NC0086584_Permit Issuance_20050523

tNAT�c
Michael F. Easley, Governor
�F
I'p
0 G
State of North Carolina
c
William G. Ross, Jr., Secretary
Department of Environment and Natural Resources
YAlan
W. Klimek, P.E., Director
Division of Water Quality
Mr. Tim Johnson
Town of Belhaven
P.O. Box 220
Belhaven, North Carolina
Dear Mr. Johnson:
27810
May 23, 2005
Subject: Issuance of NPDES Permit
NCO086584
Town of Belhaven WTP
Beaufort County
Division personnel have reviewed and approved your application for renewal of the subject
permit. Accordingly, we are forwarding the attached NPDES discharge permit. This permit is issued
pursuant to the requirements of North Carolina General Statute 143-215.1 and the Memorandum of
Agreement between North Carolina and the U.S. Environmental Protection Agency dated May 9,1994 (or
as subsequently amended).
This final permit contains no significant changes from the draft you were sent on February 16, 2005.
If any parts, measurement frequencies or sampling requirements contained in this permit are
unacceptable to you, you have the right to an adjudicatory hearing upon written request within thirty
(30) days following receipt of this letter. This request must be in the form of a written petition,
conforming to Chapter 150B of the North Carolina General Statutes, and filed with the Office of
Administrative Hearings (6714 Mail Service Center, Raleigh, North Carolina 27699-6714). Unless such
demand is made, this decision shall be final and binding.
Please note that this permit is not transferable except after notice to the Division. The Division
may require modification or revocation and reissuance of the permit. This permit does not affect the
legal requirements to obtain other permits which may be required by the Division of Water Quality or
permits required by the Division of Land Resources, the Coastal Area Management Act or any other
Federal or Local governmental permit that may be required.
If you have any questions concerning this permit, please contact Toya Fields at telephone
number [phone], extension 551.
Sincerely,
ORIGINAL SIGNED BY
SUSAN A. INILSON
Alan W. Klimek, P.E.
cc: Central Files
Washington Regional Office/Surface Water Protection
NPDES Unit i
North Carolina Division of Water Quality [phone]
1617 Mail Service Center FAX [phone]
Raleigh, North Carolina 27699-1617 On the Internet at http://h2o.enr.state.nc.us/

Permit NCO086584 - ` .-
STATE OF NORTH CAROLINA
TOWN OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provisions of North Carolina General Statute 143-215.1, other lawful standards
and regulations promulgated and adopted by the North Carolina Water Quality Commission, and the
Federal.Water Pollution Control Act, as amended,
Town of Belhaven
is hereby authorized to discharge wastewater from a facility located at the
Belhaven WTP
662 Harbinger Road
Belhaven
Beaufort County
to receiving waters designated as an unnamed tributary to Pantego Creek in the Tar -Pamlico
River Basin in accordance with the discharge limitations, monitoring requirements, and other
conditions set forth in Parts I, II, III, and IV hereof.
This permit shall become effective July 1, 2005.
This permit and the authorization to discharge shall expire at midnight on November 30, 2009.
Signed this day May 23, 2005.
ORIGINAL SIGNED BY
SUSAN A. WILSON
Alan W. Klimek, P.E., Director
Division of Water Quality
By the Authority of the Environmental Management Commission

Permit NCO086584
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility, whether for operation or discharge are hereby revoked. As of
this permit issuance, any previously issued permit bearing this number is no longer effective. Therefore, the
exclusive authority to operate and discharge from this facility arises under the permit conditions, requirements,
terms, and provisions included herein.
Town of Belhaven is hereby authorized to: / p
Continue to operate an existing 0.22 MGD membrane filtration water treatment
plant. J oa$11 : �
TX
The facility is located at the Belhaven WTP, 662 Harbinger Road, Beaufort County,
and
2. Discharge reject water from a water treatment plant at the location specified
attached map into an unnamed tributary to Pantego Creek which is classifie
NSW waters in the Tar -Pamlico River Basin.
7
A& '5LO

3
2,
Discharge location
AR
all
Rpll� nvE'iYia. 4.
�.
Cedar
Wand: GU '-M.
ml
M
L
'Skmalm
pt
j
'Beffialk
Belhaven Water Treatment Plant — NCO086584 Facility
Location
USGS Quad Name: Pantego Lat.- 35'033'26"
Receiving S#,eaiK.UT- to Pantego Creek 76037'44"
Stream Class: SC -NSW Long.:
Subbasin: Tar Pamlico = 03 03 U North Not to SCALE

