NC0023191_Permit Issuance_20000221

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
February 21, 2000
Mr. David L. Millsaps
Seven Cedars Mobile Home Park
1124 Radio Road
Statesville, North Carolina 28677
1�
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Issuance of NPDES Permit NCO023191
Seven Cedars Mobile Home Park
Iredell County
Dear Mr. Millsaps:
This letter is to inform you that the Division has finalized its review and the comment period is now closed
for NPDES permit NC0023191. A final copy of the permit is attached to this letter. This permit is issued pursuant
to the requirements of the North Carolina General Statute 143-215.1 and the Memorandum of Agreement between
North Carolina and the US Environmental Protection Agency dated December 6, 1983.
If any parts, measurement frequencies or sampling requirements contained in this permit are unacceptable
to you, you have the right to an adjudicatory hearing upon written request within thirty (30) days following receipt of
this letter. This request must be in the form of a written petition, conforming to Chapter 150B of the North Carolina
General Statutes, and filed with the Office of Administrative Hearings (6714 Mail Service Center, Raleigh, North
Carolina 27699-6714). Unless such demand is made, this decision shall be final and binding.
Please note that this permit is not transferable except after notice to the Division. The Division may require
modification or revocation and reissuance of the permit. In addition, this permit does not affect the legal
requirement to obtain other permits which may be required by the Division of Water Quality or permits required by
the Division of Land Resources, Coastal Area Management Act or any other Federal or Local governmental permit
that may be required.
If we can be of further assistance to you, please do not hesitate to contact Charles Weaver of my staff at
[phone], extension 511.
Sincerely,
Original Signed By
David A Goodrich
Kerr T. Stevens
cc: Central Files
Mooresville Regional Office / Water Quality Section
Point Source Compliance Enforcement Unit
NPDF.S Unit file<
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
Internet:http://h2o.enrstate.nc.us/NPDES 50%recycled/ 10%post-consumer paper

Permit NCO023191
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and regulations
promulgated and adopted by the North Carolina Environmental Management Commission, and the Federal Water
Pollution Control Act, as amended,
David L. Millsaps
is hereby authorized to discharge wastewater from a facility located at the
Seven Cedars Mobile Home Park
Village Drive
Statesville
Iredell County
to receiving waters designated as Third Creek in the Yadkin -Pee Dee River Basin in accordance with effluent
limitations, monitoring requirements, and other conditions set forth in Parts I, II, III, and IV hereof.
The permit shall become effective April 1, 2000.
This permit and the authorization to discharge shall expire at midnight on July 31, 2004.
Signed this day February 21, 2000.
O iginal Signed By
David A Goodrich
Kerr T. Stevens, Director
Division of Water Quality
By Authority of the Environmental Management Commission

SUPPLEMENT TO PERMIT COVER SHEET
David Millsaps
is hereby authorized to:
Permit No. NCO23191
1. Continue to operate an existing 0.010 MGD wastewater treatment plant consisting of a bar
screen, aeration basin, clarifier, V-notch weir, gravel filtration tank, chlorine contact tank with
tablet chlorination, and three (3) non -aerated sludge holding tanks located at Seven Cedars
Mobile Home Park, Village Drive, Statesville, Iredell County, and
2. Discharge from said treatment works at the location specified on the attached map into Third
Creek, which is classified as C waters in the Yadkin -Pee Dee River Basin.

Latitude:
35043' 55"
Longitude:
800 48' 05"
USGS Quad #:
E15NE
River Basin #:
03-07406
Receiving Stream: Third Creek
Stream Class:
C
Seven Cedars M HT
NOD023191
Iredell County

A.(1) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS Permit No. NCO023191
During the period beginning on the effective date of the permit and lasting until expiration, the Permittee is authorized to discharge from outfall
aerial number 001. Such discharges shall be limited and monitored by the Permittee as specified below:
EFFLUENT CHARACTERISTICS
LIMITS
MONITORING REQUIREMENTS
Monthly
Average
Weekly
Average
Daily
Maximum
Measurement
Frequency
Sample
Type
Sample
Location
Flow
0.010 MGD
Weekly
Instantaneous
I or E
BOD, 5 day, 200C
30.0 m /I
45.0 m /1
Weekly
Grab
E
Total Suspended Solids
30.0 m I
45.0 m I
Weekl
Grab
E
NH as N
2 / Month
Grab
E
Temperature
Weekly
Grab
E
H'
Weekly
Grab
E
Total Nitrogen
Quarterly
Grab
E
Total Phos horus
Quarterly
Grab
E
Notes:
t Sample locations: I —Influent, E —Effluent.
' The pH shall not be less than 6.0 standard units nor greater than 9.0 standard units.
There shall be no discharge of floating solids or visible foam in other than trace amounts.

