NC0027987_Rescission_20120821

f I
K600 37
Vulcun
Materials Company
August 21, 2012
Ms. Maureen Kinney
North Carolina Division of Water Quality
1601 Mail Service Center
Raleigh,NC 27699-1601
RE: New Contact Information
Vulcan Materials Company, LP
Facilities holding Water Permits in NC
Dear Ms. Kinney:
We have made some personnel changes within Vulcan Materials Company,LP. Please
update your records to indicate:
Water Permit Company Official Contact:
Hal Cox,Vice President
Vulcan Materials Company,LP
4401 N. Patterson Ave.
Winston Salem,NC 27105
Office(336) 767-4600
Fax [phone]
Email: [e-mail]
Water Permit Invoice and Technical Contact:
Tony Johnson,Environmental Engineer
Vulcan Materials Company, LP
11020 David Taylor Dr Suite 105
Charlotte,NC 28262
Office [phone]
Fax [phone]
Email:[e-mail]
Please let me know if you have any questions.
Sincerely,
172
ony J nson
CHARLOTTE REGIONAL OFFICE•VULCAN CONSTRUCTION MATERIALS,LP
11020 DAVID TAYLOR DRIVE 4105•CHARLOTTE,NC 28262•TELEPHONE [phone]•FAX [phone]

Kinney, Maureen
From: Johnson, Tony(MED/NC) [[e-mail]]
Sent: Tuesday, August 21, 2012 11:00 AM
To: Kinney, Maureen
Subject: Vulcan Stoneville Quarry
Attachments: Water Permit Contact Updates 8.21.12.doc.pdf
Good morning Ms. Kinney,
I received your voice mail, thank you for your call. To answer your questions about Stoneville Quarry, please
suspend monitoring requirements for at least another 5 years.
Please see attached letter with new contact information. P C. S F2-1 I jZ O
Thanks again for your help with our water permit, please let me know if you need anything else.
Tony Johnson
Environmental Engineer
Vulcan Materials Company
11020 David Taylor Dr Suite 105
Charlotte, NC 28262
Office [phone]
Cell [phone]
Fax [phone]
i

O�OFWATF,q�G
Michael F.Easley,Governor
(j William G.Ross Jr.,Secretary
North Carolina Department of Environment and Natural Resources
—!
0 Coleen H.Sullins,Director
Division of Water Quality
July 12,2007
Mr.Tim Knopf
Vulcan Construction Materials,LP
P. O.Box 4239
Winston-Salem,North Carolina 27511-4239
Subject:Issuance of NPDES Permit NC0027987
Stoneville Quarry WWTP — ►%
Rockingham County
Dear Mr.Knopf:
Division personnel have reviewed and approved your application for renewal of the subject permit.
Accordingly,we are forwarding the attached NPDES discharge permit. This permit is issued pursuant to the
requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement between North
Carolina and the U.S.Environmental Protection Agency dated May 9, 1994 (or as subsequently amended).
This final permit includes no major changes from the draft permit sent to you on May 9,2007.
If any parts,measurement frequencies or sampling requirements contained in this permit are
unacceptable to you,you have the right to an adjudicatory hearing upon written request within thirty(30) days
following receipt of this letter. This request must be in the form of a written petition,conforming to Chapter
150B of the North Carolina General Statutes,and filed with the Office of Administrative Hearings (6714 Mail
Service Center,Raleigh,North Carolina 27699-6714). Unless such demand is made,this decision shall be final
and binding.
Please note that this permit is not transferable except after notice to the Division. The Division may
require modification or revocation and reissuance of the permit. This permit does not affect the legal
requirements to obtain other permits which may be required by the Division of Water Quality or permits
required by the Division of Land Resources,the Coastal Area Management Act or any other Federal or Local
governmental permit that may be required. If you have any questions concerning this permit,please contact
Karen Rust at telephone number(919) 733-5083,extension 361.
Sincerely,�
A, ‘41/)/41-"A
-', Coleen H. Sullins
•
cc: Central Files
Winston-Salem Regional Office/Surface Water Protection Section
NPDES Files
No Carolina
�turally
N.C.Division of Water Quality 1617 Mail Service Center Raleigh,North Carolina 27699-1617 Phone: [phone] Customer Service
Internet: httpJ/h2o.enr.state.nc.us 512 N.Salisbury St. Raleigh,NC 27604 Fax: [phone] 1-877-623-6748
An Equal Opportunity/Affirmative Action Employer

Permit NC0027987
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted,by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
Vulcan Construction Materials, LP
is hereby authorized to discharge wastewater from a facility located at the
Stoneville Quarry
NCSR 1518 north of Stoneville
Rockingham County
to receiving waters designated as an unnamed tributary to Buffalo Creek in the
Roanoke River Basin in accordance with effluent limitations, monitoring
requirements, and other conditions set forth in Parts I, II, III and IV hereof.
This permit shall become effective August 1,-2007. 2 0 12-
This permit and authorization to discharge shall expire at midnight on April 30,? . ,QC I-7
Signed this day dui;-2007. 2 C% 1 Z-
A,/ V - .
< (-.• Coleen H. Sullins, Director ia l rye•
Division of Water Quality
By Authority of the Environmental Management Commission

Permit NC0027987
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility, whether for operation or
discharge are hereby revoked. As of this permit issuance, any previously issued
permit bearing this number is no longer effective. Therefore, the exclusive authority
to operate and discharge from this facility arises under the permit conditions,
requirements, terms, and provisions included herein.
Vulcan Construction Materials, LP is hereby authorized to:
1. Continue to operate three settling cells with recycling pumps (for wash water)
and filtering ponds (for wash water and pit water flow). This facility is located
north of Stoneville on NCSR 1518 at the Stoneville Quarry in Rockingham
County.
2. Discharge from said treatment works at the location specified on the attached
map into an unnamed tributary to Buffalo Creek, classified WS-IV waters in the
Roanoke River Basin.

s Nilt \\,1 .• _ ,,,--, ,.,., .. - ,
,2,,,,,) 14 40_•. - \/.' .'1...jet,,fifitii
'1 -.42 : ' * -- 411111A II Pm's;—--,-----;1* •il . _ li
\ -,t .. .4‘ .. \
a
4;4‘Zii
.‘, .. ..0V..4,11p4 / tr •Ik. .„.NIL ,\ !-----..% 1,/ - ,
' -rdi a '.--_-.•, 41.ILI w49,, ,
ieN\,,..„ -, ,.
s s,
' , )), ....:,A,.„., , o Outfall 001 1_� o,,,,,
,� (4. ,er..
/ ►�
4 t ,1
0, , IP '
-.4 ./...---411141F ‘10egj
;:::
7-.,_/' •N. ‘- o , 0 #1 i • .. . kr
\ .. ', ) . 2- 0 )1 , i ,,,/
---,r,
...,
143 11W . 1°° 4jrp
) 1' � V � s 'i � °mot <. a ��+ ere,� �
4/- A' -' fs, / .
ift(
;00\3._____,.„,. .,,
...,;
:1
0. , • ,.,, c V fr • • ,,,% ii37 . - ,4/7"..v.
7,4
, ..„.,
„..)
,t
vo, 1_,..„1„,....10,.....,
_,„,.:.y.,/- „,,‘,1 /1 tii„) __\.„):.-iiv A
Q ,/ i
; i ,. C3 -
'2.- '..1 \,),; r _, i.„4, .....,. ,,z 4-,
, „, , ai, \,- ra,-i-~-z\- --"Thl
<$4
linh".7'.-----;41;St* t 7 FT 1 \ ' ,-'4Vo ,-..1.1->-:0‘,11101 17°.).(4
.r.,...\Ns>
rill
1r4
ya ��, � ';;, i �,► e .o* 't
- -46:1141-11-141!.--jit 17 1 1 ., °
, '-\11., .. ,IFil ,,,,f,,,,,_____,..4_____0,:z.- _zt...,_<-----zac..\---- ,7:71.i.,./..214,„:4;:tri,717.0 f.L.11.•.)117;.:1„..!:/„.././. t. , z ,/ ; _, . If : ''.,$,,,::,,,,:‘,. ..
L 1. .q
\ % ::4411. Cks
. •..... liitil 0 / ) g ..
i ,,,,„„4,4
r' •,-. Y/ f 1 a\� •
/ xv 1
kiiit7' kit; /IL, 4:, , '\ . : 7...\., / .0, ,)
Po -li j Y' . i ,. .l. . 'T' • Oet- ,jy'
! .,
- . 6" "A o 40,
I We
).*tit : _,,,,A,_,03 t' wift If , 49. .
1 or , 4,,, .t f I ..
)‘110,T-rivek40/ ......______L.j.m,-,,r•e)
! ,v- ill. __,-J)lc,-'-,r ,//r.:"Y'r'4 1)i? _,-, z\7:::Nn. A ,i_c, nii-y,
Quad:Mayodan,N.C. N C O O 2 7 9 8 / Facility
Stream Class:WS-N✓ aidie,
Strew sin:30203 Vulcan Construction Location
Latitude:36°28'44" Materials -E.}
Longitude:79'53'54" Stoneville Quarry
Receiving Stream:UT Buffalo Creek North SCALE 1 :24000

Permit NC0027987
A. (1.) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS — EVA FT
During the period beginning on the effective date of this permit and lasting until expiration, the Permittee is
authorized to discharge from outfall 001. Such discharges shall be limited and monitored by the Permittee as
specified below:
EFFLUENT LIMITS MONITORING REQUIREMENTS
CHARACTERISTICS
Monthly Daily Measurement Sample Type Sample Locations
Average Maximum Frequency
Flow Monthly Instantaneous Effluent
Settleable Solids 0.1 mVL 0.2 mVL Monthly Grab Effluent
Turbidity 50 NTU Monthly Grab Effluent
Total Nitrogen Monthly Grab Effluent
(NO2+NO3+TKN)
pH2 Monthly Grab Effluent
Footnotes:
1. Effluent samples shall be collected upstream of NCSR 1518, directly after the settling basin. Samples must
be collected after rain events.
2. The pH shall not be less than 6.0 standard units nor greater than 9.0 standard units.
Best Management Practice Conditions shall be as follows:
• The permittee shall operate the facilities in a manner that minimizes the impact of
any discharge on the receiving stream.
• The permittee shall utilize the necessary management practices to prevent
contaminants from entering the surface waters as a result of blasting at this site.
• All settling basins shall be cleaned when the only remaining alternate (operating)
basin approaches 80% capacity.
There shall be no discharge of floating solids or visible foam in other than trace amounts.
A. (2.) ENGINEERING REPORT
Within two months of notification from the Division, an engineering report evaluating the
dredging of the first settling basin from the pit area (or the construction of a new settling
basin) will be required. Continued build-up of the berm surrounding this basin could
increase the turbidity and settleable solids within the discharge. This report should
include documentation of the soil disposal procedures from any dredging.

State of North Carolina i FA i e i
Department of Environment • Y
and Natural Resources4461„;z
willfr
Division of Water Quality
Michael F. Easley, Governor 11CDEI1R
William G. Ross, Jr., Secretary NORTH CAROLINA DEPARTMENT OF
Alan W. Klimek, P.E., Director ENVIRONMENT AND NATURAL RESOURCES
May 9, 2007 RECEIVED
N.C.Depot of ENR
MEMORANDUM I MAY 1 0 2007
Winetpn. alem
To: Lee Spencer RetI 90'
NC DENR/ DEH / Regional Engineer
Winston-Salem Regional Office
From: Karen Rust
NPDES Eastern Unit
Subject: Review of Draft NPDES Permit NC0027987
Stoneville Quarry WWTP
Rockingham County
Please indicate below your agency's position or viewpoint on the draft permit and return this form by June 15,2007.
Ifyou have anyquestions on the draftpermit,please contact me at the telephone number or e-mail address listed at
P
the bottom of this page.
RESPONSE: (Check one)
oncur with the issuance of this permit provided the facility is operated and maintained properly,the stated effluent limits
I-9./6.--
are met prior to discharge,and the discharge does not contravene the designated water quality standards.
Concurs with issuance of the above permit,provided the following conditions are met:
Opposes the issuance of the above permit,based on reasons stated below,or attached:
•
Signed Date: r/44 7
1617 Mail Service Center,Raleigh,North Carolina 27699-1617 919 733-5083,extension 361 (fax)919 733-0719
VISIT US ON THE INTERNET @ http://h2o.enr.state.nc.us/NPDES Karen.Rust@ ncmail.net 1

