NC0083321_Permit Issuance_20020722

NPDES DOCUMENT SCANNINO COVER SHEET
NC0083321
ONWASA - Hubert WTP
..:n"' ::•lf9i-YL>':.is'r h...Y.:ati1li:.;i.n'�i�
NPDES Permit:
��.�M„e{{„yYa6PIdYL
Document Type:"
Permit Issuance )
Wasteload Allocation
Authorization to Construct (AtC)
Permit Modification
Complete File - Historical
Engineering Alternatives (EAA)
Report
Instream Assessment (67b)
Speculative Limits
Environmental Assessment (EA)
Document Date:
July 22, 2002
This document is printed on reuse paper - ignore any
content on the reverse side

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
William G. Ross, Jr., Secretary
Alan W. Klimek, P.E., Director
July 22. 2002
Mr. Kerry Randel
Onslow County
222 Georgetown Road
Jacksonville, North Carolina 28540
AVA
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Issuance of NPDES Permit NC0083321
Hubert WTP
Onslow County
Dear Mr. Randel:
Division personnel have reviewed and approved your application for renewal of the subject permit.
Accordingly, we are forwarding the attached NPDES discharge permit. This permit is issued pursuant to
the requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement between
North Carolina and the U.S. Environmental Protection Agency dated May 9, 1994 (or as subsequently
amended) .
Please note that this facility is discharging high amounts of total residual chlorine (TRC). The average TRC
concentration in the effluent should be below 28 µg/L (0.028 mg/L). This facility discharged concentrations
well above 28 µg/L during 2000 and 2001. Unless these concentrations are reduced, the Division may
reopen this permit to include a chlorine limit
If any parts, measurement frequencies or sampling requirements contained in this permit are unacceptable
to you, you have the right to an adjudicatory hearing upon written request within thirty (30) days following
receipt of this letter. This request must be in the form of a written petition. conforming to Chapter 150E of
the North Carolina General Statutes, and filed with the Office of Administrative Hearings (6714 Mail Service
Center, Raleigh, North Carolina 27699-6714). Unless such demand is made, this decision shall be final and
binding.
Please note that this permit is not transferable except after notice to the Division. The Division may require
modification or revocation and reissuance of the permit. This permit does not affect the legal requirements
to obtain other permits which may be required by the Division of Water Quality or permits required by the
Division of Land Resources, the Coastal Area Management Act or any other Federal or Local governmental
permit that may be required.
If you have any questions concerning this permit, please contact Christie Jackson at telephone number
[phone], extension 538.
cc: Central Files
Wilmington Regional Office/Water Quality Section
NPDES Unit
Shellfish Sanitation. Gina Brooks
1617 Mail Service Center, Raleigh, North Carolina 27699-1617
An Equal Opportunity Affirmative Action Employer
Sincerely.
ORIGINAL SIGNED B"(
SUSAN A. WILSON
Alan W. Klimek, P.E.
Telephone [phone] FAX [phone]
Visrr us ON THE INTERNET @ httpJ/h2o.enr.state.nc.us/NPOES

Permit NC0083321
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
Onslow County
is hereby authorized to discharge wastewater from a facility located at the
Hubert ViTTP
374 Hubert Boulevard
(NCSR 1428/NCSR 1744)
Hubert
Onslow County
to receiving waters designated as Queen Creek in the White Oak River Basin
in accordance with effluent limitations, monitoring requirements, and other
conditions set forth in Parts I, II, III and IV hereof.
This permit shall become effective September 1, 2002.
This permit and authorization to discharge shall expire at midnight on June 30, 2007.
Signed this day July 22, 2002.
ORIGINAL SIGNED BY
SUSAN A. WILSON
Alan W. Klimek, P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission

Permit NC0083321
SUPPLEMENT TO PERMIT COVER SHEET
Onslow Countyis hereby authorized to:
1. Continue to discharge filter and ion exchange backwash from a water treatment
facility.
The facility is located in Hubert at the Hubert WTP at 374 Hubert Boulevard
(NCSR 1428/NCSR 1744) in Onslow County.
2. Discharge from said treatment works at the location specified on the attached
map into Queen Creek, classified SA-HQW waters in the White Oak River Basin.

