WQ0030665_Regional Office Historical File Pre 2018

QF w47- 4,
GAO G William G. Ross Jr., Secretary
r North Carolina Department of Enyirga tept aad Natu 1 Resot1rces
.' ss1v�41+Ch.
Aiv ,��� �.lnlli ay._„ �! c r
an Klimek, P:E:�lltreEorS
I°7OOR v visionofwiter'Qugi r:
ICE
November 30, 2006
Mr. Barry Shearin, PE, Chief Engineer
Charlotte -Mecklenburg Utilities
5100 Brookshire Blvd
Charlotte, NC 28216
Michael F. Easley, Governor
DEC 0 7 2;
fr i L.Vria)
h gip
Subject: Permit No. WQ0030665
Joy's Serenity Point
CMU Project No. 100-06-517
Pressure Sewer Extension
Mecklenburg County
Dear Mr. Shearin:
In accordance with your permit application received January 3, 2001, and subsequent
additional information received November 20, 2006, we are forwarding herewith Permit No.
WQ0030665 dated November 30, 2006, to Charlotte -Mecklenburg Utilities for the construction
and operation of the subject wastewater collection extension. This permit shall be effective
from the date of issuance until rescinded, and shall be subject to the conditions and limitations
as specified therein.
Please pay particular attention to Permit Condition 3 which requires that the
wastewater collection facilities be properly operated and maintained in accordance with 15A
NCAC 2H .0227 or any individual system -wide collection system permit issued to the Permittee.
Condition 13(c)(xii) describes the blanket variance given to Charlotte -Mecklenburg for use of
SDR 13.5 Class 315 pipe material in lieu of ferrous pipe in certain circumstances.
Permitting of this project does not constitute an acceptance of any part of the project
that does not meet 15A NCAC 2H .0200; the Division of Water Quality's (Division) Gravity Sewer
Minimum Design Criteria adopted February 12, 1996 as applicable; and the Division's Minimum
Design Criteria for the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1,
2000 as applicable, unless specifically mentioned herein. Division approval is based on.
acceptance of the certification provided by a North Carolina -licensed Professional Engineer in
the application. It shall be the Permittee's responsibility to ensure that the as -constructed
project meets the appropriate design criteria and rules. Failure to comply may. result in
penalties in accordance with North Carolina General Statute § 143-215.6A through § 143-
215.6C, construction of additional or replacement wastewater collection facilities, and/or
referral of the North Carolina -licensed Professional Engineer to the licensing board.
NorthCarolina
Naturally
Pretreatment, Emergency Response and Collection Systems Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
Telephone [phone] Fax [phone]
Internet http:l/h2o.enr.nc.state.us/ndpu
An Equal Opportunity Action Employer
50% recycled/10% post -consumer paper

Mr, Barry Shearin
November 30, 2006
Page 2
If any parts, requirements, or limitations contained in this permit are unacceptable, you
have the right to request an adjudicatory hearing upon written request within 30 days
following receipt of this permit. This request must be in the form of a written petition,
conforming to Chapter 150B of North Carolina General Statutes, and filed with the Office of
Administrative Hearings, 6714 Mail Service Center, Raleigh, NC 27699-6714, Unless such
demands are made this permit shall be final and binding.
Note that the Division has reorganized. All sewer related matters are now handled
through the Pretreatment, Emergency Response and Collection Systems Unit under the Point
Source Branch EXCEPT FOR FAST -TRACK SEWER PERMITTING WHICH CONTINUES TO BE
ADMINISTERED THROUGH OUR REGIONAL OFFICES. The Unit is located on the 13,h floor of the
Archdale building in downtown Raleigh. Please ensure the letterhead information is used for
all correspondence to ensure timely delivery.
One set of approved plans and specifications for the latest project is being forwarded
to you. If you need additional information concerning this matter, please contact Bennie
Goetze, Jr., PE at [phone] extension 375.
Sincerely
Alan W. KUrnek, P. E.
cc: Mecklenburg County Health Department
Rusty Rozzelle, Mecklenburg County Water Quality Program (700 N. Tryon St., Suite 205, Charlotte, 28202)
Mooresville Regional Office, Water Quality Section (Permit NIC0036277)
Mr, Mitch Latham, P. E. Lotham-Walters Engineering, ino„ 16507-A Northcross Dr„ Huntersville, NC, 28078
Water Quality Central Files
PERCS (formerly NDPU) Files

