NC0064734_Permit Issuance_20081222

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
December 22, 2008
Martin Lashua, Regional Director
Carolina Water Service Inc. of NC
P.O. Box 240908
Charlotte, North Carolina 28224
Subject: Issuance of NPDES
Permit NCO064734
Bradfield Farms WWTP
Cabarrus County
Dear Mr. Lashua:
Coleen H. Sullins, Director
Division of Water Quality
Division personnel have reviewed and approved your application for renewal of the subject permit. Accordingly,
we are forwarding the attached NPDES discharge permit. This permit is issued pursuant to the requirements of
North Carolina General Statute 143-215.1 and the Memorandum of Agreement between North Carolina and the
U.S. Environmental Protection Agency dated October 15, 2007 (or as subsequently amended).
On November 12, 2008 the Division received your request to change the Instream sampling frequency from three
times per week to once per week year round during the months of June through September for temperature,
dissolved oxygen and fecal coliform. Attachment A (1) Footnote 1 has been changed with the reference to
34veek sampling being deleted from your draft permit. Effluent flows below 0.460 MGD place your facility in a
Class II category. Attachment A (2) addresses flows which exceed 0.0460. These effluent flow levels change
your facility to a Class III which requires three times a week sampling for Instream parameters. Your other
If any parts, measurement frequencies or sampling requirements contained in this permit are unacceptable to
you, you have the right to an adjudicatory hearing upon written request within thirty (30) days following receipt of
this letter. This request must be in the form of a written petition, conforming to Chapter 150E of the North
Carolina General Statutes, and filed with the Office of Administrative Hearings (6714 Mail Service Center,
Raleigh, North Carolina 27699-6714). Unless such demand is made, this decision shall be final and binding.
Please note that this permit is not transferable except after notice to the Division. The Division may require
modification or revocation and reissuance of the permit. This permit does not affect the legal requirements to
obtain other permits which may be required by the Division of Water Quality or permits required by the Division of
Land Resources, the Coastal Area Management Act or any other Federal or Local governmental permit that may
be required. If you have any questions concerning this permit, please contact Bob Guerra at telephone number
[phone].
Sincerely,
h Coleen H. Sullins
Enclosure: NPDES Permit C0064734
cc: Central Files
Mooresville Regional Office / Surface Water Protection
NPDES Unit
tCarolina
ura!!y
North Carolina Division of Water Quality 1617 Mail Service Center Raleigh, NC 27699-1617 Phone [phone] Customer Service
Internee wwwmcwateraualitv.ore location: 512 N. Salisbury St. Raleigh, NC 27604 Fax [phone]
An Equal OpporluniWAf nnative Action Employer-50% Recycled110% Post Consumer Paper

Permit NCO064734
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF ENVIRONMENTAL MANAGEMENT
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provisions of North Carolina General Statute 143-
215.1, other lawful standards and regulations promulgated and adopted by the
North Carolina Environmental Management Commission, and the Federal
Water Pollution Control Act, as amended,
Bradfield Farms Water Company
is hereby authorized to discharge wastewater from a facility located at the
Bradfield Farms WWTP
4250 John Bostar Road
Harrisburg
Cabarrus County
to receiving waters designated as the McKee Creek in the Yadkin -Pee Dee River Basin,
in accordance with effluent limitations, monitoring requirements, and other
conditions set forth in Parts I, II, III and IV hereof.
This permit shall become effective February 1, 2009.
This permit and authorization to discharge shall expire at midnight on
November 30, 2013.
Signed this day December 22, 2008.
L
%rk- Coleen H. Sullins, Director
jDivision of Water Quality
By Authority of the Environmental Management Commission

Permit NCO064734
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility, whether for operation or
discharge are hereby revoked. As of this permit issuance, any previously
issued permit bearing this number is no longer effective. Therefore, the
exclusive authority to operate and discharge from this facility arises under the
permit conditions, requirements, terms, and provisions included herein.
Bradfield Farms Water Company is hereby authorized to:
1. Continue to operate an existing 0.460 MGD wastewater treatment facility
that includes the following components:
➢ Influent lift station
➢ Bar screen and flow splitter box
➢ Dual surge tanks
➢ Aeration basins
➢ Secondary clarifiers
➢ Sludge holding tanks
➢ Chlorine contact tanks with gas chlorination
➢ Traveling bridge tertiary filters
➢ Post aeration tanks
2. This facility is located at the Bradfield WWTP, 4250 John Bostar Road in
Cabarrus County.
3. After receiving an Authorization to Construct from the Division of Water
Quality, construct and operate additional wastewater treatment facilities
making the build -out treatment capacity of 0.6 MGD; and
4. Discharge from said treatment works at the location specified on the
attached map into the McKee Creek, classified C waters in the Yadkin -Pee
Dee River Basin.