Rb
Permit NCO086584
A. (1). EFFLUENT LI ATIONS AND MONITORING REQUIREMENTS - FINAL
Upon commencement of the discharge and lasting until expiration, the Permittee is authorized to discharge from
outfall serial number 001— embrane process reject. Such discharges shall be limited and monitored by the
Pemuttee as specified below:
EFFLUENT
CHARACTERISTICS
LIMITS
MONITORING REQUIREMENTS
Monthly
Average
Daily
Maximum
Measurement
Frequency
Sample Type
Sample
Location'
Flow
0.22 MGD
Continuous
Recording
E
Temperature
Monthly
Grab
E, U, D
Salinity
Monthly
Grab
E, U, D
Conductivity
Monthly
Grab
E, U, D
Ii2
Monthly
Grab
E, U, D
Dissolved Oxygen
Monthly
Grab
E, U, D
Total Dissolved Solids
Monthly
Grab
E
Total Residual Chlorine3
28.0 µ /L
Monthly
Grab
E
Total Copper
Month'
Grab
E
Total Chloride
Monthly
Grab
E
Total Iron
Monthly
Grab
E
Total Fluoride
Monthly
Grab
E
Total Nickel
8.3 µ /L
Monthly
Grab
E
Total Zinc
Month'y
Grab
E
Ammonia Nitrogen
Monthly
Grab
E
Total Nitrogen (TN)
Monthly
Grab
E
Total Phosphorus (TP)
Month'V
Grab
E
Whole Effluent Toxicity4
Quarterly
Grab
E
Notes:
1 Samples shall be collected at some point after all treatment units and prior to discharge, unless otherwise
noted. E= effluent, U= upstream of discharge location, D= downstream of discharge location.
2 The pH shall not be less than 6.8 standard units nor greater than 8.5 standard units. L 56 V L
3 Total Residual Chlorine monitoring is only required if chlorine is added. 0 �
4 Acute Toxicity Monitoring P/F (Mysidopsis Bahia) @ 90%, during the months of January, April, July, and
October. See Part I, Condition A. (2.). Further studies will be required to determine the cause of toxicity, if
any. The collection of samples shall coincide with the sampling of other parameters.
All samples collected shall be of a representative discharge. , p
There shall be no discharge of floating solids or ui fi oain other than trace amounts.

Permit NC0086584
A. (2). ACUTE TOXICITY PASS/FAIL MONITORING (Quarterly)
The permittee shall conduct acute toxicity tests on a quarterly basis using protocols defined in the
North Carolina Procedure Document entitled "Pass/Fail Methodology For Determining Acute Toxicity
En A Single Effluent Concentration" (Revised July,1992 or subsequent versions). The monitoring shall
be performed as a Mysid shrimp (Mysidopsis Bahia) 24-hour static test. The effluent concentration at
which there may be at no time significant acute mortality is 90% (defined as treatment two in the
procedure document). Effluent samples for self -monitoring purposes must be obtained during
representative effluent discharge below all waste treatment. The tests will be performed during the
months of January, April, July & October.
All toxicity testing results required as part of this permit condition will be entered on the Effluent
Discharge Monitoring Form (MR-1) for the month in which it was performed, using the parameter
code TGE3E. Additionally, DWQ Form AT-2 (original) is to be sent to the following address:
Attention: North Carolina Division of Water Quality
Environmental Sciences Section
1621 Mail Service Center
Raleigh, N.C. 27699-1621
Test data shall be complete and accurate and include all supporting chemical/physical measurements
performed in association with the toxicity tests, as well as all dose/response data. Total residual
chlorine of the effluent toxicity sample must be measured and reported if chlorine is employed for
disinfection of the waste stream.
Should there be no discharge of flow from the facility during a month in which tonicity monitoring is
required, the permittee will complete the information located at the top of the aquatic toxicity (AT) test
form indicating the facility name, permit number, pipe number, county, and the month/year of the
report with the notation of "No Flow" in the comment area of the form. The report shall be submitted
to the Environmental Sciences Branch at the address cited above.
Should the permittee fail to monitor during a month in which toxicity monitoring is required, then
monthly monitoring will begin immediately until such time that a single test is passed. Upon passing,
this monthly test requirement will revert to quarterly in the months specified above.
Should any test data from either these monitoring requirements or tests performed by the North
Carolina Division of Water Quality indicate potential impacts to the receiving stream, this permit may
be re -opened and modified to include alternate monitoring requirements or limits.
NOTE: Failure to achieve test conditions as specified in the cited document, such as minimum control
organism survival and appropriate environmental controls, shall constitute an invalid test and will
require immediate follow-up testing to be completed no later than the last day of the month following
the month of the initial monitoring.

