NCG520051_Owner (Name Change)_20160930

Water Resources
ENVIRONMENTAL QUALITY
September 30, 2016
Mr. Jason C. Deck
Ameri-con Materials, Inc.
5875 Coxe Road
Rutherfordton, NC 28139
PAT MCCRORY
Governor
DONALD R. VAN DER VAART
Secrecy".
S. JAY ZIMMERMAN
Subject: Issuance of Certificate of Coverage NCG520051
NPDES General Permit NCG520000
Harris Pit
Rutherford County
Dear Mr. Deck:
Director
The Division has reviewed and approved your request for coverage under the subject General Permit.
The Division hereby issues Certificate of Coverage (CoC) NCG520051 to discharge under wastewater
General Permit NCG520000. This CoC is issued pursuant to the requirements of North Carolina General
Statue 143-215.1 and the Memorandum of Agreement between North Carolina and the US Environmental
Protection agency dated October 15, 2007 [or as subsequently amended].
If any parts, measurement frequencies or sampling requirements contained in this General Permit are
unacceptable to you, you have the right to request an individual permit by submitting an individual permit
application. Unless such demand is made, the certificate of coverage shall be final and binding.
Please take notice that this Certificate of Coverage is not transferable except after notice to the Division.
The Division may require modification or revocation and reissuance of the certificate of coverage. Contact
the Asheville Regional Office prior to any sale or transfer of the permitted facility. Regional
Office staff will assist you in documenting the transfer of this CoC.
If you have any questions concerning the requirements of the General Permit, please contact
Brianna Young of the NPDES Unit at [phone] or via e-mail [[e-mail]].
:d07-X117,
S. Jay Zimmerman, Director
Division of Water Resources
cc: Asheville Regional Office
NPDES Unit
State of North Carolina I Environmental Quality I Water Resources
1617 Mail Service Center I Raleigh, NC 27699-1617
919 807 6300 919-807-6389 FAX
https://deq.ne.gov/about/divisions/water-resources/water-resources-permits/wastewater-branch/npdes-wastewater-permits

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENTAL QUALITY
DIVISION OF WATER RESOURCES
GENERAL PERMIT NCG520000
CERTIFICATE OF COVERAGE NCG520051
DISCHARGE OF INSTREAM MINING WASTEWATER, ASSOCIATED STORMWATER AND
SIMILAR DISCHARGES UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and
the Federal Water Pollution Control Act, as amended, the
Ameri-con Materials, Inc.
is hereby authorized to discharge sand dredging wastewater from the following facility:
Harris Pit
2166 Jack McKinney Road
Harris
Rutherford County
to receiving waters designated as the Broad River, currently classified as C waters in
subbasin 03-08-02 of the Broad River Basin, in accordance with the effluent limitations,
monitoring requirements, and other conditions set forth in Parts I, II, III and IV hereof.
This certificate of coverage shall become effective September 30, 2016.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day September 30, 2016.
for S. Zimmerman, P.G.
Director, Division of Water Resources
By Authority of the Environmental Management Commission

Pat McCrory
Governor
7
NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Resources
WATER QUALITY PERMITTING SECTION
John E. Skvarla, III
Secretary
PERMIT NAME/OWNERSHIP CHANGE REQUEST
This form is for ownership changes or name changes of NPDES wastewater permits.
• "Permittee" references the existing permit holder
• "Applicant" references the entity applying for the ownership/name change.
1. NPDES Permit No. (for which the change is requested):
or
Certificate of Coverage #:
II. Existing Permittee Information:
a. Permit issued to (company name):
b. Person legally responsible for permit:
c. Facility name:
d. Facility's physical address:
e. Facility contact person:
III. Applicant Information:
a. Request for change is a result of:
If other please explain:
NCO()
NCG5Zto51
Es Fc
First MI Last
es,
Title
7o o / Co k>'_ �..�
Permit Holder Mailing Address
RCATI��-R,FOrL) nit)'C Pi 3 9
City
Phone
State Zip
0(04(1 (te ? 3- 0(19O
Fax
?Z /
a / (o (o JA-CfC /h C Kzi✓i)/" Y &)
Address
Ru 7/fit Fo12.D rot) N t, 02 ki 3 9
City State Zip
First / MI / Last Phone
Change in ownership of the facility
❑ Name change of the facility or owner
b. Permit issued to (company name):
c. Person legally responsible for permit:
tr..rZz — CO& fr►O-7j 5 z&
nAS on) �• � SIC_
First MI Last
Title
Permit Holder Mailing Address
K6t 7atzIv Fora) Toi r e- F135
City State ip
(Atk) ' S26 2 - Owic dao( jed 3?D y4/Io
Phone E-mail Address l c 0et`
Page 1 of 2 Revised 7/01/2014

