NC0064734_Permit Issuance_20040405

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
William G. Ross, Jr., Secretary
Alan W. Klimek, P.E., Director
April 5, 2004
Mr. James T. Highley
Bradfield Farms Water Company.
P.O. Box 240908
Charlotte, North Carolina 28224
NCDENR
Subject: NPDES Permit Issuance
Permit No. NCO064734
Bradfield Farms WWTP
Cabarrus County
Dear Mr. Highley:
Division personnel have reviewed and approved your application for
renewal of subject permit. Accordingly, we are forwarding the attached NPDES
discharge permit. This permit is issued pursuant to the requirements of North
Carolina General Statute 143-215.1 and the Memorandum of Agreement
between North Carolina and the U.S. Environmental Protection Agency dated
May 9, 1994 (or as subsequently amended).
The final permit authorizes Bradfield Farms Water Company to discharge
up to 0.700 MGD of treated domestic wastewater from the Bradfield Farms
current WWTP to McKee Creek, a class C water in the Yadkin -Pee Dee River
Basin. The permit includes discharge limitations and/or monitoring for flow,
biochemical oxygen demand (BOD), total suspended solids (TSS), ammonia,
dissolved oxygen, fecal coliform bacteria, pH, and total residual chlorine.
The following modifications have been made to the Bradfield Farms WWTP
NPDES permit:
All references to Carolina Water Service hic. of NC have been
removed from the permit.
The increased instream monitoring frequency for dissolved oxygen,
temperature and fecal colifonn during the summer months of June
through September is a minimum requirement for domestic
wastewater treatment dischargers based on North Carolina
Administrative Code 15A NCAC 2B .0508 (d). In addition, North
Carolina Administrative Code 15A NCAC 2B .0508 (b) (2), allows "...
additional tests and measurements at such sampling points and
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone]/FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 100/6 post -consumer paper

Bradfield Farms WWTP
NC0064734
Page 2 - -
with such frequency as are determined by the Director to be
necessary to adequately monitor constituents of the waste
discharge and their effect upon the receiving waters." Because
McKees Creek has been determined by the "impaired" rating to
have water quality below the State standards, the Division has the
authority to require additional monitoring of wastewater
dischargers.
• The addition of instream monitoring for fecal coliform in the permit.
The receiving stream for the facility has been placed on the 2002
303 (d) list for impaired streams for the parameter of fecal coliform.
Fecal coliform data collected instream will be useful in the
development of water quality management strategy for McKee
Creek. If it is determined that Bradfield Farms' discharge is not
contributing to the impairment, it is possible that instream
monitoring for fecal coliform could be removed.
• The addition of a total residual chlorine limit for 21 ug/1 at 0.460
MGD. A compliance schedule has now been included in the
permit. The Bradfield Farms WWTP has eighteen months from
the effective date of the permit to be in compliance with the
total residual chlorine limit. This time period is allowed in order
for the facility to budget and design/construct the dechlorination
and /or alternative disinfection system(s).
• The addition of summer and winter weekly average NH3-N limits at
0.460 MGD and 0.700 MGD to reflect the Division's current policy.
According to the Code of Federal Regulations [40 CFR 122.45
(d)(2)], "continuous discharges ...shall unless impractical be stated
as... maximum daily and average monthly discharge limitations for
all dischargers other than publicly owned treatment works". The
maximum daily limit is established based on a ratio of 5:1
(maximum daily: monthly average) for non -municipal dischargers.
The corresponding daily maximum limits for ammonia nitrogen at
the flows of 0.460 MGD and 0.700 MGD are 10.0 mg/l for the
summer and 20.0 mg/1 for the winter.
The modification of the effluent monitoring frequency for BOD5,
NH3-N, TSS, dissolved oxygen, total residual chlorine, pH and fecal
coliform from weekly to three times per week upon expansion to
0.700 MGD. This change is based on the VAVTP's rating as a
Grade III facility per North Carolina regulation 15A NCAC 08G.
0302 (c) .
If any parts, measurement frequencies or sampling requirements
contained in this permit are unacceptable to you, you have the right to an
adjudicatory hearing upon written request within thirty (30) days following
receipt of this letter. This request must be in the form of a written petition,
conforming to Chapter 150B of the North Carolina General Statutes, and filed
with the office of Administrative Hearings, 6714 Mail Service Center, Raleigh,

