820385_Waste Utilization Plan_20230530

WASTE UTILIZATION PLAN
Friday, March 19, 2021 U 44W .Z 7 -23
Producer: HD3 Farms
Farm Name:
Telephone # :
Type of Operation
Mill Run 82-385
PO Box 2107
Elizabethtown, NC 28337
[phone]
Feeder to Finish Swine
Number of Animals : 12598 hogs design capacity
Application Method: Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface and/or groundwater. The plant nutrients in the animal waste should be
used to reduce the amount of commercial fertilizer required for the crops in the fields where
waste is to be applied. This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil tests are strongly
encouraged so that all plant nutrients can be balanced for realistic yields of the crop to be
grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
contents of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and avaialable water holding capacities. Normally waste shall not be applied to
land eroding at greater than 5 tons per acre per year. With special pre -cautions, waste may
be applied to land eroding at up to 10 tons per acre per year. Do not apply waste on
saturated soils, when it is raining, or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed under DEM regulations. Wind
conditions should also be considered to avoid drift and downwind odor problems. To
maximize the value of the nutrients for crop production and to reduce the potential for
pollution, the waste should be applied to a growing crop or applied to bare ground not more
than 30 days prior to planting. Injecting the waste or disking will conserve nutrients and
reduce odor problems. This plan is based on waste application through irrigation for this is
the manner in which you have chosen to apply your waste. If you choose to inject the waste
in the future, you need to revise this plan. Nutrient levels for injecting waste and irrigating
waste are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for ananlysis. This waste
utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H.0217 adopted by the Environmental Management Commission.
Page 1 of 10

AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
12598 hogs X 1.9 tons waste/hogs/year = 23936.2 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
12598 hogs X 1.7 Ibs PAN/hogs/year = 21416.6 PAN/year
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be grown,
soil type and suface application.
TABLE 1 : ACRES OWNED BY PRODUCER
TRACT FIELD SOIL TYPE &CLASS -
DETERMINING PHASE
8528 3A AUTRYVILLE ALL
8528
8528_
8528-
3A
3B
�3B
AUT_RYVILLE ALL
AUTRYVILLE ALL
AUTRYVILLE ALL
8528
I 8528
3C
AUTRYVILLE ALL
;AUTRYVILLE ALL
_ - -
AUTRYVILLE ALL
AUTRYVILLE ALL
I- 3C
85 8_
8528
i-
3D
I_ 3D
8528
3E _ _
3E
LITRYVILLE ALL
AUTRYVILLE ALL
AUTRYVILLE ALL
AUTRYVILLE ALL
8528
8528
3F
- 3F
8528
CROP YIELD LBS AW COMM ACRES
CODE N/ACRE N/ACRE
BH-
SG
5.5; 270.05i
0
- 0
0
0
0
2.16
11 1001
5.5270.05
2.16
BH
1.97
SG
BH
- SG
-
1
-- 5.5
1
100
270.05
100
-270.09�
1.97
1.97
1.97.
0
BH
SG
BH
SG
BH
5
1
5
5�
100
- 27
! - 100�
270.05�
0
0,
0�
0'
0
2.16
2.16
2.89
2.89
4.66
1, 1
8528 3G_ AUTRYVILLE ALL i BH T 5.51 270.
8528 3G AUTRYVILLE ALL ; SG� 1
A— -.5.6
8528 3H ;AUTRYVILLE ALL � i BH 5.5
8528 - 3H iAUTRYVILLE ALL SG
8528 31 AUTRYVILLE ALL
8528 31 AUTRYVILLE ALL SG_ ,
8528 _5E AUTRYVILLE ALL BH 5.5
8528 5B AUTRYVILLE ALL S-d 1
8528 SC AUTRYVILLE ALL BH 5.5j
8528 - 5C AUTRYVILLE ALL SG 1'
B5_28_ 5D AUTRYVILLE ALL _ BH I 5.51
8528 5D !AUTRYVILLE ALL �SG
8528 _5E 'AUTRYVILLE ALL SH 5.5
8528 5F i AUT_RYVILLE ALL BH 5.5"
8528 i- 5E AUTRYVILLE ALL SG _ 1
8528 5F - AUTRYVILLE ALL 4 T SG 1j
8528 - 5G AUTRYVILLE ALL
8528 - 5G AUTRYVILLE ALL -SG 1
8528 5H AUTRYVILLE ALL I SH 5.5
100�
270.051
100!
0 3.8
0 3.8
01 _ 3.52
01 3.52
0 3.82
0; 3.82
0, 3.93
O3.93
100
6.
00.05
^
0
2.
1000
�0
_
2.
270.051 270.05
01
4.
100{
270.05 j 01-2.
100i 01
2.
1001 -
8528 51 AUTRYVILLE ALL SG �}! 1 100�
8528 61kAUTRYVILLE ALL BH I 5 5 270 05
8528
8528
.._-
':� 6A
613
_-_...- ---- -- -SG
AUTRYVILLE ALL SG � 1;
AUTRYVILLE ALL i BH i 5.5
AUTRYVILLE ALL SG I
AUTRYVILLE ALL BH 1 570
AUTRYVILLE ALL SG 1
AUTRYVILLE ALL j BH 5.51
RYVILLE ALL SG _11
EAVTFYVILLE ALL BH5.5 w
1001
270.051
100
F62
05-
8528
- 6B
6C
:._-
- 6C
8528
8528
100
270.05s
100
_
8528
6D
8528
8528
- 6D
01 4.11
0 4.1
W 3.1
0 5.3
0 5.3
0 2.4
0 2A
0 1.81
0' _ 1.81
0 3.2_
LBS AW APPLIC,
USED TIME
583.308 MAR-SEP
2161
SEP-MAY
531.999
MAR-SEP
197
SEP-MAY
531.6 9
MAR-SEP
197
SEP-MAY
_
583.308.
MAR-SEP
216
SEP-MAY
780.445
MAR-SEP
289
SEP-MAY
1096.40
MAR-SEP
406
S P-MAY
1026.19
MAR-SEP
.-.._...... . _
380
.
SEP-MAY
950,576
MA_R-SEP
-_ 352
SEP-MAY
1031.59
MAR-SEP
- 3821
SEP-MAY
-1061.3=
MAR-SEP
3973
SEP-MAY
1793.13
MAR-SEP
_- 664-
SEP-MAY
793.947
MAR-SEP
294
SE_P-MAY_
1290.84
_
MAR-SEP
478
SEP-MAY
707.531
MAR-SEP
S�EP-MAY
_._2621
1204.42�
MAR-SEP-
_ 446'
SEP-MAY_
1118.01
MAR-SEP
414
SEP-MAY
850.658
MAR-SEP
3151
SEP-MAY
1439.3771
MAR-SEP
5331
SEP-MAY
667.-d4
MAR-SEP_
247
SEP-MAY
502.293
MAR-SEP
186,
SEP-MAY
869.561 j
MAR-SEP
Page 2 of 10

