NC0065358_permit issuance_19960304

Permit No. NC0065358
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT, HEALTH, AND NATURAL RESOURCES
DIVISION OF ENVIRONMENTAL MANAGEMENT
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1,
other lawful standards and regulations promulgated and adopted by the North Carolina
Environmental Management Commission, and the Federal Water Pollution Control Act, as
amended,
Hidden Forest Mobile Home Park
is hereby authorized to discharge wastewater from a facility located at
Hidden Forest Wastewater Treatment Plant
6602 Holder Inman Road Extension
Randleman
Randolph County
to receiving waters designated as an unnamed tributary to the Deep River in the Cape Fear River
Basin
in accordance with effluent limitations, monitoring requirements, and other conditions set forth in
Parts I, II, III and IV hereof.
This permit shall become effective April 1, 1996.
This permit and authorization to discharge shall expire at midnight on March 31, 2001.
Signed this day March 4, 1996.
Ovi. 1 ay
David A,, Goodrich
A. Preston Howard, Jr., P.E., Director
Division of Environmental Management
By Authority of the Environmental Management Commission

Permit No. NC0065358
SUPPLEMENT TO PERMIT COVER SHEET
Hidden Forest Estates Mobile Home Park
is hereby authorized to:
1. Continue to operate a 0.027 MGD system with an influent surge tank with bar screen, aeration
tank, clarifier, chlorination and contact tank, post aeration tank, aerated sludge holding tank,
phosphorus removal equipment, tertiary filters, a UV disinfection unit, effluent flow
measurement, and stand-by power located at Hidden Forest Mobile Home Park, 6602 Holder
Inman Road Extension, Randleman, Randolph County (See Part III of this Permit), and
2. Discharge from said treatment works at the location specified on the attached map into an
unnamed tributary to Deep River which is classified Class C waters in the Cape Fear River
Basin.

A. (). EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS SUMMER (April 1 - October 31) Permit No. NC0065358
During the period beginning on the effective date of the permit and lasting until expiration, the Permittee is authorized to discharge from
outfall(s) serial number 001. Such discharges shall be limited and monitored by the permittee as specified below:
Effluent Characteristics Discharge Limitations Monitoring
Measurement
Monthly Avg.
Flow 0.027 MGD
BOD, 5 day, 20°C 5.0 mg/I
Total Suspended Residue 30.0 mg/I
NH3 as N 2.0 mg/I
Dissolved Oxygen**
Fecal Coliform (geometric mean) 200.0 /100 ml
Total Residual Chlorine
Temperature, °C
Total Nitrogen (NO2 + NO3 + TKN)
Total Phosphorus
Conductivity
2.0 mg/I***
Weekly Avg. Daily Max
7.5 mg/I
45.0 mg/I
400.0 /100 ml
17 µg/I
* Sample locations: E - Effluent, I - Influent, U - Upstream 100 feet, D - Downstream 100 feet
** The daily average dissolved oxygen effluent concentration shall not be less than 6.0 mg/1.
*** Quarterly Average Limitation.
Frequency
Continuous
3/Week
3/Week
3/Week
3/Week
3/Week
3/Week
3/Week
Monthly
Weekly
3/Week
Requirements
Sample *Sample
Type Location
Recording I or E
Composite E
Composite E
Composite E
Grab E, U, D
Grab E,U,D
Grab E
Grab E, U, D
Composite E
Composite E
Grab U, D
The p11 shall not be less than 6.0 standard units nor greater than 9.0 standard units and shall be monitored 3/week at the effluent by grab
sample.
There shall be no discharge of floating solids or visible foam in other than trace amounts.

A. ( ). EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS WINTER (November 1 - March 31) Permit No. NC0065358
During the period beginning on the effective date of the permit and lasting until expiration, the Permittee is authorized to discharge from
outfall(s) serial number 001. Such discharges shall be limited and monitored by the perrnittee as specified below:
Effluent Charscteristiu Discharge Limitations Monitoring
Measurement
Monthly Avg.
=low 0.027 MGD
30D, 5 day, 20°C 10.0 m g / I
rota) Suspended Residue 30.0 m g / I
VH3 as N 4.0 mg/I
Dissolved Oxygen**
=ecal Coliform (geometric mean) 200.0 /100 ml
rotal Residual Chlorine
temperature, °C
Iota! Nitrogen (NO2 + NO3 + TKN)
rota) Phosphorus
conductivity
2.0 mg/I'**
Weekly Avg, Daily Max Frequency
Continuous
15.0 mg/I 3/Week
45.0 mg/I 3/Week
3/Week
3/Week
400.0 /100 ml 3/Week
17 µg/I 3/Week
3/Week
Monthly
Weekly
3/Week
* Sample locations: E - Effluent, I - Influent, U - Upstream 100 feet D - Downstream 100 feet
Requirements
Sample
Type
Recording
Composite
Composite
Composite
Grab
Grab
Grab
Grab
Composite
Composite
Grab
*Sample
Location
I or E
E
E
E
E, U, D
E,U,D
E
E, U, D
E
E
U, D
** The daily average dissolved oxygen effluent concentration shall not be less than 6.0 mg/I.
*** Quarterly Average Limitation.
The pH shall not be less than 6.0 standard units nor greater than 9.0 standard units and shall be monitored 3/week at the effluent by grab
sample.
There shall be no discharge of floating solids or visible foam in other than trace amounts.

Part III Permit No. NC0065358
E. POTW Connection Condition
The permittee shall properly connect to an operational publicly owned wastewater collection
system within 180 days of its availability to the site, if the facility is in noncompliance with any
terms and conditions of the NPDES permit or governing rules, regulations and laws.

PUBLIC NOTICE
State of North Carolina
Environmental Management
Commission
Post Office Boz 29535
Raleigh, North Carolina
27628-0535
NOTIFICATION OF INTENT TO
ISSUE A STATE NPDES PERMIT
On the basis of thorough staff re-
view and application of Article 21
of Chapter 143. General Statutes
of North Carolina. Public Law 92-
500 and other lawful standards
and regulations. the North Caroli-
na Environmental Management
Commission proposes to issue a
permit to discharge to the persons
listed below effective 3/5/96 and
subject to special conditions.
Persons wishing to comment upon
or object to the proposed determin-
ations are Invited to submit same
In writing to the above address no
later than 2/17/96. All comments
received prior to that date will be
considered In the formulation of fl-
nal determinations regarding the
proposed permit. A public meeting
may be held where the Director of
the Division of Environmental
Management finds a significant
degree of public Interest In a pro-
posed permit.
A copy of the draft permit is avail-
able by writing or calling the Divi-
sion of Environmental
Management. P.O. Box 29535. Ra-
leigh, North Carolina 27626-0535.
[phone].
The application and other informa-
tion may be inspected at these lo-
cations during normal office
hours. Copies of the information
on file are available upon request
and payment of the costs of repro-
duction. All sue:. 'omments or re-
quests regarding a proposed
permit should make reference to
the NPDES permit number listed
below.
Date January 12, 1996
Public Notice of Intent to Issue a
State NPDES Permit to the follow-
1.
Forest Estates. A.N.C. General
Partnership. P.O. Box 15411,
Winston-Salem, NC 27113 has ap-
plied for a permit renewal for a fa-
cility located at Hidden Forest
Mobile Home Park. a site on NCSR
1988. north of Randleman, Ran-
dolph County. The facility dis-
charges from one outfall adjacent
to Stewart's Pond, a privately
owned pond near the existing
wastewater treatment facility, into
an unnamed tributary to the Deep
River which Is a Class C stream In
the Cape Fear River Basin which
has a 7Q10 flow of 1.8 cfs. BOD5.
ammonia and dissolved oxygen are
water quality limited. For some pa-
rameters, the available load capac-
ity of the immediate receiving
water will be consumed. Thls may
affect future water quality based
effluent limitations for additional
dischargers within this portion of
the watershed.
David A. Goodrich
A. Preston Howard Jr., P.E.
Director, Division of
Environmental Management
It 1/16/96
NORTH CAROLINA '
RANDOLPH COUNTY c
AFFIDAVIT OF PUBLICATION
Before the undersigned, a Notary Public of said County and State,
duly commissioned, qualified, and authorized by law to administer
oaths, personally appeared
MARIA PAYNE
who being first duly sworn, deposes and says, that he (she) is
BUSINESS-MA?TAGFR
of The Courier -Tribune, engaged in the publication of a newspaper
known as The Courier -Tribune, published, issued, and entered as
second class mail in the City of Asheboro, in said County and State;
and that he (she) is authorized to make this affidavit and sworn
statement; that. the notice or other legal advertisement, a true copy
of which is attached hereto, was published in The Courier -Tribune
on the following dates:
January 16, 1996
and that the said newspaper in which such notice, paper, document,
or legal advertisement was published was, at the time of each and
every such publication, a newspaper meeting all of the require-
ments and qualifications of Section 1-597 of the General Statutes of
North Carolina, 19.13, as amended, and was a qualified newspaper
within the meaning of Section 1-597 of the General Statutes of
North Carolina.
This 16t-h day of January , 19 a6
161-h
Sworn to and subscribed before me, this day
Janu-,ry
of
I`Iy commission expires:
b- iq-q
6
19 a 6
Notary Public