Bradfield Farms WWTP -
NC0064734
Page 2 —
North Carolina 27699-6714. Unless such a demand is made, this permit shall
be final and binding.
Please take notice that this permit is not transferable. Part II, EA.
addresses the requirements to be followed in case of change in ownership or
control of this discharge. This permit does not affect the legal requirements to
obtain other permits which may be required by the Division of Water Quality or
permits required by the Division of Land Resources, Coastal Area Management
Act, or any other Federal or Local governmental permits may be required.
If you have any questions or need additional information, please contact
Ms. Jacquelyn Nowell at telephone number [phone], extension 512.
Sincerely,
ORIGINAL SIGNED BY
Mark McIntire
Alan W. Mimek, P.E.
Attachments
cc: Mooresville Regional Office / Water Quality Section
NPDES Unit/Permit File 0
Central Files
m

Permit No. NCO064734
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
Bradfield Farms Water Company
is hereby authorized to discharge wastewater from a facility located at
Bradfield Farms WWTP
Off of NCSR 2951
Southeast of Pine Ridge
Cabarrus County
to receiving waters designated as McKee Creek in the Yadkin Pee -Dee River Basin
in accordance with effluent limitations, monitoring requirements, and other conditions set forth in Parts I,
H, III and IV hereof.
This permit shall become effective May 1, 2004
This permit and authorization to discharge shall expire at midnight on November 30, 2008.
Signed this day April 5, 2004
ORIGINAL SIGNED BY
Mark McIntire
Alan W. Klimek, P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission

Permit No. NC0064734
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility, whether for operation or
discharge are hereby revoked, and as of this issuance, any previously issued
permit bearing this number is no longer effective. Therefore, the exclusive
authority to operate and discharge from this facility arises under the permit
conditions, requirements, terms, and provisions included herein.
Bradfield Farms Water Company
is hereby authorized to:
1. Continue operation of an existing 0.46 MGD wastewater treatment
facility consisting of:
• an influent lift station
• bar screen and flow splitter box
• dual surge tanks
• aeration basins
• secondary clarifiers
• sludge holding tanks
• chlorine contact tanks with gas chlorination
• traveling bridge tertiary filters
• post aeration tanks
The facility is located at Bradfield Farms Subdivision off of NCSR 2951,
southeast of Pine Ridge, Cabarrus County;
2. After receiving an Authorization to Construct from the Division of Water
Quality, construct and operate additional wastewater treatment facilities
making the build -out treatment capacity 0.7 MGD; and
3. Discharge from said treatment works at the location specified on the
attached map into McKee Creek, a class C water in the Yadkin Pee -Dee
River Basin.

Facility Information Facility
Latitude- 35015'32" Sub -Basin: 03-07.11 Location
Longitude: 80038'45"
uad #: Harrisburg, F16SW
Slrzam Class: C Bradfield Faros Water Co./Crntex Homes
Recetvtue Flow- McKee 0.70CreeGJZ.�.rt� NCO064734
Permitled Flow- 0.46 $ 0.70 MGD Cabavus Coanty

