WQ0030201_Regional Office Historical File Pre 2018 (3)

William (r. Ross, Jr., Secret
rot rat°t.taysrrtrtatra.aat as d Natural Resources
Alan \L° Klimek,, r.f Dirvctcac
1sa<isu a'r as Water (Juallty
May 5, 2006
Ms, Christie Putnam, Interim Director
Union County Public Works
400 North Church Street
Monroe, North Carolina 28112
Subject: Permit No. WQ0030201
Garmon's Crossing
Union County Public Works
Wastewater Collection System Extension
Union County, North Carolina
Dear Ms Putnam.
In accordance with your application received on April 10, 2006, we are forwarding herewith
Permit No. WQ0030201, dated May 5, 2096, to Union County Public Works for the construction and
operation of the subject wastewater collection system extension, This permit shall be effective from the
date of issuance until rescinded and shall be subject to the conditions and limitations as specified
therein. This cover letter shall be considered a part of this permit and is therefore incorporated therein
by reference.
Please pay particular attention to Permit Condition 3 which requires that the wastewater
collection facilities be properly operated and maintained in accordance with 15A NCAC 2H .02.27 or any
individual system -wide collection system permit issued to the Permittee.
Permitting of this project does not constitute an acceptance of any part of the project that does
not meet 1) 15A NCAC 2H ,0200, 2) the Division of Water Quality's (Division) Gravity Sewer Minimum
Design Criteria adopted February 12, 1996, as applicable; 3) and the Division's Minimum Design
Criteria for the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000, as
applicable, unless specifically mentioned herein. Division approval is based on acceptance of the
certification provided by a North Carolina -licensed Professional Engineer in the application. It shall be
the Permittee's responsibility to ensure that the as -constructed project meets the appropriate design
criteria and rules. Failure to comply may result in penalties in accordance with North Carolina General
Statute §143-215.6A through §143-215.6C, construction of additional or replacement wastewater
collection facilities, and/or referral of the North Carolina -licensed Professional Engineer to the licensing
board.
Mooresville Regional Office 610.East Center Ave, Suite 301 Moores vi NC 28115 Phone: [phone]Qs Fax: (704)6ti3-6040
Internet:: www.ncwaterqualitr.crg ;u teata r wrua• 1- r7-� -6"
An Equal Cpportun4y1AffirmativeActicn Employer -- 500 Recycled/1 % Post Consumer Paper
Ore
Nt7lthCaro1an3
alurally

PrIFIP-
Ms. Christie Putnam
Page 2
May 5, 2006
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North Carolina
as amended, and other applicable Laws, Rules, and Regulations, permission is hereby granted to
Union County Public Works for the construction and operation of approximately 3,170 linear feet of 8-
inch gravity sewer as part of Garmon's Crossing project, and the discharge of 7,200 gallons per day of
collected domestic wastewater into Union County's existing sewerage system, pursuant to the
application received April 10, 2006, and in conformity with 15A NCAC 2H .0200; the Division's Gravity
Sewer Minimum Design Criteria adopted February 12, 1996, as applicable; the Division's Minimum
Design Criteria for the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000,
as applicable; and other supporting data subsequently filed and approved by the Department of
Environment and Natural Resources and considered a part of this permit.
The sewage and wastewater collected by this system shall be treated in the Union County
WWTP (Twelve Mile Creek WWTP NPDES No. NC0085359) prior to being discharged into the
receiving stream.
If any parts, requirements, or limitations contained in this permit are unacceptable, you have the
right to request an adjudicatory hearing upon written request within 30 days following receipt of this
permit. This request must be in the form of a written petition, conforming to Chapter 150B of North
Carolina General Statutes, and filed with the Office of Administrative Hearings, 6714 Mail Service
Center, Raleigh, NC 27699-6714. Unless such demands are made, this permit shall be final and
binding.
If you need additional information concerning this matter, please contact Dee Browder at (704)
663-1699.
Sincerely,
/fie . . jG-�'�
for Alan W. Klimek, P.E.
cc: Mooresville Regional Office, Surface Water Protection (WWTP Permit No. NC0085359)
John Ross, Eagle Engineering
Surface Water Protection Central Files
Marie Doklovic, PERCS