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
RALEIGH
WASTEWATER COLLECTION PERMIT
In accordance with the provisions'of Article 21 of Chapter 143, General Statutes of North Carolina as
amended, and other applicable Laws, Rules, and Regulations
PERMISSION IS HEREBY GRANTED TO
CHARLOTTE-MECKLENBURG UTILMFS
Mecklenburg County
FOR THE
construction and operation of a pressure sewer collection system consisting of approximately 1355 linear
feet of 2-inch pressure sewer to serve 20 residences in Joy's Serenity Point with the discharge of 3800
GPD of collected wastewater into the Charlotte -Mecklenburg existing sewerage system, pursuant to the
application received August 7, 2006, and subsequent additional information received by the Division,
and in conformity with the project plans, specifications, and other supporting data subsequently filed
and approved by the Department of Environment and Natural Resources and considered a part of this
permit. The Joy's Serenity Homeowners Association (Permit No. Wg0030663) will be responsible for
installing, owning, and maintaining the simplex pump stations connecting to the system.
This permit shall be effective from the date of issuance until rescinded and shall be subject to the
following specified conditions and limitations:
1. This permit shall become revocable unless the wastewater collection facilities are constructed in
accordance with the conditions of this permit; 15A NCAC 2H .0200; the Division of Water Quality's
(Division) Gravity Sewer Minimum Design Criteria adopted February 12, 1996 as applicable; the
Division's Minimum Design Criteria for the Fast -Track Permitting of Pump Stations and Force Mains
adopted June 1, 2000 as applicable; and other supporting materials unless specifically mentioned
herein.
2. This permit is effective only with respect to the nature and volume. of wastes described in the
application and other supporting data.
3. The wastewater collection facilities shall be properly maintained and operated at all times. The
Permittee shall maintain compliance with an individual system -wide collection system permit for the
operation and maintenance of these facilities as required .by 15A NCAC 2H .0227. If an individual
permit is not required, the following performance criteria shall be met as provided in 15A NCAC 2H
.0227:
a. The sewer system shall be effectively maintained and operated at dill times to prevent
discharge to land or surface waters, and any contravention of the groundwater standards in
15A NCAC 2L .0200 or the surface water standards in 15A NCAC 2B .0200.
b. A map of the sewer system shall be developed and shall be actively maintained.
c. An operation and maintenance plan shall be developed and implemented.
•1

d. Pump stations that are not connected to a telemetry system shall be inspected every day (i.e.
365 days per year). Pump stations that are connected to a telemetry system shall be
inspected at least once per week. This requirement does not apply to pump stations serving a
single building associated with a properly permitted pressure sewer system.
e. High -priority sewer lines shall be inspected at least once per every six-month period of time.
f. A general observation of the entire sewer system shall be conducted at least once per year.
g, Inspection and maintenance records shall be maintained for a period of at least three years.
h. Overflows and bypasses shall be reported to the appropriate Division regional office in
accordance with 15A NCAC 2B .0506(a), and public notice shall be provided as required by
North Carolina General Statute § 143-215.1 C.
4. The sewage and wastewater collected by this system shall be treated in the Charlotte -Mecklenburg
McDowell Creek Wastewater Treatment Facility (NPDES Permit No. NC0036277) prior to being
discharged into the receiving stream,
5. This permit is not transferable. In the event there is a desire for the -facilities to change ownership, or
there is a name change of the Permittee, a formal permit request must be submitted to the Division
of Water Quality (Division) accompanied by documentation from the parties involved and other
supporting materials as may be appropriate. The approval of this request will be considered on its
merits and may or may not be approved.
6. Construction of the sewers, pump station(s) and force main shall be scheduled so as not to interrupt
service -by the existing utilities nor result in an overflow or bypass discharge of wastewater to the
surface waters of the State. -
7. Per 15A NCAC 2H .0220, upon completion of construction and prior to operation of these permitted
facilities, the completed Engineering Certification form attached to this permit shall be submitted
with the required supporting documents to the address provided on the form. A complete
certification is one where the form is fully executed and the supporting documents are provided as
applicable.
8. A copy of the approved plans and specifications shall be maintained on file by the Permittee for the
life of the wastewater collection facilities.
9. Failure to abide by the conditions and limitations contained in this permit; 15A NCAC 2H .0200; the
Division's Gravity Sewer Design Criteria adopted February 12, 1996 as applicable; the Division's
Minimum Design Criteria for the Fast -Track Permitting of Pump Station and Force Mains adopted
June 1, 2000 as applicable; and other supporting materials may subject the Permittee to an
enforcement action by the Division, in accordance with North Carolina General Statutes § 143-
215.6A through §143-215.6C.
10. The issuance of this permit does not exempt the Permittee from complying with any and all statutes,
rules, regulations, or ordinances that may be imposed by other government agencies (i.e., local,
state, and federal) having jurisdiction, including but not limited to applicable river buffer rules in 15A
NCAC 2B .0200, soil erosion and sedimentation control requirements in 15A NCAC Chapter 4 and
under the Division's General Permit NCG010000, and any requirements pertaining to wetlands under
15A NCAC 2B .0200 and 15A NCAC 2H .0500.
2

