NC0059439_Draft Permit_20220906

ROY COOPER f., •R
Governor
ELIZABETH BISER ' ' t.
Secretary % 1
RICHARD E. ROGERS, Jr.
ww
Director
NORTH CAROLINA
Environmental Quality
September 06, 2022
The Honorable Brian Shelton, Mayor
Town of Rosman
PO Box 636
Rosman,North Carolina 28772-0636
Subject: Review of Draft Permit
NPDES NC0059439
Sapphire Lake WWTP#2
WPCS Class WW-I
Transylvania County
Mayor Shelton:
In response to your request to renew the subject NPDES permit,received tardy on August 19,
2022,the Division of Water Resources (DWR or the Division)hereby transmits this draft permit
for your review and comment. Please review this document carefully to assure your
understanding of the permit limits and monitoring conditions, and to correct errors, if any.
Concurrent with this notification, the Division will solicit public comment on this draft by
publishing a notice in newspapers having circulation in the general Transylvania County area,
P g
as required by the NPDES Program. Please provide your written comments, if any,to me via
email [[e-mail]], or write to my attention care of NCDEQ/DWR/NPDES
Program no later than October 7,2022, approximately 30 days after receiving this letter. Your
written comments are welcome but are not mandatory.
Summary of Changes
The Division understands from your Application to Renew that the Town of Rosman(Rosman)
has made no significant alterations to the subject wastewater treatment system since last renewal.
We have therefore made minimal changes to your permit to include updates to permit text and the
site vicinity map.
The NPDES standard conditions (Parts II, III, and IV), are part of this permit but are not included
in this draft document(cover,map, and Part I). The latest version of Parts II, III, and IV are
available at https://bit.ly/3k5NFaL and can be viewed online or downloaded as a PDF file.
North Carolina Department of Environmental Quality I Division of Water Resources
' 512 North Salisbury Street 1 1617 Mail Service Center I Raleigh,North Carolina 27699-1617-
919.707.3616

Brian Shelton,Mayor
Renewal DRAFT review
August 2022
Page 2
Following the mandatory 45-day public comment period, the Division will review all pertinent
comments, if any, and take appropriate action prior to issuing an NPDES permit final. If you have
questions, please email the undersigned at [joe.corporon(a ncdenr.gov]. Much of NC State
Government currently functions remotely considering emergency response to ('ovid 19, therefore
correspondence via email is preferred.
Respe lly,
Joe R. Corpor, n, P.G.
DEQ /DWR(NPDES Permitting
Enclosure: NPDES Permit NC0059421 (renewal DRAFT)
ec: NPDES Program Files/Laserfiche[draft permit and Fact Sheet]
WSRO/SWPS,Tim Heim;Landon Davidson, Supervisor
OCU,Maureen Kinney
Town of Rosman,William Wesley Royal ORC [[e-mail]]

Permit NC0059439
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENTAL QUALITY
DIVISION OF WATER RESOURCES
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
(NPDES)
In compliance with the provisions of North Carolina General Statute 143-215.1, other lawful standards
and regulations promulgated and adopted by#fe North Carolina Environmental Management
Commission, and the Federal Water Pollution control Act, as amended,
Town of Rosman
is hereby authorized to discharge wastewater from a facility located at the
Sapphire Lakes WWTP #2
Off US Highway 64'at Sapphire Lakes
Transylvania County
to receiving waters designated as James Creek in the Savannah River Basin in accordance with effluent
limitations,monitoring requirements, and other conditions set forth in Parts I, II, III and IV hereof.
This permit shall become effective 2022.
This permit and authorization to discharge shall expire at midnight on August 31, 2027.
Signed this day , 2022.
for Richard E. Rogers, Jr., Director
Division of Water Resources
By Authority of the Environmental Management Commission
Page 1 of 6

