NC0028169_Permit (Issuance)_20090121

NPDES DOCUHENT SCANNING COVER SHEET
NPDES Permit:
NC0028169
Aquadale Quarry
Document Type:
Permit Issuance
Wasteload Allocation
Authorization to Construct (AtC)
Permit Modification
Complete File - Historical
Correspondence
Speculative Limits
Instream Assessment
(67b)
Environmental Assessment (EA)
Permit
History
Document Date:
January 21, 2009
This document is printed on reuse paper - ignore any
content on the reirerse side

ATA
NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue, Governor Dee Freeman, Secretary
Coleen H. Sullins, Director
January 21, 2009
Mr. Jason Conner
Hedrick Industries
15 Yorkshire Street, # 302
Asheville, N.C. 28803-2760
Subject: Issuance of NPDES Permit NC0028169
Aquadale Quarry
Stanly County
Dear Mr. Conner:
Division personnel have reviewed and approved your application for renewal of the subject permit.
Accordingly, we are forwarding the attached NPDES discharge permit. This permit is issued pursuant to
the requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement between
North Carolina and the U.S. Environmental Protection Agency dated October 15, 2007 (or as subsequently
amended).
This final permit includes no major changes from the draft permit sent to you on
December 3, 2008.
If any parts, measurement frequencies or sampling requirements contained in this permit are
unacceptable to you, you have the right to an adjudicatory hearing upon written request within thirty (30)
days following receipt of this letter. This request must be in the form of a written petition, conforming to
Chapter 150B of the North Carolina General Statutes, and filed with the Office of Administrative Hearings
(6714 Mail Service Center, Raleigh, North Carolina 27699-6714). Unless such demand is made, this
decision shall be final and binding.
Please note that this permit is not transferable except after notice to the Division. The Division may
require modification or revocation and reissuance of the permit. This permit does not affect the legal
requirements to obtain other permits which may be required by the Division of Water Quality or permits
required by the Division of Land Resources, the Coastal Area Management Act or any other Federal or Local
governmental permit that may be required. If you have any questions concerning this permit, please
contact Charles Weaver at telephone number [phone].
Sin erely,
oleen H. Sullins
cc: Central Files
Mooresville Regional Office/Surface Water Protection
NPDES Unit
Aquatic Toxicology Unit
1617 Mail Service Center, Raleigh, North Carolina 27699-1617
512 North Salisbury Street, Raleigh, North Carolina 27604
Phone: [phone] / FAX [phone] / Internet: www.ncwaterquality,org
An Equal Opportunity/Affirmative Action Employer - 50% Recycled/10% Post Consumer Paper
NorthCarolina
Naturally

Permit NC0028169
4
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission,
and the Federal Water Pollution Control Act, as amended, the
BV Hedrick Gravel and Sand Company
is hereby authorized to discharge wastewater from a facility located at the
Aquadale Quarry
NCSR 2029
West of Aquadale
Stanly County
to receiving waters designated as Long Branch Creek in subbasin 03-07-13 of the
Yadkin -Pee Dee River Basin in accordance with effluent limitations, monitoring
requirements, and other conditions set forth in Parts I, II, III and IV hereof.
This permit shall become effective March 1, 2009.
This permit and authorization to discharge shall expire at midnight on February 28, 2014.
Signed this day January 21, 2009.
ie.'�' • en H. Sullins, Director
r Division of Water Quality
By Authority of the Environmental Management Commission

Permit NC0028169
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility, whether for operation or discharge are hereby revoked.
As of this permit issuance, any previously issued permit bearing this number is no longer effective.
Therefore, the exclusive authority to operate and discharge from this facility arises under the permit
conditions, requirements, terms, and provisions included herein.
The BV Hedrick Gravel and Sand Company is hereby authorized to:
1. Continue operation of an existing quarry dewatering system, and a kiln rock wash
system located at the Aquadale Quarry site [off NCSR 2029 west of Aquadale] in
Stanly County.
2. Discharge from said treatment works at the locations specified on the attached
map through outfalls 001 and 002 to Long Branch (formerly the Treatment Works
Pond), currently classified C waters in. subbasin 03-07-13 of the Yadkin -Pee Dee
River Basin.