11. The Permittee shall provide the following for the force main:
a. An air relief valve located at all high points along the force main.
b. Three feet of cover (minimum) over the force main or the_ use of ferrous material where three
feet cannot be maintained.
c. Adherence with the following minimum separations:
(i) Storm sewers (vertical) 12 inches
(ii) Water mains (vertical -water over sewer) 18 inches or (horizontal) 10 feet
(iii) In benched trenches (vertical) 18 inches
(iv) Any private or public water supply source, including any WS-I waters or Class I or Class 11
impounded reservoirs used as a source of drinking water 100 feet
(v) Waters classified WS (other than WS-I), B, SA, ORW, HQW, or SB (from normal high water
(or tide elevation)) 50 feet
(vi) Any other stream, lake or impoundment 10 feet
(vii) Any building foundation 5 feet
(viii) Any basement 10 feet
(ix) Top slope of embankment or cuts of 2 feet or more vertical height 10 feet
(x) Drainage systems
(I) Interceptor drains 5 feet
(II) Ground water lowering and surface drainage ditches 10 feet
(xi) Any swimming pool 10 feet
(xii) Ferrous sewer pipe with joints equivalent to water main standards, shall be used where
these minimum separations cannot be maintained. A variance has been granted by the
Division on April 13, 2000 (modified January 23, 2003) for the use of SDR 13.5 PVC pipe in
lieu of ductile iron pipe within the 25-ff to 100-ft radius of private wells for pipe sizes less
than, 4 inches. In no case shall any sewer fine be placed within 25-feet of a private well
or 50-feet of a public well.
12. In the event that the . facilities fail to perform satisfactorily, including the creation of nuisance
conditions, the Permittee shall take immediate corrective action, including those that may be
required by this Division, such as the construction of additional or replacement wastewater
collection facilities.
13. Noncompliance Notification:
The Permittee shalt verbally report to a water quality staff member at the Mooresville Regional
Office, telephone number 704-663-1699, as soon as possible, but in no case more than 24 hours or
on the next working day following the occurrence or first knowledge of the occurrence of either of
the following:
a. Any process unit failure, due to known or unknown reasons, that render the facility incapable of
adequate wastewater transport such as mechanical or electrical failures of pumps, line
blockage or breakage, etc.
b. Any failure of a pumping station or sewer line resulting in a by-pass directly to receiving waters
without treatment of all or any portion of the influent to such station or facility.
3

Voice mail messages or faxed information is permissible but this shall not be considered as the initial
verbal report. Overflows and spills occurring outside normal business hours may also be reported to
the Division of Emergency Management at telephone number [phone] or [phone].
Persons reporting any of the above occurrences shall file a spill report by completing Part I of Form
CS-SSO (or the most current Division approved form), within five days following first knowledge of the
occurrence. This report shall outline the actions token or proposed to ensure that the problem does
not recur. Per Condition 1(2), PartII of Form CS-SSO (or the most current Division approved form) can
also be completed to show that the SSO was beyond control.
16. The pressure sewer lines permitted herein shall be designated "high priority" until such time that the
contributing flow provides a velocity exceeding 2 feet per second. High priority lines must be
inspected once every six months and cleaned as necessary.
Permit WQ0030665 issued this the 30th day of November, 2006
NORTH CAROLINA ENVIRONMENTAL MANAGEMENT COMMISSION
an W. Klimek, P. E., Director
f Division of Water Quality
By Authority of the Environmental Management Commission
4

