NC0056863_Authorization to Construct_20060622

Town of Rose Hill
A to C No. 056863A02
Issued September 30, 2004
ENGINEER'S CERTIFICATION
gAirrit
I,115Aliko. - (, 4^t ` - ; p t: , as a duly registered Professional Engineer in the
State of North Carolina, having been authorized to observe (periodically/weekly/full time) the
construction of the Conjunctive Use Reclaimed Wastewater System serving the Town of Rose Hill,
located in Duplin County, hereby state that to the best of my abilities, due care and diligence was used in
the observation of the following construction:
Replacement of grit removal system, and the distribution box, pursuant to the letter of
request received November 27, 2001, and in conformity with the project plan,
specifications, and other supporting data subsequently filed and approved by the
Department of Environment and Natural Resources.
I certify that the construction of the above referenced project was observed to be built within
substantial compliance and intent of the approved plans and specifications.
Signature // r; : , Registration No.
Date
Mail this Certification to:
DENR/DWQ
Design Management Unit
Construction Grants & Loans Section
1633 Mail Service Center
Raleigh, NC 27699-1633
EcEE
•

mn v. swJJ JL., secretary
ry North Carolina Department of Environment and Natural Resources
ba
Alan W. Klimek. P.E. Director
O Division of Water Quality
August 12, 2002
Mr. Thomas G. Drum, Town Administrator
Town of Rose Hill
Post Office Box 8
Rose Hill, North Carolina 28458-0008
Dear Mr. Drum:
5
AUG 2 6 2002
DENR - WATER QUALITY
POINT SOURCE BRANCH
SUBJECT: A to C No. 056863A01
Authorization to Construct
Town of Rose Hill
Town of Rose Hill WWTP
Duplin County
Project No. E-SRG-T-00-0085
A letter of request for Authorization to Construct was received on July 23, 2002 by the
Division, and final plans and specifications for the subject project have been reviewed and found
to be satisfactory. Authorization is hereby granted for the construction of modifications to the
existing 0.45 MGD Town of Rose Hill Wastewater Treatment Plant, with discharge of treated
wastewater into Reedy Branch in the Cape Fear River Basin.
This authorization results in no increase in design or permitted capacity and is awarded
for the construction of the following specific modifications:
Replacement of two screw pumps and associated electrical work.
This Authorization to Construct is issued in accordance with Part III, Paragraph A of
NPDES Permit No. NC0056863 issued March 28, 2002, and shall be subject to revocation unless
the wastewater treatment facilities are constructed in accordance with the conditions and
limitations specified in Permit No. NC0056863.
The sludge generated from these treatment facilities must be disposed of in accordance
with G.S. 143-215.1 and in a manner approved by the North Carolina Division of Water Quality.
In the event that the facilities fail to perform satisfactorily, including the creation of
nuisance conditions, the Permittee shall take immediate corrective action, including those as may
Construction Grants and Loans Section 1633 Mail Service Center
E-Mail Address www.nccgl.net
421.
NCDENR
Raleigh, NC 27699-1633 [phone] Customer Service
FAX [phone] 623-7748