PUBLIC NOTICE
STATE OF NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
NOTIFICATION OF INTENT TO ISSUE A STATE NPDES PERMIT
On the basis of thorough staff review and application of Article 21 of Chapter 143, General Statutes of
North Carolina, Public Law 92-500 and other lawful standards and regulations, the North Carolina
Environmental Management Commission proposes to issue a permit to discharge to the persons listed
below effective 11/8/99 and subject to special conditions.
Persons wishing to comment upon or object to the proposed determinations are invited to submit same in
writing to the above address no later than 10/22/99. All comments received prior to that date will be
considered in the formulation of final determinations regarding the proposed permit. A public meeting may
be held where the Director of the Division of Environmental Management finds a significant degree of
public interest in a proposed permit.
A copy of the draft permit is available by writing or calling the Division of Environmental Management,
P.O. Box 29535, Raleigh, North Carolina 27626-0535, [phone].
The application and other information may be inspected at these locations during normal office hours.
Copies of the information on file are available upon request and payment of the costs of reproduction.
All such comments or requests regarding a proposed permit should make reference to the NPDES permit
number listed below.
Date Q I S `� II[rr
Director
Division of Environmental Management
Public notice of intent to issue a State NPDES permit to the following:
1. NPDES No. NC0023191. David Millsaps, Seven Cedars Mobile Home Park, 1124 Radio Road,
Statesville, NC 28677 has applied for a permit renewal for a facility located at Seven Cedars Mobile
Home Park, 1124 Radio Road, Statesville, Iredell County. The facility discharges 0.010 MGD, of treated
domestic wastewater from one outfall into Third Creek, a Class C stream in the Yadkin -Pee Dee River
Basin which has a 7Q10 flow of 12.2 cfs. No parameters are water quality limited, but this discharge may
affect future allocations.
2. NPDES No. NC0081779. Sackner Products, 166 Orbit Road, Statesville, NC 28677-2600 has
applied for a permit renewal for a facility located at the subject address in Iredell County. The facility
discharges 0.0016 MGD of industrial wastewater from one outfall into an unnamed tributary to Back
Creek, a Class C stream in the Yadkin River Basin which has a 7Q10 flow of 0 cfs and a 30Q2 flow of 0
cfs. No parameters are water quality limited, but this discharge may affect future allocations.

1124 Radio Road
Statesville, NC 28677
February 17, 1998
Dave Goodrich, Supervisor
NPDES Unit
Division of Water Quality
P. O. Box 29535
Raleigh, NC 27626-0535
Subject: Request for Permit Modification
Seven Cedars MBP WWTP
NPDES Permit No.: NCO023191
Iredell County, NC
Dear Mr. Goodrich:
F�9 ? 3 1u�3
POINT SOURCE BRANCH
Seven Cedars NIP WWTP was last inspected on January 16, 1998, by Mr.
Roberto L. Scheller of the NC Division of Water Quality Mooresville Regional
Office.
It was noted during a review of the permit that the monitoring of influent at this
facility is inappropriate and should be removed from the permit. Upon
recommendation that I request this modification, this letter hereby serves as a
formal request for permit modification to remove sampling requirements.
Thank you for your attention to this matter. If you have any questions, please do
not hesitate to contact me at the address indicated or by telephone at (704) 873-
1331.
Sincerely,
Sio
�lCitcCei"7
David Millsaps