P1
NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
RALEIGH
WASTEWATER COLLECTION SYSTEM EXTENSION PERMIT
This permit shall be effective from the date of issuance until rescinded and shall be subject to the
following specified conditions and limitations:
1. This permit shall become voidable unless the wastewater collection facilities are constructed in
accordance with the conditions of this permit; 15A NCAC 2H .0200; the Division of Water Quality's
(Division) Gravity Sewer Minimum Design Criteria adopted February 12, 1996, as applicable; the
Division's Minimum Design Criteria for the Fast -Track Permitting of Pump Stations and Force
Mains adopted June 1, 2000, as applicable; and other supporting materials unless specifically
mentioned herein.
2. This permit shall be effective only with respect to the nature and volume of wastes described in the
application and other supporting data.
3. The wastewater collection facilities shall be properly maintained and operated at all times. The
Permittee shall maintain compliance with an individual system -wide collection system permit for the
operation and maintenance of these facilities as required by 15A NCAC 2H .0227. If an individual
permit is not required, the following performance criteria shall be met as provided in 15A NCAC 2H
.0227:
a. The sewer system shall be effectively maintained and operated at all times to prevent
discharge to land or surface waters, and any contravention of the groundwater standards in
15A NCAC 2t..0200 or the surface water standards in 15A NCAC 2B .0200.
b. A map of the sewer system shall be developed and shall be actively maintained.
c. An operation and maintenance plan shall be developed and implemented.
d. Pump stations that are not connected to a telemetry system shall be inspected every day (i.e:
365 days per year). Pump stations that are connected to a telemetry system shall be
inspected at least once per week.
e. High -priority sewer lines shall be inspected at least once per every six-month period of time.
f. A general observation of the entire sewer system shall be conducted at least once per year.
g. Inspection and maintenance records shall be maintained for a period of at least three years.
h. Overflows and bypasses shall be reported to the appropriate Division regional office in
accordance with 15A NCAC 2B .0506(a), and public notice shall be provided as required by
North Carolina General Statute §143-215.1C.
1

4. This permit shall not be transferable. In the event there is a desire for the wastewater collection
facilities to change ownership, or there is a name change of the Permittee, a formal permit request
shall be submitted to the Division accompanied by documentation from the parties involved, and
other supporting materials as may be appropriate. The approval of this request shall be
considered on its merits and may or may not be approved.
5. Construction of the gravity sewers, pump stations, and force mains shall be scheduled so as not to
interrupt service by the existing utilities nor result in an overflow or bypass discharge of wastewater
to the surface waters of the State.
6. Per 15A NCAC 2H .0220, upon completion of construction and prior to operation of these
permitted facilities, the completed Engineering Certification form attached to this permit shall be
submitted with the required supporting documents to the address provided on the form. A complete
certification is one where the form is fully executed and the supporting documents are provided as
applicable.
7. A copy of the construction record drawings shall be maintained on file by the Permittee for the life
of the wastewater collection facilities.
8. Failure to abide by the conditions and limitations contained in this permit; 15A NCAC 2H .0200; the
Division's Gravity Sewer Design Criteria adopted February 12, 1996 as applicable; the Division's
Minimum Design Criteria for the Fast -Track Permitting of Pump Station and Force Mains adopted
June 1, 2000 as applicable; and other supporting materials may subject the Permittee to an
enforcement action by the Division, in accordance with North Carolina General Statutes §143-
215.6A through §143-215.6C.
9. In the event that the wastewater collection facilities fail to perform satisfactorily, including the
creation of nuisance conditions, the Permittee shall take immediate corrective action, including
those as may be required by this Division, such as the construction of additional or replacement
facilities.
10. The issuance of this permit shall not exempt the Permittee from complying with any and all
statutes, rules, regulations, or ordinances that may be imposed by other government agencies
(local, state and federal) which have jurisdiction, including but not limited to applicable river buffer
rules in 15A NCAC 2B .0200, erosion and sedimentation control requirements in 15A NCAC Ch. 4
and under the Division's General Permit NCG010000, and any requirements pertaining to wetlands
under 15A NCAC 2B .0200 and 15A NCAC 2H .0500.
11. Noncompliance Notification:
The Permittee shall verbally report to a Division of Water Quality employee at the Mooresville
Regional Office, telephone number [phone], as soon as possible, but in no case more than
24 hours or on the next working day, following the occurrence or first knowledge of the occurrence
of either of the following:
a. Any process unit failure, due to known or unknown reasons, that renders the facility incapable
of adequate wastewater transport, such as mechanical or electrical failures of pumps, line
blockage or breakage, etc.; or
b. Any failure of a pumping station or sewer line resulting in a by-pass directly to receiving waters
without treatment of all or any portion of the influent to such station or facility.
2