be required by this Division, such as the construction of additional or replacement wastewater
treatment or disposal facilities.
The Wilmington Regional Office, telephone number [phone], shall be notified at
least forty-eight (48) hours in advance of operation of the installed facilities so that an on site
inspection can be made. Such notification to the regional supervisor shall be made during the
normal office hours from 8:00 a.m. until 5:00 p.m. on Monday through Friday, excluding State
Holidays.
Upon completion of construction and prior to operation of this permitted facility, a
certification must be received from a professional engineer certifying that the permitted facility
has been installed in accordance with the NPDES Permit, this Authorization to Construct and the
approved plans and specifications. Mail the Certification to Cecil G. Madden, Jr., P.E.,
Construction Grants & Loans, DWQ/DENR, 1633 Mail Service Center, Raleigh,
NC 27699-1633.
Upon classification of the facility by the Certification Commission, the Permittee shall
employ a certified wastewater treatment plant operator to be in responsible charge (ORC) of the
wastewater treatment facilities. The operator must hold a certificate of the type and grade at least
equivalent to or greater than the classification assigned to the wastewater treatment facilities by
the Certification Commission.
The Permittee must also employ a certified back-up operator of the appropriate type and
grade to comply with the conditions of T15A:8G.0202. The ORC of the facility must visit each
Class I facility at least weekly and each Class II, III and IV facility at least daily, excluding
weekends and holidays, must properly manage the facility, must document daily operation and
maintenance of the facility, and must comply with all other conditions of T15A:8G.0202.
A copy of the approved plans and specifications shall be maintained on file by the
Permittee for the life of the facility.
During the construction of the proposed additions/modifications, the permittee shall
continue to properly maintain and operate the existing wastewater treatment facilities at all times,
and in such a manner, as necessary to comply with the effluent limits specified in the NPDES
Permit.
You are reminded that it is mandatory for the project to be constructed in accordance with
the North Carolina Sedimentation Pollution Control Act, and, when applicable, the North
Carolina Dam Safety Act. In addition, the specifications must clearly state what the contractor's
responsibilities shall be in complying with these Acts.
2

Failure to abide by the requirements contained in this Authorization to Construct may
subject the Permittee to an enforcement action by the Division of Water Quality in accordance
with North Carolina General Statute 143-215.6A to 143-215.6C.
The issuance of this Authorization to Construct does not preclude the Permittee from
complying with any and all statutes, rules, regulations, or ordinances which may be imposed by
other government agencies (local, state, and federal) which have jurisdiction.
One (1) set of approved plans and specifications is being forwarded to you. If you have
any questions or need additional information, please contact Cecil G. Madden, Jr., P.E. at
telephone number [phone].
Sincerely,
Alan W. Klimek, . .
ID:dr
cc: The Wooten Company (Dr. Shankar R. Mistry, P.E.)
Duplin County Health Department
Wilmington Regional Office, Water Quality Section
Technical Assistance and Certification Unit
Daniel Blaisdell, P.E.
Dave Goodrich, NPDES Permitting Unit
Cecil G. Madden, Jr., P.E.
SRG
3

TOWN OF ROSE 111
P.O. BOX 8
ROSE HILL, NORTH CAROLINA 28458
FY 2004-2005
(BEGINNING JULY 1, 2004)
PERFORMANCE ANNUAL REPORT
GENERAL INFORMATION
FACILITYISYSTEM NAME:
RESPONSIBLE ENTITY:
ROSE HILL WASTEWATER TREAMENT PLANT
TOWN OF ROSE HILL
PERSON 1N CHARGE\CONTACT:GERALD F. JAMES [phone] OR [phone]
APPLICATION PERMIT: NC 0056863
DESCRIPTION OF COLLECTION OR TREATMENT PROCESS:
0.45 MGD WASTEWATER TREATMENT FACILITY CONSISTING OF AN INFLUENT
PUMP STATION, BAR SCREEN, OXIDATION DITCH, THREE (3) CLARIFIERS, AERATED
SLUDGE HOLDING TANK, FIVE (5) DRYING BEDS, CLORINE DISINFECTION BASIN AND POST
AERATION BASIN LOCATED AT ROSE HILL WASTEWATER TREATMENT PLANT, NCSR 1931
IN DUPLIN COUNTY (SEE FLOW SCHEMATIC). THE DISCHARGE FROM SAID TREATMENT
WORKS AT THE LOCATION SPECIFIED ON THE ATTATCHED MAP IS INTO REEDY BRANCH
WHICH IS CLASSIFIED CLASS C-SWAMP WATERS IN THE CAPE FEAR RIVER BASIN.
2. PERFORMANCE
TEXT SUMMARY OF SYSTEM PERFORMANCE FOR FISCAL YEAR 2004-2005
SAID WASTEWATER TREATMENT FACILITY PASSED ALL 4 QUARTERLY CHRONIC
TOXICITY THAT IS REQUIRED IN OUR NPDES PERMIT. THE FACILITY RECEIVED A NOV
(NOTICE OF VIOLATION) FOR A FLOW VIOLATION IN MARCH OF 2005.
LIST (BY MONTH) ANY VIOLATIONS OF PERMIT CONDITIONS OR OTHER
ENVIRONMENTAL REGULATIONS; MONTHLY LIST SHOULD INCLUDE DISCUSSION OF ANY
ENVIRONMENTAL IMPACTS AND CORRECTIVE MEASURES TAKEN TO ADDRESS
VIOLATIONS.
JULY 2004 NO VIOLATIONS PASSED TOXICITY
AUGUST 2004 NO VIOLATIONS
SEPT. 2004 NO VIOLATIONS
OCT. 2004 NO VIOLATIONS PASSED TOXICITY
NOV. 2004 NO VIOLATIONS
DEC. 2004 NO VIOLATIONS
JAN. 2005 NO VIOLATIONS PASSED TOXICITY