Permit NC0059439
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility, whether for operation or discharge are hereby
revoked. As of this permit issuance, any previously issued permit bearing this number is no longer
effective. Therefore,the exclusive authority to operate and discharge from this facility arises under the
permit conditions,requirements,terms, and provisions included herein.
Town of Rosman
is hereby authorized to:
1. continue to operate an existing 0.005 MGD wastewater treatment system utilizing the following
components
• dosing tank(1000-gallon)with siphon bell
• flow distribution manifold
• surface sand filter(25'x 30')
• tablet chlorination
• chlorine contact chamber
• tablet de-chlorination
• cascade aeration
these facilities located at Sapphire Lakes WWTP #2 off US Highway 64 near Round Top Mountain
at Sapphire Lakes,Transylvania County, and
2. discharge from said treatment works, at the location specified on the attached map, into James
Creek, a waterbody currently classified C+within hydrological unit 04-13-12 [HUC 0306010101] of
the Savannah River Basin.
Page 2 of 6

Permit NC0059439
PART I
A. (1.) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
[15 A NCAC 02B .0400 et seq.,02B .0500 et seq.WPCS Grade WW-I [15A NCAC 08G .0302]
Beginning on the effective date of this permit and lasting until expansion or expiration, the Permittee is
authorized to discharge from Outfall 001. Such discharges shall be limited, monitored, and reported 1
by the Permittee as specified below:
EFFLUENT LIMITS MONITORING REQUIREMENTS
CHARACTERISTICS Monthly Daily Measurement Sample
Parameter Code Average Maximum Frequency Sample Type Location 2
Flow(MGD) 50050 0.0049 Weekly Instantaneous I or E
Temperature(°C) 00010 Weekly Grab E
Total Residual Chlorine 3 50060 28 µg/L 2/Week Grab E
BOD, 5-day(20°C) C0310 30.0 mg/L 45.0 mg/L 2/Month Grab E
Total Suspended Solids C0530 — -30.0 mg/L 45.0 mg/L 2/Month Grab E
Fecal Coliform 31616 200/100 mL 400/100 mL 2/Month Grab E
(geometric mean)
pH Standard Units 00400 Not< 6.0 or> 9.0 s.u. 2/Month Grab E
Ammonia(NH3 as N) C0610 Monitor&Report 2/Month Grab E
Total Nitrogen(TN) C0600 Monitor&Report Semi-Annually Grab E
(NO2+NO3+TKN)
Total Phosphorus(TP) C0665 Monitor&Report Semi-Annually Grab E
1. The Permittee shall submit discharge monitoring reports electronically using the
Division's eDMR reporting system. [see A.(3.)].
2. I=Influent; E=Effluent
3. The Division shall consider compliant all effluent TRC values reported below 50 µg/L.
However,the Permittee shall continue to record and submit all values reported by a
North Carolina certified test method(including field certified),even if these values are
reported below 50 µg/L.
Conditions: The Permittee shall discharge no floating solids or foam visible in other than trace amounts.
Page 3 of 6

Permit NC0059439
A. (2.) ELECTRONIC REPORTING OF DISCHARGE MONITORING REPORTS
[G.S. 143-215.1(b)]
Federal regulations require electronic submittal of all discharge monitoring reports (DMRs) and program
reports. The final NPDES Electronic Reporting Rule was adopted and became effective on December
21, 2015.
NOTE: This special condition supplements or supersedes the following sections within Part II of this
permit(Standard Conditions for NPDES Permits):
• Section B. (11.) Signatory Requirements
• Section D. (2.) Reporting
• Section D. (6.) Records Retention
• Section E. (5.) Monitoring Reports
1. Reporting Requirements [Supersedes Section D. (2.) and Section E. (5.) (a)!
The permittee shall report discharge monitoring data electronically using the NC DWR's Electronic
Discharge Monitoring Report(eDMR) internet application.
Monitoring results obtained during the previous month(s) shall be summarized for each month and
submitted electronically using eDMR. The eDMR system allows permitted facilities to enter
monitoring data and submit DMRs electronically using the internet. The eDMR system may be
accessed at: https://deq.nc.gov/about/divisions/water-resources/edmr.
If a permittee is unable to use the eDMR system due to a demonstrated hardship or due to the facility
being physically located in an area where less than 10 percent of the households have broadband
access, then a temporary waiver from the NPDES electronic reporting requirements may be granted
and discharge monitoring data may be submitted on paper DMR forms (MR 1, 1.1, 2, 3)or
alternative forms approved by the Director. Duplicate signed copies shall be submitted to the
following address:
NC DEQ/Division of Water Resources/Water Quality Permitting Section
ATTENTION: Central Files
1617 Mail Service Center
Raleigh,North Carolina 27699-1617
See"How to Request a Waiver from Electronic Reporting" section below.
Regardless of the submission method,the first DMR is due on the last day of the month following
the issuance of the permit or in the case of a new facility, on the last day of the month following the
commencement of discharge.
Page 4 of 6

