NC0088749_Authorization to Construct_20120807

/VGo0ss*74y
Lissara Partners, LLC
A To C No. 088749AOI
Issued February 18, 2009
Engineer's Certification
1, John F. Phillips, P.E. , as a duly registered Professional Engineer in
the State of North Carolina, having been authorized to observe (periodically/vm*k4y/i 'e)
the construction of the modifications and improvements to the Lissara WWTP, located West of
Conrad Road in Forsyth County for Lissara Partners, LLC, hereby state that, to the best of my
abilities, due care and diligence was used in the observation of the following construction:
One (1) Van2
� -a{-)18,900 gallow equalization tank"neh with a 2 HI', 38 scfin flow
equalization blowerP, 95 gpm flow equalization pump; flow control splitter
box; three (3) 5 HP, 135 scfin main plant blowers; two (2) 20,000 gallon steel aeration
tanks; two (2) 12-ft square, 13 ft sidewater depth clarifiers with clarifier airlift pump and
scum pump; two (2) 8,100 gallon sludge tanks with supernatant airlift pump;
chlorinator/dechlorinator contact tank with two (2) tube tablet chlorine feeders and two
(2) tube tablet dechlorination feeders; effluent flow measurement box, flow measurement*
weir and ultrasonic effluent level sensor; 45 kW standby generator
blower building; and associated yard piping, electrical work and control systems in
conformity with the project plans, specifications, and other supporting data subsequently
filed and approved by the Department of Environment and Natural Resources.
* (natural gas -fired)
I certify that the construction of the above referenced project was observed to be built within
substantial compliance and intent of the approved plans and specifications.
We understand that the wastewater treatment plant flow limits of 0.054 MGD now apply.
Signature V- &4Registration No.
Date 877-20 2
10130
c
.�0�, ••CARo f
Send to: Construction Grants & Loans p�.•N ESSIpy.�'19S'•
DENR/DWQ
SEAL =
1633 Mail Service Center 10130
Raleigh, NC 27699-1633so
Note: The ATC incorrectly stated two 18,900 gallon ''�.,
The approved specifications indicatedPH� `''�, FE tanks, pp plans and
one 18,900 gallon FE tank with two 2 HP FE pumps. The
t h df f 1 d t t 1 1X
c
N C45
:o
� t
genera or was c ange rom propane ue e o na urn gas
once it was determined that natural gas piping could be AUG 0,8 2012
extended to the WWTP site.
wowdusFinwaseta.

4
DIEHL & PHILLIPS, P.A.
CONSULTING ENGINEERS
219 East Chatham Street
Cary, North Carolina 27511
Telephone [phone] -- Fax [phone]
TRANSMITTAL
August 7, 2012
TO: Construction Grants & Loans
DENR/DWQ
1633 Mail Service Center
Raleigh, NC 27699-1633
FROM: John F. Phillips, R.E.
RE: Engineer's Certification
A to C No. 088749A01
Lissara Partners, LLC
Lissara WWTP
Forsyth County
WILLIAM C. DIEHL., P.E.
JOHN F. PHILLIPS, P.E.
ALAN R. KEITH, P.E.
No. of
Copies
Description
Remarks
1
Engineer's Certification - Signed,
sealed, and dated 8-7-12
Note revisions on
Certification.
Enclosures
Cc: Mr. Lang Wilcox
Mr. Pete Ramey
RE n
%F�
AUG 0 8 20

NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue
Governor
Mr. Lang Wilcox
Lissara Partners, LLC
2631 Reynolda Road
Winston-Salem, North Carolina 27106
Dear Mr. Wilcox:
Coleen H. Sullins
Director
February 18, 2009
Dee Freeman
Secretary
SUBJECT: Authorization to Construct
A to C No. 088749A01
Lissara Partners, LLC
Lissara W WTP
Forsyth County
A letter of request for an Authorization to Construct was received September 5, 2008, by
the Division of Water Quality (Division), and final plans and specifications for the subject
project have been reviewed and found to be satisfactory. Authorization is hereby granted for the
construction of a new 0.054 MGD Wastewater Treatment Plant, with discharge of treated
wastewater into the Yadkin River in the Yadkin River Basin.
This authorization results in no increase in design or permitted capacity and is awarded
for the construction of the following:
Two (2) 18,900 gallon steel flow equalization tanks each with a 2 HP, 38 scfm flow
equalization blower and a 2 HP, 95 gpm flow equalization pump; flow control splitter
box; three (3) 5 HP, 135 scfm main plant blowers; two (2) 20,000 gallon steel aeration
tanks; two (2) 12-ft square, 13 ft sidewater depth clarifiers with clarifier airlift pump and
scum pump; two (2) 8,100 gallon sludge tanks with supernatant airlift pump;
chlorinator/dechlorinator contact tank with two (2) tube tablet chlorine feeders and two
(2) tube tablet dechlorination feeders; effluent flow measurement box, flow measurement
weir and ultrasonic effluent level sensor; 45 kW standby generator and propane fuel tank;
blower building; and associated yard piping, electrical work and control systems in
conformity with the project plans, specifications, and other supporting data subsequently
filed and approved by the Department of Environment and Natural Resources.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 One
Location: 512 N. Salisbury St. Raleigh, North Carolina 27604 NorthCarolina
Phone: [phone] FAX: [phone] Customer Service: 1-877-623-6748
Internet: www.ncwaterquality.org NIIAMIllif
An Equal Opportunity 1 Affirmative Action Employer