FEB. 2005 NO VIOLATIONS
MAR. 2005 NOTICE OF VIOLATION PERMIT EFFLUENT FLOW
APR. 2005 NO VIOLATIONS PASSED TOXICITY
MAY 2005 NO VIOLATIONS
JUNE 2005 NO VIOLATIONS
3. NOTIFICATION
STATE HOW THIS REPORT HAS BEEN MADE AVAILABLE TO USERS OR CUSTOMERS
OF THE SYSTEM AND HOW THOSE USERS HAVE BEEN NOTIFIED OF THE AVAILABILITY.
NOTIFICATION WAS MAILED TO THE ADDRESS OF EACH SEWERICUSTOMER SO AS
TO INFORM SAME THAT A COPY OF THIS REPORT COULD BE OBTAINED AT THE TOWN OF
ROSE HILL TOWN HALL (COPY OF NOTIFICATION ATTATCHED).
4. CERTIFICATION
I CERTIFY UNDER PENALTY OF LAW THAT THIS REPORT IS COMPLETE AND
ACCURATE TO THE BEST OF MY KNOWLEDGE. I FURTHER CERTIFY THAT THIS REPORT
HAS BEEN MADE AVAILABLE TO THE USERS OR CUSTOMERS OF THE NAMED SYSTEM AND
THAT OSE USERS HAVE BEEN NOTIFIED OF ITS AVAILABILITY.
z2-aS_
D F. J DATE
IC UTILITIES ' 1' i TOR
OF ROSE HIL
. BOX 8
OSE HILL, N.C. 28458

�Sl �. -r.I l�'•
Ati
r =
y.+L �:./. f t .•.:t �'; w .... ;:, u } t ry.0 r L 4.. .'%li: 1 r �.�-'r`Ywi�11�
..,, • '.ram •.y.tf . 6 t. i t � _{ � t..t, ..i, • x= .•�..: ��•
C..,. i r is tit rf r� , r�` ?�.,�,� , -9` •�: *•SI r aci� K:::tt, rk.tti cd' f'•nl
.;(.. 'Y.;.• :�1. � C M. 'r a er k�!�� t �� .� :..
.{. l.. ♦ JI..M1r. s 'i"�•L1.Y.�'.�_r-i• �.17LL. •►3�6 �. �,'�Ar.�'R _ .� ili-i%`._��• .
• V Y.
_ r—� ~ ( rG 3 -
PCsar
No.
r w w
a.4SMGZRosa ilU14
FIcw SCt.2:.t21zic
t {
t
S_Ld a I—i
f
QC-
s
ri '
wr
6 Bads
Li t
(
r
Y
7
•
•
•
tom GS: e Sludge I FG .
T
r �.
R. re-, a a ricuir Limas
Sludge t _as
Ra..._.•.:
C
'as: z i a:e+ SludTe
77.
—e
t 1 z
C.C.daticm
/ / M
1
11
a rs r. r �
1
1 7
1
+
.. 3�� . • • aa
— A