Permit No. NCO064734
A. (1) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
During the period beginning on the effective date of the permit and lasting until
expiration or expansion above 0.460 MGD, the permittee is authorized to discharge
treated wastewater from outfall 001. Such discharges shall be limited and monitored
by the Permittee as specified below:
OI
4�
t�ic-^001
'.1
�
r
Flow
0.46 MGD
Continuous
Recording
Influent or
Effluent
BOD, 5-day, 20°C
9.0 mg/L
13.5 mg/L
Weekly
Composite
Effluent
(April 1 - October 31)
BOD, 5-day, 20°C
18.0 mg/L
27.0 mg/L
Weekly
Composite
Effluent
(November 1 - March 31)
Total Suspended Solids2
30.0 mg/L
45.0 mg/L
Weekly
Composite
Effluent
NH3 as N
2.0 mg/L
10.0 mg/L
Weekly
Composite
Effluent
(April 1 - October 31)
NH3 as N
4.0 mg/L
20.0 mg/L
Weekly
Composite
Effluent
(November 1 - March 31)
Temperature
Daily
Grab
Effluent
Temperature
Weekly
Grab
U, D
pH2
Weekly
Grab
Effluent
Dissolved 0xygen3
Weekly
Grab
Effluent
Dissolved Oxygen
Weekly
Grab
U. D
Total Residual Chlorine4
21pg/L
2/Week
Grab
Effluent
Fecal Coliform
200/100 ml
400/100 ml
Weekly
Grab
Effluent
eometric mean)
Fecal Coliform
Weekly
Grab
U, D
eometric mean)
Total Nitrogen
Quarterly
Composite
Effluent
(NO2+ NO3+ TKN)
Total Phosphorus
Quarterly
Composite
Effluent
Notes:
1. U: Upstream at least 100 feet above the outfall. D: Downstream at NCSR 1169.
Instream samples shall be collected 3/week during the months of June through
September and once per week during the remaining months of the year.
2. The pH shall not be less than 6.0 standard units nor greater than 9.0 standard units.
3. The daily average effluent dissolved oxygen concentration shall not be less than 5.0
mg/L.
4. Chlorine limit applicable only if chlorination used for disinfection. Chlorine limit is
effective November 1, 2005.
There shall be no discharge of floating solids or visible foam in other than
trace amounts.

Permit No. NCO064734
A. (2) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
Beginning upon expansion above 0.460 MGD and lasting until expiration, the Permittee
is authorized to discharge treated wastewater from outfall 001. Such discharges shall
be limited and monitored by the Permittee as specified below:
e
;.� sif'Jfi1���'f •fit'=� �E
71 .,.U! M A�i:z tlr-''.' "-T•".y i:i. `ex Y
��-,�'yK._ r �F� ✓ � 3 � f �' 1.►
r 71 fi .-w"-c-rx,Pai'A-eav ;k `...�'' "..:1._ F
'x .t
�Nt*:..
t rtu�..: Y...a :.: .......•.,.......... :� ...-L�.... ...
.x} ... °....
t::.'J�
Rb `..
c
:ia>Y)1Kt
._
Flow
0.700 MGD
Continuous
Recording
Influent or
Effluent
BOD, 5-day, 20°C 2
9.0 mg/L
13.5 mg/L
3/Week
Composite
Effluent
(April 1 - October 31)
BOD, 5-day, 20°C 2
18.0 mg/L
27.0 mg/L
3/Week
Composite
Effluent
(November 1 - March 31)
Total Suspended Solids2
30.0 mg/L
45.0 mg/L
3/Week
Composite
Effluent
NH3 as N
2.0 mg/L
10.0 mg/L
3/Week
Composite
Effluent
(April 1 - October 31)
NH3 as N
4.0 mg/L
20.0 mg/L
3/Week
Composite
Effluent
(November 1 - March 31)
Temperature
Daily
Grab
Effluent
Temperature
3/Week
Grab
U. D
pHs
3/Week
Grab
Effluent
Dissolved Oxygen4
3/Week
Grab
Effluent
Dissolved Oxygen
3/Week
Grab
U. D
Total Residual Chlorines
20 Vg/L
3/Week
Grab
Effluent
Fecal Coliform
200/ 100 ml
400/ 100 ml
3/Week
Grab
Effluent
(geometric mean)
Fecal Coliform
3/Week
Grab
U. D
(geometric mean)
Total Nitrogen
Quarterly
Composite
Effluent
(NO2+ NOs+ TKN)
Total Phosphorus
Quarterly
Composite
Effluent
Notes:
1. U: Upstream at least 100 feet above the outfall. D: Downstream at NCSR 1169.
Instream samples shall be collected 3/week during the months of June through
September and once per week during the remaining months of the year.
2. The pH shall not be less than 6.0 standard units nor greater than 9.0 standard units.
3. The daily average effluent dissolved oxygen concentration shall not be less than 5.0
mg/L.
4. Chlorine limit applicable only if chlorination used for disinfection. Chlorine limit is
effective November 1, 2005.
There shall be no discharge of floating solids or visible foam in other than trace amounts.