Bradfield Farms Water Company
Bradfield Farms WWTP
350 15' 32" N
State Grid:
Harrisburg
800 38' 45" W
Permitted Flow:
0.700 MGD
McKee Creek
Drainage Basin:
Yadkin -Pee River Basin
C
Sub -Basin:
03-07-11
Facility
ei
Location
not to scale
r
NPDES Permit No. NCO064734
North
Cabarrus County

Permit NCO064734
A. (1) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
During.the period beginning on the effective date of this permit and lasting until expiration or expansion
above 0.460 MGD, the Permittee is authorized to discharge treated wastewater from outfall 001. Such
discharges shall be limited and monitored by the Permittee as specified below:
xPARAMETER� ` Rrh
•.f..h '.
- LIM_.S
SFJ X -h DSv_ i
,,,,� :M011iITORING
-
DIRE f K ,
SI1.
�a
_2
Monthly
r,r,aiTy=sMeasurementp,rySame
,
Avers a
nhen
:�Location=:
F
Y
Y
Flow
0.460 MGD
Continuous
Recording
Influent or
Effluent
BOD, 5-day, 200C
9.0 mg/L
13.5 mg/L
Weekly
Composite
Effluent
(April 1 - October 31
BOD, 5-day, 20°C
18.0 mg/L
27.0 mg/L
Weekly
Composite
Effluent
Nov 1 - Mar 31
Total Suspended
30.0 mg/L
45.0 mg/L
Weekly
Composite
Effluent
Solids
NH3 as N
2.0 mg/L
10.0 mg/L
Weekly
Composite
Effluent
(April 1- Oct 31
NH3 as N
4.0 mg/L
20.0 mg/L
Weekly
Composite
Effluent
Nov 1 - March 31
Temperature
Daily
Grab
Effluent
Temperature
Weekly
Grab
U & D
pH2
Weekly
Grab
Effluent
3
Weekly
Grab
Effluent
Dissolved Oxygen
Dissolved Okygen
Weekly
Grab
U & D
Total Residual
21.0 µg/L
2/Week
Grab
Effluent
Chlorine4
Fecal Coliform
200/ 100 ml
400/ 100 ml
Weekly
Grab
Effluent
(geometric mean
Fecal Coliform
Weekly
Grab
U & D
(geometric mean
Total Nitrogen
Quarterly
Composite
Effluent
NO2 + NO3+ TKN
Total Phosphorus
Quarterly
Composite
Effluent
Footnotes:
1. U: upstream at least 100 feet from outfall. D: downstream at least 200 feet from the
outfall.
2. The pH shall not be less than 6.0 standard units nor greater than 9.0 standard units.
3. The daily average dissolved oxygen effluent concentration shall not be less than 5.0
mg/ L.
4. The Division shall consider all effluent TRC values reported below 50 ug/ 1 to be in
compliance with the permit. However, the Permittee shall continue to record and
submit all values reported by a North Carolina certified laboratory (including field
certified), even if these values fall below 50 ug/l.
All samples collected should be from a representative discharge event.
There shall be no discharge of floating solids or visible foam in other than
trace amounts.

