NC0050792_Renewal (Application)_20210427

Yd i n STATE
t~ s, _
ROY COOPER "
Governor _ 4Q
DIONNE DELLI GATTI out„.;.
Secretary
S.DANIEL SMITH NORTH CAROLINA
Director Environmental Quality
April 27, 2021
Aqua North Carolina, Inc.
Amanda Berger, Environmental Compliance Dir.
202 Mackanan Ct
Cary, NC 27511-6447
Subject: Permit Renewal
Application No. NC0050792
Melbille Heights WWTP
Randolph County
Dear Applicant:
The Water Quality Permitting Section acknowledges the April 27, 2021 receipt of your permit renewal application and
supporting documentation. Your application will be assigned to a permit writer within the Section's NPDES WW permitting
branch. Per G.S. 150E-3 your current permit does not expire until permit decision on the application is made.
Continuation of the current permit is contingent on timely and sufficient application for renewal of the current permit.The
permit writer will contact you if additional information is required to complete your permit renewal. Please respond in a
timely manner to requests for additional information necessary to allow a complete review of the application and renewal
of the permit.
Information regarding the status of your renewal application can be found online using the Department of Environmental
Quality's Environmental Application Tracker at:
https://deq.nc.gov/permits-regulations/permit-guidance/environmental-application-tracker
If you have any additional questions about the permit, please contact the primary reviewer of the application using the
links available within the Application Tracker.
Sincerely,
Wren T -dford
Administrative Assistant
Water Quality Permitting Section
ec: WQPS Laserfiche File w/application
E Q?). Nh Calina partmt E Quay I i Water Resources
Winston-Salemort ro De Regional eon ficeof 1450nvironmental West Hanes Milllit RoadDvision Suiteof 300(Winston-Salem,North Carolina 27105
* D 336.776.9800

M
April 28, 2021
NCDENR / Division of Water Quality/ NPDES Unit
1617 Mail Service Center
Raleigh, NC 27699-0167
Re: Application for Permit Renewal
Aqua North Carolina, Inc.
MelbiRe Heights Subdivision WWTP
NPDES No. NC0050792
Randolph County
Good Afternoon:
Enclosed are three (3) copies of the completed application Form D-WWTP. This
submittal includes the necessary attachments for your office to renew the subject
permit.
Should you need any additional information or assistance, please feel free to contact
me at 910.773.0406 or by e-mail at [e-mail].
Sincerely,
Amanda Berger
Environmental Compliance Director
Aqua North Carolina
Enc: NPDES Application, Form D
Melbille Heights NPDES Permit
202 MacKenan Court, Cary, NC, 27511 > 919.467.8712 AquaAmerica.com

NPDES APPLICATION - FO ? D
For privately -owned treatment systems treating 100% domestic wastewaters <1.0 MGD
Mail the complete application to:
N. C. DENR / Division of Water Quality / NPDES Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
NPDES Permit
NC0050792
If you are completing this form in computer use the TAB key or the up - down arrows to move from one
field to the next. To check the boxes, click your mouse on top of the box. Otherwise, please print or type.
1. Contact Information:
Owner Name
Facility Name
Mailing Address
City
State / Zip Code
Telephone Number
Fax Number
e-mail Address
AQUA NORTH CAROLINA
MELBILLE HEIGHTS
202 MACKENAN COURT
CARY
27511
910.773.0406
AABerger(aquaamerica.com
2. Location of facility producing discharge:
Check here if same address as above
Street Address or State Road
City
State / Zip Code
County
■
NCSR 1922 at the Melbille Heights WWTP
ARCHDALE
NORTH CAROLINA
RANDOLPH
3. Operator Information:
Name of the firm, public organization or other entity that operates the facility. (Note that this is not
referring to the Operator in Responsible Charge or ORC)
Name AQUA NORTH CAROLINA, INC
Mailing Address 202 MACKENAN COURT
City CARY
State / Zip Code 27511
Telephone Number 910.773.0406
Fax Number ( )
e-mail Address AABerger(aquaamerica.com
1 of 4 Form-D 11/12

NPDES APPLICATION - FORM D
For privately -owned treatment systems treating 100% domestic wastewaters <1.0 MGD
4. Description of wastewater:
Facility Generating Wastewater(check all that apply):
Industrial
Commercial
Residential
School
Other
■
Number of Employees
Number of Employees
Number of Homes
Number of Students/Staff
Explain:
42
Describe the source(s) of wastewater (example: subdivision, mobile home park, shopping centers,
restaurants, etc.): SERVES RESIDENTIAL CUSTOMERS ONLY
Number of persons served: 106
5. Type of collection system
Separate (sanitary sewer only) ❑ Combined (storm sewer and sanitary sewer)
6. Outfall Information:
Number of separate discharge points 1
Outfall Identification number(s) 001
Is the outfall equipped with a diffuser? U Yes /1 No
7. Name of receiving stream(s) (NEW applicants: Provide a map showing the exact location of each
outfall)
MUDDY CREEK IN THE CAPE FEAR RIVER BASIN
8. Frequency of Discharge: ® Continuous 0 Intermittent
If intermittent:
Days per week discharge occurs: Duration:
9. Describe the treatment system
List all installed components, including capacities, provide design removal for BOD, TSS, nitrogen and
phosphorus. If the space provided is not sufficient, attach the description of the treatment system in a
separate sheet of paper.
The 0.0315 MGD package plant consist of the following:
• Influent pump station
• Bar Screen
• Equalization Basin
• Digester
• Aeration basins (2)
• Rectangular Clarifiers (2)
• Tertiary Filters
• UV Disinfection Units (2)
2 of 4 Form-D 11/12

