NC0043231_Permit (Issuance)_20050420

NPDES DOCUMENT SCANNINS COVER SHEET
NPDES Permit: NC0043231
Cedar Rock Country Club
Document Type: (Permit Issuance
Wasteload Allocation
Authorization to Construct (AtC)
Permit Modification
Complete File - Historical
Monitoring Report •
Instream Assessment (67B)
Environmental Assessment (EA)
Permit
History
Document Date: Aril 20, 2005
ThiB dooumeat is Prlated oa retase PMPer-ignore any
ooateat oa the reverse Bide

s
AMR
NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Michael F. Easley, Governor William G. Ross, Jr., Secretary
Alan W. Klimek, P.E., Director
April 20, 2005
Mr. R.L. Bush, Jr.
Hibriten Development Corporation
1 Cedarwood Drive
Lenoir, North Carolina 28645
Subject: Issuance of NPDES Permit
Permit NCO043231
Cedar Rock Country Club
Caldwell County
Dear Mr. Bush:
Division personnel have reviewed and approved your application for renewal of the subject permit.
Accordingly, we are forwarding the attached NPDES discharge permit. This permit is issued pursuant to the
requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement between North
Carolina and the U.S. Environmental Protection Agency dated May 9, 1994 (or as subsequently amended).
This permit includes no major changes from the draft permit sent to you on February 2,2005. Note
that the Total Residual Chlorine (TRC)limit in this permit takes effect November 1, 2006. If you wish to explore
dechlorination options in order to comply with the limit, consult the enclosed guidance document.
If any parts, measurement frequencies or sampling requirements contained in this permit are
unacceptable to you, you have the right to an adjudicatory hearing upon written request within thirty(30)days
following receipt of this letter. This request must be in the form of a written petition, conforming to Chapter 150E
of the North Carolina General Statutes, and filed with the Office of Administrative Hearings (6714 Mail Service
Center, Raleigh, North Carolina 27699-6714). Unless such demand is made, this decision shall be final and
binding.
Please note that this permit is not transferable except after notice to the Division. The Division may
require modification or revocation and reissuance of the permit. This permit does not affect the legal requirements
to obtain other permits which may be required by the Division of Water Quality or permits required by the Division
of Land Resources, the Coastal Area Management Act or any other Federal or Local governmental permit that
may be required. If you have any questions concerning this permit, please contact Bob Guerra at telephone
number(919)733-5083, extension 539.
Sincerely,
ORIGI
� NED Y
A. W SON
Alan W. Klimek, P.E.
cc: Central Files
Asheville Regional Office/Surface Water Protection
INPDES Unit d
1617 Mail Service Center,Raleigh,North Carolina 27699-1617 One
512 N.Salisbury St.,Raleigh,North Carolina 27604 NorthCaTolina
Phone: [phone]/FAX [phone]/Internet:h2o.enr.state.nc.us An Equal Opportunity/Affirmative Action Employer-50%Recycled/10%Post Consumer Paper ;Vatu�+ (/lUU
a"

Permit NCO043231
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other
lawful standards and regulations promulgated and adopted by the North Carolina
Environmental Management Commission, and the Federal Water Pollution Control
Act, as amended, the
Hibriten Development Corporation
is hereby authorized to discharge wastewater from a facility located at the
Cedar Rock Country Club
off NC Highway 18
Northeast of Lenoir
Caldwell County
to receiving waters designated as an unnamed tributary to Lower Creek in the
Catawba River Basin
in accordance with effluent limitations, monitoring requirements, and other
conditions set forth in Parts I, II, III and IV hereof.
This permit shall become effective June 1, 2005
This permit and authorization to discharge shall expire at midnight on February 28, 2010.
Signed this day April 20, 2005
ORIGINAL SIGNED BY
SUSAN A. WILSON
Alan W. Klimek, P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission

Permit NC0043231
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility, whether for operation or
discharge are hereby revoked. As of this permit issuance, any previously issued
permit bearing this number is no longer effective. Therefore, the exclusive authority
to operate and discharge from this facility arises under the permit conditions,
requirements, terms, and provisions included herein.
The Hibriten Development Corporation is hereby authorized to:
1. Continue to operate an existing 0.009 MGD wastewater treatment system with
the following components:
♦ Two grease traps
♦ Manual bar screen
♦ Aeration basin
♦ Activated sludge reaction tank
♦ Clarifier with skimmer
♦ Chlorine contact chamber with tablet chlorinator
♦ Flow measuring equipment
This facility is located at the Cedar Rock Country Club off NC Highway 18
northeast of Lenoir in Caldwell County.
2. Discharge from said treatment works at the location specified on the attached
map into an unnamed tributary to Lower Creek, classified C waters in the
Catawba River Basin.