Latitude: 34°42'45"
Longitude: 77°1322"
Quad # I3ONW
Receiving Stream: Queen Creek
Stream Class: SA-HQW
Subbasin: 030502
NC0083321 - Hubert WTP
Onslow County

Permit NC0083321
A. (1.) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS — FINAL
During the period beginning on the effective date of this permit and lasting until
expiration, the Permittee is authorized to discharge from outfall 001. Such discharges
shall be limited and monitored by the Permittee as specified below:
EFFLUENT
CHARACTERISTICS
LIMITS-
MONITORING REQUIREMENTS
Monthly
Average
Weeidy
Average
Daily
Maximum
Measurement
Frequency
Sample Type
Sample Location
Flow
Weekly
Instantaneous
Effluent
Total Suspended Residue
30.0 mg/L
45.0 mg/L
2/Month
Grab
Effluent
Settleable Solids
0.1 ml/L
0.2 mVL
Weekly
Grab
Effluent
Turbididity'
.
Weekly
Grab
Upstream &
Downstream
Iron
_
Weekly
Grab
Effluent
Total Residual Chlorine
Weekly
Grab
Effluent
Chloride
Weekly
Grab
Effluent
pH2
Weekly
Grab
Effluent
Footnotes:
1. The discharge shall not cause the turbidity of the receiving water to exceed 25 NTU. If
the turbidity exceeds these levels due to natural background conditions, the discharge
level cannot cause any increase in the turbidity in the receiving stream.
2. The pH shall not be less than 6.8 standard units nor greater than 8.5 standard units.
There shall be no discharge of floating solids or visible foam in other than trace amounts

Re: NC0083321 & NC0083551
Subject: Re: NC0083321 & NC0083551
Date: Mon, 01 Jul 2002 07:59:32 -0400
From: Gina Brooks <[e-mail]>
To: Christie Jackson <[e-mail]>
Hi Christie,
Sorry you didn't receive my comments. My files indicate I commented on these back
in April, so they somehow must have ended up in the black hole between here and
Raleigh. Shellfish Sanitation had no comments on either of the permits provided
the facilities are operated and maintained properly. Thanks! Gina
Christie Jackson wrote:
> Hi Gina,
> These draft sere sent for approval and I haven't heard anything. Maybe
> they didn't make it through our mail system??? Could you please take a
> look and give me your comments ASAP? I have attached a copy of the
> drafts.
> Thanks!
> Christie
> Name: 83321_box.doc
> 83321_box.doc Type: Microsoft Word Document (application/msword)
Encoding: base64
Download Status: Not downloaded with message
> Name: 83321_draft.doc
> 83321_draft.doc Type: Microsoft Word Document (application/msword)
> Encoding: base64
Download Status: Not downloaded with message
Name: 83551_box.doc
> 83551_box.doc Type: Microsoft Word Document (application/msword)
Encoding: base64
Download Status: Not downloaded with message
> 83551_draft.doc
Name: 83551_draft.doc
Type: Microsoft Word Document (application/msword)
Encoding: base64
Download Status: Not downloaded with message
Gina Brooks <[e-mail]>
Environmental Health Program Specialist
Shellfish Sanitation Section, Morehead City
DENR, DEH
1 of 2 7/2/02 7:37 AM

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
William G. Ross, Jr., Secretary
Gregory J. Thorpe, Ph.D., Acting Director
April 17, 2002
MEMORANDUM
To: Giza Brooks,
NC DENR / DEH / Shellfish Sanitation
From: Christie R. Jackson
NPDES Unit
Subject:
Review of Draft NPDES Permit NC0083321
Onslow County - Hubert WTP
Onslow County
A7A
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
II APR 24
SHELLFISH SANITATION
11
Please indicate below your agency's position or viewpoint on the draft permit and return this form by
May 24, 2002. If you have any questions on the draft permit, please contact me at the telephone number
or e-mail address listed at the bottom of this page.
A NANAN VA wNVNVAN w w/VVN� w wSw wSw wSv ^"' VVANNV vNVANAN v w w w w w w w w w w
RESP NSE: (Check one)
Concur with the issuance of this permit provided the facility is operated and maintained properly, the
stated effluent limits are met prior to discharge, and the discharge does not contravene the designated
water quality standards.
Signed
Concurs with issuance of the above permit, provided the following conditions are met:
Opposes the issuance of the above permit, based on reasons stated below, or attached:
Date: 14/Z4it) 2
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 919 733-5083, extension 538 (fax) 919 733-0719
VISIT US ON THE INTERNET @ httpJ/h2o.enr.state.nc.us/NPDES
Christie.Jackson@ ncmail.net