f
8528 - 6E
8528 7C
8528 7C
8528 _ 7D�
8528 -- 7D
8528 - 7E
8528
_ 7E
8528
8A
- 8528
_ 8A-
8528
_88
8528
- SB
8528
j 8C
8528
8C
8528
8D
8528
- 8-D -
8528
AW3
8528
AW3
8528
AW5
8528 - A_W_5
528 AW 86_
8528 - AW6
8528
AW7
8528
- AW7
AUTRYVILLE ALL
AUTRYVILLE ALL
AUTRYVILLE ALL
AUTRYVILLE ALL
AUTRYVILLE ALL
AUTRYVILLE ALL
AUTRYVILLE ALL
AUTRYVILLE ALL
4UTR_YLE VIL_ALL
0&T ILLE ALL
4UTRYVILLE ALL
4UTRYVILLE ALL
SG
BC
...._ .....1
4.675
100! Oi
.........
229 0751 01
SG
1
75
oil
Be
4.675, 229.075
or
SG
1 75�
0
-
; Be
4.675: 229.075
01
- �l
SG
_
t 751!
0
Be
4.675 229.075
0
SG
1 75'
0
_
BC 4.676 229.075
0
SG
1 75
0�1,
BC
4 675 229.075
--
0l
LLE ALL SG 1 75 0"
LLE ALL BC_ 4.675j 229 075a 0`
I I P W I - I SG 1 751
LLC FILL
IIFAII
.0 r%LL
.E ALL
.E ALL
.E ALL
.E ALL
.E ALL
01
5.5 270 05+
SG 1 100-� 0,
BH 5.5 270.651 0
SG 1 --106 - 0
BH 5.5 _270.05 0}
SG 1 100 0!
Be 4.6751 229.0751 0
3.22 3 2 SEP-MAY
2.44 558.943 MAR-SEP
2,44 1831 SEP-MAY
1.75
400.881 i MAR-SEP
131.25 SEP-MAY
1.75
4.58
1049.16 MAR-SEP
4.58
343.5's SEP-MAY
11700.57JMAR-SEP
6.11
511
-
383.25t SEP-MAY
107$941_MAR SEP
4 71
4.71
353.251 SEP-MAY
3.87
886.520fTMAR-SEP
3.87
290.25 SEP-MAY
710.133 MAR-SEP
3.1
3.1
232.5 SEP-MAY
4.26
1150.41 ] MAR-SEP
4.26
426 SEP-MAY
1.21 324.06. MAR-SEP
1.2 120 SEP-MAY
2.7 729.135 MAR-SEP
2.7 270 SEP-MAY
5.52 1264.49 MAR-SEP
SG 1 • 75 _ - TQTALS� �38073 2SEP MAY
Indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow
summer annuals.
* Indicates a Crop Rotation
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirments. Beginning in 1996 the Coastal Zone Management Act will require farmers in
some eastern counties of NC to have a nutrient management plan that addresses all
nutrients. This plan only addresses Nitrogen.
Page 3 of 10

TABLE 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land. See required specifications 2.)
There are no Acres Leased
Indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow
summer annuals.
* Indicates a Crop Rotation
* Acreage figures may exceed total acreage in field due to overseeding.
**Lbs AW N (animal waste nitrogen) equals total required nitrogen less any commercial
nitrogen (COMM N) supplied.
The following legend explains the crop codes used in TABLES 1 and 2 above:
CROP CODE CROP UNITS LBS N/UNIT
BC HYBRID BERMUDAGRASS-CON TROLLED GRAZED TONS 50
_BH HYBRID BERMUDAGRASS-HAY TONS _ 50---1
S� G SMALL GRAIN OVERSEEDED AC 50
Page 4 of 10

TOTALS FROM TABLES 1 AND 2
ACRES LBS AW
N USED
TABLE 1 111.13 39 073
TOTALS: 111.13 39,073
AMOUNT OF N PRODUCED: 21,417
"BALANCE -17,657
*** This number must be less than or equal to 0 in order to fully utilize the animal waste N
produced.
Acres show in each of the preceeding tables are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter
areas not receiving full application rates due to equipment limitations. Actual total acres in the
fields listed may, and most likely will be, more than the acres shown in the tables.
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of
sludge at agronomic rates. The sludge will be nurturient rich and will require precautionary
measures to prevent over application of nutrients or other elements. Your production facility
will produce approximately 4661.26 pounds of plant available nitrogen (PAN) per year in the
sludge that will need to be removed on a periodic basis. This figure is PAN when
broadcasting the sludge. Please be aware that additional acres of land, as well special
equipment, may be needed when you remove this sludge.
See the attached map showing the fields to be used for the utilization of waste water.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil at the time of
irrigation such that runoff or ponding occurs. This rate is limited by initial soil moisture
content, soil structure, soil texture, water droplet size, and organic solids. The application
amount should not exceed the available water holding capacity of the soil at the time of
irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of the
crop.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 5.92 months. In no instance should the volume of
waste being stored in your structure be within 1.58 feet of the top of the dike.
If surface irrigation is the method of land application for this plan, it is the responsiblity of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in Tables 1 and 2. Failure to apply the recommended rates and
amounts of Nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application rates and amounts.
APPLICATION APPLICATION
TRACT FIELD SOIL TYPE_ CROP RATE (inlhr) A_MIT (inches)
8528 5G,�5H,-6A, 6s 6C, e AUTRYVILLE ALL SG — 0 60
8528 B SC, 5D, SE 5F SG Sil 6 AUTRYVILLE ALL BH 0 60 *1
8528 7D, 7E, 8A, 8B. 8C, 8D, A AUTRYVILLE ALL BC 0.60 ( *1
* This is the maximum application amount allowed for the soil assuming the amount of
nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Page 5 of 10