BRADFIELD FARMS WATER COMPANY
AN AFFILIATE OF
U'rHH'H'THz59 HH C.
Regional Office:
5701 Westpark Dr., Suite 101
P.O. Box 240908
Charlotte, NC 28224
Telephone: [phone]
FAX: [7041 525-8174
March 10, 2004
Ms. Jacquelyn M. Nowell
NPDES Unit
NC DENR — DWQ
1617 Mail Service Center
Raleigh, NC 27699-1617
Re: Bradfield Farms WWTP
Draft Permit
NPDES NCO064734
Dear Ms. Nowell,
MAR 1 1 2004
We are in receipt of your February 4, 2004 letter and draft permit. There are some issues we would
like to have addressed.
1) Bradfield Farms Water Company is the owner and Permittee of this facility. Carolina Water
Service, Inc. of NC (CWS) is a sister company. Other than a common owner, the two companies
should not be linked and it would be best to leave off CWS from permit language.
2) We must object to the requirement of increased instream sampling during June - September. We
are not aware of any requirement for Permittees to supply increased stream monitoring data for
water quality strategy. This is above the requirements for the facility itself below 0.46 mgd,
which are only once per week and increases operational cost. The Permittee should not have to
bear undue extra burden of stream sampling for the division or other agencies.
3) The permit states a TRC limit of 21 ug/L with no provision for implementation. We can not
comply with this limit without dechlorination or alternative disinfection methods. Other permits
have allowed 18 months from the time of issue to become compliant. No such language was
found in the draft that we could locate. We will need time to comply.
We would appreciate your attention and consideration to these issues. If you have any questions,
pleAe do not hesitate to contact me at 704-525-7990, Ext. 216. Thank you for your attention and
Martin Lashua
Regional Manager
CC: Mr. Carl Daniel
Mr. Jim Highley
Mr. Mark Haver

The Knight Publishing Co., Inc.
Charlotte, NC
North Carolina ) ss Affidavit of Publication
Mecklenburg County)
THE CHARLOTTE OBSERVER
-------------------------------------------------------------
I
NCDENR/DWO/BUDGET OFFICE
ACCOUNTS PAYABLE
1617 MAIL SERVICE CENTER
RALEIGH NC 27699-1617
REFERENCE: 30019881
5049368 Public Notice -NC
Before the undersigned, a Notary Public of said
county and State, duly authorized to administer
oaths affirmations, etc., personally appeared,
being duly sworn or affirmed according to law,
doth depose and say that he/she is a
representative of the Knight Publishing Company a
corporation organized and doing business under thel
Laws of the State of Delaware, and publishing a 1
newspaper known as The Charlotte Observer in the
city of Charlotte, County of Mecklenburg and Statel
of North Carolina and that as such he/she is
famiLiar with the books, records, files and
business of said Corporation and by reference to
the files of said publication
the attached advertisement was inserted. The 1
following is correctly copied from the books and
files of the aforesaid Corporation and
Publication. I
PUBLISHED ON: 02/09
------------ FEB 18 2004
AD SPACE: 120 LINE
FILED ON: 02/13/04
NAME: TITLE.
DATE: `jy�•N
In Testimony Whereof I have hereunto set my hand and affixed my seal, the
day d year afar s id.
Notary: , My Commission Expires: _/_/4*y Commission Expires May 17, 26M

