WQ0030774_Regional Office Historical File Pre 2018

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
September 13, 2006
Mr. James Justice, Town Manager
PO Box 878
Mooresville, NC 28115
Subject: Permit No. WQ0030774
Timber Ridge Expansion Project
Wastewater Collection System Extension
Iredell County, North Carolina
Dear Mr. Justice,
In accordance with your application received on September 5, 2006, we are forwarding herewith
Permit No. WQ0030774 dated September 13, 2006, to the Town of Mooresville for the construction and
operation of the subject wastewater collection system extension. This permit shall be effective from the
date of issuance until rescinded, and shall be subject to the conditions and limitations as specified
therein. This cover letter shall be considered a part of this permit and is therefore incorporated therein
by reference.
Please pay particular attention to Permit Condition 3 which requires that the wastewater
collection facilities be properly operated and maintained in accordance with 15A NCAC 2T .0403 or any
individual system -wide collection system permit issued to the Permittee.
Permitting of this project does not constitute an acceptance of any part of the project that does
not meet 1) 15A NCAC 2T; 2) the Division of Water Quality's (Division) Gravity Sewer Minimum Design
Criteria adopted February 12, 1996, as applicable; 3) and the Division's Minimum Design Criteria for
the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000, as applicable,
unless specifically mentioned herein. Division approval is based on acceptance of the certification
provided by a North Carolina -licensed Professional Engineer in the application. It shall be the
Permittee's responsibility to ensure that the as -constructed project meets the appropriate design criteria
and rules. Failure to comply may result in penalties in accordance with North Carolina General Statute
§143-215.6A through §143-215.6C, construction of additional or replacement wastewater collection
facilities, and/or referral of the North Carolina -licensed Professional Engineer to the licensing board.
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North
Carolina as amended, and other applicable Laws, Rules, and Regulations, permission is hereby
granted to the Town of Mooresville for the construction and operation of approximately 3,267 linear feet
of 8-inch gravity sewer and the discharge of 8,750 gallons per day of collected domestic wastewater
into the Town of Mooresville existing sewerage system, pursuant to the
Mooresville Regional Office 610 East Center Ave., Suite 301 Mooresville, NC 28115 Phone: [phone] Fax: [phone]
Internet: www.ncmwaterquality.org Customer Service: 1-877-623-6748
An Equal Opportunity/Affirmative Action Employer-50% Recycledll0% Post Consumer Paper
NQ Caro ina
)Vatura'//

Mr. Justice
Page 2
September 13, 2006
application received September 5, 2006, and in conformity with 15A NCAC 2T; the Division's Gravity
Sewer Minimum Design Criteria adopted February 12, 1996, as applicable; the Division's Minimum
Design Criteria for the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000,
as applicable; and other supporting data subsequently filed and approved by the Department of
Environment and Natural Resources and considered a part of this permit.
The sewage and wastewater collected by this system shall be treated in the Town of
Mooresville WWTP (Rocky River NPDES No. NC0046728) prior to being discharged into the receiving
stream.
If any parts, requirements, or limitations contained in this permit are unacceptable, you have the
right to request an adjudicatory hearing upon written request within 30 days following receipt of this
permit. This request must be in the form of a written petition, conforming to Chapter 150B of North
Carolina General Statutes, and filed with the Office of Administrative Hearings, 6714 Mail Service
Center, Raleigh, NC 27699-6714. Unless such demands are made, this permit shall be final and
binding.
If you need additional information concerning this matter, please contact Marcia Allocco at (704)
663-1699.
Sincerely,
for Alan W. Klimek, P.E.
cc: Mooresville Regional Office, Surface Water Protection (WWTP Permit No. NC0046728)
Dan Brewer, Chas. H. Sells, Inc.
Surface Water Protection Central Files
Mina Leach, PERCS