1
lo 3a rboticit 30,,3& ebietu
1
1921 VANCE STREET P.O. BOX 2157 REIDSVILLE, NC 27320 336-349-4331
PUBLIC NOTICE
STATE OF NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT •
COMMISSION/NPDES UNIT
. 1617 MAIL SERVICE CENTER AFFIDAVIT OF PUBLICATION
RALEIGH,NC 27699.1617 NORTH CAROLINA
NOTIFICATION OF INTENT TO ISSUE A
NVDEswasTiwATER PERMIT
ROCKINGHAM COUNTY
On the basis of thorough staff review and i
application of NC General Statute 143.21,
Public law 92.500 and other lawful standards Before the undersigned, a NotaryPublic of Said
and regulations,the North Carolina g
proposestolssQeManagement nalPommistion Countyand State, dulycommissioned, qualified, and
proposes to Issuea'National Pollutant
Discharge Elimination System(NPDES) , oaths, rya
authorized by law to administ;,r oaths, personally appeared
wastewater discharge permit to the Pe �' pr
person(s)listed below effective 45 days Bonnie Todd, who beingfirst dulysworn, deposes and
from the publish date of this notice. p
Written comments regarding the proposed says. That she is an official of Media General of Reidsville,
permit will be accepted until 30 days after engaged a ed in thepublication of a newspaper known as
the publish date of this notice.All comments g g
received prior to that date are considered in The Reidsville Review, published, issued and entered as
the final determinations regarding the
proposed permit.The Director of the NC second class mail in the City of Reidsville, in said County
Division of Water Quality may decide to hold
a public meeting for the proposed permit and State; that she is authorized to make this affidavit and
should the Division receive a,significant
degree of public interest. sworn statement, that the notice or other legal advertise-
Copies of the draft permit and other ment, a true copy of which is attached hereto, was pub-
supporting information on file used to
determine conditions present in the draft lished in The Reidsville Review on the following dates:
permit are available upon request and
payment of the costs of reproduction.Mail
comments and/or requests for information I a L�
to the NC Division of Water Quality at the Q l
above addressor call Ms.Frances Candelaria
[phone],ext 520 at the Point Source
Branch.Please Include the NPDES permit
number(attached)in any communication. ;
lso
Interested persons may a visit the
Division of Water Quality at 512 N.Salisbury and that the said newspaper in which such notice, paper
Street,Raleigh,NC 27604-1148 between the
hours of 8:00am and 5:00pm to review document, or legal advertisement was published was, at the
information time of each and every such publication,a newspaper meet-
�C_ Miller Breweries East,Inc.has applied for
renewal of its NPDES permit NC0029980,for ing all of the requirements and qualifications of Sectica,I,,,,,,�
the Miller Breweries East WWTP,discharging �� ,,i,�
to the Dan River in the Roanoke River Basin. 597 of the General Statutes of North Carolina ga (!_�i,�
BOD is a water quality limited parameter. O •• w 4i,
This discharge may affect future allocations qualified newspaper within the meaning of Sectipn 597 of !lam,
in this portion of the stream. = v TA
the General Statutes of North Carolina. : , O R y ,
Mr.Sterling A.Weaver(149 Sunset Boulevard, _
Beaufort,SC 29907)has applied for renewal • ' ' — ;
of NPDES permit NC0060623 for the Stone Q • .0.1.
y Highway Mobile Home Park WWTP in T d11S ? V da- of • A `\G4.
'� Rockingham County.This permitted facility 2 ••J �.0
discharges 0.015 MGD treated wastewater to •
an unnamed tributary to Buffalo Creek in the
Roanoke River Basin.Currently,BOD, CAM G0�.
ammonia-nitrogen,and total residual Sworn to and. subscribed before me, this 4.m"nae-
chlorine are water quality limited.This
discharge may affect future allocations in dayof u.�-e-- , c�OD
this portion of the Roanoke River Basin.
Vulcan Construction Materials,LP(PO Box
4239,Winston Salem,NC 27511-4239)has
applied for renewal of NPDES permit
l. NC0027987 for the Stoneville Quarry WWTP Y '�-----� NotaryPublic
in Rockingham County.This permitted
facility discharges treated wastewater to an
unnamed tributary.to Buffalo Creek in the
Roanoke River Basin.This discharge may My commission exprires the /,-( day of ( 9
affect future allocations in this po on of the '
Roanoke River Basin. ?)r
,e
May 13,2007

Uulcun
Materials Company
August 31, 2006
Ms. Carolyn Bryant
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Point Source Branch
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Subject: NPDES Permit Renewal
Vulcan Construction Materials, LP
Stoneville Quarry (Inactive)
NPDES Permit NC0027987
Dear Ms. Bryant,
Vulcan Materials Company requests renewal of NPDES Permit NC0027987. Enclosed please
find one original and two copies of the Cover Letter, Application Form and Sludge Management
Plan.
The facility has been inactive during the current permit cycle, with no wastewater discharges
occurring. There are no plans to activate the facility in the near future. The permit is maintained
for possible future activities.
Vulcan also requests the continued waiver of monitoring requirements for the renewed permit.
This request is allowed by 15A NCAC 2B .506(E) which states (In situations where no discharge
has occurred from the facility during the report period, the permittee is required to submit a
monthly monitoring report giving all required information and indicating "NO FLOW'unless the
Director agrees to waive the reporting requirement during extended conditions of no discharge.)
The current waiver was granted in May of this year, a copy is enclosed.
If you have any questions or need additional information, please contact me at [phone].
Sincerely,
/ .
Tim Knopf
Environmental Engineer
MIDEAST DIVISION,VULCAN CONSTRUCTION MATERIALS, LP
P.O.BOX 4239•WINSTON-SALEM, NORTH CAROLINA 27115-4239•TELEPHONE [phone]

NPDES PERMIT APPLICATION - SHORT FORM C - Minor Industrial
Minor industrial, manufacturing and commercial facilities.
Mail the complete application to:
N. C. Department of Environment and Natural Resources
Division of Water Quality / NPDES Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
NPDES Permit Number NC0027987
If you are completing this form in computer use the TAB key or the up - down arrows to move from one
field to the next. To check the boxes, click your mouse on top of the box. Otherwise,please print or type.
1. Contact Information:
Owner Name Vulcan Construction Materials, LP c/o Tim Knopf
Facility Name Stoneville Quarry
Mailing Address P.O. Box 4239
City Winston-Salem
State / Zip Code N.C. 27115-4239
Telephone Number [phone]
Fax Number [phone]
e-mail Address [e-mail]
2. Location of facility producing discharge:
Check here if same as above El
Street Address or State Road Highway 220 @ Taylor Road
City Stoneville
State / Zip Code N.C. 27048
County Rockingham
3. Operator Information:
Name of the firm, consultant or other entity that operates the facility. (Note that this is not referring to the
Operator in Responsible Charge or ORC)
Name
Mailing Address
City
State / Zip Code
Telephone Number ( )
Fax Number ( )
Donn 1 of g !`RAI(11/1

NPDES PERMIT APPLICATION - SHORT FORM C - Minor Industrial
Minor industrial, manufacturing and commercial facilities.
4. Ownership Status:
Federal ❑ State ❑ Private ❑ Public El
5. Standard Industrial Classification (SIC) code(s): 1423
6. Number of employees: Presently Inactive, 3-15 employees when active.
7. Describe the treatment system List all installed waste treatment components with capacities,
describe the processes that generate wastewaters. If the space provided is not sufficient attach a
separate sheet of paper with the system description.
A series of three settling ponds that capture stone fines from stone washing process.
8. Is facility covered under federal effluent limitation guidelines? No ® Yes ❑
If yes, specify the category?
9. Principal product(s)produced: Construction Aggregates
Principal raw material(s) consumed: Granite
Briefly describe the manufacturing process(es):
Material is extracted from stone deposit and processed by conveying, crushing and screening. The
constuction aggregate is stockpiled, then loaded into customer trucks from distribution.
D�nn7 nfC
('CAI f1'?Mr.

NPDES PERMIT APPLICATION - SHORT FORM C -
Minor Industrial
Minor industrial, manufacturing and commercial facilities.
10. Amount of principal product produced or raw material consumed
(List specific amounts consumed and/or units of production over the last three years)
Product Produced or Raw Material Product Produced or Raw Material
Consumed Consumed
(AVERAGE) (PEAK)
per Day
per Month
per Year 250,000 Tons 350,000 Tons
11. Frequency of discharge: Continuous ❑ Intermittent
If intermittent:
Days per week discharge occurs: 4 - 5 Duration: 10 hours
12. Types of wastewater discharged to surface waters only
Discharge Flow
(GALLONS PER DAY)
Sanitary - monthly average
Utility water, etc. - monthly average
Process water- monthly average <100,000
Stormwater-monthly average
Other-monthly average
Explain:
Monthly Average <100,000
total discharge (all types)
13. Number of separate discharge points: 1
Outfall Identification number(s) 001
14. Name of receiving stream(s) (Provide a map showing the exact location of each outfall, including
latitude and longitude):
Unnamed tributary to Buffalo Creek
Dotun ..f F
/`FII J1'IJ/1P

NPDES PERMIT APPLICATION - SHORT FORM C - Minor Industrial
Minor industrial, manufacturing and commercial facilities.
15. Effluent Data
Provide data for the parameters listed. Temperature and pH shall be grab samples,for all other parameters 24-hour
composite sampling shall be used. If more than one analysis is reported, report drily maximum and monthly
average. If only one analysis is reported, report as daily maximum.
Parameter Daily Monthly Units of
Maximum Average Measurement
Biochemical Oxygen Demand (BOD5)
Chemical Oxygen Demand (COD)
Total Organic Carbon
Total Suspended Solids
Ammonia as N
Temperature (Summer)
Temperature (Winter)
pH
Fecal Coliform (If sanitary waste is
present)
Total Residual Chlorine (if chlorine is
used)
16. List all permits, construction approvals and/or applications (check all that apply and provide permit
numbers or check none if not applicable):
Permit
Type Permit Number Type Number
Hazardous Waste (RCRA) NESHAPS (CAA)
UIC (SDWA) Ocean Dumping (MPRSA)
NPDES NC0027987 Dredge or fill (Section 404 or
PSD (CAA) Other- State Mining Permit 70-09
Non-attainment program
17. List any chemicals that may be discharged (Please list and explain source and potential
amounts.)
18. Is this facility located on Indian country? (check one)
Yes ❑ No El
o�M a,.a r Iii ming

NPDES PERMIT APPLICATION - SHORT FORM C - Minor Industrial
Minor industrial, manufacturing and commercial facilities.
19. Applicant Certification
I certify that I am familiar with the information contained in the application and that to the
best of my knowledge and belief such information is true, complete, and accurate.
Tim Knopf Environmental Engineer
Printed name of Person Signing Title
- 3\ - o iv
Signature of A lice Date
� PP
North Carolina General Statute 143-215.6 (b)(2) provides that: Any person who knowingly makes any false
statement representation, or certification in any application, record, report, plan, or other document files or
required to be maintained under Article 21 or regulations of the Environmental Management Commission
implementing that Article, or who falsifies, tampers with, or knowingly renders inaccurate any recording or
monitoring device or method required to be operated or maintained under Article 21 or regulations of the
Environmental Management Commission implementing that Article, shall be guilty of a misdemeanor
punishable by a fine not to exceed $25,000, or by imprisonment not to exceed six months, or by both. (18
U.S.C. Section 1001 provides a punishment by a fine of not more than $25,000 or imprisonment not more than
5 years, or both, for a similar offense.)
Dom F of rs RAI nl/ng

Uulcun
Materials Company
p Y
SLUDGE MANAGEMENT PLAN
STONEVILLE QUARRY
As a normal course solids (stone fines) from wastewater settling ponds are excavated and
spread out to dry. Once dry the sludge (stone fines) is taken to the onsite overburden
(excavated soil that overlays stone reserves) storage area and layered into the fill.
The drying and overburden storage areas are protected by erosion and sediment control
measures that are approved by the Division of Land Quality as required by our Mine
Permit Number 70-09. Collected solids in all erosion control measures are treated in like
matter.
This facility is inactive at this time and therefore no wastewater sludge management is
expected in the foreseeable future.
l� I
Tim Knopf
Environmental Engineer, Southern Region
MIDEAST DIVISION,VULCAN CONSTRUCTION MATERIALS, LP
P.O.BOX 4239•WINSTON-SALEM,NORTH CAROLINA 27115-4239•TELEPHONE [phone]