DENR/DWQ
FACT SHEET FOR NPDES PERMIT DEVELOPMENT
NPDES No. NCO064734
Facility Information
Applicant/ FacilitName:
Carolina Water Service, Inc.Bradfield Farms Wastewater
Treatment Plant
Applicant Address:
PO Box 240908 Charlotte, NC 28224
Facility Address:
4250 John Bostar Road Harrisburg NC 28075
Permitted Flow
0.46 & 0.7 MGD
Type of Waste:
100% Domestic
Facility/Permit Status:
Renewal
County:
Cabarrus
Miscellaneous
Receiving Stream:
McKee Creek
Regional Office:
Mooresville
Stream Classification:
C
USGS To o Quad:
Harrisburg, F16SW
303(d) Listed?
Yes
Permft Writer:
Jacquelyn M. Nowell
Subbasin:
03-07-11
Date:
January 8, 2004
Drainage Area (mi2):
5.97
Summer 7Q10 (cfs)
0.17
Winter 7Q10 (cfs):
0.54
Average Flow (cfs):
6.3
SUMMARY OF FACILITY AND WASTELOAD ALLOCATION
The facility is requesting renewal of its existing NPDES permit. The design capacity is 0.460 MGD with an
additional effluent page for 0.7 MGD. The wastewater from the plant is 100% domestic from 1180 residential
homes. Existing limits at 0.460 MGD and 0.7 MGD are:
Summer
Winter
BOD5
9 mg/I
18 mg/I
NH4
2 mg/I
4 mg/I
TSS
30 mg/I
30 mg/I
DO
5 mg/I
5 mg/I
Fecal
200/ 100ml
200/ 100ml
pH
6-9 SU
6-9 SU
TRC
-
20 ug/1 (at 0.7 MGD only)
Effluent
monitoring for temperature, TP and TN.
Instream monitoring for temperature and DO.
Receiving Stream: McKee Creek since the last renewal has been added to the 2002 303d list. A Category 5 (water
for which a TMDL is required) 6.5 mile segment listed "from source to Reedy Creek" with causes of impairment
being fecal coliform and sediment. The impaired use is O. It is a low priority with potential sources as minor
nonmunicipal, agriculture, land development, and urban runoff/stormwater.
TOXICITY TESTING:
None Required
COMPLIANCE SUMMARY:
A review of the facility's compliance history indicates that there have been no problems meeting the existing limits.
Effluent levels of BOD, ammonia, TSS, and fecal coliform are all quite low. The monthly average flow through Oct.
2003 is approximately 0.152 MGD much less than the lowest permitted flow of 0.460 MGD.
6radticld Farms Faa Shect
NPDES Rcnewal
Psac I

INSTREAM MONITORING:
Upstream site: At least 100 feet above the outfall
Downstream site: Downstream at NCSR 1169
The facility is currently required to monitor temperature and dissolved oxygen at the locations above. The
requirement to monitor fecal coliform and conductivity was deleted in the 2000 renewal. This recommendation was
made before McKee Creek was placed on the 303d list for fecal coliform impairment. Based on this updated
information, it is recommended that instream monitoring for fecal coliform be placed back in the Bradfield Farms
permit. The monitoring frequency will be weekly to coincide with the instream monitoring frequency for temperature
and DO.
PROPOSED CHANGES:
• The addition of a weekly instream monitoring for fecal coliform to the permit based on the listing of the
receiving stream, McKee Creek, on the 2002 303(d) list of impaired streams.
• The addition of a daily maximum limit for total residual chlorine of 21 ug/l at 0.460 MGD based on new
DWQ procedure for new and existing dischargers.
• The addition of summer and winter daily maximum NH3 limits of 10 mg/I and 20 mg/l, respectively, at
0.460 MGD and 0.700 MGD.
PROPOSED SCHEDULE FOR PERMIT ISSUANCE:
Draft Permit to Public Notice: February 11, 2004
Permit Scheduled to Issue: March 29, 2004
Effective Date of the Permit: May 1, 2004
STATE CONTACT:
If you have any questions on any of the above information or on the attached permit, please contact Jackie Nowell at
[phone] ext. 512.
Alf
NAME:
NPDES SUPERVISOR COMMENT:
DATE:
NAME: DATE:
q2,11 o�
Bradfield Farms Fact Sheet
NPDES Renewal
Past: 2

Bradfield Farms WWTP
Residual Chlorine
Ammonia as NH3
(summer)
7Q10 (CFS)
0.17
7010 (CFS)
0.17
DESIGN FLOW (MGD)
0.46
DESIGN FLOW (MGD)
0.46
DESIGN FLOW (CFS)
0.713
DESIGN FLOW (CFS)
0.713
STREAM STD (UG/L)
17.0
STREAM STD (MG/L)
1.0
UPS BACKGROUND LEVEL (1
0
UPS BACKGROUND LEVEL
0.48
IWC (%)
80.75
IWC (%)
80.75
Allowable Concentration (ug)
21.05
Allowable Concentration (m
1.12
Ammonia as NH3
(winter)
7Q10 (CFS)
0.54
Fecal Limit
200/100ml
DESIGN FLOW (MGD)
0.46
Ratio of 0.2 :1
DESIGN FLOW (CFS)
0.713
STREAM STD (MG/L)
1.8
UPS BACKGROUND LEVEL
0.22
IWC (%)
56.90
Allowable Concentration (m
3.00
NC0064734 1/8/2004