Permit NC0059439
Starting on December 21,2020, the permittee must electronically report the following compliance
monitoring data and reports, when applicable:
• Sewer Overflow/Bypass Event Reports;
• Pretreatment Program Annual Reports; and
• Clean Water Act(CWA) Section 316(b) Annual Reports.
NPDES Electronic Reporting Rule—Phase 2 Extension: EPA is proposing to extend the Phase 2
deadline from December 21, 2020 until at least December 21, 2023. The current compliance date
will be extended if the implementation date is extended as a final regulation change in the federal
register.
The permittee may seek an electronic reporting waiver from the Division(see"How to Request a
Waiver from Electronic Reporting" section below).
2. Electronic Submissions
In accordance with 40 CFR 122.41(1)(9), the permittee must identify the initial recipient at the time
of each electronic submission. The permittee should use the EPA's website resources to identify the
initial recipient for the electronic submission.
Initial recipient of electronic NPDES information from NPDES-regulated facilities means the entity
(EPA or the state authorized by EPA to implement the NPDES program)that is the designated entity
for receiving electronic NPDES data [see 40 CFR 127.2(b)].
EPA plans to establish a website that will also link to the appropriate electronic reporting tool for
each type of electronic submission and for each state. Instructions on how to access and use the
appropriate electronic reporting tool will be available as well. Information on EPA's NPDES
Electronic Reporting Rule is found at: https://www.federalregister.gov/documents/2015/10/22/2015-
24954/national-pol l utant-discharge-elimination-system-npdes-electronic-reporting-rule
Electronic submissions must start by the dates listed in the"Reporting Requirements" section above.
3. How to Request a Waiver from Electronic Reporting
The permittee may seek a temporary electronic reporting waiver from the Division. To obtain an
electronic reporting waiver, a permittee must first submit an electronic reporting waiver request to
the Division. Requests for temporary electronic reporting waivers must be submitted in writing to
the Division for written approval at least sixty(60) days prior to the date the facility would be
required under this permit to begin submitting monitoring data and reports. The duration of a
temporary waiver shall not exceed 5 years and shall thereupon expire. At such time,monitoring data
and reports shall be submitted electronically to the Division unless the permittee re-applies for and is
granted a new temporary electronic reporting waiver by the Division. Approved electronic reporting
waivers are not transferrable. Only permittees with an approved reporting waiver request may submit
monitoring data and reports on paper to the Division for the period that the approved reporting
waiver request is effective.
Information on eDMR and the application for a temporary electronic reporting waiver are found on
the following web page: http://deq.nc.gov/about/divisions/water-resources/edmr
Page 5 of 6

Permit NC0059439
4. Signatory Requirements (Supplements Section B. (11.) (b) and Supersedes Section B. (11.)
All eDMRs submitted to the permit issuing authority shall be signed by a person described in Part II,
Section B. (11.)(a)or by a duly authorized representative of that person as described in Part II,
Section B. (1 I.)(b). A person, and not a position,must be delegated signatory authority for eDMR
reporting purposes.
For eDMR submissions,the person signing and submitting the DMR must obtain an eDMR user
account and login credentials to access the eDMR system. For more information on North Carolina's
eDMR system,registering for eDMR and obtaining an eDMR user account,please visit the
following web page:
http://deq.nc.gov/about/divisions/water-resources/edmr
Certification. Any person submitting an electronic DMR using the state's eDMR system shall make
the following certification [40 CFR 122.22]. NO OTHER STATEMENTS OF CERTIFICATION
WILL BE ACCEPTED:
"I certify, under penalty of law, that this document and all attachments were prepared under my
direction or supervision in accordance with a system designed to assure that qualified personnel
properly gather and evaluate the information submitted. Based on my inquiry of the person or
persons who manage the system, or those persons directly responsible for gathering the information,
the information submitted is, to the best of my knowledge and belief true, accurate, and complete. I
am aware that there are significant penalties for submitting false information, including the
possibility of fines and imprisonment for knowing violations."
5. Records Retention (Supplements Section D. (6.)t
The permittee shall retain records of all Discharge Monitoring Reports, including eDMR
submissions. These records or copies shall be maintained for a period of at least 3 years from the
date of the report. This period may be extended by request of the Director at any time [40 CFR
122.41].
Page 6 of 6