FACT SHEET FOR EXPEDITED PERMIT RENEWALS
Basic Information to determine potential for expedited permit renewal
Reviewer/Date 1.(204 /6.S i.c d a,C e 2®10 b
Permit Number NCOO )-1 Q1s 7_
Facility Name S'ro►�(�il,(� U
Basin Name/Sub-basin number Rocmolcr_ m-U 03
Receiving Stream Or B.(fr,Lc azd
Stream Classification in Permit
Does permit need NH3 limits? /Up
Does permit need TRC limits? ND •
Does permit have toxicity testing? ►1 D
Does permit have Special Conditions? yes
Does permit have instream monitoring? 0
Is the stream impaired (on 303(d) list)?
Any obvious compliance concerns? PO (l".o - opv opt r
Any permit mods since last permit? 1�25
Existing expiration date
Reissued permit expiration date Y/2 /i 2-
New proposed permit effective date
Miscellaneous Comments
YES] This is a SIMPLE EXPEDITED permit renewal (administrative
renewal with no changes, or only minor changes such as TRC, NH3,
name/ownership changes). Include conventional WTPs in this group.
YES_ This is a MORE COMPLEX EXPEDITED permit renewal (includes
Special Conditions (such as EAA, Wastewater Management Plan), 303(d)
listed, toxicity testing, instream monitoring, compliance concerns, phased
limits). Basin Coordinator to make case-by-case decision.
YES_ This permit CANNOT BE EXPEDITED for one of the following reasons:
• Major Facility(municipal/industrial)
• Minor Municipals with pretreatment program
• Minor Industrials subject to Fed Effluent Guidelines (lb/day limits for BOD,TSS,
etc)
• Limits based on reasonable potential analysis (metals, GW remediation organics)
• Permitted flow >0.5 MGD (requires full Fact Sheet)
• Permits determined by Basin Coordinator to be outside expedited process
TB Version 8/18/2006 (NPDES Server/Current Versions/Expedited Fact Sheet)

A:7A,
NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Michael F. Easley, Governor William G. Ross,Jr., Secretary
Alan W. Klimek, P.E., Director
May 9, 2006
Mr. Tim Knopf
Vulcan Construction Materials
P.O. Box 4239
Winston-Salem, N.C. 27115-4239
Subject: Waiver of Monthly Reporting Requirement
Stoneville Quarry
NPDES Permit NC0027987
Rockingham County
Dear Mr.Knopf:
The Division has reviewed your correspondence dated April 18, 2006, which states the subject facility is not
being operated and therefore is not producing a wastewater discharge. You indicated the facility will
remain inoperablewhile future options for the facilityare evaluated.
e p
After reviewing your letter and considering the recommendations of the staff in the Winston-Salem
Regional Office, I have agreed to waive the requirement to submit monthly DMRs for the subject facility,
effective May 1, 2006. The DMRs up through (and including)April 2006 should be submitted as usual.
Please be advised if and when a discharge resumes, the discharge must be monitored as per the terms of
the NPDES permit and other applicable rules or statutes. Please keep the Winston-Salem Regional Office
apprised of any pertinent developments that arise regarding this facility, especially if the facility is re-
activated.
Be advised that while requirements for operator visitation, monitoring and reporting are being waived
during the period of no discharge,the permittee is still required to pay the Annual Administering and
Compliance Monitoring Fee that is associated with this and all NPDES permits.
Thank you for your cooperation in this matter. If you have any questions, contact Charles H.Weaver, Jr.
at 919 733-5083, extension 511.
Sincerely,
Alan W. Klimek, P.E.
cc: Central Files
Winston-Salem Regional Office/David Russell
NPDES Files
1617 Mail Service Center,Raleigh,North Carolina 27699-1617
512 North Salisbury Street,Raleigh,North Carolina 27604 NorthCarolina
Phone: [phone]/FAX [phone] Internet:h2o.enr.state.nc.us Naturally
An Equal Opportunity/Affirmative Action Employer—50%Recycled/10%Post Consumer Paper

f
Re:NC0027987-suspend monitoring?
Subject: Re: NC0027987 - suspend monitoring?
From: David Russell <[e-mail]>
Date: Tue, 09 May 2006 12:51:51 -0400
To: Charles Weaver<[e-mail]>
Return-Path: <[e-mail]>
Received: from scc151.its.state.nc.us (207.192.33.38)by ms04.ncmail.net(7.2.069.1) id
442FC1930023BCA6 for [e-mail]; Tue, 9 May 2006 12:51:53 -0400
Received: from scc151.its.state.nc.us (127.0.0.1)by scc151.its.state.nc.us (7.2.052) id
44388B140019B433 for [e-mail]; Tue, 9 May 2006 12:51:53 -0400
Received: from [127.0.0.1] (152.34.245.2)by scc151.its.state.nc.us (7.2.052) id 44388B13001A1AC0
for [e-mail]; Tue, 9 May 2006 12:51:53 -0400
Message-ID: <446008A7.3090801 @ncmail.net>
Reply-To: [e-mail]
Organization: NC DENR- Winston-Salem Regional Office
User-Agent: Mozilla Thunderbird 1.0 (Windows/20041206)
X-Accept-Language: en-us, en
MIME-Version: 1.0
References: <[e-mail]>
In-Reply-To: <[e-mail]>
Content-Type: multipart/mixed; boundary=" 040504080102080803000502"
I went by there a couple of months ago....no activity...no need to monitor. DCR
David Russell
NC DENR Winston-Salem Regional Office
Division of Water Quality, Water Quality Section
585 Waughtown Street
Winston-Salem, NC 27107
Voice: (336) 771-5000 ext 284
FAX: (336) 771-4630
On 5/9/2006 11:08 AM, Charles Weaver wrote:
The Stoneville Quarry wishes to get a waiver of the DMR submittal requirement. They say the
facility is closed and not discharging.
Can we do this, or should I tell them NO?
Thanks,
CHW
David Russell <[e-mail]>
WSRO
NC DENR
1 of 1 5/9/2006 1:04 PM

Uulcun t .
AF
Materials Company { I y 2006
DIV.OF WATER QUALITY
April 18, 2006 DIRECTOR'S OFFICE
CERTIFIED MAIL 7005 0390 0004 6326 3732
RETURN RECEIPT REQUESTED
\1?6j°/
Mr. Alan W. Klimek, P.E.
North Carolina Department of Environment and Natural Resources
Division of Water Quality
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Subject: Vulcan Construction Materials, LP
Stoneville Quarry (Inactive)
NPDES Permit NC0027987
Dear Mr. Klimek,
Vulcan Materials Company requests to have monitoring requirements temporarily suspended for
the abovementioned permit. This request is allowed by 15A NCAC 2B .506(E) which states (In
situations where no discharge has occurred from the facility during the report period, the
permittee is required to submit a monthly monitoring report giving all required information and
indicating "NO FLOW'unless the Director agrees to waive the reporting requirement during
extended conditions of no discharge.)
The facility has been inactive during the current permit cycle, with no wastewater discharges
occurring. There are no plans to activate the facility in the near future. The permit is maintained
for possible future activities.
If you have any questions or need additional information, please contact me at [phone].
Sincerely,
-T. ,. lytt9.4,
Tim Knopf
Environmental Engineer _
C. Mike Poplin 1 0
11 APR 2 0 2006 id/
DENR-WATER QUALITY
SURFACE WATER PROTECTION SECTION
MIDEAST DIVISION,VULCAN CONSTRUCTION MATERIALS, LP
P.O. BOX 4239•WINSTON-SALEM, NORTH CAROLINA 27115-4239•TELEPHONE [phone]

Permit NC0027987
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
Vulcan Construction Materials, LP
is hereby authorized to discharge wastewater from a facility located at the
Stoneville Quarry
NCSR 1518 north of Stoneville
Rockingham County
to receiving waters designated as an unnamed tributary to Buffalo Creek in the
Roanoke River Basin in accordance with effluent limitations, monitoring
requirements, and other conditions set forth in Parts I, II, III and IV hereof.
This permit shall become effective September 1, 2002.
This permit and authorization to discharge shall expire at midnight on April 30, 2007.
Signed this day July 31, 2002.
ORIGINAL SIGNED BY
SUSAN A. WILSON
Alan W. Klimek, P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission

Permit NC0027987 •
SUPPLEMENT TO PERMIT COVER SHEET
Vulcan Construction Materials, LP is hereby authorized to:
1. Continue to operate three settling cells with recycling pumps (for wash water)
and filtering ponds (for wash water and pit water flow). This facility is located
north of Stoneville on NCSR 1518 at the Stoneville Quarry in Rockingham
County.
2. Discharge from said treatment works at the location specified on the attached
map into an unnamed tributary to Buffalo Creek, classified WS-IV waters in the
Roanoke River Basin.

'- ft .j(\V"` ;
r r'
v5L.n. \.i.,,i.z.e4N,— ..:/cf....\i•-•,_.,_.A., :•,,> ito. : H.•••• )1',.)
. - , ilt A .
9.) c.._./ *\ ,
/di,
, ..
. .....,
, _... ,
? ...-
,, ,..--4
k7 \\I ).•• (--/- `11 ri.,...,
. - ,) vi
0 I
x �L I I u � ( q �� •
} �� a ;.i„,) , �� 0 �d• •
- ,-;-,--;„ 1
J., La. .----.: ,,•,\••••••••\' \ '' \ • ,--...../- ' fr 7.. ''\---/ •///7 • \ .
/,ram ,J •
j2
.o��"1 Sou j L. r`S
\a• 'it�-. (i �� i �`vl lr ,-f ..� .•u. ) ,.,�
-'' ;_)Vri\-' --..---- • \ I Alek /
,-f"-^.----:-:. _ i i 2,y 1 cc.- lelliP,<Y \-- .1• •• /1:3 / air e : %
- \*_)7\,.\,_ ),‘)',,,, ate:5--1:1VH;4 )( \\ ,./(C1 / , - ... : • (
7,7(.\.p) ,(- ::;;;; L\ ,..)-,..,..--.1',.._5. _.../
(y4
/= P . ; C; y' .. ,. -
, /,„ ,„ , „ ,,_„ . \ ...... ,..:„ . „ , ,.....„ ,. .....„ , , ,, ,/, • icp
., ,_,, ,,>,._,. J \l//:, ' -'.- : 7- -.:\-'----1 ' \',1H/ f•-'4) ;1 -171_ % \ /
„..,1,-----,</• 7,', — ), 1_! rr, Czr------',v, ,..;;_. „;: • .: .;.. _ t‘ _
..== m=„..,. . .
,r) .,., , ., , , ::-. .'71 AO'' cE. .\\`v--.x' .1' -- ::,.. '-‘, • ,:e-4.4.• ..._I
,-. ,,f . ',.%,-.. -.. :-%'// i;i;'-' ..--'', ,i. `—‘,- . %•I -2 .. '--4:.
.0f,_ L' --.)- -; . t• / j:...t ,.\,. j .... • /-0 r ) ..r,i: i. , g
\ i ~ r / /mil aS'
'� �(
` . � :. StoE ' - , ,gl / /✓ ,
•
.„-..
-- -,-,
. -..."-
1.v�, 4 I/; • ....., • I f.-'`•. ••. ..\,r- I. 1 U Y e» '�
uo • ) • 1 J' o
\.'..,s- '‘ ..._-_.-./.-s, : . !\,(A\-- --:_(—...--- __•__,..,
. _.-- if e.‘ .._:-L-7. -'-',041(__- /.• i '
L'? ..1/ '''' 'C-7.`c9 %fic17:: 5.-1-r--' \ *.) ";111"_21 Ali 1 . '' L.. • . %..
1 , I r.7 e 0 .:5„,1 •#
-f.'
, • . , . ,: ,,,,,,, , ..,
C, ...___
, , , ,,..._._,,,,, .., e. —h•• • gh..., / •••... ame" . .. •
. _ AL\-, __
Quad:Niayodan,N.C. N C 0 0 2 7 9 8 7 Facility
Stream Class:WS-IV M , .,
Subbasin:30203
Vulcan Construction Materials Location
Latitude:36°28'44" Stoneville Quarry
Longitude:79°53'54" I SCALE 1:24000
Receiving Stream:UT Buffalo Creek North

