NC0086941_Issuance of Permit_20110628

•
ArC.IFAA
NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins Dee Freeman
Governor Director Secretary
June 28, 2011
Mr. Steve Hamilton, District Manager
Southeastern Wayne Sanitary District
PO Box 1583
Goldsboro, NC 27533
Subject: Issuance of NPDES Permit No. NC0086941
Devils Woodyard WTP—Class PC - 1
Wayne County
Dear Mr. Hamilton:
Division (DWQ) personnel have reviewed and approved your application for renewal of the subject permit.Accordingly,
we are forwarding the attached NPDES discharge permit. This permit is issued pursuant to the requirements of North
Carolina General Statute 143-215.1 and the Memorandum of Agreement between North Carolina and the U.S.
Environmental Protection Agency dated October 15, 2007 (or as subsequently amended).
Your email of March 4, 2011 indicated the possibility for expansion of this WTP facility and the need for an additional
effluent page reflecting said expansion. When this proposed expansion is further developed and an A to C has been
requested you should notify DWQ and request a Permit Modification for the Devils Woodyard WTP.
The following modifications in the April 13, 2011 draft permit remain in the final permit:
• Effluent limits and Monitoring requirements for Settleable Solids have been deleted
• Updated map for renewal
• Added new TRC language
• Footnotes have been modified and added.
• Upstream and downstream Turbidity sampling has been deleted and replaced with Effluent monitoring at 2/month
• Sampling frequencies have been changed for:
o Flow monitoring from weekly to 2/Month
o Total Residual Chlorine from Weekly to 2/Month
o Iron from Weekly to Quarterly
o Aluminum from Weekly to Quarterly.
• Additional monitoring requirements have been added for the following Pollutants of Concern:
o pH—2/week
o Fluoride - Quarterly sampling
o Copper—Quarterly sampling
o Zinc—Quarterly sampling.
o Ammonia Nitrogen—Quarterly sampling
• Whole Effluent Toxicity (Monitoring only)—Quarterly sampling
1617 Mail Service Center,Raleigh,North Carolina 27699-1617
Location:512 N.Salisbury St.Raleigh,North Carolina 27604 One
Phone:[phone] FAX:[phone] Customer Service:1-877-623-6748 NorthCarolina
Internet http://portal.ncdenr.org/web/wq/home Naturally
An Equal Opportunity l Affirmative Action Employer

. Permit NC0086941`
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility, whether for operation or discharge are
hereby revoked. As of this permit issuance, any previously issued permit bearing this number
is,no longer effective. Therefore, the exclusive authority to operate and discharge from this
facility arises under the permit conditions, requirements, terms, and provisions included
herein.
The Southeastern Wayne Sanitary District is hereby authorized to:
1. Continue to discharge treated filter backwash wastewater from a conventional water
treatment plant.
The facility is located at the Devil's Woodyard WTP at 4820 Arrington Bridge Road, near
Williams in Wayne County.
( -
Discharge from said treatment works at the location specified on the attached map into a
Horspen Branch, classified C-Swamp waters in the Cape Fear River Basin.
`3
o .9 - / . c
2 .---.(::-,4t4„),,,,ra (1. -1,,,,,, A„,prv,i, 11 4in^ 4 )-zr c 6.- 3 ',A, .- ‘ 4'.--J "'
v. 1.1.-^r 14,-11"1- pertcr.-Y-141 (

'Permit NC0086941
i WO
A. (1.) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS ^'
During the period beginning on the effective date of this permithand lasting until expiration,
the Permittee is authorized to discharge from outfall 001. Such discharges shall be limited
and monitored by the Permittee as specified below:
EFFLUENT LIMITS MONITORING REQUIREMENTS
CHARACTERISTICS
Monthly Daily Measurement Sample Type Sample
Average Maximum Frequency Location
50050- Flow 2/Month Instantaneous Effluent
00530—Total Suspended Solids 30 mg/L 45 mg/L 2/Month Grab Effluent
00400-pH 6.0—9.0 s.u. 2/Month Grab Effluent
50060-Total Residual Chlorine' 17 pg/L 2/Month Grab Effluent
00076—Turbidity 2/Month Grab Effluent
01105- Aluminum Quarterly2 Grab Effluent
01045-Total Iron Quarterly2 Grab Effluent
01042 -Total Copper Quarterly2 Grab Effluent
00951 - Fluoride Quarterly2 Grab Effluent
01092 -Total Zinc Quarterly2 Grab Effluent
01055- Manganese Quarterly2 Grab Effluent
00610—Ammonia Nitrogen Quarterly2 Grab Effluent
TGE6C -Whole Effluent Toxicity Quarterly Grab Effluent
Monitoring
3
Footnotes:
I <`7 1) The Division shall consider all effluent TRC values reported below 50 ug/l to be in compliance with the permit.
However,the Permittee shall continue to record and submit all values reported by a North Carolina certified
laboratory(including field certified),even if these values fall below 50 ug/l.
2) Parameter should be monitored in conjunction with toxicity test
3) Acute,Toxicity Monitoring P/F Quarterly TGE6C. See Condition A. (2.). Further studies will be required to
determine the cause of toxicity, if any. The collection of samples shall coincide with the sampling of other
parameters.
There shall be no discharge of floating solids or visible foam in other than trace amounts
All samples collected should be of a representative discharge.