07101092000
07512579
Page 17
Personal
on this
Affidavit of Publication
Daily News
Jacksonville, NC
Notary Public of the County of Onslow, State of North Carolina,
of The Daily ews, who being duly sworn, states that the advertisement entitled RE: NPDES PERMITS
a true copy of which is printed herewith, appeared in The Daily News, a newspaper published in the
City of Jacksonville, County of Onslow, State of North Carolina, 1 day a week for / week on the
following dates: April 24, 2002
PUBLIC NOTICE
State of North Carolina
Environmental Management
Commission/NPDES Unit
1617 Mail Service Center
Raleigh, NC 27699-1617
Notification of Intent to Issue a NPDES Wastewater Permit
On the basis of thorough staff review and application of NC General Statute 143.21. Public law 92-500 and
other lawful standards and regulations, the North Carolina Environmental Management Commission
proposes to issue a National Pollutant Discharge Elimination System (NPDES) wastewater discharge permit
to the person(s) listed below effective 45 days from the publish date of this notice.
NPDES Permit Number NC0023230, Town of Richlands (WWTP), P.O. Box 245, Richlands, NC 28574
has applied for a permit renewal for a facility located in Onslow County discharging treated wastewater into
Squires Run in the White Oak River Basin. Currently ammonia nitrogen, BOD, total residual chlorine and
total phosphorus are water quality limited. This discharge may affect future allocations in this portion of the
receiving stream.
NPDES Permit Number NC0083551, Onslow County - Dixon Water Treatment Plant, P.O. Box 1415,
Jacksonville, NC 28540 has applied for a permit renewal for a facility located in Onslow County discharging
untreated wastewater into an unnamed tributary to Stones Creek in the White Oak River Basin. Currently
settleable solids are water quality limited. This discharge may affect future allocations in this portion of the
receiving stream.
NPDES Permit Number NC0083321, Onslow County - Hubert Water Treatment Plant, P.O. Box 1415,
Jacksonville, NC 28540 has applied for a permit renewal for a facility located in Onslow County discharging
untreated wastewater into Queen Creek in the WHITE OAK River Basin. Currently settleable solids are water
quality limited. This discharge may affect future allocations in this portion of the receiving stream.
NPDES Permit Number NC0030431, Hewitt's Mobile Home Park, 250 Hubert Boulevard, Hubert, NC
28539 has applied for a permit renewal for a facility located in Onslow County discharging treat wastewater
into an unnamed tributary to Bell Swamp in the White Oak River Basin. Currently BOD, ammonia & fecal
coliform are water quality limited. This discharge may affect allocations in this portions of the receiving
07101092000
07512579
Page 18
stream.
Affidavit of Publication
Daily News
Jacksonville, NC
NPDES Permit Number NC0071706, Hinson Arms Apartments, 3340 Richlands Highway, Jacksonville, NC
28540 has applied for a permit renewal for a facility located in Onslow County discharging treated
wastewater into an unnamed tributary to the New River in the White Oak River Basin. Currently BOD,
ammonia, fecal coliform & total phosphorus are water quality limited. This discharge may affect future
allocations in this portion of the receiving stream.
NPDES Permit Number NC0062359, Horse Creek Farms Utilities Company, P.O. Box 14046, New Bern,
NC 28560 has applied for a permit renewal for a facility located in Onslow County discharging treated
wastewater into an unnamed tributary to Little Northeast Creek in the White Oak River Basin. Currently
BOD, ammonia, fecal coliform & total residual chlorine are water quality limited. This discharge may affect
future allocations in this portion of the receiving stream.
NPDES Permit Number NC0031577, Mercer Environmental Corporation - White Oak Estates WWTP,
1117 Gum Branch Road, Jacksonville, NC 28540 has applied for a permit renewal for a facility located in
Onslow County discharging treated wastewater into Northeast Creek in the White Oak River Basin.
Currently BOD, ammonia, fecal coliform & total phosphorus are water quality limited. This discharge may
affect future allocations in this portion of the receiving stream_
Written comments regarding the proposed permit will be accepted until 30 days after the publish date of this
notice. All comments received prior to that date are considered in the final determinations regarding the
proposed permit. The Director of the NC Division of Water Quality may decide to hold a public meeting for
the proposed permit should the Division receive a significant degree of public interest.
Copies of the draft permit and other supporting information on file used to determine conditions present in
the draft permit are available upon request and payment of the costs of reproduction. Mail comments and/or
requests for information to the NC Division of Water Quality at the above address or call Ms. Christie
Jackson at [phone], extension 538. Please include the NPDES per number (attached in any
communication. Interested persons may also visit the Division of Water Quality at 512 N. Salisbury Street,
Raleigh, NC 27604-1148 between the hours of 8:00 a.m. and 5:00 p.m. to review information on file.
April 24, 2002 `,„urrrnu,„,
‘4v). :$Rp''_o
Subscribed and sworn to this 24th day of April, 2002 4 QQ'.. ' '';
X *•
l �OTt. 2 _
n714�C011Ns
Notary Public
MY COMMISSION EXPIRED
JULY 2, 2002

