NC0000400_Issuance of Permit_20060831

�F W ArF9Q Michael F.Easley,Governor
�O William G.Ross Jr.,Sxretary
e North Carolina Department of Environment and Natural Resources
0 .r Alan W.Klimek,P.E.Director
Division of Water Quality
August 31,2006
Mr.James Thomas
K-T Feldspar Corporation
P.O.Box 309
Spruce Pine,NC 28777
Subject: NPDES Permit Issuance
NPDES Permit NC0000400
K-T Feldspar Corporation
Mitchell County •
. Dear Mr.Thomas:
Division personnel have reviewed and approved your application for renewal of the subject
permit. Accordingly,we are forwarding the attached NPDES discharge permit. This permit is issued
pursuant to the requirements of North Carolina General Statute 143-215.1 and the Memorandum of
Agreement between North Carolina and the U.S.Environmental Protection Agency dated May 9, 1994
(or as subsequently amended.)
The permit authorizes K-T Feldspar Corporation to discharge up to 1.73 MGD of treated
wastewater from the K-T Feldspar facility to the North Toe River, a class C Trout water in the French
Broad River Basin. The permit includes discharge limitations/or monitoring for flow,total fluoride,
total suspended solids(TSS),settleable solids, turbidity, pH,chloride and chronic toxicity.
The North Toe River is listed as an impaired stream on North Carolina's 2006 Draft 303(d)list.
This means that the stream does not meet all water quality standards. It is the plan of the Division to
work for the improvement and recovery of the River. In the event of the continuance of problems,the
future may require the removal of direct point source dischargers to the North Toe River for the health
of the stream. If there is noncompliance with permitted effluent limits and degradation of the North
Toe River can be attributed to K-T Feldspar Corporation WWTP discharge, then removal of the
discharge may be necessary. K-T Feldspar Corporation may determine in the future that an alternative
to surface water discharge may be more appropriate.
The following modification from the previous permit remains in this final permit:
■ The addition of a special condition for turbidity that states:In the event that violations of
the turbidity standard of the North Carolina Water Quality Standards occur as a result of
this discharge,this permit shall be modified,or alternately,revoked and reissued to
incorporate limitations sufficient to protect the receiving waters.
No` Caro ina
turaIly
North Carolina Division of Water Quality 1617 Mail Service Center Raleigh,NC 27699-1617 Phone[phone] Customer Service
Internet: www.ncwateroualitv.org Location: 512 N.Salisbury St. Raleigh,NC 27604 Fax [phone]
An Equal Opportunity/Affirmative Action Employer—50%Recycled/10%Post Consumer Paper

Letter to Mr.Thomas
Page 2
If any parts,measurement frequencies or sampling requirements contained in this permit
are unacceptable to you,you have the right to an adjudicatory hearing upon written request within
thirty(30) days following receipt of this letter. This request must be in the form of a written
petition,conforming to Chapter 150B of the North Carolina General Statutes,and filed with the
office of Administrative Hearings, 6714 Mail Service Center,Raleigh,North Carolina 27699-6714.
Unless such a demand is made, this permit shall be final and binding.
Please take notice that this permit is not transferable. The Division may require
modification or revocation and reissuance of the permit. This permit does not affect the legal
requirements to obtain other permits which may be required by the Division of Water Quality or
permits required by the Division of Land Resources,Coastal Area Management Act, or any other
Federal or Local governmental permits may be required.
If you have any questions or need additional information, please contact Ms.Jacquelyn
Nowell at telephone number(919) 733-5083,extension 512.
Sincerely,
/6 CA 411.AL
Alan W.Klimek,P.E.
Attachments
cc: Asheville Regional Office/Surface Water Protection Section
EPA Region IV/Marshall Hyatt
Aquatic Toxicology
NPDES File
Central Files

Permit Number: NC0000400
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
—' PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provisions of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act,as amended,
K-T Feldspar Corporation
is hereby authorized to discharge wastewater from a facility located at
K-T Feldspar Corporation
on NCSR 1151
west of Spruce Pine
Mitchell County
to receiving waters designated as the North Toe River in the French River Basin in accordance
with effluent limitations,monitoring requirements,and other conditions set forth in Parts I,II,
III and IV hereof.
•
This permit shall become effective October 1,2006.
This permit and authorization to discharge shall expire at midnight on February 28,2011.
Signed this day August 31,2006.
• ttiLJ
livi'Alan W.Klimek,P.E.,Director
Division of Water Quality
By Authority of the
Environmental Management Commission
1

Permit Number: NC0000400
•
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility, whether for operation or discharge are
hereby revoked,and as of this issuance,any previously issued permit bearing this number is no
longer effective. Therefore, the exclusive authority to operate and discharge from this facility
arises under the permit conditions,requirements,terms,and provisions included herein.
• K-T Feldspar Corporation
is hereby authorized to:
1. Continue operation of a 1.73 MGD wastewater treatment facility consisting of:
• three influent pump stations,
• polymer addition,
• pH adjustment,
• screw classifier, -
• inorganic solids settling ponds and
• flow totalizing and recording equipment.
The facility is located at the K-T Feldspar Corporation, on NCSR 1151, west of Spruce Pine,
Mitchell County.
2. Discharge wastewater from said treatment works through outfall 103 at the location
specified on the attached map into the North Toe River,which is classified C-Trout waters,
in the French Broad River Basin.
•
2

N
"o,
Facility Information
Latitude: 3555'39" Sub -Basin: 04-03-06
Longitude 82'05'45"
Quad #: Spruce Pine (MONE)
Stream Class: C-Trout
Receiving StrearuL North Toe River
4",
, qlj
Facility
Location
K-T Feldspar Corporation
NO00
North C0400 I I

1
Permit Number: NC0000400
A. (1). EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS- FINAL
During the period beginning on the effective date of the permit and lasting until expiration,the
Permittee is authorized to discharge process wastewater from mineral extraction of ore from
outfall 001. Such discharges shall be limited and monitored by the Permittee as specified below:
EFFLUENT LIMITATIONS MONITORING REQUIREMENTS
EFFLUENT
CHARACTERISTICS Monthly Daily Maximum Measurement Sample Type Sample
Average Frequency Location
Flow 1.73 MGD Continuous Recording I or E
Total Fluoride. 132.0 lb/day 264.0 lb/day Daily Composite E,U,D
Total Suspended Solids 1240.0 lb/day 2480.0 lb/day Daily Composite E
Settleable Solids Daily Grab E
Turbidity2 Daily Grab E, U,D
pH3 Daily Grab E, U.D
Chlorides Quarterly Composite E
Chronic Toxicitys Quarterly Composite E
Notes:
1. Sample locations: E- Effluent, I- Influent, U-upstream 100 yards from outfall, D-
downstream 100 yards from outfall. Instream samples shall be grab samples and
shall be conducted 3/week.
2. This discharge shall not cause the turbidity of the receiving waters to exceed 10
NTU. If the turbidity exceeds 10 NTU due to natural background conditions, the
discharge shall not cause any increase in turbidity of the receiving water. (See
Special Condition A.(6).
3. The pH shall not be less than 6.0 standard units nor greater than 10.0 standard
units. -
4. Chloride shall be monitored quarterly during the same months as toxicity testing.
5. Chronic Toxicity (Ceriodaphnia) Pass/Fail at 6.0%: February, May, August and
November. See Special Condition A (2).
There shall be no discharge of floating solids or visible foam in other than trace
amounts.
•
3

Permit Number: NC0000400
A.(2). CHRONIC TOXICITY PERMIT LIMIT (QRTRLY)
The effluent discharge shall at no time exhibit observable inhibition of reproduction or significant
mortality to Ceriodaphnia dubia at an effluent concentration of 6.0%.-
The
.0%-The permit holder shall perform ata minimum,quarterly monitoring using test procedures outlined in the
"North Carolina Ceriodaphnia Chronic Effluent Bioassay Procedure,"Revised February 1998,or
subsequent versions or"North Carolina Phase II Chronic Whole Effluent Toxicity Test Procedure"
(Revised-February 1998)or subsequent versions.The tests will be performed during the months of
February,May,August and November. Effluent sampling for this testing shall be performed at the
NPDES permitted final effluent discharge below all treatment processes.
If the test procedure performed as the first test of any single quarter results in a failure or ChV below
the permit limit,then multiple-concentration testing shall be performed at a minimum,in each of the
two following months as described in"North Carolina Phase II Chronic Whole Effluent Toxicity Test
Procedure"(Revised-February 1998)or subsequent versions.
The chronic value for multiple concentration tests will be determined using the geometric mean of the
highest concentration having no detectable impairment of reproduction or survival and the lowest
concentration that does have a detectable impairment of reproduction or survival. The definition of
"detectable impairment,"collection methods,exposure regimes,and further statistical methods are
. specified in the"North Carolina Phase II Chronic Whole Effluent Toxicity Test Procedure"(Revised-
February 1998)or subsequent versions.
All toxicity testing results required as part of this permit condition will be entered on the Effluent
Discharge Monitoring Form(MR-1)for the months in which tests were performed,using the parameter
code TGP3B for the pass/fail results and THP3B for the Chronic Value. Additionally,DWQ Form AT-3
(original)is to be sent to the following address:
Attention: North Carolina Division of Water Quality
Environmental Sciences Section -
1621 Mail Service Center
Raleigh,North Carolina 27699-1621
Completed Aquatic Toxicity Test Forms shall be filed with the Environmental Sciences Section no later
than 30 days after the end of the reporting period for which the report is made.
Test data shall be complete,accurate,include all supporting chemical/physical measurements and all
concentration/response data,and be certified by laboratory supervisor and ORC or approved designate
signature. Total residual chlorine of the effluent toxicity sample must be measured and reported if
chlorine is employed for disinfection of the waste stream.
Should there be no discharge of flow from the facility during a month in which toxicity monitoring is
required,the permittee will complete the information located at the top of the aquatic toxicity(AT)test
form indicating the facility name,permit number,pipe number,county,and the month/year of the report
with the notation of"No Flow"in the comment area of the form. The report shall be submitted to the
Environmental Sciences Section at the address cited above.
4