Voice mail messages or faxed information is permissible, but shall not be considered as the
initial verbal report. Overflows and spills occurring outside normal business hours may also be
reported to the Division of Emergency Management at telephone number [phone] or
[phone]. Persons reporting any of the above occurrences shall file a spill report by
completing Part I of Form CS-SSO (or the most current Division approved form), within five days
following first knowledge of the occurrence. This report shall outline the actions taken or
proposed to ensure that the problem does not recur. Part 11 of Form CS-SSO (or the most
current Division approved form) can also be completed to show that the SSO was beyond
control.
Permit issued this the 5th day of May, 2006.
NORTH CAROLINA ENVIRONMENTAL MANAGEMENT COMMISSION
j �e;---•
for Alan W. Klimek'P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission
Permit Number WQ003020i
3

Fast Track Engineering Certification
Permit No. WQ0030201
May 5, 2006
Complete and submit this form to the permit issuing regional office with the following:
• One copy of the project record drawings (plan & profile views of sewer lines) of the wastewater collection
system extension
• Supporting design calculations (selected pumps, system curve, operating point, available storage if portable
generator(s) or storage greater than longest past three year outage reliability option selected) for any pump
stations permitted as.part of this project
• Changes to the project should be clearly identified on the record drawings or in written summary form. Permit
modifications are required for anv changes resulting in non-compliance with this permit, regulations or
minimum design criteria.
This project shall not be considered complete nor allowed to operate until this Engineer's Certification and all
required supporting documentation have been received by the Division. Therefore, it is highly recommended
that this certification be sent in a manner that provides proof of receipt by the Division.
ENGINEER'S CERTIFICATION
❑ Partial ❑ Final
, as a duly registered Professional Engineer in the State of North Carolina, having
been authorized to observe(❑;periodically, ❑ weekly, ❑ full time) the construction of Garmon's Crossing, a
Union County project for the Permittee, hereby state that, to the best of my abilities, due care and diligence was
used in the observation of the construction such that the construction was observed to be built within substantial
compliance of this permit; 15A NCAC 2H .0200; the Division of Water Quality's (Division) Gravity Sewer Minimum
Design Criteria adopted February 12, 1996 as applicable; the Division's Minimum Design Criteria for the Fast -
Track Permitting of Pump Stations and Force Mains adopted June 1, 2000 as applicable; and other supporting
materials.
North Carolina Professional Engineer's
seal, signature, and date:
SEND THIS FORM & SUPPORTING DOCUMENTATION
WITH REQUIRED ATTACHMENTS TO THE FOLLOWING ADDRESS
MOORESVILLE REGIONAL OFFICE
SURFACE WATER PROTECTION
610 EAST CENTER AVENUE, SUITE 301
MOORESVILLE NC 28115
The Permittee is responsible for tracking all partial certificationsup until a final certification is received. Any
wastewater flow made tributary -to the wastewater collection system extension prior to completion of this
Engineer's Certification shall be considered a violation of the permit and shall subject the Permittee to appropriate
enforcement actions.