0
--mom
►�►�oZoZo�o�►��05����mmm®
��►Z�EoZ�OO
�� _P-4
P-4Ommm@.
�
�oo��p►_a���G�o_�om®mom
_�►500
�oZ�
�a �oZoS
_�m�m�
00
_4ro
_�-1o:
0-05
_4mmm®
Oro
-1-*OR_���po��mmm®
OD►_�
��
_� ��►Zo�o
�G
��mmm�
O'
00��►-�0ORI10
0 0
R
?►��o
1roOoo
OR 1 k0��-4mmm®
OR
F-4
�_4
po_M►W_5►_
ooPE4mmm®
�O
��►_
�u
� _�
�� _SOD
��mmm�
t 1qq 1 #99
---� jT�� rnu�ty wtK �M Wwu oU.rv,
�/ � Lnptl VUK �M (lICM 0.(nAla
e.•n•w,o. n•n urcnn. o nw
SEAL �=
1972 -` = V
74
;....
ryN��3`,;
spa.
B
g
Y t
i 3 k
Z
J �
V
w �
Z ~ O
uj U
U
w
Z ' O(j
g a �
U ~ U
LU F
w
F
mU3
1 n
U d
K F - 0
ILQ W Z
Q
F o Y
U N w
LL
O
0 V
U w
Z
3
1EET G3 OF 34

• ,
• The site map has been updated to reflect lat& long values for your discharge point.
• Parameter codes have been added to the effluent page.
• Additional monitoring requirements have been added for the following Pollutants of Concern:
o Total Copper—Quarterly sampling.
o Manganese—Quarterly sampling.
o Whole Effluent Toxicity(Monitoring only)—Quarterly sampling.
If any parts, measurement frequencies or sampling requirements contained in this permit are unacceptable to you,you have the
right to an adjudicatory hearing upon written request within thirty(30)days following receipt of this letter. This request must be
in the form of a written petition,conforming to Chapter 150B of the North Carolina General Statutes,and filed with the Office of
Administrative Hearings(6714 Mail Service Center, Raleigh, North Carolina 27699-6714). Unless such demand is made,this
decision shall be final and binding.
Please note that this permit is not transferable except after notice to the Division. The Division may require modification or
revocation and reissuance of the permit. This permit does not affect the legal requirements to obtain other permits which may
be required by the Division of Water Quality or permits required by the Division of Land Resources,the Coastal Area
Management Act or any other Federal or Local governmental permit that may be required. If you have any questions
concerning this permit, please contact Bob Guerra at telephone number(919)807-6387 or email at(bob.querra4ncdenr.aov).
# ,
64:4,4-/:71
oleen H. Sullins ..;4
Enclosure: NPDES Permit NC0086941
cc: Washington Regional Office/Surface Water Protection Supervisor Al Hodge
Aquatic Toxicology/Susan Meadows
NPDES Unit
Central files

• Permit NC0086941
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
Southeastern Wayne Sanitary District
is hereby authorized to discharge wastewater from a facility located at the
Devil's Woodyard WTP
4820 Arrington Bridge Road
Near Williams
Wayne County
to receiving waters designated as a Horespen Branch in the Cape Fear River Basin
in accordance with effluent limitations, monitoring requirements, and other conditions set
forth in Parts I, II, Ill and IV hereof.
This permit shall become effective August 1, 2011.
This permit and authorization to discharge shall expire at midnight on May 31, 2016.
Signed this day June 28, 2011.
/24w
�Co - H. Sullins,Director
'ision of Water Quality
By Authority of the Environmental Management Commission

