NC0057541_Authorization to Construct_20070730

Cummings Cove Company, LLC
A To C No. 057541 A02
Issued April 12, 2006
En ;ineer's Certification
I, wlqz.-t . G . L'aWwai, as a duly registered Professional Engineer in
the State of North Carolina, having be n auth rized to observe ( erio icallfie)
the construction of the modifications and improvements to the Cummings Cove WWTP, located
on Cummings Cove Road in Henderson County for the Cummings Cove Company, LLC, hereby
state that, to the best of my abilities, due care and diligence was used in the observation of the
following construction:
Abandonment and replacement of the existing Cummings Cove wastewater
treatment process with a 0.080 MGD package treatment system and other
necessary facilities consisting of a 150 GPM influent lift station with duplex
pumps, a 26,950-gallon equalization basin, an 80,400-gallon aeration basin, a
13,485-gallon dual -hopper clarifier, a 2,289-gallon chlorination system capable of
treating peak flows of up to 200,000 GPD, an 18,000-gallon sludge holding tank,
relocation of the existing sludge holding tanks, associated blowers, motors,
meters, electrical service, controls, standby power generation, site work including
piping, valving, and other appurtenances, in conformity with the project plans,
specifications, and other supporting data subsequently filed and approved by the
Department of Environment and Natural Resources.
I certify that the construction of the above referenced project was observed to be built within
substantial compliance and intent of the approved plans and specifications.
We understand at,Yhe new
now apply.
Signature (/v�kWP
Date q 3D b
with the modifications to expand to 0.080 MGD
Registration No.
Send to: Construction Grant& Loans
DENR/DWQ
1.633 Mail Service Center
Raleigh, NC 27699-1633
s��'9'ery'�CP
ef .• s,, .
p 6469
gip+' x, �, !
v ,k6' k`a

F VIArF
O ___
April 12, 2006
Ms. Shannon Ginn, Managing Member
Cummings Cove Company, LLC
20 Cummings Cove Parkway
Hendersonville, North Carolina 28739
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
SUBJECT: Authorization to Construct
A to C No. 057541 A02
Cummings Cove Company, LLC
Cummings Cove WWTP
Henderson County
Dear Ms. Ginn:
A letter of request for Authorization to Construct was received July 25, 2005, by the
Division, and final plans and specifications for the subject project have been reviewed and found
to be satisfactory. Authorization is hereby granted for the construction of modifications to the
existing 0.035 MGD Cummings Cove Wastewater Treatment Plant, with discharge of treated
wastewater into the French Broad River in the French Broad River Basin.
This authorization results in an increase in design and permitted capacity to 0.080 MGD,
and is awarded for the construction of the following specific modifications:
Abandonment and replacement of the existing Cummings Cove wastewater
treatment process with a 0.080 MGD package treatment system and other
necessary facilities consisting of a 150 GPM influent lift station with duplex
pumps, a 26,950-gallon equalization basin, an 80,400-gallon aeration basin, a
13,485-gallon dual -hopper clarifier, a 2,289-gallon chlorination system capable of
treating peak flows of up to 200,000 GPD, an 18,000-gallon sludge holding tank,
relocation of the existing sludge holding tanks, associated blowers, motors,
meters, electrical service, controls, standby power generation, site work including
piping, valving, and other appurtenances, in conformity with the project plans,
specifications, and other supporting data subsequently filed and approved by the
Department of Environment and Natural Resources.
This Authorization to Construct is issued in accordance with Part III, Paragraph A of
NPDES Permit No. NCO057541 issued January 18, 2006, and shall be subject to revocation
unless the wastewater treatment facilities are constructed in accordance with the conditions and
limitations specified in Permit No. NC0057541.
NorthCarolina
Naturallil
North Carolina Division of Water Quality 1617 Mail Service Center Raleigh, NC 27699-1617 Phone [phone] Customer Service
Internet: _ivi ncwaterguaLty.org 512 N. Salisbury St. Raleigh, NC 27604 FAX [phone]
An Equal Opportunity/Affirmative Action Employer — 50% Recycled/10% Post Consumer Paper

Cumming Cove Company, LLC
April 12, 2006
Page 2
The sludge generated from these treatment facilities must be disposed of in accordance
with G.S. 143-215.1 and in a manner approved by the North Carolina Division of Water Quality.
In the event that the facilities fail to perform satisfactorily, including the creation of
nuisance conditions, the Permittee shall take immediate corrective action, including those as may
be required by this Division, such as the construction of additional or replacement wastewater
treatment or disposal facilities.
The Asheville Regional Office, telephone number [phone], shall be notified at
least forty-eight (48) hours in advance of operation of the installed facilities so that an on site
inspection can be made. Such notification to the regional supervisor shall be made during the
normal office hours from 8:00 a.m. until 5:00 p.m. on Monday through Friday, excluding State
Holidays.
Upon completion of construction and prior to operation of this permitted facility, a
certification must be received from a professional engineer certifying that the permitted facility
has been installed in accordance with the NPDES Permit, this Authorization to Construct and the
approved plans and specifications. Mail the Certification to Cecil G. Madden, Jr., P.E.,
Construction Grants & Loans, DWQ / DENR, 1633 Mail Service Center, Raleigh, NC 27699-
1633.
Upon classification of the facility by the Certification Commission, the Permittee shall
employ a certified wastewater treatment plant operator to be in responsible charge (ORC) of the
wastewater treatment facilities. The operator must hold a certificate of the type and grade at
least equivalent to or greater than the classification assigned to the wastewater treatment
facilities by the Certification Commission.
The Permittee must also employ a certified back-up operator of the appropriate type and
grade to comply with the conditions of T15A:8G.0202. The ORC of the facility must visit each
Class I facility at least weekly and each Class II, III and IV facility at least daily, excluding
weekends and holidays, must properly manage the facility, must document daily operation and
maintenance of the facility, and must comply with all other conditions of T15A:8G.0202.
A copy of the approved plans and specifications shall be maintained on file by the
Permittee for the life of the facility.
During the construction of the proposed additions/modifications, the permittee shall
continue to properly maintain and operate the existing wastewater treatment facilities at all times,
and in such a manner, as necessary to comply with the effluent limits specified in the NPDES
Permit.
You are reminded that it is mandatory for the project to be constructed in accordance
with the North Carolina Sedimentation Pollution Control Act, and, when applicable, the North
Carolina Dam Safety Act. In addition, the specifications must clearly state what the contractor's
responsibilities shall be in complying with these Acts.

Cumming Cove Company, LLC
April 12, 2006
Page 3
Failure to abide by the requirements contained in this Authorization to Construct may
subject the Permittee to an enforcement action by the Division of Water Quality in accordance
with North Carolina General Statute 143-215.6A to 143-215.6C.
The issuance of this Authorization to Construct does not preclude the Permittee from
complying with any and all statutes, rules, regulations, or ordinances which may be imposed by
other government agencies (local, state, and federal) which have jurisdiction.
One (1) set of approved plans and specifications is being forwarded to you. If you have
any questions or need additional information, please contact Cecil G. Madden, Jr., P.E. at
telephone number [phone].
Sincerely
Ian W. Kli ek, E.
BSR:cgm
cc: William G. Lapsley, P.E., William G. Lapsley & Associates, P.A.
Henderson County Health Department
DWQ Asheville Regional Office, Surface Water Protection
Technical Assistance and Certification Unit
Daniel Blaisdell, P.E.
Point Source Branch, NPDES Program
Cecil G. Madden, Jr., P.E.
Seth Robertson, P.E.
A to C File