NARRATIVE OF OPERATION
Acreages based on Wettable Acres design by Dawn Williamson dated 9/27/00. The latest
RYE and nitrogen co -efficient were used. Aerway may be used on this farm including the
acres designated AW.
Page 6 of 10

PLANS & SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited. Illegal discharges are subject
to assessment of civil penalties of $10,000 per day by the Division of Water Quality for every
day the discharge continues.
2. The Field Office must have documentation in the design folder that the producer either
owns or has long term access to adequate land to properly dispose of waste. If the producer
does not own adequate land to properly dispose of waste, he shall provide NRCS with a copy
of a written agreement with a landowner who is within a reasonable proximity, allowing
him/her the use of the land for waste application for the life expectancy of the production
facility. It is the responsibility of the owner of the facility to secure an update of the Waste
Utilization Plan when there is a change in the operation, increase in the number of animals,
method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climate conditions, and level of
management, unless there are regulations that restrict the rate of application for other
nutrients.
4. Animal waste may be applied to land that has a Resource Management System (RMS) or
an Alternative Conservation System (ACS). If an ACS is used the soil loss shall be no greater
than 10 tons per acre per year and appropriate filter strips will be used where runoff leaves
the field. These filter strips will be in addition to "Buffers" required by DEM. (See FOTG
Stantard 393 - Filter Strips and Standard 390 Interim Riparian Forest Buffers).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland, the
waste may be broadcast provided the application does not occur during a season prone to
flooding. (See "Weather and Climate in North Carolina" in the NRCS Technical Reference -
Environment file for guidance.)
*7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control conditions
conducive to odor or flies and to provide uniformity of application.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with
a high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste shall
not be applied more than 30 days prior to planting of a crop on bare soil.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following:
the outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and from anv oerennial stream or river (other that an irriaation ditch or canal. Animal waste
Page 7 of 10

other than swine waste from facilities sited on or after October 1, 1995), shall not be applied
closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal Waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landownwer.
14. Waste shall be applied in a manner not to reach other property and public right - of ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted croplands
provided they have been approved as a land application site by a "technical specialist".
Animal waste should not be applied on grassed waterways that discharge directly into water
courses, except when applied at agronomic rates and the application causes no runoff or drift
from the site.
*16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
shall not be discharged into the animal waste management system.
*17. A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). If needed, special vegetation shall be
provided for these areas and shall be fenced, as necessary, to protect the vegetation.
Vegetation such as trees, shrubs, and other woody species, etc. are limited to areas where
considered appropriate. Lagoon areas should be kept mowed and accessible. Lagoon berms
and structures should be inspected regularly for evidence of erosion, leakage or discharge.
*18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the possibility
of an illegal discharge, pollution and erosion.
*19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks, and spills. A regular maintenance checklist should be
kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied as a preemergence with no other applications of
animal waste during the crop season.
*21. Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to mark
the maximum storage volume fpr waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soils shall be monitored and alternative crop sites
shall be used when these metals approach excessive levels. pH shall be adjusted for
optimum crop production amd maintained. Soil and waste analysis records shall be kept for
five (5) years. Poultry dry waste application records shall be maintained for three (3) years.
Waste application records for all other waste shall be maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina Department of
Agriculture regulations.
* Liquid Systems
Page 8 of 10

