WQ0032444_Regional Office Historical File Pre 2018 (3)

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Coleen H. Sullins, Director
Division of Water Quality
November 20, 2007
Ms. Christie Putnam, Director of Public Works
Union County Public Works
500 North Main Street
Monroe, NC 28112
Subject: Permit No. WQ0032444
Lawson Ph. 4
Union County Public Works
Union County, North Carolina
Dear Ms. Putnam,
In accordance with your application received on November 13, 2007, we are forwarding
herewith Permit No. WQ0032444, dated November 20, 2007, to the Union County Public Works for the
construction and operation of the subject wastewater collection system extension. This permit shall be
effective from the date of issuance until rescinded and shall be subject to the conditions and limitations
as specified therein. This cover letter shall be considered a part of this permit and is therefore
incorporated therein by reference.
Please pay particular attention to Permit Condition 3 which requires that the wastewater
collection facilities be properly operated and maintained in accordance with 15A NCAC 2T .0403 or any
individual system -wide collection system permit issued to the Permittee.
Permitting of this project does not constitute an acceptance of any part of the project that does
not meet 1) 15A NCAC 2T; 2) the Division of Water Quality's (Division) Gravity Sewer Minimum Design
Criteria adopted February 12, 1996, as applicable; 3) and the Division's Minimum Design Criteria for
the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000, as applicable,
unless specifically mentioned herein. Division approval is based on acceptance of the certification
provided by a North Carolina -licensed Professional Engineer in the application. It shall be the
Permittee's responsibility to ensure that the as -constructed project meets the appropriate design criteria
and rules. Failure to comply may result in penalties in accordance with North Carolina General Statute
§143-215.6A through §143-215.6C, construction of additional or replacement wastewater collection
facilities, and/or referral of the North Carolina -licensed Professional Engineer to the licensing board.
Mooresville Regional Office 610 East Center Ave., Suite 301 Mooresville, NC 28115 Phone: [phone] Fax: [phone]
Internet: www.ncmwaterquality.org Customer Service: 1-877-623-6748
An Equal Opportunity/Affirmative Action Employer-50% Recycled/10% Post Consumer Paper
o hCarolina
NNaturally

Ms. Putnam
Page 2
November 20, 2007
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North
Carolina as amended, and other applicable Laws, Rules, and Regulations, permission is hereby
granted to Union County Public Works for the construction and operation of approximately 12,785 linear
feet of 8-inch gravity sewer and the discharge of 28,500 gallons per day of collected domestic
wastewater into the Union County existing sewerage system, pursuant to the application received
November 13, 2006, and in conformity with 15A NCAC 2T; the Division's Gravity Sewer Minimum
Design Criteria adopted February 12, 1996, as applicable; the Division's Minimum Design Criteria for
the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000, as applicable; and
other supporting data subsequently filed and approved by the Department of Environment and Natural
Resources and considered a part of this permit.
The sewage and wastewater collected by this system shall be treated in the Union County's 12
Mile Creek WWTP (NPDES No. NC0085359) prior to being discharged into the receiving stream.
If any parts, requirements, or limitations contained in this permit are unacceptable, you have the
right to request an adjudicatory hearing upon written request within 30 days following receipt of this
permit. This request must be in the form of a written petition, conforming to Chapter 150B of North
Carolina General Statutes, and filed with the Office of Administrative Hearings, 6714 Mail Service
Center, Raleigh, NC 27699-6714. Unless.such demands are made, this permit shall be final and
binding.
if you need additional information concerning this matter, please contact Dee Browder at (704)
663-1699.
Sincerely,
for Coleen H. Sullins
cc: Mooresville Regional Office, Collection System Permit Files
Marc Houle, Yarbrough -Williams & Houle, Inc.
Surface Water Protection Central Files
PERCS

