WQ0029338_Regional Office Historical File Pre 2018 (2)

Michael F. Easley, Governor
William G. Ross Jr„ Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
September 22, 2005
Mr. Robert Hites, City Manager
City of Statesville
301 South Center Street
Statesville, North Carolina 28687
Subject: Permit No. WQ0029338
Georgetown Place SID
City of Statesville
Wastewater Collection System Extension
Iredell County, North Carolina
Dear Mr. Hites:
In accordance with your application received on September 2, 2005, we are forwarding herewith
Permit No. WQ0029338, dated September 22, 2005, to the City of Statesville for the construction and
operation of the subject wastewater collection system extension. This permit shall be effective from the
date of issuance until rescinded, and shall be subject to the conditions and limitations as specified
therein. This cover letter shall be considered a part of this permit and is therefore incorporated therein
by reference.
Please pay particular attention to Permit Condition 3 which requires that the wastewater
collection facilities be properly operated and maintained in accordance with 15A NCAC 2H .0227 or any
individual system -wide collection system permit issued to the Permittee.
Permitting of this project does not constitute an acceptance of any part of the project that does
not meet 1) 15A NCAC 2H .0200; 2) the Division of Water Quality's (Division) Gravity Sewer Minimum
Design Criteria adopted February 12, 1996, as applicable; 3) and the Division's -Minimum Design
Criteria for the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000, as
applicable, unless specifically mentioned herein. Division approval is based on acceptance of the
certification provided by a North Carolina -licensed Professional Engineer in the application. It shall be
the Permittee's responsibility to ensure that the as -constructed project meets the appropriate design
criteria and rules. Failure to comply may result in penalties in accordance with North Carolina General
Statute §143-215.6A through §143-215.6C, construction of additional or replacement wastewater
collection facilities, and/or referral of the North Carolina -licensed Professional Engineer to the licensing
board.
Mooresville Regional Office 610 East Center Ave., Suite 301 Mooresville, NC 28115 Phone: (704) 663-i 699 Fax: [phone]
Internet h2o.enr.state.nc.us Customer Service: 1-877-623-6748
An Equal Opportunity/Affirmative Action Employer— 50% Recycledl10% Post Consumer Paper
NCarolina
aaturallij

Mr. Hiles
Page 2
September 22, 2005
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North
Carolina as amended, and other applicable Laws, Rules, and Regulations, permission is hereby
granted to the City of Statesville for the construction and operation of approximately 597 linear feet of 8-
inch gravity sewer, as part of the Georgetown Place S/D project; and the discharge of 1,800 gallons per
day of collected domestic wastewater into the City of Statesville's existing sewerage system, pursuant
to the application received September 2, 2005, and in conformity with 15A NCAC 2H .0200; the
Division's Gravity Sewer -Minimum Design Criteria adopted February 12, 1996, as applicable; the
Division's 'Minimum Design Criteria for the .Fast -Track Permitting of Pump Stations and 'Force Mains
adopted June 1, 2000, as applicable; and other supporting data subsequently filed and approvedby. the
Department of Environment and Natural Resourcesand considered a part of this permit.
The sewage and wastewater collected by -this system shall be treated in the City of Statesville -
Fourth Creek WWTP (NPDES No. NC0031836) prior to being discharged into the receiving stream.
If any parts, requirements, or limitations contained in this permit are unacceptable, you have the
right to request an adjudicatory hearing upon written request within 30 days following receipt of this
permit. This request must be in the form of a written petition, conforming to Chapter 150E of North
Carolina General Statutes, and fled with .the Office of Administrative Hearings, 6714 Mail Service
Center, Raleigh,'NC 27699-6714. Unless such demands are made, this permit shall be final and
binding.
if you need additional information concerning this matter, please contact Dee Browder at (704)
663-1699.
Sincerely,
/J,?
for Alan W. Klimek, P.E.
cc: Iredell County Health Department
Mooresville Regional Office, Surface Water. Protection (WWTP Permit No. NC0031836)
Carroll Williams, 'PE
Surface Water Protection Central Files
'Marie Doklovic, PERCS

