WQ0032364_Regional Office Historical File Pre 2018 (3)

VC).°F W AT
Q:
C
-iceu
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Coleen H. Sullins, Director
Division of Water Quality
November 5, 2007
Ms. Christie Putnam, P.E., Director of Public Works
Union County Public Works
500 North Main Street
Monroe, NC 28112
Subject: Permit No. WQ0032364
St. Johns Forest Ph. 4B
Wastewater Collection System Permit
Union County Public Works
Union County, North Carolina
Dear Ms. Putnam,
In accordance with your application received on October 23, 2007, we are forwarding herewith
Permit No. WQ0032364, dated November 5, 2007, to the Union County Public Works for the
construction and operation of the subject wastewater collection system extension. This permit shall be
effective from the date of issuance until rescinded and shall be subject to the conditions and limitations
as specified therein. This cover letter shall be considered a part of this permit and is therefore
incorporated therein by reference.
Please pay particular attention to Permit Condition 3 which requires that the wastewater
collection facilities be properly operated and maintained in accordance with 15A NCAC 2T .0403 or any
individual system -wide collection system permit issued to the Permittee.
Permitting of this project does not constitute an acceptance of any part of the project that does
not meet 1) 15A NCAC 2T; 2) the Division of Water Quality's (Division) Gravity Sewer Minimum Design
Criteria adopted February 12, 1996, as applicable; 3) and the Division's Minimum Design Criteria for
the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000, as applicable,
unless specifically mentioned herein. Division approval is based on acceptance of the certification
provided by a North Carolina -licensed Professional Engineer in the application. It shall be the
Permittee's responsibility to ensure that the as -constructed project meets the appropriate design criteria
and rules. Failure to comply may result in penalties in accordance with North Carolina General Statute
§143-215.6A through §143-215.6C, construction of additional or replacement wastewater collection
facilities, and/or referral of the North Carolina -licensed Professional Engineer to the licensing board.
Mooresville Regional Office 610 East Center Ave., Suite 301 Mooresville, NC 28115 Phone: [phone] Fax: [phone]
Internet: www.ncmwaterquality.org Customer Service: 1-877-623-6748
An Equal Opportunity/Affirmative Action Employer— 50% Recycled/10% Post Consumer Paper
NNor` hCaroli na
aturally

Prs.m
Page 2 •
November 5, 2007
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North
Carolina as amended, and other applicable Laws, Rules, and Regulations, permission is hereby
granted to Union County Public Works for the construction and operation of approximately 1,746 linear
feet of 8-inch gravity sewer and the discharge of 13,965 gallons per day of collected domestic
wastewater into the Union County existing sewerage system, pursuant to the application received
October 23, 2007, and in conformity with 15A NCAC 2T; the Division's Gravity Sewer Minimum Design
Criteria adopted February 12, 1996, as applicable; the Division's Minimum Design Criteria for the Fast -
Track Permitting of Pump Stations and Force Mains adopted June 1, 2000, as applicable; and other
supporting data subsequently filed and approved by the Department of Environment and Natural
Resources and considered a part of this permit.
The sewage and wastewater collected by this system shall be treated in the Union County's
Twelve Mile Creek W.NTP (NPDES No. NC0085359) prior to being discharged into the receiving
stream.
If any parts, requirements, or limitations contained in this permit are unacceptable, you have the
right to request an adjudicatory hearing upon written request within 30 days following receipt of this
permit. This request must be in the form of a written petition, conforming to Chapter 150B of North
Carolina General Statutes, and filed with the Office of Administrative Hearings, 6714 Mai! Service
Center, Raleigh, NC 27699-6714. Unless such demands are made, this permit shall be final and
binding.
If you need additional information concerning this matter, please contact Dee Browder at (704)
663-1699.
Sincerely,
for Coleen H. Sullins
cc: Mooresville Regional Office, Collection System Permit Files
Marc Houle, Yarbrough -Williams & Houle, Inc.
Surface Water Protection Central Files
PERCS