tJao S67
NOogr332,1
Shcidd no -I- !z a problem — per pave 4/9/0z
� gen4 e mruC fa mit fl i to
Cpei Da p P?ffU4'i

PERMIT NUMBER: NC0083321
FACILITY NAME: Hubert WTP
CITY: Hubert
OUTFALL: 001
COUNTY: Onslow
PERIOD ENDING MONTH: 12 - 2001
REGION: Wilmington
00400
su
PH
00530
mg/1
SOLIDS, TOTAL
SUSPENDED
00545
ml/1
SOLIDS,
SETTLEABLE
00940
mg/1
CHLORIDE (AS
CL)
01045
mg/1
IRON, TOTAL(AS
FE)
50050
mgd
FLOW, IN
CONDUIT OR THRU
TREATMENT PLANT
50060
ug/1
CHLORINE,
TOTALRESIDUAL
1 -01
30
0.1
6.95 - 7.98
3.7
3,606
208
0.106
70
2-01
30
0.1
7.14 - 7.87
4.6
2,371
202
0.12
105
3-01
30
0.1
6.95 - 7.74
5.1
2,842
181
0.114
25
4-01
3t)
0.1
7.35 - 8
4.6
2,342
186
0.115
48
5-01
30
0.1
7.25 - 7.86
6.1
2,505
169
0.286
73
6-01
30
0.1
7.15 - 7.48
5.5
2,177
298
0.112
48
7-01
30
0.1
7.21 - 7.47
4.8
3,646
300
0.108
45
8-01
30
0.1
•
6.87 - 7.62
4.3
5,803
342
0.075
122
9 - 01
30
0.1
6.85 - 7.12
6.4
5,442
288
0.066
48
10.01
30
0.1
6.82 - 7.5
2.5
5,776
439
0.073
36
11-01
30
0.1
12-01
30
0.1
PAGE 1 OF 1

PERMIT NUMBER: NC0083321
FACILITY NAME: Hubert WTP
CITY: Hubert
OUTFALL: 001
COUNTY: Onslow
PERIOD ENDING MONTH: 12 - 2000
REGION: Wilmington
00400
su
PH
00530
mg/1
SOLIDS, TOTAL
SUSPENDED
00545
ml/1
SOLIDS,
SETTLEABLE
00940
mg/1
CHLORIDE (AS
CL)
01045
mg/1
IRON, TOTAL(AS
FE)
50050
mgd
FLOW, IN
CONDUIT OR THRU
TREATMENT PLANT
50060
ug/1
CHLORINE,
TOTALRESIDUAL
1 -00
30
0.1
7.07 - 8.24
1.6
3,599
160
0.131
660
2-00
30
0.1
7.03 - 7.88
1.7
2,966
156
0.139
43
3 - 00
30
0.1
7.17 - 7.73
3.4
3,605
119
0.133
40
4 - 00
30
0.1
6.91 - 7.75
3
3,871
155
0.132
68
5 - 00
30
0.1
6.9 - 7.96
4.3
4,399
230
0.128
102
6-00
30
0.1
6.92 - 7.91
12
2,054
195
0.133
78
7 - 00
30
0.1
7 - 7.85
7.9
3,353
202
0.122
75
8-00
30
0.1
6.93 - 7.95
7.4
2,460
266
0.127
114
9-00
30
0.1
7.5 - 7.81
4.6
2,625
203
0.125
38
10-00
30
0.1
7.45 - 7.96
8.4
4,057
270
0.091
93
11 -00
30
0.1
7.03 - 8
6.6
4,234
317
0.111
50
12-00
30
0.1
7.35 - 7.88
3.7
4,765
208
0.113
60
PAGE 1 OF 1