Permit NCO064734
A. (2) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
Beginning upon expansion above 0.460 MGD and lasting until expiration, the Permittee is authorized to
discharge treated wastewater from outfall 001. Such discharges shall be limited and monitored by the
Permittee as specified below:
p AuaturrF
�r .�;� �r °
' L ITS
`�:M w,. ,. �i ,,
t �.
,,� ONL RE
RiN
�:,,` x ,., ,.,GI=,
Daily`
��ll�s et CY
eamen
Type���
i�
,Average
=imam`�
Max
�
44 �4 �-r. yr �
h1
t'
.-rr
i/V VRt�On
Flow
0.700 MGD
Continuous
Recording
Influent or
Effluent
BOD, 5-day, 20°C
9.0 mg/L
13.5 mg/L
3/Week
Composite
Effluent
(April 1 - October 31
BOD, 5-day, 20°C
18.0 mg/ L
27.0 mg/ L
3/Week
Composite
Effluent
Nov 1 - Mar 31
Total Suspended
30.0 mg/ L
45.0 mg/ L
3/Week
Composite
Effluent
Solids
NH3 as N
2.0 mg/ L
10.0 mg/ L
3/Week
Composite
Effluent
(April 1-Oct 31
NH3 as N
4.0 mg/L
20.0 mg/L
3/Week
Composite
Effluent
Nov 1 - March 31
Temperature
Daily
Grab
Effluent
Temperature
3/Week
Grab
U & D
pH2
3/Week
Grab
Effluent
3
3/Week
Grab
Effluent
Dissolved Oxygen
Dissolved Oxygen
3/Week
Grab
U & D
Total Residual
20.0 µg/L
3/Week
Grab
Effluent
Chlorine4
Fecal Coliform
200 / 100 ml
400 / 100 ml
3/Week
Grab
Effluent
(geometric mean
Fecal Coliform
3/Week
Grab
U & D
(geometric mean
Total Nitrogen
Quarterly
Composite
Effluent
NO2 + NO3+ TKN
Total Phosphorus
Quarterly
Composite
Effluent
Footnotes:
1. U: upstream at least 100 feet from outfall. D: downstream at least 200 feet from the
outfall. Instream samples shall be collected 3/week during June through September
and once per week during the remaining months of the year.
2. The pH shall not be less than 6.0 standard units nor greater than 9.0 standard units.
3. The daily average dissolved oxygen effluent concentration shall not be less than 5.0
mg/ L.
4. The Division shall consider all effluent TRC values reported below 50 ug/ 1 to be in
compliance with the permit. However, the Permittee shall continue to record and
submit all values reported by a North Carolina certified laboratory (including field
certified), even if these values fall below 50 ug/l.
There shall be no discharge of floating solids or visible foam in other than
trace amounts.

Utilities, Inc.'
November 12, 2D08
Mr. Bob Guerra
NPDES Unit, Western Program
Division of Water Quality
1617 Mail Service Center
Raleigh, NC 27699-1617
Ref: Bradfield Farms Draft Permit
NCO064734
Dear Mr. Guerra,
We are in receipt of your October 22, 2008 letter and draft permit for the above referenced facility. We have reviewed the draft
and have two comments. The proposed In -stream sampling requires the temperature; d itiWd'd)Wdn and fecal col'rform to
be sampled three times per week during the months of June through September. We would like to request that the sampling of
these three parameters dissolved oxygen, temperature and fecal coliform for in -stream sampling be reduced to once per week
all year long. We do not see any added benefit of the extra sampling of these two parameters for the months requested.
We would also like to have the downstream sampling point changed from the current location of NCSR 1169 to approximately
200' downstream of discharge. The bridge location is unsafe due to the volume of traffic on the roadway and the incline down to
the stream from the roadway presents a footing hazard.
Thank you for the consideration of these two items and should you have any questions or need additional information please do
not hesitate to contact meat 704-525-7990 ext 218 or e-mail [e-mail] .
Sincere ly,,
Tony Konsul
Regional Manager
Cc; Martin Lashua
Mary Armentrout
Mark Haver
auGim kx.=93vBradfield Farms Water Co.
P.O. Box 240908 0 Charlotte, NC 213224 i P. 704-525.7990 i F: 704-525.8174
5701 Westpark Dr., Suite 101 • Charlotte, NC 28217 i www.uWater.com

