NCG520034_Permit (Issuance)_19970723

State of North Carolina
Department of Environment,
Health and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
C. Dean Rose
Carl Rose And Sons
P.O. Box 786
Elkin, NC 28621
Dear Permittee:
*VA
AEI -INFO
July 23, 1997
Subject: Certificate of Coverage No. NCG520034
Renewal of General Permit
Carl Rose And Sons / Surry
Surry County
In accordance with your application for renewal of the subject Certificate of Coverage, the Division is forwarding
the enclosed General Permit. This renewal is valid from the effective date on the permit until July 31, 2002. This
permit is issued pursuant to the requirements of North Carolina General Statute 143-215 .1 and the Memorandum of
Agreement between North Carolina and the U.S. Environmental Protection Agency dated December 6, 1983. If any
parts, measurement frequencies or sampling requirements contained in this permit are unacceptable to you, you have
the right to request an individual permit by submitting an individual permit application. Unless such demand is
made, this certificate of coverage shall be final and binding.
The Certificate of Coverage for your facility is not transferable except after notice to the Division. Use the enclosed
Permit Name/Ownership Change form to notify the Division if you sell or otherwise transfer ownership of the
subject facility. The Division may require modification or revocation and reissuance of the Certificate of Coverage.
If your facility ceases discharge of wastewater before the expiration date of this permit, contact the Regional
Office listed below at [phone]. Once discharge from your facility has ceased, this permit may be rescinded.
This permit does not affect the legal requirements to obtain other permits which may be required by the Division of
Water Quality, the Division of Land Resources, Coastal Area Management Act or any other Federal or Local
governmental permit that may be required.
If you have any questions concerning this permit, please contact the NPDES Group at the address below.
Sincerely,
.4-trt.,(,4. i,,,,,,,i„
cc:
A. Preston Howard, Jr., P.E.
Central Files
Winston-Salem Regional Office
NPDES File
Facility Assessment Unit
P.O. Box 29535, Raleigh, North Carolina 27626-0535 [phone] FAX [phone] p&e©dem.ehnr.state_nc.us
An Equal Opportunity Affirmative Action Employer 50% recycled / 10% post -consumer paper

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT, HEALTH, AND NATURAL RESOURCES
DIVISION OF WATER QUALITY •
GENERAL PERMIT NO. NCG520000
CERTIFICATE OF COVERAGE NO. NCG520034
TO DISCHARGE SAND DREDGING WASTEWATER AND SIMILAR
WASTEWATERS UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards
and regulations promulgated and adopted by the North Carolina Environmental Management
Commission, and the Federal Water Pollution Control Act, as amended,
Carl Rose And Sons
is hereby authorized to operate a facility which discharges wastewater generated during
sand dredging operations with the discharge of wastewater from a facility
located at
Carl Rose And Sons / Surry
Elkin Wildlife Road
Elkin
Surry County
to receiving waters designated as subbasin 30702 in the Yadkin River Basin
in accordance with the effluent limitations, monitoring requirements, and other conditions set forth
in Parts I, II, III and IV of General Permit No. NCG520000 as attached.
This certificate of coverage shall become effective August 1, 1997.
This certificate of coverage shall remain in effect for the duration of the General Permit.
Signed this day July 23,1997.
A. Preston Howard, Jr., P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission

Letter to DEAN ROSE
NCG520034
El
INVOICE FOR RENEWAL OF
NPDES PERMIT
Check here if you do NOT wish to renew this permit.
Please return this page along with a letter documenting your reasons
for not requesting renewal to:
Mr. Charles H. Weaver, Jr.
Division of Water Quality/WQ Section
NPDES Group
Post Office Box 29535
Raleigh, North Carolina 27626-0535
'Check here if you wish to renew this permit.
Please verify that the following information is documented accurately:
Mailing Address
DEAN ROSE
CARL ROSE AND SONS - SURRY
BOX 786
ELKIN, NC 28621
Facility Location
DEAN ROSE
CARL ROSE AND SONS - SURRY
NC HWY 268
ELKIN, NC 28621
allo revision required.
December 11,1996
lot
Ow,
Ogoo
rn
Revision required. (Please specify below.)
a rn
N.)Pe'° rn
morn
-v z rn
rn
— zoo
� p
CA)
❑ No revision required.
Revision required. (Please specify below.)
(,J k l cJ 1,'-r en c. a
C air 2 )
Please return this page with your letter requesting renewal, and $400 fee (payable to NCDEHNR) to:
Mr. Charles H. Weaver, Jr.
Division of Water Quality/WQ Section
NPDES Group
Post Office Box 29535
Raleigh, North Carolina 27626-0535
Signature of applicant or authorized representative
Date
1,2-30 -11