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
RALEIGH
WASTEWATER COLLECTION SYSTEM EXTENSION PERMIT
This permit shall be -effective from the date of issuance until rescinded and shall be subject to the
following specified conditions and limitations:
1. This permit shall become voidable unless the wastewater collection facilities are constructed in
accordance with the conditions of this permit; 15A NCAC 2T; the Division of Water Quality's
(Division) Gravity Sewer Minimum Design Criteria adopted February 12, 1996, as applicable; the
Division's Minimum Design Criteria for the Fast -Track Permitting of Pump Stations and Force
Mains adopted June 1, 2000, as applicable; and other supporting materials unless specifically
mentioned herein.
2. This permit shall be effective only with respect to the nature and volume of wastes described in the
application and other supporting data.
3. The wastewater collection facilities shall be properly maintained and operated at all times. The
Permittee shall maintain compliance with an individual system -wide collection system permit for the
operation and maintenance of these facilities as required by 15A NCAC 2T .0403. If an individual
permit is not required, the following performance criteria shall be met as provided in 15A NCAC 2T
.0403:
a. The sewer system shall be effectively maintained and operated at all times to prevent
discharge to land or surface waters, and any contravention of the groundwater standards in
15A NCAC 2E_ .0200 or the surface water standards in 15A NCAC 2B .0200.
b. A map of the sewer system shall be developed and shall be actively maintained.
c. An operation and maintenance plan shall be developed and implemented.
d. Pump stations that are not connected to a telemetry system shall be inspected every day (i.e.
365 days per year). Pump stations that are connected to a telemetry system shall be
inspected at least once per week.
e. High -priority sewer lines shall be inspected at least once per every six-month period of time.
f. A general observation of the entire sewer system shall be conducted at least once per year.
g. Inspection and maintenance records shall be maintained for a period of at least three years.
h. Overflows and bypasses shall be reported to the appropriate Division regional office in
accordance with 15A NCAC 2B .0506(a), and public notice shall be provided as required by
North Carolina General Statute §143-215.1C.

4. This permit shall not be transferable. In the event there is a desire for the wastewater collection
facilities to change ownership, or there is a name change of the Permittee, a formal permit request
shall be submitted to the Division accompanied by documentation from the parties involved, and
other supporting materials as may be appropriate. The approval of this request shall be
considered on its merits and may or may not be approved.
5. Construction of the gravity sewers, pump stations, and force mains shall be scheduled so as not to
interrupt service by the existing utilities nor result in an overflow or bypass discharge of wastewater
to the surface waters of the State.
6. Per 15A NCAC 2T .0116, upon completion of construction and prior to operation of these
permitted facilities, the completed Engineering Certification form attached to this permit shall be
submitted with the required supporting documents to the address provided on the form. A complete
certification is one where the form is fully executed and the supporting documents are provided as
applicable.
7. A copy of the construction record drawings shall be maintained on file by the Permittee for the life
of the wastewater collection facilities.
8. Failure to abide by the conditions and limitations contained in this permit; 15A NCAC 2T; the
Division's Gravity Sewer Design Criteria adopted February 12, 1996 as applicable; the Division's
Minimum Design Criteria for the Fast -Track Permitting of Pump Station and Force Mains adopted
June 1, 2000 as applicable; and other supporting materials may subject the Permittee to an
enforcement action by the Division, in accordance with North Carolina General Statutes §143-
215.6A through §143-215.6C.
9. In the event that the wastewater collection facilities fail to perform satisfactorily, including the
creation of nuisance conditions, the Permittee shall take immediate corrective action, including
those as may be required by this Division, such as the construction of additional or replacement
facilities.
10. The issuance of this permit shall not exempt the Permittee from complying with any and all
statutes, rules, regulations, or ordinances that may be imposed by other government agencies
(local, state and federal) which have jurisdiction, including but not limited to applicable river buffer
rules in 15A NCAC 2B .0200, erosion and sedimentation control requirements in 15A NCAC Ch. 4
and under the Division's General Permit NCG010000, and any requirements pertaining to wetlands
under 15A NCAC 2B .0200 and 15A NCAC 2H .0500.
11. Noncompliance Notification:
The Permittee shall verbally report to a Division of Water Quality employee at the Mooresville
Regional Office, telephone number [phone], as soon as possible, but in no case more than
24 hours or on the next working day, following the occurrence or first knowledge of the occurrence
of either of the following:
a. Any process unit failure, due to known or unknown reasons, that renders the facility incapable
of adequate wastewater transport, such as mechanical or electrical failures of pumps, line
blockage or breakage, etc.; or
b. Any failure of a pumping station or sewer line resulting in a by-pass directly to receiving waters
without treatment of all or any portion of the influent to such station or facility.
2

