NC0023191_Permit Issuance_20040806

to r. Lesley, uuven ui
State of North Carolina
William G. Ross, Jr., Secretary
Department of Environment and Natural Resources
o AF�pG
q
r_
iO -q Alan W. Klimek, P.E., Director
Division of Water Qualms
August 6, 2004
Mr. David Millsaps
Seven Cedars Mobile Home Park
1124 Radio Road
Statesville, NC 28677
Subject: Issuance of NPDES Permit
NCO023191
Seven Cedars MHP W WTP
Iredell County
Dear Mr. Millsaps:
Division personnel have reviewed and approved your application for renewal of the subject
permit. Accordingly, we are forwarding the attached NPDES discharge permit. This permit is issued
pursuant to the requirements of North Carolina General Statute 143-215.1 and the Memorandum of
Agreement between North Carolina and the U.S. Environmental Protection Agency dated May 9,1994 (or
as subsequently amended).
This final permit includes no changes from the draft permit sent to you on June 9, 2004.
This permit includes a TRC limit that will take effect on March 1, 20G6. If you wish to install
dechlorinafion equipment, the Division has promulgated a simplified approval process for such projects.
Guidance for approval of dechlorination projects is attached.
If any parts, measurement frequencies or sampling requirements contained in this permit are
unacceptable to you, you have the right to an adjudicatory hearing upon written request within thirty
(30) days following receipt of this letter. This request must be in the form of a written petition,
conforming to Chapter 150B of the North Carolina General Statutes, and filed with the Office of
Administrative Hearings (6714 Mail Service Center, Raleigh, North Carolina 27699-6714). Unless such
demand is made, this decision shall be final and binding.
Please note that this permit is not transferable except after notice to the Division. The Division
may require modification or revocation and reissuance of the permit. This permit does not affect the
legal requirements to obtain other permits which may be required by the Division of Water Quality or
permits required by the Division of Land Resources, the Coastal Area Management Act or any other
Federal or Local governmental permit that may be required. If you have any questions concerning this
permit, please contact Toya Fields at telephone number [phone], extension 551.
Sincerely,
ORIGINAL SIGNED BY
Tom Belnick
Alan W. Klimek, P.E.
cc: Central Files
Mooresville Regional Office/ Water Quality Section
NPDES Unit '
North Carolina Division of Water Quality (919) 733-50a3
1617 Mail Service Center FAX [phone]
Raleigh, North Carolina 27699-1617 on the Internet at http://h2o.enr.state.nc.us/

Permit NCO023191
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DMSION OF WATER QUALITY
_W22311
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
David L. Millsaps
is hereby authorized to discharge wastewater from a facility located at the
Seven Cedars Mobile Home Park
Village Drive
Statesville
Iredell County
to receiving waters designated as Third Creek in the Yadkin -Pee Dee River Basin in
accordance with effluent limitations, monitoring requirements, and other conditions set
forth in Parts I, II, III, and IV hereof.
The permit shall become effective September 1, 2004.
This permit and the authorization to discharge shall expire at midnight on March 31, 2009.
Signed this day August 6, 2004.
ORIGINAL SIGNED BY
Tom Belnick
Alan W. Klimek, 1 .E., Director
Division of Water Quality
By Authority of the Environmental Management Commission

Permit NCO023191
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility, whether for operation or discharge are hereby revoked. As of this
permit issuance, any previously issued permit bearing this number is no longer effective. Therefore, the exclusive
authority to operate and discharge from this facility arises under the pertnit conditions, requirements, terms, and
provisions included herein.
David Millsaps is hereby authorized to:
1. Continue to operate an existing 0.010 MGD wastewater treatment plant
consisting of the following components:
• Bar screen
• Aeration basin
• Clarifier
V-notch weir
• Gravel filtration tank
• Chlorine contact tank with tablet chlorination
Three (3) aerated sludge holding tanks
The facility is located at Seven Cedars Mobile Home Park, Village Drive,
Statesville, Iredell County, and
2. Discharge from said treatment works at the location specified on the attached
map into Third Creek, which is classified as C waters in the Yadkin -Pee Dee
River Basin.
v, d 'J V. 3' . , ,, ,

