NC0028827_Permit (Issuance)_20020715

NPDES DOCUMENT SCANNINii COVER SHEET
NC0028827
Snug Harbor WWTP
NPDES Permit:
Document Type:
Permit Issuance
Wasteload Allocation
Authorization to Construct (AtC)
Permit Modification
Complete File - Historical
Other [rating sheet]
Speculative Limits
Instream Assessment (67b)
Environmental Assessment (EA)
Permit
History
Document Date:
July 15, 2002
This docnrnent ins printed on reuse paper - ignore any
content on the resrerse side

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
William G. Ross, Jr., Secretary
Alan W. Klimek, P.E., Director
July 15, 2002
Mr. F. Patrick Ausband
Snug Harbor at Sea Level, Inc.
P.O. Box 150
Sea Level, North Carolina 28577
AVA
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Issuance of NPDES Permit NC0028827
Snug Harbor WWTP
Carteret County
Dear Mr. Ausband:
Division personnel have reviewed and approved your application for renewal of the subject permit.
Accordingly, we are forwarding the attached NPDES discharge permit. This permit is issued pursuant
to the requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement
between North Carolina and the U.S. Environmental Protection Agency dated May 9, 1994 (or as
subsequently amended).
The Total Residual Chlorine monitoring has been reduced to 2/week to correspond to the facility's
class II rating. However, please note that this facility is discharging high amounts of total residual
chlorine (TRC). The average TRC concentration in the effluent should be below 28 µg/L (0.028 mg/L).
This facility discharged concentrations well above 28 µg/L during 2000 and 2001. Unless these
concentrations are reduced, the Division may reopen this permit to include a chlorine limit and/or
require dechlorination facilities.
If any parts, measurement frequencies or sampling requirements contained in this permit are
unacceptable to you, you have the right to an adjudicatory hearing upon written request within thirty
(30) days following receipt of this letter. This request must be in the form of a written petition,
conforming to Chapter 150B of the North Carolina General Statutes, and filed with the Office of
Administrative Hearings (6714 Mail Service Center, Raleigh, North Carolina 27699-6714). Unless
such demand is made, this decision shall be final and binding.
Please note that this permit is not transferable except after notice to the Division. The Division may
require modification or revocation and reissuance of the permit. This permit does not affect the legal
requirements to obtain other permits which may be required by the Division of Water Quality or
permits required by the Division of Land Resources, the Coastal Area Management Act or any other
Federal or Local governmental permit that may be required.
If you have any questions concerning this permit, please contact Christie Jackson at telephone
number [phone], extension 538.
Sincerely,
ORIGINAL SIGNED BY
SUSAN A. WILSON
Alan W. Klimek, P.E.
cc: Central Files
Wilmington Regional Office/Water Quality Section
NPDES Unit
1617 Mail Service Center, Raleigh, North Carolina 27699.1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer VISri US ON THE INTERNET @ httpJ/h2o.enr.state.nc.usNNPDES

Permit NC0028827
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
Snug Harbor at Sea Level, Inc.
is hereby authorized to discharge wastewater from a facility located at the
Snug Harbor WWTP
272 US Highway 70
northwest of Sea Level
Carteret County
to receiving waters designated as Salters Creek in the White Oak River Basin
in accordance with effluent limitations, monitoring requirements, and other
conditions set forth in Parts I, II, III and IV hereof.
This permit shall become effective August 1, 2002.
This permit and authorization to discharge shall expire at midnight on July 31, 2007.
Signed this day July 15, 2002.
ORIGINAL SIGNED BY
SUSAN A. WILSON
Alan W. Klimek, P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission

Permit NC0028827
SUPPLEMENT TO PERMIT COVER SHEET
Snug Harbor at Sea Level, Inc. is hereby authorized to:
1. Continue to operate an existing 0.02 MGD wastewater treatment system with the
following components:
• Flow equalization with dual pumps and aeration
• 5 aeration basins
• Dual clarifiers
• Dual high rate mixed media tertiary filters
• Aerated sludge digester
• Recorder and flume
• Hypochlorinator
• Aerated effluent pump station
• Standby power
The facility is located northwest of Sea Level at Snug Harbor WWTP at 272 US
Highway 70 in Carteret County.
2. Discharge from said treatment works at the location specified on the attached
map into Salters Creek, classified SC waters in the White Oak River Basin.