V
Voice mail messages or faxed information is permissible, but shall not be considered as the
initial verbal report. Overflows and spills occurring outside normal business hours may also be
reported to the Division of Emergency Management at telephone number [phone] or
[phone]. Persons reporting any of the above occurrences shall file a spill report by
completing Part I of Form CS-SSO (or the most current Division approved form), within five days
following first knowledge of the occurrence. This report shall outline the actions taken or
proposed to ensure that the problem does not recur. Part II of Form CS-SSO (or the most
current Division approved form) can also be completed to show that the SSO was beyond
control.
Permit issued this the 20th day of November, 2007.
NORTH CAROLINA ENVIRONMENTAL MANAGEMENT COMMISSION
ti t
for Coleen H. Sullins, Director
Division of Water Quality
By Authority of the Environmental Management Commission
Permit Number WQ0032444
3

Fast Track Engineering Certification
Permit No. WQ0032444
November 20, 2007
Own er/WWTPNUQCS
Christie Putnam
Union County Public Works
400 North Church Street
Monroe, NC 28112
PE
Marc Houle
Yarbrough -Williams & Houle., Inc.
PO Box 7007
Charlotte, NC 28241
Complete and submit this form to the permit issuing regional office with the following:
• One copy of the project record drawings (plan & profile views of sewer lines) of the wastewater collection
system extension
• Supporting design calculations (selected pumps, system curve, operating point, available storage if portable
generator(s) or storage greater than longest past three year outage reliability option selected) for any pump
stations permitted as part of this project
• Changes to the project should be clearly identified on the record drawings or in written summary form. Permit
modifications are required for any changes resulting in non-compliance with this permit, regulations or
minimum design criteria.
This project shall not be considered complete nor allowed to operate until this Engineer's Certification and all
required supporting documentation have been received by the Division. Therefore, it is highly recommended
that this certification be sent in a manner that provides proof of receipt by the Division.
ENGINEER'S CERTIFICATION
❑ Partial ❑ Final
, as a duly registered Professional Engineer in the State of North Carolina, having been
authorized to observe (❑ periodically, ❑ weekly, ❑ full time) the construction of Lawson Ph. 4, a Union County
project for the Permittee, hereby state that, to the best of my abilities, due care and diligence was used in the
observation of the construction such that the construction was observed to be built within substantial compliance of
this permit; 15A NCAC 2T; the Division of Water Quality's (Division) Gravity Sewer Minimum Design Criteria adopted
February 12, 1996 as applicable; the Division's Minimum Design Criteria for the Fast -Track Permitting of Pump
Stations and Force Mains adopted June 1, 2000 as applicable; and other supporting materials.
North Carolina Professional Engineer's
seal, signature, and date:
SEND THIS FORM & SUPPORTING DOCUMENTATION
WITH REQUIRED ATTACHMENTS TO THE FOLLOWING ADDRESS
MOORESVILLE REGIONAL OFFICE
SURFACE WATER PROTECTION
610 EAST CENTER AVENUE, SUITE 301
MOORESVILLE NC 28115
The Permittee is responsible for tracking all partial certifications up until a final certification is received. Any
wastewater flow made tributary to the wastewater collection system extension prior to completion of this
Engineer's Certification shall be considered a violation of the permit and shall subject the Permittee to appropriate
enforcement actions.