1
NC0028169 - Aquadale Quarry
Latitude: 001: 35°13'45" 002: 35°13'38"
Longitude: 001: 80°14'47" 002: 80°1453"
Quad #: G 18 NW Sub -Basin: 03-07-13
Stream Class: C River basin: Yadkin -Pee Dee
Receiving Stream: Long Branch
•
I
- s
, I
:
1- • (
.1 I t
• '
Facility
Location
BV Hedrick Gravel and Sand Company
Stanly County

Permit NC0028169
A. (1) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS [001]
During the period beginning on the effective date of the permit and lasting until expiration, the
Permittee is authorized to only discharge from outfall 001 during 5-year storm event.
Such discharges shall be limited and monitored by the Permittee as specified below:
Parameter
Effluent Limits
Monitoring Requirements
Monthly Average
Daily Maximum
Measurement
Frequency
Sample
Type
Sample Location'
Flow
Weekly
Instantaneous
Effluent
Total Suspended Solids
30.0 mg/L
45.0 mg/L
2/Month
Grab
Effluent
Oil and Grease
30.0 mg/L
60.0 mg/L
2/Month
Grab
Effluent
Lead
2/Month
Grab
Effluent
Chromium
2/Month
Grab
Effluent
Manganese
Monthly
Grab
Effluent
Acute Toxicity 2
Quarterly
Grab
Effluent
Turbidity3
50 NTU
2/Month
Grab
Effluent, U, D
Temperature, °C4
2/Month
Grab
Effluent, U, D
pH
2/Month
Grab
U, D
pH
> 6.0 and < 9.0 standard units
2/Month
Grab
Effluent
Footnotes:
1. U: upstream from the outfall where the railroad tracks cross the channel D: downstream 200 feet
from the outfall.
2. Acute Toxicity (Fathead Minnow); see A. (3).
3. The effluent shall not cause the turbidity of the receiving stream to exceed 50 NTU. If natural
background conditions in the receiving stream (upstream) are greater than 50 NTU, then the effluent
shall not cause an increase in the turbidity of the receiving stream.
4. The temperature of the effluent shall not cause an increase in the temperature of the receiving stream
of more than 2.8 °C and in no case cause the ambient water temperature to exceed 32 °C.
BMP Conditions
> The permittee shall operate the facilities in a manner, which will minimize the impact on the receiving
water.
> The permittee shall utilize sound management practices to ensure that contaminants do not enter the
surface waters as a result of blasting at the site.
There shall be no discharge of floating solids or visible foam in other than trace amounts.
Definitions:
Mg/L — milligrams per liter NTU - Nephelometric Turbidity Units C — Celsius

Permit NC0028169
A. (2) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS [002]
During the period beginning on the effective date of the permit and lasting until expiration, the
Permittee is authorized to discharge from outfall 002. Such discharges shall be limited and
monitored by the Permittee as specified below:
Parameters
Effluent Limits
. Monitoring Requirements
Monthly Average
Daily Maximum
Measurement
Frequency
Sample Type
Sample Locationl
Flow
Weekly
Instantaneous
Effluent
Total Suspended Solids
30.0 mg/L
45.0 mg/L
2/Month
Grab
Effluent
Oil and Grease
30.0 mg/L
60.0 mg/L
2/Month
Grab
Effluent
Lead•
2/Month
Grab
Effluent
Chromium
2/Month
Grab
Effluent
Manganese
Monthly
Grab
Effluent
Acute Toxicity 2
Quarterly
Grab
Effluent
Turbidity3
50 NTU
2/Month
Grab
Effluent, U, D
Temperature, °C4
2/Month
Grab
Effluent, U, D
pH
2/Month
Grab
U, D
pH
> 6.0 and < 9.0 standard units
2/Month .
Grab
Effluent
Footnotes:
1. U: upstream from the outfall where the railroad tracks cross the channel D: downstream 200 feet
from the outfall.
2. Acute Toxicity (Fathead Minnow) See Part I A. (3.).
3. The effluent shall not cause the turbidity of the receiving stream to exceed 50 NTU. If natural
background conditions in the receiving stream (upstream) are greater than 50 NTU, then the effluent
shall not cause an increase in the turbidity of the receiving stream.
4. The temperature of the effluent shall not cause an increase in the temperature of the receiving stream
of more than 2 8 °C and in no case cause the ambient water temperature to exceed 32 °C.
BMP Conditions
> The permittee shall operate the facilities in a manner, which will minimize the impact on the
receiving water.
> The permittee shall utilize sound management practices to ensure that contaminants do not enter
the surface waters as a result of blasting at the site.
There shall be no discharge of floating solids or visible foam in other than trace amounts.