Briar
Bed
ll
.
� J
Qo-
� J
4
Outfall 001
50 �.
}
•'ALw. r
Devils
\ Woodyard `
WTP `
/ 47.6
1
SE Wayne Sanitary District Facility
Devils Woodyard WTP Location AAAW,
Latitude: 35' 13' 02" N State Grid: Williams not to scale
Lonctitude: 77' 57' 27" W Permitted Flow: NIA
Receivinq Stream: Horsepen Branch Drainage Basin: Cape Fear River Basin ]� NPDES Permit No. NCO081141
Stream Class: C - SW Sub-Basin/HUC: 03-06-21/030300007 Worth orth Wayne County

Permit NC0086941
A. (2.) CHRONIC TOXICITY MONITORING (QRTRLY)
The permittee shall conduct quarterly chronic toxicity tests using test procedures outlined in the"North
Carolina (Ceriodaphnia Dubia) Chronic Effluent Bioassay Procedure,"Revised February 1998,or
subsequent versions.
The effluent concentration defined as treatment two in the procedure document is 90%. The testing shall be
performed as a Ceriodaphnia dubia 7day pass/fail test. The tests will be performed during the months of
January,April,July and October. Effluent sampling for this testing shall be performed at the NPDES
Permitted final effluent discharge below all treatment processes.
All toxicity testing results required as part of this permit condition will be entered on the Effluent Discharge
Monitoring Form (MR-1)for the month in which it was performed, using the parameter code TGP3B.
Additionally, DWQ Form AT-1 (original)is to be sent to the following address:
Attention: North Carolina Division of Water Quality
Environmental Sciences Section
1621 Mail Service Center
• Raleigh, N.C. 27699-1621
Completed Aquatic Toxicity Test Forms shall be filed with the Environmental Sciences Section no
later than 30 days after the end of the reporting period for which the report is made.
Test data shall be complete and accurate and include all supporting chemical/physical measurements performed
in association with the toxicity tests, as well as all dose/response data.Total residual chlorine of the effluent
toxicity sample must be measured and reported if chlorine is employed for disinfection of the waste stream.
Should there be no discharge of flow from the facility during a month in which toxicity monitoring is required,the
permittee will complete the information located at the top of the aquatic toxicity(AT)test form indicating the
facility name, permit number,pipe number, county, and the month/year of the report with the notation of"No
Flow"in the comment area of the form.The report shall be submitted to the Environmental Sciences Section at
the address cited above.
Should the permittee fail to monitor during a month in which toxicity monitoring is required,then monthly
monitoring will begin immediately. Upon submission of a valid test,this monthly test requirement will revert to
quarterly in the months specified above.
Should any test data from this monitoring requirement or tests performed by the North Carolina Division of Water
Quality indicate potential impacts to the receiving stream,this permit may be re-opened and modified to include
alternate monitoring requirements or limits.
If the Permittee monitors any pollutant more frequently than required by this permit,the results of such
monitoring shall be included in the calculation&reporting of the data submitted on the DMR&all AT Forms
submitted.
NOTE: Failure to achieve test conditions as specified in the cited document,such as minimum control
organism survival,minimum control organism reproduction,and appropriate environmental controls,
shall constitute an invalid test and will require immediate follow-up testing to be completed no later than
the last day of the month following the month of the initial monitoring.

•
FACT SHEET
COMPLEX EXPEDITED PERMIT RENEWAL
Permit Writer/Date Bob Guerra /6-28-11
Permit Number NC0086941
Facility Name Devil's Woodyard WTP
Basin Name/Sub-basin number Cape Fear River/03-06-21
Receiving Stream Horsepen Branch
Stream Classification in Permit C-Swamp
Does permit need Daily Max NH3 No
limits?
Does permit need TRC limits/language? New language added
Does permit have toxicity testing? Newly added per WTP Strategy
Does permit have Special Conditions? Just Tox testing
Does permit have instream monitoring? Deleted per WTP strategy and replaced with effluent
monitoring
Is the stream impaired (on 303(d)list)? No
Any obvious compliance concerns? No—see Attached enforcement history
Any permit mods since last permit? No
Current expiration date 05-31-2011
New expiration date 05-31-2016
Comments received on Draft Permit? Facility requested Speculative limits for an increase of its
existing WTP from 0.9 MGD to 1.62 MGD. Treatment
facilities at the existing facility will be duplicated during the
proposed expansion. Speculative limits letter issued 2-12-
2010 with permit limits/monitoring being the same as the
existing permit limits/monitoring.Advised facility in cover
letter to request Permit Modification when ATC is
requested for additional flows at facility.
Changes to the Previous Permit:
• Effluent limits and Monitoring requirements for Settleable Solids have been deleted
• Updated map for renewal
• Added new TRC language
• Footnotes have been modified and added.
• Upstream and downstream Turbidity sampling has been deleted and replaced with Effluent
monitoring at 2/month
• Sampling frequencies have been changed for:
o Flow monitoring from weekly to 2/Month
o Total Residual Chlorine from Weekly to 2/Month
o Iron from Weekly to Quarterly
o Aluminum from Weekly to Quarterly.
• Additional monitoring requirements have been added for the following Pollutants of Concern:
o pH—2/week
o Fluoride -Quarterly sampling
o Copper—Quarterly sampling.
o Zinc—Quarterly sampling.
o Ammonia Nitrogen—Quarterly sampling
• Whole Effluent Toxicity(Monitoring only)—Quarterly sampling
BIMS Downloads:
• Permit enforcement history:
o None during existing permit cycle
• NOV's issued limit exceedances:
o None during existing permit cycle
DMR Parameter Values Export: (2006—2010)
• No discharge during current permit cycle. Backwash is recycled internally