-TRACK APPLICATION for GRAVITY SEWERS, PUMP STATIONS, AND FORCE MAINS
PAGE 3
USE THE TAB KEY TO MOVE FROM FIELD TO FIELD! Application Number: jr, ., i t„,, :,,-,, --.,
(to be completed by DVVQ) ....,) GoA
: 1
1, Owner:
la. Union County Public Works
Full Legal Name (company, municipality, HOA, utility, etc.)
.r.v, lb. Christie L. Putnam, RE., Director of Public Works
Signing Official Name and Title (Please review 15A NCAC 2H .02 6(b) ffor authorized signing officials!)
lc, The legal entity who will own this system is.
Individual 0 Federal 0 Municipality Ej State/County 0 Private Partnership El Corporation El Other (specify):
0 ld. 500 N Main Street, Suite 500
LL Mailing Address
if North Carolina
State
0
1
h, 704-296-4212 1 704-296-4232 1.1
Telephone Facsimile
O 2. Project (Facility) information:
2a, Lawson Ph, 4
Brief Project Name (permit will refer to this name)
3, Contact Person.
3a. Mike Garbark, P E., Assistant Director of Public Works
le* Monroe
City
lg. 28112
Zip Code
E-mail
2b. Union
County Where Project is Located
Name and Affiliation of Someone Who Can Answer Questions About this Application
3b, 704-296-4239
Phone Number
3c, mikegarbarl_ieco,union.nc.us
E-mail
1. Project is Zi New 0 Modification (of an existing permit) If Modification, Permit No,:
For modifications, attach a separate sheet clearly explaining the reason for the modification (i.e. adding another
phase, changing line sizetlength, etc.). Only include the modified information in this permit application - do not
duplicate project information in B(7) and B(10-11) that has already been included in the original permit.
2 Owner is Public (skip to Item B(3)) 0 Private (go to Item 2(a))
2a. If private, applicant will be: 2b. If sold, facilities owned by a (must choose one
Retaining Ownership (i.e, store, church, single office, etc.) or 0 Public Utility (Instruction III)
Leasing units (lots, townhomes, etc. - skip to Item B(3)) 0 Homeowner Assoc./Developer (Instruction IV)
0 Selling units (lots, townhomes, etc— go to Item B(2b))
3. Union Count Public Works Dept _
Owner of Wastewater Treatment Facility F) Treating Wastewater From This Project
4a. Twelve Mile Creek 4b. NC 0085359
0 Name of WWTF VtWTF Permit
LL, 5a, Union Co, Public Works I5b, 8" & 36" 5c, WO 0024444 & WO 0012167
Z Owner of Downstream Sewer—iReceiving Sewer Size 0 Force Main
1 Gravity
I
I — Permit Number of Downstream Sewer (if known)
The origin of this wastewater is (check all that apply):
El Residential Subdivision E Car Wash
0 Apartments/Condominiums 0 Institution
El Mobile Home Park 0 Hospital
0 School 0 Church
0 Restaurant 0 Nursing Home
0 Office Li Other (specify):
100 % Domestic/Commercial
% Industrial
Other (specify):
7. Volume of wastewater to be allocated for this particular project: 28,500 gallons per day
*Do not include previously permitted allocations (SEE NOTE 8 BELOW)
8, If the permitted flow is zero, indicate why:
El Interceptor Line - Flow will be permitted in subsequent permits that connect to this line
0 Flow has already been allocated in Permit No
El Rehabilitation or replacement of existing sewer with no new flow expected
FTA 02/03 - Rev. 3 04/05

