NC0085626_Permit (Issuance)_20020408

NPDES DOCUMENT SCANNING COVER SHEET
NPDES Permit:
NC0085626
Madison WTP
j, .aM.Ai94:.resLbrypny.�- f.•+�`�
Document Type:(
Permit Issuance
Wasteload Allocation
Authorization to Construct (AtC)
Permit Modification
Complete File - Historical
Engineering Alternatives (EAA)
Staff Report
Instream Assessment
(67b)
Environmental
Assessment (EA)
Permit
History
Document Date:
April 8, 2002
This document is printed on reuse paper - 'more any
content 011 the re -sr -erne aide

OFi=4:i9
PG 4R A
r NCDENR
Mr. Micheal O. Morrison
Utilities Director
120 North Market Street
Madison, North Carolina 27025
Dear Mr. Morrison:
Michael F. Easley
Governor
William G. Ross, Jr., Secretary
North Carolina Department of Environment and Natural Resources
Gregory J. Thorpe, Ph.D., Acting Director
Division of Water Quality
April 8, 2002
Subject Issuance of NPDES Permit NC0085626
Madison WTP
Rockingham County
Division personnel have reviewed and approved your application for renewal of the subject permit.
Accordingly, we are forwarding the attached NPDES discharge permit. This permit is issued pursuant to the
requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement between North
Carolina and the U.S. Environmental Protection Agency dated May 9, 1994 (or as subsequently amended).
Please note that the requirements of this permit will take effect on June 1, 2002. Until May 31, 2002, your
existing permit will remain in effect.
If any parts, measurement frequencies or sampling requirements contained in this permit are unacceptable to
you, you have the right to an adjudicatory hearing upon written request within thirty (30) days following receipt of
this letter. This request must be in the form of a written petition, conforming to Chapter 150B of the North Carolina
General Statutes, and filed with the Office of Administrative Hearings (6714 Mail Service Center, Raleigh, North
Carolina 27699-6714). Unless such demand is made, this decision shall be final and binding.
Please note that this permit is not transferable except after notice to the Division. The Division may require
modification or revocation and reissuance of the permit. This permit does not affect the legal requirements to obtain
other permits which may be required by the Division of Water Quality or permits required by the Division of Land
Resources, the Coastal Area Management Act or any other Federal or Local governmental permit that may be
required.
If you have any questions concerning this permit, please contact Charles Weaver at telephone number (919)
733-5083, extension 511.
cc: Central Files
Winston-Salem Regional Office/Water Quality Section
NPDES Unit
N. C. Division of Water Quality / NPDES Unit
1617 Mail Service Center, Raleigh, NC 27699.1617
Internet: h2o.enr.state.nc.us
Sincerely,
ORIGINAL SIGNED BY
SUSAN A, WILSON
Gregory J. Thorpe, Ph.D.
Phone: [phone]
fax: [phone]
DENR Customer Service Center: 1 800 623-7748

Permit NC0085626
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended, the
Town of Madison
is hereby authorized to discharge wastewater from a facility located at the
Madison WTP
403 Lindsey Bridge Road
Madison
Rockingham County
to receiving waters designated as an unnamed tributary to Big Beaver Island Creek
in the Roanoke River Basin in accordance with effluent limitations, monitoring
requirements, and other conditions set forth in Parts I, II, III and IV hereof.
This permit shall become effective June 1, 2002.
This permit and authorization to discharge shall expire at midnight on May 31, 2007.
Signed this day April 8, 2002.
ORIGINAL SIGNED BY
SUSAN A. WILSON
Gregory J. Thorpe, Ph.D., Acting Director
Division of Water Quality
By Authority of the Environmental Management Commission

Permit NC0085626
SUPPLEMENT TO PERMIT COVER SHEET
The Town of Madison is hereby authorized to:
1. Continue to operate a drinking -water treatment plant with a discharge of filter -
backwash wastewater. This facility is located west of Madison on Lindsey Bridge
Road at the Madison WTP in Rockingham County.
2. Discharge from said treatment works at the location specified on the attached
map into an unnamed tributary to Big Beaver Island Creek, classified C waters
in the Roanoke River Basin.

