77°53'23"
Boiler Stack
Hominy Swamp/27-86-8
C; Sw, NSW
o , 11
o , „
o , 11
o , „
a. Level of accuracy? Select Method of measurement? Select Datum? Select
b. Instructions for determining the waterbody stream index number and its associated classification can be found at the following web address:
bgps://ncdenr.s3.amazonaws.com/s3fs-public/Water%2OQualily/Aquifer%2OProtection/LAU/Agreements/W SCA%2008-13.pdf
FORM: RWCU 06-16 Page 6 of 7

VIIL IRRIGATION OF FOOD CHAIN CROPS
1. Will the system be used to irrigate food chain crops? ❑ Yes or ® No
2. If Yes, please complete the flowchart below by checking the appropriate yes/no responses. If No, skip this Section.
Will the portion of the crop intended for
human consumption be peeled, skinned,
cooked, or thermally processed prior to
human consumption?
Yes
Type 1 reclaimed water is
allowed pursuant to (15A
NCAC 02U .0301(b)), for
direct or indirect contact
irrigation.
No
Will the irrigation activity result in the
direct contact of reclaimed water on
the portion of the crop intended for
human consumption (direct contact
irrigation)?
Yes
This activity is not allowed
without further study pursuant
to 15A NCAC 02U .1401(a)(5).
No
Type 2 reclaimed water is
allowed pursuant to
15A NCAC 02U .0301(a), for
indirect contact irrigation.
3. For food crop irrigation sites not owned by the reclaimed water supplier, has a Landowner Agreement been included in the
application package as outlined in Instruction I? ❑ Yes or ❑ No or ❑ N/A
4. What type of notification will be provided at the irrigation site(s) to inform the public about the use of reclaimed water in
accordance with 15A NCAC 02U .1401?
FORM: RWCU 06-16 Page 7 of 7

Professional Engineer's Certification: �j )
a� attest that this application for _ it��
has been reviewed by me and is accurate, complete
and consistent with the information supplied in the engineering plans, calculations, and all other supporting documentation to the best of
my knowledge. I further attest that to the best of my knowledge the proposed design has been prepared in accordance with this
application package and its instructions as well as all applicable regulations and statutes. Although other professionals may have
developed certain portions of this submittal package, inclusion of these materials under my signature and seal signifies that I have
reviewed this material and have judged it to be consistent with the proposed design. Note: In accordance with NC General Statutes
143-215.6A and 143-215.6B, any person who knowingly makes any false statement, representation, or certification in any application
package shall be guilty of a Class 2 misdemeanor, which may include a fine not to exceed $10,000 as well as civil penalties up to
$25,000 per violation.
North Carolina Professional Engineer's seal, signature, and date:
G A
/I/ /J41
Applicant's Certification (signing authority must be in compliance with 15A_NCAC 02T .0106):
1, Rich „Deming_ CEO
(signing authority name — PLEASE PRINT) (title)
attest that this application for _ _ . Carolina Poultry Power, RG2 _
(facility name)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that any discharge of wastewater from
this non -discharge system to surface waters or the land will result in an immediate enforcement action that may include civil penalties,
injunctive relief, and/or criminal prosecution. I will make no claim against the Division of Water Resources should a condition of this
permit be violated. I also understand that if all required parts of this application package are not completed and that if all required
supporting information and attachments are not included, this application package will be returned to me as incomplete. I further certify
that the applicant or any affiliate has not been convicted of an environmental crime, has not abandoned a wastewater facility without
proper closure, does not have an outstanding civil penalty where all appeals have been exhausted or abandoned, are compliant with any
active compliance schedule, and do not have any overdue annual fees under Rule 15A NCAC 02T .0105, Note: In accordance with NC
General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false statement, representation, or certification in
any application package shall be guilty of a Class 2 misdemeanor, which may include a fine not to exceed $10,000 as well as civil
penalties up to $25,000 per violation. 1 /11 /2024
Signature: Date:
FORM: RW CU 06-16 Page 8 of 7