'TA ,
SOC PRIORITY PROJECT: NO
To: Permits and Engineering Unit
Water Quality Section
Mention: Charles Weaver
Date: September 10, 2003
NPDES STAFF REPORT AND RECOMMENDATIONS
County: Cabarrus
NPDES Permit No.: NCO064734
MRO No.: 03-JW 66
PART I - GENERAL INFORMATION
Facility and address: Bradfield Farms WWTP
Bradfield Farms Water Company
C/O Carolina Water Service, INC.
PO Box 240908
Charlotte, NC 28224
2. Date of investigation: August 6, 2003
3. Report prepared by: B. Dee Browder, Environ. Engr. I
4. Person contacted and telephone number: Steve Childers, [phone]
5. Directions to site: From the intersection of Hwy. 29/49 and the new I-485 intersection
travel approximately 3 miles northeast on Hwy. 29/49 then turn right onto Robinson
Church Road (which changes to Harrisburg Road). Travel approximately 5 miles then turn
left onto Reedy Creek Road. Travel 0.7 miles and turn left onto Clayford Ridge Road.
Take an immediate right onto Dearwood Place followed by a left onto Damson Plum
Lane. At this point the road turns to gravel and the treatment facility is approximately 0.4
mile down the gravel road.
NOTE: During the next visit to this site the I-485 exit for Harrisburg Road should be
open.
6. List for all discharge points: -
Latitude: 350 15' 32"
Longitude: 800 38' 45"
Attach a USGS Map Extract and indicate treatment plant site and discharge point on map.
USGS Quad No.: F 16 SW Harrisburg, NC
7. Site size and expansion area consistent with application: Yes.

Page Two
S. Topography (relationship to flood plain included): Rolling 3-12% slopes. The site is not
located in flood plain.
9. Location of nearest dwelling: Approx. one-half mile from the WWTP site.
10. Receiving stream or affected surface waters: McKee Creek
a. Classification: C
b. River Basin and Subbasin No.: Yadkin 030711
C. Describe receiving stream features and pertinent downstream uses: The receiving
stream was approximately 25 feet wide and 6 feet deep at the time of investigation.
Class C uses downstream.
PART II - DESCRIPTION OF DISCHARGE AND TREATMENT WORKS
1. a. Volume of Wastewater: 0.230 MGD (Design Capacity)
b. What is the current permitted capacity: 0.230 MGD
C. Actual treatment capacity of current facility (current design capacity): 0.230
MGD
d. Date(s) and construction activities allowed by previous ATCs issued in the
previous two years: N/A
e. Description of existing or substantially constructed WWT facilities: The existing
WWT facilities consist of an influent lift station, influent bar screen, flow splitter
box and two parallel 0.23 MGD plants. Each plant consists of an aerated
equalization basin, aeration basin, secondary clarifier, aerobic sludge digester,
tablet chlorination/disinfection, chlorine contact tank, traveling bridge tertiary
filter, post aeration tank and flow measurement device.
f. Description of proposed WWT facilities: N/A
g. Possible toxic impacts to surface waters: There are no toxic impacts expected.
Chlorine is added to the waste stream.
h. Pretreatment Program (POTWs only): Not needed.
2. Residual handling and utilization/disposal scheme:Residuals are hauled to the Sugar Creek
WWTP.
a. If residuals are being land applied specify DEM Permit No. N/A.
Residuals Contractor: N/A
Telephone No.: N/A

Page Three
Residuals Contractor: N/A
Telephone No.: N/A
b. Residuals stabilization: PSRP PFRP
C. Landfill: N/A
3. Treatment Plant Classification: Class (no change from previous rating).
4. SIC Code(s): 4952 Wastewater Code(s): 05
5. MTU Code(s):
PART III - OTHER PERTINENT INFORMATION
1. Is this facility being constructed with Construction Grant Funds or are any public monies
involved (municipals only)? No
2. Special monitoring or limitations (including toxicity) requests: None at this time.
3. Important SOC/JOC or Compliance Schedule dates: N/A
Submission of plans and specifications
Begin Construction
Complete construction
4. Alternative Analysis Evaluation
a. Spray Irrigation: N/A
b. Connect to regional sewer system: None available at this time.
c. Subsurface: N/A
d. Other disposal options: N/A
PART IV - EVALUATION AND RECOMMENDATIONS
Carolina Water Services request renewal of the discharge permit for Bradfield Farms W WTP.
The Bradfield Farms W WTP serves approximately 1300 homes and has one pump station
(Peacock Pump Station) located on Peacock Road. The W WTP and the collection system seemed
to be adequately maintained and operated at the time of the field visit. This office recommends
renewal of this permit.
�3
Signature of Report Preparer Date
Water Quality Regii&al Supervisor Date