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
RALEIGH
WASTEWATER COLLECTION SYSTEM EXTENSION PERMIT
This permit shall be effective from the date of issuance until rescinded and shall be subject to the
following specified conditions and limitations:
1. This permit shall become voidable unless the wastewater collection facilities are constructed in
accordance with the conditions of this permit; 15A NCAC 2T; the Division of Water Quality's
(Division) Gravity Sewer Minimum Design Criteria adopted February 12, 1996, as applicable; the
Division's Minimum Design Criteria for the Fast -Track Permitting of Pump Stations and Force
Mains adopted June 1, 2000, as applicable; and other supporting materials unless specifically
mentioned herein.
2. This permit shall be effective only with respect to the nature and volume of wastes described in the
application and other supporting data.
3. The wastewater collection facilities shall be properly maintained and operated at all times. The
Permittee shall maintain compliance with an individual system -wide' collection system permit for the
operation and maintenance of these facilities as required by 15A NCAC 2T .0403. If an individual
permit is not required, the following performance criteria shall be met as provided in 15A NCAC 2T
.0403:
a. The sewer system shall be effectively maintained and operated at all times to prevent
discharge to land or surface waters, and any contravention of the groundwater standards in
15A NCAC 2L .0200 or the surface water standards in 15A NCAC 2B .0200.
b. A map of the sewer system shall be developed and shall be actively maintained.
c. An operation and maintenance plan shall be developed and implemented.
d. Pump stations that are not connected to a telemetry system shall be inspected every day (i.e.
365 days per year). Pump stations that are connected to a telemetry system shall be
inspected at !east once per week.
e. High -priority sewer lines shall be inspected at least once per every six-month period of time.
f. A general observation of the entire sewer system shall be conducted at least once per year.
g. Inspection and maintenance records shall be maintained for a period of at least three years.
h. Overflows and bypasses shall be reported to the appropriate Division regional office in
accordance with 15A NCAC 2B .0506(a), and public notice shall be provided as required by
North Carolina General Statute §143-215.1C.
1

•
•
4. This permit shall not be transferable. In the event there is a desire for the wastewater collection
facilities to change ownership, or there is a name change of the Permittee, a formal permit request
shall be submitted to the Division accompanied by documentation from the parties involved, and
other supporting materials as may be appropriate. The approval of this request shall be
considered on its merits and may or may not be approved.
5. Construction of the gravity sewers, pump stations, and force mains shall be scheduled so as not to
interrupt service by the existing utilities nor result in an overflow or bypass discharge of wastewater
to the surface waters of the State.
6. Per 15A NCAC 2T .0116, upon completion of construction and prior to operation of these
permitted facilities, the completed Engineering Certification form attached to this permit shall be
submitted with the required supporting documents to the address provided on the form. A complete
certification is one where the form is fully executed and the supporting documents are provided as
applicable.
7. A copy of the construction record drawings shall be maintained on file by the Permittee for the life
of the wastewater collection facilities.
8. Failure to abide by the conditions and limitations contained in this permit; 15A NCAC 2T; the
Division's Gravity Sewer Design Criteria adopted February 12, 1996 as applicable; the Division's
Minimum Design Criteria for the Fast -Track Permitting of Pump Station and Force Mains adopted
June 1, 2000 as applicable; and other supporting materials may subject the Permittee to an
enforcement. action by the Division, in accordance with North Carolina General Statutes §143-
215.6A through §143-215.6C.
9. In the event that the wastewater collection facilities fail to perform satisfactorily, including the
creation of nuisance conditions, the Permittee shall take immediate corrective action, including
those as may be required by this Division, such as the construction of additional or replacement
facilities.
10. The issuance of this permit shall not exempt the Permittee from complying with any and all
statutes, rules, regulations, or ordinances that may be imposed by other government agencies
(local, state and federal) which have jurisdiction, including but not limited to applicable river buffer
rules in 15A NCAC 2B .0200, erosion and sedimentation control requirements in 15A NCAC Ch. 4
and under the Division's General Permit NCG010000, and any requirements pertaining to wetlands
under 15A NCAC 2B .0200 and 15A NCAC 2H .0500.
11. Noncompliance Notification:
The Permittee shall verbally report to a Division of Water Quality employee at the Mooresville
Regional Office, telephone number [phone], as soon as possible, but in no case more than
24 hours or on the next working day, following the occurrence or first knowledge of the occurrence
of either of the following:
a. Any process unit failure, due to known or unknown reasons, that renders the facility incapable
of adequate wastewater transport, such as mechanical or electrical failures of pumps, line
blockage or breakage, etc.; or
b. Any failure of a pumping station or sewer fine resulting in a by-pass directly to receiving waters
without treatment of all or any portion of the influent to such station or facility.
2