H
Discharge location
10
am
R 4
-NI)
. /,,, I /
I
M-1
Facility
F
Seven Cedars MHP - NCO023191 Location
USGS Quad Name: Shepherds Lat.: 35*43'55"
Receiving Stream: Third Creek Long.: 80*48'05"
Stream Class: C
: N�ortjj Not to SCALE
Subbasin: Yadkin -Pee Dee - 030706
r\

Permit NCO023191
A.(1) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
During the period beginning on the effective date of the permit and lasting until expiration, the
Permittee is authorized to discharge from outfall serial number 001. Such discharges shall be
limited and monitored by the Permittee as specified below:
EFFLUENT
CHARACTERISTICS
LIMITS
MONITORING REQUIREMENTS
Monthly
Average
Weekly
Average
Daily
Maximum
Measurement
Frequency
Sample
Type
Sample
Location'
Flow
0.010 MGD
Weekly
Instantaneous
I or E
BOD, 5 day, 20°C
30.0 mg/L
45.0 mg/L
Weekly
Grab
E
Total Suspended Solids
30.0 mg/L
45.0 mg/L
Weekly
Grab
E
NH3 as N
2 / Month
Grab
E
Total Residual Chlorine'
28.0 µg/L
Weekly
Grab
E
Temperature
Weekly
Grab
E
PH
Between 6 and 9 s.u.
Weekly
Grab
E
Total Nitrogen
Quarterly
Grab
E
Total Phosphorus
Quarterly
Grab
E
Notes:
1. Sample locations: I - Influent, E - Effluent.
2. TRC limit shall take effect March 1, 2006. Limit and monitoring requirements only apply if
chlorine is used for disinfection.
There shall be no discharge of floating solids or foam visible in other than trace amounts.

Published at the Crossroads of North Carolina where I-40 and I-77 Interchange
STATESVILLE RECORD & LANDMARK
Established in 1874 A MEDIA GENERAL NEWSPAPER
P.O. BOX 1071/PHONE: [phone]/STATESVILLE, NORTH CAROLINA 28687
June 30, 2004
Dear Advertiser,
Here are your tearsheets for ads that ran in the Statesville Record & Landmark and/or the
Mooresville Tribune. Your invoice will come from a different publication. Thank you
for advertising in our papers. Buc Nonce
Sincerely,
Pamela Waddell
Business Department
STATE O
NORTHNMENTAL
LINA
ENVIRONMENTAL .
MANAGEMENT
COMMISSIONS UNIT
1617 MAIL SERVICE
CENTER
NOTIFICATION
NC2 FINTEN
699-1617
NOTIFICATION OF INTENT
TO ISSUE A NPDES
WASTEWATER PERMIT
the basis of thorough sta
' SW and other loxhil
cs and reguWtions, the
Carolina Environmental
.mein Commission pro
to issue a National Poll
Discharge Elviirre5on
(NPDE6) waslewata
le PeonT to the per,
bled below effective 45
om the publish date of
canments regarding
need permit will be coo
until 30 days after the
date of this notice. All
is received prior to
e are considered in the
the proposed permit. The At
mortar of the NC Divisionof
Water Oualf may decide to
hold a public meeting for pro-
posed permft should the Dlvl-
Son receive a signikcant de
gree of public imemi
Copies of the draft and other
supporting information on fie
used to detennirm conditions
Present in the draft por it are
available Was request amt
payment of the costs of ral
dlr.4on. Mail comments an-
Nor r Weds for information to
the NC Division of water
Oualry at the above address
a cap ms. Cari Bryant at
919-733-5083, id 520. Please
Include the NPDES perm
number (aaaztwd) in any corn-
municakin. Interested per
Sons may also visit the Divi-
sion of Water Ouadty at 612 N.
Sabbury Street Palepgh, NC
276D4-1145 between the
hays of 8:00am and 5'DOpm
to review information on file.
Cotptly. This permdted facility
drscHwrges 010 MOO of treat
ad wastewater to Third Creek
in the YadrJo-Pee River Basin.
Currently DOD and total rei
sidual chlorine are water qualL
ty funded. This dscharge may
affect future alloci= in dis
portion of the YaduoPe s Dee
IlC0037371 for the Norm Irs-
del High School WWTP in Ire
del County. This pennided is.
obey discharges .0125 MOD of
healed wastewater to Palen
son Creek in the Yadkin Pee
Dee River Basin. Currently
SOD, lecal'coliform and total
residual are water quality
dm4ed. This discharge may
alert future allocations in this
potion of ha Yates Pee Dee
River Basin
,done I t
David L MHlsaps 11124 Radio
Road, Statesville, NC 286771
has applied for renewal of
NPDES permit NC0023191 for
the Seven Cedars Mobile
Home Pad WWTP-m Iredeft i