$ui pap Auu uzoij sainpaaoid jusodsip pods atpjo uopuluauinoop apnjoui
pinogs iiodai s!uJ. atp Uj Tflm spijos ajquarnas puu Appiging atp asua.Ioui
pjnoa uisuq srq-4 5'uipuno.uns uuaq atjij 3o do-pjinq panunuo0 paiinbai aq rpm (uisuq
uiplas mar u;o uoj'onxsuoo alp .zo) rare iid atji uioij uisuq Wuppas ;s.IT,; agijo �ui�paip
at j� upunjuna podai WupaatOua Uu `uoisiniQ aTjg tnoi; uonuotp ou jo stpuoui omT trumm
ZUOd'12i "Jmm33A oma ('Z) v
•slunouiu 30E4 uutjg Jati}o ui uzuo3 ajgisin so sppos $Upuoj;jo a .JEgasip ou aq pugs aiatu,
•1iiouduo %08 sagouo1ddu uisEq
($ufEsado) a}uuzape 5'uiuiutuai Aiuo uatjm pauuajo aq pulls suisuq Wum1as
•aps sup iu uriSEjq Jo pnsa.I E SE sJalum az 3jins atp upalua uloij spUEUIUm-luoo
guava ld o; sa3nouid 1uatua uueuU £russaoau atfl azggn pugs aalpuuad ata €
•u uarjs Wuiniaoai atjl uo a .retiosip /cue
;o pudun atu sazpuiui n }utj}.zauuuul u ui sai}ijiauJ aqg aluiado jpjs aarpuuad atj j,
:smono; se aq Hells suot;ipuo3 aot;3Eid ;uauia;llBusyi ;sag
•s;Tun piepue1s 0.6 uuq; sou stun prepu'}s 0•9 usq;ssai aq;ou gulls Hd auj •g
•s;uana uTEi_mire papaiioo aq
uff;sn saiduieg • nsuq$uTppas alp iaie Apoapp •g t g I ugoN jo uneaisdn papaiioo aq!lugs saidures;uaniln T
:saaou1oo,J
luanlll3 ge19 A14luoW zHd
(N0l+EON+ZON)
luenlli3 ge10 AIgluoW ue6oll!N lelol
ivan e1 J( i ! an
Ill3 4 J IgluoW f11N 09 �l.P g 1
luanl43 ge19 AIgluoW l/Iw Z•0 -/lw l•0 sP!IoS emee eS
luanli}3 snoeueluelsui dlgiuoW Mo13
AouanbaJd wnwlxew a6wand
Tuoneoo3 aidweg adiii aidwes ivawainseaw 1(Ilea 1(Iyjuow
SOIiSI1:13i3YHVH3
SJN31411381(1O3H ONIHOiINOW Sit14111 iN3fll3A3
:moiaq paj oads
su aantuuad alp Aq paiojtuoui puu pa;nug aq hells sa$.iugosTp gong •i 00 flJTno uioi3 a' retios!p o; pazuoq;nu
s! aaptuuad •uonu udxa'nun ugsui puu;Tuuad stgp 3o ajEp anfoajja age uo Wuiuu0aq popad age�uunQ
sivawaum6au ouruoiuiow axx SNOLLVs rz i aaZ333 CI) •V
• L86LZ003N Tiauad

. —____—...._—___
'q paveY s,467/
0 \-ill,. • .1, el ii .....
* lir Awil
4hnm! w /1,,i, ,
DE•iiR - MIER QUALITY
POi ET SOURCE BRANCH
1921 VA ET P.O. BOX 2157 REIDSVILLE, NC 27320 336-349-4331
Clipping of AFFIDAVIT OF PUBLICATION
pp g Legal Advertisement NORTH CAROLINA
PUBLIC NOTICE NPDES permit numuer ROCKINGHAM COUNTY
STATE OF NORTH (attached) in any
CAROLINA communication. Interested
ENVIRONMENTAL persons may also visit the
'MANAGEMENT Division of Water Quality at Before the undersigned, a Notary Public of Said
COMMISSION/NPDES 512 N. Salisbury Street,UNIT Raleigh, NC 27604-1148 County and State, duly commissioned, qualified, and
1617 MAIL SERVICE begin the hours of 8:00am authorized by law to administer oaths, personally
CENTER and 5:00 pm to review
RALEIGH,NC 27699- information on file. appeared David Clevenger, who being first duly sworn,
1617 NPDES Permit Number deposes and says. That she is an official of Media
NOTIFICATION OF NC0002828 Diakon Molding,
INTENT TO ISSUE A Inc.PO Box 1350,Reidsville, General of Reidsville,Inc. engaged in the publication of
NPDES WASTEWATER NC 27320 has applied for a a newspaper known as,The Reidsville Review, pub-
PERMIT permit renewal for a facility
On the basis of thorough located in Rockingham lished, issued and entered as second class mail in the
staff review and application County discharging treated
of NC General Statute 14321, wastewater into an unnamed City of Reidsville, in said County and State; that sheis
Public law 92-500 and other tributary to Lick Fork Creek authorized to make this affidavit and sworn statement,
in the Roanoke River Basin.
lawful standards and Currently BOD, ammonia
regulations,the North Carolina that the notice or other legal advertisement, a true copy
nitrogen and total residual
Environmental Management chlorine are water quality of which is attached hereto, was published in The
Commission proposes to limited.This discharge may
issue a National Pollutant Reidsville Review on the following dates:
affect future allocations in
Discharge Elimination Systemthis portion of the receiving .
(NPDES) wastewater
j
stream. A""�r, / /j d Q
discharge permit to the NPDES Permit Number
person(s) listed below 0027987 Vulcan Construction
effectivective 45 days from the Materials, LP (Stoneville
publish date of this notice. Quarry), P.O. Box 4239,
Written comments regal Winston-Salem, NC 27115
the proposed permit will be and that the said newspaper in which such notice,paper
has applied for a permit
accepted until 30 days after renewal for a facility located document,or legal advertisement was published was, at
the publish date of this notice. in Rockingham County
All comments received prior discharging treated the time of each and every such publication, a newspa-
to that date are considered wastewater into an unnamed per meeting all of the requirements and qualifications
in the final determinations tributary to Buffalo Creek in
regarding the proposed the Roanoke River Basin. of Section I-597 of the General Statutes of North
Pew The Director of the NCCurrently no parameters are
Division of Water Quality water quality limited. This Carolina and was qualified newspaper within the mean-
may decide to hold a public discharge may affect future ing of Section I-597 of the General Statutes of North
meeting for the proposed allocations in0 thisstream.portion of
permit should the Division Carolina.April a significant degree April 28,2002 --- 1-----
of publict interest. /7 - day of c)� Y
Copies of the draft permit This
and other supporting
information on file used to
determine conditions present `'
in the draft permit are �7
available upon request and Sworn to and subscribed before me,this / / .�-
4
payment of the costs of day ofil /,)" ,_-- y Of)reproduction.Mail comments
and/or requests for donation n
to the NC Division Water '
Quality at the above address
or call Ms.Christie Jackson extension t
�� ��r --a. '�� ,.yr Notary Public
at(919)733-5038, 6-77 �j �
538. Please include the \ C a // S

I -
State of North Carolina j
Department of Environment f •
and Natural Resources - �'
Division of Water Quality
oissmaimork
0
Michael F. Easley, Governor --_ r -. ;`;H
William G. Ross Jr. Secretary
NORTH CAROLINA DEPARTMENT OF
AND NATURAL RESOURCE
GregoryJ. Thorpe, Ph
.D., ActingDirector
ENVIRONMENTU At_
p �V
A April 10 2002
c)
p RE . �,
MEMORANDUM A.C. Dept:,Q :v' • $ 9\•
To: Lee Spencer
APR 15 2002
NC DENR/ DEH / Regional Engineer
Winston-Salem Regional Office Winston-Salem
From: Charles H. Weaver,Jr. '
!! / Regional Offfc
NPDES Unit I �%
Subject: Review of Draft NPDES Permit NC0027987
Vulcan Construction materials / Stoneville Quarry
Rockingham County
Please indicate below your agency's position or viewpoint on the draft permit and return this form by May 10,2002.
If you have any questions on the draft permit,please contact me at the telephone number or e-mail address listed at
the bottom of this page.
?0024.,40 N4. ►c` b ak g' ***-+.1'et1
RESPONSE: (Check one)
oncur with the issuance of this permit provided the facility is operated and maintained properly,the stated effluent limits
are met prior to discharge,and the discharge does not contravene the designated water quality standards.
Concurs with issuance of the above permit,provided the following conditions are met:
Opposes the issuance of the above permit,based on reasons stated below,or attached:
/(7
Signed d4 Date: v� d
1617 Mail Service Center,Raleigh,North Carolina 27699-1617 919 733-5083,extension 511 (fax)919 733-0719
VISIT US ON THE INTERNET @ http://h20.enr.state.nc.Us/NPDES Charles.Weaver@ ncmail.net

PERMIT NUMBER: NC0027987 OUTFALL: 001 PAGE 1 OF 1
•
FACILITY NAME: Vulcan Materials-Stoneville PERIOD ENDING MONTH: 12 2000
CITY: Stoneville COUNTY: Rockingham REGION: Winston-Salem
00076 00400 00545 00600 50050
ntu su m1/1 mg/1 mgd
TURBIDITY, HCH PH SOLIDS, NITROGEN, TOTAL FLOW, IN
TURBIDIMITER SETTLEABLE (AS N) CONDUIT OR THRU
TREATMENT PLANT
0,1
1 -00
2-00 "
3-00 =>r t?.
4-00
r'i
5-00
6-00
7-00
8-00
9-00 "o
0,1
10-00 u`"
11 -00 "`
012-00 t

PERMIT NUMBER: NC0027987 OUTFALL: 001 PAGE 1 OF 1
•
FACILITY NAME: Vulcan Materials-Stoneville PERIOD ENDING MONTH: 12 2001
CITY: Stoneville COUNTY: Rockingham REGION: Winston-Salem
00076 00400 00545 00600 50050
ntu su m1/1 mg/1 mgd
TURBIDITY, HCH PH SOLIDS, NITROGEN, TOTAL FLOW, IN
TURBIDIMITER SETTLEABLE (AS N) CONDUIT OR THRU
TREATMENT PLANT
1 -01
2-01
3-01
4-01
5-01
6-01
7-01
8-01
9-01
10-01

Uulcnn
Materials Company
•
1 Lu 7
r_=
O �.t
November 29, 2001 i. oci
t w
Mr. Charles H. Weaver o x
North Carolina Department of Environment and Natural ResourcesCL
Division of Water Quality, NPDES Unit
1612 Mail Service Center �
Raleigh,NC 27699-1612
Subject: NPDES Permit Number NC0027987
Stoneville Quarry
Rockingham County
Dear Mr. Weaver:
I am responding to the Notice of Violation(Failure to Submit Permit Renewal
Application), which we received on November 26, 2001. Enclosed please fmd the
required original and two copies of the cover letter, application form, and sludge
management plan.
The abovementioned facility is an inactive operation at this time; therefore no wastewater
discharges are expected in the foreseeable future.
I apologize for any inconvenience this oversight may have caused. If I may be of any
further assistance please contact me at [phone].
Sincerely,
Tim Knopf
Environmental Engineer, Southern Region
C: Mike Poplin
MIDEAST DIVISION,VULCAN CONSTRUCTION MATERIALS,LP
P.O.BOX 4239•WINSTON-SALEM,NORTH CAROLINA 27115-4239•TELEPHONE [phone]

Uulcun
Materials Company
SLUDGE MANAGEMENT PLAN
STONEVILLE QUARRY
As a normal course solids (stone fines) from wastewater settling ponds are excavated and
spread out to dry. Once dry the sludge (stone fines) is taken to the onsite overburden
(excavated soil that overlays stone reserves) storage area and layered into the fill.
The g n drY i and overburden storage areas are protected by erosion and sediment control
measures that are approved by the Division of Land Quality as required by our mining
permit. Collected solids in al
l erosion control measures are treated in like matter.
This facility is inactive at this time and therefore no wastewater sludge management is
expected in the foreseeable future.
T.R. Knopf
Environmental Engineer, Southern Region
MIDEAST DIVISION,VULCAN CONSTRUCTION MATERIALS, LP
P.O.BOX 4239•WINSTON-SALEM,NORTH CAROLINA 27115-4239•TELEPHONE [phone]

State'of North Carolina
Department of Environment 461:1911471
and Natural Resources
Division of Water Quality AigniminimMlk
James B. Hunt, Jr., Governor I1CDEI"IR
Bill Holman, Secretary NORTH CAROLINA DEPARTMENT OF
Kerr T. Stevens, Director ENVIRONMENT AND NATURAL RESOURCES
December 3, 1999
Mr. R. M. Poplin
Vulcan Construction Materials, LP
P.O. Box 4239
Winston-Salem, North Carolina 27115
Subject: NPDES Permit Modification - Ownership Change
Permit NC0027987
Stoneville Quarry WWTP
Rockingham County
Dear Mr. Poplin:
In accordance with your request received November 24, 1999, the Division is forwarding the subject
permit modification. This modification documents the change in ownership at the subject facility. All other terms
and conditions in the original permit remain unchanged and in full effect. This permit modification is issued
under the requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement
between North Carolina and the U. S. Environmental Protection Agency dated December 6, 1983.
If any parts, measurement frequencies or sampling requirements contained in this permit modification
are unacceptable to you,you have the right to an adjudicatory hearing upon written request within thirty(30)
days following receipt of this letter. This request must be a written petition conforming to Chapter 150B of the
North Carolina General Statutes, filed with the Office of Administrative Hearings, Post Office Drawer 27447,
Raleigh, North Carolina 276 1 1-7447. Unless such demand is made, this decision shall be final and binding.
This permit does not affect the legal requirement to obtain other permits which may be required by the
Division of Water Quality, the Division of Land Resources, Coastal Area Management Act, or any other Federal or
Local government permit that may be required. If you have any questions concerning this permit, please contact
Christie Jackson at the telephone number or address listed below.
Sincerely,
.,t.i. -,(04_,,
tri...4("" ,
err T. Stevens
cc: Central Files
Winston-Salem Regional Office,Water Quality Section
NPDES Unit
Point Source Compliance Enforcement Unit
1617 Mail Service Center,Raleigh,North Carolina 27699-1617 919 733-5083,extension 538 (fax)919 733-0719
VISIT US ON THE INTERNET @ http://h2o.enr.state.nc.us/NPDES [e-mail]

Permit NC0027987
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards
and regulations promulgated and adopted by the North Carolina Environmental Management
Commission, and the Federal Water Pollution Control Act, as amended,
Vulcan Construction Materials, LP
is hereby authorized to discharge wastewater from a facility located at the
Stoneville Quarry WWTP
On NCSR 1518
Stoneville
Rockingham County
to receiving waters designated as an unnamed tributary to Buffalo Creek in the
Roanoke River Basin
in accordance with effluent limitations, monitoring requirements, and other
conditions set forth in Parts I, II, III and IV hereof.
This permit shall become effective December 3, 1999.
This permit and authorization to discharge shall expire at midnight on February 28, 2002.
Signed this day December 3, 1999.
•
rr T. Stevens, Director
Division of Water Quality
By Authority of the Environmental Management Commission

•
Permit NC0027987
SUPPLEMENT TO PERMIT COVER SHEET
Vulcan Construction Materials, LP, is hereby authorized to:
1. Continue to operate three settling cells with recycling pumps (for wash water) and
filtering ponds (for wash water and pit water flow).
This facility is located at the Stoneville Quarry on NCSR 1518 near Stoneville in
Rockingham County.
2. Discharge from said treatment works at the location specified on the attached map
into an unnamed tributary to Buffalo Creek, classified WS-IV waters in the
Roanoke River Basin.

