NC0078115_Authorization to Construct_20080416

Aqua North Carolina, Inc.
A To C No. 078115A02
Issued January 8, 2008
Engineer's Certification
I, T /0.41-,..e , as a duly registered Professional Engineer in
the State of North Carolina, having been authorized to observe (periodically/weekly/full time)
the construction of the modifications and improvements to the Greystone Subdivision WWTP,
located on Creek Bed Road in Forsyth County for Aqua North Carolina, Inc., hereby state that, to
the best of my abilities, due care and diligence was used in the observation of the following
construction:
Installation of a dechlorination system utilizing sodium sulfite pursuant to the fast
track application received on December 27, 2007, and in conformity with the
Minimum Design Criteria for Dechlorination Facilities.
I certify that the construction of the above referenced project was observed to be built
within substantial comjpliance and intent of the approved plans and specifications.
Signature
Date
Send to:
Registration No. /6 ¢-3
Construction Grants & Loans
DENR/DWQ
1633 Mail Service Center
Raleigh, NC 27699-1633
e'4 'RURrONV,
St.,
'44 ;38i4i33Lg.
RECE!VED
J4111 1
RRt�.•am' �,w ' ';
APR 2 5 2008
DENR WAT.., ,.
J
n

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
January 8, 2008
Mr. Gary Moseley
Aqua North Carolina, Inc.
4163 Sinclair Street
Denver, North Carolina 28037
SUBJECT: Authorization to Construct
A to C No. 078115A02
Aqua North Carolina, Inc.
Greystone Subdivision WWTP
Dechlorination Facilities
Forsyth County
Dear Mr. Moseley:
Coleen H. Sullins, Director
Division of Water Quality
A fast track application for Authorization to Construct dechlorination facilities was
received on December 27, 2007, by the Division. Authorization is hereby granted for the
construction of modifications to the existing Greystone Subdivision WWTP, with discharge of
treated wastewater effluent into Belews Creek in the Roanoke River Basin.
This authorization results in no increase in design or permitted capacity and is awarded
for the construction of the following specific modifications:
Installation of a dechlorination system utilizing sodium sulfite pursuant to the fast
track application received on December 27, 2007, and in conformity with the
Minimum Design Criteria for Dechlorination Facilities.
This Authorization to Construct is issued in accordance with Part III, Paragraph A of
NPDES Permit No. NC0078115 issued September 27, 2007, and shall be subject to revocation
unless the wastewater treatment facilities are constructed in accordance with the conditions and
limitations specified in Permit No. NC0078115.
In the event that the facilities fail to perform satisfactorily, including the creation of
nuisance conditions, the Permittee shall take immediate corrective action, including those as may
be required by this Division, such as the construction of additional or replacement wastewater
treatment or disposal facilities.
The Winston-Salem Regional Office, telephone number [phone] shall be notified
at least forty-eight (48) hours in advance of operation of the installed facilities so that an on site
o Nne hCarolina
Naturally
North Carolina Division of Water Quality
Internet www.ncwateroualitv.orq 512 N. Salisbury St.
1617 Mail Service Center Raleigh, NC 27699-1617 Phone [phone] Customer Service
Raleigh, NC 27604 FAX [phone]
An Equal opportunity/Affirmative Action Employer — 50% Recycled/10% Post Consumer Paper

Mr. Greeson
January 8, 2008
Page 2
inspection can be made. Such notification to the regional supervisor shall be made during the
normal office hours from 8:00 a.m. until 5:00 p.m. on Monday through Friday, excluding State
Holidays.
Pursuant to 15A NCAC 2H .0140, upon completion of construction and prior to operation
of these permitted facilities, the completed Engineering Certification form attached to this permit
shall be submitted to the address provided on the form.
Upon classification of the facility by the Certification Commission, the Permittee shall
employ a certified wastewater treatment plant operator to be in responsible charge (ORC) of the
wastewater treatment facilities. The operator must hold a certificate of the type and grade at least
equivalent to or greater than the classification assigned to the wastewater treatment facilities by
the Certification Commission.
The Permittee must also employ a certified back-up operator of the appropriate type and
grade to comply with the conditions of T15A:8G.0202. The ORC of the facility must visit each
Class I facility at least weekly and each Class II, III and IV facility at least daily, excluding
weekends and holidays, must properly manage the facility, must document daily operation and
maintenance of the facility, and must comply with all other conditions of T15A:8G.0202.
A copy of the approved plans and specifications shall be maintained on file by the
Permittee for the life of the facility.
During the construction of the proposed additions/modifications, the permittee shall
continue to properly maintain and operate the existing wastewater treatment facilities at all times,
and in such a manner, as necessary to comply with the effluent limits specified in the NPDES
Permit.
You are reminded that it is mandatory for the project to be constructed in accordance
with the North Carolina Sedimentation Pollution Control Act, and, when applicable, the North
Carolina Dam Safety Act. In addition, the specifications must clearly state what the contractor's
responsibilities shall be in complying with these Acts.
Prior to entering into any contract(s) for construction, the recipient must have obtained all
applicable permits from the State.
Failure to abide by the requirements contained in this Authorization to Construct may
subject the Permittee to an enforcement action by the Division of Water Quality in accordance
with North Carolina General Statute 143-215.6A to 143-215.6C.
The issuance of this Authorization to Construct does not preclude the Permittee from
complying with any and all statutes, rules, regulations, or ordinances which may be imposed by
other government agencies (local, state, and federal) which have jurisdiction.

Mr. Greeson
January 8, 2008
Page 3
If you have any questions or need additional information, please do not hesitate to contact
Cecil G. Madden, Jr., P.E. at telephone number [phone].
Sincere
/)/14/11
ColeH. Sullins
AR/cgm
cc: James Thurman Horne, P.E., Horizon Engineering & Consulting, Inc., Mount Pleasant
Forsyth County Health Department
DWQ Winston-Salem Regional Office, Surface Water Protection
Technical Assistance and Certification Unit
Daniel Blaisdell, P.E.
Point Source Branch, NPDES Program
Cecil G. Madden, Jr., P.E.
Anita E. Reed, P.E.
ATC File