Permit NC0028169
A. (3) ACUTE TOXICITY Limit (Quarterly)
The permittee shall conduct acute toxicity tests on a quarterly basis using protocols defined in the North
Carolina Procedure Document entitled "Pass/Fail Methodology For Determining Acute Toxicity In A Single
Effluent Concentration" (Revised -July, 1992 or subsequent versions). The monitoring shall be performed as
a Fathead Minnow (Pimephales promelas) 24-hour static test. The effluent concentration at which there
may be at no time significant acute mortality is 90% (defined as treatment two in the procedure document).
Effluent samples for self -monitoring purposes must be obtained during representative effluent discharge
below all waste treatment. The tests will be performed during the months of February, May, August
and November.
All toxicity testing results required as part of this permit condition will be entered on the Effluent
Discharge Monitoring Form (MR-1) for the month in which it was performed, using the parameter code
TGE6C. Additionally, DWQ Form AT-2 (original) is to be sent to the following address:
Attention:
NC DENR / DWQ / Environmental Sciences Section
1621 Mail Service Center
Raleigh, North Carolina 27699-1621
Completed Aquatic Toxicity Test Forms shall be filed with the Environmental Sciences Section no later
than 30 days after the end of the reporting period for which the report is made.
Test data shall be complete and accurate and include all supporting chemical/physical measurements
performed in association with the toxicity tests, as well as all dose/response data. Total residual chlorine of
the effluent toxicity sample must be measured and reported if chlorine is employed for disinfection of the
waste stream.
Should there be no discharge of flow from the facility during a month in which toxicity monitoring is
required, the permittee will complete the information located at the top of the aquatic toxicity (AT) test
form indicating the facility name, permit number, pipe number, county, and the month/year oldie report
with the notation of "No Flow" in the comment area of the form. The report shall be submitted to the
Environmental Sciences Section at the address cited above.
Should any single quarterly monitoring indicate a failure to meet specified limits, then monthly monitoring
will begin immediately until such time that a single test is passed. Upon passing, this monthly test
requirement will revert to quarterly in the months specified above.
Should the permittee fail to monitor during a month in which toxicity monitoring is required, then monthly
monitoring will begin immediately until such time that a single test is passed. Upon passing, this monthly
test requirement will revert to quarterly in the months specified above.
Should any test data from either these monitoring requirements or tests performed by the North Carolina
Division of Water Quality indicate potential impacts to the receiving stream, this permit may be re -opened
and modified to include alternate monitoring requirements or limits.
If the Permittee monitors any pollutant more frequently then required by this permit, the results of such
monitoring shall be included in the calculation & reporting of the data submitted on the DMR & all AT
Forms submitted.
NOTE: Failure to achieve test conditions as specified in the cited document, such as minimum control
organism survival and appropriate environmental controls, shall constitute an invalid test and will require
immediate follow-up testing to be completed no later than the last day of the month following the month of
the initial monitoring.

Draft Permit - Aquadale Quarry /001
Subject: Draft Permit - Aquadale Quarry /001
From: Susie Meadows <[e-mail]>
Date: Mon, 05 Jan 2009 16:00:17 -0500
To: Charles Weaver <[e-mail]>
Hi Charles,
I was looking over the Draft Permit for Aquadale Quarry /001 (NC0028169/001).
For Outfall 001, they have been running a "Limit," however in the Draft Permit it
states "Monitoring." Is this correct? Are they changing to "Monitoring?"
Thanks.
Susie
Susan Meadows, Environmental Biologist
Aquatic Toxicology Unit
DWQ/Environmental Sciences Section
4401 Reedy Creek Road Raleigh, NC 27607
[e-mail]
t: [phone]
f: [phone]
1 of 1 1/8/2009 8:36 AM