A. (1). EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS FINAL Permit No. NC0027987
During the period beginning on the effective date of the permit and lasting until expiration, the Permittee is authorized to discharge from outfall(s) serial number'
001 into the Dan River. Such discharges shall be limited and monitored by the Permittee as specified below:Ate
• CS LIMITS MONITORING REQUIREMENTS
TA, ft�'` j ' f Monthly Weekly Daily Measurement Sample Sample
•.;: Average Average.. Maximum • Frequency Type Location'
Flow Monthly Instantaneous E
Settleable Solids 0.1 ml/I 0.2 m1l Monthly Grab E
Turbidity 50 NTU Monthly Grab E
pH2 Monthly Grab E
Total Nitrogen (NO2 +NO 3+TKN) Monthly Grab E
Notes:
1 Sample locations: E - Effluent upstream of NCSR 1518, directly after the settling basin. Facility must take monitoring samples after a rain event.
2 The pH shall not be less than 6.0 standard units nor greater than 9.0 standard units.
BMP Conditions shall be maintained as follows:
1. The permittee shall operate the facilities in a manner which will minimize the impact on the receiving waters.
2. The permittee shall utilize sound management practices to ensure that contaminants do not enter the surface waters as a result of blasting at this site.
3. All settling basins shall be cleaned out whenever the only remaining alternate (operating) basin is approaching 80%full.
An Engineering Report shall be required as specified in Part I, Special Condition A. (2).
There shall be no discharge of floating solids or visible foam in other than trace amounts.

State of North Carolina
Department of Environment 46111111:illrA
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor t4CDEtIR
Wayne McDevitt, Secretary NORTH CAROUNA DEPARTMENT CF
ENVIRONMENT AND NATURAL RESOURCES
Kerr T. Stevens, Director
WATER QUALITY SECTION
PERMIT NAME/OWNERSHIP CHANGE FORM
I. CURRENT PERMIT INFORMATION:
Permit Number: N/C_._2 Z 9 8 7_ or
Certificate of Coverage Number: N/Ci
I. Permit holder's name: Vulcan Materials Company
2. Permit's signing official's name and title: R.M. Poplin
(Person legally responsible for permit)
Manager, Environmental Services
(Title)
P.O. Box 4239 Winston-Salem
3 Mailing address: Cav:
State: NC Zip Code. 27115 Phone 336) 767 - 4600
II. NEW OWNER/NAME INFORMATION:
I This request for change is a result of:
Change in ownership of property/company ❑ Name change only
E Other(please explain):
2 tv, owner's/operator's name(name to be put on permit%certificate of coverage):
Vulcan Construction Materials, LP
3 New owner'sioperator's or signing official's name and title: R. M. Poplin
(Person legally responsible for permit)
Manager, Environmental Services
(Title)
P.O. Box 4239 Winston-Salem
4 Mailing address: City:
Seale: NC Zip Code: 27115 Phone:, 336) 767 - 4600
Facility Contact:
S W U-23 9-061899

PERMIT NAME / OWNERSHIP CHANGE FORM
THIS APPLICATION PACKAGE WILL NOT BE ACCEPTED BY THE DIVISION OF WATER
QUALITY UNLESS ALL OF THE APPLICABLE ITEMS LISTED BELOW ARE INCLUDED WITH THE
SUBMITTAL.
REQUIRED ITEMS:
I This completed application
2. Legal documentation of the transfer of ownership(such as a contract.deed,articles of incorporation)
Certification must be completed and siened by both the current permit holder and the new applicant in the case of
change of ownership. For name change only.complete and sign the application certification.
Current Permittee's Certification:
I R_ M Poplin ,attest that this application for
nameiownership change has been reviewed and is accurate and complete to the best of my knowledge. I understand
that if all required pa f this pplication are n pleted and that if all required supporting information and
attachments are not,ijded, is plic pack _e will be returned as incomplete.
Signature: .. Date: November 15, 19
99
Applicant's Certification:
I, R M Poplin .attest that this application for a
name/ownership change has been reviewed and is ac rate and complete to the best of my knowledge I understand
that if all required pa f this plication of completed and that if all required supporting information and
attachments are not n dged.t i a c on package will be returned as incomplete.
Signature: ( Date: November 15, 1999
THE COMPLETED APP• ATION PACKAGE,INCLUDING ALL SUPPORTING INFORMATION&:
MATERIALS,SHOULD BE SENT TO THE FOLLOWING ADDDRESS:
Stormwater and General Permits Unit
Division of Water Quality
1617 Mail Service Center
Raleigh,North Carolina 27699-1617
SWU-239-061899

Vulcun
Materials Company
MIKE POPLIN P.O BOX 4239
SENIOR ENVIRONMENTAL ENGINEER WINSTON-SALEM.NORTH CAROLINA 27115-4239
MIDEAST DIVISION TELEPHONE [phone]
FAX [phone]
November 15, 1999
Mr. Charles Weaver
Stormwater and General Permits Unit
NC Department of Environment and Natural Resources
Division of Water Quality
1617 Mail Service Center
Raleigh, NC 27699-1617
Re: Ownership Change from Vulcan Materials Company to Vulcan
Construction Materials, LP
Permit No.NC0027987, Stoneville Quarry
Dear Mr. Weaver:
Vulcan Materials Company ("Vulcan") currently holds the above referred water permit.
In connection with a corporate reorganization, Vulcan will transfer the above referenced site to its
wholly owned affiliate, Vulcan Construction Materials, LP ("VCM"), effective January 1, 2000.
Enclosed find our check in the amount of $50.00 as payment of the associated processing fee.
VCM is a Delaware limited partnership. Vulcan's current operation and employees will not
change as a result of the transfer, and VCM will continue to operate under the terms and
conditions of Vulcan's current permit. The contact information currently on file with your office
will remain the same.
Accordingly, Vulcan requests that the above referenced permit, along with all rights and
legal obligations, be transferred to VCM effective January 1, 2000. Please find enclosed a
completed Permit Name/Ownership Change Form for the above referenced site. Should you have
any questions or need further information, please call me at(336) 767-4600.
Sincerely,
Mike Poplin
Manager, Environmental Services
C: Frederic Smith, Bradley Arant Rose& White, LLP
stoneville water name change 11-99

State of North Carolina
Department of Environment •
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor NCDENR
Wayne McDevitt, Secretary NORT„ CAROL!NA DEnARTMENT CF
Ewi RON MENT AND NATURAL RESOURCES
Kerr T. Stevens, Director
WATER QUALITY SECTION
PERMIT NAME/OWNERSHIP CHANGE FORM
CURRENT PERMIT INFORMATION:
Permit Number: N/C'a_�2 Z 9 R 7 or
Certificate of Coverage Number: N/C'
1. Permit holder's name: Vulcan Materials Company
2. Permit's signing official's name and title: R.M. Poplin
(Person legally responsible for permit)
Manager, Environmental Services
(Title)
P.O. Box 4239 Winston-Salem
3 Mailing address: City:
ate: NC Zip Code: 27115 Phone 336, 767 - 4600
II. NEW OWNER/NAME INFORMATION:
1 This request for change is a result of:
Change in ownership of propertycompanv ❑ Name change only
❑ Other(please explain):
2 New owner's;operator's name(name to be put on permit;certificate of coverage):
Vulcan Construction Materials, LP
3 New owner'sioperator's or signing official's name and title: R. M. Poplin
(Person legally responsible for permit)
Manager, Environmental Services
(Title)
P.O. Box 4239 Winston-Salem
4 Mailing address: city:
State: NC Zip Code: 27115 Phone: 336) 767 - 4600
Facility Contact:
SWU-239-061899

PERMIT NAME / OWNERSHIP CHANGE FORM
THIS APPLICATION PACKAGE WILL NOT BE ACCEPTED BY THE DIVISION OF WATER
QUALITY UNLESS ALL OF THE APPLICABLE ITEMS LISTED BELOW ARE INCLUDED WITH THE
SUBMITTAL.
REQUIRED ITEMS:
1. This completed application
2. Legal documentation of the transfer of ownership(such as a contract,deed,articles of incorporation)
Certification must be completed and signed by both the current permit holder and the new applicant in the case of
change of ownership. For name change only.complete and sign the application certification.
Current Permittee's Certification:
I, R M Poplin .attest that this application for
namerownershtp change has been reviewed and is accurate and complete to the best of my knowledge. I understand
that if all required parts?f this application are n pleted and that if all required supporting information and
attachments are not in uded,t tis applic package will be returned as incomplete.
Signature: 6 Date:
November 15, 1999
Applicant's Certification:
1, R_ M Pop]j rl .attest that this application for a
nameiownership change has been reviewed and is accurate and complete to the best of my knowledge I understand
that if all required parts-,f this application of completed and that if all required supporting information and
attachments are not included.thi a 'caiion package will be returned as incomplete.
Signature: 7 y /( . " Date: November 15, 1999
THE COMPLETED APPLICATION PACKAGE,INCLUDING ALL SUPPORTING INFORMATION 8
MATERIALS,SHOULD BE SENT TO THE FOLLOWING ADDDRESS:
Stormwater and General Permits Unit
Division of Water Quality
1617 Mail Service Center
Raleigh,North Carolina 27699-1617
SWU-239-061899

CS

Vulcun
Materials Company
in _ IF
MIKE POPLIN P 0404231 6 99 `
SENIOR ENVIRONMENTAL ENGINEER WINSTON-SALEM,NOR CARO INA 27115-4239
MIDEAST DIVISION LEPH E 336 767-4600
RA(
_ ATER° MITI
November 15, 1999 POINT SOURCE Pr•
IF
Mr. Charles Weaver
Stormwater and General Permits Unit
NC Department of Environment and Natural Resources
Division of Water Quality
1617 Mail Service Center
Raleigh,NC 27699-1617
Re: Ownership Change from Vulcan Materials Company to Vulcan
Construction Materials, LP
Permit No.NC0027987, Stoneville Quarry
Dear Mr. Weaver:
Vulcan Materials Company ("Vulcan") currently holds the above referred water permit.
In connection with a corporate reorganization, Vulcan will transfer the above referenced site to its
wholly owned affiliate, Vulcan Construction Materials, LP ("VCM"), effective January 1, 2000.
Enclosed find our check in the amount of$50.00 as payment of the associated processing fee.
VCM is a Delaware limited partnership. Vulcan's current operation and employees will not
change as a result of the transfer, and VCM will continue to operate under the terms and
conditions of Vulcan's current permit. The contact information currently on file with your office
will remain the same.
Accordingly, Vulcan requests that the above referenced permit, along with all rights and
legal obligations, be transferred to VCM effective January 1, 2000. Please find enclosed a
completed Permit Name/Ownership Change Form for the above referenced site. Should you have
any questions or need further information, please call me at(336)767-4600.
Sincerely,
Mike oplin
Manager,Environmental Services
C: Frederic Smith, Bradley Arant Rose& White, LLP
stoneville water name change 11-99