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
RALEIGH
WASTEWATER COLLECTION SYSTEM EXTENSION PERMIT
This permit shall be effective from the date of issuance until rescinded and shall be subject to the -
following specified conditions and limitations:
1. This permit shall become voidable unless the wastewater collection facilities are constructed in
accordance with the conditions of this permit; 15A NCAC 2T; the Division of Water Quality's -
(Division) Gravity Sewer Minimum Design Criteria adopted February 12, 1996, as applicable; the
Division's Minimum Design Criteria for the Fast -Track Permitting of Pump Stations and Force
Mains adopted June 1, 2000, as applicable; and other supporting materials unless specifically
mentioned herein.
2. This permit shall be effective only with respect to the nature and volume of wastes described in the
application and other supporting data.
3. The wastewater collection facilities shall be properly maintained and operated at all times. The
Permittee shall maintain compliance with an individual system -wide collection system permit for the
operation and maintenance of these facilities as required by 15A NCAC 2T .0403. If an individual
permit is not required, the following performance criteria shall be met as provided in 15A NCAC 2T
.0403:
a. The sewer system shall be effectively maintained and operated at all times to prevent
discharge to land or surface waters, and any contravention of the groundwater standards in
15A NCAC 2L .0200 or -the surface water standards in 15A NCAC 2B .0200.
b. A map of the sewer system shall be developed and shall be actively maintained.
c. An operation and maintenance plan shall be developed and implemented.
d. Pump stations that are not connected to a telemetry system shall be inspected every day (i.e.
365 days per year). Pump stations that are connected to a telemetry system shall be
inspected at least once per week.
e. High -priority sewer lines shall be inspected at least once per every six-month period of time.
f. A general observation of the entire sewer system shall be conducted at least once per year.
g. Inspection and maintenance records shall be maintained for a period of at least three years.
h. Overflows and bypasses shall be reported to the appropriate Division regional office in
accordance with 15A NCAC 2B .0506(a), and public notice shall be provided as required by
North Carolina General Statute §143-215.1 C.
1

4. This permit shall not be transferable. In the event there is a desire for the wastewater collection
facilities to change ownership, or there is a name change of the Permittee, a formal permit request
shall be submitted to the Division accompanied by documentation from the parties involved, and
other supporting materials as may be appropriate. The approval of this request shall be
considered on its merits and may or may not be approved.
5. Construction of the gravity sewers, pump stations, and force mains shall be scheduled so as not to
interrupt service by the existing utilities nor result in an overflow or bypass discharge of wastewater
to the surface waters of the State.
6. Per 15A NCAC 2T .0116, upon completion of construction and prior to operation of these
permitted facilities, the completed Engineering Certification form attached to this permit shall be
submitted with the required supporting documents to the address provided on the form. A complete
certification is one where the form is fully executed and the supporting documents are provided as
applicable.
7. A copy of the construction record drawings shall be maintained on file by the Permittee for the life
of the wastewater collection facilities.
8. Failure to abide by the conditions and limitations contained in this permit; 15A NCAC 2T; the
Division's Gravity Sewer Design Criteria adopted February 12, 1996 as applicable; the Division's
Minimum Design Criteria for the Fast -Track Permitting of Pump Station and Force Mains adopted
June 1, 2000 as applicable; and other supporting materials may subject the Permittee to an
enforcement action by the Division, in accordance with North Carolina General Statutes §143-
215.6A through §143-215.6C.
9. In the event that the wastewater collection facilities fail to perform satisfactorily, including the
creation of nuisance conditions, the Permittee shall take immediate corrective action, including
those as may be required by this Division, such as the construction of additional or replacement
facilities.
10. The issuance of this permit shall not exempt the Permittee from complying with any and all
statutes, rules, regulations, or ordinances that may be imposed by other government agencies
(local, state and federal) which have jurisdiction, including but not limited to applicable river buffer
rules in 15A NCAC 2B .0200, erosion and sedimentation control requirements in 15A NCAC Ch. 4
and under the Division's General Permit NCG010000, and any requirements pertaining to wetlands
under 15A NCAC 2B .0200 and 15A NCAC 2H .0500.
11. Noncompliance Notification:
The Permittee shall verbally report to a Division of Water Quality employee at the Mooresville
Regional Office, telephone number [phone], as soon as possible, but in no case more than
24 hours or on the next working day, following the occurrence or first knowledge of the occurrence
of either of the following:
a. Any process unit failure, due to known or unknown reasons, that renders the facility incapable
of adequate wastewater transport, such as mechanical or electrical failures of pumps, line
blockage or breakage, etc.; or
b. Any failure of a pumping station or sewer line resulting in a by-pass directly to receiving waters
without treatment of all or any portion of the influent to such station or facility.
2