cc: Tech. Services (Marcia Toler-McCullen)
Permits and Engineering
County Health Dept.
entral;Files
WSRO
Date June 27, 1989
NPDES STAFF REPORT AND RECOMMENDATIONS
County Surry
NPDES Permit No. NC00769-88- (Preliminary)
1•1CG5Zoo34
PART I - GENERAL INFORMATION
1. Facility and Address:
Carl Rose & Sons, Inc.
P. O. Box 786
Elkin, NC 28621
2. Date of Investigation: June 20, 1989
3. Report Prepared by: Abner Braddy
4. Persons Contacted and Telephone Number:
Mr. Dean Rose, Secretary/Treasurer
[phone]
Mr. David Pruitt, Foreman
5. Directions to Site:
001 - From Winston-Salem, travel Hwy. 52 N. to its
intersection with Hwy. 268 outside Pilot Mtn., N.C.;
turn left (west) on Hwy. 268, and continue to a point
200.0 yards east of where the I-77 overpass crosses
Hwy. 268; turn left down an unmarked dirt road and the
site will be located on the northern bank.
002 - Same as 001, but 100.0 yards farther east.
003 - From Hwy. 52 N., turn left (west) on Hwy. 268; at
the intersection of Hwy. 268 and S.R. 1141, turn left
(west) on S.R. 1141; site is located at the end of S.R.
1141.
6. Discharge Point - Latitude:
Longitude:
001 - 36° 15' 03,"
002 - 360
15 la.'4,`3,16 "'s-'4;.
003 - 36° 1511,\ 31" x 2?
001
002
003
80 4'5''
80° 49.' :► 3��
80
p LIMED

Attach a USGS Map Extract and indicated treatment plant
site and discharge point on map.
USGS Quad No. B15-SE or USGS Quad Name Elkin North
7. Size (land available for expansion and upgrading):
There is adequate size for installation of the proposed
settling basins.
8. Topography (relationship to flood plain included):
All 3 outfalls will be located in the flood plain.
9. Location of nearest dwelling:
None within 1000.0'
10. Receiving stream or affected surface waters: Yadkin
River
a. Classification: "C"
b. River Basin and Subbasin No.: 03-07-02
c. Describe receiving stream features and pertinent
downstream uses: This area of the Yadkin River is
primarily a rural watercourse, impacted by both
point and non -point sources. Since no water
intakes are located immediately below these sites,
there should be negligble impact on water quality.
PART II - DESCRIPTION OF DISCHARGE AND TREATMENT WORKS
1. Type of wastewater: % Domestic
100o Industrial
a. Volume of Wastewater: Intermittent; maximum
discharge would be 144,000 gallons/hour.
b. Types and quantities of industrial wastewater:
River bottom will be "vacuumed" by dredge, with
sand then pumped to the river bank by slurry. The
wastewater is not impacted by addition of any,.
deleterious substances, and is essentially ra.,t.; ct N
river water.
J:M
c. Prevalent toxic constituents in wastewater : sir... JSa:�
None
�-�'
d. Pretreatment Program (POTWs only) N/A Y •
cti��
in development approved -,L,r,Y`
should be required not needed

2. Production rates (industrial discharges only) in pounds
Variable
a. highest month in the last 12 months
b. highest year in last 5 years
3. Description of industrial process (for industries only)
and applicable CFR Part and Subpart:"
Sand is processed through a hopper, with different size
particles being selectively graded.
4. Type of treatment (specify whether proposed or
existing):
Primary sedimentation by 100' x 70' x 3.0' dug basins
at each outfall, with 12'1discharge conduit.
5. Sludge handling and disposal scheme:
N/A
6. Treatment plant classification: Less than 5 points
7. SIC Code(s) 43
Wastewater Code(s) 1442
PART III - OTHER PERTINENT INFORMATION
1. Is this facility being constructed with Construction
Grants Funds (municipals only)? N/A
2. Special monitoring requests: Monitoring not required;
see Paul Wilms memo of 3/21/88.
3. Additional effluent limits requests: None
4. Other:
PART IV - EVALUATION AND RECOMMENDATIONS
The WSRO recommends approval of the subject perii%JJ
with no monitoring requirements. The permit should state
that the settling basins shall be maintained in a fashion
such that adequate retention time for removal of "fines" is
provided. Given the nature of the operation and receiving
stream, minimal water quality impact is anticipated.
Signature of report pr--- er
Water duality Supervisor

• /067
• •
---- • •
Oa
•
••;:;.—% •
I•
..$ CROSSROADS 9 10.
• STATESVILLE 36 Mt.
• .....:g15F51.
(ELKIN SOUTH)
4856 III NE .11
SCALE 1:24 000
518
Ai I I r
7130" 1119
000--
1 520