PUBLIC NOTICE
State of North Carolina
Environmental Management
Commission
Post Office Box 29535
Raleigh. North Carolina
27626-0535
NOTIFICATION OF INTENT TO
ISSUE A STATE NPDES PERMIT
On the basis of thorough staff re-
view and application of Article 21
of Chapter 143. General Statutes
of North Carolina. Public Law 92-
500 and other lawful standards
and regulations. the North Caroli-
na Environmental Management
Commission proposes to issue a
permit to discharge to the persons
listed below effective 3/5/96 and
subject to special conditions.
Persons wishing to comment upon
or object to the proposed determin-
ations are invited to submit same
in writing to the above address no
later than 2/17/96. All comments
received prior to that date will be
considered In the formulation of fi-
nal determinations regarding the
proposed permit. A public meeting
may be held where the Director of
the Division of Environmental
Management finds a significant
degree of public interest in a pro-
posed permit.
A copy of the draft permit is avail-
able by writing or calling the Divi-
sion of Environmental
Management. P.O. Box 29535. Ra-
leigh, North Carolina 27626-0535.
[phone].
The application and other informa-
tion may be inspected at these lo-
cations during normal office
hours. Copies of the information
on file are available upon request
and payment of the costs of repro-
duction. All sue:. -omments or re-
quests regarding a proposed
permit should make reference to
the NPDES permit number listed
below.
Date January 12, 1996
Public NoUce of intent to issue a
State NPDES Permit to the follow-
(ria•
,r,,�.._
lei Ian
Forest .sates, A.N.C. General
Partnership, P.O. Box 15411,
Winston-Salem. NC 27113 has ap-
plied for a permit renewal for a fa-
cility located at Hidden Forest
Mobile Home Park. a site on NCSR
1988, north of Randleman, Ran-
dolph County. The facility dis-
charges from one outfall adjacent
to Stewart's Pond, a privately
owned pond near the existing
wastewater treatment facility, into
an unnamed tributary to the Deep
River which is a Class C stream In
the Cape Fear River Basin which
has a 7Q 10 flow of 1.8 cfs. BOD5.
ammonia and dissolved oxygen are
water quality limited. For some pa-
rameters, the available load capac-
ity of the immediate receiving
water will be consumed. This may
affect future water quality based
effluent limitations for additional
dischargers within this portion of
the watershed.
David A. Goodrich
A. Preston Howard Jr.. P.E.
Director. Division of
Environmental Management
It 1/16/96
NORTH CAROLINA
RANDOLPH COUNTY t,
AFFIDAVIT OF PUBLICATION
Before the undersigned, a Notary Public of said County and State,
duly commissional, qualified, and authorized by law to administer
oaths, personally appeared
MARIA PAYNE
who being first duly sworn, deposes and says: that he (she) is
BUS INFSS - MANAGPR
of The Courier -Tribune, engaged in the publication of a newspaper
known as The Courier -Tribune, published, issu:d, and entered as
second class mail in the City of Asheboro, in said County and State;
and that he (she) is authorized to make this affidavit and sworn
statement: that the notice or other legal advertisement, a true copy
of which is attached hereto, was published in The Courier -Tribune
on the following dates:
January 16, 1996
and that the said newspaper in which such notice, paper, document,
or legal advertisement was published was, at the time of each and
every such publication, a newspaper meeting all of the require-
ments and qualifications of Section 1-597 of the General Statutes of
North Carolina, 19.:3, as amended, and was a qualified newspaper
within the meaning of Section 1-597 of the General Statutes of
North Carolina.
Of
This
1 6 i- h day of
January
19 Q6
1 6 i- h
Sworn to and subscribed before me, this day
Janu-,ry
19 a 6
My commission expires:
Notary Public
b-fq-q6