Permit Number: NC0000400
Should the permittee fail to monitor during a month in which toxicity monitoring is required,monitoring
will be required during the following month.
Should any test data from this monitoring requirement or tests performed by the North Carolina Division
of Water Quality indicate potential impacts to the receiving stream,this permit may be re-opened and
modified to include alternate monitoring requirements or limits.
NOTE: Failure to achieve test conditions as specified in the cited document,such as minimum control
organism survival,minimum control organism reproduction,and appropriate environmental controls,
shall constitute an invalid test and will require immediate follow-up testing to be completed no later than
the last day of the month following the month of the initial monitoring.
Should any test data from this monitoring requirement or tests performed by the North Carolina Division
of Water Quality indicate potential impacts to the receiving stream,this permit may be re-opened and
modified to include alternate monitoring requirements or limits.
NOTE: Failure to achieve test conditions as specified in the cited document,such as minimum control
organism survival,minimum control organism reproduction,and appropriate environmental controls, .
shall constitute an invalid test and will require immediate follow-up testing to be completed no later than
the last day of the month following the month of the initial monitoring.
•
5

Permit Number: NC0000400
A. (3). BIOCIDES
•
The permittee shall obtain authorization form the Division of Water Quality prior to utilizing
any new biocide in cooling water to be discharged. The permittee shall notify the Director in
writing,not later than ninety(90) days prior to instituting use of any additional biocide used in
cooling systems,which may be toxic to aquatic life other than those previously reported to the
Division of Water Quality. Such notification shall include completion of Biocide Worksheet
Form 101 and a map locating the discharge point and receiving stream. No chromium,zinc,or
copper shall be added to the treatment system except as pre-approved additives to biocidal
compounds.
A. (4). WASTEWATER DIVERSION
Diversion or bypassing of untreated wastewater from the treatment facility is prohibited.
A. (5). SOLIDS REMOVAL
Solids removed or resulting from the wastewater treatment process shall be contained and
disposed of in such a manner as to prevent any contamination of the surface waters of the State.
A.(6). TURBIDITY •
In the event that violations of the turbidity standard of the North Carolina Water Quality
Standards occur as a result of this discharge, this permit shall be modified,or alternately,
revoked and reissued to incorporate limitations sufficient to protect the receiving waters.
A. (7). FLUORIDE REOPENER
This permit shall be modified, or revoked and reissued to incorporate new fluoride effluent
limitations in the event that acute or chronic bioassay testing or other studies results in a change
in the North Carolina Water Quality Standard for fluoride.
A. (8). PERMIT MODIFICATIONS
This permit shall be modified,or revoked and reissued to incorporate new limitations in the
event that production changes are requested or should any new fluoride using discharge
request to locate on the North Toe River.
6

7
• DENR/DWQ
FACT SHEET FOR NPDES PERMIT DEVELOPMENT
NPDES No. NC0000400
Facility Information
Applicant/Facility Name: K-T Feldspar Corporation
Applicant Address: P.O.Box 309 Spruce Pine NC 28777
Facility Address: Hwy 226 North Spruce Pine NC 28777
Permitted Flow 1.73 MGD
Type of Waste: Industrial
Facility/Permit Status: Renewal
Facility Classification Physical/Chemical Class II
County: Mitchell
Miscellaneous
Receiving Stream: North Toe River Regional Office: Asheville
Stream Classification: C Trout USGS Topo Quad: D1ONE
303(d)Listed?: No* Permit Writer: Jackie Nowell
Subbasin: 04-03-06 Date: 4/26/2006
Drainage Area (mi2): 133
Summer 7Q10 (cfs) 44 «�++
Winter 7Q10(cfs): 553 °
Average Flow (cfs): 264
IWC(%): 5.74%
Primary SIC Code: 1499(Mining)
SUMMARY OF FACILITY INFORMATION AND WASTELOAD ALLOCATION
K-T Feldspar Corporation is requesting a permit renewal for its feldspar mining and processing
facility. The facility is permitted to discharge into the North Toe River,class C-Trout waters,in
French Broad River Basin. The renewal application states that outfall 103 discharges process
water.
The existing wastewater treatment plant consists of:
• Three influent pump stations;
• Standby power;
• thickeners;
• polymer addition;
• lime addition;
• screw classifier;
• inorganic settling ponds;
• flow recirculation;
• flow totalization and recording equipment,
RECEIVING STREAM INFORMATION:
*The North Toe River is not listed on North Carolina's 2004-303(d)list,however it should be
noted that the 2005 French Broad River Basin Management Plan has a segment of the North Toe
River with a use support rating of Impaired based on turbidity and riparian area loss. The
segment also has a bioclassification rating of Fair(It is listed as biologically impaired on the
2006 Draft 303d list).
K-T Feldspar Corporation Factsheet
NPDES Renewal
Page 1

At this time,DWQ proposes no changes to the previously developed load allocations. Neither .
the impairment nor the turbidity violation is directly attributable to the discharges. However,
the facility will be notified via the cover letter about potential impacts due to the Draft 303d.
INSTREAM MONITORING:
Upstream: 100 yds above discharge
Downstream: 100 yds below discharge
Parameters: Fluoride,Turbidity,pH,settleable matter
A review of 2004 and 2005 instream data shows no exceedences of the instream fluoride
standard of 1.8 mg/1. Upstream and downstream Fl samples averaged less than 0.5 mg/i.
Both upstream and downstream turbidity samples exceeded the standard in July and August
2003 and in June through August 2005. The remaining months turbidity ranged from 2.2 NTU
to 9.5 NTU.
TOXICITY TEST RESULTS:
Quarterly Chronic P/F,6%Ceriodaphnia test. FEB MAY AUG NOV
Facility's compliance with toxicity limit has been excellent. All chronic tests were passed in
2004 and 2005. Recommendation: Renewal of quarterly chronic test @ 6%
COMPLIANCE REVIEW:
Facility has been in compliance with all permit limits consistently with the exception of one
exceedence of the TSS daily maximum limit in Sept. 2004. Overall compliance record is good.
*Will notify facility that PPA must be done and submitted for review before permit can be
renewed.
PROPOSED CHANGES:
• The addition of a special condition for turbidity. This will allow reopening of the permit for
the inclusion of limits etc if it is shown that K-T Feldspar contributed to stream
degradation..
PROPOSED SCHEDULE FOR PERMIT ISSUANCE:
Draft Permit to Public Notice: 05/10/2006
Permit Scheduled to Issue: 07/03/2006
Projected Effective Date of Permit: 08/01/2006
STATE CONTACT:
If you have any questions on any of the above information or on the attached permit, please
contact Ja A e Nowell at(919) 733-5083 ext.512.
AI
NAME: a't'. A DATE: I/uP x.60 k
K-T Feldspar Corporation Factsheet
NPDES Renewal
Page

•
• REGIONAL OFFICE COMMENT:
/57.? 0 44i ,4' ZSg,41 (.4/>Ai Z7S 7-
DATE:
NPDES SUPERVISOR COMMENT:
NAME:.0v7„...r , DATE:
rH H : 1.1 )
_
Li JUN 1 6 2006
DENR- WATER QUALITY
K-T Feldspar Corporation Factsheet BOAT SOURCE BRANCH
NPDES Renewal
Page 3

r .
J.„,Eo Sr,„
A UNITED STATES ENVIRONMENTAL PROTECTION AGENCY
:4 2ra>W REGION 4
3.1 ATLANTA FEDERAL CENTER
61 FORSYTH STREET
til4
4 PHOjt-G ATLANTA, GEORGIA 30303-8960
MAY 2 4 2006 :�--� """'_.,
Ms. Jackie Nowell
North Carolina Department of Environment and
Natural Resources
Division of Water Quality Er AY 3 1 2006
NPDES Unit _
1617 Mail Service Center Y' r ' `;
Raleigh, NC 27699-1617
SUBJ: Draft NPDES Permit
K-T Feldspar Corp. - Permit No. NC0000400
Dear Ms. Nowell:
In accordance with the EPA/NCDENR NPDES MOA, we have completed review of the
draft permit specified above and have no comments or objections to its conditions. We request
that we be afforded an additional review opportunity only if significant changes are made to the
draft permit prior to issuance or if significant comments objecting to it are received. Otherwise,
please send us one copy of the final permit when issued.
If you have any questions, please call me at [phone].
Sincerely,
Marshall Hyatt, Environmental Scientist
Permits, Grants, and Technical Assistance Branch
Water Management Division
Internet Address(URL)• http://www.epa.gov
Recycled/Recyclable•Printed with Vegetable ON Based Inks on Recycled Paper(Minimum 30%Postconsumer)