7111
DENR/DWQ
FACT SHEET FOR NPDES PERMIT DEVELOPMENT
NPDES No. NC0023191
Facility Information
FacilityName:
Seven Cedars Mobile Home Park
Permitted ow:
0.0 10 MUD
County:
Iredell
Facility ass:Regional
ice:
ooresvi e
aci ity ermitStatus:
(i.e. New, Modification,
Existing or Renewal)
xisting
U SGS I opoQuad-.
Stream Characteristics
ReceivingStream:
ird Creek
Stream Classification:
C
12-108-20-4
inter c s
u asm:
- -
c s
Drainage Area (mi ):Average
Flow c s :
Summer (cis)
o :
Changes Incorporated into Permit Renewal
Proposed Changes
Parameters Affected
Basis lor change(s)
Effluent Limitations and
ChangedpH monitoring
Requirement of NC
Monitoring Requirements
equency from 2/month to
Administrative Code 2B.0500
Page
weekly.
for class II facility.
Part III
DeletedSpecial Condition E
Facility has ins e a
chlorine contact tank with
tablet chlorination.
Effluent Limitations and
7udded-17Nan
s data wi It be use in e
Monitoring Requirements
monitoring. Monitoring will
development of nutrient
Page
be on quarterly basis.
strategies for the Yadkin
Basin.
Summary
The facility has requested a permit renewal with no modifications. It is recommended
that the permit be renewed as drafted.
The following notes were taken during the review of the application package:
• 3
isrd List Review: Third Creek is not listed on the North Carolina 303d
t.
• Review of Basin Plan: Third Creek is listed as support threatened based on
Fecal o i orm eve s. Nonpoint source runoff contamination is the probable
cause although several small facilities in the subbasin show occasional
violations.
To improve water quality in impaired streams and protect other waters from
further degradation, the specific pollutant sources must be identified. As
Page 1
Version: June 12, 1999

DENR/DWQ
FACT SHEET FOR NPDES PERMIT DEVELOPMENT
NPDES No. NCO023191
(Continued)
resources allow, DWQ intends to develop NPS management strategies for
this waterbody for the second Yadkin -Pee Dee River Basin Plan.
Staff Report (most recent dated February 19,1999): Facility has the
uultimate design of0.025 Ma
D, w c Would allow the connection
of approximately 100 mobile homes. At the present time, 66 mobile homes
are connected to the WWTP facility. The existing permit contains a flow
limitation of 0.010 MGD, which is more representative of current hydraulic
flow. Facility is classified as a Class II facility. Residuals are currently
disposed of via a septage hauler (Sigmon Environmental) who takes the
residuals to CMUD McAlpine Creek WWTP for disposal.
Region has requested that influent BOD and TSR be removed from the
permit. Region has no other comments in reference to the permitted facility.
Region recommends renewal of permit as requested by Permittee.
• Wasteload Allocation (prepared 2/9/93): Limits were determined to be
watery q a Ity limited. 01) limit was set at 16 mg/l. Ammonia limit was set
at 9.0 mg/l, DO limit was set at 6.0 mg/l, TSS limit was set at 30.0 mg/l,
Fecal Coliform was set at 200 /100ml.
Instream monitoring was recommended for DO, Temperature, Fecal
Coliform, and Conductivity.
• DMR Review:
Facility appears to be operating within the constraints of their existing permit
conditions. BOD levels range from 1.74 mg/l to 11.0 mg/l, TSS levels range
from 5.5 m to 3.5 mg/l over the period from 1998 to Apn-TF999 (monthly
average levels).
Compliance Evaluation Ins ection Re ort dated 5-4-99. Self monitoring reports
were reviewedor a period arc to tebruary 1999. The subject facility did
not report any limit violations during the review period. Monitoring appears to be
conducted according to NPDES permit requirements.
Compliance Evaluation Ins ction Re ort dated 1-28-98. Self monitoring reports
were reviewed or a period ovem r 19 to October 1997. The subject facility
did not report any limit violations during the review period.
Compliance Evaluation Ins ction ReRort dated 6-30-97. Self monitoring reports
were reviewed or the period May 1996 to Ap1997.ril a subject facility did not
report any limit violations during the review period.
Page 2
Version: June 12, 1999

DENR/DWQ
FACT SHEET FOR NPDES PERMIT DEVELOPMENT
NPDES No. NC0023191
(Continued)
Proposed Schedule for Permit Issuance
Draft Permit to Public Notice: 9/8/99
Permit Scheduled to Issue: 10/25/99
State Contact
If you have any questions on any of the above information or on the attached
permit, please contact Charles Weaver at [phone], extension 511.
Copies of the following are attached to provide further information on the permit
development:
• Existing permit effluent sheets with changes noted (existing facilities only)
• Draft Permit
Signature:
NPDES Recommendation by:
Regional Office Comments
!)/isle SY�'-prn ".s ,q// de,*erx�
NON/
Reviewed By:
iGYS��e.�JT yFH*. DP/I��t�C
s-V"Vzrrli
Lct �o S �r�W
,r.,
or-, irWv
/S
ignature:
a
2 7 Gb
Regional Supervisor:
(/yJ
ign e:
a
NPDES Unit:
Page 3
Version: June 12, 1999
I -k' t