Voice mail messages or faxed information is permissible, but shall not be considered as the
initial verbal report. Overflows and spills occurring outside normal business hours may also be
reported to the Division of Emergency Management at telephone number [phone] or
[phone]. Persons reporting any of the above occurrences shall file a spill report by
completing Part I of Form CS-SSO (or the most current Division approved form), within five days
following first knowledge of the occurrence. This report shall outline the actions taken or
proposed to ensure that the problem does not recur. Part II of Form CS-SSO (or the most
current Division approved form) can also be completed to show that the SSO was beyond
control.
Permit issued this the 13th day of September, 2006.
NORTH CAROLINA ENVIRONMENTAL MANAGEMENT COMMISSION
for Alan W. Klimek, P Fes, Director
Division of Water Quality
By Authority of the Environmental Management Commission
Permit Number WQ0030774
3

Fast Track Engineering Certification
Permit No. WQ0030774
September 13, 2006
Town of Mooresville
PO Box 878
Mooresville, NC 28115
Complete and submit this form to the permit issuing regional office with the following:
• One copy of the project record drawings (plan & profile views of sewer lines) of the wastewater collection
system extension
• Supporting design calculations (selected pumps, system curve, operating point, available storage if portable
generator(s) or storage greater than longest past three year outage reliability option selected) for any pump
stations permitted as part of this project
• Changes to the project should be clearly identified on the record drawings or in written summary form. Permit
modifications are required for any changes resultinq'in non-compliance with this permit. regulations or
minimum design criteria.
This project shall not be considered complete nor allowed to operate until this Engineer's Certification and all
required supporting documentation have been received by the Division. Therefore, it is highly recommended
that this certification be sent in a manner that provides proof of receipt by the Division.
ENGINEER'S CERTIFICATION
❑ Partial ❑ Final
, as a duly registered Professional Engineer in the State of North Carolina, having been
authorized to observe (❑ periodically, ❑ weekly, ❑ full time) the construction of Timber Ridge Expansion, a Iredell
County project for the Permittee, hereby state that, to the best of my abilities, due care and diligence was used in the
observation of the construction such that the construction was observed to be built within substantial compliance of
this permit; 15A NCAC 2T; the Division of Water Quality's (Division) Gravity Sewer Minimum Design Criteria adopted
February 12, 1996 as applicable; the Division's Minimum Design Criteria for the Fast -Track Permitting of Pump
Stations and Force Mains adopted June 1, 2000 as applicable; and other supporting materials.
North Carolina Professional Engineer's
seal, signature, and date:
SEND THIS FORM & SUPPORTING DOCUMENTATION
WITH REQUIRED ATTACHMENTS TO THE FOLLOWING ADDRESS
MOORESVILLE REGIONAL OFFICE
SURFACE WATER PROTECTION
610 EAST CENTER AVENUE, SUITE 301
MOORESVILLE NC 28115
The Permittee is responsible for tracking all partial certifications up until a final certification is received. Any
wastewater flow made tributary to the wastewater collection system extension prior to completion of this
Engineer's Certification shall be considered a violation of the permit and shall subject the Permittee to appropriate
enforcement actions.

