NC0085871_Issuance of Permit_20040416

sCoF W A rF9 Michael F. E
Goarnor
NCDENR William G. Ross,Jr., Secretary
North Carolina Department of Environment and Natural Resources
0 -c Alan W. Klimek, P.E., Director
Division of Water Quality
April 16,2004
Mr. Andy Karlbergs
Director,Real Estate
Flakt Products, Inc.
501 Merrit 7
Norwalk,CT 18252
Subject: Issuance of NPDES Permit NC0085871
Flakt Products Remediation Site
Forsyth County
Dear Mr. Karlbergs:
•
Division personnel have reviewed and approved your application for renewal of the subject permit.
Accordingly,we are forwarding the attached NPDES discharge permit. This permit is issued pursuant to the
requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement between North
Carolina and the U.S. Environmental Protection Agency dated May 9, 1994(or as subsequently amended).
This final permit includes no major changes from the draft permit sent to you on February 18,2004.
If any parts,measurement frequencies or sampling requirements contained in this permit are unacceptable to
you,you have the right to an adjudicatory hearing upon written request within thirty(30) days following receipt of
this letter. This request must be in the form of a written petition, conforming to Chapter 1 SOB of the North Carolina
General Statutes, and filed with the Office of Administrative Hearings (6714 Mail Service Center,Raleigh,North
Carolina 27699-6714). Unless such demand is made, this decision shall be final and binding.
Please note that this permit is not transferable except after notice to the Division. The Division may require
modification or revocation and reissuance of the permit. This permit does not affect the legal requirements to obtain
other permits which may be required by the Division of Water Quality or permits required by the Division of Land
Resources,the Coastal Area Management Act or any other Federal or Local governmental permit that may be
required. If you have any questions concerning this permit,please contact Sergei Chernikov at telephone number
[phone],extension 594.
Sincerely,
ORIGINAL SIGNED BY
SUSAN A. WILSON
Alan W. Klimek,P.E.
cc: NPDES Unit Q
Winston-Salem Regional Office / Water Quality Section
Ricky A. Ryan,P.E.
MACI'EC Engineering and Consulting, Inc.
1431 Centerpoint Blvd.,Suite 150
Knoxville,TN 37932-8226
N.C.Division of Water Quality/NPDES Unit Phone:[phone]
1617 Mail Service Center,Raleigh,NC 27699-1617 fax:[phone]
Internet:h2o.enr.state.nc.us DENR Customer Service Center 1 800 623-7748

•
• Permit No. NC0085871
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act,as amended,
Flakt Products,Inc.
is hereby authorized to discharge wastewater from a facility located at
Flakt Products
200 Lowery Street
Winston Salem
Forsyth County
to receiving waters designated as Brushy Fork in the Yadkin Pee Dee River Basin in accordance with effluent
limitations, monitoring requirements, and other conditions set forth in Parts I, II,III, and IV hereof.
The permit shall become effective June 1, 2004.
This permit and the authorization to discharge shall expire at midnight on May 31, 2009.
Signed this day April 20,2004.
ORIGINAL SIGNED BY
SUSAN A. WILSON
Alan Klimek, P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission

Permit No. NC0085871
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility,whether for operation or discharge are hereby revoked. As of this
permit issuance,any previously issued permit bearing this number is no longer effective.Therefore,the exclusive
authority to operate and discharge from this facility arises under the permit conditions,requirements,terms,and
provisions included herein.
Flakt Products, Inc.
is hereby authorized to:
1. Continue to operate an existing 0.0864 MGD groundwater remediation treatment system consisting
of extraction wells, sequestering agent tank and transfer pump, equalization tank with transfer pump,
air stripper, flow monitoring devise, located off Lowery Street in Winston Salem,Forsyth County.
2. Discharge treated wastewater(via Outfall 001) from said facility into Brushy Fork, currently a Class
C water in the Yadkin-Pee Dee River Basin, at the location specified on the attached map.