CAROLINA WATER SERVICE, INC.
1 yp� AN(\A'FFL UFT�fE/(O'f
UIFI �I IlfI ICSSo 1 c
Regional Office:
5701 Westpark Dr., Suite 101
P.O. Box 240908
Charlotte, NC 28224
Telephone: [phone]
FAX: [phone]
June 2, 2003
Mrs. Valery Stephens
NC DENR / Water Quality / Point Source Branch
1617 Mail Service Center
Raleigh, NC 27699-1617
Re: Notice of Renewal Intent
Bradfield Farms W WTP
NPDES Permit NCO064734
Cabarrus County
Dear Mrs. Stephens:
JUN — 6 2003 t ''
DENR-WATER OU4LI TY
POINT SOURCE BRANCH
Carolina Water Service, Inc. of NC is hereby requesting renewal of the aforementioned
permit. Enclosed are one signed original and two copies of this letter, the application, and
our sludge management plan.
If you should need additional information regarding the permit renewal application or have
questions about the information I have provided, please contact me at 704-525-7990,
extension 221.
WHh
�t
Sr. Regional Manager
cc: Carl Daniel

CAROLINA WATER SERVICE, INC.
1 1 IAA14 AFFILjI�ATTEEOOf
U IrILII I�IjL�S011ll Il�o
Regional Office:
5701 Westpark Dr., Suite 101
P.O. Box 240908
Charlotte, NC 28224
Telephone: [phone]
FAX: [phone]
June 2, 2003
Mrs. Valery Stephens
NC DENR/Water Quality/Point Source Branch
1617 Mail Service Center
Raleigh, NC 27699-1617
Re: Bradfield Farms WWTP
NPDES Permit No. NCO064734
Sludge Management Plan
Dear Mrs. Stephens:
Please be advised that sludge generated at the aforementioned facility is removed and
disposed of by the following two waste haulers:
Bio-Tech, Inc.
151 Old Wire Road
West Columbia, SC 29172
803-796-8925
Liquid Waste, Inc.
9300 Steele Creek Road
Charlotte, NC 28273
704-588-2392
If you should need additional information regarding our sludge management program,
please contact me by calling 704-525-7990.
Wn reln rel ,
Jim Highley
Senior Regional Manager

CAROLINA WATER SERVICE, INC.
AN AffILIATE Of
1 L111�SSo(� Ca
Regional office:
5701 Westpark Dr., Suite 101
P.O. Box 240908
Charlotte, NC 28224
Telephone: VO4) 525-7990
PAX: [phone]
February 17, 1999
Ms. Susan Wilson, Supervisor
Point Source Compliance Branch
Division of Water Quality
NC DENR
PO Box 29539
Raleigh, NC 27626-0535
Re: North Carolina NPDES Discharge Monitoring Reports (DMR's)
Dear Ms. Wilson,
Pursuant to .•15A NCAC 2B .0506(b)(2)(d), please accept this letter as official
authorization and designation that, in addition to myself, the following :staff
members have been given Signatory • Authority on behalf of the Company....
Brune .T: Haas - Regional Manager
Martin J. Lashua - Regional Manager • • �::
James T. Highley- - Senior Regional Manager
It is my understanding that this letter should be sufficient to address this issue.
However, -if there is some form or other document that needs to be executed, we
would appreciate your assistance to,• provide it at your earliest convenience.
This designation does not change any other "Permittee" information in any
way, and all official correspondence*** *should continue to be addressed solely to •
my attention.
If you need any additional information; please do not hesitate to call me in our .
Charlotte Regional Office at 704-525-7990.
Thank you in advance for your assistance and attention.
Sincerely,
Carl Daniel
Vice President
cc: Jim T. Highley
. Bruce T. Haas
Marfia• J..Lashua
Richard Bridgeman - DWQ1Mooresville