Mr. Lang Wilcox
February 18, 2009
Page 2
This Authorization to Construct is issued in accordance with Part III, Paragraph A of
NPDES Permit No. NCO088749 issued August 15, 2008, and shall be subject to revocation
unless the wastewater treatment facilities are constructed in accordance with the conditions and
limitations specified in Permit No. NC0088749.
The sludge generated from these treatment facilities must be disposed of in accordance
with G.S. 143-215.1 and in a manner approved by the Division.
In the event that the facilities fail to perform satisfactorily, including the creation of
nuisance conditions, the Permittee shall take immediate corrective action, including those as may
be required by this Division, such as the construction of additional or replacement wastewater
treatment or disposal facilities.
The Winston Salem Regional Office, telephone number [phone], shall be notified
at least forty-eight (48) hours in advance of operation of the installed facilities so that an on site
inspection can be made. Such notification to the regional supervisor shall be made during the
normal office hours from 8:00 a.m. until 5:00 p.m. on Monday through Friday, excluding State
Holidays.
Upon completion of construction and prior to operation of this permitted facility, a
certification must be received from a professional engineer certifying that the permitted facility
has been installed in accordance with the NPDES Permit, this Authorization to Construct and the
approved plans and specifications. Mail the Certification to: Construction Grants & Loans,
DWQ/DENR, 1633 Mail Service Center, Raleigh, NC 27699-1633.
Upon classification of the facility by the Certification Commission, the Permittee shall
employ a certified wastewater treatment plant operator to be in responsible charge (ORC) of the
wastewater treatment facilities. The operator must hold a certificate of the type and grade at
least equivalent to or greater than the classification assigned to the wastewater treatment
facilities by the Certification Commission.
The Permittee must also employ a certified back-up operator of the appropriate type and
grade to comply with the conditions of T15A:8G.0202. The ORC of the facility must visit each
Class I facility at least weekly and each Class II, III and IV facility at least daily, excluding
weekends and holidays, must properly manage the facility, must document daily operation and
maintenance of the facility, and must comply with all other conditions of T15A:8G.0202.
A copy of the approved plans and specifications shall be maintained on file by the
Permittee for the life of the facility.
During the construction of the proposed additions/modifications, the permittee shall
continue to properly maintain and operate the existing wastewater treatment facilities at all times,

Mr. Lang Wilcox
February 18, 2009
Page 3
and in such a manner, as necessary to comply with the effluent limits specified in the NPDES
Permit.
You are reminded that it is mandatory for the project to be constructed in accordance
with the North Carolina Sedimentation Pollution Control Act, and when applicable, the North
Carolina Dam Safety Act. In addition, the specifications must clearly state what the contractor's
responsibilities shall be in complying with these Acts.
Prior to entering into any contract(s) for construction, the recipient must have obtained all
applicable permits from the State.
Failure to abide by the requirements contained in this Authorization to Construct may
subject the Permittee to an enforcement action by the Division in accordance with North
Carolina General Statute 143-215.6A to 143-215.6C.
The issuance of this Authorization to Construct does not preclude the Permittee from
complying with any and all statutes, rules, regulations, or ordinances which may be imposed by
other government agencies (local, state, and federal) which have jurisdiction.
One (1) set of approved plans and specifications is being forwarded to you. If you have
any questions or need additional information, please contact Seth Robertson, P.E. at telephone
number [phone].
Sincerely,
Coleen H. Sullins
swc:sr
cc: John F. Phillips, P.E. — Diehl & Phillps, P.A., 219 E. Chatham Street, Cary, NC 27511
Forsyth County Health Department
Winston Salem Regional Office, Surface Water Protection
Technical Assistance and Certification Unit
Point Source Branch, NPDES Program
Daniel Blaisdell, P.E.
Steve Coffey, P.E.
ATC File No. 088749A0I