4°30
970 000
FEET
NV/LLE H
4026
36' 22'302+
801'00'
591 1 710 000 FEET
593 57'30"
Quad: Mayodan, N.C.
Latitude: 36°22'45"
Longitude: 79°59'04"
Stream Class: C
Subbasin: 30202
Receiving Stream: UT Big Beaver Island Creek
NC0085626
Town of Madison WTP
North
SCALE 1:211000

Permit NC0085626
A. (1.) EFFLUENT LIIVIITATIONS AND MONITORING REQUIREMENTS
During the period beginning on the effective date of this permit and lasting until expiration, the Permittee is
authorized to discharge filter backwash from outfall 001. Such discharges shall be limited and monitored by
the Permittee as specified below:
EFffFLUIlE/NT ` '.
CHARAC ERI8T IC
•. , : ��:
' -.. ,„_..�. --. 7 .
__1 LIMITS
..7 7 . a. fl } r•
= _._.
t zy , t ONITO.EING
... _,, - fi!^
REQ DIRE fEt T9 :
- t ~, ..t 4 'Y 1
, dnthlt: =
� . �lTuera ...
DaII
.;l�C.a u! ._..
ea' m `,
�..reg9eric ;'
=Sample 1yp
r. - _... _
. Sample Locatloni ,
; ` ..: 4
Row
Weekly
Estimate
Effluent
Total Suspended Solids
30.0 mglL
45.0 mg&
2/Month
Grab
Effluent
Settleable Solids
0.1 mVL
0.2 mVL
Weekly
Grab
• Effluent
Turbidity2
Weekly
Grab
Upstream & Downstream
Iron
Weekly
Grab
Effluent
_ -:
Total Residual Chlorine
l
��
/5/,
Weekly
Grab
Effluent
Aluminum
`
Weekly
\ }
Grab
Effluent
Footnotes:
1. Upstream = at least 100 feet upstream from tite outfall. Downstream = at least 100 feet downstream from
the outfall.
2. The discharge from this facility shall not caus turbidity in the receiving stream to exceed 50 NTU. If the
instrearn turbidity exceeds 50 NTU due to natu al background conditions, the discharge cannot cause
turbidity to increase in the receiving stream.
All samples collected should be from a rep sentative discharge event.
There shall be .no discharge of floating solid or visible foam in other than trace amounts.

