WQ0033924_Regional Office Historical File Pre 2018

r,J,L
AAA
NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins Dee Freeman
Governor Director Secretary
Mr. Dwight Smith, Town Administrator
Town of Norwood
PO Box 697
Norwood, NC 28128
1
April 6, 2009
Subject: Permit No. WQ0033924
Eastover PS FM Replacement
Wastewater Collection System Extension
Stanly County, North Carolina
Dear Mr. Smith,
In accordance with your application received on March 30, 2009, we are forwarding herewith
Permit No. WQ0033924 dated April 6, 2009, to the Town of Norwood for the construction and operation
of the subject wastewater collection system extension. This permit shall be effective from the date of
issuance until rescinded and shall be subject to the conditions and limitations as specified therein. This
cover letter shall be considered a part of this permit and is therefore incorporated therein by reference.
Please pay particular attention to Permit Condition 3 which requires that the wastewater
collection facilities be properly operated and maintained in accordance with 15A NCAC 2T .0403 or any
individual system -wide collection system permit issued to the Permittee.
Permitting of this project does not constitute an acceptance of any part of the project that does
not meet 1) 15A NCAC 2T; 2) the Division of Water Quality's (Division) Gravity Sewer Minimum Design
Criteria adopted February 12, 1996, as applicable; 3) and the Division's Minimum Design Criteria for
the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000, as applicable,
unless specifically mentioned herein. Division approval is based on acceptance of the certification
provided by a North Carolina -licensed Professional Engineer in the application. It shall be the
Permittee's responsibility to ensure that the as -constructed project meets the appropriate design criteria
and rules. Failure to comply may result in penalties in accordance with North Carolina General Statute
§143-215.6A through §143-215.6C, construction of additional or replacement wastewater collection
facilities, and/or referral of the North Carolina -licensed Professional Engineer to the licensing board.
Mooresville Regional Office
Location: 610 East.CenterAve., Suite 301 Mooresville, NC 28115
Phone: [phone] Fax: [phone] \ Customer Service: 1-877-623-6748 .
Internet: www.ncwaterqualitv.orq
An EouaI Oaoortunity `Affirmative Action Employer— 50% Recycled/10% Post Consumer paper
No thCaroli na
atureff

14. Have the following permits/certifications been submitted for approval for the system or project to be served?
Wetland/Stream Crossings - General Permit or 401 Certification? © Yes El No N/A.
Sedimentation and Erosion Control Plan? ❑ Yes © No N/A
Stormwater? d Yes El No N/A
15. Does this project include any high priority lines, e 15A NCAC 02T 0402 (2)] involve aerial lines, siphons, or interferen
manholes)? These Tines will be considered high priority and must be checked once eyery six months
Check if Yes. [J and provide details
Owner/Permittee's Certification: (Signature of Signing Official and Project Name)
1, Dwight Smith , attest that this application for „Eastover Pump Station Force Main Replacement
has been reviewed by me and is accurate and complete to the best of my knowledge. 1 understand that if all required
parts of this application any not completed and that if all required supporting documentation and attachments are not
included, this application package is subject to being returned as incomplete. Note: In accordance with North Carolina
General Statutes 143-215.6A and 143-215.68, any person who knowingly makes any false statement ,representation{ ort
certification in any application shall be guilty of a Class 2 misdemeanor„ which may include a fine not to exceed $10,000
as well civil penalties up tr r$25,000 per violation..
-�'-9��,.�� � ..�.� ��....,,,�...e_—mac! ��•
igning Official Signature
716,
Date
ENGINEERING DESIGN DOCUMENTS MUST BE COMPLETED PRIOR TO SUBMITTAL OF THIS
APPLICATION. THESE DOCUMENTS MUST INCLUDE PLAN AND PROFILE OF SEWERS, THEIR PROXIMITY
fjry TO OTHER UTILITIES, DESIGN CALCULATIONS, ETC, REFER TO 15A NCAC 02T ,0305
Z.
0
2. Professional Engineer's Certification: (Signature of Design Engineer and Project Name)
t, Stephen G. Chambers, PE , attest that this application for_ Eastover Pump Station Force Main Replacement
_ has been reviewed by me and is accurate, complete and consistent with the information in the engineering plans,
calculations, and all other supporting documentation to the best of my knowledge. 1 further attest that to the best of my
knowledge the proposed design has been prepared in accordance with the applicable regulations, Gravity Sewer Minimum
Design Cnferna for Gravity Sewers adopted February 12, 1996, and the Minimum Design Criteria for the Fast -Track
Permitting of Pump Stations and Force Mains adopted June 1, 2000 and the watershed classification in accordance with
Division guidance. Although other professionals may have developed certain portions of this submittal package, inclusion
of these materials under my signature and seal signifies that 1 have reviewed this material and have judged it to be
consistent with the proposed design_ Note: In accordance with NC General Statutes 143-215.6A and 143-215.68, any
person who knowingly makes any faise statement, representation, or certification in any application shall be guilty of a
Class 2 misdemeanor which may include a fine not to exceed $10,000 as well as civil penalties up to $25,000 per violation.
2a, Stephen G. Chambers PE
Professional Engineer Name
2b, Chambers Eng neering PA
Engineering Firm
2c. PO Box 1726
Mailing Address
2d. Albemarle_.
City
2g. 704-984-6427
Telephone
2e, N
State
2h. 704-984-6428 2i.
Facsimile
NC PE Seal, 5nature
FTA I2/07