The Stanly News & Press
PO BOX 488
ALBEMARLE NC 28002
704-982-2121
AFFIDAVIT OF INSERTION
DATE: 12/04/08
STARTDATE CLASS
DESCRIPTION
WORDS INS CHG
02100838-000
NCDENR/DWQ/PSB/NPDES
1617 MAIL SERVICE CENTER
RALEIGH NC 27699-1617
12/04/2008 355 PUBLIC NOTICE STATE OF
NORTH CAROLINA, STANLY COUNTY
AFFIDAVIT OF PUBLICATION
Before the undersigned, a Notary Public of said
County and State, duly commissioned, qualified,
and authorized by law to administer oaths,
personally appeared: SANDY SELVY, who being
first duly sworn, deposes and says: that he is
PUBLISHER of a newspaper known as THE
STANLY NEWS AND PRESS, published, issued, and
entered as second class mail in the City of
Albemarle, in said County and State; that he is
authorized to make this affidavit and sworn
notice or other legal advertisement, a true copy of
which is attached hereto, was published in THE
STANLY NEWS AND PRESS on the dates specified
on the copy attached and that the said newspaper
in which such notice, paper, document or legal
advertisement was published was, at the time of
each and every such publication, a newspaper
meeting all of the requirements and qualifications of
Section 1-597 of the General Statures of North
Carolina and was a qualified newspaper within the
meaning of Section 1-597 of the General Statures
of North Carolina.
Y SEL
PUBLISHER
326
2 92.28
Public Notice
PUBLIC NOTICE
STATE OF NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT
COMMISSION/NPDES UNIT
1617 MAIL SERVICE CENTER
RALEIGH, NC 27699-1617
NOTIFICATION OF INTENT
TO ISSUE A NPDES
WASTEWATER PERMIT
On the basis of thorough staff review
andcal
S nnkle [phone] at the
Point Source i Dina Branch. Please include
Po
the NPDES permit number(below)In
Interested per -
any communication.
sons may also visit the Division Street,
Wa-
ter Quality at 512 N. Salisbury
Raleigh, NC 27604-1148 betweenotfee
hours of 8:00 a.m. and 5:00 p.m.
view information on file.
The BV Hedrick Gravel and Sand Co.
(7 Yorkshire Street, #102, Asheville, NC
28803) has • applied for renewal of
------412a 8( rP 9 fNrr l 69 for their
This
Aquada a
permitted facility discharges industnatBranch in
process wastewater to Long
the Cur-
rently oil
Pee-Dee
eand 'total suspended
solid oil are grease ualf limited. This
discharge
affectwayefuture allocations
discharge may
in this portion of the Yadkin Pee -Dee
River Basin.
December 4, 2008.
Sworn to and subscribed to before me this
4th day of December, 2008
KIMMIE S. JOSON, Notary Public
My commission expires February 21, 2013

SOC PRIORITY PROJECT: No
To: Western NPDES Unit
Surface Water Protection Section
Attention: Charles Weaver
Date: September 12, 2008
NPDES STAFF REPORT AND RECOMMENDATION
County: Stanly
Permit No. NC00281 9( 9
PART I - GENERAL INFORMATION
1. Facility and address: BV Hedrick Sand and Gravel Company
12423 Old Aquadale Road
Norwood, N.C. 28128
2. Date of investigation: September 11, 2008
3. Report prepared by: Michael L. Parker, Environmental Engineer II
4. Persons contacted and telephone number: Mr. Jason Conner, [phone].
5. Directions to site: From the community of Aquadale in southern Stanly County, travel
west on SR 1922 (South Stanly School Road) approximately 0.2 mile and turn right on
SR 2001 (Old Aquadale Road). Travel approximately 1.0 mile and turn left on SR 2029.
BV Hedrick is located at the end of SR 2029.
6. Discharge point(s). List for all discharge points:
Outfall 001
Latitude: 35 ° 13' 38"
Longitude: 80° 14' 49"
Outfall 002
35 ° 13' 27"
80° 14' 49"
U.S.G.S. Quad No.: G 17 NE & G 18 NW U.S.G.S. Name: Oakboro & Aquadale, N.C.
7. Site size and expansion are consistent with application? Yes, sufficient area exist for the
construction of additional WWT facilities, if necessary.
8. Topography (relationship to flood plain included): Hilly, with severe slopes in the
vicinity of the rock quarry. The portion of the site where the discharge originates is not
located in a flood plain.
9. Location of nearest dwelling: None within 500 feet.