BEAUFORT COUNTY
NORTH CAROLINA
AFFIDAVIT OF PUBLICATION
Before the undersigned, a Notary Public of said County
and State, duly commissioned, qualified and authorized FUli NOTICE
by law to administer oaths, personally appeared Brenda STATE OF NORTH NA
ENVIRONMENTALMANAGEMENT
Foster, who being first duly sworn, deposes and says that comMISSIONINPDES UNIT
1617 MAIL SERVICE CENTER
she is the Classified Manager of the Washington Daily RALEIGH, NC 2.7699-1617
a published, NOTIFICATION OF INTENT TO ISSUE A
News, a newsp
aper, per, p ed, issued and entered as NPDES WASTEWATER PERMIT
second class mail in Washington, NC in said county ' and On the basis of thorough staff review and ap l
�plication of NC General Statute 143.21, i
state; that she is authorized to make this affidavit and Public law 92-500 and other lawful standards ;
and regulations, the North Carolina
swom statement; that the notice or other legal Environmental Management Commission
Po
advertisement, a true copy of which is attached hereto, Dscharge Elimi ationoss to issue aonal Systemlant (NPDES)
wastewater discharge permit to the
was published in the Washington Daily News on the person(s) listed below effective 45 days from
following dates: the publish date of this notice.
Written comments regarding the proposed
/� permit will be accepted until 30 days after
/, C�� �� the publish date of this notice. All considered
s
( received prior to that date are considered
in the final determinations regarding the pro-
posed permit. The Director of the NC
Division of Water Quality may decide to hold
a public meeting for the proposed permit
should the Division receive a significant de. .
gree of public interest.
Copies of the draft permit and other support -
and that the said newspaper in which such notice, paper, ing information on file used to determine
document, or legal advertisement was published was conditions present in the draft permit are
p > at available upon request and payment of the
the time of each and every publication, a newspaper costs of reproduction. Mail comments and/or
requests for information to the NC.
meeting all of the requirements and qualifications of Division of Water Quality at the above ad-
dress or call the Point Source Branch at
Section I-597 of the General Statutes of North Carolina [phone], extension 520. Please tn-
ualified newspaper within the meaning of in a the NPDES permit number (attached)
and was a
q gape g In any communication. Interested persons
lity
Section I-597 of the General Statutes of North Carolina. may also visit the Division of WaleigN, NC
at 512 N. Salisbury Street, Ralei tJ, NC
27604-1148 between the hours of 8:00 a.m.
Tluso� day Of 2W and :: p.m. to review information on file.
The Toww n of Belhaven (P.O. Box 220, Bel-
haven, NC 27810) has applied for renewal of
(.� NPDES permit NC0086594 for the Belhaven
WTP #2 in Beaufort County. This permitted
facility discharges 0.22 MGD of treated
wastewater to an unnamed tributary to Pan -
(Signature of person making affidavit) tego Creek in the tar Pamlico River basin.
currently total residual chlorine and nickel
are water quality limited. This discharge may
Sworn to and subscribed before me, a No Public, affect future allocations in this portion of the
Tar Pamlico River Basin.
/ 4-7 1 tictbis� 15_ day of 20�LL. -
(Notary Public)
My commission expires ra a y 10 0
1
I
Publication cost S ' / ) paid, .�:I. �`"`"

