NC0051918_Authorization to Construct_20051202

NPDES DOCIMENT 5CANNINC COVER SHEET
NPDES Permit:
NC0051918
Cleveland County WTP
Document Type:
Permit Issuance
Wasteload Allocation
.
,(AtC)
'
Authorization to Construct.
Permit Modification
Complete File - Historical
Engineering Alternatives (EAA)
Application
Instream Assessment
(67b)
Environmental Assessment (EA)
Permit
History
Document Date:
December 2, 2005
This document is printed on reuse paper - ignore any
content on the reerne side

/vCe S79/ 8'
Cleveland County Sanitary District
A to C No. 051918A01
Issued November 13, 2005
Engineer's Certification
.; •
I, m WJI6, as a duly registered Professional Engineer in
the State of North Carolina, having been authorized to observe (periodically/ )
the construction of the modifications and improvements to the Cleveland County WTP, located
on Casar-Lawndale Road in Cleveland County for the Cleveland County Sanitary District,
hereby state that, to the best of my abilities, due care and diligence was used in the observation
of the following construction:
Installation of a gaseous sulfur dioxide dechlorination system pursuant to the fast
track application received on November 2, 2005, and in conformity with the
Minimum Design Criteria for Dechlorination Facilities.
I certify that the construction of the above referenced project was observed to be built
within substantial compliance and intent of the approved plans and specifications.
Signature • c'
Date 121 11 0_5
Send to:
Registration No. 1 ZSO9
Construction Grants & Loans
DENR/DWQ
1633 Mail Service Center
Raleigh, NC 27699-1633

OF WAR
' 7tom
f Oita r
November 18, 2005
Mr. Lanny B. 011is
Cleveland County Sanitary District
P.O. Box 788
Lawndale, North Carolina 28090
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
SUBJECT: Authorization to Construct
A to C No. 051918A01
Cleveland County Sanitary District
Cleveland County WTP
Cleveland County
Dear Mr. 011is:
Alan W. Klimek, P.E. Director
Division of Water Quality
A fast track application for Authorization to Construct dechlorination facilities was
received on November 2, 2005, by the Division. Authorization is hereby granted for the
construction of modifications to the existing Cleveland County WTP, with discharge of filter
backwash water into the First Broad River in the Broad River Basin.
This authorization results in no increase in design or permitted capacity and is awarded
for the construction of the following specific modifications:
Installation of a gaseous sulfur dioxide dechlorination system pursuant to the fast
track application received on November 2, 2005, and in conformity with the
Minimum Design Criteria for Dechlorination Facilities.
This Authorization to Construct is issued in accordance with Part III, Paragraph A of
NPDES Permit No. NC0051918 issued May 1, 2005, and shall be subject to revocation unless
the wastewater treatment facilities are constructed in accordance with the conditions and
limitations specified in Permit No. NC0051918.
In the event that the facilities fail to perform satisfactorily, including the creation of
nuisance conditions, the Permittee shall take immediate corrective action, including those as may
be required by this Division, such as the construction of additional or replacement wastewater
treatment or disposal facilities.
The Mooresville Regional Office, telephone number [phone], shall be notified at
least forty-eight (48) hours in advance of operation of the installed facilities so that an on site
North Carolina Division of Water Quality
Nor Carolina
Alaturally
1617 Nlail Service Center Raleigh, NC 27699-1617 Phone [phone] Customer Service
Internet: h2o.enr.state.nc.us 512 N. Salisbury St.
Raleigh, NC 27604 FAX [phone]
An Equal Opportunity/Affirmative Action Employer — 50% Recycled/10% Post Consumer Paper

Mr. Lanny 011is
November 18, 2005
Page 2
inspection can be made. Such notification to the regional supervisor shall be made during the
normal office hours from 8:00 a.m. until 5:00 p.m. on Monday through Friday, excluding State
Holidays.
Pursuant to 15A NCAC 2H .0140, upon completion of construction and prior to operation of
these permitted facilities, the completed Engineering Certification form attached to this permit shall be
submitted to the address provided on the form.
Upon classification of the facility by the Certification Commission, the Permittee shall
employ a certified wastewater treatment plant operator to be in responsible charge (ORC) of the
wastewater treatment facilities. The operator must hold a certificate of the type and grade at least
equivalent to or greater than the classification assigned to the wastewater treatment facilities by
the Certification Commission.
The Permittee must also employ a certified back-up operator of the appropriate type and
grade to comply with the conditions of T15A:8G.0202. The ORC of the facility must visit each
Class I facility at least weekly and each Class II, III and IV facility at least daily, excluding
weekends and holidays, must properly manage the facility, must document daily operation and
maintenance of the facility, and must comply with all other conditions of T15A:8G.0202.
A copy of the approved plans and specifications shall be maintained on file by the
Permittee for the life of the facility.
During the construction of the proposed additions/modifications, the permittee shall
continue to properly maintain and operate the existing wastewater treatment facilities at all times,
and in such a manner, as necessary to comply with the effluent limits specified in the NPDES
Permit.
You are reminded that it is mandatory for the project to be constructed in accordance
with the North Carolina Sedimentation Pollution Control Act, and, when applicable, the North
Carolina Dam Safety Act. In addition, the specifications must clearly state what the contractor's
responsibilities shall be in complying with these Acts.
Failure to abide by the requirements contained in this Authorization to Construct may
subject the Permittee to an enforcement action by the Division of Water Quality in accordance
with North Carolina General Statute 143-215.6A to 143-215.6C.
The issuance of this Authorization to Construct does not preclude the Permittee from
complying with any and all statutes, rules, regulations, or ordinances which may be imposed by
other government agencies (local, state, and federal) which have jurisdiction.

Mr. Lanny 011is
November 18, 2005
Page 3
If you have any questions or need additional information, please do not hesitate to contact
Cecil G. Madden, Jr., P.E. at telephone number [phone].
Sincerely,
Alan W. Klimek, P.E.
MH/cgm
cc: Keith Webb, P.E. — McGill Associates
Cleveland County Health Department
Mooresville Regional Office, Surface Water Protection Section
Technical Assistance and Certification Unit
Daniel Blaisdell, P.E.
Point Source Branch, NPDES Program
Cecil G. Madden, Jr., P.E.
Mark Hubbard, P.E.
AtoCFile