L J U N 2 1 2004
`---- —
Q=iii - WATER QUALITY
PUliiT SOURCE :3RANCH
i. �`{.�-:•Yi�i��iY'.:riM.Su'yY+.YlY$,.eS�wW1Jr+^i'DF—tlWyy,�,�,rs'
-fr-
NORTH CAROLINA
IREDELL COUNTY
AFFIDAVIT OF PUBLICATION
Before the undersigned, a Notary Public of said
County and State, duly commissioned, qualified,
and authorized by law to administer oaths, per-
sonally appeared Kimberly P. ownbey who
being first duly sworn, deposes and says: that
she is an employee authorized to make this
statement by Media General Newspapers, Inc.
engaged in the publication of a newspaper
known as the Statesville Record & Landmark
published, issued, and entered as second class
mail in the city of Statesville in said County adn
State, that she is authorized to make this affidavit
and sworn statement; that the notice or other
legal advertisement, a true copy of which is
attached hereto, was published in the Statesville
Record & Landmark on the following dates:
and that the said newspaper in which such
notice, paper, document, or legal advertisement
was published was at the time of each and every
such publication, a newspaper meeting all of the
requirements and qualifications of Section 1-597
of the General Statues of North Carolina and was
a qualified newspaper within the meaning of
Section 1-597 of the Greater Statues of North
Carolina.
This _)�]— day ­S-LOAO , 20',.,�A
\ . NC . j� _�
I((Sig (Signature o rson ma ing afficlSJjt)
Sworn to and subscribed before me, this I—Z
day of 20
� Q
Notary ublic
Commission expires:

SOC PRIORITY PROJECT: NO
To: Permits and Engineering Unit
Water Quality Section
Attention: Charles Weaver
Date: March 24, 2004
NPDES STAFF REPORT AND RECOMMENDATIONS
County: Iredell
NPDES Permit No.: NCO023191
MRO No.: 04-21
PART I - GENERAL INFORMATION
1. Facility and address: Seven Cedars MHP WWTP
Village Drive
Statesville, NC 28677
2. Date of investigation: March 19, 2004
3. Report prepared by: B. Dee Browder, Environ. Engr. I
4. Person contacted and telephone number: David Millsaps, [phone]
3 0 20!'4
5. Directions to site: From the junction of NC Hwy. 70 and Bethesda Road east of
the City of Statesville, travel south on Bethesda Road approximately 2.3 miles and
turn left onto Village Drive. The WWTP is located at the end of this road.
6. Discharge point(s), List for all discharge points: -
Latitude: 356 43' 55"
Longitude: 80° 48' 05"
Attach a USGS Map Extract and indicate treatment plant site and discharge point
on map. N/A
USGS Quad No.: E 15 NE
7. Site size and expansion area consistent with application: Yes.
8. Topography (relationship to flood plain included): The site topography is hilly, 5-
15% slopes. The WWTP site is not located in a flood plain. The outfall line is
located in a flood plain extending approximately 300 yards from the plant to the
discharge point.

