NC0024376_Authorization to Construct_19940126

•
State of North Carolina
Department of Environment,
Health and Natural Resources j • •
Division of Environmental Management f
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary E E H Ni Ft
A. Preston Howard, Jr., P.E., Director
January 26, 1994
Mr. Ken Hay
The Wilds Christian Camp
P.O. Box 796
Taylors, SC 29687
Subject: Permit No. NC0024376
Authorization to Construct
The Wilds Christian Camp
Wastewater Treatment Facility
Transylvania County
Dear Mr.Hay:
A letter of request for an Authorization to Construct was received May 27, 1993 by the Division
and final plans and specifications for the subject project have been reviewed and found to be satisfactory.
Authorization is hereby granted for the construction of an addition to an existing 20,000 gallon per day
treatment facility consisting of a 16,000 gallon equalization basin, a three outlet flow splitter box, dual
30,000 gallon aeration basins, triplex clarifier chambers providing a minimum of four hours detention time
at design flow, a maximum surface loading rate of 200 gallons per day per square foot and a weir loading
rate of 2500 gallons per day per foot, three inch diameter air lift sludge return lines,positive scum return
system, triplex blowers capable of delivering 300 cubic feet per minute of air, chlorine contact chamber
providing a minimum of thirty(30) minutes of contact time at the design flow, duplex tablet chlorinators,
duplex tablet dechlorinators,conversion of existing flow equalization basin to a sludge holding tank and all
necessary piping, pumps and appurantances with discharge of treated wastewater into Toxaway Creek in
the Savannah River Basin.
This Authorization to Construct is issued in accordance with Part III, Paragraph A of NPDES
Permit No. NC0024376 issued June 18, 1993, and shall be subject to revocation unless the wastewater
treatment facilities are constructed in accordance with the conditions and limitations specified in Permit No.
NC0024376.
The sludge generated from these treatment facilities must be disposed of in accordance with.G.S.
143-215.1 and in a manner approved by the North Carolina Division of Environmental Management.
In the event that the facilities fail to perform satisfactorily, including the creation of nuisance
conditions, the Permittee shall take immediate corrective action,including those as may be required by this
Division, such as the construction of additional or replacement wastewater treatment or disposal facilities.
The Asheville Regional Office, telephone number(704)251-6208, shall be notified at least forty-
eight (48) hours in advance of operation of the installed facilities so that an in-place inspection can be
made. Such notification to the regional supervisor shall be made during the normal office hours from 8:00
a.m. until 5:00 p.m. on Monday through Friday, excluding State Holidays.
P.O.Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50%recycled/10%post-consumer paper

Permit No. NC0024376
Authorization to Construct
The Wilds Christian Camp
January 26, 1994
Page 2
Upon completion of construction and prior to operation of this permitted facility, a certification
must be received from a professional engineer certifying that the permitted facility has been installed in
accordance with the NPDES Permit, this Authorization to Construct and the approved plans and
specifications. Mail the Certification to the Permits and Engineering Unit,P.O. Box 29535, Raleigh,NC
27626-0535.
Upon classification of the facility by the Certification Commission, the Permittee shall employ a
certified wastewater treatment plant operator to be in responsible charge (ORC)of the wastewater treatment
facilities. The operator must hold a certificate of the type and grade at least equivalent to or greater than the
classification assigned to the wastewater treatment facilities by the Certification Commission. The
Permittee must also employ a certified back-up operator of the appropriate type and grade to comply with
the conditions of Title 15A, Chapter 8A, .0202. The ORC of the facility must visit each Class I facility at
least weekly and each Class II, III, and IV facility at least daily, excluding weekends and holidays, and
must properly manage and document daily operation and maintenance of the facility and must comply with
all other conditions of Title 15A, Chapter 8A, .0202. Once the facility is classified, the Permittee must
submit a letter to the Certification Commission which designates the operator in responsible charge within
thirty days after the wastewater treatment facilities are 50%complete.
A copy of the approved plans and specifications shall be maintained on file by the Permittee for the
life of the facility.
Failure to abide by the requirements contained in this Authorization to Construct may subject the
Permittee to an enforcement action by the Division of Environmental Management in accordance with
North Carolina General Statute 143-215.6A to 143-215.6C.
The issuance of this Authorization to Construct does not preclude the Permittee from complying
with any and all statutes, rules, regulations, or ordinances which may be imposed by other government
agencies (local, state, and federal)which have jurisdiction.
One (1) set of approved plans and specifications is being forwarded to you. If you have any
questions or need additional information,please contact Mr. Sean D. iGoris, telephone number 919/733-
5083.
Sin rely,
•
Ai
Preston ' ., Jr., P.E.
cc: Transylvania County Health Department
Asheville Regional Office,Water Quality
Training and Certification Unit