Latitude: 34°53'27"
Longitude: 76°24'00"
guad # H33NW
Receiving Stream: Salters Creek
Stream Class: SC
Subbasin: 030504
NC0028827 Snug Harbor at Sea Level WWTP
Carteret County

Permit NC0028827
A. (1.) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS - FINAL
During the period beginning on the effective date of this permit and lasting until
expiration, the Permittee is authorized to discharge from outfall 001. Such discharges
shall be limited and monitored by the Permittee as specified below:
EFFLUENT
CHARACTERISTICS
LIMITS
MONITORING REQUIREMENTS
Monthly.
Average
Weekly
Average
Daily
Maximum
Measurement
Frequency
Sample Type
Sample Location1
Flow
0.020 MGD
Weekly
Instantaneous
Influent or Effluent
BOD, 5-day (202C)
30.0 mg/L
45.0 mg/L
Weekly
Grab
Effluent
Total Suspended Residue
30.0 mg/L
45.0 mg/L
Weekly
Grab
Effluent
NH3 as N
2/Month
Grab
Effluent
Dissolved 0xygen2
Weekly
Grab
Effluent
Fecal Coliform (geometric mean)
14/100 ml
28/100 ml
Weekly
Grab
Effluent
Total Residual Chlorin&
2/week
Grab
Effluent
Temperature (4C)
Weekly
Grab
Effluent
pH4
Weekly
Grab
Effluent
Footnotes:
1. Downstream = at the Fish House.
2. The daily average dissolved oxygen effluent concentration shall not be less than 5.0 mg/L.
3. Toxicity testing and/or dechlorination may be required in the future if Total Residual
Chlorine effluent levels are not significantly reduced.
4. The pH shall not be less than 6.8 standard units nor greater than 8.5 standard units.
There shall be no discharge of floating solids or visible foam in other than trace amounts

07101092000
07512734
Page 1
Affidavit of Publication
Daily News
Jacksonville, NC
Pers s nally ap • eared before me, a Notary Public of the County of Onslow, State of North Carolina,
o the ;�tgtlLLt._2
of l wily News, o . -ing y sworn, states that the advertisement entitled RE: NPDES PERMIT
a true copy of which is printed herewith, appeared in The Daily News, a newspaper published in the
City of Jacksonville, County of Onslow, State of North Carolina, Jw, ..- _ on the
following dates: May 4, 2002
PUBLIC NOTICE
State of North Carolina
Environmental Management
Commission/NPDES Unit
1617 Mail Service Center
Raleigh, NC 27699-1617
Notification of Intent to Issue a NPDES Wastewater Permit
On the basis of thorough staff review and application of NC General Statute 143.21. Public law 92-500 and
other lawful standards and regulations, the North Carolina Environmental Management Commission
proposes to issue a National Pollutant Discharge Elimination System (NPDES) wastewater discharge permit
to the person(s) listed below effective 45 days from the publish date of this notice.
NPDES Permit Number NC0028827, Snug Harbor at Sea Level, Inc., P.O. Box 150, Sea Level, NC 28577
has applied for a permit renewal for a facility located in Carteret County discharging treated wastewater into
Salters Creek in the White Oak River Basin. Currently fecal coliform are water quality limited. This discharge
may affect future allocations in this portion of the receiving stream.
Written comments regarding the proposed permit will be accepted until 30 days after the publish date of this
notice. All comments received prior to that date are considered in the final determinations regarding the
proposed permit. The Director of the NC Division of Water Quality may decide to hold a public meeting for
the proposed permit should the Division receive a significant degree of public interest.
Copies of the draft permit and other supporting information on file used to determine conditions present in
the draft permit are available upon request and payment of the costs of reproduction. Mail comments and/or
requests for information to the NC Division of Water Quality at the above address or call Ms. Christie
Jackson at [phone], extension 538. Please include the NPDES per number (attached in any
communication. Interested persons may also visit the Division of Water Quality at 512 N. Salisbury Street,
Raleigh, NC 27604-1148 between the hours of 8:00 a.m. and 5:00 p.m. to review information on file.
May 4, 2002
07101092000
07512734
Page 2
Affidavit of Publication
Daily News
Jacksonville, NC
Subscribed and sworn to this 4th day of May, 2002
x(?Ol .C-. ,
Notary Public
MY COMMIYSSION EXPIRES
JUL2, 2002
Cry