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT AND NATURAL'RESOURCES
RALEIGH
WASTEWATER COLLECTION SYSTEM EXTENSION PERMIT
This permit shall be effective from the date of issuance until rescinded and'shall be subject to the
following specified conditions and limitations:
1. This permit shall become voidable unless the wastewater collection facilities are constructed in
accordance with the conditions of this permit; 15A NCAC 2H .0200; the Division of Water,Quality's
(Division) Gravity Sewer Minimum Design Criteria adopted February -12, 1996, as applicable; the
Division's Minimum Design Criteria for the Fast -Track Permitting of Pump Stations and Force
Mains adopted June 1, .2000, as applicable; and other supporting materials unless specifically
mentioned herein.
2. This .permit shall be effective only with respect to the nature and volume of wastes described in the
application and othersupporting data.
3. The wastewater collection facilities shall be properly maintained and operated at all times. The
Permittee shall maintain compliance with an individual system -wide collection system permit for the
operation and maintenance of these facilities as required by 15A NCAC 2H .0227. If an individual
;permit is not required, the following performance criteria shall be met as provided in 15A NCAC 2H
.0227:
a. The sewer system shall be effectively maintained and operated at all times to prevent
discharge to land .or surface waters, and any contravention of the groundwater standards in
15A NCAC 2L .0200 or the surface water standards in 15A NCAC 2B .0200.
b. A map of the sewer system shall be developed and shall be actively maintained.
c. An operation and maintenance plan shall be developed and implemented.
d. Pump stations that are not connected to a telemetry system shall be inspected every day (i.e.
365 days per year). Pump stations that are connected to a telemetry system shall be
inspected at least once per week.
e. High -priority sewer lines shall be inspected at least once per every six-month period of time.
f. A general observation of the entire sewer system shall be conducted at least once per year.
g. Inspection and maintenance records shall be maintained for.a period of at least three years.
h. Overflows and bypasses shall be reported to the appropriate Division regional office in
accordance with 15A NCAC 2B .0506(a), and public notice shall be provided as required by
North Carolina General Statute §143-215.1 C.
1

4. This permit shall not be transferable. In the event there is a desire for the wastewater collection
facilities to change ownership, or there is a name change of the Permittee, a formal permit request
shall be submitted to the Division accompanied by documentation from the parties involved, and
other supporting materials as may be appropriate. The approval of this request shall be
considered on its merits and mayor may not be approved.
5. Construction of the gravity sewers, pump stations, and force mains shall be scheduled so as not to
interrupt service by the existing utilities nor result in an overflow or bypass discharge of wastewater
to the surface waters of the State.
6. Per 15A NCAC 2H .0220, upon completion of construction and prior to operation of these
permitted facilities, the completed Engineering Certification form attached to this permit shall _be
submitted with the required supporting documents to the address, provided on the form. A complete
certification is one where the form is fully executed .and the supporting documents are provided as
applicable.
7. A copy of the construction record drawings shall be maintained on file by the Permittee for the life
of the wastewater collection facilities.
8. Failure to abide by the conditions and limitations contained in this permit; 15A NCAC 2H .0200; the
Division's Gravity Sewer Design Criteria adopted February 12, 1996 as applicable; the Division's
Minimum .Design Criteria for the Fast -Track Permitting of Pump Station and Force Mains adopted
June 1, 2000 as applicable; and other supporting materials may subject the Permittee to an
enforcement action by the Division, in accordance with North Carolina General Statutes §143-
215.6Athrough §143-215.6C.
9. In the event that the wastewater collection facilities fail to perform satisfactorily, including the
creation 'of nuisance conditions, the Permittee shall take immediate corrective action, including
those as may be required .by this 'Division, such as the construction of additional or replacement
-facilities.
10. The issuance of this permit shall not exempt the Permittee from complying with any and all
statutes, rules, regulations, or ordinances that may be imposed by other government agencies
(local, state and federal) which have jurisdiction, including but not limited to applicable river buffer
rules in 15A NCAC 2B .0200, erosion and sedimentation control requirements in 15A NCAC Ch. 4
and under the Division's General Permit NCG010000, and any requirements pertaining to wetlands
under 15A NCAC 2B .0200 and 15A NCAC 2H .0500.
11. Noncompliance Notification:
The Permittee shall verbally report to a Division of Water Quality employee at the Mooresville
Regional Office, telephone number [phone], as soon as possible, but in no case more than
24 hours or on the next working day, following the occurrence or first knowledge of the occurrence
-of either of the following:
a. Any process unit failure, due to known or unknown reasons, that renders the facility incapable
of adequate wastewater transport, such as mechanical or electrical failures of pumps, line
blockage or breakage, etc.; or
b. Any failure of a pumping station or sewer line resulting in a by-pass directly to receiving waters
without treatment of all or any portion of the influent to such station or facility.
2