State of North Carolina
I epartment of Environment and Natural Resources
Division of Water Quality
Floacking/Acceptance for Sewer Extension Permit Applications
(FTSI.i Ifl/07)
Pr©ect A l'cant Name: Town of Norwood
Project Name for which tloN s being requested: Eastover Pump Station Force Main
Replacement
afore than one ME- 10/07 may he required, in le pro oa c°t if the owner oJ'the WW7P is not responsible fOr curl
pump stations along the route of the proposeda�tc srtc r lcr s.
1, Complete this section ottly if you are the owner of the wastewater treatment plant.
a. WWTP Facility Name: Town of Norwood WW"Tl
b. WWTP Facility Permit #: NC0021 25
c. :WWTP facility's permitted flow
d. Estimated obligated flow not yet tributary to the W WTP
e. WWTP facility's actual avg. flow
f. Total, flow for this specific request
g. Total actual and obligated lows to the facility
h. Percent of permitted flow used
All flows are in MGD
0.75
t),32
0.32
42.7%
II. Complete this section for each ptatnp station you are responsible for along the route of this
proposed wastewater flow.
List pump stations located between the project connection point and the W WTP
Pump Station Name Approx. Capacity, MGD Approx. Current Avg.
(Firrn/I.)esign)
Daily i low, MGD
Certification Statement:
W. Dwight Smith _ .certit slat to the best of my knowledge, the addition of
volume of wastewater to be pernnittstl rrr this l rcaject leas been evaluated along the route to the
receiving wastewater treatment facility° and that the flow from this project is not anticipated to cause any
capacity related sanitary sewer overflows car overburden any downstream pump station en route to the
receiving treatment plant tender normal circumstances, This analysis has been performed in accordance
with local established policies and procedures using the best available data. This certification applies to
those items listed above in Sections 1 and II for which 1 am the responsible party. Signature of this form
indicates aces ante of this wastewater, flow,

FORM WSCAS-12/07
WATERSHED CLASS
FOR SEWER SYSTEMS
F
CATION ATTACHMENT
A leant Name m Project Name
Torn of Norwood Eastover Pump Station Force Main Replacen
Professional Engineer Name
En Firm Name
Stephen G. Chambers, PE Chambers Engineering, PA
ocation
ID
Name of i,IWaterbody,
Unnamed tributary to Pee
Dee River
River acerb©dy Stream Waterbody
County Basin Index No. Classification
Stanly Yadkin
Pee Dee
WS-IV, B, CA
t If unnamed, indicate "unnamed tributary to X", where Xis the named waterbody to which the unnamed tribute
1 certify that as a Registered Professional Engineer in the State of
North Carolina that if have diligently followed the Division's instructions
for classifying waterbodies and that the above classifications are
inclusive of the stated project, complete and correct to the best of my
knowledge and belief
PE Seal, Signature and Date
*** END OF FORM WSCAS-l2/07 ***
FORM: WSCAS-12/07
Page 1

Town of Norwood
Eastover PS FM Replacement
ine ring. PA
NC 28001 704-084-6/27
I!YSGS Cut Sheet
I 1of

