WQ0000838_Staff Report_20230124

State of North Carolina
Division of Water Resources

Water Quality Regional Operations Section
Staff Report

FORM: WQROSSR 04-14 Page 1 of 5

To: NPDES Unit Non-Discharge Unit Application No.: WQ0000838

Attn: Zachary Mega Facility name: GFI Class B Residuals Program

From: J. Chris Smith
Raleigh Regional Office

Note: This form has been adapted from the non-discharge facility staff report to document the review of both non-
discharge and NPDES permit applications and/or renewals. Please complete all sections as they are applicable.

I. GENERAL AND SITE VISIT INFORMATION
1. Was a site visit conducted? Yes or No
a. Date of site visit:
b. Site visit conducted by:
c. Inspection report attached? Yes or No
d. Person contacted:
e. Driving directions:
2. Discharge Point(s):
Latitude: Longitude:
Latitude: Longitude:
3. Receiving stream or affected surface waters:
Classification:
River Basin and Subbasin No.
Describe receiving stream features and pertinent downstream uses:
II. PROPOSED FACILITIES: NEW APPLICATIONS
1. Facility Classification: (Please attach completed rating sheet to be attached to issued permit)
Proposed flow:
Current permitted flow:
2. Are the new treatment facilities adequate for the type of waste and disposal system? Yes or No
If no, explain:
3. Are site conditions (soils, depth to water table, etc) consistent with the submitted reports? Yes No N/A
If no, please explain:
4. Do the plans and site map represent the actual site (property lines, wells, etc.)? Yes No N/A
If no, please explain:
5. Is the proposed residuals management plan adequate? Yes No N/A
If no, please explain:
DocuSign Envelope ID: E6AEA42F-E2FC-4139-A287-473DE422F8B6
FORM: WQROSSR 04-14 Page 2 of 5
6. Are the proposed application rates (e.g., hydraulic, nutrient) acceptable? Yes No N/A
If no, please explain:
7. Are there any setback conflicts for proposed treatment, storage and disposal sites? Yes or No
If yes, attach a map showing conflict areas.
8. Is the proposed or existing groundwater monitoring program adequate? Yes No N/A
If no, explain and recommend any changes to the groundwater monitoring program:
9. For residuals, will seasonal or other restrictions be required? Yes No N/A
If yes, attach list of sites with restrictions (Certification B)
Describe the residuals handling and utilization scheme:
10. Possible toxic impacts to surface waters:
11. Pretreatment Program (POTWs only):

III. EXISTING FACILITIES: MODIFICATION AND RENEWAL APPLICATIONS
1. Are there appropriately certified Operators in Charge (ORCs) for the facility? Yes No N/A
ORC: Bryan A. Smith Certificate #: 13265 Backup ORC: Jason Smith Certificate #: 13266
2. Are the design, maintenance and operation of the treatment facilities adequate for the type of waste and disposal
system? Yes or No
If no, please explain:
Description of existing facilities:
Proposed flow:
Current permitted flow:
Explain anything observed during the site visit that needs to be addressed by the permit, or that may be important
for the permit writer to know (i.e., equipment condition, function, maintenance, a change in facility ownership,
etc.)
3. Are the site conditions (e.g., soils, topography, depth to water table, etc) maintained appropriately and adequately
assimilating the waste? Yes or No
If no, please explain:
4. Has the site changed in any way that may affect the permit (e.g., drainage added, new wells inside the compliance
boundary, new development, etc.)? Yes or No
If yes, please explain:
5. Is the residuals management plan adequate? Yes or No
If no, please explain:
6. Are the existing application rates (e.g., hydraulic, nutrient) still acceptable? Yes or No
If no, please explain:
7. Is the existing groundwater monitoring program adequate? Yes No N/A
If no, explain and recommend any changes to the groundwater monitoring program:
8. Are there any setback conflicts for existing treatment, storage and disposal sites? Yes or No
If yes, attach a map showing conflict areas.
9. Is the description of the facilities as written in the existing permit correct? Yes or No
If no, please explain:
10. Were monitoring wells properly constructed and located? Yes No N/A
If no, please explain:

DocuSign Envelope ID: E6AEA42F-E2FC-4139-A287-473DE422F8B6
FORM: WQROSSR 04-14 Page 3 of 5
11. Are the monitoring well coordinates correct in BIMS? Yes No N/A
If no, please complete the following (expand table if necessary):
Monitoring Well Latitude Longitude
○ ′ ″ - ○ ′ ″
○ ′ ″ - ○ ′ ″
○ ′ ″ - ○ ′ ″
○ ′ ″ - ○ ′ ″
○ ′ ″ - ○ ′ ″
12. Has a review of all self-monitoring data been conducted (e.g., DMR, NDMR, NDAR, GW)? Yes or No
Please summarize any findings resulting from this review:
Provide input to help the permit writer evaluate any requests for reduced monitoring, if applicable.
13. Are there any permit changes needed in order to address ongoing BIMS violations? Yes or No
If yes, please explain:
14. Check all that apply:
No compliance issues Current enforcement action(s) Currently under JOC
Notice(s) of violation Currently under SOC Currently under moratorium
Please explain and attach any documents that may help clarify answer/comments (i.e., NOV, NOD, etc.)
If the facility has had compliance problems during the permit cycle, please explain the status. Has the RO been
working with the Permittee? Is a solution underway or in place?
Have all compliance dates/conditions in the existing permit been satisfied? Yes No N/A
If no, please explain:
15. Are there any issues related to compliance/enforcement that should be resolved before issuing this permit?
Yes No N/A
If yes, please explain:
16. Possible toxic impacts to surface waters:
17. Pretreatment Program (POTWs only):

DocuSign Envelope ID: E6AEA42F-E2FC-4139-A287-473DE422F8B6
FORM: WQROSSR 04-14 Page 4 of 5
IV. REGIONAL OFFICE RECOMMENDATIONS
1. Do you foresee any problems with issuance/renewal of this permit? Yes or No
If yes, please explain: See Additional Regional Staff Review Items
2. List any items that you would like the NPDES Unit or Non-Discharge Unit Central Office to obtain through an
additional information request:
Item Reason

3. List specific permit conditions recommended to be removed from the permit when issued:
Condition Reason

4. List specific special conditions or compliance schedules recommended to be included in the permit when issued:
Condition Reason

5. Recommendation: Hold, pending receipt and review of additional information by regional office
Hold, pending review of draft permit by regional office
Issue upon receipt of needed additional information
Issue
Deny (Please state reasons: )
6. Signature of report preparer:
Signature of regional supervisor:
Date:

DocuSign Envelope ID: E6AEA42F-E2FC-4139-A287-473DE422F8B6
1/24/2023
FORM: WQROSSR 04-14 Page 5 of 5

V. ADDITIONAL REGIONAL STAFF REVIEW ITEMS
The application appears to be mostly complete. The lab analyses results for the new residual source appear to be
within acceptable limits for all regulated materials for this type of permit. Based upon the reported PAN contents of
the residual sources and the proposed agricultural crop needs the facility has adequate acreage for land application of
the proposed new dry tonnage limit.
Note: the application states that LASCA forms were provided for all fields, but none were included. LASCA forms
are required for new fields and fields modified by the application. None of the fields in this application are new or
modified, so these forms are not required.
RRO staff noted the following information missing from the application:
• No CPLR values for field GFI-7A
• Field JTB-7 is not labeled on the map provided (appears to be mislabeled as Field 2)
• Field JC-6 is not listed on the LOA (probably belongs on the same LOA as Field JC-5)
DocuSign Envelope ID: E6AEA42F-E2FC-4139-A287-473DE422F8B6