NC0020052_Permit (Issuance)_20100119

NPDES DOCUMENT SCANNIM& COVER SHEET
NPDES Permit: NCO020052
McAdenville WWTP
Document Type: Permit Issuance
Y
wK-
Wasteload Allocation
Authorization to Construct (AtC)
Permit Modification
Speculative Limits
Compliance
Instream Assessment (67B)
Environmental Assessment (EA)
Permit
History
Document Date: January 19, 2010
TJXIM docume3Mt oa reur3e paper-*@PMI0 re y
coVkteat 93ML the r4e%rCrse Side

NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coieen H, Sullins Dee Freeman
Governor Director Secretary
January 19, 2010
The Honorable Farrell A. Buchanan
Town of McAdenville
100 Main Street
McAdenville, NC 28101
Subject: Issuance of NPDES Permit NCO020052
Town of McAdenville WWTP
Gaston County
Dear Mayor Buchanan:
Division personnel have reviewed and approved your application for renewal of the subject permit. Accordingly,
we are forwarding the attached NPDES discharge permit. This permit is issued pursuant to the requirements of
North Carolina General Statute 143-215.1 and the Memorandum of Agreement between North Carolina and the
U.S. Environmental Protection Agency.dated October 15, 2007 (or as subsequently amended).
This final permit includes no changes from the draft permit sent to you on December 2, 2009.
If any parts, measurement frequencies or sampling requirements contained in this permit are unacceptable to you,
you have the right to an adjudicatory hearing upon written request within thirty (30) days following receipt of this
letter. This request must be in the form of a written petition, conforming to Chapter 150B of the North Carolina
General Statutes, and fled with the Office of Administrative Hearings (6714 Mail Service Center, Raleigh, North
Carolina 27699-6714). Unless such demand is made, this decision shall be final and binding.
Please note that this permit is not transferable except after notice to the Division. The Division may require
modification or revocation and reissuance of the permit. This permit does not affect the legal requirements to
obtain other permits which may be required by the Division of Water Quality or permits required by the Division
of Land Resources, the Coastal Area Management Act or any other Federal or Local governmental permit that
may be required.
If you have any questions concerning this permit, please contact Bob Sledge at telephone number(919) 807-
6398.
Sincerely,
/ col
een H. Sullins
cc: Central Files l
Mooresville Regional Office/Surface Water Protection Section
NPDES Unit
1617 Mall Service Center,Raleigh,North Carolina 27699-1617 Olic t�CdI U1111d
Location:512 N.Salisbury St.Raleigh,North Carolina 27604 L.V
Phone:[phone] FAX:[phone] Customer Service:1-B77-623-6748 �TU1l
Internet:wmnv.nc%Yaterquality.org /��lr
t1�1'+>171�jJ
An Equal Opportunity 1 Allirmatrve Action Employer v a%

Permit NC0020052
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provisions of North Carolina General Statute 143-215.1, other lawful standards
and regulations promulgated and adopted by the North Carolina Environmental Management
Commission, and the Federal Water Pollution Control Act, as amended, the
Town of McAdenville
is hereby authorized to discharge wastewater from a facility located at the
McAdenville WWTP
Church Street
Gaston County
to receiving waters designated as the Sotlth Fork Catawba River in the Catawba River Basin in
accordance with effluent limitations, monitoring requirements, and other conditions set forth in Parts I,
II, I11 and 1V hereof.
This permit shall become effective vlarch 1, 2010.
This permit and authorization to discharge shall expire at midnight on January 31, 2015.
Signed this day January 19, 2010.
Coleen H. Sullins, Director
Division of Water Quality
By Authority of the Environmental Management Commission