L)ratt Permits(12)
Subject:Draft Permits(12)
From: John Giorgino<[e-mail]>
Date: Mon,22 May 2006 14:40:18-0400
To: Jackie Nowell<[e-mail]>
Jackie, I have reviewed the following permits (I am late getting back to you on some
of them, but did not have any comments) . Thanks for forwarding them.
NC0025321
NCO021962
NCO074705
NC0023884
NC0005177
NC0000361
NC0000400
NC0084620
NCO085839
NC0000353
NC0000175
NC0060534
John Giorgino
Environmental Biologist
North Carolina Division of Water Quality
Environmental Sciences Section
Aquatic Toxicology Unit
•
Mailing Address:
1621 MSC
Raleigh, NC 27699-1621
Office: 919 733-2136
Fax: [phone]
"The real work of men was hunting meat. The invention of agriculture was a giant step
in the wrong direction, leading to serfdom, cities, and empire. From a race of
hunters, artists, warriors, and tamers of horses, we degraded ourselves to what we are
now: clerks, functionaries, laborers, entertainers, processors of information." -
Edward Abbey
1 of 1 immin6 111R PM

• REASONABLE POTENTIAL ANALYSIS
KT Feldspar Corp. WWTP Outfall 001
NC0000400 Qw= 1.73 MGD
Time Pesti 5/26/2006
Qw(MGD) 1.73 WWTP Class II
7Q10S(cfs) 44 IWC(56)@ 7Q10S 5.7442
7Q 10W(cls) 55 7Q/OW 4.6488
3002(c1s) 79 3002 3.2829
Arg.Stream Flow,QA(cfs) 264 QA 1.0055
RecYing Stream North Toe River Stream Class C
STANDARDS 8
PARAMETER TYPE CRITERIA(2) PQL Units REASONABLE POTENTIAL RESULTS RECOMMENDED ACTION
(I) NC Wirt /i fAV/ UM_ IdaRNa Aloask•cb
drank Aar
Acute: N/A
Arsenic NC 50 ug/L 1 0 N/A
Chronic 870--_—_—___—_—_____—_______—_____
Acute. N/A
Beryllium C 6.5 ug/L 1 0 N/A
Note:n<12 Chronic:_—_ --_—_____—_—_—_—_—_—_—_—_—_—___
646
L.imited data set
Acute: 15
Cadmium NC 2 15 ug/L 1 0 N/A
Chronic: 35
'a set
Acute: 1,022
Chromium NC 50 1,022 ug/L 1 1 N/A
Note:n<12 /Chronic: 870 data=4.9 ug/I-,no monitoring or lend recommended
Limited data set
Acute: 7
Copper NC 7 AL 7 3 ug/L 1 1 N/A L
Note:n<12 Chronic: 122 data=l0 ug/i-,no monitoring or limit recommended
Limited data set
Acute: 22
Cyanide NC 5 N 22 10 ug/L 1 0 N/A
Note:n<12 Chronic:
87
Limited data sat
AWN: N/A
Fluoride NC 1,800 ug/L 1 1 WA
Note:n<12 ~Chronic: 31,336 data=170 ug/I- no monitoring or limit recommended
Limited data set
Acute: 34
Lead NC 25 N 33.8 ug/L 1 1 N/A
Note:n<12 Chronic: 435 data=l5 ug/F,no monitoring or limit recommended
Limited data set
Acute: WA
Mercury NC 0.012 0 0002 ug/L 0 0 N/A
Chronic:_—_O________—_—___—____.___.__—_—_—_
Acute: N/A
Barium NC 1,400 ug/L 1 1 N/A
Chronic: 24,372 datai0 ug./1-,no monitonng or limit recommended
set
Acute. 261
Nickel NC 88 261 ug/L 1 1 N/A
Chronic: 1,532 data=8.3 ug/F.no monitoring or limit recommended
limited data set
Acute: N/A
Phenols A 1 N ug/L 1 1 N/A
Note:n<12 Chronic: 30 data=22 ug I,no monitoring or limit recommended
Limited data set
Acute: 56
Selenium NC 5.0 56 ug/L 1 0 N/A
Note:n<12 'Chronic. 87
Limited data set
Acute- 1
Silver NC 0.06 AL 1.23 ug/L 1 0 N/A
Note:n<12 Chronic: 1 --------------------------
Limited data set
Acute: 67
Zinc NC 50 AL 67 ug/L 1 1 N/A
'vote:n<12 Chronic: 870 data=27 ug/l,no monitoring or hoot recommended
Limited data set
'Legend. "Freshwater/ scharge
C=Carcinogenic
NC=Non-carpnogemc
A=Aestneoc
400rpa2006,ma
6/20/2006

y PUBLIC NOTICE �•
STATE OF ""' '`' `
NORTH CAROLINA wpm/
ENVIRONMENTAL
MANAGEMENT
COMMISSION/NPDES UNIT
1617 MAIL SERVICE CENTER
RALEIGH,NC 27699-1617
NOTIFICATION OF INTENT
TO ISSUE A NPDES
WASTEWATER PERMIT r
On the basis of thorough staff
review and application of NC
General Statute 143.21, Pub-
lic Law 92-500 and other lawful
standards and regulations, the
North Carolina Environmen-
tal Management Commission
purposes to issue a National
pollutant Discharge Elimina-
tion system (NPDES) waste-
water discharge permit to the
person(s) listed below, effec-
tive 45 days from the publish
date of this notice. :"
Written comments re
in
the proposed will
be ac-
( i
cepted until 30 days
afterr the
he
publish date of this notice.
comments received prior to
that date are considered in the .,
final determinations regard-
ing
g .
the proposed The
Director of the .
NC Division of
Water Quality may decide to
hold a public meeting for the
proposed permit should the
Division receive a significant
degree of public interest.
Copies of the draft permit and
other supporting information
on file used to determine con-
ditions present in the draft per-
mit are available upon request

mg veterans."tin
L & J Lawnmowing and
Weedeating Service Call
Joey at 385-9488 or Logan at
ALl9 ae4p..r a:.and payment of the costs of
reproduction. Mail comments
and/or requests for informa-
tion to the NC Division of Water
Quality at the above address or
call Ms. Carolyn Bryant, (919)
733-5083, extension 363, or
Ms. Frances Candelaria, (919)
733-5083, extension 520,
at the Point Source Branch.i
Please include the NPDES
permit number (attached) in
any communication. Interested
• persons may also visit the divi-
sion of Water Quality at 512 N.
Salisbury Street, Raleigh, NC
27604-1148 between the hours
of 8:00 a.m. and 5:00 p.m. to
review information on file. t,`'
NPDES Permit Numb
NC0000400,K-T Feldspar Cor-
poration, Mitchell County, has
applied for renewal of its permit
for a facility discharging treated
industrial wastewater to the
North Toe River in the French
Broad River Basin. Currently
jN fluoride and total suspended
solids are water quality limited.
This discharge may effect the
:' future allocations in the portion
of the receiving stream
#5606-5/17/06
{� Nalyr aft
•
105 Announcements
Free Gospel Tapes - Write to:
Caleb Yarborough, #35 Look-
ing Glass Drive,Burnsville,NC
28714.6-7
Build it and he will come,and

KT Feldspar Corporation Instream Data(2003-2005)
Date Ups Fl Dwn Fl Ups Turbidity Dwn Turbidity
Apr-03 0.33 0.48 9.2 8.7
May-03 0.28 0.46 6.5 7.1
Jun-03 0.41 0.76 5.6 6
Jul-03 0.55 0.78 11.2 11.2
Aug-03 0.54 0.68 16.4 16.6
Sep-03 0.543 1.16 4.7 5.1 Da. Max. Fl value 2.98 mg/I
Oct-03 0.86 1.22 2.2 2.4
Apr-04 0.5 0.77 7 7
May-04 0.66 0.77 6 6
Jun-04 0.63 1.38 12 12.3
Jul-04 0.65 0.83 7.5 7.5
Aug-04 0.74 1.18 6.7 6.6 Da. Max. Fl value 1.98 mg/1
Sep-04 0.27 0.39 9.5 10.1
Oct-04 0.288 0.479 3.6 4.1 Da. Max. Fl value 1.97 mg/I
Apr-05 0.39 0.55 5.6 5.9
May-05 0.37 0.72 4.2 6.4
Jun-05 0.28 0.562 15 15
Jul-05 0.41 0.43 16 16.5
Aug-05 0.63 0.76 18 18
Sep-05 0.67 0.9 3.1 3.3
Oct-05 0.73 1.25 6 6
Ups 100 yards ab Plant Discharge
Dwn 100 yards below Plant Discharge