Latitude:
36' 05' 30"
Longitude:
800 13' 18"
USGS Quad #:
C18SW
River Basin #:
03-07-04
Receiving Stream:
Brushy Fork
Stream Class:
C
Flakt Products, Inc.
NCO085871
Forsyth County

Permit No. NC0085871
A. (1) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
Beginning on the effective date of this permit and lasting until expiration, the Permittee is authorized to
discharge treated wastewater from Outfall 001. Such discharges shall be limited and monitored by the
Permittee as specified below:
EFFLUENT LIMITATIONS MONITORING REQUIREMENTS
EFFLUENT
CHARACTERISTICS Monthly Daily Measurement Sample Sample Location
Frequency
Average Maximum Type
-. — - • -
Flow' 0.0864 MGD Continuous Recorder Influent or Effluent
Total Suspended Solids 30.0 mg/L Quarterly Grab Effluent
Benzene Quarterly Grab Effluent
Carbon tetrachloride Quarterly Grab Effluent
Chloroform Quarterly Grab Effluent
1,1-dichloroethene Quarterly Grab Effluent
1,2-dichloroethane Quarterly Grab Effluent
Methylene chloride Quarterly Grab Effluent
Trichloroethene Quarterly Grab Effluent
Tetrachloroethene Quarterly Grab Effluent
1,1,2,2-tetrachloroethane Quarterly Grab Effluent
1,1,2-trichloroethane Quarterly Grab Effluent
Total Arsenic Quarterly Grab Effluent
Total Copper Quarterly Grab Effluent
Total Iron Quarterly Grab Effluent
Total Lead Quarterly Grab Effluent
Total Manganese Quarterly Grab Effluent
Total Zinc Quarterly Grab Effluent
Chronic Toxicit? Quarterly Composite Effluent
Footnotes:
1. If the discharge is not continuous, flow may be monitored weekly by an instantaneous flow
measurement.
2. Chronic Toxicity(Ceriodaphnia) P/F at 4.5%, March, June, September, December [see A. (2)].

Permit No. NC0085871,
A. (2) CHRONIC TOXICITY PASS/FAIL PERMIT LIMIT (Quarterly)
The effluent discharge shall at no time exhibit chronic toxicity using test procedures outlined in the"North
Carolina Ceriodaphnia Chronic Effluent Bioassay Procedure,"Revised November 1995,or subsequent versions.
The effluent concentration at which there may be no observable inhibition of reproduction or significant mortality
is 4.5% (defined as treatment two in the procedure document). The permit holder shall perform quarterly
monitoring using this procedure to establish compliance with the permit condition. The tests will be performed
during the months of March,June,September,and December. Effluent sampling for this testing shall be
performed at the NPDES permitted final effluent discharge below all treatment processes.
If the test procedure performed as the first test of any single quarter results in a failure or ChV below the permit
limit, then multiple-concentration testing shall be performed at a minimum, in each of the two following months as
described in "North Carolina Phase II Chronic Whole Effluent Toxicity Test Procedure" (Revised-February 1998)
or subsequent versions.
All toxicity testing results required as part of this permit condition will be entered on the Effluent Discharge
Monitoring Form(MR-1)for the month in which it was performed, using the parameter code TGP3B.
Additionally,DWQ Form AT-1 (original)is to be sent to the following address:
Attention: Environmental Sciences Branch
North Carolina Division of Water Quality
4401 Reedy Creek Road
Raleigh,North Carolina 27607
Test data shall be complete and accurate and include all supporting chemical/physical measurements performed in
association with the toxicity tests, as well as all dose/response data. Total residual chlorine of the effluent toxicity
sample must be measured and reported if chlorine is employed for disinfection of the waste stream.
Should there be no discharge of flow from the facility during a month in which toxicity monitoring is required, the
permittee will complete the information located at the top of the aquatic toxicity(AT)test form indicating the
facility name,permit number,pipe number,county,and the month/year of the report with the notation of"No
Flow" in the comment area of the form. The report shall be submitted to the Environmental Sciences Branch at the
address cited above.
Should any single quarterly monitoring indicate a failure to meet specified limits,then monthly monitoring will
begin immediately until such time that a single test is passed. Upon passing,this monthly test requirement will
revert to quarterly in the months specified above.
Should the permittee fail to monitor during a month in which toxicity monitoring is required, then monthly
monitoring will begin immediately until such time that a single test is passed. Upon passing,this monthly test
requirement will revert to quarterly in the months specified above.
Should any test data from this monitoring requirement or tests performed by the North Carolina Division of Water
Quality indicate potential impacts to the receiving stream,this permit may be re-opened and modified to include
alternate monitoring requirements or limits.
NOTE: Failure to achieve test conditions as specified in the cited document, such as minimum control organism
survival, minimum control organism reproduction,and appropriate environmental controls, shall constitute an
invalid test and will require immediate follow-up testing to be completed no later than the last day of the month
following the month of the initial monitoring.