The Charlotte Observer Publishing Co.
Charlotte, NC
North Carolina ) ss Affidavit of Publication
Mecklenburg County)
THE CHARLOTTE OBSERVER
---------------------------------------------------------------------------
DINA SPRINKLE
NCDENR/DWO/POINT SOURCE BRANCH
1617 MAIL SERVICE CENTER
RALEIGH NC 27699
REFERENCE: 30063432
6262871 NPDES N00064734
Before the undersigned, a Notary Public of said
County and State, duly authorized to administer
oaths affirmations, etc., personally appeared,
being duly sworn or affirmed according to law,
cloth depose and say that he/she is a
representative of The Charlotte Observer
Publishing Company, a corporation organized and
doing business under the laws of the State of
Delaware, and publishing a newspaper known as The
Charlotte Observer in the city of Charlotte,
County of Mecklenburg, and State of North Carolina
and that as such he/she is familiar with the
books, records, files, and business of said
Corporation and by reference to the files of said
publication, the attached advertisement was
inserted. The following is correctly copied from
the books and files of the aforesaid Corporation
and Publication.
PUBLISHED ON: 10/24
AD SPACE: 132 LINE
FILED ON: 10/31/08
I_ PueL6^. NoncE
ENVIRONMENTAL MANAGEMEW COMM IN ON/NPDES UNn
1617 MAIL SERVICE CEMEfl
NOTIFICannGH. NC 2)699_1617
NAME:11-S'Y1 A;�� A4,lk" TITLE:
DATE:
In Testimony Whereof I have hereunto set my hand and affixed my seal, the
day and y ar aforesaid.
MYtOlnlllllssion Lyres May
17,
2011
Notary c ,
y—I.omm ssion Expires:

MR.' .-
470 it'
10 2008 Tole Alias
lip
A
,3wS Je7

lip
_v
�•. '!`mil � ..S`' .[\
a T.
n
A
I� J

r
d4 +

-'*. - : - '. of
I

F.
P 4"
m
,�m

- - ..:
- ^-. 1 .�
�. _
Y JJ
'-,. „.:J
..... ..•+i.��7

Irp
I

irn
��i%"� Fyn :r s +. 7�,� `r, � RS.S '�`.�<fi-<yf°,aar� �t t �" u •t "'�' 9� � _,.,��t��„�,�, +u,. ..,i..
i .:,.y, ,\,4 •'�N"Arw�'�+, ?:. t '" `�y� !%w 9!4'' ,yr. `+dsa - 1 K�,�,E 'a
r ,
.• ^ E 1 Yanft �,� J ' �r���.+A v�jYA� t% i �� r e{{`wT v Ys4 ��" �'%f �' TJ�"1�
� a M) JI i _.. �4Y6f: % aJ is rlp°"�'" • ! 0•". �h�d adf�\`(�!'?�
fie'&?te

7-
--1
0 "" .
�l
AIS

onn
' Bono
�aoe❑ �
w -
® 3010
Ultrasonic
Flow TrammlUer —
L.

S J
N
�:�� it _ .. .M•
n
W
S
-
tF
J w
wave,
,
ag
Yn �\

`�` �' .�,. �4. �"� � �. ,,�x���.•rr .' � :,,: :�'�1:. b i}+'+Y�r(�w. art, `, f�..- ` ,\. ,.<
414
r i ` ¢ f w!, . � V t a•1.Y �. _ n't�'�"�';lt' �'� ` �� � �.`i »�yK1 i
�t3 J y .
40
wt.y
A� J
wMC.
q�1 9m- Y
f4 7A,
i

��� %�„�_� x—' ,.Y�t� �M- •ea" i�'
�F�>_
.. _ _ � _ _ =� SL"'_ e�'"Ys'.1,.`'iYK ��• .,ems. .`! s���!j
mow. .L .- - - - "♦ � _" - _ - � � v._ _ �__ - �'.
=e ::

AIR

SOC PRIORITY PROJECT: Yes —No x
If Yes, SOC No.
To: Western NPDES Program Unit
Surface Water Protection Section
Attention: Dina Sprinkle
Date: May 14, 2008
NPDES STAFF REPORT AND RECOMMENDATION
County: Cabarrus
PART I - GENERAL INFORMATION
1. Facility and Address: Bradfield Farms W WTP
Carolina Water Service, Inc. of NC
P.O. Box 240908
Charlotte, NC 28224
2. Date of Investigation: 05/08/08
5
��li Ali
MAY 2 1 2008
3. Report Prepared By: Samar Bou-Ghazale, Environmental Eng. II
4. Persons Contacted and Telephone Number: Mr. Larry Henry; 704/361-0641 / Sip dC?7 q
5. Directions to Site: From the junction of Robinson Church Road (S.R. 1168) and peach
Orchard Road (S.R. 1169) in southwestern Cabarrus County, travel southeast on S.R.
1169 approximately 1.5 miles and turn right on Joan Bostar lane (S.R. 2951). Travel
approximately 0.4 mile on S.R. 2951 and turn right onto a gravel access road. The
wastewater treatment plant is located at the end of this road.
6. Discharge Point(s). List for all discharge points:
Latitude:35°15'32" Longitude:80°38'45"
Attach a U.S.G.S. map extract and indicate treatment facility site and discharge point on
map.
U.S.G.S. Quad No.: F 16 SW U.S.G.S. Name: Harrisburg, N.C.
7. Site size and expansion are consistent with application?