State of North Carolinar wh,
Department of Environment •
and Natural Resources 011 y'
Division of Water Quality
James B. Hunt, Jr., GovernorII1CDEIIR
Bill Holman, Secretary NORTH CAROLINA DEPARTMENT OF
Kerr T. Stevens, Director ENVIRONMENT AND NATURAL RESOURCES
November 18, 1999
Mr. Mike Poplin
Vulcan Construction Materials, LP
P.O. Box 4239
Winston-Salem, North Carolina 27115
Subject: NPDES Permit Modification request
Permit NC0027987
Stoneville Quarry
Wake County
Dear Mr. Poplin:
The Division received the permit modification request and your check (# 196) for$50.00 on
November 16, 1999. Thank you for submitting this package.
Changes in the permitting fees for NPDES facilities took effect on January 1, 1999. Among those
changes was the revision of modification fees for all NPDES permits. The modification you requested is not
considered a major modification. Therefore, no fee is required for this modification request. I am returning
the check you submitted with the permit application.
If you have any additional questions concerning this permit modification, please contact me at (919)
733-5083, extension 511.
Sincerely,
// 1/111/11(qj ;7-
Charles H. Weaver,Jr.
NPDES Unit
cc: Central Files
NPDES File
it
1617 Mail Service Center,Raleigh,North Carolina 27699-1617 919 733-5083,extension 511 (fax)919 733-0719
VISIT US ON THE INTERNET @ http://h2o.enr.state.nc.us/NPDES [e-mail]

; - • RECEtVEO s�6
C. DePt. 0 �;�lR
Staff Review and Evaluation OCT 2 9 1996
NPDES Wastewater Permit " ,; 1;�_. ;, 'n!"n
FACILITY INFORMATION STREAM CHARAC I ERIS'I ICS
Facility Vulcan Materials - Stoneville Stream Name Y�' 3f1 ice
r.�z4)PC`r-e"-
NPDES No. NC0027987 Stream Class WS-IV (22-30-4)
Design Flow Variable Sub-basin 030203
Facility Class Not Rated Drainage Area (mi2) 0.4
S7Q10 (cfs) 0.0
W7Q10 (cfs)
30Q2 (cfs)
IWC (%) 100%
Proposed Changes Parameters Affected Basis for change(s)
Add Special Condition E. Engineering Analysis Moved from Effluent Page
Stream Class C to WS-IV classified 8/4/92.
Compliance Schedule: None
Special Condition(s): E. Engineering Evaluation
Permits&Engineering Comments:
Recommend renewal of NPDES permit with existing limits and with changes noted above. Facility
consists of settling cells and filtering ponds for wash water and pit flow. Facility is a granite crushing for
gravel operation.
Presently facility is inactive and no discharge is expected in the near future. Regional office will be
notified when the facility is reactivated. DMRs show no discharge from 1993 untii present.
Water classification change in 1992. Thgis reclassification does not affect existing limits, thus no changes
required. Language requiring an engineering analysis was put in effluent page of last permit with no dates
specified for submittal. To date no report has been submitted. Therefore,this requirement is being moved
to a special condition and a submission date of two months after DWQ notification is being given. If the
plant reactivates and their discharge causes turbidity or settleable solids problems, they can be made to
evaluate dredging of the first settling basin or constructing a new settling basin. Either of these options
should improve the effluent charged.
Prepared by: c_ VL9-4`J :IAA'1
Steven D. Pellei
Regional Office Evaluation and Recommendations:

- IBC, Do- Z-/ci
---I tJSRO it w �. OF 8-fi STc N C l -IM i 1- �a 2 _S tTT Lc f7 CEi.t S 4 f LrE2 i
o
?n )) Ft WA-f'�2- ,QT C (ZAr 1 t TE CJ US!$I me, 2_ Cr2l v -L
--OPE-RA-Eta r.) . PR-EN F.rTuy Q v4a-ns! isry /'71 iE a,)Q rl, t s clnn P-fs6
is f-/ PCc-1X5D NEAP- Fti ug- --- G; o ce w:L_.
6 c 9 nit`A cit-t lAm.,5-.i FA IL`3
7.6 2_£- njT NO `S}iSCL(PR.fi�
aqf vm .u'f�n
/� a Lo�IT f� G4r-71 A F 1J(JCL-tr g_N rT 72A•- ZE 14,4y 6 t
`fy Iitt��� dQ S e: ,QBCC �?l �/)S" Prz.ca ;riE1,cfj�—
4 �.."• ;: ;: ,� y,,, To Aklitt35 �/LEb e C i0A, ot:: NE--cry•
• -EA..ti LM& 0o7- t S aw,t TTt , -
r w ,
a ?x
vv‘ cwsS wS - I 22 -Jo :4
Ewe i=Vru vicnk.. IP Ee i co N b r l o E , -- ---
Sup ►v\ - 4-Er-c-fz- bU,/0- ✓10-n-GCA71 fry-. _--
-

State of North CarolinaI PDepartment of Environment,
Health and Natural Resources A •
Division of Water Quality
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary p E H N FR.
A. Preston Howard, Jr., P.E., Director
April 28, 1997
Mr. Mike Poplin
Environmental Engineer
Vulcan Materials Company
P.O. Box 4239
Winston-Salem,North Carolina 27115-4239
Subject: NPDES Permit Issuance
Permit No. NC0027987
Stoneville Quarry WWTP
Rockingham County
Dear Mr.Poplin:
In accordance with the application for a discharge permit received on September 4, 1996, the
Division is forwarding herewith the subject NPDES permit. This permit is issued pursuant to the
requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement between
North Carolina and the U.S.Environmental Protection Agency dated December 6, 1983.
The Division received your comment letter dated December 31, 1996,pertaining to the elimination of
the Engineering Report,the addition of a footnote for Monitoring Requirements, and the requirement of a
stormwater permit.
Due to concerns with poor solids settling within the settling ponds and the potential to significantly
increase the turbidity of the discharge from the ponds the Winston-Salem Regional Office recommended
inclusion of the requirement for the engineering report upon DWQ's notification. Since there is potential
for this discharge to cause turbidity problems in the receiving water(classified as Water Supply IV waters)
the Division reserves the right to require the permittee to evaluate alternatives to improve settling of solids
in the discharge. While the Division does not see a need for the report at this time, the requirement to
complete an engineering report after notification by DWQ must remain in the permit.
As with facilities with similar discharges, the DWQ requires that an ORC certify that no discharge
has taken place monthly. Therefore, the footnote you recommended for inclusion(to only submit DMRs
for those months when discharges take place)can not be added. Incidentally, the monitoring frequencies
in the general permit for mine dewatering are also monthly.
A stormwater permit is required if there is any point source discharge from the areas associated with
industrial activities due to precipitation or mine dewatering. If stormwater is discharged from your site
from outfalls other than the outfall now permitted by this NPDES permit then you are required to obtain a
stormwater permit.
If any parts, measurement frequencies or sampling requirements contained in this permit are
unacceptable to you,you have the right to an adjudicatory hearing upon written request within thirty (30)
days following receipt of this letter. This request must be in the form of a written petition,conforming to
Chapter 150B of the North Carolina General Statutes, and filed with the Office of Administrative
Hearings, Post Office Drawer 27447, Raleigh, North Carolina 27611-7447. Unless such demand is
made,this decision shall be final and binding.
Please take note that this permit is not transferable. Part II, E.4. addresses the requirements to be
followed in case of change in ownership or control of this discharge.
P.O.Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50%recycled/ 10%post-consumer paper
A

This permit does not affect the legal requirements to obtain other permits which may be required by
the Division of Water Quality or permits required by the Division of Land Resources, Coastal Area
Management Act or any other Federal or Local governmental permit that may be required.
If you have any questions concerning this permit,please contact Steve D. Pellei at telephone number
[phone], extension 516.
Sincerely,
Original Signed By
David A. GoodricA. Preston Howard, Jr.,r P.E.
cc: Central Files
Winston-Salem Regional Office,Water Quality Section
Mr. Roosevelt Childress,EPA
Permits and Engineering Unit
Facility Assessment Unit
Technical Assistance&Certification Group

•
Permit No. NC0027987
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT, HEALTH, AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards
and regulations promulgated and adopted by the North Carolina Environmental Management
Commission, and the Federal Water Pollution Control Act, as amended,
Vulcan Materials Compnay
is hereby authorized to discharge wastewater from a facility located at
Stonevillle Quarry
on NCSR 1518
Stoneville
Rockingham County
to receiving waters designated as an unnamed tributary to Buffalo Creek in the Roanoke River Basin
in accordance with effluent limitations, monitoring requirements, and other conditions set forth in Parts I,
II, III and IV hereof.
The permit shall become effective June 1, 1997
This permit and the authorization to discharge shall expire at midnight on February 28, 2002
Signed this day April 28, 1997
Original Signed By
David A. Goodrich
A. Preston Howard, Jr., P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission

Permit No. NC0027987
SUPPLEMENT TO PERMIT COVER SHEET
Vulcan Materials Company
is hereby authorized to:
1. ontinue to operate three settlin cells with recycling pump "for wash wateand filtering ponds
(for wash water and pit water flow) facility located at Stoneville Quarry, NCSR 1518,
Stoneville. Rockingham County (See Part III of this Permit), and
it
2. Discharge from said treatment works at the location specified on the attached map into an
unnamed tributary to Buffalo Creek which is classified Class WS-IV waters in the Roanoke
River Basin.

, . ., ,
, . \y„,14,iic --- 3?,,v.i. \-7/ A \--i-L\L.:..i.c.ff .)(:._?ji.--,--ri\-,41%,--,;. ,,y-r ,_
kii,
,,,„.77 „.._ ioNic. ., >) ' - tiiii,,..:,..,, ,_
_4,4-f_.4 V:
ro /-k, -- , \ *---Ngit ---tr l. - 't .4411". iSir
of-\\„_ \ji ,I, gT. ,\_ . 1 („„, p, _ ....,
•4\1\\...)Thr _../..- „.._,, c'. l5'":
j.\I : (.\3\\. (, '' _/ if/Z 15,
. .. '411\.. .
•
t/ a �`M • \, ,i,f..,,,,
Fus
its �, i
ilpo r.,•. ,
2 I ,,--\ ..// ._/ \r± cr----f ,- , soave - --Qi / \ -.. i
1 t -- ---_---_, -..‹, if ;- -- 1 r \ -- '4"fj `-,-Pcsint..‘ 41.4-1 // - y i
;-• 0 ant V/71 ')( \C\yi ( T Zi . 1
. A.; ,. .7( 1
:"(r V./ \ 1 ,1\- --7..- -- \ • )k / = :
�- �( '/(c �� ,�,�'�� • :1:� :ems s/ �, i
.. f P(r.j.:(` 4
-- _' ----/ ---)„ ..: -7-z f-T..-- \ 1 / c71' .'..' ' - '.
„----_,--„ •, ,& .‘4, •. -. i
:.
StO
4#
‘ ..._. ,. --,- , _‘, \.,..., -...! , (
c 9,i `,.,,',-, 'i
:.
0
....._ . ,, .,
.,.; 1
J 1 _ V �� '�Iti
I �• I Eli
1 4 r �� ;j' I r . `�i
� �l'io>i �-1"JZ '
H--N.A,4,' / c- L- _ -- 1A7%) (IA
) •
•
1 L , 1 C • � ' :l
4t N --5 C
-_---i-''' i •-tct4-- -/--- ,\'7, .(- - ? ' fj-..f.- -- er‘cbmg/1---.. - - 1-''',-, j)::;J:r- • i
ROAD CLASSIFICATION •SCALE 1:24 000
PRIMARY HIGHWAY LIGHT-DUTY ROAD,HARD OR 0 1 MILE
HARD SURFACE 1. 111111 IMPROVED SURFACE
SECONDARY HIGHWAY 0 7000 FEET
HARD SURFACE =MCI UNIMPROVED ROAD == = MIE —
1 0 1 KILOMETER
Latitude 36°28'44" Longitude 79°53154" ® i
Map # B19NW Sub-basin 03-02-03 CONTOUR INTERVAL 20 FEET
Stream Class WS-3Y '
QUAD LOCATION Vulcan Materials
Discharge Class 42 41 NC0027987
Receiving Stream UT to Buffalo Creek Rockingham County
Design Q Variahlp Permit expires 2/28/02 Stoneville Quarry

A. (1). EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS FINAL Permit No. NC0027987
During the period beginning on the effective date of the permit and lasting until expiration, the Permittee is authorized to discharge from outfall(s) serial number
001 into the Dan River. Such discharges shall be limited and monitored by the Permittee as specified below:
EFFLUENT CHARACTERISTICS LIMITS MONITORING REQUIREMENTS
Monthly Weekly I Daily Measurement Sample Sample
Average Average 1 Maximum Frequency Type Location'
Flow Monthly Instantaneous E
Settleable Solids 0.1 m1/I 0.2 ml/1 Monthly Grab E
Turbidity 50 NTU Monthly Grab E
pH2 Monthly Grab E
Total Nitrogen (NO2 + NO 3+TKN) Monthly Grab E
Notes:
I Sample locations: E - Effluent upstream of NCSR 1518, directly after the settling basin. Facility must take monitoring samples after a rain event.
2 The pH shall not be less than 6.0 standard units nor greater than 9.0 standard units.
BMP Conditions shall be maintained as follows:
1. The permittee shall operate the facilities in a manner which will minimize the impact on the receiving waters.
2. The permittee shall utilize sound management practices to ensure that contaminants do not enter the surface waters as a result of blasting at this site.
3. All settling basins shall be cleaned out whenever the only remaining alternate (operating) basin is approaching 80%full.
An Engineering Report shall be required as specified in Part I, Special Condition A. (2).
There shall be no discharge of floating solids or visible foam in other than trace amounts.