ACK APPLICATION for GRAVITY SEWERS, PUMP STATIONS, AND FORCE MAINS
PAGE 3
V
4a, Twelve
Name of WWTF
USE THE TAB KEY TO MOVE FROM FIELD TO FIELD!
Owner:
Union County Public Works
Full Legal Name (company, municipality, HOA, utility, etc,)
lb. Christie L. Putnam, P.E. Interim Director of Union County Public Works _
Signing Official Name and Title (Please review 15A NCAC 2H .0206(b) for authorized signing officials!)
Application Number:
(to be completed by DWQ
lc. The legal entity who will own this system is:
El Individual © Federal © Municipality X State/County El Private Partnership 0 Corporation LJ Other
1 d. 400 N, Church Street
Mailing Address
1f. North Carolina
State
lh. 70 j 296-4210
Telephone Facsimile
2. Project (Facility) Information:
2a. Garman's Crossing
Brief Project Name (permit will refer to this na
3. Contact .Person..
3a. Charles P. O'Cain, P.E., Deputy Director of Union County Public Works
Name and Affiliation of Someone Who Can Answer Questions About this Application
3b, [phone] 3c. o'[e-mail] _
Phone Number E-mail 1 Project is X New 0 Modification (of an existing permit) if Modification, Permit No,:
For modifications, attach a separate sheet clearly explaining the reason for the modification (i.e. adding another
phase, changing line size/length, etc.). Only include the modified information in this permit application - do not
duplicate project information in B(7) and B(14-11) that has already been included in the original permit.
1e. Monroe
2. Owner is X Public (skip to Item B(3))
2a. if private, applicant will be:
City
lg. 28112-4804
Zip Code
E-mail
2b, Union
County Where Project is Located
Private (go to Item 2(a))
2b. If sold, facilities owned by a (must choose one
© Retaining Ownership (i.e. store, church, single office, etc.) or 0 Public Utility (Instruction III)
0 Leasing units (lots, townhomes, etc, - skip to Item 8(3)) El Homeowner Assoc./Developer (Instruction IV)
D Selling units (lots, townhomes, etc. - go to Item B(2b))
3. Union County ._._
Owner of Wastewater Treatment Facility (WWTF) Treating Wastewater From This Project.
4b. NC0065359
WWTF Permit No.
5a. Union County 5b. "' X Gravity Sc.WQ001907
Owner of Downstream Sewer Receiving Sewer Size 0 Force Main Permit Number of Downstream
6. The origin of this wastewater is (check all that apply):
X Residential Subdivision
0 Apartments/Condominiums
© Mobile Home Park.
Lp School
© Restaurant
Office
0 Car Wash
0. Institution
El Hospital
0 Church
0 Nursing Home
0 Other (specify):
known)
100 %© Domestic/Commercial
7, Volume of wastewater to be allocated for this particular project: *7,200 gallons per day
Do not include previously permitted allocations (*SEE NOTE 8 BELOW)
% Industrial
%© Other (specify):
8. If the permitted flow is zero, indicate why:
0 Interceptor Line - Flow will be permitted in subsequent permits that connect to this line
0 Flow has already been allocated in Permit No. _
0 Rehabilitation or replacement of existing sewer with no new flow expected
*Flow for additional 40 lots will be permitted at a future date. (Sewer in this additional area is for construction only.)
ETA 02103 - Rev. 3 04/05