Voice mail messages or faxed information is .permissible, but shall not be considered as the
initial verbal report. Overflows and spills occurring outside normal business hours may also be
reported to the Division of Emergency Management at telephone number [phone] or
[phone]. Persons reporting any of the above occurrences shall file a spill report by
completing Part I of Form CS-SSO (or the most current Division approved form), within five days
following first knowledge of the occurrence. This report shall outline the actions taken or
proposed to ensure that the problem does not recur. Part 11 of Form CS-SSO (or the most
current Division approved form) can also be completed to show that the SSO was beyond
control.
Permitissued this the.22nd day of September, 2005.
'NORTH CAROLINA ENVIRONMENTAL" MANAGEMENT COMMISSION
D, / %Ce
for Alan W. Klimek, .E., Director
Division of Water Quality
By Authority of the Environmental Management Commission
Permit Number WQ0029338
3

Fast Track Engineering Certification
Permit -No. WQ0029338
September 22, 2005
Complete and submitthis form to the permit issuing regional office with the following:
• One copy of the project record drawings (plan & profile views of sewer lines) of the wastewater collection
system extension
• Supporting design calculations (selected. pumps, system curve, operating point, available storage if portable
generator(s) or storage greaterthan longest past three year outage:reliability option selected) for any pump
stations permitted as part of this project
• ,Changes to the project should .be .clearly identified on the -record drawings or in written summary form. Permit
modifications are required for any changes resulting in non-compliance with this permit, regulations or
minimum design criteria.
Thisproject shall not be considered complete nor allowed to operate until this Engineer's Certification and all
required supporting documentation have been received by the.Division. Therefore, it is highly recommended
thatthis certification be'sent in a.manner that.provides,proof of receipt by the Division.
ENG1NEER'S•CERTIFICATION
❑ Partial ❑.Final
,'as a duly registered Professional Engineer in the State of North Carolina, having
been authorized to observe (❑.periodically, .❑ weekly, ['full time) the construction of the Georgetown Place
S/D, Iredell County project for the Permittee hereby state that, to the best of my abilities, due care and diligence
was used.in the:observation of .the.construction such that the construction was observed to be built within
-substantial compliance of this permit; 15A`NCAC2H .0200; the Division of Water. Quality's (Division) Gravity
Sewer'Minimum:Design Criteria adopted -February 12,'1996 as applicable; -the Division's Minimum Design Criteria
for the Fast -Track Permitting ofPump Stations and Force Mains adopted June '[, 2000 as applicable; and other
supporting materials.
North Carolina Professional Engineer's
seal, signature, and date:
SEND THIS FORM:8, SUPPORTING DOCUMENTATION
WITH REQUIRED ATTACHMENTS TO THE FOLLOWING ADDRESS
MOORESVILLE REGIONAL OFFICE
SURFACE WATER PROTECTION
610 EAST CENTER AVENUE, SUITE 301
-MOORESVILLE NC 28115
The Permittee is responsible for tracking all partial certifications up until a final certification is -received. Any
wastewater flow made tributary to the wastewater collection system extension prior to completion of this
Engineer's Certification shall be considered a violation of the permit and shall subject the Permittee to appropriate
enforcement actions.