Permit NCO020052
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility, whether for operation or discharge are hereby
revoked. As of this permit issuance, any previously issued permit,bearing this number is no longer,
effective. Therefore, the exclusive authority to operate and discharge from this facility arises under the
permit conditions, requirements, terms, and provisions included herein.
The Town of McAdenville
is hereby authorized to:
1. Continue to operate an existing 0.13 MGD contact-stabilization wastewater treatment facility with
the following components:
♦ Influent pump station
♦ Bar screen
♦ Grit chamber
♦ Contact aeration basin
♦ Reaeration basin
♦ Aerobic digester
♦ Clarifier
♦ Effluent disinfection
♦ Dechlorination
♦ Flow measuring device
This facility is located at the McAdenville WWTP, at the end of Church Street in McAdenville in
Gaston County.
2. Discharge from said treatment works at the location specified on the attached map into the South
Fork Catawba River, classified WS-V waters in the Catawba River Basin.

Permit NCO020052
! `s� ';�. I .r/•' ---� � -:i jC 1 1 `\ �- \ a '`• i "'- J `.;�, '' ,s�,,y ij�•2_x vz
I F.I ,is>< r r� �/ ♦ '` ,• . f \- � ♦• I.'7x�Y� �i x s *{ yy�; �; •
' � � 'f � i w Y��.w I• �`�: �\��C�}2^ �i• c7 .,�"; f �:y xY'/t f%
..�'. -/� -X' i•r�l•1 rJ sY i jr•r1�`• ��,.._•• •�,�,\ '. �r3t.� � - '+S ,e�l • %
f' •�.�- r• /�n ' t V� - i � ,w� � �.� +x. �r, - `•S�'.al�f�' f i 1 '�' �' ,lJ •--�
i I f! ,.. I` Y I `w �• M
_ 7 !:� � J� t���J r 7 t Ir.d -`/..-r_•^�'S I�r��� rx'�•r� ++?� > ('`{ �• ' • �/j.��,u' r' }
/ r ! ie s- ` 1• \ t. �"'�•' •
r! /-r �"f' '� +I ` \��y\Iti •`��` t, ` ~. �' .•1_T 5. 1(;1 `1`� I ,/-.gT "� rt Fc`\ a.. / t• 1:.
;r 't• 1\1• �i •.-i.� (1 r� � -r r 1 s's3( �/ f• T'J{ \.� � /,�i� -SAID.
• 1 � I 1L!/Ve.•e. J t S ,. 27 'i� ! I{ i s -��. Y� �.
. • �'aD1SpG15a t ;ti\ �\1 ! `~� r`,1 �� s .,1„ \.!'SyYr. �(v�`� it� f7 �ry'M�+al t�'/�s�`{ r,���n
�•+;_�- � �'�i / i"'r - 1° Y.r-: -~,��w-=�J�. r�f'-�C a� �,-i.\-a � `�,it��„�i}r �� r\{ t�� `��
J' , I.t r•' .�e .t•.
`�: ,`\~ C- r-•`.� °`�x�s fi :\`Tr.�f'.``. 1 `.,7 �-i`.4�M < � �i_I/Y�� r ;�,. �.� t •.O� � "�/�� 2s� �..-r�•.