•
'Voice mail messages or faxed information is permissible, but shall not be considered as the
initial verbal report. Overflows and spills occurring outside normal business hours may also be
reported to the Division of Emergency Management at telephone number [phone] or
[phone]. Persons reporting any of the above occurrences shall file a spill report by
completing Part I of Form CS-SSO (or the most current Division approved form), within five days
following first knowledge of the occurrence. This report shall outline the actions taken or
proposed to ensure that the problem does not recur. Part II of Form CS-SSO (or the most
current Division approved form) can also be completed to show that the SSO was beyond
control.
Permit issued this the 5th day of November, 2007.
NORTH CAROLINA ENVIRONMENTAL MANAGEMENT COMMISSION
i-Z--1 6 t---,
for Coleen H. Sullins, Director
Division of Water Quality
By Authority of the Environmental Management Commission
Permit Number WQ00323364
3

•
•
Track Engineering Certification
INo. WQ0032364
ber 5, 2007
Owner/WWrPM/QCS PE
Christie Putnam Marc Houle
Union County Public Works Yarbrough -Williams & Houle Inc.
400 North Church Street PO Box 7007
Monroe, NC 28112 Charlotte, NC 28241
Complete and submit this form to the permit issuing regional office with the following:
• One copy of the project record drawings (plan & profile views of sewer lines) of the wastewater collection
system extension
• Supporting design calculations (selected pumps, system curve, operating point, available storage if portable
generator(s) or storage greater than longest past three year outage reliability option selected) for any pump
stations permitted as part of this project
• Changes to the project should be clearly identified on the record drawings or in written summary form. Permit
modifications are required for any changes resulting in non-compliance with this permit, regulations or
.minimum design criteria.
This project shall not be considered complete nor allowed to operate until this Engineer's Certification and all
required supporting documentation have been received by the Division. Therefore, it is highly recommended
that this certification be sent in a manner that provides proof of receipt by the Division.
ENGINEER'S CERTIFICATION
❑ Partial ❑ Final
, as a duly registered Professional Engineer in the State of North Carolina, having been
authorized to observe (❑ periodically, ❑ weekly, ❑ full time) the construction of St. Johns Forest Ph 4B, a Union
County project for the Permittee, hereby state that, to the best of my abilities, due care and diligence was used in the
observation of the construction such that the construction was observed to be built within substantial compliance of
this permit; 15A NCAC 2T; the Division of Water Quality's (Division) Gravity Sewer Minimum Design Criteria adopted
February 12, 1996 as applicable; the Division's Minimum Design Criteria for the Fast -Track Permitting of Pump
Stations and Force Mains adopted June 1, 2000 as applicable; and other supporting materials.
North Carolina Professional Engineer's
seal, signature, and date:
SEND THIS FORM & SUPPORTING DOCUMENTATION
WITH REQUIRED ATTACHMENTS TO THE FOLLOWING ADDRESS
MOORESVILLE REGIONAL OFFICE
SURFACE WATER PROTECTION
610 EAST CENTER AVENUE, SUITE 301
MOORESVILLE NC 28115
The Permittee is responsible for tracking all partial certifications up until a final certification is received. Any
wastewater flow made tributary to the wastewater collection system extension prior to completion of this
Engineer's Certification shall be considered a violation of the permit and shall subject the Permittee to appropriate
enforcement actions.