' ( O nTsrHARr
e0p
60
1, A T• 35" 54' ZS
ub r
mmbb t ,► O N rr . B/° Z7 'y5
((y�I �
/ !z I ' ee i ppp I
i
jr.9f
Y
/l1
4 i ,
1-mmtdu , Facility
nt,attn� gl ,, a. NCO043231 5
Receiving She:m�t - Location - -
I T f [_(,I,el QRek Cedar Rock Country
Club SCALE 1 :24000
5ubl nsin'.STIR;I

Permit NCO043231
A. (1.) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS — FINAL
During the period beginning on the effective date of this permit and lasting until expiration, the Permittee is
authorized to discharge from outfall 001. Such discharges shall be limited and monitored by the Permittee as
specified below:
dEFFLUENT U,'(ql '1� ��1 1 � d , LIMITS l' u ° i�MONITORING+REQUIREMENTS,,)�
a' k 1�1 1 t°�i Yin ,;il 3 1 e !,� :� fi p
(CHARACTERISTICS'rr sP t�sr;ll� � )° r
Na �3q3q�i "'i�'' 1 Monthl ', t " i"jD`II",,lq�, 1Measuiemerd Sample Type SartipleLrocattona jf
�� icl.ye:x..:%r+" j "IMR:a151Nfl+H�Nw A 1 ,spa flyAi �l it�. f te'u f31,i
9. �d.'�"r1t� A n Lf3i4 iPa lai05, ."p� 1�Vefa @iiji,;t,,,Maxmjum^� �'.Mf�rn". 7I,..itt#�t"
Flow 0.009 MGD Weekly Instantaneous Influent or Effluent
BOD, 5-day(20°C) 30.0 mg/L 45.0 mg/L Weekly Grab Effluent
Total Suspended Residue 30.0 mg/L 45.0 mg/L Weekly Grab Effluent
NH3 as Nl 8.0 mg/L 35.0 mg/I Weekly Grab Effluent
(April 1 —October 31
NH3 as Nl 27.0 mg/L 35.0 mg/I Weekly Grab Effluent
November 1 —March 31
Fecal Coliform 200/100 ml 400/100 ml Weekly Grab Effluent
(geometric mean
Total Residual Chlorine2 28 ug/l 2/Week Grab Effluent
Temperature(°C) Weekly Grab Effluent
pH3 Weekly Grab Effluent
Footnotes:
1. Based on adverse comments from EPA, the Division of Water Quality was required to implement daily
maximum NH3 as N (ammonia) limits for non-municipal facilities, as required by the Code of Federal
Regulations. This implementation policy was adopted October 15, 2002. The weekly average value is five
times the monthly average value (this multiplier was established based on a review of treatment capability at
various plants). Daily maximum values are capped at 35.0 mg/L.
2. Limit takes effect December 1, 2006. Until the limit takes effect, the permittee shall monitor TRC (with no
effluent limit).
3. The pH shall not be less than 6.0 standard units nor greater than 9.0 standard units.
There shall be no discharge of floating solids or visible foam in other than trace amounts.