NCDENR/DWQ
FACT SHEET FOR NPDES PERMIT DEVELOPMENT
Town of Belhaven
NCO086584
Facility Information
(1.) Facili Name.
Town of Belhaven WTP
(2.) Permitted Flow (MGD):
0.22
(6.) County:
Beaufort
(3.) Facility Class:
I
(7.) Regional Office
Washm tvp
(4.) Pretreatment Program
(5.) Permit Status:
i N/A
Existing
(8.) USGS ToPo Q uad
32 ES>r
(9.) USGS Quad Name:
Pante o
Stream Characteristics
G.) Receiving Stream:
(2.) Sub basin:
UT to Pantego Creek
03-03-07
(7.) Drainage Area (mi2):
(8.) Summer 7Q10 (cfs):
0
(3.) Stream Index Number.
(9.) Winter 7Q10 (cfs):
0
K) Stream Classification:
Se-NwW- C. S
(lOJ 30Q2 (cfs):
0
(5.)303(d) Status:
Not listed
(11.) Average Flow (cfs):
0
(12.) IWC %:
100
1.0 Proposed Changes Incorporated into Permit Renewal
Remove limit and monitoring requirements for arsenic, cadmium, chromium, cyanide, lead,
mercury, settleable solids and selenium due to lack of reasonable potential for these pollutants to
cause an exceedance of water quality standards.
Remove monitoring requirements for TSS, turbidity, beryllium, and silver based on
requirements of new membrane permitting strategy.
Add monthly effluent monitoring requirements for temperature, salinity, conductivity, DO,
TDS, chloride, NH3, and TN based on new permitting strategy for membrane water treatment
plants.
2.0 Summary
This is a renewal for an existing membrane filtration water plant for the Town of
Belhaven. This permit was first issued in 1999 and a number of limits and monitoring
requirements were included based on expected effluent characteristics. For this renewal the
permit will be further tailored based on the results of those tests, as well as to align with the
current membrane WTP strategy.
3.0 Compliance Summary
DMR Data Review
DMRs were reviewed for the period of January 2003 through November 2004. It appears that
data was only submitted for the limited parameters. Therefore there is no information on
parameters with only monitoring requirements (beryllium, copper, salinity, silver, zinc, fluoride,
iron, TRC and instream dissolved oxygen). Limited data is available for pH monitoring. No
violations were ever issued for these omissions.

NPDES Permit Fact Sheet — 2/9/2005
Page 2
Town of Belhaven WTP
NCO086584
Reported values for arsenic, cadmium, cyanide, lead, settleable solids, and selenium were all
below their respective detection levels; therefore the limits and monitoring requirements for
those parameters will be removed.
RPA Analysis
RPAs were performed for chromium, mercury and nickel. The limit and monitoring
requirements for mercury will be removed, as there is no reasonable potential for the facility's
discharge to cause a water quality violation for this parameter.
The limit and monitoring requirement for chromium will be removed. An initial RPA performed
for this parameter using 16 data points and only 3 detects yielded a maximum predicted value of
25.8 µg/L. This is above the allowable limit of 20 µg/L. However, it appears that the actual
maximum reported value is only 10 µg/L and in this case the high number of values below the
detection level had an effect on the dataset. Rather than taking these values as 1h BDL (2.5 µg/L),
the DL was used (5 µg/L). This yielded a maximum predicted concentration of 14.6 µg/L, which
is below the allowable concentration. Additionally, according to the new permitting strategy for
membrane water treatment plants, chromium is not a parameter of concern.
Three of the 16 nickel measurements showed values at or above the detection level. Two were at
10 µg/L, once was at 12 jig/L. Although nickel is not listed as a parameter of concern in the
current permitting strategy, it appears that it may be an issue at this facility. Therefore the limit
and monitoring requirement will remain in this permit.
WET Test Results
The Belhaven WTP has a quarterly acute monitoring requirement using an effluent concentration
of 90% and mysid shrimp. The first tests were taken in 2004. The WTP passed 3 of the first 4
tests conducted. Although they failed in October 2004, they passed the test taken the following
month.
Correspondence File Review/Compliance History
Correspondence files were reviewed for the period of 2002-2004. Although it appears that the
facility did not monitor for parameters no limited in the permit, they did not receive violations
for this.
There was one WET failure in October 2004, however the test is monitoring only so it does not
constitute a permit violation.
There were 3 violations of the nickel limit: 10 µg/L in October 2003,12 µg/L in February 2004,
and 10 µg/L in June 2004.
4.0 Proposed Schedule for Permit Issuance
Draft Permit to Public Notice: Feb 16, 2005
Permit Scheduled to Issue: April 1, 2005

' NPDES Permit Fact Sheet — 2/9/2005 Town of Belhaven WTP
Page 3 NC0086584
5.0 State Contact Information
If you have any questions on any of the above information or on the attached permit, please
contact Toya Fields at [phone], extension 551.
Copies of the following are attached to provide further information on the permit development:
• Draft permit
• RPA Summary
• Membrane WTP permitting strategy
Regional Office Comments:
Regional Recommendation by:
Signature Date