Part I Permit No. NC0027987
A. (2). ENGINEERING REPORT
Within two months of DWQ notification, an engineering report evaluating the dredging of the first settling
basin from the pit area or the construction of a new settling basin will be required. Continued building up
of the berm surrounding this basin carries a strong potential for increasing the turbidity and settleable
solids contained within the discharge and therefore alternatives must be evaluated. Along with this report
documentation of the spoil disposal from the dredging should accompany the results.

„ \,...- „..\t_ tx, _ =t;‘,( _•7_,._---_-2\7 .> \w-- -, , -_-,J ........ .
yv....--v,_ p 1 0 kit.;
(5, \,\ ,,,,,,T-n? f,\ -c--2_,\cvt-rjo ,
,z,-,,-2-s-.5...5 Lt (-=11-- \\,' . . _ .-.7-
'7,‘
zuit „ , 017 ,. \\. u,.... .8,0
p , fi.. i.../---,,' ,,,,-......, , \\
.c,„7_(5.
�-. ? n � _. , 11 p� .
\ --- \---•• ill '' .3 \..,..._,--51\(
--e�• �- ��� �� ',A
,� 11 .r„J�l / ��• \ _ � !"�.,f' r II 1
, ....-.) . —- ----, s--; ' ..,i.1\ 1\ c. --, e _ i-7-3
1� Dim t� /;
/, r �,.� • .al barge Poi . `�— `J�
7..y
B28_ l' •
,- ° •-•, i‘. ,\_(:-/ . (
* :;‘” ...i/fl ;ft, A--
___. :::1_, ,, ,, -----\ -. ‘..n..▪ ,_
..,c
.1 �� • Sto'e i10/ '°i ✓- ^�
ao ._., •_.--- ,1. ••.l•• 7----/ r. yi. .(,..,"--# ' ../
ill " ' '-''' .. '. "11 '-;411 ./ .rrt.\\../ :2(;-71
. 11-7i-1)'••
4 it°'►� �% � �o rse Irf
1 t N ��� 7� , � .7 - 1• ,� it
J ��;' A,- � a cM 79,.t •i , /
\ROAD CLASSIFICATION
SCALE 1:24 000
PRIMARY HIGHWAY LIGHT-DUTY ROAD,HARD OR 0 1 MILE
HARD SURFACE IMINNINEM IMPROVED SURFACE - -
SECONDARY HIGHWAY 0 7000 FEET
HARD SURFACE UNIMPROVED ROAD = == mom mom -
1 0 1 KILOMETER
Latitude 36°28'44" Longitude 79°53'54" mum
Map # B19NW Sub-basin 03-02-03 CONTOUR INTERVAL 20 FEET
Stream Class \A S -._Y- .
QUAD LOCATION Vulcan Materials
Discharge Class 42 41
NC0027987
Receiving Stream UT to Buffalo Creek Rockingham County
Design Q variahla Permit expires 2/28/02 Stoneville Quarry

1 �TO�E\J 1l_U_ QU -
•
lI WASH TOWER 7
1 I
PL AA7 AREA I
ESN LC.l� -
1'\\
it:2
�, WASH WATER. • P I T
• � SE'T'CL11.1G 6AS11�S
*I
.3 •
RECYCLE
PUMP •
•
Qu RRY WFaNE F11ZEl_ '�
S(51 EM¢ D1SCIA Aw.
t
- FILYEK` Dl pigisav;
S u P
t `
:,: ! �jETTL1N0 crs'U;
N 6AS1N
.17:1414.
SYREAM 6ED C0N4.10.0 CT ED
F1 T y
of �'c ERS�coNE �. .R .
r
F1LTER St01.kE
CHECK DAM

• . ' f • RECEIVED
N.C. Dept. of EHNR
JUN 0 9 1993
FACT SHEET FOR WASTELOAD ALLOCATION Winston-Salem
Request# 7440 Regional Office
Facility Name: Vulcan Materials Company - Stoneville Quarry
NPDES No.: NC0027987
Type of Waste: Industrial- 100%
Facility Status: Existing
Permit Status: Renewal
Receiving Stream: unnamed tributary to Buffalo Creek
Stream Classification: C
Subbasin: 03-02-03
County: Rockingham Stream Characteristic:
Regional Office: Winston-Salem USGS#
Requestor: Robson Date:
Date of Request 4/26/93 Drainage Area(mi2): 0.4
Topo Quad: B19NW Summer 7Q10(cfs): 0.0
Winter 7Q10(cfs):
Average Flow(cfs):
30Q2(cfs):
IWC(%):
Wasteload Allocation Summary
(approach taken,correspondence with region,EPA,etc.)
Facility must take monitoring samples after a rain event. Runoff from this storm event must be a major
factor constituting discharge flow from facility. Flow,setteable solids,pH,and turbidity will be influenced
by such an event,thus the monitoring samples will represent the influences of this event.
Facility may recieve Total-nitrogen and/or Total-phosphorus monitoring in the future if problems in the
area are not rectified.
An engineering report evaluating the dredgingiag of the first settling basin from the pit area or the t?
construction of a new settling basin will be required. Continued building up of the berm surrounding this
basin carries a strong potential for increasing the turbididty and settleable solids contained within the
discharge and therefore must be disuaded. Along with this report,documentation of spoil disposal from the
dredging should accompany the results. .n 0'i r.
rn '
Special Schedule Requirements and additional comments from Reviewers: r-). r r,
m
Recommended by: — Date: Zs rnAY CVO
Farrell Keough
Reviewed byInstream Assessment 1��� 'N Date: t✓P/3-10
''gional Supervisor: Date: to//--
Permits&Engineerin - Date: Z//Z % 3
RETURN TO TECHNICAL SERVICES BY: JUL 0 3 1993

2
Existing Limits
Daily Ave. Daily Max. Monitoring Frequency
Flow(mgd): monthly[Instantaneous]
Settleable Solids (ml/1): 0.1 0.2 monthly[Grab]
pH(SU): 6-9 monthly[Grab]
Turbidity(NTU): 50 monthly[Grab]
Recommended Limits
Daily Ave. Daily Max. Monitoring Frequency WQ/EL
Flow(mgd): monthly[Instantaneous-refer note on cover page]
Settleable Solids (ml/1): 0.1 0.2 monthly[Grab] WQ
pH(SU): 6-9 monthly[Grab] EL
Turbidity(NTU): 50 monthly[Grab] EL
* sampling point is upstream of SR 1518,directly after the settling basin.
Limits Changes Due To: Parameter(s) Affected
Change in 7Q10 data
Change in stream classification
Relocation of discharge
Change in wasteflow
New pretreatment information
Other(onsite toxicity study,interaction,etc.)
_x_ Parameter(s)are water quality limited. For some parameters,the available load
capacity of the immediate receiving water will be consumed. This may affect future water
quality based effluent limitations for additional dischargers within this portion of the
watershed.
OR
No parameters are water quality limited,but this discharge may affect future
allocations.

3
INSTREAM MONITORING REQUIREMENTS
Upstream Location:
Downstream Location:
Parameters:
Special instream monitoring locations or monitoring frequencies:
I N SPECIAL INFORMATION&S C IAL CONDITIONS
Adequacy of Existing Treatment
Has the facility demonstrated the ability meet the proposed new limits with existing
treatment facilities? Yes No n
If no,which parameters cannot be met? /r wt, J,
Would a"phasing in" of the new limits be appropriate?Yes ( No V
If yes,please provide a schedule(and basis for that schedule)with the regional
office recommendations:
lh.P , Il V Pir✓ Jr., un- ✓ O� �
a-(l Zy c ; .�j %�.!1, cY, 712 U G /
GE,— I (/Jlw ti�� _ , /, l C.—ta
If no,why not? !�
Special Instructions or Conditions
Wasteload sent to EPA? (Major) (Y or N)
(If yes,then attach schematic,toxics spreadsheet,copy of model,or,if not modeled,then old
assumptions that were made,and description of how it fits into basinwide plan)
Additional Information attached? (Y or N) If yes,explain with attachments.

•
Facility Name: Vualcan Materials Company - Stoneville Quarry
Permit Number: NC0027987
• Engineer: Robson
Subbasin: 03-02-03
Recieving Stream: unnamed tributary to Buffalo Creek
USGS quad#: B 1 9 N W
Request Number: 7440
Date: 4/26/93
Comments
Existing WLA checked: x
Staff Report: x
Topo checked: x site map attached to Staff Report
USGS Flows confirmed:
PIRF/ APAMS: nr
IWC Spreadsheet: nr
Stream Classification: x
Nutrient Sensitivity:
Instream Data: x telephone conversation w/Ron Linville[W-SROJ documented NTU state standard violations
History
File
Facility has history of turbidity and potential nutrient problems. WLA from early '80's attempted full-range nitrogen
and total phosphorus monitoring due to fish kills downstream. Unfortunately, documentation and site evaluation
techniques were not very rigorously pursued, (e.g. no fish tissue analysis, no evaluation of surrounding pond happenings,
dramatic climate variations not accounted for, etc.) and the facility was able to skirt any attempt at permit modification.
Staff Report and conversation with Ron Linville [W-S ROl
Facility is a granite crushing operation for gravel production. All three settling ponds have a grey, cloudy look;
obviously no settling is taking place. Much of this may be due to their construction. When the initial pond gets filled, the
facility increases the height of the bern, (earthen dam) encasing the pond. This causes a "stair-stepping" effect on the
ponds that follow and does not allow for any settling to take place. Turbidity levels as high as 70 NTU have been taken at
the sampling point, (refer attached map to Staff Report). The sampling site is after three (3) settling pond, a "wetland-like"
filtering dam area, and another settling basin; the effluent should be very clean and clear after this many impoundments...
Unfortunately, exacerbating this situation is the fact that the permit has a 50 NTU Turbidity limit as a daily average
not a maximum; W-S RO request this to be changed. Linville also would like language to require sampling be taken after
a rainfall event as this is what is really causing the problems. If we can, W-S RO would like the Fact Sheet to suggest that
the Engineer for Vulcan Materials look into the design of the settling ponds and make whatever changes are necessary to
stop the "stair-stepping" situation of discharge from one pond to the next. This may need to be required in the permit as
the #1 settling pond is at 80-90% of capacity. Language should require either a dredging of this pond, with a permitted
carrier and dump site location for the spoil, or the requirement to build a new lagoon; continued building up of the berm
should not be allowed...
The Fact Sheet will contain language recommending possible nutrient monitoring if continued problems are
documented in this area. Linville feels facility will comply with changes to rectify the NTU problems they have been
having, but if we push them too hard, (especially w/ regards to nutrients which proved to be such a problem enforcing in
the past) then the facility will fight any possible upgrades. Due to documentation of possible nutrient problems in the past,
I would like to have a paper-trail present for any possible need of such limits in the future. As pointed out by Linville,
explosives involve various nitrogen compounds.

cc: Technical Support Branch
Permits and Engineering
Rockingham Co. Health Dept.
Water Quality-Central Files
WSRO
DATE: September 17, 1992
NPDES STAFF REPORT AND RECOMMENDATIONS
Rockingham County
NPDES No. NC0027987
(proposed NCG620014)
PART I - GENERAL INFORMATION
1. Facility and Address:_. Site address:
Mr. R. M. Poplin PO Box 820
Vulcan Mtrls Co.. Stoneville Quarry Taylor Rd.
PO Box 4295 Stoneville, N. C. 27048
Winston-Salem. NC 27115
Gush m ii-t. 6 m/e 1
2. Date of Investigation: NA poNei took 827 Aw0
3. Report Prepared By: Ron Linville - tk^VG ci 30 Am/ Fr
1'p Kt4A/, D'An.ptcp ( ,so Atf -la 5v71
4. Persons Contacted and Telephone Number: I p .rt , 60 nrty uuct�
Mr. R. M. Poplin [phone] AYE — '"01(-1 b� dA►1� n,q
J4W 60n1E astt4 tl1N st lot ,
5. Directions to Site: From 220N Business in Stoneville take eeparo
770E then left on Taylor St. (NCSR1518). Quarry is _-t,kE oxioltz , cam R.4,41,11
approximately 0.7 mile on left. rUENAs
-''"A' InKir� io look At
6. Discharge Points- 001 'A AIz p,, E{c�
Latitude: 36° 28' 44" Powao
Longitude: 79° 53' 54" Na'°'vE� INvuiv,` viag.40 d5
oz..1 coo au
Nc�i
Attach a USGS Map Extract and Indicate treatment plant site `roftmenici '. .6e
and discharge point on ma
p. NtRa ri r+oN,-t,
it/tint-6
USGS Quad No.: B19NW and USGS Quad Name: Mayodan
7. Size (land available of expansion and upgrading):
Adequate.
8. Topography (relationship to flood plain included):