Permit No. NCO023191
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT, HEALTH, AND NATURAL RESOURCES
DIVISION OF E-NVIRONMENTAI MANACFM NT Ala
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
In compliance with the provision of North Carolina General Statute 143-215.1,
other lawful standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Po ution Control Act, as amended,
Da dL saps
is hereby authorized to discharge wastewater from a facility located at
Seven Cedars Mobile Home Park
1174 D@Rd VoIT
ll Sf-'tew.;iu-
Iredell County
to receiving waters designated as Third Creek in the Yadkin -Pee Dee River Basin
in accordance with effluent limitations, monitoring requirements, and other conditions set forth in
Parts I, 11, and III hereof.
This permit shall become effective ram, 9�4
oly
This permit and the authorization to discharge shall expire at midnight on July
l
, Director
Division of Environmental Management
By Authority of the Environmental Management Commission

Permit No. NCO023191
SUPPLEMENT TO PERMIT COVER SHEET
David Millsaps
is hereby authorized to: p.vt0
1. Continue to operate an ezistingRvastewater treatmen stem consisting of a bar screen, aeration
basin, clarifier, V - notch weir, gravel filtration tana a ffatv�' -bnk located
at Seven Cedars Mobile Home Park, 1k�4 Ra'e r o� Iredell
County ( , and
2. Discharge from said treatment works at the location specified on the attached map into Third
Creek which is classified Class C waters in the Yadkin -Pee Dee River Basin.
Mass C-
IZ-ws- ao -y

A. (). EFFLUENT LIM[1TAT1ONS AND MONITORING REQUIREMENTS FINAL
Permit No. NCO023191
During the period beginning on the effective date of the permit and lasting until expiration, the Permittee is authorized to discharge from
outfall(s) serial number 001. Such discharges shall be limited and monitored by the permittee as specified below:
Effluent Characteristics
Flow
BOD, 5 day, 200C
Total Suspended Residue
NH3 as N
Discharge Limitations
Monthly Avg_ Weekly Avg. Daily Max
0.010 MGD
30.0 mg/I 45.0 mg/I
30.0 mg/I 45.0 mg/I
Temperature
P tt
-fN
t
%Sample locations: E - Effluent, I - Influent
Monitoring
Requirements
Measurement
Sample
'Sample
Frequency
Type
Location
Weekly
Instantaneous
I or E
Weekly"
Grab
E
Weekly
Grab
E
2/Month✓
Grab
E
Weekly
Grab
E
4AWA�
C
��.Jrrly
2
( 4o,-W47
V The pH shall not be less than 6.0 standard units nor greater than 9.0 standard unit�rat the effluent by grab
sam le
There shall be no discharge of floating solids or visible foam in other than trace amounts.

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
Mr. David Millsaps
1124 Radio Road
Statesville, North Carolina 28677
Dear Mr. Millsaps:
AT4 ��'
iv�M
A
C) E N F=1
March 6, 1998
Subject: NPDES Permit Modification
NPDES Permit No. NCO023191
Seven Cedars Mobile Home Park
Iredell County
On September 26, 1994, the Division of Water Quality issued NPDES Permit No. NCO023191
to David Millsaps. A review of the permit file has indicated that an error was inadvertently made in
the permit. Accordingly, we are forwarding herewith modifications to the subject permit to correct
the error. These permit modifications are issued to delete influent sampling from the effluent page.
Please find enclosed an amended effluent page which should be inserted into your permit. The
old effluent page should be discarded. All other terms and conditions contained in the original
permit remain unchanged and in full effect. These permit modifications are issued pursuant to the
requirements of North Carolina General Statutes 143-215.1 and the Memorandum of Agreement
between North Carolina and the U. S. Environmental Protection Agency.
If any parts, measurement frequencies or sampling requirements contained in this permit
modification are unacceptable to you, you have the right to an adjudicatory hearing upon written
request within thirty (30) days following receipt of this letter. This request must be in the form of a
written petition, conforming to Chapter 150B of the North Carolina General Statutes, and filed
with the Office of Administrative Hearings, Post Office Drawer 27447, Raleigh, North Carolina
27611-7447. Unless such demand is made, this decision shall be final and binding.
If you have any questions concerning these permit modifications, please contact Mr. Mack
Wiggins at telephone number 919/733-5083.
Sincerely
. Preston Howard, Jr.,L
cc. Central Files
Mooresville Regional Office
Point Source Compliance and Enforcement Unit
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post-consumerpaper