z
IT
I
0
C
m
O
0
D
y
0
O
O
F-
M - D z
z
STATE OF NORTH
3
= H
o
CARD A
Ef`11'IRONMEN'TAL MANAGEMENT';;-':;
DG
r
0
_
3 =
I 'COM1L4$ION/NPDES UNIT `
z m
I a 4617 MAYLSERVICE CENTER ;
n m< z
(7i
21. RALEIGR:NC 27699:1617
ro < N v
J +-, -1 m
= c
SIOTaP1 OF
I CATION INTENT TO ISSUE
0 mD (ti
c
C
- ',`?.. NPDES WAMWATER PERMIT
1010
W
"'•
w On the'basis oitboeough staff teview
-I z
and:appli.
tr4Qfioaof NC C'6tw Statute 141-2 1, Public
!�
t&
I 1~ 42.500-and other lavibd standards and regula-
(toot, the North Varujina Environmental
i Qtlagement Cordon proposes to'isatic;'
y, Nkdonal-Pnllutaot?'IY[rach
w,Elimirwtion S*
Mit'_:VVDFSI wSatifWaterdischarge per d"-
y z
•t}e pe abnfs) "Sted'below effective 45 days
CI
: %in the publish date of this uotice.
H O
ro The'Flaki Pruducti, Inc (501 Merrit 7,
k�.t ^F„y
��jyl l�ayy
� 'Norwalk, CT Igi521hes appgrd for renewal of
NPDH.S- permit NC0085971 for the Maki -
Ya -Product Rernrdh0on .Site In Forsyth Cnunty..
"U permitted facility d1wharges treated
J
y wutewahr to the Rru,by Fork In the Vadkla
`per-D a River Rasta, Currently total nupend-
II t ;lld -solk6 ate water quality limited. This dls.
dwr6N ..lay affect future allucstioas in this par..-
.thlb of the Yadkin Pe,Dee River Beth.
D Z
eye
Kr e..�j
Wtltttn commeq gerdIng the prollosed
'.
D P - O
rn J Z rrt
y
M.
rn0 will be. nhl 30.days -tubarthe pub,
; " t ofth
Z
eya
CIAH Q
.All comments received
1h$t 4aM'are
3 A
O
n considered in the final
2 D <
t
9060he regarding the purposed pcmtir
,D'ireEtor of the NC Division of Water
z r- m ID
A
` �"tp may decide to hold a public meeting for
t7ND\�
ti
*r'opoed permit should the Division [eceivq
<
X
�s/gnificant degree of public imcrest. -
... -
N in
J H H m
0 Q m tl1
Z
n w
v a (�
i.�t;,�,ies of they
^g it and other supporting
m =
0 m
o aw
N C
( [i000pd [a determine ctmdrtino
ptasent ttF the draft permit ate available
—t Z
A (/;
a O
upon
IiGa>s and f3ajrpentof the costs of mproduc-
idaUi"mmn4llts
a
and/or requests for
l r,,, atauorF o41�te NG Division of Water Quay at
` 9Pe aimve addreig, ' lj M& vale(y SfcPb Os+K .
II (9191 733-5Q$3, extpnouro2D. please include
dre NPDES per" tjt number (attached) in "':
afhtnumca[inh,r. lhumSted Iartsotn: may
vlart the D"Inn of Water Qua"ty it 514'1J•
S�Iishury Street, Raleigh, NC 27604-1148
,
w Iho3btW u€8:00'a:m �S:QO ppy �o
Y.. ,.trifnrypa�Ilrr�nrMfild. ' p._,,-:
;lr'eb/w�ry 19.2W4