CC:
Permits and Engineering
Technical Support Branch
Randolph County Health Dept.
Central Files
WSRO
SOC PRIORITY PROJECT: Yes No X
If Yes, SOC No.
To: Permits and Engineering Unit
Water Quality Section
Attention: Jay Lucas
Date: 11 October 1995
NPDES STAFF REPORT AND RECOMMENDATION
County Randolph
Permit No. NC0065358
PART I - GENERAL INFORMATION
1. Facility and Address: Hidden Forest Mobile Home Park
3950 Overdale Road
Winston-Salem, NC 27117
2. Date of Investigation: 10 October 1995
3. Report Prepared by:
W. Corey Basinger
Environmental Engineer
4. Persons Contacted and Telephone Number:
* Mr. Morris Crafton, Owner [phone]
* Mr. Mark Jenkins, ORC (910) 65t0-4505, [phone]
5. Directions to Site: From Greensboro, travel Hwy 220 South
to the Level Cross exit. Turn left onto NCSR 2101 and cross
over Hwy 220. Take the first access road to the left and
follow it into the Park. Thq wastewater treatment plant is
located in the rear of the Park. The discharge line is
located across Hwy 200 adjacent to Stewart's Pond.
6. Discharge Point(s), List for all discharge points:
Latitude: 35° 53' 38" Longitude: 79° 49' 31"
U.S.G.S. Quad No. D-19NE 'U.S.G.S. Quad Name Pleasant
Garden
7. Site size and expansion area consistent with application?
XX Yes No If No, explain:

8. Topography (relationship to flood plain included):
The treatment facility is located above the flood plain.
9. Location of nearest dwelling: The nearest dwelling is
approximately 250 feet from the plant.
10. Receiving stream or affected surface waters:
UT to Deep River
a. Classification: Class C OS
b. River Basin and Subbasin No.: 03-06
c. Describe receiving stream features and pertinent
downstream uses: Agricultural
Part II - DESCRIPTION OF DISCHARGE AND TREATMENT WORKS
1. a. Volume of Wastewater to be permitted: 0.027 MGD
(Ultimate Design Capacity)
b. What is the current permitted capacity of the Waste
Water Treatment facility? 0.027 MGD
c. Actual treatment capacity of the current facility
(current design capacity)? 0.027 MGD
d. Date(s) and construction activities allowed by previous
Authorizations to Construct issued in the previous two
years.
1993 - Outfall relocated to current location adjacent
Stewart's Pond.
e. Please provide a description of existing or
substantially constructed wastewater treatment
facilities; The existing facility currently consists
of an influent surge tank with bar screen, aeration
tank, clarifier, aerated sludge holding tank, tertiary
filters, phosphorus removal equipment, UV disinfection,
chlorination and contact tank, post aeration tank,
effluent flow measurement, and stand-by power.
f. Please provide a description of proposed wastewater
treatment facilities. None
g•
Possible toxic impacts to surface waters: None known.
2. Residuals handling and utilization/disposal scheme:
a. If residuals are being land applied, please specify DEM
Permit No.
Residuals Contractor

NPDES Permit Staff Report
Telephone No.
b. Residuals stabilization: PSRP PFRP
Other
c. Landfill:
d. Other disposal/utilization scheme (Specify): Residuals
are removed when necessary by licensed hauler.
3. Treatment plant classification (attach completed rating
sheet) . Class III
4. SIC Code(s) : 6515
Primary 08 Secondary
Main Treatment Unit Code: 0 6 1 x 7
PART III - OTHER PERTINENT INFORMATION
1. Is this facility being constructed with Construction Grant
Funds or are any public monies involved. (municipals only)?
N/A
2. Special monitoring or limitations (including toxicity)
requests: None at, this time.
PART IV - EVALUATION AND RECOMMENDATIONS
Hidden Forest Mobile Home Park has applied for renewal of
NPDES Permit No. NC0065358. All upgrades and construction
activities have been completed.
WSRO recommends reissuance of this permit in accordance with
Division guidelines.
(It should be noted that the facility has experienced 15
monthly effluent limit violations since December 1994. Fast
Track Enforcement proceedings are'in progress)
// •a/ePlet
Environmental 'ngineer 1 Date
/C/2 /SS"
ter Quality egional Survisor Date