\��r• �. �., F+' - Aw •�,�•-.•�`i �4'e, r.. l ,� p -< <`*,'^ '"ix. !r b f i° �St 'LIP,
L•J f!�` \\ _-}ram: I f-_ ? � y I�� �.� r • �! r.r.S'� �• __� � �'!S'� `e.'.
r f
WIP_
}Ir+Y-5 11.i. �-. •J / •/t l ! a%f i ti e~l :{-efS .�.�wiTFhrt 7 -%'KF'1,�5
,Af 'cWa18i `~ F� 1`i e'AUen'
;•• *�':��� '.ar1�5 tnt ��., r1,�1 � , l,`\\�. r � } I�1 � �";./(• � �`�.,}� l�e�i �\ �., J .•,f_ •�•�,�"s 'k 5��1 ,`�~
•1 ••/ .♦ i -i.trs j. l ;`' 1 J !L)j,%a••• ���,•, 1:° (� J I / �T' t�-'�\5�.;,1
�rrr • I'.°I •f �♦ t l/ r*I tr --.. `._,�l�j •+ �_y J \' ; y1 � -ate`". 7. 5 �.r'• ; �, s5�
!!. { �� c + 't � -rii• .ltSt or,: ` i I 1 'r -\ i � I•�,. ey
1/f I ♦ �� �.S `,� '�L.ti � /�i'• �•fl f,+ .s• �"[.•. } .r+y 31. r * alir•-�.
/ � � � . ! s�--•.� z 'f�/ �.Ir Si't r-• i r ��j/� � � � y i ��i r' t� r -�`,� 5 j a
1l t� RYlar�J J•.'i •_ C` [`,_ �J,�.t'`: �1�•�r1.-a• a�,..'•Sj 4 - ~ �s j ',�-•,1' - -1� f j S• -1•
•ry �./ s\t-ill k�Y I I'� S r�� *ti�'al 11• • � �5 ' d �' i�'`�. � '�1•'J, i/ •
fr,` iGardens
w j, fl 1, • _L • i �J • \ f a l.J a' - • p c l �L� s,4i�.k�7
t�
r a;s; / '" 't,Ty�� itafl' `a\ ..t�rj ri - —f� i Th•9dtEr_
( rt I•� J�= e •[ _.4 l l f�r .\�� •/, r z_ •y
• \` �;� r.l•p Ff �'s' FI ��5 1S„ f %r 5 +1&a$'Q"'• !- � t F Y ti j- �,•�� } - , rl 41:an
J. 1``- i s r F/!� ~, � � r•. �/L. � �l� �I$�� 4 / s� w 4, s ` `
-i.Y f� ir..a-y / �//�r4 �6 i, � !���..�.•�■ � A�
� `�•-J// � �• •�•�r-'r � � � 'T.yS 1 del 1 }i \�,� ♦1) � �`mow t
1. ' • I •♦♦•_Y•� •:K w �, �-r,{Y —fs[ ap,` r �` \'w� 1 � �.,tia
• ♦ .r/• 1' Y. •.�a f a. ♦ ` °.Y w' �S,]Snr\`.• �' 4,, \ /�• +± 1
_ ��- ±_ `''r i f!2�'i %�`-. •.are`♦ i•`*.. '� �Y t� ..\_s � j .� .1 j ♦ ,..'� *• � f:+• �
:'-a—- \tr is 1f �:'� 'y1 l [. '.r. S r r _ s \ _,� r + f � ��♦! •� /
sue. r-•' ** - J:r:' •+.,��'!.•4 a • `' � --w s �:,; �' . � • �:i
' ��Qf ,;.� I_•.•..; y ;J , ramer on% . r `; , ''� GC
.,���`, �, ,�{ l �rl{,]��. 1,�,�-�j� `f�t`il ',��t"S•YIS�s� io �� e�����! -�. ,.:�r
7.
A\ : C- 1 tt
Latitude: 35 15'22'Longitude: 81 04'21" NCO020052 Facility
y
River Basin#:uad 03 0a36 Town of MCAdenvllle Location
Receiving Stream: South Fork Catawba WWTP
River
Stream Class: WS-v Cffotth SCALE 1:24000