SOC PRIORITY PROJECT: NO
If Yes, SOC No.
To: Permits and Engineering Unit
Water Quality Section
—Attention: Christie Jackson
(Review Engineer)
Date: April 17, 2002
NPDES STAFF REPORT AND RECOMMENDATION
County: Carteret
Permit No. NC0028827
PART I - GENERAL INFORMATION
I. Facility and Physical location: Mailing Address:
APR 1 8 2002
D+EliR - WATER QU L/
POINT SCUriCE BRANCH
Snug Harbor on Nelson Bay P.O. Box 150
US Highway 70 Sea Level, North Carolina 28577
2. Date of Investigation: April 16, 200 f'
3. Report Prepared by: Mike Williams t /.4.
4. Contact Persons and Telephone Number:
Mr. Patrick Ausband, Executive Director (252)225-441 1
5. Directions to Site: From Beaufort, N.C., travel northeast along US Highway 70,
through Bettie, Smyrna, and Davis, NC. , to the Nelson Bay Bridge at Salters
Creek. Immediately beyond the bridge, the Highway divides into US Highway
70 and NC Highway 12. Bear right on US Highway 70. The facility is 400 feet
on the right (southwest) side of the highway. The WWTP is to the right upon
entrance down a narrow, thickly wooded driveway.
6. Discharge Point's), List for all discharge points:
Latitude: 34 53 27 Longitude: 76 24 00
Attach a USGS map extract and indicate treatment facility site and discharge point on
map.
U.S.G.S. Quad No: H-33 NW U.S.G.S. Quad Name: Long Bay

7. Site size and expansion area consistent with application? N/A
8. Topography (relationship to flood plain included): The site is located on flat
parcel of land adjacent to a tidal creek of approximately 5 to10 feet AMSL.
9. Location of nearest dwelling: Within 300 to 400 feet of the facility. No other
homes within Y2 mile.
10. Receiving stream or affected surface waters: Salters Creek in the White Oak
River Basin.
a. Classification: Class "SC" waters
b. River Basin and Subbasin No.: 03-05-04
c. Describe receiving stream features and pertinent downstream uses: Salters
Creek is a tidal tributary to Nelson Bay and Core Sound, Classified "SA".
Downstream uses include fishing, harvesting of shellfish and secondary
recreation.
PART II - DESCRIPTION OF DISCHARGE AND TREATMENT WORKS
1. a. Volume of Wastewater to be permitted: 0.02 MGD
b. What is the current permitted flow limit? Same
c. Actual treatment capacity of the current facility? 0.02 MGD
d. Date(s) and construction activities allowed by previous Authorizations to
Construct issued in the previous two years: None
e. Please provide a description of existing or substantially constructed
wastewater treatment facilities: The WWTP consists of aerated flow
equalization, with 2 pumps, 5 aeration basins, dual clarifiers, dual high rate
mixed media tertiary filters, aerated sludge digester, liquid hypochlorinator
chlorination, contact tank, and post aeration, flow measuring, effluent
pump station, and standby power.
f. Please provide a description of proposed wastewater treatment facilities:
None proposed.
g. Possible toxic impacts to surface waters: None anticipated.