•
1 'J
•
PUBLIC NOTICE OatiblSTATE OF NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION/NPDES UNIT
1617 MAIL SERVICE CENTER
RALEIGH NC 27689.1617
NOTIFICATION OF INTENT TO ISSUE A
NPDES WASTEWATER PERMIT
On the basis of thorough staff review and application of NC General Stat-
ute 143.21,Public law 92-500 and other lawful standards and regula-
tions.the North Carolina Environmental Management Commission pro-
poses to issue a National Pollutant Discharge Elimination System
(NPDES)wastewater discharge permit to the person(s)listed below ef-
fective 45 days from the publish date of this notice.
Written comments regarding the proposed permit will be accepted until
30 days after the publish date of this notice.All comments received prior
to that date are considered In the final determinations regarding may
u�
pro-
posed permit.The Director of the NC Division of Water QQal
de-
ckle to hold a public meeting for the proposed permit should the Division
receive a significant degree of public interestt.
Copies of the drat permitand other supporting information on file used
to determine conditionsresent in the draft permit are available upon re-
quest and payment of the costs of reproduction.Mail comments and/or
requests for information bove
ressor call M aletmoytSe��NC at 9)733-5083.extensioof Water Duality at the n 520.
Please include the NPDES permit number(attached)in any communica-
tion.Interested persons may also vist the Division of Water Quality at
512 N.Salisbury Street,Raleigh,NC 27904-1148 between the hours of
8:00 a.m.and 5:00 p.m.to review information on file.
The City of Lexington(28 West Cants Street NC 27292)
has applied for renewal of NPDES permit NC0055788 �tyhe�LLexxiinngtton
rges
treated wastewater to the Abbottional WWTP in Davidson.Creek In Yadldn Pee-Dee permitted eRiver Ba-
sin.Currently
mer-
cury,
ammonia nitrogen,total phosphorus,cyanide,mer-
ry, and total residual chlorine are water quality limited.This
discharge may affect future allocations in this portion of the Yadkin Pee-
Dee River Basin.
WiIow Creek Holding.,LLC In High Point,NC has applied for renewal
of NPDES permitC0034452 for its Willow Creek wastewater treatment
plant in Davidson County.This permitted facility dischargesreaMt ted
wastewater to Abbots Creek in the Yadkin-Pee Dee River Bass
Cur-
rently,ammonia nitrogen,BOD,and total residual chlorine are water
quality
the watershed.
Thls
discharge may affect future allocations in this portion
of The Flakt Products,Inc.(501 Pawn 7,Norwalk,CT 18252)has applied
for renewal of NPDES permit NC0085871 for the Flakt Product Remedia-
tion Site in Forsyth Conty.This permitted facility discharges treated
wastewater to the BrushyFork in the Yadkin Pee-Dee River Basin.Cur-
rently total suspended solids are water quality limited.This discharge
may affect future allocations in this portion of the Yadkin Pee-Dee River
Basin.
WSJ:February 21,2004
WINSTON•SALEM JOURNAL PROOF
Customer: NCDENR/DWQ/NPDES Contact: FAX / VALERY Phone: [phone]
Address: 1617 MAIL SERVICE CENTER ATTN: VALERY STEPHENS
RALEIGH NC 276991617
Ad Number: 480349
Insert Dates: 02/21 004
Price: 294.78
Section: CL Class: 99; LEGALS Size: 2 x 51.00
Printed By: KSAPP Date: 02/19/2004 For: 9999
Signature of Approval: Date:
MAR 3 2004

imap://sergei.chernikov%40dwq.denr.ncmail.net @cros.ncmail.net:143...
•
Subject: Draft Permit Reviews(4)
From:John Giorgino<[e-mail]>
Date: Wed, 25 Feb 2004 10:16:04-0500
To: sergei chernikov <[e-mail]>
Sergei,I reviewed the following draft permits:
NC0055786 Lexington Regional WWTP-No Comments
NC0079898 Needmore Road Landfill - No Comments
NC0086487 Albemarle Facility-Section A(2), Chronic Toxicity does not contain the "new" EPA
language. first test of any single quarter results in a failure multiple-concentration testing shall
be performed ,„Please seethe 3rd�aragra_ph of the above 2 facilities. Those are correct.
NC0085871 Flakt Products - Section A(2),Chronic Toxicity does not contain the "new" EPA
language. first test of any single quarter results in a failure multiple-concentration testing shall
be performed Please see the first 2 facilities for the correct language, 3rd paragraph. n,.e_ S. e
-John
John ' _orgino
Envir- - mental Biologist.
North "arolina Division of Water Quality
Aquat Toxicology Unit
Maili: Address:
1621 ' 'C
Rale.i' NC 27699-1621
Offic : 919 733-2136
Fdx: 9 733-9959
Email [e-mail]
Web P e: http://www.esb.enr.state.nc.us
1 of 1 4/14/2004 10:43 AM