Page Two
10. Receiving stream or affected surface waters: Long Branch (both outfalls)
a. Classification: C
b. River Basin and Subbasin No.: Yadkin 03-07-13
c. Describe receiving stream features and pertinent downstream uses: Long Branch
at outfall 001 is a heavily braided channel, which passes through an area that was
at one time a small pond. As a result of long-term siltation from past site
activities, this former pond completely filled in with sediment and is now heavily
vegetated by wetland plants and trees. Any discharges from outfall 001 would
have to pass through this vegetation and then through a 2.58 acre man-made
impoundment before exiting underground and eventually returning to normal
stream conditions. The discharge at outfall 002 (Long Branch) is actually into the
man-made impoundment noted above, which is located immediately below outfall
001. There is no discernable outlet from this structure, however, past DWQ
investigations were able to determine that water in this impoundment exited
underground and reappeared immediately below the impoundment as a flowing
stream. In previous correspondence from the Division, the former owner of this
site (Carolina Solite) was notified that this channel was considered "Waters of the
State" and could not be used for treatment. There are no known users downstream
of either discharge.
PART II - DESCRIPTION OF DISCHARGE AND TREATMENT WORKS
1. a. Volume of wastewater to be permitted: No limit in the current permit (intermittent
discharge)
b. What is the current permitted capacity of the wastewater treatment facility? No limit
(intermittent discharge)
c. Actual treatment capacity of the current facility (current design capacity)? There are
no WWT facilities.
d. Date(s) and construction activities allowed by previous Authorizations to Construct
issued in the previous two years: There have been no ATCs issued in the past two
years nor are any being considered at this time.
e. Please provide a description of existing or substantially constructed wastewater
treatment facilities: Existing WWT facilities at outfall 001 consist of a 0.2 acre
earthen settling basin concrete settling cells (the discharge from this outfall is only
allowed during a 5-year storm event or greater). The effluent from the concrete
settling cells discharges to the quarry pit and then eventually out through outfall 002.

Page Three
f. Please provide a description of proposed wastewater treatment facilities: There are
no proposed WWT facilities at this time.
2. Residuals handling and utilization/disposal scheme: Residuals generated in the settling
processes are removed as needed and stockpiled on -site.
3. Treatment plant classification: P/C 1
4. SIC Code(s): 3295 Wastewater Code(s): 42 Main Treatment Unit Code: 50000
PART III - OTHER PERTINENT INFORMATION
1. Is this facility being constructed with Construction Grant Funds or are any public monies
involved (municipals only)? Public monies were not used in the construction of this facility.
2. Special monitoring or limitations (including toxicity) requests: The current permit list the
upstream monitoring location for both outfall 001 and 002 as: "200 feet from the outfall".
During the site visit on 9/11/2008, it was determined that this location is not appropriate
given the current site constraints and a new location was located and agreed upon by both
DWQ and Hedrick personnel. This new location is on Long Branch at a point upstream
where the railroad track crosses the channel. This location should satisfy the upstream
monitoring requirements for both outfalls.
3. Important SOC, JOC or Compliance Schedule dates: This facility is neither under an SOC
nor is one being considered at this time.
PART IV - EVALUATION AND RECOMMENDATIONS
BV Hedrick has applied for renewal of the subject permit. There have been some changes to
the current operation since the permit was last renewed (see Part II, No. 1(e) above) including the
addition of a second outfall. There are no significant changes proposed at this renewal with the
exception of the changes noted in Part III, No. 2 above.
It is recommended that the perglit be reissued as requested.
ure of Report Preparer
Da
/i of
Water Quality Regional Supervisor Date
h:ldsrldsr081hedrick.doc

HEDRICK INDUSTRIES
7 Yorkshire St. Suite 102
Asheville, NC 28803
828-277-7030
August 22, 2008
Attn: Mrs. Dina Sprinkle
NC DENR / DWQ / Point Source Branch
1617 Mail Service Center
Raleigh, NC 27699-1617
Dear Mrs. Dina Sprinkle:
B.V. Hedrick Gravel and Sand Company would like to renew NPDES Permit
NC0028169. I have included in the packet the application, updated map, and a narrative
of the water treatment process. We do not have a sludge management plan at this facility.
We do not generate sludge or any other solids at this site.
If you have any questions please call me at 828-277-7030.
Sincerely,
Jason Conner
Environmental Director