✓ l f -\_ \ \ 1(IL 1 \ a + •� (,�.r c /-, ) 1 ..sue'-->-
•
t1._N\ •-'1' f ° ,,./,,t t }/` ,�") ,. t / I1
1 rii x` aC0 ',;1;\4 r.
��
r Jiff ''< l l t ,i— , ''.I 1 r , .
. i. i' l ff/:'` � �'
\ �AV ` L. o _'';. ,./ lit: l 1Lt.r
.^ j— �.� /! :-f 1 ' `l� \�l
i�_ tit I�
'4'1 (,. * , ‘, . ti \ I ,. si •,rr''''' / i , , / • ii\
' St
HWY I-64% t I '?r:. t ,
• • BM S 55 1 ' )13 ‘i• '
IL; 1 C •' i \� i i \I\ •`• \./\
r 1t 1� ' \
(.•
.",.. 4)...-.1 i ,.. ..•i ', `, ,., ‘Ntt; • '.• -.
,t Qfkland ;ti lli; ,
James Creek -
28a \ , `.: ` ' (flows S) •;••• e. , _ -t~ - ;i
•
•
1► 4,2
`-
/' t '\., 1/ 6 -_s ( / ✓` ' .. ' \ 3°p0�
�� ' /\ ,, :‘ 1 ' v, •sir•, , . , }
3\----'\
, ,-----,( -Z..-
t /r -•;N-. • ifs, \-: ( 1 f ' , ,
' �y --- �� J .__. trhdtop'
,ram • -1/ ,- , , - f ' r- ".
> ' � % \`�==M Outfall 001 t �,�� �% \ ,.��
! j^, s Flows SW • o nt . -'�r i t - _-
,;(,,i:,.e',Ls_l0._N_,.J,./...^JOK,r:..„2,„,, 1 1J C. ' 1. �� / f
\ J` '/P t r� 1' ,,/ t�/-1r ' .. `1�/ � 1�7 ..,V ' I t 1 `._s...
i4s
.-,-Th',1,1.
r1t.,,-C\,Y,,,s\\/i/, )//, A,).• i .-.,-'...-...--.,'.'',,'
.''-..-...-"--:-'-NsN•\,\-t._,/c.,,\'-.?I
'' `,.•,'" IJ (,} �• i \ ,�r•`- i `./► 1.
2r , 0 )64/7. __.._s0
„/,,4, .) t‘ 35-- ,,, iS-r5"-":7'.....------\--/- \':)2, ;,' 1-1 '...:3"..."---\-->"/,-......--.----,"—J i.. ,e',tC, ' /L. '''
,{_... •\j/:1(.....,
�\ \&• , J`'• Whitewater Rd.�' `- =' %' il / ,\` t```��fit_` `mod •�- /,o% �� �... 1 '' �• ? �
V '0) '-'>'' ') i ''' . j
i l,� �I( (7:("<, t �1,,.'0/ 1 (.I'/ .. _ram~1,_ 0 p: 1 iP
Town of Rosman Facility
Sapphire Lakes WWTP#2 Location
Latitude: 35°06'33" N State Grid/USGS: G7SW/Reid,NC not to scale
Longitude: 82°58'35" W HUC: 0306010101
Stream Class: C;Trout Hydrological Unit: 04-13-12
Permitted Flow: 0.005 MGD Receiving Stream: James Creek North NPDES Permit NC0059439
Transylvania County