NCDENR/DWQ
FACT SHEET FOR NPDES PERMIT DEVELOPMENT
Flakt Products, Inc.
NPDES No. NC0085871
Facility Information
(1.)Facility Name: Flakt Products
(2.)Permitted Flow(MGD): 0.0864 (6.)County: Forsyth
(3.)Facility Class: I (7.) Regional Office: Winston Salem
(4.)Facility Status: Renewal (8.) USGS Topo Quad: C 1 8SW
(New or existing)
(Winston-Salem
East)
(5.)Permit Status: Renewal
(i.e., New, Modification,
or Renewal)
Stream Characteristics
(1.)Receiving Stream: Brushy Fork
(2.)Subbasin: 030704 (8.)Drainage Area(m12): 7.3
(3.)Index No.: 12-94-12-6 (9.)Summer 7Q10(cfs) 2.9
(4.)Stream Classification: C (10.)Winter 7010(cfs): NA
(5.)303(d)Listed: NO (11.)3002(cfs): NA
(6.)305(b)Status: NA (12.)Average Flow(cfs): NA
(7.)Use Support: (13.)1WC(%): 4.5%
Summary
• This is a minor renewal for a solvent-contaminated groundwater remediation system with a design
flow of 0.0864 MGD. The site was previously used for metal fabrication activities with solvent use;
trichloroethene and 1,1,1-trichloroethane were released at some time. The treatment system includes
air stripper, but no GAC.
• Facility discharges to Brushy Fork, which confluences with Salem Creek approximately 1,500-ft
downstream. There is a Brushy Fork listed on 303(d)list for sediment in subbasin 030707,but
nothing listed for this subbasin(030704). Brushy Fork has a 7Q10 flow of 2.9 cfs.
DMR Data and Compliance.
• DMRs have been reviewed for the period January 2000 through December 2003. The facility has been
consistently passing its toxicity limit with one exception. Only one NOV was issued during the
previous permit cycle for toxicity violation in 1999. During the review period only the following
metals were occasionally detected: zinc,copper, lead, manganese,and iron. The maximum
concentration of all detected metals never exceeded standards or action levels. The organic
contaminants were never detected in the samples (below detection levels).

NPDES PERMIT FACT SHEET
Page 2 NPDES No. NC0085871
Proposed Schedule for Permit Issuance
Draft Permit to Public Notice: 2/18/2004 (est.)
Permit Scheduled to Issue: 5/2/2004 (est.)
State Contact
If you have any questions on any of the above information or on the attached permit,
please contact Sergei Chernikov at [phone],extension 594.
Regional Office Comments
Regional Recommendation by:
Signature Date
Reviewed and accepted by:
Regional Supervisor:
Signature Date
NPDES Unit Supervisor:
Signature Date
Page 2
Version:February 4,2004