h. Pretreatment Program (POTWs only): N/A
in development
should be required
approved
not needed X
2. Residuals handling and utilization/disposal scheme: Land Application
If residuals are being land applied, please specify DWQ Permit No.
WQ0000455
Residuals Contractor: Russell Lewis Farms
3. Treatment plant classification: Class II
4. SIC Code(s): 8052
Wastewater Code(s) Primary: 11 Secondary:
Main Treatment Unit Code:
PART 1I1 - OTHER PERTINENT INFORMATION
1. Is this facility being constructed with Construction Grant Funds or are any public
monies (municipals only) involved? No
2. Special monitoring or limitations (including toxicity) requests: limitations and
monitoring requirements in accordance with the basin -wide permitting strategy.
3. Important SOC, JOC or Compliance Schedule dates: N/A
Date
Submission of Plans and Specifications N/A
Begin Construction: N/A
Complete Construction: N/A
4. Alternative Analysis Evaluation: Has the facility evaluated all of the non -
discharge options available? Please provide regional perspective for each option
evaluated.
Spray Irrigation: Insufficient and low-lying land area
Regional System: Too far from population
Subsurface: High water table
Other disposal options: N/A

b. Other Special Items: See evaluation
PART IV - EVALUATION AND RECOMMENDATIONS
The 120 bed nursing and retirement facility is served by the above ground
concrete extended aeration plant. The plant has generally been in compliance with the
NPDES permit conditions and limitations. The plant was found to be in good condition
at the time of the inspection. The effluent was clear and free of solids and no problems
were observed.
It is recommended that a permit be drafted and placed at public notice, If no
significant adverse comments are received, it is recommended that NPDES permit
NC0028827 be reissued to Snug Harbor on Nelson Bay, in accordance with the basin -
wide permitting strategy.
Signature of R-port Preparer Date
Water Quality Regional Supervisor
Snugharb.npd.
cc: Wilmington Regional Office
Central Files
C-Gh ® e J- t , 2 O0 -

PERMIT NUMBER: NC0028827
FACILITY NAME: Sailor's Snug Harbor WWTP
CITY: Sealevel
OUTFALL: 001
COUNTY: Carteret
PERIOD ENDING MONTH: 12 - 2001
REGION: Wilmington
PAGE 1 OF 2
00010
deg c
TEMPERATURE,
WATER DEG.
CENTIGRADE
00300
mg/1
DO, Oxygen,
Dissolved
00310
mg/1
BOD, 5-DAY
(20 DEG. C)
00340
mg/1
COD, Oxygen
Demand, Chem.
(High Level)
00400
su
PH
00530
mg/1
SOLIDS, TOTAL
SUSPENDED
00545
ml/1
SOLIDS,
SETTLEABLE
00600
my/1
NITROGEN, TOTAL
(AS N)
1 - 01
,.3()
11
8.7
3.6
8 - 8.3
8.4
2 01
30
14
8.1
3.8
8.1 - 8.3
6.6
3-01
14
9
2.8
8 - 8.3
6.7
4 - 01
,A,
18
8.8
8.1 - 8.6 V
4.6
5 - 01
'`,
21
8
2.9
8 - 8.3
5.2
6-01
25
7.25
4.9
8.1 - 8.3
4.7
7-01
G
25
7.75
2.65
8 - 8.3
1.8
8 - 01
:>G
G
26
8.2
2.5
7.9-8.3
1.5
9 - 01`'
24
7.5
2.3
8-8.2
3
10 - 01
;{0
20
8
2.1
8-8.2
4
11-01
12-01
"'

