NC0040011_Authorization to Construct_19860214

vC4
qt�M
State of North Carolina
Department of Natural Resources and Community Development
Division of Environmental Management
512 North Salisbury Street • Raleigh, North Carolina 27611
James G. Martin, Governor
S. Thomas Rhodes, Secretary February 14, 1986 ,
. Paul Wilms
Director
Mr. Curtis Davis, Chairman
FEB 2, 0 Lg
Yanceyville Sanitary District
Yanceyville Utility Dept.
Main Street
Yanceyville, NC 27379
Dear Mr. Davis:
PERMITS & ENGIN ERIi
SUBJECT: Permit No. NCO040011
Authorization to Construct
Yanceyville Sanitary District
Yanceyville Wastewater Treatment
Facility Improvements
EPA Project No. C370494-02
The final plans and specifications for the subject project have been
reviewed and found to be satisfactory.
Authorization is hereby granted for the upgrade of the existing 0.125
MGD single cell stabilization lagoon to a 0.20 MGD oxidation pond to consist
of a new manual bar screen, three (3) five (5) HP surface aerators, new lagoon
influent structure, effluent polishing sand filter (gravity high rate type)
with clearwell, two (2) 660 gpm backwash pumps, an air scour backwash
system, backwash wetwell with two (2) 150 gpm backwash return submersible
Pumps, intermittent sand filter for recycled backwash, prefabricated chlorinator
building with gas chlorination system, approximately 1130 l.f. of 10-inch
effluent lie, cascade reaeration, approximately 1020 l.f. of 4-inch
force main, effluent flow metering device, access road, appurtenances,
and electrical work.
Do not proceed with construction until the Authorization -to -Award
package, EEO, and MBE documentation/certification have been reviewed, and
you are in receipt of our approval if Federal Funding is desired for
project construction.
Pollution Prevention Pays
P.O. Box 27687, Raleigh, North Carolina 27611-7687 Telephone [phone]
An Equal Opportunity Affirmative Action Employer

The Permittee shall employ an actively State certified wastewater
treatment plant operator to be in responsible charge of the wastewater
treatment facilities. Such operator must hold a valid State certificate of
the grade at least equivalent to the classification assigned to the wastewater
treatment facilities by the Certification Commission. When a new chief
operator must be obtained to be in responsible charge of the new facilities,
it is required that this be done by the time the construction of the facili-
ties is 50% completed.
This Authorization -to -Construct is issued in accordance with Part III,
Paragraph C of NPDES Permit No. NC0O4O011 issued June 29, 1984,
and shall be subject to revocation unless the wastewater treatment facilities
are constructed in accordance with the approved plans, specifications, and
supporting documents, and are in compliance with the conditions and
limitations specified in Permit No. NC0040011.
During the construction of the proposed additions/modifications,
the Permittee shall continue to properly maintain and operate the
existing wastewater treatment facilities at all times, and in such
manner, as necessary to comply with the effluent limits specified in the
NPDES Permit.
You are reminded that it is mandatory for the project to be constructed in
accordance with the North Carolina Sedimentation Pollution Control Act; and
when applicable, the North Carolina Dam Safety Act. In addition, the
specifications must clearly state what the contractors' responsibilities
shall be in complying with these acts.
The selling or free distribution of wet, dried, composted sludge or
sludge -like materials from wastewater facilities without prior review and
approval by this Division is illegal.
One (1) set of final approved plans and specifications is to be
forwarded to you, one (1) set to the Environmental Protection Agency (EPA) ,
and two ( 2 ) sets to the Corps of Engineers.
If you have any questions or need additional information, please contact
Mr. Bill Hoffman, telephone number 919/733-6900.
Sincerely,
%� R. Paul Wilms
Director
WSH/JS/aat
cc: Caswell County Health Dept.
Alley, Williams, Carmen & King, Inc.
Raleigh Corps of Engineers
Winston-Salem Regional Office
Mr. Walter Taft
Mr. Arthur Mouberry
Mr. Bobby Blowe
Ms. Brenda Chesson
Mr. W. S. Hoffman
EPA
GPF