6-2005 08:36 FROM:R CARROLL WILLIAMS P 828132716792
AST -TRACK APPLICATION for
0
bd.
2a,
TO 17048763727 P.1
P� S 'ATIONS, AND FORCE MAINS
USE THE TAB KEY TO MOVE FROM FIELD TO FIELDI E Application Number:
ado be �t®wtsd ter �
Full Leai Name (ampany, rrtipatit: t itA, �y
et Address
TAY65‘./r awr
h tzed signrn otfk a
City
Zip Code
A
E-mail
2b. t rLw
Brief Project Name t;perrnit wW refer to this name)
Contact Person:
e4Rgo// frtiiifiti4,115
Narne and Affiliation of Someone Vkl'ho Can Ans
t. X. 70yt s°7 F 3 5
Phone Number
County Where Project is Located
ieef7
About this Application
e
E-mail
1, Project is 'New
For modifications, attac
phase, changing finer sizeAength, etc.
duplicate project information in B(7)
2.
If Modification, Permit No.:
BOA 0 Private (go
mason for the modification (Le. adding.
nforrnsoon in this permit application -
reen included in the original permit.
2(a))
2a, If private, applicant will be:
0 Retaining Ownership (Le. store, church, single of ice e
Z 0 Leasing units (ids, townhomes, etc. - skip to Item
0 © Selling units (lots, townhomes, etc. - go to Item B(2b))
0
Residenlial Subdivision
Atrrts1Condornin iums
Park
© Car Wash
0 Institution
0 Hospital
Church
Nursing Home
0 Other (specify):
ifell, facilities owned by a (must choose one)
© Publit tJtitity (lnstnrctlon tit)
❑ Homeowner Assoc./Developer (tnsfrucction IV)
% Other (specify):
7. Volurno of wastewater to Q
roject:
04.0 gal
r day
B. If the permitted flow Is zero, indicate why; till*.
Q Interceptor LOU) - Flow vriii be permitted is subsequent pernits that connect to this line
[ Ftow has already been allocated in Permit No.
El Rehabilitation of replacement of existing sewer with no new flow expected

Sedimentation and Erosion Control Plan?
Stormwater?
ATi(ON I'h r GRA"
P1 F STA II"I INS, AND FORCE PAGE 4
Provide the wastewater flow calculations used in determining the permitted flow in accordance with 15A NCAC 2H
.0219(t) for Item B(7) or the design flow for line or pump station sizing if zero flow in the space below ti Values other than
that in 15A NCAC 2H .02190X1-2) must be supported with actual water or wastewater use data in accordance with t5A
NCAC 2H .0219(1)(3)•
5" L..ph (1-fou.1u5) @ 3 /3e -riPe".5 eac.& /Aa GPO La Y.
IS' Do GPO
10. Summary of Sewer Lines to be Permitted (attach additional sheets if necessary)
Size (inches)
Length (feet)
ENTER TOTAL LINE LENGTH IN MILES p t 1
0
Summary of Pump Stations to be Permitted (attach additional sheets as necessary
Location ID
(self chosen - as shown on
plans for cross-reference)
i4 A
MGD) GPM TDH
Gravity or Fo
(use the pull down menu)
RA`I r '1(
Power Reliability Option
ign. Flow Operational Point (1- dual line feed; 2- permanent generator w!ATS; 3-
portable generator 'iv/telemetry, 4-wet well storage)
12. Does the sewer system comply with the Minimum Design Criteria forthe Fast Track Permitting of Pump Stations and Force
M °• s (latest version), the Gravity Sewer Minimum Design Criteria (latest version) and 15A NCAC 2H .(200 as applicable?
Yes Q No If no, please reference the pertinent minimum design criteria or regulation and Indicate why a
variance is requested. SUBMIT TWO COPIES OF PLANS, SPECIFICATIONS OR CALCULATIONS
PERTINENT TO THE VARIANCE WITH YOUR APPLICATION
Have the following
been submitted for appro
etland/Stream Crossings - General Permit or 401 Certification? 0 Yes p No l 'NLA
'Yes Q No 0 NIA
©Yes 0No 9- A
14. Does this project involve aerial lines or siphons? Check if yes: 0 kJ/A
These Ines wit be considered hiah sonority and must be checked once every six months
15. Does this project have gravity sewer lines designed at minimum slopes? J
Be aware that the Division will not accept installed lines more than 10`1t, (tatter than the
corrected prior to submitting the final engineering certiCacation..
pe. Lines installed outside this tolerance should be