PERMIT NUMBER: NC0028827
FACILITY NAME: Sailor's Snug Harbor WWTP
CITY: Sealevel
OUTFALL: 001
COUNTY: Carteret
PERIOD ENDING MONTH: 12 - 2001
00610
mg/1
NITROGEN,
AMMONIA TOTAL
(AS N)
00665
mg/1
PHOSPHORUS,
TOTAL(AS P)
31616
#/100m1
COLIFORM, FECAL
MF, M-FC
BROTH,44.5C
50050
mgd
FLOW, IN
CONDUIT OR THRU
TREATMENT PLANT
50060
ug/1
CHLORINE,
TOTALRESIDUAL
1 - 01
1.1
0.006
296
2-01
1.6
0.007
324
3-01
0.05
1
0.007
430
4-01
1.1
0.007
391
5-01
1.62
1.1
0.007
0.31
6-01
0.1
1.7
"`
0.008
0.31
7-01
0.1
1
0.008
0.41
8-01
0.08
0.008
0.26
9-01
0.1
1.7
0.006
0.22
10-01
0.44
1.1
0.007
0.34
11 - 01"
12-01
REGION: Wilmington
PAGE 2 OF 2

PERMIT NUMBER: NC0028827
FACILITY NAME: Sailor's Snug Harbor WWTP
CITY: Sealevel
OUTFALL: 001
COUNTY: Carteret
PERIOD ENDING MONTH: 12 - 2000
REGION: Wilmington
PAGE 1 OF 2
00010
deg c
TEMPERATURE,
WATER DEG.
CENTIGRADE
00300
mg/1
DO, Oxygen,
Dissolved
00310
mg/1
BOD, 5-DAY
(20 DEG. C)
00400
su
PH
00530
mg/1
SOLIDS, TOTAL
SUSPENDED
00610
mg/1
NITROGEN,
AMMONIA TOTAL
(AS N)
31616
#/100m1
COLIFORM, FECAL
MF, M-FC
BROTH,44.5C
50050
mgd
FLOW, IN
CONDUIT OR THRU
TREATMENT PLANT
1 - 00
30
30
0.02
11
8.4
5.8
7.9 - 8.2
11
0.006
2 - 00
30
30
0.02
13
8.9
3.8
8.1 - 8.3
11.1
0.04
0.006
3 - 00
30
30
0.02
17
8
3.18
8-8.3
2
0.007
4 - 00
30
30
0.02
18
8.5
3.3
8-8.3
3.1
0.7
0.007
5 - 00
30
30
0.02
22
8.9
3.7
8 - 8.2
2.5
0.05
0.007
6 - 00
30
30
0.02
24
9
3.9
7.4 - 8.2
2.9 .
0.09
0.006
7 - 00
30
30
0.02
26
9.05
2.75
8 - 8.3
7.9
0.1
0.007
8 - 00
30
30
0.02
25
8.2
2.12
7.8 - 8.3
4.4
0.12
0.008
9 - 00
30
30
0.02
26
7.95
2.4
7.8 - 8.3
4
0.007
10-00
30
30
0.02
20
8.9
2.5
7.8 - 8.1
5.2
0.12
0.006
11 - 00
30
30
0.02
15
9.12
4.08
7.9 - 8.2
5.2
0.06
0.007
12 - 00
30
30
0.02
12
8.3
2.15
8 - 8.2
8.2
0.06
0.006

PERMIT NUMBER: NC0028827
FACILITY NAME: Sailor's Snug Harbor WWTP
CITY: Sealevel
1 - 00
2-00
3-00
4-00
5-00
6-00
7-00
8-00
9-00
10-00
11 - 00
12-00
50060
ug/1
CHLORINE,
TOTALRESIDUAL
648
625
516
599
548
505
510
348
790
507
531
640
OUTFALL: 00l
COUNTY: Carteret
PERIOD ENDING MONTH: 12 - 2000
REGION: Wilmington
PAGE 2 OF 2

Snug 9larbor
on 9elson 'Bag
Mrs. Valery Stephens
NCDENR/ Water Quality/ Point Source Branch
1617 Mail Service center
Raleigh, NC 27699-1617
Re: Renewal NPDES Permit No. NC0028827
Mrs. Stephens;
1D
i(�
&a.J
29 January, 2002 (3s)
Please accept this letter as a request to renew our permit to operate a
wastewater treatment facility for Snug Harbor at Sea Level, Inc.
Enclosed, please find an original and two (2) copies each of the
completed application, map showing discharge location, and description of
sludge management.
Should you have any questions or require any additional information,
please do not hesitate to contact me.
Sincerely,
F. Patrick Ausband
Executive Director
FPA/bcd
N
CV
m
I
90 'Box 150 cSea.2eoel, 9YC 28577 252-225-4411