Page Two
9. Location of nearest dwelling: The nearest dwelling is approximately 300 feet from
the WWTP site.
10. Receiving stream or affected surface waters: Third Creek
a. Classification: C
b. River Basin and Subbasin No.: Yadkin 03-07-06
C. Describe receiving stream features and pertinent downstream uses: The
receiving steam is approximately 30 feet wide and had good flow on the
day of the investigation. General Class C uses downstream
PART H - DESCRIPTION OF DISCHARGE AND TREATMENT WORKS
a. Volume of wastewater: 0.025 MGD (Design Capacity)
b. What is the current permitted capacity: 0.025 MGD
C. Actual treatment capacity of current facility (current design capacity):0.025
MGD
d. Date(s) and construction activities allowed by previous ATCs issued in the
previous two years: N/A
e. Description of existing or substantially constructed WWI' facilities: The
facility consists of a bar screen, aeration basin (diffused air), clarifier, V-
notch weir, gravel filtration tank, chlorine contact tank with tablet
chlorination, and three non -aerated sludge holding tanks.
Description of proposed WWT facilities: N/A
g. Possible toxic impacts to surface waters: Chlorine is added to the waste
stream
h. Pretreatment program (POTWs only): Not needed.
2. Residual handling and utilization/disposal scheme: Materials are removed by
Massey Septic Company and transported to the City of Salisbury WWTP.
a. If residuals are being land applied specify DEM Permit No. N/A.
Residuals contractor: N/A
Telephone No. ( )N/A
b. Residuals stabilization: PSRP PFRP
d. Landfill: N/A

Page Three
3. Treatment plant classification: Class II
4. SIC Code(s): 6515 Wastewater Code(s): 08
3. MTU Code(s): 02002
PART III - OTHER PERTINENT INFORMATION
Is this facility being constructed with construction grant funds or are any public
monies involved (municipals only)? No
2. Special monitoring or limitations (including toxicity) requests: None at this time.
3. Important SOC/JOC or compliance schedule dates: N/A
Submission of plans and specifications
Begin construction
Complete construction
4. Alternative analysis evaluation
a. Spray irrigation: N/A
b. Connect to regional sewer system: N/A
C. Subsurface: N/A
d. Other disposal options: N/A
PART IV - EVALUATION AND RECOMMENDATIONS
The pennittee is applying for renewal of the permit to discharge wastewater. It is
recommended that the permit be renewed as requested. Some repairs are being made to
the concrete cap on the brick wall surrounding the aeration basin. Also, some repairs
were being made to the distribution box containing the chlorine contact chamber.
Signature of Report Preparer Dab
1 �
Water Quality Regioyk Supervisor Date
h:Wddn97edv

FACT SHEET FOR EXPEDITED RENEWAL
Permit Number
C;) -5
Facility Name
Se e r-, /'11+2
Reviewer
J'o 1'n
Basin/Sub-basin
YhA in-. - 03-0-O
Receiving Stream
h ii-d
Stream Classification in permit
G
Stream Classification in BIMS
Is the stream impaired (listed on 303(d))?
N_'V
Is stream monitoring required?
No
Do they need NH3 limit(s)?
NO
Do they need TRC limit(s)?
65
Do they have whole -effluent toxicity testing?
p
Are there special conditions?
p
Any obvious compliance concerns?
jV 0
Existing Expiration Date
3f __TLtL'( O
Proposed Expiration Date
#-
Miscellaneous Comments:
If expedited, is this a simpler permit or a more difficult one?

David Millsaps
1124 Radio Road
Statesville, N. C. 28677
January 23, 2004
E C E U �.
,w80W
6EgF4Q,WATER QUALITY
p(3MMZOQURCE BRANCH
North Carolina Department of Environment and Natural Resources,
Division of Water Quality
Alan W. Klimek, P. El. Director
Division of Water Quality
Attention: Charles H. Weaver, Jr. NPDES Unit
Subject: Request for Permit Renewal
Seven Cedars Mobile Home Park Waste Water Treatment Plant (WWTP)
Permit No. NCO023191 Iredell County hereby request renewal of Permit (NPDES).
There have been no changes to the WWTP.
Enclosed you will find a map of discharge locations.
Thank you for your attention to this matter.
David Millsaps