Instream Turbidity Data from Mines (Comparison)
Date Unimin-Schoolhouse Feldspar Corp K-T Feldspar Unimin-Quartz
Up Turb Dwn Turb Up Turb Dwn Turb Up Turb Dwn Turb Up Turb Dwn Turb
Apr-04 19.6 17.8 5.09 5.21 7 7 4 9
May-04 7.6 9.8 7.45 7.5 6 6 12 13
Jun-04 15.3 16.3 22.96 22.43 12 12.3 20 17
Jul-04 8.4 9.7 11.16 11.06 7.5 7.5 10 10
Aug-04 7.5 6 4.78 5.42 6.7 6.6 10 8
Sep-04 10.1 9.8 13.72 14.16 9.5 10.1 18 17
Oct-04 2.7 3.1 4.33 8.56 3.6 4.1 4 3
Apr-05 3.6 5.1 6.4 6.96 5.6 5.9 7.1 5.3
May-05 7.5 4.9 8.4 9.41 4.2 6.4 6.4 5.5
Jun-05 18.4 24.3 18.3 10.3 15 15 44 39
Jul-05 11.9 14.8 22.11 19.24 16 16.5 33 28
Aug-05 10.9 14 11.22 37.27 18 18 22 17
Sep-05 3.6 3.5 3.66 3.78 3.1 3.3 4.04 3.8
Oct-05 2.5 1.9 3.2 3.77 6 6 3.2 2.9
Year 2004-June 2004,turbidity was exceed both upstream and downstream of all mine discharges
Sept. 2004 exceeded at two discharges, ups and/or down exceeded at two discharges
April 2004- Schoolhouse exceeded ups and down
July 2004- Feldspar exceeded up and down, 11 NTU
Year 2005-June,July, August 2005-turbidity was exceed both upstream and downstream of all mine discharges
No exceedences the other summer months,Apr, May, Sept, Oct.

v -
0,1
8/19/05
NCDENR
Water Quality Division
2090 US Highway 70
Swannanoa, NC 28778
Ref: Renewal application for NPDES Permit NC0000400
Enclosed are copies of the renewal application for K-T Feldspar Corporation water
permit NC0000400.
There have been no changes to the facility or the water system that would affect the
current or past permit requirements. We request that the parameters of the current water
permit remain the same for the forth-coming water permit.
I have attempted to the best of my knowledge to complete the renewal package accurately
and completely. If there are any problems or questions please contact me at (828) 765-
9621 ext. 14.
Sincerely,
,r J
w
/
ames W. Thomas
K-T Feldspar Corporation _,
%` i1
- - --'
,,. , -) 11;,,1 AUG 1 9 2005
. L ____I
AUG 2 5 2005 WATER(DU' ' - ION
pC, iT S:L.,,.- i ;H
•
K-T FELDSPAR CORPORATION
P.O.Box 309-Spruce P,ne-N C 287774,,--, 3 member of
PHONE:[phone] - FAX:[phone] - WEBSITE:www.k-tclay.com I M E R Y S

. Please print or type in the unshaded areas only
• (M-in areas are spaced for elite type.i.e., 12 characters/Inch). For Approved. OMB No.2040-0086. Approval expires 5-31-92
FORM U.&ENVIRONMENTAL PROTECTION AGENCY I. EPA I.D.NUMBER —
I ��1EPA GENERAL INFORMATION s T/A
Consolidated Permits Program F D
• GENERAL (Read the'General Instructions"before starting) 1 2 13 " 14 15
LABEL ITEMS GENERAL INSTRUCTIONS
L EPA I.O. NUMBER If a preprinted label has been provided,
affix it in the designated space. Review the
information carefuffy if any of it is
T kisp/92 C
incorrect cross through itp and enter the
UL FACILITY NAMEK. h2 p(L14�tcM correct data in the at propriate fill-in area
below.Also,if any of he preprinted data is
absent (the area to the left of the label
V. FACILITY PLEASE PLACE LABEL IN THIS SPACE space
appear), information that should
MAILING UST PO Bbk 369 SA�u.c€ P /7 in area(s) below.providef thI be eis�commpplete
i ' KJ� zS�'I and correct you need not complete Items
I, Ill, V, and VI(except VI-B which must be
VI. FACILITY completed regardless). Complete all items
if no label has been pr.proved. Refer to the
LOCATION instructions for detailed item descriptions
SipR k� Pf �b and for the legal authorization under which
CRO r Nf}- this data is collected.
II. POLLUTANT CHARACTERISTICS
UCTIONS: Complete rough J to determine whether you need to submit any permit application forms to the EPA. If you answer"yes`to any
questions,you must submit this form and the supplemental from listed in the parenthesis following the question.Mark'X'in the box in the third column if
the supplemental form is attached. If you answer"no to each question,you need not submit any of these forms. You may answer no if your activity is
excluded from permit requirements;see Section C of the instructions.See also,Section D of the instructions for definitions of bold-faced terms.
SPECIFIC QUESTIONS MARK+� SPECIFIC QUESTIONS MARK"X"
FORM YES NOFORM :
YES NO ATTACHED ATTACHED
A. Is this facility a publicly owned treatment works B. Does or will this (adiity (either existing or
which results in a discharge to waters of the ❑ x El proposed) include a concentrated animal ❑ E ❑
U.S.?(FORM 2A) "`x� feeding operation or aquatic animal
-- 18 17 18 production waters of thefacility
U S.w?(FORM 2B)ich results n a discharge 19 20 21
—0. Is this facility which currently results in D. Is this proposal facility(other than those described ❑ ® El to waters of the U.S. other than ❑ ® M A or B above)which will result in a discharge
those described in A or 8 above?(FORM 20) _ 22 23 24 to waters of the U.S.?(FORM 20) 25 26 27
E. Does or will this facility treat,store,or dispose of F. Do you or will you inject at this facility industrial or
hazardous wastes?(FORM 3) ❑ WI ❑ municipal effluent below the lowermost stratum ❑ ® ❑
�U
containing, within one quarter mile of the well
bore, underground sources of drinking water?
28 2B 30 (FORIA 4) 31 32 33
G. Do you or will you inject at this facility any H. Do you or will you inject at this facility fluids for
produced water other fluids which we brought to special processes such as mining of suffer by the
the surface in connection with conventional oil or ❑ LN ❑ Frasch process,solution mining d minerals,in El (�
El�l ❑
natural gas production, inject fluids used for situ combustion of fossil fuel,or recovery of
enhanced recovery of oil or natural gas,or inject geothermal energy?(FORM 4)
fluids for storage at liquid hydrocarbons?
(F�4) 34 35 36 37 38 39
I. this facility a proposed stationary source J. is this facility a proposed stationary source J,
which is one of the 28 industrial categories rased which is NOT one of the 28 industrial categories iK
in the instructions and which wit potentially emit ❑ El listed in the instructions and which will potentially ❑ ❑
100 tons per year of any air pollutant regulated emit 250 tons per year of any air pollutant
under the Clean Air Act and may affect or be regulated under the Clean Air Act and may affect
located in an attainment area? ORM 40 41 • 42 or be located in an attainment are? ORM 43 44 45
III. NAME OF FACILITY
cSKIP
1 K- T rC lc.JspAk_ (1,2 -)
15 1629 30 1)0
IV. FACILITY CONTACT
1111111..
A. NAME&TITLE(last, first, &title) B.PHONE(area code&no.)
C
2 ThcmA5 t-- TArries SR . 7(Q
/eEluw ,LI,�I t'r.. 82.8 S` 942.1
15 16 45 48 48 49 51 52 55
V. FACILITY MAILING ADDitEssillillilliMmummummis
A.STREET OR P.O. BOX
c
3Pc Eck 309
15 18 45
B.CITY OR TOWN C.STATE D.ZIP CODE
4 SFPWF Put-+ NL Z11
15 18 40 41 42 47 51
VI. FACILITY LOCATION
A.STREET,ROUTE NO.OR OTHER SPECIFIC IDENTIFIER
5 1.3112_ Sit 22.4c, By-p -ss
15 1e 45
B.COUNTY NAME
in c+ae-1 1 CL1-4f 1
48 — 70 _
C.CITY OR TOWN D.STATE E.ZIP CODE F.COUNTY CODE
15 16 40 41 42 47 51 -i 52 54