d. Facility name:
e. Facility's physical address:
f. Facility contact person:
s4O// Jn (°(GGNN/y 7' 21)
Address
,b1 rt,if2/G o4o Ta 10 i 02 g/ ? y'
City State Zip
�'ct Sand C AEC IC
First MI Last
44)-(43 • oi5"y
Phone
Title
dad 'Cei 37 aheo,coi
E-mail Addra�s'�
IV. Will the permitted facility continue to conduct the same commercial/industrial activities conducted prior to
this wnership or name change?
Yes
❑ No (please explain)
If applicable, the applicant shall submit a major permit modification request to DWR. A major modification shall be
defined as one that increases the volume, increases the pollutant load, results in a significant relocation of the
discharge point, or results in a change in the characteristics of the waste generated.
V. Required Items: THIS APPLICATION WILL BE RETURNED UNPROCESSED IF ITEMS ARE
INCOMPLETE OR MISSING: %�
1. This completed application is required for both name change and/or ownership change request:. f h PrdLeihs..
2. Legal documentation of the transfer of ownership (such as relevant pages of a contract deed, or a bill of sale) is
required for an ownership change request. Articles of incorporation are not sufficient for an ownership change.
Applicable regulations: 40 CFR 122.41, 40 CFR 122.61 and 15A NCAC 02H .0114
The certifications below must be completed and signed by both the permit holder prior to the change (Permittee), and the
new applicant in the case of an ownership change request. For a name change request, the signed Applicant's Certification
is sufficient.
PERMITTEE CERTIFICATION (Permit holder prior to ownership change):
attest that this application for a name/ownership change has been reviewed and is accurate and complete to the best
y knowledge. I understand that if all required parts of this application are not completed and that if all required
pporting information is not included is application package will be returned as incomplete.
Signature
CANT CERTIFICATION
Date
attest that this application for a name/ownership change has been reviewed and is accurate and complete to the best
my knowledge. I understand that if all required parts of this application are not completed and that if all required
support' rjg information is not included, thJ's-a)pplication package will be returned as incomplete.
C ,
—/6
Signature Date
**************************
PLEASE SEND THE COMPLETE APPLICATION PACKAGE TO:
Division of Water Resources
Water Quality Permitting Section
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
NPDES PERMIT NAME/OWNERSHIP CHANGE REQUEST
Page 2 of 2 Revised 7/01/2014

Water Resources
ENVIRONMENTAL QUALITY
June 29, 2016
Jason Deck
Ameri-Con Materials, Inc.
5875 Coxe Road
Rutherfordton, NC 28139
SUBJECT: Compliance Evaluation Inspection
Deck Sand Company Site - 2166 Jack McKinney Road
Permit No: NCG520051
Rutherford County
Dear Mr. Deck:
PAT MCCRORY
Governor
DONALD R. VAN DER VAART
Secretary
S. JAY ZIMMERMAN
JUN 3 0 ZUth
CENTRAL FILES
DWR SECTION
Director
Enclosed please find a copy of the Compliance Evaluation Inspection form from the inspection conducted on
June 15, 2016. The facility appeared to be in compliance with permit NCG520051.
Please submit the enclosed Permit Name/Ownership Change Request form to change the permit to your name.
Please refer to the enclosed inspection report for observations and comments. If you or your staff have any
questions, please call me at 828-296-4662.
Sincerely,
an Price, PE
Assistant Regional Supervisor
Asheville Regional Office
Enc.
cc: MSC 1617-Central Files -Basement
Asheville Files
G:1WR\WQ\Rutherford\Wastewater\General\NCG52 Sand Dredges\Deck Sand NCG52005111une 15, 2016 Site Visit\CEI.06-29-2016_Deck NCG520051.docx
State of North Carolina I Environmental Quality I Water Resources
2090 U.S. Highway 70 Swannanoa, NC 28778
828 296 4500