0
Zce
W
LL
z
z
ACK APP ICATION for (;RAVITY SE "1 ERS, PUMP STATIONS, AND FORCE MAINS
USE THE TAB KEY TO MOVE FRO
Owner:
la. Union County Public Works
Full Legal Name (company, municipality, HOA, utility, etc,)
1b. Christie L. Putnam, P.E., Director of Public Works
Signing Official Name and Title (Please review 15A NCAC 2H .0206(b) for authorized signing o
Application Number:
(to be completed by DWQ)
lc. The legal entity who will own this system
❑ Individual ❑ Federal ❑ Municipality State/County ❑ Private Partnership ❑ Corporation ❑ Other (specify):
ld. 500 N. Main Street Suite 500
Mailing Address
1f. North Carolina
State .�.---....-...�..�.-.�. _
l h. 704-296-4212 1 i,
Telephone
2. Project (Facility) Information:
2a. St. Johns Forest Ph. 46
704-296-4232
Facsimile
le. Monroe
City
lg. 28112
Zip Code
E-mail
2b. Union
Brief Project Name (permit will refer to this name) County Where Project is Located
3. Contact Person
Mike Garbark, P E., Assistant Dire or of
ks
3a. Name and Affll la ion of Someone Who Ca Public
rQuestions About this Application
3b. 704-296--4239 Vic. mikec9arbarkreico.union,nc.us
Phone Number _ E-mail
1 Project is New 0 Modification (of an existing permit) If Modification, Permit No..m
For modifications, attach a separate sheet clearly explaining the reason for the modification (i.e. adding another
phase, changing line size/length, etc.), Only include the modified information in this permit application - do not
duplicate project information in 8(7) and 8(10-11) that has already been included in the original permit,
2. Owner is [' Public (skip to Item 8(3)) ❑ Private (go to Item 2(a))
2a. If private, applicant will be
Retaining Ownership (i.e. store„ church, single office, etc.) or
❑ Leasing units (lots, townhomes, etc. - skip to Item B(3))
O 0 Selling units (lots, townhomes, etc. - go to Item B(2b))
Imo- 3, Union County Public Works Dept,
Owner of Wastewater Treatment Facility
re • 4a, Twelve Mile Creek
Name of WWT,F
5a. Union C© Public Works b. 8°' Gravity
Owner of Downstream eer (Receiving Sewer Size ❑ Force Main
The origin of this wastewater is (check at that apply):
Residential Subdivision
Apartments/Condominiums
❑ Mobile Home Park
❑ School
❑ Restaurant
❑ Office
0 Car Wash
Institution
❑ Hospital
❑ Church
0 Nursing Home
❑ Other (specify).
2b, If sold, facilities owned by a (must choose one)
• Public Utility (Instruction III)
O Homeowner Assoc.IDevelope
F) Treating Wastewater From This Project
4b NC 0085359
VVVVTF Per
mit No.
WQ 0028692
(
nstruction IV)
Permit Number of Downstream Sewer (if known
• Domestic/Commercial
• Industrial
% Other (specify):
7, Volume of wastewater to be allocated for this particular project. 13365 gallons per day
`Do not include previously permitted allocations
8. If the permitted flow is zero, indicate why:
❑ Interceptor Line - Flow will be permitted in subsequent permits that connect to this line
Flow has already been allocated in Permit No.
El Rehabilitation or replacement of existing sewer with no new flow expected
I °TA 02103 - Rev. 3 04105