NPDES APPLICATION - FORM D
For privately -owned treatment systems treating 100% domestic wastewaters <1.0 MGD
Components continued:
o Flow meter
o Sludge Holding Tank
® Emergency Generator
10. Flow Information:
Treatment Plant Design flow 0.0315 MGD
Annual Average daily flow 0.007 MGD (for the previous 3 years)
Maximum daily flow 0.022 MGD (for the previous 3 years)
11. Is this facility located on Indian country?
■
Yes No
12. Effluent Data
NEW APPLICANTS: Provide data for the parameters listed. Fecal Coliform, Temperature and pH shall be grab
samples, for all other parameters24-hour composite sampling shall be used. If more than one analysis is reported,
report daily maximum and monthly average. If only one analysis is reported, report as daily maximum.
RENEWAL APPLICANTS: Provide the highest single reading (Daily Maximum) and Monthly Average
over the past 36 months for parameters currently in your permit. Mark other parameters "N/A".
Parameter
Maximum
Daily
Monthly
Average
Measurement
Units
of
4.3
2.2
Biochemical
Oxygen
Demand
(BOD5)
mg/L
Fecal
Coliform
210.0
1.3
#/
100m1
Total
Suspended
Solids
12.0
2.8
mg/L
28.0
21.3
°Celsius
Temperature
(Summer)
Temperature
(Winter)
18.0
12.8
°Celsius
pH
7.8
N
/ A
UNITS
Type
Hazardous Waste
13. List all permits, construction approvals and/or applications:
Permit Number Type
NESHAPS (CAA)
UIC (SDWA) Ocean Dumping (MPRSA)
NPDES NC0050792 Dredge or fill (Section 404 or CWA)
PSD (CAA) Other
Non -attainment program (CAA)
(RCRA)
Permit Number
3of4
Form-D 11/12

NPDES APPLICATION - FORM D
For privately -owned treatment systems treating 100% domestic wastewaters <1.0 MGD
14. APPLICANT CERTIFICATION
I certify that I am familiar with the information contained in the application and that to the
best of my knowledge and belief such information is true, complete, and accurate.
Amanda A Berger Director of Compliance
Printed name of Person Signing Title
41 a ---, o 0_ /
Signature of Applicant v Date
North Carolina General Statute 143-215.6 (b)(2) states: Any person who knowingly makes any false statement representation, or certification in any
application, record, report, plan, or other document files or required to be maintained under Article 21 or regulations of the Environmental Management
Commission implementing that Article, or who falsifies, tampers with, or knowingly renders inaccurate any recording or monitoring device or method
required to be operated or maintained under Article 21 or regulations of the Environmental Management Commission implementing that Article shall be
guilty of a misdemeanor punishable by a fine not to exceed $25,000, or by imprisonment not to exceed six months or by both. (18 U.S.C. Section 1001
provides a punishment by a fine of not more than $25,000 or imprisonment not more than 5 years, or both, for a similar offense.)
4 of 4 Form-D 11/12

tri
�P>
t1
°
,
W.
..
ig
,7.�.,
�
cam
•
-
----=
)
1
`.
5
Di
I
.1fr.....al
t
lie-
lk
:11
A
iartr
-
"Pli
Mil
-.."
111111.1111V
a
e ries
c.--.
rim
a
411
for
Fir
°
ar
.
. .
•
t':.
0
.
t
0
r%
I�
-
0
s0
.
`
S
•
0
I
Lb"
i
.
0
rez..
All
(
•i
1
i
a
,
An
r
i-
"
Tri,
,
if
0
cr
re
...„.
es
°
'�'�c--'
/
1
I
°
II
•
....——,-#.,
Vl�it%%',�
/
�.�
.
.
rd_dialop
�_
�/
/L�
I
°cI.
"
Nos, -cat
o/
wit
��
LLT:itereal�;t
Irt`'
-
r
j�zap:
,C
,tom,-
14
VI
Ti
rii
,►�,%�
a
-•.,
..
1'
el
4
d111)16711I
° '
i
i
earN,
10
"7
P4
.l . 4
I
h
ri
°l
it
.4•`
°lro-b
(a_11
"
°
•
n1 Q
P
--
-'
�--,
_4`'
c�,�l.1°
Icy
` ..
S
....�
,
OUTFALL
001
County:
Receiving Stream:
Latitude:
Longitude:
Randolph
Muddy Creek
35° 52' 57"
79° 53' 41"
Stream Class:
Sub -Basin:
Grid/Quad:
HUC#:
WS-IV, CA"
030608
D19NW
03030003
Page '2
Facility
Location
(not to scalel

Aqua North Carolina, Inc.
202 MacKenan Court
Cary, NC 27511
www.aquaamerica.com
SL A E E 3' LA
For
Aqua North Carolina, Inc.
No sludge will be treated on any wastewater treatment plant site operated by Aqua
N.C., Western Division
Where practical, sludge removed from a Aqua N.C., Western Division facility will
be transported via a contract hauler to another Aqua N.C., Western Division
facility for the purpose of "seeding" a new or under loaded plant.
Unusable (or "dead") sludge will be removed by a contract hauler and properly
disposed of in accordance with NCGS 143-215.1. Contract haulers used by Aqua
N.C., Western Division will be required to report the quantity of sludge
transported and identify the location of the proposed disposal site if the sludge is
not taken to an existing plant operated by Aqua N.C., Western Division. Aqua
N.C., Western Division has not entered into any agreement to accept sludge into
its facilities from plants not owned by them.
Aqua N.C., Western Division will keep records on the quantity of sludge removed from
each facility, the name of the contract hauler, and the destination of the sludge (whether
used in another plant or disposed of). The information will be kept on file and will be
made available to any regulatory agency having jurisdiction over sludge treatment or
disposal
Aqua N.C., Western Division includes all of the facilities under the jurisdiction of the
Winston-Salem Regional Office.