Permit NCO020052
A. (L) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS - FINAL
During the period beginning on the effective date of this permit and lasting until expiration, the
Permittee is authorized to discharge from outfall 001. Such discharges shall be limited and monitored
by the Permittee as specified below:
EFFLUENT
MONITORING
CHARACTERISTICS�4; LIMITS 4 FtEOWREMENTS.
.. -:Monthly Weekly Kflaily. Measuremen# rSample Sample Coca#ions
+-Average .'Average�'. -,Maximum Frequency Type .
Flow 0,13 MGD Continuous Recording Influent or Effluent
BOD,5-day(20"C) 30.0 mglL 45.0 mglL Weekly Composite Influent and Effluent
Total Suspended Solids' 30.0 mg/L 45.0 mg/L Weekly Composite Influent and Effluent
NH3 as N Weekly Composite Effluent
Fecal Coliform 2001100 ml 4001100 ml Weekly Grab Effluent
(geometric mean
Total Residual Chlorine2 28 ug/L 2/Week Grab Effluent
Temperature (°C) Daily Grab Effluent
Total Nitrogen Quarterly Composite Effluent
NO2+NO3+TKN
Total Phosphorus Quarterly Composite Effluent
pH3 Weekly Grab Effluent
Footnotes:
1. The monthly average effluent BOD and Total Suspended Residue concentrations shall not exceed
B% of the respective influent values (85% removal).
2. The Division shall consider all effluent TRC values reported below 50 µg/L to be in compliance
with the permit. However, the Permittee shall continue to record and submit all values reported by
a North Carolina certified laboratory (including field certified), even if these values fall below 50
µg/L.
3. The pH shall not be less than 6.0 standard units nor greater than 9.0 standard units.
There shall be no discharge of floating solids or visible foam in other than trace amounts.

Permit NCO020052
A. (2.) Report on Regionalization
By January 31 of each year this permit is in effect, the Town shall provide the Division with a report
detailing the Town's progress toward entering into an agreement with other municipalities and/or
entities that would lead to the Town's wastewater being treated at a regional treatment facility and
elimination of the Town's existing discharge. Should the Town enter into such an agreement, the
report shall then document progress toward actual connection to the regional treatment facility and
elimination of the Town's discharge. This report is to be sent to:
NC Division of Water Quality
Surface Water Protection Section
Mooresville Regional Office
610 East Center Avenue; Suite 301
Mooresville, NC 28115

4�y
1
HC®ENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins Dee Freeman
Governor Director Secretary
December 2, 2009
MEMORANDUM
To: Britt Setzer
NC DENR /DEH/Regional Engineer
Mooresville Regional Office
From: Bob Sledge �i
NPDES Unit
Subject: Review of Draft NPDES Permit NCO020052
Town of McAdenville WWTP
Gaston County
Please indicate below your agency's position or viewpoint on the draft permit and return this form by
January 15, 2010. If you have any questions on the draft permit, please contact me at [phone]
or via e-mail at [e-mail]:
RESPONSE: (Check one)
Concur with the issuance of this permit provided the facility is operated and maintained properly,
the stated effluent limits are met prior to discharge, and the discharge does not contravene the
designated water quality standards.
F-1 Concurs with issuance of the above permit, provided the following conditions are met:
Opposes the issuance of the above permit, based on reasons stated below, or attached:
Signed Date: 3 Q
U —1 .
1617 Me]Service Center,Raleigh,North Carolina 27699-1617 One
Location:512 N.Salisbury St.Raleigh,North Carolina 27604 North Carolina
Phone:[phone] FAX:[phone]Customer Service:1-877-623-6748
Internet:www.ncwaterquality.org �atura!!
An Equal 0oportunity 1 Affirmative Acton Employer