RACK APPLICATION for GRAVITY SEWERS, PUMP STATIONS, AND FORCE MAINS
PAGE 4
9. Provide the wastewater flow calculations used in determining the permitted flow in accordance with 15A NCAC 2H
.0219(1) for Item B(7) or the design flow for line or pump station sizing if zero flow in the space below. Values other than
that in 15A NCAC 2H .0219(1)(1-2) must be supported with actual water or wastewater use data in accordance with 15A
NCAC 2H .0219(1)(3).
(3 bedroom) X (95 qpd) X (49 lots) = 13.965 qpd
10. Summary of Sewer Lines to be Permitted (attach additional sheets if necessary)
Size (inches)
Length (feet)
Gravity or Force Main
(use the pull down menu)
8^
1,746
Gravity
Ei
LLJ
m
z
Z i -ENTER TOTAL LINE LENGTH IN MILES
O
0.33
>—
Si11. Summary of Pump Stations to be Permitted (attach additional sheets as necessary)
1 Location ID
j (self chosen - as shown on !Design Flow
IH ' plans for cross-reference)(MGD)
Operational Point
GPM @ TDH
Power Reliability Option
(1- dual line feed; 2- permanent generator w/ATS; 3-
portable generator w/telemetry; 4-wet well storage)
CL I-----
0'
LL
I �
I-
5
C
LLI
a
m
;12.
,
Does the sewer system comply with the Minimum Design Criteria for the Fast Track Permitting of Pump Stations and Force
Mains (latest version), the Gravity Sewer Minimum Design Criteria (latest version) and 15A NCAC 2H .0200 as applicable?
►. Yes ❑ No If no, please reference the pertinent minimum design criteria or regulation and indicate why a
variance is requested. SUBMIT TWO COPIES OF PLANS, SPECIFICATIONS OR CALCULATIONS
PERTINENT TO THE VARIANCE WITH YOUR APPLICATION
113. Have the following permits/certifications been submitted for approval?
1 I Wetland/Stream Crossings - General Permit or 401 Certification?
1
i Sedimentation and Erosion Control Plan?
Stormwater?
❑ Yes
1A Yes
® Yes
•
•
•
No
No
No
® N/A
❑ N/A
• N/A
14. Does this project involve aerial lines or siphons? Check if yes: ❑
rrheseJines wilLbe_considered_hls h_Orioritv_and_must_be checked_once_everv_sixmonths_
i15. Does this project have gravity sewer lines designed at minimum slopes? ■
Be aware that the Division will not accept installed lines more than 10% Hatter than the minimum slope. Lines installed outside this tolerance should be
corrected prior to submitting the final engineering certification..
FTA 02/03 - Rev. 3 04/05

0
LU
z
0
CK APPLICATION for GRAVITY SEWERS, .L'UMP STATIONS, AND FORCE MAINS PAGE 5
1. Use the Division's guidance document entitled, "DETERMINING STREAM CLASSIFICATIONS FOR FORM FTA 02/03
' (FAST -TRACK SEWER SYSTEMS)." to collect and record the stream classification data below (attach additional sheets as:
necessary) This document is available from our web site or by contacting the appropriate Division of Water Quality
regional office (see instructions for addresses) OR indicate the following:
EJ A Stream Classification is not needed because all parts of the project are at least 100 feet away from any down s ope
waterbody; AND,
Ej A Stream Classification is not needed because the design does not depend on wet well storage as a power reliability
option for any pump station near a Class C down slope waterbody.
Location ID on Map
(self chosen - as shown on
map for cross-reference)
St Johns Forest Ph. 4B
Name of
Waterbody County River Basin
12 Mile Creek Union Catawba
Waterbody Stream
Index
11-138
Submit the 8.5" x 11" COLOR topographic map as required in Instruction VI
regardless of whether a classification is provided!
1 Applicant's Certification:
la
Si.ing Official Si*ature
2. Professional Engineer's Certification'
Waterbody
Classification
1, Christie L. Putnam, attest that this application for St. Johns Forest Ph. 48 has
been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of
this application are not completed and that if all required supporting documentation and attachments are not included,
this application package is subject to being returned as incomplete, Note: In accordance with North Carolina General
Statu 143-215.6A and 143-215,68, any person who knowingly makes any false statement, representation, or
in any applicatio shall be guilty of a Class 2 misdemeanor which may include a fine not to exceed $/0,000
civil penalties • to $25OQ0 per violation„
id JLO
Date
attest that this application for St. Johns Forest Ph, 48 has been reviewed by me and is
accurate, complete and consistent with the information in the engineering plans, calculations, and all other supporting
documentation to the best of my knowledge. I further attest that to the best of ,my knowledge the proposed design has
been prepared in accordance with the applicable regulations, Gravity Sewer Minimum Design Criteria for Gravity Sewers
adopted February 12, 1996, and the Minimum Design Criteria for the Fast -Track Permitting of Pump Stations and Force
Mains adopted June 1, 2000 and the watershed classification in accordance with Division guidance, Although certain
portions of this submittal package may have been developed by other professionals, inclusion of these materials under my
signature and seal signifies that I have reviewed this material and have judged it to be consistent with the proposed design,
Note. In accordance with NC General Statutes 143-215.6A and 143-215.6B, any person who knowingly makes any false
statement, representation, or certification in any application shall be guilty of a Class 2 misdemeanor which may lude a
fine not to exceed $10,000 as well as civil penalties up to $25,000 per violation,
2a. Marc A. Houle
Professional Engineer Name
2b, Yarbrough-VVilliams & Houle, Inc.
Engineering Firm
2c, P,O, Box 7007
Mailing Address
2d, Charlotte
City
2g. 704-556-1990
Telephone Facsimile
2e, NC 2f, 28241 N
State ; Zip
„ '111/rfiCi0
2h. 704-5 6-0505 .2i, Marchy-wh.com ;
;
i Seal, Signa:re & Da
E-mail :
FTA 02/03 - Rev, 3 04/05