CA'f ON for GRAB Y SE PS `AT IONS, ANi FORCE MAINS
PAGE 5
Use the Division's guidance document entitled, "DETERMINING STREAM CLASSIFICATIONS FOR FORM FTA 02103
(FAST -TRACK SEWER SYSTEMS)" to collect and record the stream classification data below (attach additional sheets as
necessary). This document is available from our web site or by contacting the appropriate Division of Water Quality
idnal office (see instructions for addresses) OR indicate the following:
A Stream Classification is not needed because all parts of the project are at least 100 feet away from any down slope
w terbody; AND,,
Stream Classification is not needed because the design does not depend on wet well storage as a power reliability
option for any pump station near a Class C down slope waterbody.
Location ID on Map
(self chosen - as shown on Name of Waterbody Stream Waterbody
map for cross-reference) Waterbody County River Basin Index Classification }.
Submit the 8.5" x 11" COLOR topographic map as required in Instruction VI
regardless of whether a classification is provided[
Applicant"s Certification:
1, SIGNING OFFICIAL NAME, attest that this application for PROJECT NAME
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required
parts of this application are not completed and that if all required supporting documentation and attachments are not
included, this appficafion package is subject to being returned as incomplete. Note: In accordance with North Carolina
General Statutes 143-215.6A and 143-215.68, any person who knowingly makes any false statement, representation, or[
certification in any application shall be guilty of a Class 2 misdemeanor which may include a fine not to exceed $10,00
as well as civil penalties up to $25, 000 per violation.
1;
Signing Official Signature
2. Professional Engineer's Certification:
05
Date
I attest that this application for has been reviewed by me and is accurate, co
and consistent with the information in the engineering plans, calculations, and all other supporting documentation to the
best of my knowledge, I further attest that to the best of my knowledge the proposed design has been prepared in
accordance with the applicable regulations, Gravity Sewer Minimum Design Criteria for Gravity Sewers adopted February
12, 1996, and the Minimum Design Criteria for the Fast -Track Permitting of Pump Stations and Farce Mains adopted June
1, 2000 and the watershed classification in accordance with Division guidance. Although certain portions of this submittal
package may have been developed by other professionals, inclusion of these materials under my signature end seal
signifies that I have reviewed this material and have judged it to be consistent with the proposed design. Note: In
accordance with NC General Statutes 143-215.6A and 143-215.68, any person who knowingly makes any false statement,
representation, or certification in any application shall be guilty of a Class 2 misdemeanor which may include a fine not to
exceed $10 000 as well as civil penalties up to $25, 000 per violation.
2a. .. �F�!"�t�csc,i� IA) er.,L. tick wt 5
Professional Engineer Name
2b. . Q, A :t,o i-11,-
Engineering Firm
2c.
Mailing Address
2d. i c.t4- ► {�
City
P�-
2e.
State
2g. l { 3.-i-46q 2h, 2i. r�,
Telephone Facsimile
E-mail
SEAL
3202
Seal, Signature Date