REASONABLE POTENTIAL ANALYSIS
Belhaven WTP
NCO086584
Time Period
0
Ow (MGD)
0.22
701oS (cls)
0
701OW(cis)
0
3OQ2 (cis)
0
Avg. Stream Flow, QA (ds)
0
RecWng Stream UT to Pantego Creek
WWTP Class I
lWC (%) Q 7010S 100
7Q1OW 100
Q 30Q2 NIA
Q CA NIA
Stream Class SC -NSW
Outfall 001
Qw = 0.22 MGD
STANDARDS &
PARAMETER
TYPE
CRITERIA (2)
PQL
Units
REASONABLE POTENTIAL RESULTS
RECOMMENDED ACTION
(1)
NC Was/ %FAY/
a #Vst AkxPled CW AfJow+LlrCw
Chronic Acids
Acute: N/A
Chromium
NC
20
ugIL
16 3
25.8
_ _ _ _ _ _
------hronic: 20
_ _ _ _
see Chromksm 2 below. -------------------
Acute: N/A
less than values (c.5.0 ugll) are adding additional variation
Chromium2
NC
20.0
uglL
is 16
14.6
to the dataset. If all the_ND_s are assumed to be Just below
_
_ _ _ _
Chronic 20
the OL (5 ug/L instead of 25) this decreases the variance.
Max predicted < allowable. remove ftft and monitortng.
Acute: N/A
Mercury
NC
25
0.2
ng/L
16 11
16.7
_
-------
Chron�: 2_5
remove limit. monitoring requireinerst
Acute: 75
-- - -
Nickel
NC
a 75
ug/L
is 3
22.1
were actually only 3 detects. Two were right at the D
------
_ _ _
Chronic --I -—
_ _
(SOug/L) and one was just above (12 uglL)
Acute: N/A
—
-- ® Type
Chronic:
_^ — - - -- -—_---_—_— -
Acute: N/A
0 0
N/A
_____
Chronic rror ® Type -- --- — — --- - ----- - — ---
Acute: NIA
0 0
N/A
________
Chronic: Error ® Type
— - — — ---- - — — - --^--
Acute: N/A
0 0
N/A
Chronic: Error ®Type
---------------------------
Acute: NIA
0 0
WA
_ _
Chronic: Error�Type
_ _— ——.^_—.—_—_—_—_—_—•—_—_^_^
Acute: WA
0 0
WA-
— —
Chronk:: error � Type --------------------------
Acute: WA
0 0
WA
_ _ _
Chronk : rror ®Type
— — --- -------------_—_^----
Acute: WA
0 0
WA__
Chronic: Error®Type
Acute: NIA
0 0
WA
_ _ __
�Chronlc: error C� Typo.
-- — ---------------------------
Acute: WA
0 0
WA
___
Chronic: rrorC�-
_ — - —
Acute: WA -
0 0
WA
---------
Legend: " Freshwater Discharge
C = Carrxnogenk
NC = Norrcarch7ogenk
A = AssUmfic
$ON rpa.xls, rpa
218R005

f lapor
Dr. Cltarle9 O. 38oprtte
Tobin Alanager
Eim Al. 3folpleon
Toinn (Clerk
:Marie 3f. k(banl8, CAC
Town of
e5labIi511 1899
Charles H. Weaver, Jr.
NC DENR/Water Quality/NPDES Unit
1617 Mail Service Center
Raleigh, NC 27699-1617
etb ab erg
Tobm Council
Ororge R. C-bron, 3r., ttlapor Vm-Trm
Oilbert 38aher
CP]ltl is B. �patl
-IaairS 16. j¢tabgeB
Kinba (Z. Wilkergon
The Town of Belhaven would like to request renewal of NPDES Permit
NC0086584.
At this time no changes have occurred that would change the character of
the discharge.
Sincerely, �
Garland S. Grant, III
Town of Belhaven / 2Uj - D L4
Wgit Our lVeWite
bttp://Wbrtn.belllab ennr.ug
Yost ®ffire 9Box 220, jDelbaben, -Qorth Carolina 27SIO 0 [phone] • 7fax [phone]