Yes x No_ If No, explain:
8. Topography (relationship to flood plain included): Rolling 3-12% slopes. The site is not
located in a flood plain area.
9. Location of nearest dwelling: None within 500 feet. This office has recommended that
no dwellings be located closer than 200 feet from the wastewater facility.
10. Receiving stream or affected surface waters: Mckee Creek
a. Classification: C
b. River Basin and Subbasin No.: Yadkin; 030711
C. Describe receiving stream features and pertinent downstream uses: The receiving
stream was approximately 20-25 feet wide. Stream channel was well defined and
no detrimental effects were observed as a result of the discharge. General C
classification uses downstream.
PART II - DESCRIPTION OF DISCHARGE AND TREATMENT WORKS ' '
1. a. Volume of wastewater to be permitted: 0.700 MGD (Ultimate Design Capacity)
b. What is the current permitted capacity of the wastewater treatment facility? 0.700
MGD
C. Actual treatment capacity of the current facility (current design capacity)? 0.700
MGD
d. Date(s) and construction activities allowed by previous Authorizations to
Construct issued in the previous two years: N/A
e. Please provide a description of existing or substantially constructed wastewater
treatment facilities: The existing wastewater treatment facilities consist of an
influent lift station, influent bar screen/flow splitter box, and two identical
WWTPs; each plant consists of a surge tank, an aeration basin, a secondary
clarifier, an aerated sludge holding tank, an effluent flow recorder and totalizer, a
tablet chlorinator and contact tank, tablet de -chlorinator, stand-by power supply, a
traveling bridge tertiary filter, and a post aeration tank.
f. Please provide a description of proposed wastewater treatment facilities: N/A
Page 2

g. Possible toxic impacts to surface waters: None at this time.
h. Pretreatment Program (POTWs only): N/A
2. Residuals handling and utilization/disposal scheme: N/A
a. Other disposal/utilization scheme (specify): Waste sludge is removed and
transported by Bio-Tech, Inc., to a facility located in South Carolina for final
disposal (permit# ND0069761).
3. Treatment plant classification (attach completed rating sheet): Class II
4. SIC Code(s): 4952
Wastewater Code(s):
Primary: 05 Secondary:
Main Treatment Unit Code:
PART III - OTHER PERTINENT INFORMATION
1. Is this facility being constructed with Construction Grant Funds or are any public monies
involved (municipals only)? N/A
2. Special monitoring or limitations (including toxicity) requests: None at this time.
3. Important SOC, JOC or Compliance Schedule dates: (please indicate) N/A
4. Alternative Analysis Evaluation: Has the facility evaluated all of the non -discharge
options available? The applicant was not required to submit alternative analysis
evaluation since the facility is not in substantial non-compliance with the terms and
conditions of the NPDES permit.
Please provide regional perspective for each option
evaluated: N/A
Spray Irrigation: N/A
Subsurface: N/A
Connection to Regional Sewer System: No regional sewer system is available in the
Page 3

vicinity.
Air Quality and/or Groundwater concerns or hazardous materials utilized at this facility that
may impact water quality, air quality, or groundwater: No AQ or GW concerns nor are
hazardous materials utilized at this facility with the exception of chlorine.
6. Other Special Items: N/A
PART IV - EVALUATION AND RECOMMENDATIONS
The permittee, Carolina Water Service, Inc. of NC is applying for renewal of the permit
to discharge treated domestic wastewater.
The wastewater treatment plant appeared to be in good operational condition during the
time of the investigation.
Pending review and approval by the Western NPDES Program Unit, It is recommended
that the NPDES permit for this facility be reissued.
-
Signature of Report P arer
/C1"rZ/,--
Surface Water Protection Regional Supervisor
Date
Page 4