Brown Far-m---s-
;JI
wL,
W
V
kRR
PM
596
ar,

NAME OF FARM: Mill Run 82-385
OWNER / MANAGER AGREEMENT
I (we) understand and will follow and implement the specifications and the operation and
maintenance precedures estalished in the approved animal waste utilization plan for the farm
named above. I (we) know that any expansion to the existing design capacity of the waste
treatment and/or storage system or construction of new facilities will require a new utilization
plan and a new certification to be submitted to DEM before the new animals are stocked.
I (we) understand that I must own or have acces to equipment, primarily irrigation equipment,
to land apply the animal waste described in this waste utilization plan, This equipment must
be available at the appropriate pumping time such that no discharge occurs from the lagoon
in a 25-year 1-day storm event. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates that no runoff occurs.
NAME OFF OWNER: HD3 Farms
SIGNATURE: - DATE:.5��
NAME OF MANAGER (if different from owner):
SIGNATURE:
please print
DATE:
NAME OF TECHNICAL SPECIALIST: Curtis Barwick
AFFILIATION: Barwick Ag Services
ADDRESS (AGENCY): 103 Country Club Circle
Clinton, NC 28328
(910 385-1000 r
SIGNATURE: � DATE:
�-� % ,2 3
Page 10 of 10

5
0
r
Jr
M
• ��y 1__y' _ 1
ry
J�
q

z JK
99
y
lzr
r*qmv
Wit
paw
41
'
� a �; ' • �
�
.•R. a�r
�Cr
F .,
Is
•
Y. ,fit•
.
..�N
�• �
e
tam
.g' •.
It '�
�, �•; :{.
Q,
go
31odimi"
�`
r
iiiiP"
y
^t
sL
ax�awa
H 99
Esc se ..vl -
m+
�d, 9aN4os jy a aeaue''
1
1 i E 3.9xFr llo n
�` 'sL A� 99£

34
RISER
h'
N sruT., E
s6r4M"E
3 30.32'
SIGdT POLE
38
1162 :
62
20
RIS
° jJ _ l
33
RISER
32
RISER �RISER
26
&
31
Vill 30 29
.60 1 CEIRETERY RIW.R
CLOI ACRES+-
-GMT POLE

Updated Crop Management Practices for Bermuda Winter Overseed
This document, as approved by the Interagency Nutrient Management Committee on
October 10, 2017, hereby modified the July 13, 1998 Memorandum "Crop Management
Practices for Select Forages Used in Waste Management". This modification u dates
the application window protocol for the 100 lb Nitrogen PAN rate for both Cerea S y
and Annual Ryegrass, as well as winter small grains.
• Farms utilizing the 100 Ibs.lac PAN rate for the overseed are allowed to appy no
more than 50 lbs./ac PAN from October 1 through December 31 and no mare than
50 lbs./ac PAN from January 1 through March 31.
• Applications made during the months of December and January cannot exceed the
combined total of 25 lbs./ac PAN for the two -month period.
• The last application of animal waste is to be applied to the bermuda crop prior to
September 30.
The PAN rate for grazed systems must be reduced by 25%.
All other requirements of the July 13, 1998 Memorandum continue to apply. Those
requirements include but are not limited to:
Cereal rye and annual ryegrass should be planted by October 15 to provide the best
opportunity to get winter growth.
A harvest is required prior to heading or April 7, whichever comes first, for bdth
cereal rye and annual ryegrass. This is necessary to minimize the potential ibr
shading of emerging bermuda and reducing its yield. To favor the productioip of
bermuda, additional harvest of annual ryegrass will be required when the ryegrass
canopy reaches 12-15 inches height.
hese management requirements shall also apply to overseeded winter small grWn.
A - /I A-,
6/f-
Nov 16, 2017