NPDES APPLICATION FOR PERMIT RENEWAL- SHORT FORM D
To be filed only by privately -owned dischargers of 100% domestic wastewater (<1 MGD flow)
N. C. Department of Environment and Natural Resources
Division of Water Quality / NPDES Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
http://h2o.enr.state.nc.us/NPDES/
North Carolina NPDES Permit Number I NC00 6 4 7 3 4
PIease print or type
1. Contact Information:
Facility Name
Bradfield Farms WWTP
Owner Name
Bradfield Farms Water Company
Street Address
PO Box 240908
City
Charlotte
State / Zip Code
NC 28224
Telephone Number
(7 0 4) 5 2 5- 7 9 9 0
Fax Number
(7 0 4) 5 2 5- 817 4
e-mail Address
Operator Name
Steve E. Childers
Street Address
PO Box 240908
City
Charlotte
State / Zip Code
NC 28224
County
Mecklenburg
Telephone Number
(7 0 4) 5 2 5- 7 9 9 0
2. Location of facility producing discharge:
Check here if same
as above 1_1
Facility Name (If different from above)
Street Address or State Road 4250 John B o s t a r Road
City
Harrisburg
State / Zip Code
NC 28075
County
Cabarrus
3. Reason for application:
Expansion/ Modification * Existing Unpermitted Discharge
Renewal _XNew Facility
* Please provide a description of the expansion/modification:
Page 1 of 3 Version 12102

NPDES APPLICATION FOR PERMIT RENEWAL- SHORT FORM D
To,be filed only by privately -owned dischargers of 100% domestic wastewater (< 1 MGD flow)
4. Description of the existing treatment facilities (list all installed components with
capacities):
0.46 MGD wastewater treatment facility consisting of influent lift
station, bar screen & flow splitter box. Two parallel 0.23 MGD plants,
e
condary
tion,
chlorine contact tank, traveling bridge tertiary filter, post aeration
tank & inrumented flow measurement. Facility has standby emergency
5. Description of wastewater (check all that apply):
type of Facility Generating Wastewater
Industrial
Commercial
Residential
School
Other
X
Number of Employees
Number of Employees
Number of Homes
Number of Students/Staff
Describe the source(s) of wastewater (example: subdivision, mobile home park, etc.):
Subdivision
1180
6. List all permits, construction approvals and/or applications (check all that apply):
jype
RCRA
UIC
NPDES
PSD
Permit Number Type Permit Number
Non -Attainment
Ocean Dumping
Dredge/Fill Permits
Other
NESHAPS
7. Number of separate wastewater discharge pipes (wastewater outfalls):
One
S. If the facility has multiple discharge outfalls, record the source(s) of wastewater for
each outfall:
N/A
Page 2 of 3 Version 12102

NPDES APPLICATION FOR PERMIT RENEWAL- SHORT FORM D
Ta be filed only by privately -owned dischargers of 100% domestic wastewater (< 1 MGD flow)
9. Name of receiving stream(s) (Provide a map showing the exact location of each outfali):
McKee Creek in the Yadkin Pee —Dee River Basin
10. Is this facility located on Native American lands? (check one)
YES ❑ NO 0
I certify that I am familiar with the information contained in the application and
that to the best of my knowledge and belief such information is true, complete, and
accurate.
James T. Highley
Printed Name of Person Signing
Sr. Regional Manager
Title
North Carolina General Statute 143-215.6(b)(2) provides that: Any person who knowingly makes any false statement representation, or
certification In any application, record, report, plan, or other document files or required to be maintained under Article 21 or regulations of the
Environmental Management Commission implementing that Article, or who falsifies, tampers with, or knowingly renders inaccurate any
recording or monitoring device or method required to be operated or maintained under Article 21 or regulations of the Environmental Management
Commission implementing that Article, shall be guilty of a misdemeanor punishable by a fine not to exceed $10,000, or by imprisonment not to
exceed six months, or by both. (18 U.S.C. Section 1001 provides a punishment by a fine of not more than $10,000 or imprisonment not more
than 5 years, or both for a similar offense.)
Page 3 of 3 Version 12102