Utilities, Inc'
April 10, 2008
Mrs. Dina Sprinkle
NC DENR
Division of Water Quality
Point Source Branch
1617 Mail Service Center
Raleigh NC 27699-1617
Re: Bradfield Farms WNTP
NPDES NC0064734
Renewal Request
Dear Mrs. Sprinkle,
COPY
Please find enclosed Application and attachments and consider this letter as our official request to renew the NPDES permit for
the facility referenced above.
If you should have any questions or need any additional information, please do not hesitate to call me at 704-525-7990 x 218 or
by email at tikonsulno uiwater.com
Thank you in advance for your attention.
Sincerely, \
Tony onsul
Regional Manager
Cc: Martin Lashua
Mary Armentrout
a uses, im mffwy Bradfield Farms Water Co.
P.O. Box 240908 e, Charlotte, NC 28224 = P: 704-525-7990 < F: 704525-8174
5701 Westpark Dr., Suite 101 Charlotte, NC 28217 : www.uiwater.com

NPDES APPLICATION - FORM D
For privately owned treatment systems treating 100% domestic wastewaters <1.0 MGD
Mail the complete application to:
N. C. Department of Environment and Natural Resources
Division of Water Quality / NPDES Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
NPDES Permit 000064734=
If you are completing this form in computer use the TAB key or the up — down arrows to move from one
field to the neat. To check the boxes, dick your mouse on top of the box Otherwise, please print or type.
1. Contact Information:
Owner Name
Bradfield Farms Water Company
Facility Name
Bradfield Farms -WWTP
Mailing Address
P.O. Box 240908
City
Charlotte
State / Zip Code
NC, 28224
Telephone Number
[phone] ext 218
Fax Number
[phone]
e-mail Address
tjkonsulQuiwater.com
2. Location of facility producing discharge:
Check here if same address as above ❑
Street Address or State Road 4250 John Bostar Rd
City
State / Zip Code
County
Harrisburg
NC, 28075
Cabarrus
3. Operator Information:
Name of the firm, public organization or other entity that operates the facility. (Note that this is not
referring to the Operator in Responsible Charge or ORC)
Name Bradfield Farms Water Company
Mailing Address
City
State / Zip Code
Telephone Number
Fax Number
1 of 3
P.O. Box 240908
Charlotte
NC, 28224
[phone]
[phone]
Form-D 1/06

�f
NPDES APPLICATION - FORM D
For privately owned treatment systems treating 100% domestic wastewaters <1.0 MGD
4. Description of wastewater:
Facility Generating Wastewater(check all that applyj:
Industrial
❑
Number of Employees
Commercial
❑
Number of Employees
Residential
®
Number of Homes 1347
School
❑
Number of Students/ Staff
Other
❑
Explain:
Describe the source(s) of wastewater (example: subdivision, mobile home park, shopping centers,
restaurants, etc.):
Subdivision
1347 x 2.5 = 3368
Population served: 3368
5. Type of collection system
® Separate (sanitary sewer only) ❑ Combined (storm sewer and sanitary sewer)
6. Outfall Information:
Number of separate discharge points 1
Outfall Identification number(s) 001
Is the outfall equipped with a diffuser? ❑ Yes ® No
7. Name of receiving stream(s) (Provide a map showing the exact location of each outfallj:
McKee Creek
S. Frequency of Discharge: ® Continuous ❑ Intermittent
If intermittent:
Days per week discharge occurs: Duration: _
9. Describe the treatment system
List all installed components, including capacity, provide design removal for BOD, TSS, nitrogen and
phosphorus. If the space provided is not sufficient, attach the description of the treatment system in a
separate sheet of paper.
The 0.46MGD wastewater treatment facility consists of a common influent bar screen and
splitter box. Two parallel 0.23MGD plants each consisting of aerated equilization basin,
aerations basins, secondary clarifier, aerobic sludge digester, tablet chlorination and tablet
dechlorination with contact tank, traveling bridge tertiary filter, post aeration tank and a flow
meter. Facility has a back-up stand-by generator with an automatic transfer switch. Facility has a
combined continuous flow meter and recording chart.
2 of 4 Form-D 1106