_ CONTINUED FROM THE FRONT
VII.SIC CODES 4-d". , in order of. ". "
A.FIRST B.SECOND
7 1 y :O I r ffr) 7 (specify)
i o� 7
15 ,e 17 in d'�rl�ll,„ �eldspArZ 15 16 19
C.THIRD' D.FOURTH
c ( ifY) 7 (sPecffy)
7 7
15 16 17 15 18 19
VIII. OPERATOR INFORMATION
A.NAME B.Is the name listed in Item
VIII-A also the owner?
1�
8 7 2Ias/Al2 C�RpP A7I[M El YES El NO
18 19 55
C.STATUS OF OPERATOR(Enter the appropriate least-Into the answer box, if'Other,'specify) 0.PHONE'area code&no.)
F=FEDERAL M=PUBLIC(other than Federal or state) (specify) C -
SST STATE
O=OTHER(specify) m A D 2 8' 7(05-- q4 z)
58 15 - _ 18 18 19 21 22 25
E.STREET OR PO BOX
?D Bort- 3o9
55
F.CITY OR TOWN G.STATE H.ZIP CODE IX.INDIAN LAND
c Is the facility local on ndian lands?
B SPoeuC,E p,n.e N C715 ❑YES NO
15 16 40 4ie 4 ,
X. EXISTING ENVIRONMENTAL PERMITS
A.NPDES(Discharges to Surface Water) D.PSD(Air Emissions from Proposed Sources)
9 16N 17 NC 0000400 9 P O I2 9 3l 2 0
18 30 15 18 17 18 30
B.UIC(Underground Injection of Fluids E.OTHER(specify) (Specify)
C T 17 18 30 1C95 1 16 17 1 18 30
C.RCRA(Hazardous Wastes) E.OTHER(specify) (Specify)
C T I ' c T 6
9 R 9
15 16 17 18 30 15 NM 18 30
XI.MAP
Attach to this application a topographic map of the area extending to at least one mile beyond property boundaries. The map must
show the outline of the facility, the location of each of its existing and proposed intake and discharge structures, each of its
hazardous waste treatment, storage, or disposal facilities, and each well where it injects fluids underground. Include all springs,
rivers and other surface water bodies in the m area. See instructions for recise r uirements.
XII. NATURE OF BUSINESS (provide a brief description)
7 Riciscr eoa.poa AA-, r- ib A ni IN i t4 m,lI r n5�pitacessm S opea>�4-,ul' Op
Tek15)04/t .
XIII. CERTIFICATION (see instructions)
1 certify under penalty of law that I have personally examined and am familiar with the information submitted in this application and
all attachments and that, based on my inquiry of those persons immediately responsible for obtaining the information contained in
the application, I believe that the information is true, accurate and complete. I am aware that there are significant penalties for
submitting false information, including the possibility of fine and imprisonment. _
A NAME &OFFICIAL TITLE (type or print) B.SIGNATUREC DATE SIGNED
S (,D 7ji0mA5 i _) Li i 7/ZZk5—
COMMENTS FOR OFFICIAL USE ONLY
C
15 16 55
11

rA 1-n-NVMRew(copy i+'oa.feta I or Foran I)I OMB
Please print a type In etre unshaded uses onlyEpA . i+ Approval expires 8-31-98.
FORM ♦� U.a-ENVIRONM PROTECTION AGENCY
2c
APPLICATION FOR PERMIT TO DISCHARGE WASTEWATER
EXISTING MANUFACTURING,COMMERCIAL,MINING AND SILVICULTURAL OPERATIONS
1tPDES Consolidated Permits Program
L OUTPALL LOCATION
Fa each outfall,list the latitude and Longitude of its location to the merest 15 seconds end the name of the receiving waw.
r a e.LATITUDE
NUM NCR
C.LONGITUDE
Mgr) w.est.. a.INN a.e.c. I.nae. 4 i rue. 3 WM. O- RCCEIV LNG teems.Memel
/03 35° SS if 9" YZ` 06 13" AJoekilATi- 1i/r2.
Il.FLOWS,SOURCES OF POLLUTION,ANO TREATMENT TECHNOLOGIES
A. Attach a line drawing showing the wet r flow through the facility.Indicate sources of Mak*wear.operations contributing eeeetaweter to the effluent,
and treatment wefts libeled to ow,sepond,tri due Rare detailed descriptions in Item B.Construct a wear balance on the fns drawing by showing average
flows bemoan intake, ao«stismk.,:tmateneint anla end outtalk. If a water balance cannot be determined k far arse l mialag acd diad.provide.
pictorial d.oription of the eabwo and amount of any Imams of wear and any collection or treatment measures.
B. For each oltf.B protide a description of: to All operations contributing wastewater to the effluent,including process teestawagr,aennery westewitar,
cooling water.end storm wear runoff;(4 The sanrage flow contributed by each operation;and C31 The treatment mashed by the westaweoar_Continua
on additional sheets If necessary.
I.OUT- >R or*Rwr$oaef$I cONTRIaUr,No'tow
3.TREATMENT
f ALLN4 .
(11.9l O ENArsON(MO ( �t-ftJ w a IDESCrtrrTlON b.t rsT TA `Eac IRON
103 tees o-C' � kis pf� �/�r7&D L,
•
Orr CIAL U a .NLP e • r Lkfl re.AlmITIPP
EPA Form 1510 2r (s .ti • s ?' r 73 f1

to 1 NUE!) ROM R a
off,leeks.or spills,
C.Except for stormvlete the folloarina was.) in Items Il-A or B intermittent or seasonal?
MHO(M to deetiow III) .
3.FREQUENCY 4.FLOW
I.OUTFALL Z.OPER ATIONts)
NUMBER CONTRIBUTING FLOW • DAYS b.11401,47143a.Pt$w RATE la TOTAL.voweesl
(fLtff t� PLR WEEK PER YEAR
as stied) (+Wed1Y WA gnaw
�1eee) f>Pe l� AvwA•e acme TE01.1 a.MAX/6114111t.tame tswaa a.rAtswtaar ATION
�rV 1 •Aat.• aeInA•• oAw,• an days
Nln
RC PRODUCTION
A.Does aneffluent guiddias limitation promulgeted by EA ttsdsr Section 304 of the Clean Water Act apply to your fscility7
Writs(ceavleee Ileal W )'
IL Are the limitations in the appficabie effluent guideline�d In terms of ❑No(es to Section IV)
CI Yaw f oat$ate Itetw ID-C)
production for oilier eyesore(toto of q,, IV)
C. N you antwaered"Vie'So_ NO(So to Section IV)
used In the�icaaa effluentguideline.a d Intimate the efIectsd anises_111-11,Nat the quantity which represents an actual measexement of your
of production, in the teems and units
1-AVERAGE DAV PROOR)CTION
R wwa•a••Flaw 1.w• h.arwrra w r - L AFFECTED
aA•uwt C.• a•Atf•n,Pn•wC•,MA••wiAI,••c. OVTPALLs
(eDecll'7) (ant oartfoll Rant bars)
PIA— Nle
•
IV-IMPROVEMENTS
Ara
A.
�ow rewired by any Federal,State Or focal authority to meat
any inlpterrtermay t schedule for the construction,
but r not limiteentd sK Practices or any Whoa environmental programs which may al f ect Me discharges upgrading or operation of waste-
or leen cond<tiorfs. permit OOnditiwn,administrative or enforcement Aden,enforcement described in this application?This includes,
compliance schedule letters,stipulations,court orders,and grant
Ovas(e•ttpirer Bae following Wag) K no(go to It,,,. iv-a)
t•spasm Pic ATton or conorrson. L ArrirCTED OuT/ACCs
AO REiae['N7 ETC. ]_enter DantIT10N OF MOJ iCT
3C4. P[NA CON
e .
.• salaams w d
•reawe•• FUANCrDATt
a_
/ •Ytw■Feo CTrru
NFt- .
9. OPTIONAL You may attach addltionsl shoats
planned R#»dulea.04 now have underv�y Or spion. Idaacrigigi any ndicate
dica water pollution control programs/a other
ay Or planned,and
which may•aart
Ion
have
t� -,` ;, „ whether each program is now underway a planned,end ind.ata your actual a
MAIeK"7L�, tsCR1LTlON or ADDITIONAL CONTROL PROGRAMS 1111 ATTAC1410
FPA Form 3670-2C(Alva 2-85)