NPDES APPLICATION FOR PERMIT RENEWAL- SHORT FORM D
To be filed only by privately -owned dischargers of 100% domestic wastewater (<1 MGD flow)
N. C. Department of Environment and Natural Resources
Division of Water Quality / NPDES Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
http://h2o.enr.state.nc.us/NPDES/
North Carolina NPDES Permit Number I NC00 23191
Please print or type
1. Contact Information:
Facility Name
Seven Cedars Mobile Home Park
Owner Name
David Millsaps
Street Address
1124 Radio Road
City
Statesville
State / Zip Code
North Carolina, 28677
Telephone Number
704-873-1331
Fax Number
704-873-1331
e-mail Address
dmilsaosabellsouth.net
Operator Name
David Millsaps
Street Address
1124 Radio Rd
City
Statesville
State / Zip Code
NC, 28677
County
Iredell
Telephone Number
704-873-1331
2. Location of facility producing discharge:
Check here if same as above ❑
Facility Name (If different from above(
Street Address or State Road
City
State / Zip Code
County
3. Reason for application:
Expansion/Modification *
Seven Cedars Waste Water Treatment Plant
Village Drive
Statesville
North Carolina, 28677
Iredell
Existing Unpermitted Discharge
Renewal X New Facility
* Please provide a description of the expansion/modification:
Page 1 of 3 Version 12102

NPDES APPLICATION FOR PERMIT RENEWAL- SHORT FORM D
To be filed only by privately -owned dischargers of 100% domestic wastewater (< 1 MGD flow)
4. Description of the existing treatment facilities (fist all installed components with
capacities}
It is a 0.010 MGD Waste Water Treatment Plant consisting of bar screen, aeration basin with
diffused air, clarifier with sludge return lines, V-notch Weir, gravel filtration tanks, and aerated
sludge holding tanks. The sludge tanks consist of four tanks: two 1000 gallon tanks and two
2000 tanks. Sigmon Environmental INC. [phone] and Massey Septic Tank Co., INC.
[phone] remove our sludge from plant.
S. Description of wastewater (check all that applyr
'Throe of Facility Generating Wastewater
Industrial Number of Employees
Commercial Number of Employees
Residential —� Number of Homes 66
School Number of Students/Staff
Other
Describe the source(s) of wastewater (example: subdivision, mobile home park, etc.):
Mobile Home Park
6. List all permits, construction approvals and/or applications (check all that apply):
love Permit Number Tyye
RCRA Non -Attainment
UIC Ocean Dumping
NPDES _Azc 00 31911 Dredge/Fill Permits
PSD Other
NESHAPS
Permit Number
7. Number of separate wastewater discharge pipes (wastewater outfalls):
One
8. If the facility has multiple discharge outfalls, record the source(s) of wastewater for each
outfall:
°3ce 2 -f 3 Version 12102

NPDES APPLICATION FOR PERMIT RENEWAL- SHORT FORM D
To be filed only by privately -owned dischargers of 100% domestic wastewater (<1 MGD flow)
9. Name of receiving streams) (Provide a map showing the exact location of each outfallf.
Third Creek in the Yadkin -Pee Dee River Basin. (See attached map)
10. Is this facility located on Native American lands? (c k one)
/ YES ❑ NO /1;10-/
,w 9. �.,r a-,.! /o t. t ivos�e 6/4d�i-� �w.w C/r.'f-rH ?o it o/GJ:-nt� �K.Es
/FS A�a-a�� L�O//s,i Slur 5� iffir �.r�.�. clar uiPr� i.•T �t.vu�.�'�x dos✓. K , G/�1..,
/1a/H��. v� TCav� art C1✓lp Co.+Te rT IsrofSaJ.
f tify tha£ I am familihr with the �ilformatioa cone is ned in t t application arit at t'o% T" '
the best of my knowledge and belief such information is true, complete, and accurate.
David L. Millsaps
Printed Name of Person Signing
Owner, Operator in responsible charge, Grade 2 WW Cert. No 11777
Title
North Carolina General Statute 143-215.6(b)(2) provides that: Any person who knowingly makes any false statement representation, or
certification in any application, record, report, plan, or other document files or required to be maintained under Article 21 or regulations of the
Environmental Management Commission implementing that Article, or who falsifies, tampers with, or knowingly renders inaccurate any
recording or monitoring device or method required to be operated or maintained under Article 21 or regulations of the Environmental
Management Commission implementing that Article, shall be guilty of a misdemeanor punishable by a fine not to exceed $10,000, or by
imprisonment not to exceed six months, or by both. (18 U.S.C. Section 1001 provides a punishment by a fine of not more than $10,000 or
imprisonment not more than 5 years, or both for a similar offense.)
Page 3 of 3 Version 12102