United States Environmental Protection Agency
E PA Washington, D.C. 20460
Water Compliance Inspection Report
Form Approved.
OMB No. 2040-0057
Approval expires 8-31-98
Section A: National Data System Coding (i.e., PCS)
Transaction Code NPDES yr/mo/day Inspection
1 Ed 2 LI 3 I NCG520051 111 12 I 16/06/15 117
Type
18 I r I
11111111111
Inspector Fac Type
19 Li 2011
21111111 111111I111111111111111111
r6
Inspection Work Days Facility Self -Monitoring Evaluation Rating B1 QA
671 I 70 Li 71 11 72 LI I
Reserved
73 11( 74 751
I I I I I I 18°
Section B: Facility Data
Name and Location of Facility Inspected (For Industrial Users discharging to POTW, also include
POTW name and NPDES permit Number)
Deck Sand Company
2166 Jack McKinney Rd
Harris NC 28074
Entry Time/Date
10:00AM 16/06/15
Permit Effective Date
12/08/01
Exit Time/Date
10:20AM 16/06/15
Permit Expiration Date
17/07/31
Name(s) of Onsite Representative(s)/Titles(s)/Phone and Fax Number(s)
Ill
Other Facility Data
Name, Address of Responsible Official/Title/Phone and Fax Number
Contacted
James L Deck,7001 Coxe Rd Rutherfordton NC 28139//828-245-3225/
No
Section C: Areas Evaluated During Inspection (Check only those areas evaluated)
Permit Operations & Maintenance Records/Reports Self -Monitoring Program
Facility Site Review • Effluent/Receiving Waters
Section D: Summary of Finding/Comments (Attach additional sheets of narrative and checklists as necessary)
(See attachment summary)
Name(s) and Signature(s) of Inspector(s) Agency/Office/Phone and Fax Numbers Date
George A Price ARO WQ//828-296-4500/
40524010----.1 /7..„.....— 6/2- ///4
Signature of Management Q A Reviewer Agency/Office/Phone and Fax Numbers Date
EPA Form 3560-3 (Rev 9-94) Previous editions are obsolete.
Page# 1

31
NPDES
NCG520051
111 121
yr/mo/day
16/06/15
I17
Inspection Type
18 u.
(Cont.)
1
Section D: Summary of Finding/Comments (Attach additional sheets of narrative and checklists as necessary)
Zan Price with the Division of Water Resources (DWR) and owner Jason Deck were present at the
site inspection.
The permit is current and the annual fees have been paid. DWR gave Jason a Change of Ownership
form to submit since the permit is still in his father's name, James Deck of Deck Sand Company.
The suction dredge was not in operation during the site visit. Workers were completing maintenance
on the dredge.
Streambanks were well vegetated and stable.
The Broad River was turbid upstream and downstream from the dredging operation from a large rain
event on June 14, 2016.
The settling basin was dry and appeared adequate. Per Jason Deck, they clean out the settling basin
approximately two times per year.
Page# 2

Permit: NCG520051 Owner - Facility: Deck Sand Company
Inspection Date: 06/15/2016 Inspection Type: Compliance Evaluation
Operations & Maintenance
Is the plant generally dean with acceptable housekeeping?
Does the facility analyze process control parameters, for ex: MLSS, MCRT, Settleable
Solids, pH, DO, Sludge Judge, and other that are applicable?
Comment:
Yes No NA NE
■ ❑❑❑
❑ ❑ • ❑
Permit Yes No NA NE
(If the present permit expires in 6 months or less). Has the permittee submitted a new 0 0 0
application?
Is the facility as described in the permit? II 0 0 0
# Are there any special conditions for the permit? 0 II 0 0
Is access to the plant site restricted to the general public? 0 0 • 0
Is the inspector granted access to all areas for inspection? 11 0 0 0
Comment: Ownership has been transferred to Jason Deck. DWR provided a change of ownership
form to Mr. Deck.
Effluent Pipe
Is right of way to the outfall properly maintained?
Are the receiving water free of foam other than trace amounts and other debris?
If effluent (diffuser pipes are required) are they operating properly?
Comment:
Yes No NA NE
❑ ❑ II ❑
• ❑ ❑ ❑
❑ ❑ 11 ❑
Page# 3