NORTH CAROLINA
WAYNE COUNTY
CLIPPING OF LEGAL
AFFIDAVIT OF PUBLICATION ADVERTISEMENT
Before the undersigned,a Notary Public of said County and State, duly ATTACHED HERE
commissioned, qualified, and authorized by law to administer oaths, per-
I Public
sonally appeared North Carolina Enviromnental
Management
Teresa BozEillar1 Commission/NPDES Unit
1617 Mail Service Center
who being first duly sworn, deposes and says: that he (she) is Raleigh,NC 27699-1617
Notice of Intent to Issue a
Legal Clerk NPDES Wastewater Permit
The North Carolina Environ-
(Publisher, or other officer or employee authorized to make affidavit) of mento) Management s
mission proposes to mentaa
WAYNE PRINTING COMPANY, INC., engaged in the publication of a harge
pe toS the perwastewaser on(s)rson(s)listed
newspaper known as GOLDSBORO NEWS-ARGUS, published, issued, below.
Written pe
and entered as second class mail in the city of Goldsboro in said County ing the proposed permit will
be accepted until 30 days af-
and State; that he (she) is authorized to make this affidavit and sworn ter the publish date of this
notie. ctor of the C
statement; that the notice or other legal advertisement, a true copy of DivisionheofDWater Quality
in GOLDSBORO NEWS-
(DWI) may hold a public
which is attached hereto, was
publishedhearing should there be a sig-
ARGUS on the following dates: Mficant degree of public in-
terest Please mail comments
and/or information requests
to DWQ at the above address.
April 22, 2011 Interested persons may visit
the DWQ at 512 N.Salisbury
Street,Raleigh,NC to review
information on file.Additional
information on NPDES per-
mitsand that the said newspaper in which such notice, paper, document, or and this noticermays be
P P found on our website:
legal advertisement was published was,at the time of each,and every such http://portal.ncdenr.org/web/
wq/swp/ps/n pdes/calendar,
publication, a newspaper meeting all of the requirements and or by calling(919)807-6304.
qualifications of Section 1-597 of the General Statutes of North Carolina tary District requested rn nre e-
1
and was a qualified newspaper within the meaning of Section 1-597 of the to Devils wal of pW odyn Wermit oodyard
General Statutes of North Carolina. Wayne County;this permitted
discharge is treated
filter-backwash wastewater
to Horsepen Branch, Cape �
Fear River Basin.
This 28 day of April 20 11Legal Apo 22,2011 II
a . . tx,
(Signature of person making adavit)
Sworn to and subscribed before me, this 28th day of
Cji ' April / , 20 11
/ Or 1/ 227
àarY?blic9 My Commission expires: 67V
� ,