CK APPLICATION for GRAVITY SEWERS, PUMP STATIONS, AND FORCE MAINS
PAGE 4
13. P,ERMIT IliVFORMATIO1J (CONTINUED}:;
9. Provide the wastewater flow calculations used in determining the permitted flow in accordance with 15A NCAC 2H
.0219(I) for Item B(7) or the design flow for line or pump station sizing if zero flow in the space below. Values other than
that in 15A NCAC 2H .0219(I)(1-2) must be supported with actual water or wastewater use data in accordance with 15A
NCAC 2H .0219(I)(3).
20 lots x 120 gpd x 3 bedrooms = 7,200
10. Summary of Sewer Lines to be Permitted (attach additional sheets if necessary)
Size (inches)
Length (feet)
Gravity or Force Main
(use the pull down menu)
8"
3,170
Gravity
ENTER TOTAL LINE LENGTH IN MILES
0.60
11. Summary of Pump Stations to be Permitted (attach additional sheets as necessary)
Location ID
(self chosen - as shown on
plans for cross-referenceL
Design Flow
(MGD)
Operational Point
GPM @ TDH
Power Reliability Option
(1- dual line feed; 2- permanent generator w1ATS; 3-
partable generator w/telemetry; 4-wet well storageL
12. Does the sewer system comply with the Minimum Design Criteria for the Fast Track Permitting of Pump Stations and Force
Mains (latest version), the Gravity Sewer Minimum Design Criteria (latest version) and 15A NCAC 2H .0200 as Applicable?
X Yes ❑ No if no, please reference the pertinent minimum design criteria or regulation and indicatewhy a
variance is requested. SUBMIT TWO COPIES OF PLANS, SPECIFICATIONS OR CALCULATIONS
PERTINENT TO THE VARIANCE WITH YOUR APPLICATION
13. Have the following permits/certifications been submitted for approval?
Wetland/Stream Crossings - General Permit or 401 Certification? ❑ Yes 0 No
Sedimentation and Erosion Control Plan? Yes X No
Stormwater? Yes X No
X N/A
❑ N/A
• N/A
14. Does this project involve aerial lines or siphons? Check if yes: •
Tese]ines will.he daaslderod..ttlah j ority and.muscle_checkedonce.evecv.slxmonths
15. Does this project have gravity sewer lines designed at minimum slopes?
Be aware that the Division will not accept installed lines more than 10% flatter than the minimum slope. Lines installed outside this tolerance should be
corrected prior to submitting the final engineering certification..
FTA 02/03 - Rev. 3 04/05

1i ACK APPLICATION for GRAVITY SEr%'ERS, PUMP TA ON AND FORCE MAINS PAGE 5
1. Lise the Division's guidance document entitled, "DETERMINING STREAM CLASSIFICATIONS FOR FORM ETA 02103
(FAST -TRACK SEWER SYSTEMS)" to collect and record the stream classification data below (attach additional sheets as,
necessary). This document is available from our web site or by contacting the appropriate Division of Water Quality
regional office (see instructions for addresses) OR indicate the following:
D A Stream Classification is not needed because all parts of the project are at least 100 feet away from any down slope
waterbody; AND,
A Stream Classification is not needed because the design does not depend on wet well storage as a power reliability
option for any pump station near a Class C down slope waterbody.
Location ID on Map
(self chosen - as shown on
map for cross-reference)
From Source to Crooked
Crook
Name of
Waterbody
S. Fork
r'rn-k d Cr©©Ir
County
Union
River Basin
Yadkin
Waterbody Stream Waterbody
Index. Classification
13-17-20-2 C
Submit the 8.5" x 11" COLOR topographic map as required in Instruction VI
regardless of whether a classification is provided!
Applicant's Certifi
ion:
1, Christie L. Putnam, attest that this application for Garmon s Crossing has been reviewed by me and is accurate and
complete to the best of my knowledge, i understand that if all required parts of this application are not completed and
that if all required supporting documentation and attachments are not included, this application package is subject to
being returned as incomplete. Note: In accordance with North Carolina General Statutes 143-215.6A and 143-215.6B,
any person who knowingly makes any false statement, representation, or certification in any application shall be guilty of
a Class-2 misdemeanor which y include a fine not to exceed $10.000 as well as civil penalties up to $25,0-00 per
g iing Official Signature
Professional Engineer's Certification:
Date
1 attest that this application for Garmon's Crossing has been reviewed by me and is accurate, complete and consistent with
the information in the engineering plans, calculations, and all other supporting documentation to the best of my knowledge,
1 further attest that to the best of my knowledge the proposed design has been prepared in accordance with the applicable
regulations, Gravity Sewer Minimum Design Criteria for Gravity Sewers adopted February 12, 1996, and the Minimum
Design Criteria for the Fast -'Track Permitting of Pump Stations and Force Mains adopted June 1, 2000 and the watershed
classification in accordance with Division guidance. Although certain portions of this submittal package may have been
developed by other professionals, inclusion of these materials under my signature and seal signifies that 1 have reviewed
this material and have judged it to be consistent with the proposed design. Note: In accordance with NC General Statutes
143-215.6A and 143-215.6B, any person who knowingly makes any taise statement, representation, or certification in any
application shall be guilty of a Class 2 misdemeanor which may include a fine not to exceed $10,000 as well as civil
penalties up to $25, 000 per violation.
ohn H. Ross, P.E.
essional Engineer Name
2b. Eagle Engineering
Engineering Firm
2c. 310 Indian Trail -Fairview Road
Mailing Address
2d, Indian Trail
2e, NC 2f. 28079
City State Zip
29, [phone] 2h. [phone] 2i, jross©eagieonline.n
Telephone Facsimile
E-mail
Seal, Signature
ETA 02103 - Rev, 3 04/05