The Charlotte Observer Publishing Co.
Charlotte, NC
North Carolina ) ss Affidavit of Publication
Mecklenburg County)
THE CHARLOTTE OBSERVER
-------------+----------
___________ r rolm•BnviroNomaimaria
+
________________ I `Y' tr"��om ssion/NPOES Unit9emanil f'[t..�`l.h
g l�t 617,Mail Service Center�- ,� }v•1�
I f V; "fiaSei h NG 27699-1St7 fF R
ATTN DINA SPRINKLE No oflnterif lsmea NPDESWastewkter!serous �s�l
_;T Nortd CarOliria Erivirrinmenial Mana emert Commrssion�
NCDENR/DWQ/NPDES I r - 4
L prop nas,ie Issua a NPDES'wastewaler.riischarge permit io,thet
1617 MAIL SERVICE CTR
Pe (a)fisted Below:={_�: :�-,,,•-�,n;=::c- �s.=.:�'::^7
Written somrnents regarding,the proposed,permit will`.ba;
BALE I GH NC 27699-1617 I accepted unlit 30 days after the publish date of this-nctina.-,They
Director of theNC-Division of Water Quality IDWO)may hold e
publie.hearirlg;shoukl there be-a significant degree of public,
interest,Please.mail comments and/gvinformation requests to
DWQ at the above address.Interested Berson may visit the DWO.
Ell 512 N Salisbury Street,:Raleigh;NO to review information on
REFERENCE: 3D045571 I I file.Additional information on NP ES perm m its and iha WOW ay
be found on our wabsiW.wwWrruw•,aterquaW.Org;.or by Calling
Wastewater Discharge I 91g 6p76C304 ^; 7"
6415988 I 1 The Lincoln ;ounA requested newat of permit N06067222 foe
-Kilian Creek rn'U,,-,:tn County Sins teed dscharge is
ireated,mun>crpaf wastewater-tp,Killian!Creek,Catawba "I,
Before the undersigned, a Notary Public of said I eas,n �:Z 1 + '-`eV'-- �a�f I,�Y:;
authorized to administer Dawson Intematon"Propertes requested,eneWaf of NPDES
County and state, duly I permit NC0096487 for.is tybernarfe facihry in Stan g+y County;this
personally appeared, pe rmttaddischarga steatedgn7u5dwaterto the>oplir$ranch;
oaths affirmations, etc., I Yadkin Pee-DeerirverBasin. t. y _-<<I-rt.
to law, � �-The:Cdy,'af Hickory!requested'. or-moailication,of permit
being duly scorn or affirmed according I NCOQ25Wfor.Hickory-Catawbav inCBtawbaCounry.this
se and say that he/she is a permitmo4discnarga'u_treated•umcipalEwaslewater to i_yle•
Creek,Catawba.River Basin,
Bath depose I 4. -. . r•..i..-. ;p":�.�ta�rt .
Celtlwell County•$Chock r944ested;renewal.bt NPDES e
The Charlotte observer NC0050075,,for_,Colletlsville,Elements •School„'_ acility
representative of I rryy I�
a corporation organized and discharges'treatad;wasieweter,to;Johns-Rtver.in_.2ha Catawba
Pub l i sh i n9 Company, P° I River Baairi<Currently,no parameters ere wafer quality nmaed.;
R,L ques:Hush reted'renawal'oi'pefmft N66043231.6i the Cedar
doing business under the laws of the State of a�kCoi,;,rry(;IabWWTPincaldwalt county-Faaltydischarges
Delaware, and publishing a newspaper known as The I treated domestic wastewater to an_Unnamed tributary to'I_dwer
Creek-in the'Cartawba-River Basin.'-Ammonia rulrogen;fecal
n the city of Charlotte, I corporm and Intel residual chlorine are water quality hm4ed.','.,,
Charlotte Observer i �' "'•�' 4'• y
ceklweli Coupryry Schools requested))nevrzis Ia Np0E5"arges
Of Mecklenburg, and State of North Carolfinal NC0ed wastewater
aer(Elementary SCreek_ThiUVICytlecharges,
County I treated wasigvreter into'S[affortl'Creek Tin Ihei Catawba!Rr,+er
Basin.TotaF:,residual,chlorine,iiecal,;col'rtorm and ammonia
and that as such he/she is familiar with the nitrogen are water quality limited
',;_,� --
books, records, files, and business of said rne"cAyoicastoniarequestedrene,,,alofpermaNCaoaomDfor
its Water-,TrealmenI..Planl in Gaston.County;,ihis,5 permitted
ration and by reference to the files of said dmcharge''is-treated filter-backwash wastewater,to an unnamed
corporation I I tributa+y.to tong Creek in the Catawba�RivtIr Basin.?}-�_•j sg;
the attached advertisement was I The Tawm( H7eA6& lle requested renewal nF peroit NCCMbM2
publication, I for',the•McAdenvrlle'l"MTP In,Gaston County,this. erm�tted
-discharge is-[rested was[ewafer,to the South j'ork Catawba River
inserted. The following ;s correctly copied Coin in the Catawba River,Basin ;;+1.�' ;E x,r,�.r - -ii",. -.
the books and files of the aforesaid Corporation I I Carolina Water.Service,'(nc.o1 N6`request-ad renow'A of peritit
NCDO3342t foe the'College Park WWfP in Gaston County;this
and Publication. permitted discharge Is heated domestic yvastawater to Little Long
Creek ihthe Catawba River
Burlington Industries requested d renewat of permit IyC004$32p to,
this t aurtingian Industries/.Richmond Plant in lleuTtand County,
,permitteb_'dischargge.`s'treated industrial�and:sanitary
wastewaters to Hitchoock Greek %_dkln.Pea Dee River Basin.) -
I LP6415989•p:� (' ,C,L t:�
I r.
I
I
PUBLISHED ON: 12/04
I
I
I
. 1
AD SPACE: 140 LINE
FILED-ON: 12/11/09 -------
- 15�►"1 TITLE: -
NAME: DATE:
In Testimony Whereof I have hereunto set my
han�and affixed my seal, the
day and year aforesaid. My Commission EXOeS MaY 17, 2011
>< y Commission Expires:
Notar .