Whole Effluent Toxicity Testing Self-Monitoring Summary January 15,2004
•
FACILITY REQUIREMENT YEAR JAN FEB MAR APR MAY JUN JUL AUG SEP OCT NOV DEC
First Union Commons chr lim:90!/a 2000 - - - - - - - - - - - -
NC0086886/001 Begin:4/1/2001 Frequency Q Mar Jun Sep Dec + NonComp Single 2001 - - - Fail Pass Fail <45 54.1 Pass - - Pass
County:Mecklenburg Region:MRO Subbasin:CTB34 2002 - - Pass - - NR/Pass - - NR/Fail(Sig) NR/92.5 NR/s100 NR/Pass
PE:0.086 Special 2003 - - NR/Pass NR NR/Pass NR/Pass - - Pass - -
7Q10:0.85vt
IWC(%;100 2004
Flakt Products,Inc. chr lim:4.5% 2000 - - Pass - - Pass - - Pass - - H
NC0085871/001 Begirr.8/1/1999 Frequency Q P/F + Mar loci Sep Dec + NonComp Single 2001 Late - Pass - - NP/Paas - - Pass - - Pass
County:Forsyth Region:WSRO Subbasin:YADO4 2002 - - Pass - - Peas - -
Pass - - Pass
PE: 0.0864 Special 2003 - - Pass - - Pass - - Pass - -
7Q10:2.9 1 W CI°4%'.4.5 2004
Flint Hills Resources,LLP 24hr p/fac lint:90% 2000 Pass - - Pass - - Pass - - NR/Pass - -
NC0076732/001 Begin.10/1/1996 Frequency Q • Jan Apr Jul Oct NonComp Single 2001 Pass - - Pass - - Pass - - Pass - -
County:New Hanover Region:WIRO Subbasin:CPFI7 2002 Pass - - >100 - Pass Pass - - Pass - -
PE: 0.1 Special 2003 Pass - - Pass - - Pass - - Pass -
7Q10:Tidal IWC(%;NA 2004
Forest City WWTP chr lim:18% 9 2000 Pass - - Pass - - Pass - - Pass - -
NC0025984/001 Begin:12/1/1998 Frequency Q P/F + Jan Apr Jul Oct + NonComp Single 2001 Pass - - Fail >35 29.6 Pass - - Pass - -
County:Rutherford Region:ARO Subbasin:13121302 2002 Fail 10.6 27.4,21.2 Pass - - Pass - - Pass - -
PF:4.95 Special 2003 Pass - - Pass,>72 - - Pass - - Pass -
7Q10:34.8 IWC(%'18.0 2004
Forest Clty-Rlverstoue led Park WWTP Acute P/F Lim:90%Fathead 2000 - - - - - - - - - - - -
NC0087084/001 Begin:1/1/2004 Frequency Q P/F + Mar Jun Sep Dec + NonComp Single 2001 - - - - - - - - - - - -
County:Rutherford Region:ARO Subbasin:BRD02 2002 - - N - - N - - N - - N
PF:0.1 Special 2003 - - N - - N - - H - -
7Q10: 195 IWC(%;0.08 2004
Fort Bragg WWTP/001 chr lim:26% 2000 Pass - - Pass - - Pass - - Pass - -
NC0003964/001 Begin:8/1/2001 Frequency Q Jan Apr Jul Oct + NonComp Single 2001 Pass - - NR - Pass Pass - - Pass - -
County:Cumberland Region:FRO Subbasin:CPFI4 2002 Pass - - Pass - - Pass - - Pass - -
P E:8.0 Special 2003 Pass - - Pass - - Pass - - Pass -
7Q10:35.8 IWC(%;26 2004
Fortron Industries/001 chr lin:0.9% 2000 - Pass - - Pass - - Pass - - Pass -
NC0082295/001 Begin-8/1/1997 Frequency Q P/F + Feb May Aug Nov + NonComp Single 2001 - Pass - - Pass - - Pass - - Pass -
County:New Hanover Region:WIRO Subbasin:CPFI 7 2002 - Pass - - Pass - - Pass - - Pass -
PF:0.245 Special 2003 - Pass - - Pass - - Pass - - Pass
7Q10:910 IWC)%;1.16 2004
Franklin Co.WASA chr lim:49%(1.0 MGD),74%(3.0 MGD) 2000 Pass - - NR/Pass - - Pass - - Pass - -
NC0069311/001 Begin:1/1/2001 Frequency Q Jan Apr Jul Oct + NonComp Single 2001 Pass - - Pass - - Pass - - Pass - -
County:Franklin Region:RRO Subbasin:TAR01 2002 Pass - - Fail 34.6 62.6 Fail 62.6 62.6 62.6 - -
P E: 1.0 Special 2003 Pass,>100 - - Pass - - Pass - - Pass -
7Q10: 1.6 IWC(%;49 2004
Franklin WWTP chr lim:1.6% 2000 - - Pass - - Pass - - Pass - - Pass
NC0021547/001 Begin:8/1/2003 Frequency Q P/F + Mar Jun Sep Dec + NonComp Single 2001 - - Pass - - Pass - - NR/Pass - - Pass
County:Macon Region:ARO Subbasin:LTN01 2002 - - late Pass - Pass - - Pass - - Pass
PF: 1.65 Special 2003 _ _ Pass - - Pass - - Pass - -
7Q10: 157 IWC(%;1.6 2004
Fequsy-Varies WWTP chr lim:90% 2000 - - Pass - - Pass - - Pass - - Pass
NC0066516/00I Begin:11/1/2003 Frequency Q Mar Jun Sep Dec + NonComp Single 2001 - - Pass - - Pass - - Pass - - Pass
County:Wake Region:RRO Subbasin:NEU03 2002 - - Pass - - Pass - - Pass - - Pass
PE: 0.5 Special 2003 - - Pass - - Pass - - Pass - -
7Q10:0.0 IWC(%;100 2004
Fuqusy-Vnrins/Kenneth Cr WWTP chr lim:90% 9 2000 - - Pass - - Pass - - Pass - - Pass
NC0028118/001 Begin:7/1/2002 Frequency Q Mar Jun Sep Dec + NonComp Single 2001 - - Pass - - Pass - - Pass - - Pass
County:Wake Region:RRO Subbasin:CPF07 2002 - - Pass - - Pass - - Pass - - Pass
PF: 1.2 Special 2003 - - Pass - - Pass - - Pass - -
7Q10:0.0 IWC(%;100 2004
9 Pre 2000 Data Available
LEGEND:
PERM=Permit Requirement LET=Administrative Letter-Target Frequency=Monitoring frequency:Q-Quarterly;M-Monthly;BM-Bimonthly;SA-Semiannually;A-Annually;OWD-Only when discharging;D-Discontinued monitoring requirement
Begin=First month required 7Q10=Receiving stream low flow criterion(cfs +=quarterly monitoring increases to monthly upon failure or N Months that testing must occur-ex.Jan,Apr,Jul,Oct NonComp=Current Compliance Requirement
PF=Permitted flow(MOD) IWC%=Instream waste concentrati P/F=Pass/Fail test AC=Acute CHR=Chronic
Data Notation:1-Fathead Minnow;•-Ceriodaphnia sp.;my•Mysid shrimp;ChV-Chronic value;P-Mortality of stated percentage at highest concentration;at-Performed by DWQ Aquatic Ton Unit;hi-Bad test
Reporting Notation:---=Data not required;NR-Not reportc Facility Activity Status:I-Inactive,N-Newly Issucd(To construct);H-Active but not discharging;t-More data available for month in question;• =ORC signature needed
20