• ••••--
A 1.0.MUSHIER(copy from am 1 of Forma 1)
• CONTINIXO-FROPA PAGE 2
cHAacTnssiics
A Ile • • beton,proceeding—Complete one sit of tables tor esch outtell—Annabel.the outtaftWumber in the specie provkled.
7•T •ttelyc•O•Tass V-A.va.end V-C are included on separate sheets numbered V-1 through V41.
•.•
-0.Atee the!pew osioveto list any of the pollutants listed In Tabk 2o3 of the instructions viikft you know or have moon to believe Is discharged
discharged from any outfall. For every pollutent you list.Iniefty dew:nbu tho nwoons yo believe It to be present and Mott anY analytical
YOttr
I.
permeation.
POLLUTANT S.SOURCE II.POLLUTANT S.SOURCE
NI) iiihd-Ads 145/ezi
7? •Mbie 24.-3 ARE
6.10.4)U 40 Be
disciw6Kti I .
A "PPR ji4.4
evelductEct ix, /cot
(0,11 be IAlCJLzdJ
iffs-1/4-
ppl Ur%
In.POTENTIAL DISCHARGES NOT COVERED BY ANALYSIS
Is wry poilutant listed in Item V-Cs substance or.component of a substsnal which you currondy use or nissulochwo as on inesensodselle productor -
*produce . .
IX]TES abe aN sac*potiutonet below, ON°(to to bon WS)
ciegitx. GIG,1141- t )
_ice L. 7440-0 2-on )
7-146-
ZA-rtkurv.
EPA Form 510-2C (8-90) PAGE 3 OF 4
CONTINUE ON REVERS'
3

CONTINUED FROM THE FRONT
VII. BIOLOGICAL TOXICITY TESTING DATA
You Mtrr any knowledge or reason to believe that anyYkaf lust Yo d le Ior-oti a.
•
receiving weber in relation to your dtsdierge within the last 3 years?• - - btll�
MMES(Identify the tertle)and deacribe Omit-purposes below) - - ONO tlfc.elf Bretton vllty •
A used-eatr tok,coh 15 cinch-Ida/ aye eRlued- ditc-lia/26,e. (o all (03) ;,
.110
/JoR TOE le west - II Ef rue col-) -roam fiT--1 Re,oca aIv oluic PEG/co.
l9c4e Lc. So " t s sc.bp+ I4kd
•
610hs5,1 - C. Jut)Ili Pd5S`Fr9(I CRan
CJe`r 6-17e,7 d,ly
e_klIona t lee
VIILCONTRACT ANALYSIS INFORMATION
Were arty of the.anetyses reported in Item V perloripred by a centred laboratory or oonsuiting firm/
Qvas(tint the name,addros,ow(Ielepkorsr ess000sof wdpoitubwh No(go to Seetlon JZJ
analyzed by.each such laboratory or Pow►slot!
•
A.VAMC aL ADOREia I -?ELI HZSNE D.POLLUTANTS ANALYZED
` (aura code! NaJ Bis()
Ix.CE R I I F IcA t t(NNg
I certify under penalty oflaw that this document and a//enrichments were prepared under my direction or supervision in accordance with a system designed to
assure that Ovalifnedpersonnel properly gather and evaluate the information submitted.Based on my inquiry of the person or persons who manage the system or
those parsons directly responsible for gathering the information the information submitted to the best o/myknow(sdge and belief.true,accurate.and complete
1 am aware that there are significant penalties for submitting fah*information.including the possibility of fine and
hipriso+vnerN for knowing vro(atiorts.
A NAME & orrictAL TITLE((ype or puny) e. PHONE NO.(orae code i no.)
T m e S GJ - nurn,4s Sia�J Em.) .�><� b i_2 V.70 7G C-96 2
C SIGNATURE ----
D, DATE SIGNED
C alis/U

PLEASE PRINT OR TYPE IN THE UNSHADED AREAS ONLY. You may report some or all of [OA I.o.fvuMrcR Dopy from Item 1 of Form 11
hlr Information on separate sheets(use the same format/Instead of completing these pages,
SEE INSTRUCTIONS.
' v
_ C`.T .. -c • ' S t .. , ,,y, 1J' <0..r. 2.('I
�_.____.. ._-___��.___-•_,•:'. ,5 I•l'i .., t: deal ,tis 'Jr every pol;uiar't In leis table Complete one table for each outfall See instructions for additional details. _— --
2. EFFLUENT
3. UNITS
POLLUTANT •. MAXIMUM p A 1 L Y VALUE p p� • • • • 4. INTAKE f o p r r ut l a l l
b. MAxlat 11 auolla bf•JY VALUE aua a• ♦ •
s hatcl(y if blank) JJ
I'I (�I(! d. NO.OF a. LONG TERM
h) rAaa (•I ANALYSES a.CONC[N• AVLhwGj VALUE b NO Or
tanunre�_Tlpn, 1'1 WAS. co«caw�rhArl el, S•nt[hT1ATIa 1' rA••
"I ) TRATION b. MASS (,) ANALYSES
�+ 8oc r)amlcal II • co«ca«rw Ar,o«, 1044A1.1
BOD)" O•m•ntl NDT D�.'iPG4-ed Qa � (
b. Chemical ? 1- �L 1+60e A f-11`( G( 12 -`�-IYI� GA1 r,l /r�L.
(COOxyD) Demand 6 I fL !
rcoD) (ray �n��L
c. Total Organic
•
Carbon(roc) 2. Z/TiL • /./ `!L
d. Total Suspended
4_
8olltls(1391 7qo n,�l1, I,Og_o)bs 132m1L
� •, 2(03 lbs 71 mi/,4 ►9y /175q m9/� Par.trY ,ls
a. Ammonla(as N)
VALUE `VALUE -
r C ^
Clew p, 9�(2 m�Q b.y1S mGj� VALUE ,3�9 /•rC7VRr ��S�J m�7(✓ VALUE
a. Temperature VALUE VALUE Qla _
(winter) VALUE
VALUE 7 '7 3 /Z d� ' O� VALUE
IS, Temperltvr• VALUE VALUE
(�
:surRrnerl r] / VALUE
ff •
C
DI►!A
•
MINIMUM MAXIMUM 'MINIMUM MAXIMUM �S
01-1
c
6 •0Z /C�•n r7 G.02_ . 5'7 cr 7~ STANDARD UNITS
_ . I. IHNHI,
'AP' B • Mark "X"In column 2.8 for each pollutant you know or have reason to believe Is present. Mark"X"in column 2.b for each pollutant you believe to De absent. If you mark column 2.for any pollutant
which is limited•rther directly,Or Indirectly but•xoreasly,in an•fluent limitations puldelin•,you must provide the results of at leaston•analysis for that pollutant For other pollutants for which you mark
oeium.n 2a,you must provide quant,tative date or an explanation of their presence In your diacharga.Complete one table for each outlet' See the Instructions for additional details and requirements.
POLLUT• T2 MARK 'x
ANT AND 3. EFFLUENT
CAS NO. . aa ��d��a ••- a. MAXIMUM DAILY VALUE b. MAXIA(�M i V VALUE C.Lt3Nt3 T M 4. UNITS
' T ADte, .a. ^w I bd p/� R �[VR VALUL S. INTAKE (optional)
id «,.� I 1 auaflogreJ �J oua/lable�• QNO. O/ a L6�r G T[RM
aa«r o•.cal.Iw A r.o« I�) MA" (,) ANAL• a. CONC[N• AVERAGE VALUE
b. MASS • NO.OF
co«c• ,ow co«c AAAA+e« Ill •�Aaa yfE$ TR ATION UT
ANAL'
F]rom,d• \ / Ce«c•«rw Ar+o« ',INA,' YSES
:4969.67.91
Chlorine,
otel ftstldual
Color k
Fecal `
:oilform ..„,4.
?r!
)_
>. Fluoride 5�.(� SIL 233 ► s 33m�/4 r.R',SOB aaa�) !2 /6SZy l� Gy /6s _�al /� �S N
,toils(as N)
•
EPA form 1510.20 IS•90) PAGE V•1 .L:.
CONTINUE ON REVERSE

i fkM Y•b CQNTIN41E0 FROM FRONT
!"OLLUT• 1. MAwt4. 'x ••
NT AND 3. SFFL11[NT
CAS NO. .ori• ivio I. MAXIMUM DAILY VALUK b. MAXI M I• 4, UNITS S. INTAKE (npnnnal!
V vALUtt o.LONti T M
(ll ai•allab4) .�:i .aai 0. f�Ylt•.VALU[ tl. HO.Or �pNp T�
c....w�.,or. I�) •• COMC�Mlw,.�lOq 1.1 ..wu ANAL• �. CONCRM• Aei LK G[ V Rll,,��
cow �.. TPATION MAS! A AL(,K •.NO.OF
•
Tr.its; Oq•n, IHREIESI+) ..�.. YS[S ANAL
74tai Orpan�c Irl M... rift
a.N)
h Alt and0 moo
4
-�_
L hoop • s .
lasfj, Total \/
(773.14.0) 'x`
MI
1. Rad)aaottvlty
(o
Total
2) lista,
Total
(3) Radium,
Total k
•
14) Radium
226, Total
k.COCK*
IM SO4)
,14609.79.8)
i. urfklis
fi) .1111
(as el
m,SuHtt•
v 803)
14266.48.3)
• Surfactants
).Aluminum, 1111 .'.
�rota1 4/
✓ rn3/4 VAkAaaN (�IKedan Auay
1r
f.29.9a6) 4.SrA5li— 12 16 S
ig/� 5i. sr um,
oul
XO. �41 (,ytknOWr't 8 • .m p
1111111.111
7440.39-3) i b.o41 � ' 1• P e�F nil- �t►t,c$
•
ot.,
'440424)
Cobalt,
oul
•440_46.4)
Iron, Total
'43949-6) (X\
Mil ,..
)tai X
419.98.4)
V o l ytatl•nu m, am.
;al ��.
1111111111111111114.39.96.6) X
Mill Total
44
0.31.6) .--
Titan urn,
til 11111-
440•2-6) ■U
EPA Form 7510.2C (8•90) PAGE V-2 �
-