SOC PRIORITY PROJECT: No
To: Western NPDES Unit
Surface Water Protection Section
Attention: Tom Belnick
Date: August 31, 2009
NPDES STAFF REPORT AND RECOMMENDATIONS
County: Gaston
NPDES Permit No.: NCO020052
PART I - GENERAL INFOR1VIATION
1. Facility and address: Town of McAdenville
Post Office Box 9
McAdenville,NC 28101
2. Date of investigation: August 27, 2009
3. Report prepared by: Michael L. Parker, Environmental Engineer II
4. Person contacted and telephone number: James Davis, ORC [phone]
5. Directions to site: From the jct. of Main Street (Hwy. 7) and Wesleyan Drive (SR 2209)
in the Town of McAdenville, travel south on Wesleyan Drive = 150 yards and turn left
into a paved parking lot just before crossing abridge over a stream. Travel through the
parking lot around behind an adjacent brick building. The paved parking lot ends and
the road turns to gravel as it circles behind a large pond. The gravel road then forks into
three gravel roads (take the far left fork), and the WWTP is located at the end of this road.
6. Discharge point(s): Latitude: 35" 15' 20"
Longitude: 800 04' 22"
USGS Quad No.: F14SE
7. Receiving stream or affected surface waters: South Fork Catawba River
a. Classification. WS-III
b. River Basin and Subbasin No.: Catawba 030836
C. Describe receiving stream features and pertinent downstream uses: The receiving
stream has considerable flow, and there are permitted dischargers both upstream
and downstream of this location.