MACTEC
November 7, 2003
NC DENR
Attn: Valery Stephens
Water Quality Section
Point Source Branch
1617 Mail Service Center
Raleigh, NC 27699-1617
Re: NPDES Permit Renewal Application
NPDES Permit No. NC0085871
Flakt Products Remediation Site
Forsyth County
Enclosed please find an application for renewal of NPDES permit #NC0085871 using Short
Form C-GW. There have been no changes at the facility since the issuance of the last permit.
Should there be any questions regarding this submission please direct them to my attention at
[phone] or via email at [e-mail]
Sincerely,
MACTEC Engineering and Consulting
Ri y A. yan,P.E.
Senior P ' cipal Project Manager
[537]
attachment
MACTEC Engineering and Consulting,Inc.
1431 Centerpoint Boulevard
Suite 150•Knoxville,TN 37932-1962
865-531-1922•Fax:[phone]

DATE, 09/16/031 CHECKED BY: I DATE:

Summary of Recent Effluent Reporting Results
Flakt Products, Inc.
NPDES Permit NC0085871
Winston-Salem, NC
Parameter Code units Results
Jun-03 Apr-03 Dec-02 Sep-02 Jun-02
TSS 00530 mg/I 1.5 1.1 BOL 1.1 1.3
Benzene 34235 ug/I BQL BQL BQL BQL BQL
Chloroform 34316 ug/I BQL BOL BOL BOL BOL
Carbon Tetrachloride 31202 ug/1 BOL BQL BQL BOL BQL
1,1-DCE 34501 ug/I BQL BQL 9 BQL 2
1,2-DCA 32103 ug/I BQL BOL BOL BOL BQL
Methylene Chloride 34423 ug/I BQL BQL BQL BOL BQL
TCE 78391 ug/I BQL BQL 6 BQL 1
PCE 78389 ug/I BQL BQL BQL BQL BOL_
1,1,2,2-TCA 81549 ug/I BQL BOL BQL BQL BQL_ _
1,1,2-TCA 34511 ug/I BOL BQL BQL BQL BQL
As 01002 mg/I BQL BQL BQL BQL BQL
Cu 01042 mg/I 0.0385 0.0185 0.802 BOL 0.0115
Fe 01045 mg/I BQL 0.122 BQL BOL BOL
Pb 01051 mg/I BOL BOL 0.67 BQL BQL
Mn 01055 mg/I 0.29 0.165 0.132 0.198 0.235
Zn 01092 mg/I 0.031 0.0232 0.0918 BQL BOL
Note:
The above table represents a summary of analytical results as submitted in the last 5 DMR reports.
* Shaded Cells indicate the maximum concentration detected from the reporting period.
BOL= Below Quantitation Limit