-TRACK APPLICATION for GRAVITY SEWERS, PUMP STATIONS, AND FORCE MAINS
PAGE 4
a.
LL!
n
z
H
Z
O
U
O
—
Q
E
rt
0
LL
Z
I--
2
IX
W
d
m
9. Provide the wastewater flow calculations used in determining the permitted flow in accordance with 15A NCAC 2H
.0219(1) for Item 8(7) or the design flow for line or pump station sizing if zero flow in the space below. Values other than
that in 15A NCAC 2H .0219(I)(1-2) must be supported with actual water or wastewater use data in accordance with 15A
NCAC 2H .0219(1)(3).
•
(3 bedroom) x (95 god) x (100 Tots) = 28,501) qpd
10. Summary of Sewer Lines to be Permitted (attach additional sheets if necessary)
Size (inches)
Length (feet)
Gravity or Force Main
(use the pull down menu)
8"
12,785
Gravity
ENTER TOTAL LINE LENGTH IN MILES
2.42
11. Summary of Pump Stations to be Permitted (attach additional sheets as necessary)
Location ID
(self chosen - as shown on
I plans for cross-reference)
I
I Design Flow
(MGD)
Operational Point
GPM @ TDH
Power Reliability Option
(1- dual line feed; 2- permanent generator w/ATS; 3-
portable generator w/telemetry; 4-wet well storage)
12. Does the sewer system comply with the Minimum Design Criteria for the Fast Track Permitting of Pump Stations and Force
Mains (latest version), the Gravity Sewer Minimum Design Criteria (latest version) and 15A NCAC 2H .0200 as applicable?
►' Yes • No If no, please reference the pertinent minimum design criteria or regulation and indicate why a
variance is requested. SUBMIT TWO COPIES OF PLANS, SPECIFICATIONS OR CALCULATIONS
PERTINENT TO THE VARIANCE WITH YOUR APPLICATION
13. Have the following permits/certifications been submitted for approval?
Wetland/Stream Crossings - General Permit or 401 Certification?
Sedimentation and Erosion Control Plan?
Stomiwater?
• Yes • No ►l N/A
1 Yes • No • NIA
❑ N/A
@ Yes ■ No
14. Does this project involve aerial lines or siphons?
These_ fines_ will_be_consideredhiat .orioritxand_nusLbe checked
15. Does this project have gravity sewer lines designed
Be aware that the Division will not accept installed lines more
corrected prior to submitting the final engineering certification..
Check if yes: ❑
once every six_months
at minimum slopes? ❑
than 10% flatter than the minimum slope. Lines Installed outside this tolerance should be
FTA 02/03 - Rev. 3 04/05