MAT` HEWS, N, C.
35A90-A&TF-024
WAXHAW, N. C.
34080-16-Tr-024
1970
pru '10fl .1sr:r) 19e:0
'dMA 4853 b 916^8611IF$ 1.142
f4
BAKERS, N. C,
35080 A5 1F 024
1071
D14A 4854 PI SF, SEA000 Y64?
MONR©E, R. C.
34080-445-TIF.024
1971
DMA 4855 I NF.- SE141F.8 4'442

Permit Number WQ0032364
Central Files: APS SWP
11 /05/07
Permit Tracking Slip
Program Category
Non -discharge
Permit Type Fast Track
Gravity Sewer Extension, Pump Stations, & Pressure Sewer
Extensions
Primary Reviewer
dee.browder
Permitted Flow
13965
Facility
Status
Active
Project Type
New Project
Version Permit Classification
1.00 Individual
Permit Contact Affiliation
Facility Name
St. Johns Forest Ph 4B
Location Address
Owner
Owner Name
Union County Public Works
Dates/Events
Orig issue
11/05/07
App Received
10/23/07
Regulated Activities
Subdivision
Wastewater treatment and disposal
Outfall NULL
Scheduled
Draft Initiated Issuance
Major/Minor
Minor
Region
Mooresville
County
Union
Facility Contact Affiliation
Owner Type
Government - County
Owner Affiliation
Christine Putnam, Director Interim
500 N Main St Ste 500
Monroe NC 281124730
Public Notice Issue Effective
11/05/07 11/05/07
Reauested!Received Events
Additional information requested
Additional information received
Expiration
Waterbody Name Stream Index Number Current Class Subbasin

UNION COUNTY PUBLIC WORKS
500 N. Main Street, Suite 500
Monroe, NC 28112
704/296-4210
Fax [phone]
To: NC Department of Environment and Natural Resources
Mooresville Regional Office
610 East Center Avenue
Suite 301
Mooresville, N.C. 28115
TRANSMITTAL
Attention: Date: 10/19/07
Regarding: Sanitary Sewer to serve St. John's Forest, Phase 4B Subdivision
We are sending you: I I Copy of letter I Plans E Prints — Shop Drawings
Other
Copies
Description
Original Non -Discharge Permit Application
Copy of Non -Discharge Permit Application
Check for $480.00 (Application Fee)
These are transmuted as checked below:.
For approval
Remarks:
Signed:
Received by:
For your use As requesteryi
d 10 re ei
Date: