WQ0022208_Regional Office Historical File Pre 2018 (2)

Michael F. E
NC DEPT
North Carolina DepartmenRitaiir
RESVIL tri; CZR!,k
AlanAk k,P E, Director
Division of Water Quality
y, Governor
Secretary
esources
Joel Mashburn, County Manager
lredell County
Post Office Box 788
Statesville, NC 28687
Dear Mr. Mashburn:
February 3, 2003
116 I 1 2005
AT W
Subject: Permit No. WQ0022208
lredell County
Millard Refrigerated Services, Inc.
Wastewater Collection System Extension
lredell County
In accordance with your application received December 20, 2003, and additional information
received January 6, 2003, we are forwarding herewith Permit No. W00022208, dated February 3,
2003, to lredell County for the construction and operation of the subject wastewater collection system
extension. This permit shall be effective from the date of issuance until rescinded and shall be subject
to the conditions and limitations as specified therein. This cover letter shall be considered a part of this
permit and is therefore incorporated therein by reference.
Please pay particular attention to Permit Condition 3 which requires that the wastewater
collection facilities be properly operated and maintained in accordance with 15A NCAC 2H .0227 or any
individual system -wide collection system permit issued to the Permittee.
Permitting of this project does not constitute an acceptance of any part of the project that does
not meet 15A NCAC 2H .0200; the Division of Water Quality's (Division) Gravity Sewer Minimum
Design Criteria adopted February 12, 1996 as applicable; and the Division's Minimum Design Criteria
for the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000 as applicable,
unless specifically mentioned herein, Division approval is based on acceptance of the certification
provided by a North Carolina -licensed Professional Engineer in the application. It shall be the
Permittee's responsibility to ensure that the as -constructed project meets the appropriate design criteria
and rules. Failure to comply may result in penalties in accordance with North Carolina General Statute
§143-215.6A through §143-215.6C, construction of additional or replacement wastewater collection
facilities, andlor referral of the North Carolina -licensed Professional Engineer to the licensing board.
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North
Carolina as amended, and other applicable Laws, Rules, and Regulations, permission is hereby
granted to Iredell County for the construction and operation of approximately 7,600 linear feet of 4-inch
force main to serve 25 employees as part of the Millard Refrigerated Services, Inc. project, and the
discharge of 625 gallons per day of collected domestic wastewater into the City of Statesville's existing
sewerage system, pursuant to the application received December 20, 2003 and in conformity with 15A
NCAC 2H .0200; the Division's Gravity Sewer Minimum Design Criteria adopted February 12, 1996 as
applicable; the Division's Minimum Design Criteria for the Fast -Track Permitting of Pump Stations and
Non -Discharge Permitting Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
DENR Customer Service Center
An Equal Opportunity Action Employer
Internet http://h2o,enr.state.nc.usMdpu
Telephone [phone] Fax [phone]
Telephone [phone]
50% recycled/10% post -consumer paper

Force Mains adopted June 1, 2000 as applicable; and other supporting data subsequently filed and
approved by the Department of Environment and Natural Resources and considered a part of thii
permit.
The sewage and wastewater collected by this system shall be treated in the City of Statesville
Wastewater Treatment Facility (Permit No. NC0031836) prior to being discharged into the receiving
stream.
This permit shall become voidable unless the agreement between Iredell County and City of
Statesville for the collection and final treatment of wastewater is in full force and effect.
If any parts, requirements, or limitations contained in this permit are unacceptable, you have the
right to request an adjudicatory hearing upon written request within 30 days following receipt of this
permit. This request must be in the form of a written petition, conforming to Chapter 150E of North
Carolina General Statutes, and filed with the Office of Administrative Hearings, 6714 Mail Service
Center, Raleigh, NC 27699-6714. Unless such demands are made, this permit shall be final and
binding.
If you need additional information concerning this matter, please contact Kristin E. Miguez at
733-5083 extension 524.
Sincerely,
cc: Iredell County Health Department
Mooresville Regional Office, Water Quality Section (WWTF Permit No. NC0031836)
West Consultants, PLLC
City of Statesville (PO Box 1111, Statesville, NC 28687)
Central Files
NPDU Files

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
RALEIGH
WASTEWATER COLLECTION SYSTEM EXTENSION PERMIT
This permit shall be effective from the date of issuance until rescinded and shall be subject to the
following specified conditions and limitations:
This permit shall become voidable unless the wastewater collection facilities are constructed in
accordance with the conditions of this permit; 15A NCAC 2H .0200; the Division of Water Quality's
(Division) Gravity Sewer Minimum Design Criteria adopted February 12, 1996 as appiicable; the
Division's Minimum Design Criteria for the Fast -Track Permitting of Pump Stations and Force
Mains adopted June 1, 2000 as applicable; and other supporting materials unless specifically
mentioned herein.
2. This permit shall be effective only with respect to the nature and volume of wastes described in the
application and other supporting data.
3. The wastewater collection facilities shall be properly maintained and operated at all times. The
Permittee shall maintain compliance with an individual system -wide collection system permit for the
operation and maintenance of these facilities as required by 15A NCAC 2H .0227. If an individual
permit is not required, the following performance criteria shall be met as provided in 15A NCAC 2H
.0227:
a. The sewer system shall be effectively maintained and operated at all times to prevent
discharge to land or surface waters, and any contravention of the groundwater standards in
15A NCAC 2L .0200 or the surface water standards in 15A NCAC 2B .0200.
b. A map of the sewer system shall be developed prior to January 1, 2004 and shall be actively
maintained.
c. An operation and maintenance plan shall be developed and implemented.
d. Pump stations that are not connected to a telemetry system shall be inspected every day (i.e.
365 days per year). Pump stations that are connected to a telemetry system shall be
inspected at least once per week.
e. High -priority sewer lines shall be inspected at least once per every six-month period of time.
f. A general observation of the entire sewer system shall be conducted at least once per year.
g. Inspection and maintenance records shall be maintained for a period of at least three years.
h. Overflows and bypasses shall be reported to the appropriate Division regional office in
accordance with 15A NCAC 28 .0506(a), and public notice shall be provided as required by
North Carolina General Statute §143-215.1C.

4.
This permit shall not be transferable. In the event there is a desire for the wastewater collectio9
facilities to change ownership, or there is a name change of the Permittee, a formal permit request
shall be submitted to the Division accompanied by documentation from the parties involved, and
other supporting materials as may be appropriate. The approval of this request shall be
considered on its merits and may or may not be approved.
. Construction of the gravity sewers, pump stations, and force mains shall be scheduled so as not to
interrupt service by the existing utilities nor result in an overflow or bypass discharge of wastewater
to the surface waters of the State,
6. Upon completion of construction and prior to operation of these permitted facilities, a certification, a
copy of the construction record drawings, as well as supporting design calculations for any pump
stations permitted as part of this project shall be received from a North Carolina -licensed
Professional Engineer certifying that the facilities have been installed in accordance with this
permit; 15A NCAC 2H .0200; the Division's Gravity Sewer Design Criteria adopted February 12,
1996 as applicable; the Division's Minimum Design Criteria for the Fast -Track Permitting of Pump
Station and Force Main adopted June 1, 2000 as applicable; and other supporting materials. If this
project is to be completed in phases and partially certified, you shall retain the responsibility to
track further construction approved under the same permit, and shall provide a final certificate of
completion once the entire project has been completed. A copy of the construction record
drawings, indicating the facilities constructed in the phase being certified, shall be submitted with
each partial certification. Mail the Engineer's Certification, one copy of the "Construction Record
Drawings", and one copy of the supporting design calculations to the Non -Discharge Permitting
Unit, 1617 Mail Service Center, Raleigh, NC 27699-1617.
7, A copy of the construction record drawings shall be maintained on file by the Permittee for the life
of the wastewater collection facilities.
Failure to abide by the conditions and limitations contained in this permit; 15A NCAC 2H .0200; the
Division's Gravity Sewer Design Criteria adopted February 12, 1996 as applicable; the Division's
Minimum Design Criteria for the Fast -Track Permitting of Pump Station and Force Mains adopted
June 1, 2000 as applicable; and other supporting materials may subject the Permittee to an
enforcement action by the Division, in accordance with North Carolina General Statutes §143-
215.6A through §143-215.6C.
9. In the event that the wastewater collection facilities fail to perform satisfactorily, including the
creation of nuisance conditions, the Permittee shall take immediate corrective action, including
those as may be required by this Division, such as the construction of additional or replacement
facilities.
10. The issuance of this permit shall not exempt the Permittee from complying with any and all
statutes, rules, regulations, or ordinances that may be imposed by other government agencies
(local, state and federal) which have jurisdiction, including but not iimited to applicable river buffer
rules in 15A NCAC 2B .0200, erosion and sedimentation control requirements in 15A NCAC Ch, 4
and under the Division's General Permit NCG010000, and any requirements pertaining to wetlands
under 15A NCAC 2B .0200 and 15A NCAC 2H .0500.
11. Noncompliance Notification:
The Permittee shall report by telephone to the Mooresville Regional Office, telephone number
[phone], as soon as possible, but in no case more than 24 hours or on the next working
day, following the occurrence or first knowledge of the occurrence of either of the following:
a. Any process unit failure, due to known or unknown reasons, that renders the facility incapable
of adequate wastewater transport, such as mechanical or electrical failures of pumps, line
blockage or breakage, etc.; or

Any failure o a pumping station► or sewer lino resulting in a bypass directly t
Without treatment of all or nr portion of the influent to such station or facility.
Persons reporting such occurrences by telephone shall also,file awritten report in letter to rithin
ive days following first knowledge of the occurrence. This report must outline the actions taken or
proposed to be taken to ensure that the problem does not recur,
P rrni
Per
sued this the third day of February, 2003
NORTH CAROLINA ENVIRONMENTAL MANAGE ENT COSSION
for Alan W. lli + ; k, P. Director
Division of Water Quality
By Authority of the EnvironmentalManagement ComCommission
Number

Permit No. WQ0022208
February 3, 2003
ENGINEER'S CERTIFICATION
Partial
Final
, as a duly registered Professional Engineer in the State of North
Carolina, having been authorized to observe (periodically, weekly, full time) the construction of the
project, for the
Project Name Location and County
Permittee hereby state that, to the best of my abilities, due care and diligence was used in the
observation of the construction such that the construction was observed to be built within substantial
compliance of this permit; 15A NCAC 2H .0200; the Division of Water Quality's (Division) Gravity Sewer
Minimum Design Criteria adopted February 12, 1996 as applicable; the Division's Minimum Design
Criteria for the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000 as
applicable; and other supporting materials.
North Carolina Professional Engineer's seal, signature, and date:
The above Engineer's Certification shall be completed and submitted to the address below with one
copy of the "Construction Record Drawings" of the wastewater collection system extension as well as
supporting design calculations for any pump stations permitted as part of this project. This project shall
not be considered complete nor allowed to operate until this Engineer's Certification and all required
supporting documentation have been received by the Division. Any wastewater flow made tributary to
the wastewater collection system extension prior to completion of this Engineer's Certification shall be
considered a violation of the permit and shall subject the Permittee to appropriate enforcement actions.
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
1617 MAIL SERVICE CENTER
RALEIGH, NORTH CAROLINA 27699-1617
4

North Carolina Depar
December 1, 2004
Joel Mashburn
lredell County
PC Box 788
Statesville NC 28687
SUBJECT: Millard Refrigeration
Permit No. WQ0022208
Wastewater Collection System Extension
Final Engineering Certification
Dear Permittee:
n
Michael F. Easley, Governor
WitVxa G. Ross Jr,, Secretary
Environment and Natural Resources
Alan W. Klimek, P.E„ Director
Division of Water Quality
The Division received a final engineering certification for the subject project on September 29,
2003. Enclosed is a copy of the certification page for your records. Please be reminded that the
Permittee is responsible for keeping a copy of the final record drawings for the life of the project. If
you have not received such copy from your consultant, please contact them immediately to
obtain a copy.
Lastly, you are receiving this letter because the Division has you listed as the responsible party. If this
permitted system is no longer owned by you, please complete Form PNOCF-S as this permit is not
automatically transferable. Form PNOCF-S can be downloaded from
httr : h2o.enr.state.nc.us/ndpu/ndpuapps.html#Sewer,
if you have any questions concerning this document or the completion of Form PNOCF-S
necessary), please contact me at the letterhead address or via E-mail at
[e-mail].
Sincerely,
at- Man
K. Marie Doklovic, PE
Environmental Engineer
Enclosure
Cc:
tvlocresville Regional office, Surface Water Protection Section (all documents)
Benjamin Thomas PE, West Consultants PLLC (no enclosures,)
Surface Water Protection Section Central Files (w/o plan sheets)
One
NNorthCaroiina
atulafly
Pretreatment, Emergency Response and Collection Systems Unit Internet httpl/h2o.enr.nc.state.us/ndpu
1617 Mail Service Center, Raleigh, NC 27699-1617 An Equal Opportunity Action Employer
Telephone [phone] Fax [phone]% recycled/10% post -consumer paper

Permit No. WQ0022208
February 3, 2003
ENGINEER'S CERTIFICATION
Partial
Final
as a duly registered Professional Engineer in the State of North
Carolina, having been authorized to observe (periodically, weekly, full time) the construction of the
�i rid for the
ocati©n and County
project, I recta( It'Lr `3Seaver
Project Ala
Permittee hereby state that, to the best of my abilities, due care and diligence was used in the
observation of the construction such that the construction was observed to be built within substantial
compliance of this permit; 15A NCAC 2H .0200; the Division of Water Quality's (Division) Gravity Sewer
Minimum Design Criteria adopted February 12, 1996 as applicable; the Division's Minimum Design
Criteria for the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000 as
applicable; and other supporting materials.
North Carolina Professional Engineer's seal, signature, a e:
The above Engineer's Certification shall be completed and submitted to the address below with one
copy of the "Construction Record Drawings" of the wastewater collection system extension as well as
supporting design calculations for any pump stations permitted as part of this project. This project shall
not be considered complete nor allowed to operate until this Engineer's Certification and all required
supporting documentation have been received by the Division. Any wastewater flow made tributary to
the wastewater collection system extension prior to completion of this Engineer's Certification shall be
considered a violation of the permit and shall subject the Permittee to appropriate enforcement actions.
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
1617 MAIL SERVICE CENTER
RALEIGH, NORTH CAROLINA 27699-1617
4