: Mapor
jar. 0arle8 O. 1Bopeue
Tobin I6lanager
luinl A. 3101jnoon
Town Cirrh
tflarie 3. 4bamo, CAC
Town Of 6 �b¢YbAbETC
Town Council
George R. ebron, 3fr., : ftapor pro-Tem
evahli8p 1899 Albert 36aker
Cpathia In. I)ratb
3faniN j9. j)O!X g
Kinba C. Vilkeroon
Mr. Charles H. Weaver, Jr.
NC DENR/Water Quality/NPDES Unit
The Water Treatment Facility located at 662 Harbinger Rd. Belhaven NC.
Discharges only a concentrate of water and minerals; which is a byproduct
of the membrane filtration process. The concentrate water then flows down
an unknown tributary, approximately 1.5 miles then enters Pantego Creek.
Sincere)
Garland S. Grant, Ill
Town of Belhaven
Visit Our ]Veb5ite
lj ttp://mtntu.b rib ab ennt.ug
j3o.5t Office 35ox 220, Jftlbaben, -Qortb Carolina 27610 0 [phone] 0 -fax [phone]

Mapor
&. tbarles 0. JBopette
Eabtn Manager
Tim A. 3rorynsan
Tolun (fleck
Aitrie 3. 2Dams, tCOC
Tobin of
e0tablisll IS99
JB Ctb ab en
Charles H. Weaver, Jr.
NC DENR/Water Quality/NPDES Unit
Tolun Council
Oeorge R. ebron, -Tr., }napar Pro-Eem
21ltert JBakrr
Cpnthia A. death
ja1ne8 JB. 300bge5
Yinba C. Wilkerson
The Town of Belhaven operates a membrane filtration groundwater
Treatment facility in beaufort county. There are three wells that supply
Raw water to our plant. Well 92 is out of service for repairs.
Each well draws water from the Yorktown Aquifer. Groundwater
enters the plant where it is treated with 93% sulfuric acid to lower pH
to 6.5-SU. This converts the sulfides to carbonates.
Scale inhibitor is also injected it helps keep scale and silica from building
on the membrane surfaces.
The name of this chemical is Hypersperse MDC 700.
A total of two skids treat the in coming feed water. Each skid will produce
150 gpm. of Permeate and 50 gpm, of Concentrate (wastewater).
The total wastewater produced from both skids is 1.00 gpm.
A pH of 7.0 standard units is the average of the Concentrate going to
waste. The Permeate leaves the skids at a rate of 150 gpm. per skid
and enters a aerator where the converted sulfides are vented to the
atmosphere. Leaving the aerator the Permeate enters a final treatment stage
where Sodium Hydroxide 25% and Sodium Hypochlorite 12.5% are
injected. In respective order pH is raised to 7.6 to7.8 standard units
and a disinfectant is added to a total of 1.5 ppm. This drinking water
then enters a 300,000 gallon holding tank to meet the chlorine demand
then is pumped to the Town of Belhaven for consumption.
No facility changes are seen in the next five years.
Sincerelyr
Garland S. Grant II
Town of Belhaven a
'visit Our lVeUite
bttp://WWlp.belbab enut.u5
Post (Office 3Box 220, j8elhaben, Pord) Carolina 27810 0 [phone] 0 9fax [phone]

x...
S
i
8 7 g 5
4 3 2 1 1 1.
EMISIONS
LTR DESCRIPTION DATE
SEE SHEET T FOR REMISION
TRAI
HOA ON CONCEC ATE PERM
D AL
HMI
-- --- ! --l-i i -- -- -- -- -- -- --- - i -- -- ----- --
HFRI
!
DI DO DI DI � +� AI PLC
I I I I I -- --- I---- -- I--- -- -- PLC
I I I I I I I
I I I I DPI � I i
I I I j I I I
I I I I I I I
I I
I I I I I I i
I I I I
PI I I (�
I I I I i I
I I I I I
�TRAIN
CROSSOVER l CE
C I C J_ I I 5—WAY VALVE I 1 OND. TRAIN A
I NFM 1-1 4P580
DEGASIFIER
PI pc,L S i PI I L M 1 _ SHEET 5 C
I rsv
CV-07
M I sv
FROM I
CARTRIDGE FILTER(S)NFM 1-2 FILTER(S) ® �SST31610 NFM 2-1 I PERMEATE
CLEANING RETURN
SHEET 2 C/—Oq. BFV-16
7 sv
BP-01 MEASUREMENT
SDI NFM 1-3
NFM 2-2 \ II
.BOOST, (Fffl
PUMP sv lYJ
_ �
NFM 1-4 TRAIN A REJECT
M 1" 2" LY-08A BFV-21A 21/2PYC8D
316 SS10
SHEET 5
BFV-19A _ O SST PVC CONCENTRATE
B CLEANING SUPPLY/RETURN 4" PVC 80 B
SHEET 8 BFV-20A
2"
CLEANING CONNECTION NF SECTION
(�I�-) REMOVABLE (NF-01)
SPOOL
4PVC60
4PVC80
CLEANING SUPPLY/RE
SHEET 8
NF TRAIN A
MEMBRANE SYSTEMS
Immown"TalmTNO
ATNNI8 AND DATA R AP ARE
OMN 13Y AWD ig Rn• MaFdBRME T!I• lnt�prtlt�tl 9Clutlwl� ComOany"T8 THAT NO +�N ��O' tan, oxTae
ug WALL BE MAK OF Ttff SAME ENM-T TOWN OF BELHAVEN
To FACIlfATE Tlff MSTAl A110N, YNNTFNANCE
FUMEM er°SAMM PMTF.'DDp BEAUFORT COUNTY, NORTH CAROLINA A
i 02M1414 WATER TREATMENT SYSTEM -IMPROVEMENTS
_ N0' NANOFILTRATION (NF) SYSTEM
DUlM Br LEC' DM 2/21/02 PIPING AND INSTRUMENTATION DIAGRAM
aM REV
SEASIDE ,UTILITIES nai. D BEL5680 p
RALEIGH, NORTH CAROLINA nra va Barg
SCAM: NONE HST,S®80C BHEBT 3 OF B
8 7 6 5 4 3 2 1 5/20/03