Not in floodplain.
9. Location of nearest dwelling: Homes To SE on SR1518.
10. Receiving stream or affected surface waters: UT Buffalo Crk.
a. Classification: C
b. River Basin and Subbasin No.: ROA 03-02-03
c. Describe receiving stream features and pertinent
downstream uses: Rural and agricultural. Receiving
stream flows into two private ponds.
PART II - DESCRIPTION OF DISCHARGE AND TREATMENT WORKS
1. Type of wastewater: % Domestic
100 % Industrial
a. Volume of Wastewater: 180,000 GPD
b. Types and quantities of industrial wastewater:
Water from the pit, stone wash water.
c. Prevalent toxic constituents in wastewater:
d. Pretreatment Program (POTWs only)
in development approved
should be required X not needed
2. Production rates (industrial discharges only) in pounds:
NA. Quarry is inactive.
a. highest month in the last 12 months:
b. highest year in the last 5 years:
3. Description of industrial process (for industries only) and
applicable CFR Part and Subpart: Granite aggregate
production.
4. Type of treatment (specify whether proposed or existing):
Existing. Three settling cells w/ recycling pumps for wash
water. Wash water and pit water flow to filtering ponds.

•
5. Sludge handling and disposal scheme:
Removed by crane with dipper to stockpile and/or fill material.
6. Treatment Plant Classification: Not rated.
7. SIC Code(s) 1423
Wastewater Code(s) Primary 41 Secondary 42
MTU Code 500 0
PART III - OTHER PERTINENT INFORMATION
1. Is this facility being constructed with Construction Grants
Funds (municipals only)?
2. Special monitoring requests: None
3. Additional effluent limits requests: Nitrogen limits are
recommended due to the previous algal blooms and fish kills
that may have been associated with high Nitrogen levels
suspected in the pit dewatering effluent.
4. Other: As this facility is inactive, the company should
notify the WSRO in a timely manner prior to resuming
operations. The reopener and toxicity clauses should remain in
the new permit (ie. Part III - E&F).
PART IV - EVALUATION AND RECOMMENDATIONS
The facility should be required to clean out all full dry settling
basins whenever the only remaining alternate (operating)
basin is approaching 80% full.
WSRO recommends that the permit be reissued as an
individual permit instead of a general permit due to
previous situations relative to the operation of this mine.
Signature of Repor Preparer
_Ale
Water Quality Regional Supervisor
Date

I
. l
Engineer Date Rec. # ,
NPDES WASTE LOAD ALLOCATION "3---g lob Af'
Vt'jcait
/ /E. Date:Name: Mitl. '� eV/ f Facility ,,
v Existing Permit No. : /UC.co gl? b 7 Pipe No. : 60 ( County: le 110 4f'ri
Proposed n
8 Design Capacity (MGD) : G d.O.S".O Industrial (% of Flow) : ADO/ Domestic (% of Flow) : C,J
_
L �/ /l C Sub-Basin: O3-O 2- -03 76
Receiving Stream: u T 63ult;6 C`ee lc Class:.
E) Reference USGS Quad: Q /7 A/14) (Please attach) Requestor: .L/a ✓c /4/4�--s Renal Office
°C (Guideline limitations, if applicable, are to be listed on the back of this form.) '
Design Temp. : Drainage Area: O . 111 r,+.'L Avg. Streamflow:
•
7Q10: r) G--t'r S Winter 7Q10: 30Q2:
ar Slope
� Location of D.O.minimum (miles below outfall) :
EE CU
Velocity (fps) : Kl (base e, per day, 20°C) : K2 (base e, per day, 20°C) :
0
c.,
0
.r Effluent Monthly Effluent Monthly,
Characteristics Average Comments Characteristics Average Comments
:A
a.
1yuO q/ "'Gel ia(INi{Ct:It� p��/��
Cl) SC T-r'1eal le yr��er ;v, c�:se4a e _slo1/ kefca�,le .Se'�/ea�lt. v I
74
ev Age rease s or�c an O.! 1�ie �4t�c i..ea:�crinq /�Oi rii vetf'U.
1 (4r6icl,47 : The .1ur6ij 47 el `L6e dseLve.Siilisi Lcause clike -74,-,404 � lie receivi'aJ
w€ )k >le
exc.eeo( .s''o Mtcl, '
Original Allocation I I
PLOTTED
Revised Allocation VT Date(s) of Revision(s)
(Please attach previous allocation)
�Conf•'rmation ---
�� 6M Z
� Date:
P epared By: De lien;; I,- e u�u ti Reviewed By: �� �. ‘Ays..
Cb 0 T I.d O'Y1 (Y•siC 1 p c�
I

For Appropriate Dischargers, List Complete Guideline Limitations Below
Effluent Monthly Maximum Daily
Characteristics Average Average Comments
Type of Product Produced / y
Lbs Da Produced Effluent Guideline Reference

NPDES WASTE LOAD ALLOCATION
1-4 do
Modeler Date Rec. #
PERMIT NO.: NC0027987 I
PERNIITTEE NAME: Vulcan Materials Company 2 kt(u(el
FACILITY NAME: Stoneville Quarry Drainage Area(mi ) 0.9 Avg. Streamflow (cfs):
Facility Status: Existing 7Q10 (cfs) 0.0 Winter 7Q10 (cfs) 30Q2 (cfs)
Permit Status: Renewal Toxicity Limits: IWC % Acute/Chronic
Major Minor Instream Monitoring:
Pipe No.: 001 '‘,
Design Capacity:
Domestic (% of Flow): Sampling point is upstream of SR 1518,directly after the settling basin.
Industrial (% of Flow): 100 % Daily Ave. ) Daily Max. Monitoring Frequency
Flow(mgd): monthly [Instantaneous]
Comments: Settleable Solids (ml/1): '0.1 0.2 monthly[Grab]
pH(SU): 6-9 monthly[Grab]
filtering ponds for wash water and pit dewatering and 3 settling cells Turbidity(NTU): 50 monthly [Grab]
with recycling pumps. WSO is recommending Nitrogen limits for this
quarry permit and we needed Tech. Support recommendations. Facility must take monitoring samples after a rain event. Runoff from this storm
event must be a major factor constituting discharge flow from facility. Flow,
setteable solids, pH, and turbidity will be influenced by such an event, thus the
RECEIVING STREAM:an unnamed tributary to Buffalo Creek monitoring samples will represent the influences of this event.
Class: C Facility may recieve Total-nitrogen and/or Total-phosphorus monitoring in the future
if problems in the area are not rectified.
Sub-Basin: 03-02-03
An engineering report evaluating the dredginging of the first settling basin from the
Reference USGS Quad: B 19NW (please attach) pit area or the construction of a new settling basin will be required. Continued
County: Rockingham building up of the berm surrounding this basin carries a strong potential for
y increasing the turbididty and settleable solids contained within the discharge and
Regional Office: Winston-Salem Regional Office therefore must be isua Along with this report, documentation of spoil disposal
from the dredging should accompany the results.
Previous Exp. Date: 1/31/93 Treatment Plant Class:
Classification changes within three miles: R
Lopyrir
Requested by: Susan obson Date: 4/23/93 C, r
Prepared by: Date: 1-/8 iq 2t- '='-'(,4 Refer : Basinwide / Streamline WLA File
Reviewed by: D te: -
—4
/' Completed By Permits & Engineering
At Front Of Subbasin
—Sob w F / /7i .3

NPDES WASTE LOAD ALLOCATION
1111
Facility Name: coy, �1►cti �G�S SA-tc�f- Crit�n� . Date
Regional Office
° Existing I Permit No. : �CX��7 9 R 7 Pipe No. : County:
so Proposed
a�
Design Capacity (MGD) : Industrial (% of Flow) : Domestic (% of Flow) :
_ Receiving Stream: Class: Sub-Basin:
R
.2
C
Reference USGS Quad: (Please attach) Requestor:
cc (Guideline limitations, if applicable, are to be listed on the back of this form.)
Design Temp. : Drainage Area: Avg. Streamflow:
7Q10: Winter 7Q10: 30Q2:
::
� Location of D.O.minimum (miles below outfall) : Slope:
E Velocity (fps) : K1 (base e, per day, 20°C) : K2 (base e, per day, 20°C) :
0
c.�
CO
H Effluent Monthly Effluent Monthly
Characteristics Average Comments Characteristics Average- Comments
�
1 ra 11
� . � mor-1n, !. s; 1 y . _ ��
a)
Original Allocation 1 I
Revised Allocation 1 1 Date(s) of Revision(s)
(Please attach previous allocation)
Prepared By: Reviewed By: Date:

{
•
For Appropriate Dischargers, List Complete Guideline Limitations Below
Effluent Monthly Maximum Daily
Characteristics Average Average Comments
Type of Product Produced Lbs/Day Produced Effluent Guideline Reference

:J9-'/r�� 5- 2 '6Z
Form`#OOL.,
#245
WASTE LOAD ALLOCATION APPROVAL FORM
Facility Name: Vulcan Materials - Stoneville
County: Rockingham Sub-basin: 03-02-03
Regional Office: WSRO Requestor: Dave Adkins
Type of Wastewater: Industrial 100
Domestic %
If industrial, specify type(s) of industry: mine dewatering
Receiving stream: UT Buffalo Creek Class: C
Other stream(s) affected: Class:
7Q10 flow at point of discharge: 0 cfs
30Q2 flow at point of discharge:
Natural stream drainage area at discharge point: 0.4 mi2
Recommended Effluent Limitations
Monthly Avg.
Qw = <0.05 MGD
+) pH = 6-8.5 SU - WQ limited
-1
E Settleable matter in discharge shall not cause settleable matter
'-' at downstream monitoring point to increase more than 0.1 ml/1
1• { above the upstream monitoring point value for settleable matter.
w { Turbidity in discharge shall not cause turbidity in downstream
R- { monitoring point to increase more than 50 Standard Turbidity
b Units above the upstream monitoring int v lue or turbidity. �f
o ko ; G/i/SL Tt�.t.Q,-s'd;4 y 54 r 4e -e xc'C. e `t
Z. ,fie N TL( ;v. Pee-eivt K.5 tAlcde-t r —liar (vLo. he,,r J
Note: it is also recommended that this discharger be required
to monitor for ammonia, nitrate + nitrite and total
phosphorus, particularly ammonia, weekly.
This allocation is: /_/ for a proposed facility
/ / for a new (existing) facility
/iTY a revision of existing limitations (pH was 6-9 SU; new
— monitoring proposed)
Li a confirmation of existing limitations
Recommended and reviewed by:
Qm , �, Ym Date: -
�
Head, Techncial Services Br nch i// � Ai Date: �, ...7-`
Reviewed by: / z
Regional SupervisorX .2%1 Date: b/
7
Permits Manager W L-�� � Date: ( , l-
�
Approved by: / 3 ��
Division Director iG /�'J Date:CEIVEu
('�
North Piedmont
Regional Office
IIY 14 1507
WATER QUALITY Div
i

Division of Environmental Management
May 11, 1982
MEMORANDUM
TO: Russell Radford, Regional Supervisor
Winston Salem Regional Office
FROM: Forrest Westall, Head
Monitoring and Technic Services Branch
SUBJECT: Allocation for Vulcan Materials, Stoneville
Rockingham County
In the past, this quarry dewatering discharge has been discussed in
connection with water quality in the two Watkins Ponds below the discharge.
In February 1981, an investigation of a fish kill in the ponds was made
by DEM. The report issued as a result of this investigation showed
excessive nutrients, particularly nitrogen, in the pond and upstream.
Since the date of the report, there has been a significant decrease in
the nutrient content in the ponds and feeding stream. It is likely
that operating procedures at the facility changed. Therefore, we do not
believe it is necessary to include nutrient limitations in the Vulcan
Materials permit at this time. However, we do feel that nutrient
monitoring should be required in order to remain aware of any further
changes in the water quality of the effluent.
If you have any questions, please do not hesitate to call us.
cc: Jennifer Buzun
RECEIVED
North Piedmont
Regional Office
MAY 14 1982
CATER GRAM Dry.
_ i