T,

0 0.3 0.6 0.9 1.2
0 0.2 0.4 0.6 0.8 1 mi
Map center is UTM 17 511542E 3964183N (WGS84/NAD83)
Statesville East quadrangle
Projection is UTM Zone 17 NAD83 Datum
M=
75
lat
http://wvvw.topozone.com/printasp?z=17&n=3964183.00009561&e=511542&s=50&size=m&layer=... 6/13/2005

Permit Number WQ0029338
Central Files: APS_ SWP_
09/22/05
Permit Tracking Slip
Program Category
Non -discharge
Status Project Type
In review New Project
Permit Type Version
Gravity Sewer Extension, Pump Stations, & Pressure Sewer A
Extensions
Primary Reviewer
dee.browder
Permitted Flow
5040
Farility
Facility Name
Georgetown Place S/D
Location Address
Owner
Permit Classification
Individual
Permit Contact Affiliation
Major/Minor Region
Minor Mooresville
County
Iredell
Facility Contact Affiliation
Owner Name Owner Type
City of Statesville Government - Municipal
Dates/F.10,Di
Scheduled
Orig Issue App Received Draft Initiated Issuance
09/02/05
Owner Affiliation
Robert Hites, Jr
PO Sox 1111
Statesville NC 28687
Public Notice Issue
Effective Expiration
Regulated Activities $Qauested/Received Fvents
Subdivision Additional information requested
Wastewater collection Additional information received
0utfall NULL
Waterbody Name Stream Index Number Current Class Subbasin

. Fast Track Engineering Certification
0 Partial
Permit No. WQ0029338
September 22, 2005
Complete and submit this form to the permit issuing regional office with the following:
• One copy of the project record drawings (plan & profile views of sewer lines) of the wastewater collection
system extension
• Supporting design calculations (selected pumps, system curve, operating point, available storage if portable
generator(s) or storage greater than longest past three year outage reliability option selected) for any pump
stations permitted as part of this project
• Changes to the project should be clearly identified on the record drawings or in written summary form. Permit
modifications are required for any changes resulting in non-compliance with this permit, regulations or
minimum design criteria.
This project shall not be considered complete nor allowed to operate until this Engineer's Certification and all
required supporting documentation have been received by the Division. Therefore, it is highly recommended
that this certification be sent in a manner that provides proof of receipt by the Division.
ENGINEER'S CERTIFICATION
[r.] rnal
1, , as a duly registered Professional Engineer in the State of North Carolina, having
been authorized to observe (Periodically, ❑ weekly, D full time) the construction of the Georgetown Place
Sfl], Iredell County project for the Pemiittee hereby state that, to the best of my abilities, due care and diligence
was used in Ile observation of the construction such that the construction was observed to be built within •
substantial compliance of this permit; 15A NCAC 2H .0200; the Division of Water Quality's (Division) Gravity
Sewer Minimum Design Criteria adopted February 12,1996 as applicable; the Division's Minimum Design Criteria
for the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000 as applicable; and other
supporting materials.
North Carolina Professional Engineer's
seal, signature, and date:
SEND THIS FORM & SUPPORTING DOCUMENTATION
WITHREQUIREITA TACHMENTS TO Tl-tEFOLLOWING-ADDRESS
MOORESVILLE REGIONAL OFFICE
SURFACE WATER PROTECTION
610 EAST CENTER AVENUE, SUITE 301
MOORESVILLE NC 26115
The Permittee is responsible for tracking all partial certifications up until a final certification is received. Any
wastewater flow made tributary to the wastewater collection system extension prior to completion of this
Engineer's Certification shall be considered a violation of the permit and shall subject the Permittee to appropriate
enforcement actions.