cl
0
WELL WATER
7
BYPASS
BLEND FILTERS
STATIC MIXER
A B
SULFURIC ACID "
FEED SYSTEM
SCALE INHIBITOR
FEED SYSTEM
PROCESS DATA
Z
VFD
M
5
TRAIN
CROSSOVERS
111111
SHEET 2
CLEANING
VFD
SUPPLY/
RETURN
M
�
HIGH PRESSURE
CARTRIDGE PUMPS
FILTERS
8
►.I
PROCESS STREAMS
1O
20
3O
®
SO
0©2
©3
Gig
Ole
®
lelg
Pg1
®
®3
®
®5
FLOW RATE, GPM
447
47.2
47.2
400
200
200
200
200
111
111
89
89
39
39
150
150
347
50
50
347
347
160
160
160
PRESSURE, PSIG
50
50
45
5b
45
45
231
231
15
15
171
171
15
15
15
15
15
91
91
15
►
ATM
50
45
CONCENTRATION, MG/L AS IONS
760
76
760
760
760
760
760
760
71
71
1632
1632
187
187
101
t0i
193
2761
2761
193
193
NA
NA
NA
CHEMICAL TREATMENT
AO
BQ
©
DO
EO
FO
FLOW RATE,-GPH
1.2
2.6
0.8
0.6
r
0.7
PUMP.CAPACITY, GPH
2.8
2.8
2.8
2.8
2.8
2.8
DOSAGE, MG/L
35
5
2
10
10
CONCENTRATION, % W/V
93
10
12.5
19
pl.
S.G. (APPROX.)
1.9
1
1-
1
7
6
i�
I
*ENGINEERS TO SPECIFY
4
3
SEASIDE UTILITIES
RALEIGH, NORTH CAROLINA-
3
2
1
TRAIN A c
REJECT
s �a I.Ji45+�
SHEET 2
CLEANING SUPPLY/
RETURN
s
7 SHEET 2
4
TO
DEGASIFIER
= PERMEATE TO
rn CLEANING TANK
M' FILL
N
B
TRAIN B
REJECT
Tw43
— 9 SHEET 2
CLEANING SUPPLY
RETURN
MEMBRANE SYSTEMS
NIN, SPEgFlG110N5 AND DATAC b R P 0 R a T I o
s PRNT ARE FURNISIkD BY Alb Th. Int.
I INC PROPERTY OF 1A:30UXE sw eimo, prebd soWklen. Cempeny
ACCWM WAMVM THAT NO
MEMMsrN1A�M MMUMM TOWN OF BELHAVEN
24 ' SAO PMTIWE F'Q"""�"T "� BEAUFORT COUNTY, NORTH CAROLINA A
�
02M1414 WATER TREATMENT SYSTEM IMPROVEMENTS
NANOFILTRATION (NF) SYSTEM
LEC VAT' 8/8/02 PROCESS FLOW DIAGRAM
nm 5D BEL5671 :7A
m awn
BCALS: NONE BEL5071A SHEET i OF 2
2 1 1 1/7/03

NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Michael F. Easley, Governor William G. Ross, Jr., Secretary
Alan W. Klimek, P.E., Director
November 8, 2004
[��I;yrtyt�.Itau�+l
Mr. Tom Johnson
Town of Belhaven
301 East Main Street
Belhaven, North Carolina 27810
Subject: Notice of Violation
Failure to Submit Permit Renewal Application
NPDES Permit NCO086584
Belhaven WTP
Beaufort County
Dear Mr. Johnson:
The subject permit expires on November 30, 2004. North Carolina Administrative Code (15A NCAC 2H.0105(e))
requires that an application for permit renewal be filed at least 180 days prior to expiration of the current permit. To
satisfy this requirement, your renewal package should have been sent to the Division postmarked no later than June 3,
2004.
The Division has not received a renewal request for the subject permit. This is a violation of your permit at Part It.
B. 10., which states "Any permittee that has not requested renewal at least 180 days prior to expiration... will subject the
permittee to enforcement procedures as provided in NCGS 143-215.6 and 33 USC 1251 et. seq.".
In order to prevent an assessment of civil penalties you must submit a completed permit application (see enclosed
forms). Submit the completed application package to the address listed at the bottom of this page. If the Division receives
no response by November 22, 2004, enforcement action will proceed against the Town of Belhaven.
Use the enclosed checklist to complete your renewal package. The checklist identifies the items you must submit
with the permit renewal application. if all wastewater discharge from your facility has ceased and you wish to rescind this
permit, contact me at the address or telephone number listed below.
Sincerely,
Charles H. Weaver, Jr.
Point Source Branch
cc: Central Files
Washington Regional Office / Roger Thorpe
NPDFS File
1617 Mail Service Center, Raleigh, North Carolina 27699.1617 One
512 North Salisbury Street, Raleigh, North Carolina 27604 NorthCarohna
Phone:[phone],extension511/FAX[phone]/[e-mail] Naturally
f
An Equal Opportunity/AffirmativeAction Employer -50%Recycled/l0%Post Consumer Paper

6- ' 4 V _l
NPDES Permit NCO086584
Belhaven WTP
The following items are REQUIRED for all renewal packages:
❑ A cover letter requesting renewal of the permit and documenting . any changes at the
facility since issuance of the last permit. Submit one signed original and two copies.
❑ The completed application form (copy attached), signed by the permittee or an Authorized
Representative. Submit one signed original and two copies.
❑ If an Authorized Representative (such as a consulting engineer or environmental
consultant) prepares the renewal package, submit written documentation showing the
authority delegated to any such Authorized Representative (see Part II.B.11.b of the
existing NPDES permit).
❑ A narrative description of the sludge management plan for the facility. Describe how
sludge (or other solids) generated during wastewater treatment are handled and disposed.
If your facility has no such plan (or the permitted facility does not generate any solids),
explain this in writing. Submit one signed original and two copies.
PLEASE NOTE:
Due to a change in fees effective January 1, 1999, there is no renewal fee required with
your application package.
Send the completed renewal package to:
Charles H. Weaver, Jr.
NJ" "FN1? I W�+.+.- n.,.,if;.., / XT"T%WC' TT-21. T
SENDER:
■Complete Items 1 and/or 2 for additional services.
•Complete Items 3, 4a, and 4b.
■ Print your name and address on the reverse of this form so that we can return this
card to you.
■ Attach this form to the front of the mailplece, or on the back if space does not
permit.
■wdte'Retum Receipt Requested' on the mailpiece below the article number.
■The Return Receipt will show to whom the article was delivered and the date
delivered.
3. Article Addressed to:
Tim Johnson
Town of Belhaven
301 EAST MAIN STREET
BELHAVEN NC 27810
5. M
y (Pri rT�b
6. SI re: sse gen
PS Form 3811, kC9ber 1994
I also wish to receive the
following services (for an
extra fee):
ai
1. ❑ Addressee's Address
2. ❑ Restricted Delivery
W
Consult postmaster for fee.
m
7003 1010 0000
4620 1056"
4b. Service Type
❑ Registered
❑ Certified
m
❑ Express Mail
❑ Insured
❑ Retum Receipt for Merdmcrise ❑ COD
7. Date of Delivery
0
pig
O
8. Addressee's Ad re (only
ff requested
and fee is paid)
W