Permit No. WQ0030665
November 30, 2006
ENGINEER'S CERTIFICATION
Partial Final
I, , as a duly registered Professional Engineer in the State of
North Carolina, having been authorized to observe (periodically, weekly, full time) the construction of
1355 linear feet of 2-inch pressure sewer
for the Permittee hereby state that, to the best of my abilities, due care and diligence was used in the
observation of the construction such that the construction was observed to be built within substantial
compliance and intent of this permit, the approved plans and specifications, and other supporting
materials.
Signature
Registration No.
Date
Seal:
If modifications to the design (that affect the permit) are not on the record drawings, please indicate
them below or attach an additional sheet:
The above Engineer's Certification must be completed and submitted to the address below with one
(1) copy of the Record Drawings (i.e., as -constructed plans) of the permitted facilities. This project shall
not be considered complete and allowed fo operate until this Engineer's Certification and the Record
Drawings have been submitted. Any wastewater flow made tributary to the permitted facilities prior to
completion of this Engineer's Certification shall be considered a violation of the permit and shall subject
the Permittee to appropriate enforcement actions.
The Permittee is responsible for tracking all partial certifications up until a final certification is received. An overall final certification
is required with supporting documents even if multiple partial certifications and plans have been submitted.
NORTH CAROLINA DEPARTMENT OF ENVIRONMENT & NATURAL RESOURCES
DIVISION OF WATER QUALITY
WATER QUALITY SECTION
PRETREATMENT, EMERGENCY RESPONSE & COLLECTION SYSTEMS UNIT
1617 MAIL SERVICE CENTER
RALEIGH, NORTH CAROLINA 27699-1617

Aye Michael F. Easley, CGovernor
WilliamG. i;
North C_arohna Department of Environment Alt !MAT
Al
November 6, 2006
Mr. Barry Shearin, Chief Engineer
Charlotte -Mecklenburg Utilities
5100 Brookshire Boulevard
Charlotte, North Carolina 28216
Subject: Application No. WQ0030665 1 Additional Information Reques r t
Joy's Serenity Point
Wastewater Collection System Extension
Mecklenburg County
ime
Division o'
NOV C 8 200
Dear Mr. Shearin:
The Pretreatment, Emergency Response and Collection System Unit has conducted a preliminary review of the
subject permit application package. Additional information is required before we can continue our review,
Please address the attached items no latter than December 6, 2006,
Please be aware that you are responsible for meeting all requirements set forth in North Carolina des and
regulations. Any oversights that occurred in the review of the subject application package are still the
responsibility of the applicant. In addition, any omissions made in responding to the above items may result in
future requests for additional infornation,
Please reference the subject application number when providing the requested information. Two copies of all
revised and/or additional documentation should be signed, sealed, dated, and submitted to the address below,
Please note that failure to provide this additional information on or before the above requested date may result in
your application being returned as incomplete.
If you have any questions regarding this request, please do not hesitate to contact Bennie Goetze., Jr., P. E. at
[phone], extension 375. You may also check the future status of this project online at
http://www.newaterqualit ,or irns/ and following the report links. Thank you for your cooperation.
Sincerely,
Alan W Klimek. P.
cc: Ms. Dee Browder, Mooresville Regional Office,
Mr. Mitch Latham, P. E,,, Latham -Walters Engineering, Inc., 16507-A NoiThctoss Dr., Huntcrsville, NC 28(?7.
Permit Application File WQ0030665
Pretreatment, Emergency Respon
Location: 512 N. Salisbury St,
Internet:
cLt liit�•.crrg
27604
1617 Mail Service Center
Phone [phone]
Fax [phone]
An Equal 0ppertunitytAirmative 50% Recyeledri0% Post Consumer Paper
Raleigh, NC 27699-1617
Customer Service
1-877-623-6748
NottliCaroIina
Naturally
CE1
`l CF

Charlotte -Mecklenburg Utilities
Joy's Serenity Point
Pressure Sewer - Line Work Only
Application Number WQ0030665
Review Comments
November 6, 2006
_ _ _General
I . Based on the A/E's certification in the Permit Application that all 15A NCAC 2H .0200
requirements regarding gravity sewers and force mains, and the Division of Water Quality's
Gravity Sewer Minimum Design Criteria adopted February 12, 1996 have been met, a review of
these items has not been performed. It shall be the permittee's responsibility to ensure the plans
and specifications meet the appropriate design criteria and rules. Final approval of these
documents will not imply approval of any variance from these criteria unless specifically
requested and granted. Failure to comply may result in penalties in accordance with North
Carolina General Statute 143-215.6A— 143-215.6C, construction of additional facilities, and/or
referral of the N.C. Professional Engineer to the licensing board.
•
2. Provide a completed Watershed Classification form.
3. Application, Part V.6 - This indicates a total of 1355 feet of 2-inch line is to be permitted. The
plans show 1378 feet. Please clarify.
Specifications
1. Some specifications appear to beincluded in the submittal package but they are page numbered
as if they were a part of the calculations. They were not attached to the calculations and were not
signed and sealed by the engineer as required.