NPDES PERMIT APPLICATION -. SHORT FORM C
For manufacturing or commercial facilities with a discharge <1 MGD (or WTPs)
N. C. Department of Environment and Natural Resources
Division of Water Quality I NPDES Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
North Carolina NPDES Permit Number NCO() ca 3321
Please print or type
1. Applicant and facility producing discharge
A. Name i-\ D (D to-)p\}ea' k C et tir e..c\-k. P i'R CAA - C)C\ lOuD Coun-k-Lt
B. Mailing address of applicant:
Street address 222 CC b Oftt:X.a)n "Rd
City 3A Scilo-ll k t County DtiAn t Ot.
State[Dr CbtiaA Zip Code 1.`651/0
Telephone Number (q to ) 455 - Dl a'd
Fax Number ( q to ) q 5'S - MS
e-mail address ERt i-- Ftt4D6L. C13. Qn15lG.. . t44C• 0,5
C. Location of facility:
Street 31 1-1 61UT1
city Hue) AZT County On. 1 Dt.Z
StateMdr41 111A Zip Code 215
Telephone Number ( to )
2. Standard Industrial Classification (SIC) code(s): CA
3. Number of employees: 3I ;
4. Principal product(s) produced: Pbtttn\e Out-6' ,� L
Principal raw material(s) consumed:T 'D(1 km,p �ettm\e.S �� lGv ==-
5. Principal process(es):F\ i `k-V Cep'\ 1 -b T\ SkfalANNote C Cfl1 CD % k O IT1 bfl
6. Amount of principal product produced or raw material consumed
1 b
`nn
v N r :J
r:
c,a
LLi
roduction
Co:
J G-
1
���.,� .�r�.....................---._-..---- - -
Product Produced or Raw Material Consumed
(AVERAGE)
-
Product Produced or Raw Material Consumed
(PEAK)
per Day
1155 o ODC)
a l l OD \ D O O
per Month
1
per Year
7. Check here if discharge occurs all year tg , or
Circle the month(s) in which discharge occurs: January February March April
May June July August September October November December
Days per week discharge occurs: 9 0 'kS PEA ksE54c
tln.rinn _A -CO
Dona 1 'f')

NPDES PERMIT APPLICATION - SHORT FORM C
For manufacturing or commercial facilities with a discharge <1 MGD (or WTPs)
8. Types of wastewater discharged to surface waters only (check as applicable).
Discharge per operating day
Flow
(GALLONS PER OPERATING DAY)
Volume treated before discharging
(PERCENT)
Sanitary - daily average
Cooling water, etc. - daily average
•
Process water - daily average
.
Maximum per operating day for
total discharge (all types)
r S O ID0b
j
I D pajv
9. If any of the types of wastewater identified in item 8 (either treated or untreated) are discharged to places
other than surface waters, record the amount(s) discharged below:
A. Municipal sewer system 0 qpd
B. Underground well 0 gpd
C. Septic tank b gpd
D. Evaporation lagoon or pond 0 gpd
E. Other, specify 0 gpd
10. Number of separate discharge points:
11. Name of receiving stream(s): QUf'_e' C15 C _BLS
12. Does your discharge contain or is it possible for your discharge to contain one or more of the following
substances added as a result of your operations, activities, or processes? Circle all that apply:
aluminum ammonia beryllium cadmium chromium chlorine (residual
copper cyanide lead mercury nickel oil and grease
phenols selenium zinc None of the above
I certify that I am familiar with the information contained in the application and that to the best of my
knowledge and belief such information is true, complete, and accurate.
ueery WavAdel Pub.c U.fi 1 i t-i e s 7 .` reCfirr~
Printed narfle of Person gning Title
5J& ai
Signature of Apcant Date
1
North Carolina General Statute 143-215.6 (b)(2) provides that Any person who knowingly makes any false statement representation, or certification in
any application, record, report, plan, or other document files or required to be maintained under Article 21 or regulations of the Environmental
Management Commission implementing that Article, or who falsifies, tampers with, or knowingly renders inaccurate any recording or monitoring device or
method required to be operated or maintained under Article 21 or regulations of the Environmental Management Commission implementing that Article,
shall be guilty of a misdemeanor punishable by a fine not to exceed $10,000, or by imprisonment not to exceed six months, or by both.
Donal nf')
Voreinn —A_00