NPDES PERMIT APPLICATION - SHORT FORM C - Minor Industrial
Minor industrial, manufacturing and commercial facilities.
Mail the complete application to:
N. C. Department of Environment and Natural Resources
Division of Water Quality / NPDES Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
NPDES Permit Number
NCOO 4/1,
If you are completing this form in computer use the TAB key or the up - down arrows to move from one
field to the next. To check the boxes, click your mouse on top of the box. Otherwise, please print or type.
1. Contact Information:
Owner Name
Facility Name
Mailing Address
City
State / Zip Code
Telephone Number
Fax Number
e-mail Address
, • V. iiriNl / a( 60414a. St4ivt, rD, / Pots,/
v*'a/12.0 ge✓4rti2
1°, d. 150f qs
4 SifM4ni)�
/et 2pv v
271- ?o3o
(Of) 277- 71'32
t Pi1A t ' 1 �, i�', Gk f it o • Gout
2. Location of facility producing discharge:
Check here if same as above 123
Street Address or State Road
City
State / Zip Code
County
3. Operator Information:
Name of the firm, consultant or other entity that operates the facility. (Note that this is not referring to the
Operator in Responsible Charge or ORC)
Name
Mailing Address
City
State / Zip Code
Telephone Number
Fax Number
,�•V. uirniek 6.n4✓rL ; S' « !'gmAil
% yDflK)#))r) sr. S Tim
( 62f) 271- 7n3o
(Vf) 217- 7043.2
Page 1 of 4 C-MI 03105

NPDES PERMIT APPLICATION - SHORT FORM C - Minor Industrial
Minor industrial, manufacturing and commercial facilities.
4. Ownership Status:
Federal ❑ State ❑ Private M Public ❑
5. Standard Industrial Classification (SIC) code(s):
6. Number of employees: Lip
7. Describe the treatment system List all installed waste treatment components with capacities,
describe the processes that generate wastewaters. If the space provided is not sufficient attach a
separate sheet of paper with the system description.
l✓ 41:60,c4Sli4ct
8. Is facility covered under federal effluent limitation guidelines'? No VI Yes
If yes, specify the category?
9. Principal product(s) produced: 21 hiir Iv4/WJT 4bb11(MTg
Principal raw material(s) consumed: 5, j2Ji
Briefly describe the manufacturing process(es):
C 1a45/4vb4, OffivO1A'b, Zt 11.N �i�I.r/v st,er '''wb . S lz/H&
Page 2 of 4 C-MI 03/05

•
NPDES PERMIT APPLICATION - SHORT FORM C - Minor Industrial
Minor industrial, manufacturing and commercial facilities.
10. Amount of principal product produced or raw material consumed
(List specific amounts consumed and/or units of production over the last three year
Product Produced or Raw Material
Consumed
(AVERAGE)
Product Produced or Raw Material
Consumed
(PEAK)
per Day
3 y p
6 70
per Month
A7S 0
13 Yod9
per Year
/P5 f vo
Id', tea
11. Frequency of discharge: Continuous ❑ Intermittent IR
If intermittent:
Days per week discharge occurs: Duration: 6
12. Types of wastewater discharged to surface waters only
Discharge
Flow
(GALLONS PER DAY)
Sanitary - monthly average
Utility water, etc. - monthly average
O
Process water - monthly average
&j H p O v n
1 �
Stormwater - monthly average
1,
y y p, pc O
Other - monthly average
Explain:
Monthly Average
total discharge (all types)
i
1 YO) P p 0
13. Number of separate discharge points: 02
Outfall Identification number(s) D D1 - 00 Z
14. Name of receiving stream(s) (Provide a map showing the exact location of each outfall, including
latitude and longitude
zo•V/b ifiY& A Ctfib-i lC
Page 3 of 4
C-MI 03/05

NPDES PERMIT APPLICATION - SHORT FORM C - Minor Industrial
Minor industrial, manufacturing and commercial facilities.
15. Effluent Data
Provide data for the parameters listed. Temperature and pH shall be grab samples, for all other parameters 24-hour
composite sampling shall be used. If more than one analysis is reported, report daily maximum and monthly average.
If only one analysis is reported, report as daily maximum.
Parameter
Daily
Maximum
Monthly
Average
Units of
Measurement
Biochemical Oxygen Demand (GODS)
Chemical Oxygen Demand (COD)
Total Organic Carbon
Total Suspended Solids
!•I .ii.0'
30, D f1.
I L
Ammonia as N
i
0
Temperature (Summer)
Temperature (Winter)
pH
Fecal Coliform (If sanitary waste is
present)
Total Residual Chlorine (if chlorine is
used)
16. List all permits, construction approvals and/or applications (check all that apply and provide permit
numbers or check none if not applicable
Type
Permit Number Type
Hazardous Waste (RCRA) NESHAPS (CAA)
UIC (SDWA) Ocean Dumping (MPRSA)
NPDES Dredge or fill (Section 404 or CWA)
PSD (CAA) Other
Non -attainment program (CAA)
Permit Number
17. List any chemicals that may be discharged (Please list and explain source and potential
amounts.)
0/2 a- Git/Silt5/y
18. Is this facility located on Indian country? (check one)
Yes ❑ No cgi
Page 4 of 4 C-MI 03/05