!�CK ATM for GRAVITY S1";Wt!:Rfti, PUMP SFOR('E NUYINS
z
z
USE THE TAB KEY TO MOVE FROM FIELD TO FIELD
1. Owner:
la. Town of Mooresville
Full Legal Name (company, municipality, HO.A, utility, etc,)
1b, Mr. James Justice, Town Manager
Signing Official Name and Title (Please review 15A NCAC 2H .0206(b) for authorized signing officials!)
1 c. The legal entity who will own this system is:
❑ Individual ❑ Federal Z Municipality ❑ State/County ❑ Private Partnership 0 Corporation ❑ Other (specify):
PO Box 878
Street Address
1 f, NC
State
1 h. 704-662-7041 704-662-7039
Telephone .._ Facsimile
2. Project (Facflr°ty) Info r at(on:
Se S tTimber Ridge Expansion 2b. Irede
Application Number:
(to be completed by DWJQ!
Moore
City
lg. 28115
Zip Code
1j,
E-mai
Ile
Brief Project Name (permit wilt refer to this name) County Where Project is Located
Contact Person:
Mr. Dan Brewer, P.E.
Name and Affiliation of Someone Who Can Answer Questions About this Application
3b. 704-662-0100
Phone Number
Project is New Modification (cif an existing permit)
2, Owner is El Public (skip to Item B(3
2a. If private, applicant will be:
3c. dbrewer [e-mail]
E-mail
odificati
Private (go to Item 2(a))
2b. If sold, faties owned by a (must choose on
❑ Retaining Ownership (i,e. store, church, single office, etc.) or ❑ Public( tility (Instruction Ill)
❑ Leasing units (lots, townhomes, etc. - skip to Item B(3)) ❑ Homeowner Assoc./Developer (Insttruetl+ n IV)
❑ Selling units Imo, to iorn s, etc. - go to Item B(2b))
astewater Treatmertt Facili
4a, Rocky River WWTP
Name of WWTF
WTF)'Treatin
0 5a, Town of Mooresvmfle 5b, 12"
Owner of Downs
tream Sewer Receiving Sewer Size
6. The origin of this wastewater is (check all that apply):
astewater From This Project
4b, NC Q046728
WWTF Permit No.
❑ Residential Subdivision ❑ Car Wash
❑ Apartments/Condominiums ❑ Institution
Mobile Horne Park ❑ Hospital
© School ❑ Church
Ei Restaurant ❑ Nursing Home
Office ®' Other (specify): Retail
Permit Number of Down
7. Volume of wastewater to be permitted in this project: 8,750 gallons per day
if known
100 % Domestic/Commercial
0'/© 8ndustrial
is Other (specify):
If the permitted 'flow is zero, indicate why.
❑ Interceptor Line - Flow will be permitted is subsequent permits that connect to this line
❑ Flow has already been allocated in Permit No. _
0 Rehabilitation or replacement of existing sewer with no new flow expected