Central Files: APS_ SWP_
04/04/09
Permit Number WQ0033924
Permit Tracking Slip
Program Category Status Project Type
Non -discharge In review New Project
Permit Type Fast Track Version Permit Classification
Gravity Sewer Extension, Pump Stations, & Pressure Sewer A Individual
Extensions
Primary Reviewer Permit Contact Affiliation
dee. browder
Permitted Flow
0
Facility
Facility Name
Eastover PS FM Replacement
Location Address
Owner
Major/Minor Region
Minor Mooresville
County
Stanly
Facility Contact Affiliation
Owner Name Owner Type
Town of Norwood Government - Municipal
Dates/Events
Orig Issue App Received
04/06/09 03/30/09
Regulated Activities
Subdivision
Wastewater collection
Outfall NULL
Draft initiated
Scheduled
Issuance
Owner Affiliation
W
PO Box 697
Norwood
Public Notice Issue
Smith, Administrator Town
NC 28128
Effective Expiration
04/06/09 04/06/09
Reues ed!Received Events
Additional information received
Additional information requested
Waterbody Name Stream Index Number Current Class Subbasin

rig , FA
3/27/2009
NCDENR, Mooresville Regional Office
Attn.: Ms. Dee Browder
610 East Center Ave.
Mooresville, NC 28115
Rey Town of Norwood
Fast Track Nan -Discharge Permit
Eastover Pump Station Force Main Replacement
Dear Ms_ Browder -
On behalf of The Town of Norwood I am submitting herein an application package for a Non -
Discharge permit in association with the above referenced project, This application includes
the requested permitting of 2,280 linear feet of 6" force main sewers discharging from the
Eastover Pump Station. There are no new flows generated as a result of this request. This
request deals with the installation of a 6" force main which will be serviced by an engine driven
pump assembly. The Town will continue to operate the existing 4" force main serviced by
motor driven pumps, This arrangement will allow the Town to increase total pumping capacity
at the Eastover station, We will be submitting further permitting requests as we develop a
replacement program for the aging Eastover Pump Station and associated collection system.
It is anticipated at that time that the existing 4" force main will be taken out of service,
This application is being submitted under the Fast Track Application process utilizing form
FTA 12/07.
On behalf of the Town of Norwood I would like to extend my appreciation for your time and
efforts in this matter,
Sincerely,
Stephen G. Chambers, PE
President
Attach: Permit Package (2 copies)
cc: Dwight Smith, Town of Norwood
P0, Box 1726 - 129. N. First St. - Albee," age, NC 28002 -- 704-98 ,6427

Fast Track Engineering Certification
Permit No. WQ0033924
April 6, 2009
Owner/WQCS/WWTP
Dwight Smith, Town Administrator
Town of Norwood
PO Box 697
Norwood, NC 28128
PE
Stephen Chambers
Chambers Engineering, PA
PO Box 1726
Albemarle, NC 28002
Complete and submit this form to the permit issuing regional office with the following:
• One copy of the project record drawings (plan & profile views of sewer lines) of the wastewater collection
system extension
• Supporting design calculations (selected pumps, system curve, operating point, available storage if portable
generator(s) or storage greater than longest past three year outage reliability option selected) for any pump
stations permitted as part of this project
• Changes to the project should be clearly identified on the record drawings or in written summary form, Permit
modifications are required for any changes resulting in non-com liance with thi e i ulations or
minimum design criteria.
This project shall not be considered complete nor allowed to operate until this Engineer's Certification and all
required supporting documentation have been received by the Division, Therefore, it is highly recommended
that this certification be sent in a manner that provides proof of receipt by the Division.
ENGINEERS CERTIFICATION
Final
1 6,10^.4;444.44*,rafa duly registered Pr.fessional Engineer in the State of North Carolina, having been
authorized to observe (0 periodically, Li weekly, fufulltime) the construction of Eastover PS FM Replacement, a
Stanly County project for the Permittee, hereby s ate that, to the best of my abilities, due care and diligence was used
in the observation of the construction such that the construction was observed to be built within substantial
compliance of this permit; 15A NCAC 2T; the Division of Water Quality's (Division) Gravity Sewer Minimum Design
Criteria adopted February 12, 1996 as applicable; the Division's Minimum Design Criteria for the Fast -Track
Permitting of Pump Stations and Force Mains adopted June 1, 2000 as applicable; and other supporting materials.
North Carolina Professional Engineer's
seal, signature, and date:
Partial
SEND THIS FORM & SUPPORTING DOCUMENTATION
WITH REQUIRED ATTACHMENTS TO THE FOLLOWING ADDRESS
MOORESVILLE REGIONAL OFFICE
SURFACE WATER PROTECTION
610 EAST CENTER AVENUE, SUITE 301
MOORESVILLE NC 28115
The Permittee is responsible for tracking all partial certifications up until a final certification is received. Any
wastewater flow made tributary to the wastewater collection system extension prior to completion of this
Engineer's Certification shall be considered a violation of the permit and shall subject the Permittee to appropriate
enforcement actions,