cn
ppirRA,CK APPLICATION for GRAVITY SEWERS, PUMP STATIONS, AND FORCE MAINS PAGE 5
_
; 1, Use the Division's guidance document entitled, "DETERMINING STREAM CLASSIFICATIONS FOR FORM FTA 02/03
(FAST -TRACK SEWER SYSTEMS)" to collect and record the stream classification data below (attach additional sheets as
necessary). This document is available from our web site or by contacting the appropriate Division of Water Quality
Z regional office (see instructions for addresses) OR indicate the following:
O A Stream Classification is not needed because all parts of the project are at least 100 feet away from any down slope
waterbody; AND,
LJ A Stream Classification is not needed because the design does not depend on wet well storage as a power reliability
option for any pump station near a Class C down slope waterbody,
Location ID on Map
(self chosen - as shown on
map for cross-reference)
Lawson Ph. 4
Name of
Waterbody County
East Fork Twelve Union
(-Jot:A
Waterbody Stream Waterbody
River Basin Index Classification
Catawba 11-138-2
Submit the 8.5" x 11" COLOR topographic map as required in Instruction VI
regardless of whether a classification is provided!
1, Applicant's Certification:
la,
Signing Officia
2. Professional Engineer's Certification:
I, Christie L. Putnam, attest that this application for Lawson Ph. 4 has been reviewed by me and is accurate and
complete to the best of my knowledge. I understand that if all required parts of this application are not completed and
that if all required supporting documentation and attachments are not included, this application package is subject to
being returned as incomplete, Note: In accordance with North Carolina General Statutes 143-215.6A and 143-215.68,
any person who knowingly makes any false statement, representation, or certification in any application shall be guilty o
a cia'S-1 2 misdemeanor which may include a fine not to exceed $/0,000 as well as civil penalties up to $25,000 per
IWO .
natu re/
Date
1 attest that this application for Lawson Ph. 4 has been reviewed by me and is accurate, complete and consistent with the
information in the engineering plans, calculations, and all other supporting documentation to the best of my knowledge. 1
further attest that to the best of my knowledge the proposed design has been prepared in accordance with the applicable
regulations, Gravity Sewer Minimum Design Criteria for Gravity Sewers adopted February 12, 1996, and the Minimum
Design Criteria for the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000 and the watershed
classification in accordance with Division guidance, Although certain portions of this submittal package may have been
; developed by other professionals, inclusion of these materials under my signature and seal signifies that I have reviewed
this material and have judged it to be consistent with the proposed design. Note: In accordance with NC General Statutes
W 143-215.6.A and 143-215.68, any person who knowingly makes any false statement, representation, or certification in any
application shall be guilty of a Class 2 misdemeanor which may include a fine not to exceed $10„000 as well as civil
penalties up to $25,000 per violation.
2a, Marc A. Houle
Professional Engineer Name
2b. Yarbrough -Williams & Houle, Inc.
Engineering Firm
2c. P.O. Box 7007
Mailing Address
2d, Charlotte 2e. NC 2f. 28241
City i State Zip
2g. 704-556-1990 I2h, 704-556-0505 2i. March@y-wh,com
Telephone I Facsimile I E-mail
Seal, Signature &Dthe
FTA 02/03 - Rev, 3 04/05

WAXHAW, N, C.
34O80-H6-TF-424
1970
pH()Y(3 EVISED 1988
DMA 4855 I NW -SERIES V842

UNION COUNTY PUBLIC WORKS
500 N. Main Street, Suite 500
Monroe, NC 28112
704/296-4210
Fax [phone]
To: NC Department of Environment and Natural Resources
Mooresville Regional Office
610 East Center Avenue
Suite 301
Mooresville, N.C. 28115
Attention:
Regarding: Sanitary Sewer to serve Lawson, Phase 4 Subdivision
We are sending you:
Copies
Date
10/4/07
10/4/07
10/1/07
NC DENR MR0
D . Q- urtace Water Pratectton
Date: 11/2/07
Copy of letter I Plans 1 1 Prints l Shop Drawings
FlOther
Description
Original Non -Discharge Permit Application
Copy of Non -Discharge Permit Application
Check for $480.00 (Application Fee)
These are transmitted as checked below:
X For approval For your use As requested For review and comments
Remarks:
Signed:
Received by:
Date:

Permit Number WQ0032444
Central Files: APS SWP
11/19/07
Permit Tracking Slip
Program Category
Non -discharge
Status Project Type
In review New Project
Permit Type Fast Track Version
Gravity Sewer Extension, Pump Stations, & Pressure Sewer A
Extensions
Primary Reviewer
dee.browder
Permitted Flow
28500
Facility
Permit Classification
Individual
Permit Contact Affiliation
Facility Name Major/Minor Region
Lawson Ph. 4 Minor Mooresville
Location Address
Owner
County
Union
Facility Contact Affiliation
Owner Name Owner Type
Union County Public Works Government - County •
Owner Affiliation
Christine Putnam, Director Interim
500 N Main St Ste 500
Monroe NC 281124730
Dates/Events
Orig Issue
11/20/07
App Received
11/13/07
Regulated Activities
Subdivision
Wastewater collection
Outfall NULL
Draft Initiated
Scheduled
Issuance
Public Notice Issue Effective Expiration
11/20/07 11/20/07
Reauested/Received Events
Additional information requested
Additional information received
Waterbody Name Stream Index Number Current Class Subbasin