NPDES APPLICATION - FORM D
For privately owned treatment systems treating 100% domestic wastewaters <1.0 MGD
10. Flow Information:
Treatment Plant Design flow 0.46 MGD
Annual Average daily flow 0.1708 MGD (for the previous 3 years)
Maximum daily flow 0.4540 MGD (for the previous 3 years)
11. Is this facility located on Indian country?
❑ Yes ® No
12. Effluent Data
Provide data for. the parameters. listed. Fecal.Cpliform, Temperature andplYshall be grab.samples, for all other
parameters 24-hour composite sampling shall be used. Effluent testing data must be based on at least flue; samples
and must be rid more than four and one half years old.
Parameter
Daily
Maximum
Monthly
Average
Units of
Measurement
Number of
Samples
Biochemical: Oxygen`Demand
(BODs)
7.9
.. 2.5
mg/�L . . -. _:
� (5),- Jan
Fecal Coliforni
<2
1
#/ 100ml
(5) - Jan 08
Total Suspended Solids
11
2.2
mg/ L
(5) - Jan 08
Temperature (Summer)
30.1
28.0
(4) - July 07
Temperature (Winter)
16.9
14.4
Celcius
(5) - Jan 08
pH
7.03
6.84
units
(5) - Jan 08
13. List all permits, construction approvals and/or applications:
Type Permit Number Type Permit Number
Hazardous Waste (RCRA) NESHAPS (CAA)
UIC (SDWA) Ocean Dumping (MPRSA)
NPDES NCO064734 Dredge or fill (Section 404 or CWA)
PSD (CAA) Special Order of Consent (SOC)
Non -attainment program (CAA) Other' --_
14. APPLICANT CERTIFICATION
I certify that I am familiar with the information contained in the application and that to the
best of my knowledge and belief such information is true, complete, and accurate.
ire, S ;61ond bfrer
Printed name of Person Signing Ti e
3 of 4 Form-D 1106

f;
Uffi ES, Inc.*
April 10, 2008
Mrs. Dina Sprinkle
NC DENR
Division of Water Quality
Point Source Branch
1617 Mail Service Center
Raleigh NC 27699-1617
Re: Bradfield Fames WWTP
NPDES NCO064734
Sludge Management Plan
Dear Mrs. Sprinkle,
As sludge and other solids are generated at this facirdy, they are periodically removed by a contractor, BioTech, Inc., and
transported to their Iand application faicirdy located in Cayce, South Carolina (Permit ND0069761).
Other contractors are available should BioTech be unable to meet a schedule.
If you should have any questions or need any additional information, please do not hesitate to call me at 704-525-7990 x 216 or
by email at gkonsul(Quiiwater.com.
Thank you in advance for your attention.
Si
Tony Konsul
Regional Manager
a use, kn =rwv Bradfield Farms Water Co.
P.O. Box 24M ® Charlotte, NC 28224 a P: 704-525-7990 9 F: 704-525-8174
5701 Wesipark Dr., Suite 101 ® Charbtre, NC 28217 o www.ulwater.com

FACT SHEET FOR EXPEDITED PERMIT RENEWALS
Basic Information to determine potential for expedited permit renewal
Reviewer/Date
VEM y 4 0r
Permit Number
coo& 1/7'31/
Facility Name
ar4d 4 p „, s WiJT.A
Basin Name/Sub-basin number
V ad& n Ocr o3 o i-
Receiving Stream
McKer
Stream Classification in Permit
G
Does permit need NH3 limits?
No
Does permit need TRC limits?
n o s
Does permit have toxicity testing?
A&
Does permit have Special Conditions?
wo
Does permit have instream monitoring?
el
Is the stream impaired on 303 d list)?
es
Any obvious compliance concerns?
Any permit mods since lastpermit?
Prya arrar 4
Existing expiration date
New expiration date
lr so Zvi 3
New permit effective date
Mkrellaneom Comments
YES_ This is a SIMPLE EXPEDITED permit renewal (administrative
renewal with no changes, or only minor changes such as TRC, NH3,
/ name/ownership changes). Include conventional WTPs in this group.
YES This is a MORE COMPLEX EXPEDITED permit renewal (includes
Special Conditions (such as EAA, Wastewater Management Plan), 303(d)
listed, toxicity testing, instream monitoring, compliance concerns, phased
limits). Basin Coordinator to make case -by -case decision.
YES_ This permit CANNOT BE EXPEDITED for one of the following reasons:
• Major Facility(municipal/industrial)
• Minor Municipals with pretreatment program
• Minor Industrials subject to Fed Effluent Guidelines (lb/day limits for BOD, TSS,
etc)
• Limits based on reasonable potential analysis (metals, GW remediation organics)
• Permitted flow > 0.5 MGD (requires full Fact Sheet)
• Permits determined by Basin Coordinator to be outside expedited process
TB Version 8/18/2006 (NPDES Server/Current Versions/Expedited Fact Sheet)