Copies 'of the*draft NORTH CAROLINA,
permit'-, ertd", otherll CALDWELL COUNTY,
supporting �rinforma PUBLIC NOTICE- AFFIDAVIT OF PUBLICATION
bon on�f., used to -'
determine conditions 'STATEOF `1,,!)
ipresent h m the draft NORTH,CAROLINA Before the undersigned,a Notary Public of said County
tpermitu`aret avarlable� ENVIROMENTAL-i
@ up on,;,request�y aril ` MANAGEMENT?t. and State, duly commissioned, qualified, and authorized
,Caldwellr<g ourity a me COMMISSION/( by law to administer oaths, personally appeared
School's` Y nt ofathe,costs Pe Y PPe
NPDES of reproc III n tiiMail NPDES UNIT aas
{wNoy>4 CtNC0041157t comments4and/or re 1617•MAILSERVICE'
r»1914 Hicko Boule CENTER .......
S ryxr que6W'; or�.informa r% xg Bretuia..W..Eenlsy........................
yard",S W�h Lenoir„ RAL'E UM"NC 27699u who beingfirst dui sworn, deposes and says: that
tion to the NC Dryi q}II y po y
its, errtntdischa g �Pro thSo uce eBrar ch' ' A N ATION+OF%+
inl1eu ftoe0004MIGDitz at
si of WaterOuality WAST:TO,ISSUE
NC:28645 has ,a 4NOTIFIC
'P PDES he is.....�i1C�Z]JO.f�SI..P.�C46. 4Z...................
9 P. ' EWATER of The Lenoir News-Topic,engaged in the publication of a
domestic types[ f ;ylf 'atk (919)s 733-5083v� f+ PERMITA , frt" P
" wastewater fro-m+ittie.vextension,-,' �52f1�,pn+,thetasrs of thor-.` newspaper known as Lenoir News-Topic, published,
v GatewayafAiternatiGe Please M:Includetneu ougFi ,<."staffCrev(e'wj issued, and entered as second class mail in the City of
School ,WWTP 'fto " NPDES'permtttium ° and1u,,appl(cahon 1of t Lenoir, in said Count and State; that he is authorized to
t Upper LlttletiRiver rn bar attached"in an` NC�Genreret�Btat,,d Y
O'the 'Catawba 'River ( ) Y +143 2'1 P,Obit �1 law, make this affidavit and sworn statement; that the notice
_ communrcatron �lfi
Basin Currently' "terested I D2 personsk, 92 500 „and Otfter or other legal advertisement, a true copy of which is at-
ammonia.a.1.1 chlcr'�"?ma.... ..uwsd the"Dlr^ lawful�standerds'and y;[ached hereto,was published in Lenoir News-Topic on the
r Ine;arelwater quahty� twsion t�of �„Water[ regulahonsy' l ," ttie+'following dates:
kmdedrThisdrs', qualityrat f512f ,fV f North Carolina Enwrv.:
charge mays affect`, Sahsbu °Street) Ra omental=z, Mana a m
future"allo`catwns ui Ieigh""*NC '277602ii anent 2 tiCommission'l
this ,potcn of ,thew 1148lietweenr';'the proposes tdissue,$"a' """' Fb'4""""""" """' "" """
over basln'M. t F' r
hours)iofi 8 00 a m National,, Pollutant
Caldwell ICoun nand"5 00,p m to,re` Discha a riElrmma=
SchoolPDES st it ........................................................
No era 3=NC0041220`J, i vww attonoon tion tF ")System and that the said newspaper in which such notice, paper,
.ftle th 5 ,(t"t (NPDES)= wastewa-
1914 Hickoryi Blvd rdShuforaz mills""Ino ,ter;,Idscharge•�permit�document, or legal advertisement was published was, at
tSW ` Lenoir"+pNChas a lied 'for re`- of 1heR arsons list= ,'the time of each and eve
28645 li fi`as applied" newal Ppr " p" ' Oi every publication, a newspaper
or m of,� t errriit ed below. effewtive'n meetingall of the requirements and qualifications of See-
j0akf?rH II ma rkNC0035211 for it's 45 . 11 s from the;r tion 1-597 of the General Statutes of North Carolina and
A Y ,
ry, Dudley v� �j Shodig publish date ofgthis;�
Scho01� WWTP'dis ,r " a fir, r
2 , .�y �aW WTP Caldwell I nohce ��. was a qualified newspaper within the meaning of Section
charging up t0�0003 County-,Thrsiperrtuf-JWntten ccanmenta�re-,
MGD of 'I type i tad'facilityktliachar� iygarding the ,'�pro�� t-597o[YheGeneralStatutesotNorthCarolina.
oseal,
gMpuntaint Ruii Creek' ter'to'the U aelrrUt-,# acceptetlB mut l `G' 30a This .......dayot .......... ..Y.............. �i
4th February
V in the Catawba River i ' PP p
BAsin p r, Cur ently„ fwbadr Riv`erµeBasin iC l slip datee this.no-
ammonia andgchlor CurrenlyBOD am1i lice r All comments) ............•••••
me rare�water'quality, m0nia nitrogen dfecel,�receroed;poor toithat:
4Ujlurq -*maiViiattec-i colrform`andtotakre.idate eresconsidered'
chergQw may y affect } srdualsiiohlonnewrare m the fniel detenni-, Sworn to and subscribed before me,this ..4.th........
.f.futurerallocahons rin+ water 'uali klimrted nations ire ard16 a
This.portionti�of the � Thisdiecharge6maq Sthelprop ed permi9j Februar iaea
4jiver basni ' , ,�, .tie,:: - day of . •...........Y.............................�....
HibrdenSDe elopm t lions in"this raolrt on NC DlDvis onoofoWa eei ��� � /�� �� �
�Corporabon; PDES p � / Li x- �`"
Permitw.B ' ti'No of nver,ti$srq '" Quality, maywdecrde� �".f ..
noir NC,28845 lies the,h ry s onyx eceive` Notary Public
NC0043 'tmeetm for the pro-*,
"(S'denvood Dilve Le
pose
D My Commission expires: ...............................
appked ffor,�renewal a signihca"a,'degree,
01 its Cadarz Rock of publiointerest. •.
ryCountry Club' waste"
watera��permiV3 drs
c6erging up'tov0 009
fMGDofptreated do i
mastic a wastewater
S�to:an unnamed tnbu-�
gtery&to' L`oweiCreek
- thefCatawtia;Rfver
sin Ammonia;,and�!
cFilonfie are'^rwater''
,,,guahty,Jrmited.;This:.
;maY.�y"affect'.;',future'.;:
discharges.Nf.m. tfiis`
Porhona of,n the,•river•.
` basin ��:,� o•
,gka4

CEDAR V ROCK
COUNTRY CLUB
August 13, 2004 _
u� AUG 11 2003
OEHR - WATER QUALM
POINT SOURCE BRAN"cH
Mr. Charles H. Weaver, Jr.
NCDENR/Water Quality/NPDES Unit
1617 Mail Service Center
Raleigh, NC 27699-1617
Dear Mr. Weaver:
I am requesting renewal of NPDES Permit NCO043231 for Cedar
Rock Country Club. Enclosed in our renewal application
along with a narrative description of the sludge management
plan for the facility.
Sincerely,
1
Emily B. aig
Office Manager
Enclosures
450 CEDAR ROCK ESTATES DRIVE • LENOIR, NORTH CAROLINA 28645
[phone] FAX [phone]

CEDAR V ROCK
COUNTRY CLUB
August 13, 2004
Subject: Sludge Management
Facility: Cedar Rock Country Club
NPDES PERMIT NC0043231
Caldwell County, NC 28645
The sludge is removed by Phillips Septic Services of
Caldwell County and is transported to the City of
Lenoir Municipal(WWTP0023981 )for disposal .
4"."a
Office Man ger
Emily B. raig
450 CEDAR ROCK ESTATES DRIVE • LENOIR, NORTH CAROLINA 28645
[phone] FAX [phone]

t01NHUhb CT./.-
1 ` /pwB! y C SOWa`a': a''c''0 5 ,<ydga� ogOS SHELDY Lr -
f03 .
gN
OR/O
n�, W CE O •.:om n9,f, iSs caa� n�� AF, �tRll GE'80 41 g
:. k/p GF m o ""! ��•g yf YITHO NE COLONY
HA •j9 ,9
R °(.y�G a gi o or
N /C c� ! _ HERLO KOR. aBg4 , S pry ga oag c 7f
Cr �3 0g)}lOp i �•� i^ o�(. 4 s� KAY T 1� Cy4R `BCie�I J T L�ga Rp
�{7p 6f O .7�0
/ � �a4g � �pgOp � ,aya• B �.�, 4pyT � h/ Bgf a
AO qN y
,� id° �B p<as '99 q'o PAID Es-
.
' pi`' �\ - ' .,..,. �`'^a � .` n CT STLE �Qpo'4�+r..,)�'. GOTTRECC 5s
C L'7\ —HILL �, z=RD. Rrll R o 9iP'WErELO
O iRELL P.P s m t P �QF
.el
0 o9 yn9C P 3000�
.16
RED HILL
PL. PL.
•:l BDODSIDE
'<9P DELLCROFT
/TFZ y CWOOD PL. ` � ('t LN. -
m .p
H COLONY ROCK
4 R(Ic B,p
ay P� C 00
O
y 'Hy O
r- p111tl
CIR. 3\�a O�
FOUR
SEASONS DR.
d < y
C 4'YFVIEW J �3
O
CEDAR