• 4 '_ \•
(Snug 9Iirbor
on 9Yelson Bag
29 January, 2002
Re: Sludge management plan for Snug Harbor at Sea Level, Inc. NPDES Permit
No. NC0028827.
Our sludge is removed from our facility by Lewis Farms and Liquid Waste,
6455 Piney Woods Road, Watha, NC 28471. We are listed on their permit
number WQ0000455.
F. Patrick Ausband
Executive Director
FPA/bcd
nl.O Box 150 cSea.eevel, 9'C26577 252-225-4411

NPDES PERMIT APPLICATION - SHORT FORM D
To be filed only by dischargers of 100% domestic wastewater (<1 MGD flow)
N. C. Department of Environment and Natural Resources
- • Division of Water quality / NPDES Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
North Carolina NPDES Permit Number
(if known)
NCOO 9 227
• Please print or type
1. Mailing address - of applicant/permittee:
Facility Name
Owner Name
Street Address
City
State
ZIP Code
Telephone Number
Fax Number
e-mail Address
SAI 4 1-/.4.M2 N e .
SA-mE '
1.7a.. Ngiv/70 P.c0IkOX t50.
•
7-1377
( 2S-2) Jive/
(---a ) 1'.s- /474, •
2. Location of facility producing discharge:
Name (If different from above)
Facility Contact Person _
Street Address or State Road
City/Zip Code
County
Telephone Number
S. Reason for application:
• Expansion/Modification
K ..4 j.51a 4 31 ..
5y, A E` VV ._Z.. Nam. 2.515 7
CAA TVZ5
(2S'2) 2 -Vv//
Existing Unpermitted Discharge
Renewal New Facility
* Please provide a description of the expansion/modification:
4. Description of the existing treatment facilities (list all installed components with
capacities):
O. 0 "a..
E ,4 0 4-
Page 1 of 2
Version 11/2000

NPDES PEST APPLICATION - SHORT FORM D
To be filed only by dischargers of 100% domestic wastewater (<1 MGD flow)
5. Description of wastewater (check all that apply):
Type of Facility Generating Wastewater
Industrial . • ; • - •Number of Employees
Commercial Number of Employees
Residential - .Number of Homes
School Number of Students/Staff
Other
Describe the source(s) of wastewater (example: subdivision, mobile home park, etc.) :
• 6. Number of separate wastewater discharge pipes (wastewater outfalls):
D P
7. If the facility has multiple discharge outfalls, record the source(s) of wastewater for each
outfall:
8. Name of receiving streams) (Provide a map showing the exact location of each outfan):
SA-,-t./4s 6Rai<
I certify that I am familiar with the information contained in the application and that to the
best of my knowledge and belief such information is true, complete, and accurate.
C:F7
./i1)4/‹.
Printed Nance of Person Si
• .�:t
Title
/'i-8v2--
Sign'tje of Applicant ' Date Signed
North Carolina General Statute 143-215.6E (I) provides that Any person who knowingly makes any false statement representation, or
certification in any application, record, report, plan, or other document files or required to be maintained under Article 21 or regulations of the
Environmental Management Commission implementing that Article, or who falsifies, tampers with, or knowingly renders inaccurate any
recording or monitoring device or method required to be operated or maintained under Article 21 or regulations of the Environmental
Management Commission implementing that Article, shaU be guilty of a misdemeanor punishable by a fine not to exceed $10,000, or by
imprisonment not to exceed six months, or by both.. (18 U.S.C. Section 1001 provides a punishment by a fine of not more than $10,000 or
imprisonment not more than 5 years, or both for a similar offense.)
Page 2 of •2 Version 11/2000