NCG500635_Permit (Issuance)_20070723

ArA
NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Michael F. Easley, Governor William G. Ross, Jr., Secretary
Coleen H. Sullins, Director
July 30, 2007
Robert L. Greene
INGENCO Wholesale Power, LLC
2250 Dabney Road
Richmond, VA 23230
Subject: Renewal of coverage / General Permit NCG500000
INGENCO New Bern Plant
Certificate of Coverage NCG500635
Craven County
Dear Permittee:
In accordance with your renewal application [received on July 24, 2007], the Division is renewing
Certificate of Coverage (CoC) NCG500635 to discharge under NCG500000. This CoC is issued pursuant to the
requirements of North Carolina General Statue 143-215.1 and the Memorandum of Agreement between North
Carolina and the US Environmental Protection agency dated May 9, 1994 [or as subsequently amended].
If any parts, measurement frequencies or sampling requirements contained in this General Permit are
unacceptable to you, you have the right to request an individual permit by submitting an individual permit
application. Unless such demand is made, the certificate of coverage shall be final and binding.
Please take notice that this Certificate of Coverage is not transferable except after notice to the
Division. The Division may require modification or revocation and reissuance of the certificate of coverage.
Contact the Washington Regional Office prior to any sale or transfer of the permitted facility.
Regional Office staff will assist you in documenting the transfer of this CoC.
This permit does not affect the legal requirements to obtain other permits which may be required by
the Division of Water Quality or permits required by the Division of Land Resources, Coastal Area
Management Act or any other Federal or Local governmental permit that may be required.
If you have any questions concerning the requirements of the General Permit, please contact Jim
McKay [919 733-5083, extension 595 or [e-mail]].
Sincerely,
for Coleen H. Sullins
cc: Central Files
Washington Regional Office / Surface Water Protection
NPDES file
1617 Mail Service Center, Raleigh, North Carolina 27699-1617
512 North Salisbury Street, Raleigh, North Carolina 27604
Phone: [phone] / FAX [phone] / Internet: www.ncwaterquality.org
An Equal Opportunity/Affirmative Action Employer — 50% Recycled/10% Post Consumer Paper
NorthCarolina
Naturally

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NCG500000
CERTIFICATE OF COVERAGE NCG500635
TO DISCHARGE NON -CONTACT COOLING WATER, COOLING TOWER AND BOILER
BLOWDOWN, CONDENSATE AND SIMILAR WASTEWATERS UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and
the Federal Water Pollution Control Act, as amended,
INGENCO Wholesale Power, LLC
is hereby authorized to discharge Non -contact Cooling Water from a facility located at
INGENCO New Bern Plant
7420 Old U.S. Hwy 70 West
New Bern
Craven County
to receiving waters designated as an unnamed tributary to Batchelor's Creek in subbasin
30408 of the Neuse River Basin in accordance with the effluent limitations, monitoring
requirements, and other conditions set forth in Parts I, II, III and IV hereof.
This certificate of coverage shall become effective August 1, 2007.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day July 30, 2007.
/1„ t-7527 ,t,..,
for Coleen H. Sullins, Director
Division of Water Quality
By Authority of the Environmental Management Commission

1NGENCO
Distributed Energy
4 2007
July 23, 2007
Mr. Charles H. Weaver
NC DENR/DEQ/NPDES
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Re: Renewal Application NCG500635
Dear Mr. Weaver:
Attached is an application to renew the existing certificate of coverage for our facility
covered under COC NCG500635. This COC was issued November 22, 2006. The plant
has not operated at this time. All correspondence regarding this COC should be sent to:
INGENCO Wholesale Power
2250 Dabney Road
Richmond, Virginia 23230
ATTN: Robert Greene
If you have any questions regarding this application, please contact me at (804) 521-
3557.
Sincerely,
Robert L. Greene, Ph. D.
Environmental Compliance Manager
2250 Dabney Road Richmond, VA 23230

ATA
NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Michael F. Easley, Govemor William G. Ross, Jr., Secretary
Alan W. Klimek, P.E., Director
NOTICE OF RENEWAL INTENT
Application for renewal of existing coverage under General Permit NCG500000
Existing Certificate of Coverage (CoC): NCG500635
(Please print or type)
1) Mailing address* of facility owner/operator:
Company Name INGENCO Wholesale Power. LLC
Owner Name INGENCO Wholesale Power. LLC
Street Address 2250 Dabney Road
City Richmond State VA ZIP Code 23230
Telephone Number [phone] Fax: [phone]
Email address [e-mail]
* Address to which all permit correspondence should be mailed
2) Location of facility producing discharge:
Facility Name INGENCO New Bern Plant
Facility Contact
Street Address 7420 Old US HWY 70 West
City New Bern State NC ZIP Code 28562
County Craven
Telephone Number [phone] Fax: [phone]
Email address [e-mail]
Note: The facility contact is Robert L. Greene, 2250 Dabney Road, Richmond, VA.
3) Description of Discharge:
a) Is the discharge directly to the receiving stream? 0 Yes 0 No
(If no, submit a site map with the pathway to the potential receiving waters clearly marked. This includes tracing the pathway of the
storm sewer to the discharge point, if the storm sewer is the only viable means of discharge.)
b) Number of discharge outfalls (ditches, pipes, channels, etc. that convey wastewater from the property):
1
c) What type of wastewater is discharged? Indicate which discharge points, if more than one.
X Non -contact cooling water
0 Boiler Blowdown
Outfall(s) #: 001
Outfall (s) #:
Page 1 of 3