(PA I.D.NUMBER (copy jrVm Item 7 of Form 2) OUTFALL NUMBER
CONTINUED FROM PAGE 3 OF FORM 2-C • l 03
—
PART C • If you are a primary industry end this outfall contains process wastewater,refer to Table 2c•2 in the instructions to determine which of the GC/MS fractions you must test for.Mark"X"in column
2-a for ell such GC/MS fractions that apply to your industry and for ALL toxic metals,cyanides,and total phenols,If you are not required to mark Column 2.a(secondary industries, nonprocess
.vastewarer curtails, end nonrequrred GC/MS fractions), mark"X•'in column 2-b for each pollutant you know or have reason to behave is present.Mark"X"in column 2•c for each pollutant you
be..eve is absent If you mark column 2a for any pollutant,you must provide the results of et least one analysis for that pollutant.If you mark column 2b for any pollutant,you must provide the results
of et least one analysis for that pollutant If you know or have reason to believe it.—ill be discharged in concentrations of 10 ppb or greater. If you mark column 2b for acrole n, acrylonitrile. 2.4
din tropnanol or 2•methyl 4, 6 d nitrophenol, you must provide the results of at least one analysis for each of these pollutants which you know or have reason to believe that you discharge tn
eorcentraIions of t 00 ppb or greater Otherwise,for pollutants for which you mark column 2b.you must either submit at least one analysis or briefly describe the reasons the pollutant is expected to
be d scnarged Note that tnere are 7 pages to this part,please review each carefully.Complete one table(all 7pages) for each outfall See instructions for additional details and requirements
I. POLLUTANT 2 MAwK .x-
3. EFFLUENT
AND CAS Ayq 4. UNITS 3. INTAKE (vpnoncll
•,••• tl ••- L •• b. MAXI M a Y YALU[ C.LONO'r a O11a D1f• VALUE
NUMBER •
„41•' ,•v•ali•v•. a. MAXIMUM DAILY VALUE ,U,9,�rd NO.OF • LONG TERM
(!/oyciiabl•1 •��•• i�r•i• •ia• ISI•
ANAL,
.T.
CPIONCtN• b NO Or
III 1 CONC•AAAAt,or C4rrCeM'Tr1A1LQA Irl rte•• -h£ftiL)1•11g1 Yf[3 TATION b MAfa ANAL
YSCa
METALS,CYANIDE AND TOTAL PHENOLS
1 M, Antimony, /
Total(744pJa O) ,/\1
3M. Arsenic, Totals
17440-38-2) X(
3M. Beryllium,
Total, 7440.41.7)
4M, Cadmium, 1/
Total(7440-43.9) 'y\
6M.Chromium,
Total (7440-47.31 )(
4. Tout
To
(7
(7444 )7
(713 -12.1)ast /
nu4•u•1) X
BM.Mercury,Total ` ,
(7436-97.6) X
DM.Nkkal, Total' ""on AveAvg M1`i
(�..oaaoXl n.02.6 0314 ' ' aozon�/e <1.o� 01511— P«u
rods
tielenlum, ` /
TegC(7762.40.2) /X\
11M31lver,Total.
(.1.”514-X÷4)
r,
12M,Thallium,
Total(7440.28.0)
13M,Zinc, Total
17 440-641-41
14M;Cyanide,
l Total(67.12-6)
15M:Phenols, I • .
•
Total
;f
DIOXIN
1.3,7,6-Tetra- D[SCRIaE RESULTS
•
.;hlo(odlbens.o-P-
UIQX
l++(1764-01-6) _ ,'
EPA Fora 3110-2C (6-110) PAGE V-3 CONTINUE ON REVERSE

CONTINUED FROM THE FRONT •
I. POLLUTANT I.MARX 'X'
AND CAS 3. EFFLUENT
NUMBER !ya h V•• ••• I. MAXIMUM DAILY VALUE b MAXI M ]d p�Y VALUE c.LONQ T MUNITS S. INTAKE u
' '" •ui•v•• Qab �/R VALUE ( Prfonc!)
f!/ou•i(ablrl "• " • , bl Q '0 01 a LONG TERM
co co..c•( I ,o" (+I r••. NNW, AwAL• 4 MASS
b. MO Or
OCASS FRACTION —VOLATILE COMPOUNDS Id r"•• IIINIMMI (+( r•.• vies TAATION ANAL,
(di.wr oww- (II `+••• ries
(107-028) /y1
2V.Acrylon(trlla
(107.131)
3V.Bataan• X
(71-4,12) 1 •
4V. BIS(Chloro-
methyl) Ether \`
(542-88.1) !1\
5V. Bromolorm \,
(76.26.2) x
8V.Carbon
Tatrachlarld• �/
(56-234) 'A` /
7V.Chlorobanzena •
(10840-7)
Elly.Chlorodl•
bromomethan•
(124-46.1)
V. Chloroathan• X
(76-00-3) `
,OV. 2-Chloro•
•thylvInyl Ether
(110-75-8)
`
•
11V.Chloroform
;87.66.?)
12V. Dlchloro-
oromomethana �/
(75.27.4) y�\
13V. Dlehloro-
dl}tuoromaMane
(75.71.8) ?c' I
14V. 1,1-Dkhloro.
•
I ether*(76-34-3)
•.
15V, 1,24D(ohloro-
.thans(107.06_2)
•
'DV. 1,1•131chlor0.
m, 1
ylene(76-36-4)
!7V, 1,2•Dlahloro-
X
'ropana(78-87.6) •
INV.l,3-0Idyory.
w+•rt•(54.2-754)
•
1GV, Ethylben[eM
100-41-4)
•
20V. Methyl
3romlde(7443.8)
2W. Matttyl
Chloride(74$7.3) X----
-
EPA Form 3610-2C ($.90)
PAGE V-4
CONTINUE ONAF7y:(

.ONTINUEO FROM PAGE V-4
1, POLLUTANT 2. MANI4 'K'
AND CAS 3. EFFLUENT UNITS S, INTAKE
b. 1a Axlt�u M 3pp DpA,�Y VALUE c,LONb T M VALUE /optional]
NUMBER '! ' •• � •a• I. MAXIMUM DAILY VALUE [LIM 3lablr
(i/suaiablr " 1 �(a�ailaple� ti NOOF •. CONC[N• • LONG TERM p NO OF
j •VIA- ii hr ,twT ('1 ANAL• b MASI AYIRAGj VALUE
LCI (_ ca..c■hri,w T,oh[_ (a) rA•• GQhC{hlT{ATIOh (.) rw{• COhc{nr){•tioh (1) rw{• 'rf[L 7RATION (i) colic•.,• I,) uw•{ ANAL-
VIES
3C/Mi FRACTION - VOLATILE COMPOUNDS(continued) rA r.oh •
22V.Methylene
ChSride(7640-2) 1
V 1,1Tetra
1
(70J46) x
24V,Tetreehloro
ethylene(127.16-41 )Cr ' , .
[254.Toluerw -
(1a1iL-0)
i 26 w
1i.'1 •Trer1 l .
(16640.5) •
chbrogthar, X
(71-66•{) _ j
28V. 1,1,2•Trl-
ch breethan• "
79-00-5)
X , • .
29V, Trlehloro•» 1/
Tthyla (79-01-6) !J(\
)OV,Triehloro- } ,
'worometharm X
76-80-4)
11V.Vinyl �/
Chlorkie(76-01.4) !/l`
3C/MS FRACTION -ACIO COMPOUNDS
1 A.2-Chlorophenol �/
95-57-51 /�
2A.2,4•Dlnhloro• l/
ahenol(120.83-2) /,[\
IA,'2,4Olmethyl-
.henOt(106-07.9) X
. ,
CA.:S,4-D I n kro•O•
,r sol(534.62.1)
1 A.'2,4-O In po-
Mwr �/ ,
))Mewl(61-28.6) liX\
, a
A.2•Nitrophenol V -
A.88454)
•
4-N ltroph.nol !X`
100-02-7)
•
A.F Chbro-M- l/ '
0141(69-60-7) ,,}(\
h,k:-Pdnteoh lora
1'?o"yk.
f.. ' 6)
x
t •: Tri-
h :rflt. ' •1 [
.Ir. v FX
PA Form 1510.2C (8•901 PAGE V•5 CONTINUE ON REVERSE