To: Permits and Engineering Unit
Water Quality Section
Attention: Charles Weaver
SOC Priority Project: No
Date: February 19, 1999
NPDES STAFF REPORT AND RECOMMENDATIONS
County: Iredell
NPDES Permit No.: NC0023191
MRO No.: 99-04
PART I - GENERAL INFORMATION
Facility and Address: Seven Cedars Mobile Home Park
1124 Radio Road
Statesville, N.C. 28677
2. Date of Investigation: February 9, 1999
3. Report Prepared By: Michael L. Parker, Environ. Engr. H
4. Person Contacted and Telephone Number: Mr. David Millsaps, Owner and ORC, (704)
873-1331.
5. Directions to Site: From the junction of Hwy. 70 and SR 2359 (Bethesda Rd.) east of the
City of Statesville, travel south on SR 2359 approx. 2.3 miles and tam left into the entrance
of the MHP. The W WTP site is located at the end of this road.
6. Discharge Point(s), List for all discharge Points: -
Latitude: 350 43' 55"
Longitude: 80' 48' 05"
Attach a USGS Map Extract and indicate treatment plant site and discharge point on map.
USGS Quad No.: E 15 NE
7. Size (land available for expansion and upgrading): There is ample area available for
expansion of the W WTP, if necessary.
8. Topography (relationship to flood plain included): Hilly, 5-15% slopes. The W WTP site is
not located in a flood plain.
9. Location of Nearest Dwelling: The nearest dwelling is approximately 300 feet from the
WWTP site.

Page Two
10. Receiving Stream or Affected Surface Waters: Third Creek
a. Classification: C
b. River Basin and Subbasin No.: Yadkin 03-07-06
C. Describe receiving stream features and pertinent downstream uses: Excellent flow
observed in the receiving stream. The area is generally rural and the receiving stream
is primarily used for secondary recreation.
PART II - DESCRIPTION OF DISCHARGE AND TREATMENT WORKS
a. Volume of Wastewater: 0.025 MGD (Design Capacity)
b. What is the current permitted capacity: P.010 MGD (see Part IV below).
C. Actual treatment capacity (current design capacity): 0.025 MGD.
d. Description of existing or substantially constructed WWT facilities: The existing
W WT facilities consist of a bar screen, an aeration basin (diffused), a clarifier, a V-
notch weir, a gravel filtration tank, chlorine contact tank with tablet chlorination, and
three (3) non -aerated sludge holding tanks.
e. Description of proposed treatment facilities: There are no proposed W WT facilities.
f. Possible toxic impacts to surface waters: Chlorine is added during the treatment
process.
2. Residuals handling and Disposal Scheme: Residuals are currently disposed of via a septage
hauler (Sigmon Environmental) who takes the residuals to CMUD's McAlpine Creek
WWTP for disposal.
3. Treatment Plant Classification: No change from previous rating (Class II).
4. SIC Code(s): 6515
Wastewater Code(s): 08
5. MTU Code(s): 02002
PART III - OTHER PERTINENT INFORMATION
1. Is this facility being constructed with Construction Grants Funds (municipals only)? No
2. Special monitoring requests: None at this time.
3. Additional effluent limits requests: None, pending receipt and approval of the WLA.
4. Air Quality and/or Groundwater concerns or hazardous waste utilized at this facility that
may impact water quality, air quality or groundwater? No AQ or GW concerns nor are
hazardous materials utilized at this facility.
tt 1

Page Three
PART IV - EVALUATION AND RECOMMENDATIONS
The existing WWT facility serving the Seven Cedars Mobile Home Park has a design
capacity of 0.025 MGD which would allow the connection of approximately 100 2-bedroom mobile
homes. At the present time, 66 mobile homes are connected to the WWT facility. The Permit,
however, contains a flow limitation of 0.010 MGD, which is more representative of current
hydraulic flow.
The Permit also contains influent monitoring for BOD and TSR. The collection of this data
is considered unnecessary since the data provides little, if any benefit in the day -today operation of
the W WTP. It is recommended that the influent monitoring of the aforementioned parameters be
removed at Permit reissuance. _
The permittee proposes no other changes and/or modifications to the Permit at this time.
It is recommended that the permit be renewed as requested.
Signature of Report Preparer Date
Water Quality Regional Supervis Date
h:\dsr\dsr99\7cedars.dsr