NC0056618_Authorization to Construct_20050712

Carolina Water Service, Inc.
A to C No. 056618A01
Issued June 13, 2005
Engineer's Certification
I, L-1 PN WOO � L-� J �U � u 0 , as a duly registered Professional Engineer in
the State of North Carolina, having been authorized to observe (periodically/weekly/full time)
the construction of the modifications and improvements to the Carolina Pines WWTP, located on
State Road 1176 in Craven County for Carolina Water Service, Inc., hereby state that, to the best
of my abilities, due care and diligence was used in the observation of the following construction:
Installation of three tablet feed dechlorination units, pursuant to the fast track
application received on May 19, 2005, and in conformity with the Minimum
Design Criteria for Dechlorination Facilities.
I certify that the construction of the above referenced project was observed to be built
within substantial compliance and intent of the approved plans and specifications.
Signature Registration No. �C—
Date O�— 0 (— fri,,"O
Send to: Construction Grants & Loans
DENR/DWQ
1633 Mail Service Center
Raleigh, NC 27699- l 633
Rn
,1 U L 1 2 2005VIA' -11Y
t I
CAg0 ��''.
0 •..........• Z
�•: �FES8j� ,�2y'•:
PC 5279
•'" P: O`er
'•,?'••;;'C�/NEE.' J
E.
1nN GRANTA
'A

Mr. Jerry Underwood
Carolina Water Service, Inc.
5058 Hwy 70 West
Westridge Center, N-2
Morehead City, North Carolina 28557
SUBJECT:
Dear Mr. Underwood:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
June 13, 2005
Authorization to Construct
A to C No. 056618A01
Carolina Water Service, Inc.
Carolina Pines WWTP
Craven County
Alan W. Klimek, P.E. Director
Division of Water Quality
A fast track application for Authorization to Construct dechlorination facilities was
received on May 19, 2005, by the Division. Authorization is hereby granted for the construction
of modifications to the existing Carolina Pines WWTP, with discharge of treated wastewater into
the Neuse River in the Neuse River Basin.
This authorization results in no increase in design or permitted capacity and is awarded
for the construction of the following specific modifications:
Installation of three tablet feed dechlorination units, pursuant to the fast track application
received on May 19, 2005, and in conformity with the Minimum Design Criteria for
Dechlorination Facilities.
This Authorization to Construct is issued in accordance with Part III, Paragraph A of
NPDES Permit No. NCO056618 issued November 12, 2003, and shall be subject to revocation
unless the wastewater treatment facilities are constructed in accordance with the conditions and
limitations specified in Permit No. NC0056618.
In the event that the facilities fail to perform satisfactorily, including the creation of
nuisance conditions, the Permittee shall take immediate corrective action, including those as may
be required by this Division, such as the construction of additional or replacement wastewater
treatment or disposal facilities.
The Washington Regional Office, telephone number [phone], shall be notified at
least forty-eight (48) hours in advance of operation of the installed facilities so that an on site
NorthCarolina
vVatura!!y
North Carolina Division of Water Quality 1617 Mail Service Center Ralei,-h, NC 27699-16 t 7 Phone [phone] Customer Service
Internet: h2o.enr.state.nc.us 512 N. Salisbury St. Raleigh, NC 27604 FAX [phone]
An Equal Opportunity/Affirmative Action Employer — 50% Recycled/10% Post Consumer Paper

Mr. Jerry Underwood
June 13, 2005
Page 2
inspection can be made. Such notification to the regional supervisor shall be made during the
normal office hours from 8:00 a.m. until 5:00 p.m. on Monday through Friday, excluding State
Holidays.
Pursuant to 15A NCAC 2H .0140, upon completion of construction and prior to operation of
these permitted facilities, the completed Engineering Certification form attached to this permit shall be
submitted to the address provided on the form.
Upon classification of the facility by the Certification Commission, the Permittee shall
employ a certified wastewater treatment plant operator to be in responsible charge (ORC) of the
wastewater treatment facilities. The operator must hold a certificate of the type and grade at least
equivalent to or greater than the classification assigned to the wastewater treatment facilities by
the Certification Commission.
The Permittee must also employ a certified back-up operator of the appropriate type and
grade to comply with the conditions of T15A:8G.0202. The ORC of the facility must visit each
Class I facility at least weekly and each Class Il, III and IV facility at least daily, excluding
weekends and holidays, must properly manage the facility, must document daily operation and
maintenance of the facility, and must comply with all other conditions of T15A:8G.0202.
A copy of the approved plans and specifications shall be maintained on file by the
Permittee for the life of the facility.
During the construction of the proposed additions/modifications, the permittee shall
continue to properly maintain and operate the existing wastewater treatment facilities at all times,
and in such a manner, as necessary to comply with the effluent limits specified in the NPDES
Permit.
You are reminded that it is mandatory for the project to be constructed in accordance
with the North Carolina Sedimentation Pollution Control Act, and, when applicable, the North
Carolina Dam Safety Act. In addition, the specifications must clearly state what the contractor's
responsibilities shall be in complying with these Acts.
Failure to abide by the requirements contained in this Authorization to Construct may
subject the Permittee to an enforcement action by the Division of Water Quality in accordance
with North Carolina General Statute 143-215.6A to 143-215.6C.
The issuance of this Authorization to Construct does not preclude the Permittee from
complying with any and all statutes, rules, regulations, or ordinances which may be imposed by
other government agencies (local, state, and federal) which have jurisdiction.

Mr. Jerry Underwood
June 13, 2005
Page 3
If you have any questions or need additional information, please do not hesitate to contact
Cecil G. Madden, Jr., P.E. at telephone number [phone].
XSincerely,ek, P.E
MH/cgm
cc: Linwood Stroud, P.E. — Stroud Engineering, P.A.
Craven County Health Department
Washington Regional Office, Surface Water Protection Section
Technical Assistance and Certification Unit
Daniel Blaisdell, P.E.
Point Source Branch, NPDES Program
Cecil G. Madden, Jr., P.E.
Mark Hubbard, E.I.
A to C File