CONTINUED FROM THE FRONT
I t, POLLUTANT! 2. MAeeK 'X' ), CFF
AND CAS LUENT 1 n
UNITS S. INTAKE loPIInatJ
NUMBER •t"• h •.• C. ••• •. MAXIMUM GAILY VALUE I. MAxIII M 1 ob^eY VALUE C.LON6T �Jl1tl �t pQ
-a ,.�•a�,.� /( b! J aua�a Dl•J �A I
rl NO OF • LONG TERM
(ii avoidable) "` ••' CONCEN• 'b. NO OF
ovi• .i.",t ..wr ( ) c win"Tion "�• •TRATION MASS 1,.'NATION wC•w ANAL
ANAL b
rn CowC•OT TT NDS• 11) ""�' QI•c1 1 1+1 r.." Co'C•.al•AT,ow lel rSCS hi w"•• YSES
GC/MS FRACTION —BASE/NEUTRAL COMPOUNDS *law
1 3.n2.9)
M X
lea- •sa)
28.Acansphtylan•
F(206-98-8) )(1
38.Anthracana ..��
(12012.7)
`46. Ban22dlna '
(92-87-5)
68. Bonze(a) —
' Anthre+cano
(56-66-3)
68. Bonze(a) r
Pyrona(50-32-8)
r4
18.3,4-BoS.-
S.- L .-
f1uOrm•1thaM
r
(2015-912)
88,Banzo(gni) ` .- - —
Poryloi•1a JCA/, —
`191.24.2)
De. cyto(k) 1/ .- ,
Fluot•ranthan• X
(207-08-9)
105.Bb(2•Chloro-
•theory)Methane
•
1111.91.11
1113.BIE(2-Chloro•
ethyl) fithor
(111414-4)
126 611 f2•CNar+raa
yrol0 Etfw(102.60.1 X.
138.Sia(2•Ethri•
hazy!)Phthalata
(11141.7)
14g.;4 eromo- X
1
ohaltyl PhanY( •
Ett$4;101-66-3) " ,
1511.lutyl Batzyl
PhtIl 6*1i6-6e1 •
laii16Cgbro-
1
X
Vlaanyl
t 72-31
2184141,
165:4314enzo(ads)
1neliriaoa
53.743) ' •
(08.1,2-D ich loro-
+an2ana(96.60-1)
118, 1,3•Dlchloro•
__ : . - .
Arizona(611.73-1 X li 1
1
11
I
S .PAGE V•• CONTINUE ON PAGV7PA Form 3510-2C (i-90)

CONTINUED FROM PAGE V-6
I. POLLUTANT I. MARK 'x'
AND CAS 3, EFFLUENT 4. UNITS
NUMBER 066 T a ac' [ a`• S. MAXIMUM DAILY VALUE b. MA7t Ir.1�M ]p D�Y VALU[ C.LOMQ 1' M Ay 5. INTAKE 1.,prioncli ,
I °vcil°b t1 �r fl yrp. YALVE ,l No Or
(!/i�el!°blr/ �`.• •::• .:�. 11 1 OV° ° t a. CONCEN- • LONG TERM
��� co�c•vTw Al+or I+I r..� 1�1 - ' ANAL• b MASS
AVERAGE VALUE b NO OA
[owca+.r�At+o� I+I �'��' CUMta I I I+1 106.6♦ YSES /RATION (�) co..c•. ANAL
OC/MS FRACTION– BASE/NEUTRAL COMPOUNDS(continued'L._....._._.______:
°" I+� MASS YSEs
I 1w ATlOn
, 8., 1,443 Ichloto-
I
,040.A4.na 006-46-7 !)(\
4 7.4r3`p 0* . X
1pA yl
ItIlr te X
Pir
.X
.4.71,11O2,4-0 Mitre-
le/r0.0;(121-14-2)
0e946-, Dln leo-
,
tpluana(646.20-2)
Phthalate Ir. O°"'' `
(11744-0)
308.1.2-01Phany L
hydraalrt•.(ar naAcro• Y
bern•)(122-66-7 '/1\
,
31 1,..Fluonnth.n•
(206-44-0)
324.rluatone \ -
ill 643-7) . X
J34<1iwrAnlDwr+, V
1144) '
348.Hear
ohlotebutadlen* - y
1 (87-68.1) ll/\`
368.H•ucaohloro- 1,
eyo lope ntad l ena 'Jly1
(77-47.4) /'
368. H•xaohloro.
mane(67.72-1)
372. Ind
(1,2,3-ed) Pyran•
1193-39-5)
388. Iaophoron• (,
(78.59.1) 1y\
398.Naphthalin• f/
91.20.3) X
408. Nitrobenzene /
98-96-3) f�11 —--__,
418.N-Nitro• /
sodlmathylamin• .IX62.76.9)
42B. Nylaminodl.
X
621-64-7)
PA Form 1510.20 (140) PAGE V-7
CONTINUE ON REVERSE

CONTINUED FROM THE FRONT
I1, POLLUTANT 1. MART( 'x'
AND CAS 3. EFFLUENT 4 UNITS S, INTAKE 1
NUMBER •••t h ••• c •c• b. MAXIMll�1M p p/�V VALU[ '0.LONG Y[ (r7prirtnoll .J
SRV• i•v•o •' MAXw UM DAILY VALUr (I uua!!a b(fJ M VALUt d.No or
` (f�ouG""��"'` a CONGEN• • LONG TERM D NO Or
,If available) I•�ow mot .:,;. •i w. I���Iw, 1
1 eo..c• •,o«` It) •'w•• cowc•«>•Iw�r�o« UI �+«•• (�l Irl ��•• VSES ANAL-
TM AT D. MASS AVERAG€ YAVVE y ANAL
aCAWS FRACTION —BASE/NEUTRAL COMPOUNDS(continued/
COMC•" o«' "«"« Irl ".•• NSEs
tw AtlO«
4.38.N-Nkro-
•od Iphsny I.rn In. y
;88304)
\/,
441.PMrt.nthnn.
(56-014) /)(� : 4,'
' :
i t Z9 Qpa) 'X\ I8145
ohlorodainserto
I.
�12w3/ ,�(\
OCIMIIPRACTION—PESTICIDES '
tr .
?I X
2 i
' C x84441)
V C k31 7)
til. -BHC 4
6. 9"9)
SP.a-BHC
SP,CAloro.n. ,
167.74.9) /�/l
/P.4,4'-DDT
50-29-3)
7246-9) I X
°,4,4'.-00 ID /
'244.4) r,A\ _
JP. Dleidren
10-57-1)
I
1P.dn .n `
116.49.9-7)) H '
2P.�•EndotuHan I! "
15.29-7) '�(`
I
JP.Endowlfsn
j Ifst. Y
:031-074) r\
4P.Endrin \'
'2.20-8)
X.
SP, t
Id.hyd.yd.
421-93.4)
;P, Heptachlor - .
6-44-8) \ _ 1 1
1 Form 3510-2C (8•90) PAGE V•8 CONTINUE ON PAGE V•

EPA I.D. NUM[[R(copy from Item 1 of Form 1) OUTFALL NUMBER
CONTINUED FROM PAGE V-8
I. POLLUTANT
AND CAS 1. MARK A
3. EFFLUENT _ �. UNITS
NUMBER r•• tl ••. c •. h. MAXI M ] AIY VALu[ C.LONO TtRli AVR S. INTAKE (optional)
-
,..•r .�a,.• v• • MAXIMUM DAILY VALUE � A 84 (I/ 110D1 VALU[ ,1 No Ou0 O aU0 e� •. GONCE M • LONG TERM D.MO.Or
-,!•wola birl •w•.13_ i.,;•. L,:�. ISI ANAL. b. P•4 ASS AY[RAGE VALUE
A.13_ cnued.•.•r,o.. Irl ..wr. co..c•r.rl..wr,o« Irl mow•• cQ..c•wr1.l•wr.4� Irl Kw.• YS[S TA ATION I�1 co..c... ANAL
GC/MS FRACTION—PESTICIDES(continued)I')
,ww„o I �... Yses
17P. Hmpt chlor `/ -
E pox Ida X
(1024-ala) /
18P. PCs-1242
(53469-31.9)
I T I
19P.PCB-1254 IX
1!
(11097.69.1) X
- A
20P,PCB-1221r
(11104.28.2)
1 PCB•1232
(
(1111 41.16.6))
r r �J-
22P.PC8•1248
4(12672.296) X /,' .
I
23P.PCB-1260 �/ 10.. 0
(1109x82-5) r/11
2(1264P,PCB-
74111016.2) •
,
26P,ToxapMn•
(8001-35-2)
PAGE V-9
/
I
•
A Form 3516-2C (140)

21-1(1'35G
1,
K- r red4.-,,qp- C-Ato
6021ACE P,ne,NL Z8777
M, -4.kv"e I(
Pezw(� � NCoQbyoo
,� pPaornn o % 3, oco ooa
la,441,Ks Pee paY