NPDES PERMIT APPLICATION - SHORT FORM C-GW
To be filed by persons engaged in groundwater remediation projects
N. C. Department of Environment and Natural Resources _ � \/ r
Division of Water Quality / NPDES Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
NOV 1 0 2003
NPDES Permit NCOO 85871
Please print or type
1. Applicant and facility producing discharge
A. Name Flakt Products, Inc.
B. Mailing address of applicant:
1. Street address 501 Merrit 7
2. City Norwalk 3. County Fairfield
4. State CT 5. Zip Code 06851
Telephone Number ( 203 ) 750-2211
Fax Number ( 203 ) 750-2268
e-mail address: [e-mail]
C. Location of facility:
1. Street 200 Lowery Street
2. City Winston-Salem 3. County Forsyth
4. State NC 5. Zip Code 27101
Telephone Number ( ) None
Fax Number ( ) None
2. Standard Industrial Classification (SIC) code(s) (if known):
3. This application is for a: n New Permit n Permit Renewal l l Permit Modification
4. Product(s) recovered (circle all that apply): Gasoline Diesel fuel Solvents
Other(describe)
5. (a) Check here if discharge occurs all year X , or
(b) Circle the month(s) in which discharge occurs: January February March April
May June July August September October November December
(c) Days per week discharge occurs: Continuous
6. Volume of wastewater discharged to receiving stream(s): 86,400 GPD*
*Gallons per operating day
7. Check here if wastewater is discharged directly to the receiving stream(s) X
If not, state the specific discharge location:
Mark the path taken by the wastewater to the receiving stream(s) on the site map. If a storm sewer is the only viable
means of discharge,trace the route of the storm sewer to its discharge point(s).
Short Form C-GW Version 9-99

I
NPDES PERMIT APPLICATION - SHORT FORM C-GW
To be filed by persons engaged in groundwater remediation projects
8. Number of separate discharge points: 1
NOTE: If the facility has separate discharge points (outfalls), include a schematic diagram of
wastewater flow at the facility.
9. Name of receiving water(s): Brushy Fork
This application package must include the items listed below. This application will be returned if the
required items are not included.
❑ A USGS topographical map(or copy of the relevant portion)which shows all outfalls
O A report of alternatives to surface water discharge as outlined by the Division's"Guidance for Evaluation of Wastewater Disposal
Alternatives"(required by 15A NCAC 2H.0105(c)) ( Submittal with Initial Permit Application dated 6/6/96.1
® A summary of the most recent analytical results containing the maximum values for each chemical detected
Applications for new (un-permitted) discharges must also include the items listed below. This
application will be returned if the required items are not included.
❑ An engineering proposal describing the remediation project in detail(required by 15A NCAC 2H.0105(c))
❑ If the treatment system will discharge to a storm sewer,attach written approval from the municipality responsible for the sewer.
❑ A list of any chemicals found in detectable amounts at the site,with the maximum observed concentration reported for each chemical
(the most recent sample must be collected less than one year prior to the date of this application)
o A summary of analytical results containing the maximum values for each chemical detected
o The removal efficiency of each compound detected(if known)
For fuel remediation projects,analyses for volatile organic compounds (VOCs)should be performed. Analyses for any fuel additives likely
to be present at the site should also be performed. At minimum,analyses should be performed for the following compounds:
benzene* toluene* ethylbenzene* xylene* lead methyl tert-butylether(MTBE) dibromoethane(EDB)
1,2-dichloroethane isopropyl ether napthalene phenol
(*an EPA-approved method capable of detection levels to 1 ppb should be used to detect these compounds).
For solvents or unidentified projects,an EPA Method 624/625 analysis should be performed. The data submitted with this application
should include the ten largest peaks not identified as targeted compounds and not present in the procedural blank. These peaks should be
identified and approximately quantitated(as per the same restrictions found on the NC DENR/DWQ Annual Pollutant Analysis
Monitoring(APAM)Requirement—Reporting Form A).
If metals or pesticides are suspected to be present,these compounds should be analyzed to the same detection level as presented in the
NC APAM.
I certify that I am familiar with the information contained in the application and that to the best of
my knowledge and belief such information is true, complete, and accurate.
Andy Karl bergs Director, Real Estate
Printed name of Person Signing Title
1U— —
Signature of Applicant Date
North Carolina General Statute 143-215.6(b)(2)provides that: Any person who knowingly makes any false statement representation,or certification in
any application,record,report,plan,or other document files or required to be maintained under Article 21 or regulations of the Environmental Management
Commission implementing that Article,or who falsifies,tampers with,or knowingly renders inaccurate any recording or monitoring device or method
required to be operated or maintained under Article 21 or regulations of the Environmental Management Commission implementing that Article,shall be
guilty of a misdemeanor punishable by a fine not to exceed$10,000,or by imprisonment not to exceed six months,or by both.
(18 U.S.C.Section 1001 provides a punishment by a fine of not more than$10,000 or imprisonment for not more than 5 years,or both,for a similar
offense.)
Short Form C-GW Version 9-99