Guerra, Bob
From: Cecil Madden [[e-mail]]
Sent: Friday, March 04,2011 9:28 AM
To: Guerra, Bob
Cc: [e-mail];[e-mail]
Subject: Re: Southeastern Wayne Sanitary District Application for Renewal NC0086941
Hello Bob,
Here are a few comments regarding the Renewal/Expansion.
The SEWSD has confirmed the following GPS Coordinates 35 13'02" N, 77 57"27 W.
SEWSD currently disinfects with chlorine. Their goal is to have the capability to use chloramination if and when they
begin purchase of water from the City of Goldsboro. In order to purchase water from Goldsboro for their daily use,their
method of potable water disinfection needs to be compatible.
Construction Grants and Loans will not accept plans and specifications for the expansion of the discharge facility until the
Draft NPDES Permit is advertised, and they prefer not to receive the request for an A to C until the Final NPDES Permit is
issued. The USDA recently authorized funding for the project. Design is about to be initiated.
Regards,
Cecil G. Madden,Jr., P.E.
McDavid Associates, Inc.
P. O. Box 1776
Goldsboro, NC 27533
919-736-7630 Phone
919-735-7351 Fax
cqmmcdavid-inc.com
Physical Address:
109 East Walnut Street
Goldsboro, NC 27530
----Original Message
From: Guerra, Bob
To: Cecil Madden
Sent: Thursday, March 03,2011 1:11 PM
Subject: RE: Southeastern Wayne Sanitary District Application for Renewal NC0086941
Thanks for the information. Have P&S been submitted and has an ATC been requested for the expansion?
If not I will issue the permit with one effluent page and handle the expansion as a permit modification.
You have 30 days to comment when the draft is put out for public notice.
From: Cecil Madden f mailto:[e-mail]
Sent:Thursday, March 03, 2011 12:05 PM
To: Guerra, Bob
Cc: [e-mail]; [e-mail]
Subject: Southeastern Wayne Sanitary District Application for Renewal NC0086941
Hello Mr. Guerra,
1

Southeastern Wayne Sanitary District
P. O.Box 1583
Goldsboro,N.C.27533
[phone]
November 22,2010
Mrs.Dina Sprinkle
NCDENR/DWQ/Point Source Branch
1617 Mail Service Center •
Raleigh,N.C.27699-1617
Subject: NPDES Permit Renewal
NPDES Permit No.NC0086941 •
Southeastern Wayne Sanitary District
Wayne County,NC
Dear Mrs. Sprinkle:
This letter will serve as Southeastern Wayne Sanitary District's request for renewal of our
NPDES Permit NC0086941. There has been no discharge from this facility since August 2005. In lieu of
discharge,the water is being blended with raw water coming into the plant. However,the District must
maintain the ability to discharge. Please fmd attached the following items: •
1. Completed Application Form
2. Map Showing Discharge Location
3. Flow Schematic,and
4. Residuals Management Plan
On or about October 22,2008,this office requested to be decertified, since we were not
discharging. There is an agreement with the City of Goldsboro to analyze any samples until we are
recertified,in the event we need to resume discharging:
Should you have questions regarding our request for renewal you may contact
Cecil G.Madden,Jr.,P.E.with McDavid Associates,Inc.at(919)736-7630 or call me.
S.•cer-J,,
Steve Hamilton
District Manager
Attachments
cc: McDavid Associates,Inc.
W:1D10XX_GENND100X_MSW\D1005_CORRES_MSW\CGM120101SEWSD-NPDES RENEWAL\REQUEST FOR RENEWAL.DOC

r Southeastern Wayne Sanitary District
P. O. Box 1583
Goldsboro,N.C. 27533
[phone]
Residuals Management Plan
Quantity Generated
Residuals to be handled come from the backwashing of iron filters. It is anticipated that approximately
that 1 mg/I of iron will be removed.
Annual Iron Removal = 365 days x 0.9 MGD x 8.43 x 1 mg/1
= 2,740 lbs.
= 2,740 lbs. / 140 lbs/ft3
= 19.6 ft3 per year
Residuals Handling and Storage
Backwash from the iron filters is distributed to two 40'by 20'waste settling tanks where the solids
precipitate out.
Depth of Residuals = Annual Residuals/Tank Area
Within Tanks
= 19.6ft/(2x40' x20')
= 0.01225' deep
= 0.147"deep
Adequate storage is available.
Ultimate Disposal or Reuse
Residuals do not have to be removed frequently. They are being handled under contract with Granville
Farms, Inc,Post Office Box 1396,Oxford,NC 27565. The last time residuals were removed was March
2008. Attached is a copy of the chemical analysis of the residuals.
A
4' TAP; .,1
Steve Hamilton,District Manager
�i!l9a77:ii))
(�-, �, 0C14i ,,
$ •i4.';�, ',tom.. a Ll . ✓'"J
wir
1 O SEM.. ` +a, _ _ SEAL • �0
°
16359 `' 1972 •
Aof �+5 V ilk ~✓ °.;J,
'y c e�t �`Pye.4 oma.. ��' ..
Cecil G.Madden, r.,P.E. �.c ,,
v `O',OCCL,fr:,,' ^C. • `LI
McDavid Associates, Inc. `�e<'41::::z:,,:;',7 -', t;', is •A' , ::,,:,
[phone] lf
/47.f ID
W:\D10XX_GEN\D100X_MSW\D1005_CORRES_MSW\CGM\2010\SEWSD-NPDES RENEWAL\REQUEST FOR RENEWAL.DOC