Eribmiittr Tgruirtu 6
1921 Vance Street • PO Box 2157 •Reidsville, NC 27320 • 336-349-4331w\
PUBLIC NOTICE
STATE OF NORTH
CAROLINA
ENVIRONMENTAL
L MANAGEMENT
COMMISSION/NPDES
UNIT
1617 MAIL SERVICE
CENTER
RALEIGH, NC 27699-
1617
NOTIFICATION OF
INTENT TO ISSUE A
NPDES WASTE
WATER PERMIT
On the basis of thorough
staff review and application
of NC General Statute 14321,
Public law 92-500 and other
lawful standards and
regulations, the North Cerc6na
environmental Management
Commission proposes to
issue a National Pollutant
Discharge Elimination System
(NPDES) waster water
discharge permit to the
person(s) listen below
effective 45 days from the
publish date of this notice.
Written comments regard
ing the proposed permit will
be accepted until 30 days
after the publish date of this
notice. All comments received
prior to that date are
considered in the final
determinations regarding the
proposed permit. The Director
of the NC Division of Water
Quality may decide to hold a
public meeting for the
proposed permit should the
Division receive a significant
degree of public interest.
Copies of the draft permit
and other supporting
information on file used to
determine conditions present
in the draft permit are
available upon request and
payment of the costs of
reproduction. Mad comments
ardor requests for information
to the NC Division -of Water
Quality at the above address
or call Ms. Christie Jackson
at [phone], extension
538. Please include the
NPDES permit number
(attached) in any
communication. Interested
persons may also visit the
Division of Water Quality at
512 N. Salisbury Street,
Raleigh, NC 27604-1148
between the hours of 8:00
a.m. and 5:00 p.m. to review
information on file.
NPDES Permit Number
NC0085626. Town of
Madison (WTP) 120 North
Market Street, Madison, NC
27025 has applied for a permit
rPnpwal far a farll;h, In....+-..J
r� Hocktnrgham County
discharging filter -backwash
waste water into an unnamed
tributary to Big Beaver Island
Creak in the Roanoke River
I Basin. Currently no
parameters are water quality
limited. This discharge may
affect future allocations in
this portion of the receiving
stream.
NPDES Permit Number
NC0060542. Mr. Bryan Neal
(Gold
W P)."'17l60Hsi psonore the undersigned, a Notary Public of Said County and
Road,
pplieddale,Nc27mit commissioned,ualified and authorized by law to admin-
hac applied for a permity qualified,
in
lki ghacilityIocattylS personally appeared David Clevenger, who being first
in Rockingham countylS,
Affidavit of Publication
North Carolina ultr
Rockingham County
water intog tran unnamed
waste
'orn deposes and says. That he is an official of Media
water into an unnamed �
tributary R no Hke Rivegans Creek) f Reidsville Inc. engaged in the publication of a newspaper
in the Roanoke River Basin. �
Curentn are wed r quality The Reidsville Review, published, issued and entered as sec -
nitrogen are water qualitya
limited. This discharge may
affect future allocations in mail in the City of Reidsville, in said County and State; that
this portion of the receiving
stream. lorized to make this affidavit and sworn statement, that the
NPumbe
NC002D5151, CiES ty oitf Eden, other legal advertisement, a true copy of which is attached
Dry
d "'�E308 EaumDriNC/as published in The Reidsville Review on the following
27288 has applied for a permit
renewal for a facility located
in Rockingham County (� �
discharging treated waste 3 f\USI.c. I c I l ^��. Al
water into Dan River in the
Roanoke River Basin.
Currently fecal coliform and
color are water quality limited.
This discharge may affect
future allocations in this he said newspaper in which such notice, paper document, or
portion of the receiving
stream. ertisement was published, at the time of each and every such
January27p002
uDllcation, a newspaper meeting all the requirements and qualifica-
tions of Section I-597 of the General Statutes of North Carolina and
was qualified newspaper within the meaning of Section I-597 of the
General Statutes of North Carolina.
(Affiant)
Sworn to and subscribed before me, this
day of
eo_
b U B G
i � U ��
My Commission Expires on O8/30/05,` 4"... ............... .'

TOWN OF MADISON
Public Utilities
120 North Market Street
Madison, NC 27025
336/427-0221 • FAX: [phone]
01-02-01
Mr. Charles H. Weaver, Jr.
NC DENR / Water Quality / NPDES Unit
1617 Mail Service Center
Raleigh, NC 27699-167
Re: NPDES PERMIT # NC0085626 RENEWAL
Mr. Weaver,
rL
JAN - 5 2001
L____
CENR - WATER QUALirY
POINT SOURCE BRANCH
The Town of Madison is requesting the renewal of the Water Treatment Facility NPDES
permit # NC0085626.
There have been no changes in the facility since the last permit renewal.
All alum sludge is held in 2 drying beds at the facility. No sludge has been removed
since the last permit renewal. The town has contracted with Precision Liquid
Applications, Inc. for the permitting and disposal of the sludge.
Enclosed is the NPDES Permit application. Please call if you have any further
questions.
Sincerely,
7 i Jc9
Micheal O. Morrison
Utilities Director
[e-mail]