Central Files: APS SWP
05/04/06
Permit Number WQ0030201 Permit: Tracking Slip
Program Category Status Project Type
Non -discharge In review New Project
Permit Type Fast Track Version Permit Classification
Gravity Sewer Extension, Pump Stations, & Pressure Sewer A Individual
Extensions
Primary Reviewer Permit Contact Affiliation
dee.browder
Permitted Flow
7200
Facility
Facility Name Major/Minor Region
Garmon's Crossing Minor Central
Location Address
Owner
Owner Name
Union County
Dates/Events
County
Unknown
Facility Contact Affiliation
Owner Type
Government - County
Owner Affiliation
Christine Putnam, Director Interim
400 N Church St
Monroe
NC 28111
' Scheduled
Orig Issue App Received Draft Initiated issuance
04/10/06
Regulated Activities
Subdivision
Wastewater collection
Outfall NULL
Public Notice Issue
Effective Expiration
Re uestedlReceived Events
Additional information received
Additional information requested
Waterbody Name
Stream Index Number Current Class Subbasln

ch 22, 2006
Cif ARE:OTTE: NC' 7:8217
Christy
ta Cha e i
tmon County Public Wo
Church400 N. Street
onroe, NC 28112
Fro Dc Development
Re: a o Crossing
This tt r is to ,s ackno ledgetnentt t evelopment
yC is t with w to it 20 sewer taps(flows) for the
bdivision knownGarmons Crossing t this time of application. The
wiling 40 taps ill be permitted forconstruction only at zero flow,
tted at a later date not yet determined.
neerely,
rek Lawson
.H..H.L Development

UNION COUNTY PUBLIC WORKS
400 N. Church Street
Monroe, NC 28112-4804
704/296-4210
Fax [phone]
To: NC Department of Environment and Natural Resources
Mooresville Regional Office
610 East Center Avenue
Suite 301
Mooresville, N.C. 28115
Attention:
TRANSMITTAL
Regarding: Sanitary Sewer to serve Garmon's Crossing subdivision
Date: 4/6/06
We are sending you: ❑ Copy of letter ❑ Plans ❑ Prints ❑ Shop Drawings
® Other
Copies
Date
No.
Description
1
11/29/05
Original Non -Discharge Permit Application
1
11/29/05
Copy of Non -Discharge Permit Application
1
11-29-05
1142
Check for $400.00 (Application Fee) kit, cJEPT. OF Etdti'iriGmr,..ei�,1
Akin A.tATIin1A! f�it'P!rlirspro%
1
3/22/06
Flow letter from developer L1O0RES'; ' ° ' 'h!AL OFFICE
APR 1 ( 29n: .
These are transmitted as checked below:
Vr/4 TER QALITY SECTION
® For approval ❑ For your use ❑ As requested ❑ For review and comments
Remarks:
Signed:
Received by:
Date: