820318_Waste Utilization Plan_20221208

SLUDGE APPLICATION PLAN
PRODUCER: Smithfield Hog Production Facilities 82-318
LOCATION: Sampson County
TELEPHONE: [phone]
TYPE OPERATION: Farrow - Wean
NUMBER OF ANIMALS: N/A
(Design Capacity)
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface and/or groundwater. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops in the fields where the waste is
to be applied. This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle. Annual soil tests are strongly encouraged so that all
plant nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and available water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special precautions, waste may be
applied to land eroding at up to 10 tons per year. Do not apply waste on saturated soils, when it
is raining, or when the surface is frozen. Either of these conditions may result in runoff to
surface waters which is not allowed under DEM regulations. Wind conditions should also be
considered to avoid drift and downwind odor problems. To maximize the value of nutrients for
crop production and to reduce the potential for pollution, the waste should be applied to a
growing crop or applied to bare ground not more than 30 days prior to planting. Injecting the
waste or disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H.0217 adopted by the Environmental Management Commission.
Page 1

WASTE UTILIZATION PLAN
Amount of sludge(aallons i
Amount of Plant Available Nitrogen (PAN) Produced Per Year
870,000 gallons x 15 Ib.s PAN/1000 gallons 13,050 lbs. PAN/year. (PAN from N.C.
Tech
13,050 Total
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner
Guide Std. 633)
The following acreage will be needed for waste application based on the crop to be grown and surface
application:
Tract
Field
No.
Soil
Type
Table 1: ACRES OWNED BY PRODUCER
Crop Lbs. N Acres Lbs. N Month of
Per Acre Utilized Application
0
0.00
(See pace 10)
0
0
0
0
0
0
0
0
0
0
Total
0.00
-
*This N is from animal waste only. If nutrients from other sources such as commercial fertilizer are
applied, they must be accounted for. N must be based on realistic yield expectation.
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N requirements.
Beginning in 1996 the Coastal Zone Management Act will require farmers in some eastern counties of
North Caroline to have a nutrient management plan that addresses all nutrients. This plan only
addresses Nitrogen.
Page 2

WASTE UTILIZATION PLAN
Table 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner must be attached)
(Required only if operator does not own adequate land [see
Required Specification 2])
Tract Field Soil
No. Type
Crop
Lbs. N Acres Lbs. N Month of
Per Acre*
Utilized Application
* See footnote for Table 1
Total
Totals from above Tables
Acres Lbs. N
Utilized
Table 1
Table 2
Table 3
Total
Amount of N Produced
Surplus or Deficit
0.00
106.60
13,083
0.00
0.00
106.60
13083.20
13,050
(33)
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to prevent over
application of nutrient or other elements.
Page 3

WASTE UTILIZATION PLAN
See attached map showing the fields to be used for the utilization of waste water.
Application of Waste by Irrigation
Field Soil Type Crop Application Application
No. Rate Amount (In.)
THIS TABLE IS NOT NEEDED IF WASTE IS NOT BEING APPLIED BY IRRIGATION, HOWEVER A SIMILAR TABLE WILL
BE NEEDED FOR DRY LITTER OR SLURRY.
Call the local Natural Resources Conservation Service (formerly Soil Conservation Service) or Soil
and Water Conservation District office after you receive the waste analysis report for assistance in
determining the amount per acre to apply and the proper application rate prior to applying the
waste.
Narrative of operation:
SB515 setbacks apply. They are as follows:
1. 100' from water supply well
2. 200' from residence
3. 50' from public ROW.
4. 50' from property line not owned by the producer or lessor.
5. 75' from blue -line stream
Actual sludge analysis should be used for all recordkeeping. Records should be kept on SLD2
forms after applications documenting volumes applied.
Page 4

1
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of waste, he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic
crop yields based on soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of application for
other nutrients.
4 Animal waste shall be applied to land eroding Tess than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre per
year providing grass filter strips are installed where runoff leaves the field. (See FOTG
Standard 393 - Filter Strip).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6 When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor or flies.
8
Animal waste shall not be applied to saturated soils, during rainfall events, or when the
Page 5

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
11
12
13
14
Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property
boundary and from any perennial stream or river (other than an irrigation ditch or canal.
Animal waste other than swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters. (See Standard 393 - Filter
Strips).
Animal waste shall not be applied closer than 100 feet to wells.
Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
Waste shall be applied in a manner not to reach other property and public right-of-ways.
Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
15 discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist".
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that causes no runoff or drift from the site.
16
Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system
Page 6

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20
Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications animal waste
during the crop season.
Highly visible markers shall be installed to mark the top and bottom elevations of the
21 temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22
23
Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 7

WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm:ry-\
�-103
Owner / Manager Agreement
(we) understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a new
certification to be submitted to the Division of Environment Management (DEM) before the
new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface waters of the state from a storm event less
severe than the 25-year, 24-hour storm. The approved plan will be filed on -site at the
farm office and at the office of the local Soil and Water Conservation District and will be
available for review by DEM upon request.
Name of Facility Owner:
(Please print)
Signature:
Name of Manager (If different from owner):
Signature:
Name of Technical Specialist: (Please print)
Affiliation: Murphy Brown, LLC
Date:
Date:
Ord ► �.j•--� �'r`.
Address (Agency): PO Box 856
Warsaw, NC 28398
[phone]
Signature:
Date:
Page 8

WASTE UTILIZATION PLAN
Table 1: ACRES OWNED BY PRODUCER
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Type
Per Acre* Utilized Application
Devane
1
NoA
Wheat
125
26.00
3,250.00
Sept -April
Devane
2
NoB
Wheat
122
39.20
4,782.40
Sept -April
Devane
3
NoB
Wheat
122
41.40
5,050.80
Sept -April
TOTAL 106.6
13083.2
Page 10

WASTE UTILIZATION PLAN
ANIMAL WASTE UTILIZATION AGREEMENT
(Needed only if additional land has to be leased, etc.)
, hereby give
permission to apply animal waste from his Waste Utilization System on acres
of my land for the duration of time shown below.
I understand that this waste contains nitrogen, phosphorous, potassium, and other
trace elements and when properly applied should not harm my land or crops. I also
understand that the use of waste will reduce my needed for commercial fertilizer.
Adjacent Landowner: Date:
Waste Producer: Date:
Technical Representative: Date:
SWCD Representative: Date:
Term of Agreement: , 19 to , 20
(Minimum of Ten Years on Cost Shared Items)
(See Required Specification No. 2)
Page 9

Animal Waste Utilization Agreement
Smithfield Hog Production Division
I, William Devane, hereby give Smithfield Hog Production Division permission to apply animal
waste from the waste utilization system on Nso acres of my land for the duration of time
specified below.
I understand that this waste contains nitrogen, phosphorous, and other trace elements and when
properly applied should not harm my land or crops. I also understand that the use of wase will
reduce my overall needs for commercial fertilizer, and that Nitrogen limitations exist based on
individual farm Waste Utilization Plans. After the completion of animal waste application,
Smithfield HPD shall provide said Landowner / Farmer with a Nitrogen total of animal wase
derived nutrients vs. remaining nutrients allowed in the Waste Utilization Plan.
This lease will stand year over year after the end of the lease agreement unless the Landowner or
Smithfield HPD provides written notification no later than 90 days from termination date.
f
Date: 12/52
Technical Representative Michael Norris
Date: 12/5/22
Term of Agreement 12/5 2022 to 12/2,� 0

4TriiNUL
Zone Summary
Grower: Carolina Ridge Farms
Farm: Devane Farm
Field: Devane 1
Area: 27.0 ac
Min
Max
Area
zone
Zone 1
--
--
5.76 ac
Zone 2
1
--
--
4.70 ac
Zone 3
--
--
5.06 ac
Zone 4
--
--
5.19 ac
Zone 5
--
--
6.27 ac
26,98 ac I
Avg. 0.00 seed/ac
COASTAL
AgroRusinegs
Clinton NC
1104 N US 421 Hwy
Clinton, NC 28328
Acct #1104
11/01/22 03:37 PM

o
3
3
O
se
se
8
B.
5
3,
N
0
co
a
S
a
cb
po
i!7
3
c
K
m
W
7
m
d
3
co
cT
O
0
'Oa
0
S
Soil Fertility Recommendations (Ibs/A)
CT
CO
CO
CO
r
0)
0
r
m
CO
1,3
W
V
Co
!O
00
Co
m
COOf
rn
m
a
c0
<o
CO
1,3
N
5
rn
CT
0)
5
0)
A
r-
N
V
a
m
COOT
A
to
V
W
(O
0
be
O
co
W
N
m
N
0
CO
Co
01
C
5
V
r-
V
rn
r-
O
x
CT
0
CT
CT
V
(O
N
V
N
O
CD
N
co
co
0
2
0'
w
0
001
3
r
N
r-
A
w
2
0)
x
N
O
0)
V
to
Al
r
9
00
OD
n
0)
r
A
Of
a
o wo
W
Co
N
!O
W
(O
N
CT
4.f
co
50
N
1,1
O
N
0
V
CO
C
6
S
m
i
a
g
a
Cif
tie
S
3
co
N
N
N
MAN UV Sfl N W0IT
TES
COASTAL AGROBUSINESS [1104]
Grower: CAROLINA RIDGE FARMS
364 W. Park Drive I Warsaw, NC 28398- I Phone [phone]

COASTAL
oIVtix.
Zone Summary
Grower: Carolina Ridge Farms
Farm: Devane Farm
Field: Devane 2
Area: 39.2 ac
Min
Max
Area
zone
Zone 1
--
--
4,16 ac
Zone 2
--
--
6.73 ac
Zone 3
--
--
6.02 ac
Zone 4
--
--
5.83 ac
Zone 5
,
--
`-
6.35 ac
_
Zone 6
--
--
5.23 ac
LZone 7
--
--
4.91 ac
39.23 ac
Avg. 0.001b/ac
CJiASTAL
AgroRusiness
s..rwd,.r,y,.Hprmfor 1,r
Clinton NC
1104 N US 421 Hwy
Clinton, NC 28328
Acct # 1104
11/01/22 03:37 PP