CK APPLICATION for GRAVITY SEWERS, PUMP STATIONS, AND FORCE MAINS
PAGE 4
'
I
!
p
M
Z
Z
V
Z
Q11.
M
c
0
LL
Z
W
a
CO
.
Lthe
Provide the wastewater flow calculations used
.0219(1) for Item B(7) or the design flow for line
that in 15A NCAC 2H .0219(1)(1-2) must be
Division of Water Quality, Non -Discharge
accordance with 15A NCAC 2H .0219(I)(3).
in determining the
or pump station sizing
approved prior to submittal
Permitting Unit, 1617
= 8,750 gpd
permitted flow in
if zero flow in
of this application.
Mail Service Center,
accordance with 15A NCAC 2H
the space below. Values other than
Submit a separate request to
Raleigh, NC 27699-1617 in
i
I
I
14 lots x 25 employees/lot x 25 gallons/employee/day
10.
Summary of Sewer Lines to be Permitted (attach additional sheets if necessary)
j
Size (inches)
Length (feet)
Gravity or Force Main
(pull down menu)
8
3,267
Gravity
Gravity
Gravity
Gravity
Gravity
Gravity
Gravity
ENTER TOTAL LINE LENGTH IN MILES
0.62
Summary of Pump Stations to be Permitted (attach additional sheets as necessary)
f Location ID Design Flow 1 Operational Point
(as shown on plans) (MGD) GPM @ TDH
Power Reliability Option
(dual line feed, permanent generator w/ATS,
portable generator wltelemetry, wet well storage)
i
I 1
12.
SUBMIT
Does the sewer system comply with the Minimum
Mains (latest version), the Gravity Sewer Minimum
Design Criteria for the Fast Track Permitting of Pump Stations and Force
Design Criteria (latest version) and 15A NCAC 2H .0200 as applicable?
pertinent minimum design criteria or regulation and indicate why a
OR CALCULATIONS PERTINENT TO THE VARIANCE WITH YOUR APPLICATION
►�1 Yes IN No If no, please reference the
variance is requested:
TWO COPIES OF PLANS, SPECIFICATIONS
13.
Have the following permits/certifications been submitted for approval?
Wetland/Stream Crossings - General Permit or 401 Certification?
Sedimentation and Erosion Control Plan?
Stormwater?
• Yes • No 11 NIA
® Yes ❑ No
• N/A
0 N/A
❑ Yes • No
FTA 02/03

CK APPLICATION for GRAVITY SEWERS, PUMP STATIONS, AND FORCE MAINS
PAGE 5
Ir
Z
O
1-t
Q
1. Use the Division's guidance document entitled, "DETERMINING STREAM CLASSIFICATIONS FOR FORM FTA 02103
(FAST -TRACK SEWER SYSTEMS)" to collect and record the stream classification data below (attach additional sheets as
necessary). This document is available from our web site or by contacting the appropriate Division of Water Quality
regional office (see instructions for addresses) OR indicate the following:
100 feet away from any slope
❑ A Stream Classification is not needed because all parts of the project are at leas downlope
waterbody; AND
V
LL.
• A Stream Classification is not needed because the design does not depend on wet well storage as a power reliability
option for any pump station near a Class C down slope waterbody.
U)
Location ID
on Maw
Name of
Waterbody i County
River Basin
Waterbody Stream
Index
Waterbody
Classification
0
A
West Branch Rocky Iredell
River
Yadkin
13-17-3
C
a
111
Ce
co
Submit the 8.5" x 11" topographic map as required in Instruction VI regardless of whether a classification is provided!
1. Applicant's Certification:
1, Mr. James Justice, attest that this application for Sanitary Sewer System to Serve Timber Ridge Industrial Park,
Phase 7 has been reviewed by me and is accurate and complete to the best of my
knowledge. 1 understand that if all required parts of this application are not completed and that if all required supporting
documentation and attachments are not included, this application package is subject to being returned as incomplete.
Note: In accordance with North Carolina General Statutes 143-215.6A and 143-215.6B, any person who knowingly
makes any false statement, representation, or certification in any application shall be guilty of a Class 2 misdemeanor
which may include a fine not to exceed $10,000 ell as civil penalties up to $25,000 per violation.
1a. G 4/0( �r C.
Signing Official Signature Date
Z
0
H
Q
V
LL
H '
Ce
V„j
0
Cl
2. Professional Engine s ertification:
! attest that this a placation for Sanitary Sewer System to Serve Timber Ridge Industrial Park, Phase 7
has been reviewed by me and is accurate, complete and consistent with the information in the engineering plans,
calculations, and all other supporting documentation to the best of my knowledge. I further attest that to the best of my
knowledge the proposed design has been prepared in accordance with the applicable regulations, Gravity Sewer Minimum
Design Criteria for Gravity Sewers adopted February 12, 1996, and the Minimum Design Criteria for the Fast -Track
Permitting of Pump Stations and Force Mains adopted June 1, 2000 and the watershed classification in accordance with
Division guidance. Although certain portions of this submittal package may have been developed by other professionals,
inclusion of these materials under my signature and seal signifies that l have reviewed this material and have judged it to
be consistent with the proposed design. Note: In accordance with NC General Statutes 143-215.6A and 143-215.6B, any
person who knowingly makes any false statement, representation, or certification in any application shall be guilty of a
Class 2 misdemeanor which may include a fine not to exceed $10,000 as well as civil penalties up to $25,000 per violation.
. 0,„ iC.f4tpl II t�,ry,,
2a. Mr_ Dan Brewer ' ��1 CAilt-; ��'%,
���'''
Professional Engineer Namet.
2b. Chas. H Sells, Inc. a : O."- '�e _
r
_ a
Engineering Firm L _
2c 128 Overhill Drive, Suite 105 ; 17582 `^ g
'I
q .�` �
Address a1. 1Q'a4.,FNOI1,1 �`� .�
ff
2d. Mooresville 12e. NC 2f. 28117 '�•,,,, �. gi+y,
City I State [_......_. Zip..- _--- --
704-662-0100 2h. 704-662-0101 2i. [e-mail]
`�.��
��•0/Nisi, t 4''''''`„2g.
Telephone 1 Facsimile E-mail
Seal, Signature & Date _f
FTA 02/03

Permit Number WQ0030774
Central Files: APS SWP
09/12/06
Permit Tracking Slip
Program Category Status Project Type
Non -discharge In review New Project
Permit Type _ Fast Track Version Permit Classification
Gravity Sewer Extension, Pump Stations, & Pressure Sewer A Individual
Extensions
Primary Reviewer Permit Contact Affiliation
marcia.allocco
Permitted Flow
8750
Facility
Facility Name
Timber Ridge Expansion
Location Address
Owner
Major/Minos Region
Minor Mooresville
County
Iredell
Facility Contact Affiliation
Owner Name Owner Type
Town of Mooresville Government - Municipal
Owner Affiliation
James Justice, Manager Town
PO Box 878
Mooresville
Dates/Events
NC 281150878
Orig Issue
App Received
09/05/06
Draft Initiated
Scheduled
Issuance
Public Notice Issue
Effective Expiration
Regulated Activities ReauestedlReceived Events
Commercial or industrial, other Additional information requested
Wastewater collection Additional information received
Outfall NULL
Waterbody Name Stream Index Number Current Class Subbasin

Consul nngin er ,Surveyors& hoto rarer e
wa;
NCDEN'R, Division of. 'Water )u tlit
610 E. Center Ave.
M©oresvi11e, NC' 281 15
SEP P
Reference: Application fortlic Sanitary Sewer Extension
To Serve Timber Ridge Expansion
Mooresville, North Carolina.
Ladies and Gentlemen:
DAN E BREWER. RE.
C j; ,iAtiSEY A
,t
Ao K E3F;4�ci�' �nER, F i. S
On behalf of the. 'Town of Moor%sville, i lease find enclosed one ore copy of the hast-
Track Application 'for Gravity Sewers, Pump Stations, and Force Mains fear the above referenced
project. Also included is a check in the amount of,S400 for the permit processing fee.
In summary, the project con
commercial business park loca
guidelines a flow rate of 8,750 CPI) is es
8-inch diameter sanitary sewer extension to serve a.
Road in Mooresville, NC. Based upon the NC'DENR.
.ated fo.r the project.
If you have any questions or require additional infonmation, please convict us.
Respectfully submitted,.
Chas. H. Sells, Inc.
Donna H.. Barbour, P.E.
Project Engineer II
Cc: Mr, Richard Skrfk Southern C:onstruc
ITC)