. 0
NPDES PERMIT APPLICATION - SHORT FORM C - Minor Industrial
Minor industrial, manufacturing and commercial facilities.
19. Applicant Certification
I certify that I am familiar with the information contained in the application and that to the
best of my knowledge and belief such . information is true, complete, and accurate.
V C.9'Co 0c6PrmA �..)
1q 4' GO.r/x//r/Z
Printed name of Person Signing
Title
22/o
Sign a of Applicant 7/2
te
North Carolina General Statute 143-215.6 (b)(2) provides that: Any person who knowingly makes any false
statement representation, or certification in any application, record, report, plan, or other document files or
required to be maintained under Article 21 or regulations of the Environmental Management Commission
implementing that Article, or who falsifies, tampers with, or knowingly renders inaccurate any recording or
monitoring device or method required to be operated or maintained under Article 21 or regulations of the
Environmental Management Commission implementing that Article, shall be guilty of a misdemeanor punishable
by a fine not to exceed $25,000, or by imprisonment not to exceed six months, or by both. (18 U.S.C. Section
1001 provides a punishment by a fine of not more than $25,000 or imprisonment not more than 5 years, or both,
for a similar offense.)
Page 5 of 4 C-MI 03/05

HEDRICK INDUSTRIES
7 Yorkshire St. Suite 102
Asheville, NC 28803
828-277-7030
Description of Treatment System:
All processing water and storm water from processing area A and B is diverted to dike A.
The water is then pumped from this location to the existing concrete cells which can
handle over 1 million gallons of water. We use a flocculent (O'B FLOC AE-612) to treat
the water in the concrete cells. The water is then pumped from the cells to the pit. From
there the water is pumped from the pit to the waters of the state formerly known as the
Treatment Works Pond (outfall 002). I have also added outfall 001 from the dike area in
case of a possible discharge during a 5 year storm event.

FACT SHEET FOR EXPEDITED PERMIT RENEWALS
Basic Information to determine potential for expedited permit renewal
Reviewer/Date
. p4 .(/ / to g
Permit Number •
�J c p 0 �' (6,
Facility Name9
,,� �, c tu
Basin Name/Sub-basin number
1 ti d (c.4.,,, d 3 0 7 13
Receiving Stream
`cry, c.. Q n ,/,
Stream Classification in Permit
c. 0
Does permit need NH3 limits?
0 o
Does permit need TRC limits?
191
Does permit have toxicity testing?
Wa
Does permit have Special Conditions?\
-\A
Does permit have instream monitoring?
9A/0
Is the stream impaired (on 303(d) list)?
'a
Any obvious compliance concerns?
Any permit mods since last permit?
44)
Existing expiration date
a1909
New expiration date
/ / / e-f
New permit effective date
Miscellaneous Comments
YE $ / This is a SIMPLE EXPEDITED permit renewal (administrative
renewal with no changes, or only minor changes such as TRC, NH3,
name/ownership changes). Include conventional WTPs in this group.
This is a MORE COMPLEX EXPEDITED permit renewal (includes
Special Conditions (such as EAA, Wastewater Management Plan), 303(d)
listed, toxicity testing, instream monitoring, compliance concerns, phased
limits). Basin Coordinator to make case -by -case decision.
YES_ This permit CANNOT BE EXPEDITED for one of the following reasons:
• Major Facility (municipal/industrial)
• Minor Municipals with pretreatment program
• Minor Industrials subject to Fed Effluent Guidelines (lb/day limits for BOD, TSS,
etc)
• Limits based on reasonable potential analysis (metals, GW remediation organics)
• Permitted flow > 0.5 MGD (requires full Fact Sheet)
• Permits determined by Basin Coordinator to be outside expedited process
YES
TB Version 8/18/2006 (NPDES Server/Current Versions/Expedited Fact Sheet)