0
0
3
0
V Of
0
z
0
0
0
C))
0
^00
z
0
-a
CO
z
0
^
Y�
•
0 0
0 z
N
o.
-n
v
CO
CO
.0
C)
C.!
..f.
CO
CO
O
A
CO
N
CO
CO
CO
828812QW
8288110W
828810QW
828809QW
CO
ND
CO
CO
O
195 H
211 VH
0)
0)
2
184 H
A
V
>
155 H
1220 VH
V
M
N
M
IV
O
E
239 A
CA
>
263 A
0)
W
>
194 A
1197 A
>
>
=
=
312 VH
798 M
894 M
795 M
0
O
0)
]>
c:
)
O
>
J.
V
>
11397 A
m
in
O)
0
o)
)
CT
a)
ti
Fn.
v)
0)
irower: CAROLINA RIDGE FARMS
n/Field: DEVANE FARM / DEVANE 2
LID: 79E63878525
Aethod: Mehlich III Received: 10/18/2022
pH S 6 2n Mn Fe Cu Na HM ENR
V
O
O
V
iv
0)
V
O
O
V
O
0)
V
iv
O
V
ix,
Cn
V
V
O
O
r
W
r
N
r
CO
V
Of
E
Off)
E
O
A
r
O
i.1)
r
O
CT
r
O
in
r
O
V
r
O
V
r
O
V
r
W
CO
r-
4.3 M
A
CO
.0
i0
Of
V
D
V
N
a
CO
0
a
v)
r
1 20 L
29 L
0)
r-
20 L
o
3
22 L
273 H
CO
O
2
CCOO
CO
2
CO
O
2
Ca 0)
0
2
CO
.•
2
505 VH
12.8 M
3.2 A
CO
A.
>
Co
CO
>
3.7 A
CO
C)
>
.0
......
>
A
CO0ON)
NO
CON
N
C.
Cn
O
O
0
CO
O
V
O
U
Co
O
11
O
Cif
V
O
CO
A
0)
A
C))
A
V
CT
O
O)
O
CO
in
V
O
W
in
A
'b
O)
-
O)
�1
O)
N
A
is
117.5 143.2 134.61 1.1 1
CO
IV
on
bo
CO
Al
1 18.1 147.3 126.81 1.0
CO
i0
V
N
CCOO
0
Of
O
.0
Cco
A
E.
CA0
i7o
W
ib
Co
co
.0
CM
lV
t)
iO
CO
V
N
..,
iv
+
CO
T
364 W. Park Drive I Warsaw, NC 28398- I Phone [phone]

ji�ivtix.
Zone Summary
Grower: Carolina Ridge Farms
Farm: Devane Farm
Field: Devane 3
Area: 41.4 ac
Min
Max
Area
zone
Zone 1
--
--
5.01 ac
17 Zone 2
--
--
5.66 ac
LZone 3
--
ac
Zone 4
--
--
v6.13
5.74 ac
IZone 5
--
--
6.56 ac
Zone 6
--
--
6.24 ac
Zone 7
--
--
6.04 ac
41.38 ac
Avg. 0.00 lb/ac
COASTAL
AgroRu ineml
SuiW in m bar
Clinton NC
1104 N US 421 Hwy
Clinton, NC 28328
Acct #1104
11/01/22 03:38 Pr

•
v
Co
w
co
isa
N
V
CO
D
Co
Ci
r
0)
Co
Co
Co
O
2
N
(0
(r
co
co
W
N
0
CO
N
O)
A
CoCo
Co
2
03
N
Co1.3
00
0
Co
W
co
co
w
-4
N
w
CO
((D
(O
N
CO
CO
CO
N
D
0.1
w
N
Co
CO
00
V4)
co
O
0)
1-
a
coc
N
v
CO
N
O
0.
co
1.71
V1
1
O
N
r-
F.
r
N
t.1
1—
W
ON)
N
N
N
CD
A
N
N
A
0)
i.)
-4
U
ON)
w
r
v
C
V
A
N
N
iO
CO
C
O7
w
00
a_
0)
0)
V
O
1—
N
co
r
w
r
0)
rn
S
V
O
N
(0
(n
Oa
IV
V
N
G
N
(7n
COCO
O
r
r
CO
r
N
(r
W
0.
V
O
CO
r
W
r
(!f
W
O
2
C)1
Co
o O
coNCo
CO
N
(0
C
O
W
A
CO
O
a
W
CJ
(O
w
N
c
ff
a
a
a
33
3
0
a
SZ DN'NO1NIlD
AMH TZb Sfl N t'OTT
Z'9 :Hd la$Je1
[vOTT] SS3NISf19OHJV 1V1SVO0
Grower: CAROLINA RIDGE FARMS
364 W. Park Drive I Warsaw, NC 28398• I Phone [phone]
L
On
f„
17/1
— V►
icn
�.
cr
0 /!
O
N a
3
0