NCG500000 renewal application
❑ Cooling Tower Blowdown Outfall (s) #:
❑ Condensate Outfall (s) #:
❑ Other Outfall (s) #:
(Please describe "Other")
d) Volume of discharge per each discharge point (in GPD):
#001: 5760 #002: #003: #004
4) Please check the type of chemical [s] added to the wastewater for treatment, per each separate discharge
point (if applicable, use separate sheet):
❑ Chlorine
X None
❑ Biocides 0 Corrosion inhibitors 0 Algaecide 0 Other
5) If any box in item (4) above [other than None] was checked, a completed Biocide 101 Form and
manufacturers' information on the additive must be submitted to the following address for approval:
NC DENR / DWQ / Environmental Sciences Section
Aquatic Toxicology Unit
1621 Mail Service Center
Raleigh, NC 27699-1621
6) Is there any type of treatment being provided to the wastewater before discharge (i.e., retention ponds,
settling ponds, etc.)? 0 Yes X No
(If yes, please include design specifics (i.e., design volume, retention time, surface area, etc.) with submittal package. Existing
treatment facilities should be described in detail. )
7) Discharge Frequency:
a) The discharge is: X Continuous 0 Intermittent 0 Seasonal*
i) If the discharge is intermittent, describe when the discharge will occur:
ii) *Check the month(s) the discharge occurs: 0 Jan 0 Feb 0 Mar. 0 Apr 0 May 0 Jun 0 Jul
❑ Aug. 0 Sept. 0 Oct. 0 Nov. 0 Dec.
b) How many days per week is there a discharge? 7
c) Please check the days discharge occurs: 0 Sat. 0 Sun. ❑ Mon. 0 Tue. 0 Wed. ❑ Thu. 0 Fri.
Additional Application Requirements:
The following information must be included in triplicate [original + 2 copies] with this application or it will
be returned as incomplete.
> Site map. If the discharge is not directly to a stream, the pathway to the receiving stream must
be clearly indicated. This includes tracing the pathway of a storm sewer to its discharge point.
➢ Authorization for representatives. If this application will be submitted by a consulting
engineer (or engineering firm), include documentation from the Permittee showing that the
Page 2 of 3

NCG500000 renewal application
consultant submitting the application has been designated an Authorized Representative of the
applicant.
Certification
I certify that I am familiar with the information contained in this application and that to the best of my
knowledge and belief such information is true, complete, and accurate.
Printed Name of Person Signing: Robert L. Greene
Title: Envir
G
ental Complianpe Manager
- ex- e — - - J72 3/6,7
(Signature of Applicant) (Date Signed)
North Carolina General Statute 143-215.6 b (i) provides that:
Any person who knowingly makes any false statement, representation, or certification in any application, record, report, plan or other document
filed or required to be maintained under Article 21 or regulations of the Environmental Management Commission implementing that Article, or who
falsifies, tampers with or knowingly renders inaccurate any recording or monitoring device or method required to be operated or maintained under
Article 21 or regulations of the Environmental Management Commission implementing that Article, shall be guilty of a misdemeanor punishable by
a fine not to exceed $25,000, or by imprisonment not to exceed six months, or by both. (18 U.S.C. Section 1001 provides a punishment by a fine
of not more than $25,000 or imprisonment not more than 5 years, or both, for a similar offense.)
asasasasasaEaEasasasaEa
This Notice of Renewal Intent does NOT require a separate fee.
The permitted facility already pays an annual fee for coverage under NCG500000.
aEUEaEaEaEaEaEasasaEaEa
Mail the original and two copies of the entire package to:
Mr. Charles H. Weaver
NC DENR / DWQ / NPDES
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Page 3 of 3

TopoZone - USGS Jasper (NC) Topo Map Page 1 of 1
0 1
2 3
4 5 km
0 1 2 3 4
UTM 18 302642E 3893549N (NAD27)
USGS Jasper (NC) Quadrangle
Projection is UTM Zone 18 NAD83 Datum
5 mi
M=-9.728
G=-1.249

INGENCO Tuscarora Landfill Project
imap://[e-mail]:143/...
Subject: [Fwd: INGENCO Tuscarora Landfill Project]
From: "Pat.Durrett" <[e-mail]>
Date: Mon, 27 Nov 2006 07:35:01 -0500
To: Sergei Chernikov <[e-mail]>
Sergei,
I recently submitted a staff report for INGENCO. I did not have the Lat & Lon. for
the site until now. Here it is:
35 deg 10' 38.45N
77 deg 13' 59.14W
This was submitted to me by Bob Green of INGENCO.
Pat
Subject: INGENCO Tuscarora Landfill Project
From: "Robert L. Greene" <[e-mail]>
Date: Tue, 21 Nov 2006 13:54:37 -0500
To: <[e-mail]>
Pat,
The lat and long for the discharge are:
35 Deg 10' 38.45"N
77 Deg 13' 59.14"W
Bob Greene
INGENCO
[phone]
1 of 1 11/27/2006 10:21 AM