Page Two
PART II - DESCRIPTION OF DISCHARGE AND TREATMENT WORKS
1. a. Actual treatment capacity: 0.130 MGD (Design Capacity)
b. Current permitted capacity: 0.130 MGD
C. Description of existing or substantially constructed WWT facilities: The existing
WWT facilities consist of influent pumps, a bar screen, flow measuring device,
aeration, reaeration, aerated sludge holding, a clarifier, chlorine contact basin with
tablet disinfection, and dechlorination.
d. Description of proposed WWT facilities: There are no proposed WWT facilities at
this time.
e. Possible toxic impacts to surface waters: Chlorine is added to the waste stream,
however, toxic impacts have not been documented at this facility.
2. Treatment plant classification: Class 11 (no change from previous rating).
3. Compliance Background: This facility has a mixed compliance history with both effluent
and DMR violations being recorded. Effluent quality is generally good, however, there
have been some effluent limitation accedences recorded. DMR violations are primarily
centered around a failure to record data on the DMR forms.
PART III - OTHER PERTINENT INFORbIATION
1. Special monitoring or limitations (including toxicity) requests: None at this time.
PART IV - EVALUATION AND RECOMMENDATIONS
The Town of McAdenville (the Town) has requested renewal of the subject NPDES
permit. The only changes/modifications to the WWTP since the permit was last reissued is the
addition of dechlorination facilities. The existing WWTP receives wastewater from 290 out of
the 600 residences located in the Town. The WWTP is very old and is showing signs of
degradation.
In a conversation with a McAdenville Town Administrator, it was learned that the Town
has entered into a partnership with the Town of Lowell and the City of Gastonia to investigate
the possibility of closing both Lowell's and the Town of McAdenville's WWTPs, and sending the
wastewater to the City of Gastonia for treatment. This partnership also involves the City of
Gastonia purchasing the Town of Cramerton's Eagle Road WWTP, and the wastewater from both
Lowell and McAdenville sent to the Cramerton WWTP for final treatment and disposal. Pharr
Yarns is also a part of this partnership, however, they have a clause where they can opt out at any
time. Preliminary design of the infrastructure necessary to collect and transport the wastewater
from the two Towns has begun and a Grant has been applied for to help fund both the design and
construction. McAdenville's Town administrator was confident that the elimination of both
McAdenville's and Lowell's WWTPs would occur during the 5-year term of the new permit.

Page Three
It is recommended that the subject permit be renewed as requested. If any changes, such
as new limits and/or monitoring requirements are proposed in the permit upon renewal,
consideration should be given to incorporating a compliance schedule in the permit so that the
Town will have appropriate time to get the infrastructure designed and built, which will eliminate
the discharge prior to any new effluent limitations becoming effective.
Signature of Report Preparer D6te
q14 � lz---- 011,91
Water Quality Regional Supervisor bate
h 1ds6dsr09hncaden%Ue.doc

FACILITY NAME AND PERMIT NUMBER: PERMIT ACTION REQUESTED: RIVER BASIN:
Ob2 f iv<-Neu,a 60;l+ Fel< ay , i,j
_ FORM "
NPDES
APPLICATION OVERVIEW
- .:". ," r- � ..T;fi.,.;s ✓-Y' ':' +'', f•^:r,'"7;,. '•;y' �`-2J7 .k"�- y;.�`," ,-�-., '
Form 2A has been developed sln a modular format anif.consists of a "Basic Applicattonpinformation"`packet___
and a:'Supplemental Application Information" packet:'The Basic Applslcatton;lnformafion packet is'dlvided
into two parts:-.AII'applicants must complete Parts.A and C: Applicants W- ith'a design flow greater than or.'.
equal 6.6.1 MGD'must also complete Part B.',Some applicants must'also complete the Supplemental...
-Apo.lication lnforniation packet -T14' 'followiiig,iterrtS explain_inrhich parts of Form 2A you.must complete.
BASIC APPLICATION INFORMATION:
A. Basic Application Information for all Applicants. All applicants must complete questions A.1 through A.B. A treatment works.
that discharges effluent to surface waters of the United Slates must also answer questions A.9 through A.12.
B. Additional Application Information for Applicants with a Design Flow z 0.1 MGD. All treatment works that have design flows
greater than or equal to 0.1 million gallons per day must complete questions B.1 through B.6.
C. Certification. All applicants must complete Part C(Certification). -
SUPPLEMENTAL APPLICATION INFORMATION: �� a
D. Expanded Effluent Testing Data. A treatment works that discharges effluent to surfs t o e U�lif t fe dte:et
E)
one or more of the following criteria must complete Part D(Expanded Effluent Testing- t
1. Has a design Flow rate greater than or equal to 1 MGD,
2. Is required to have a pretreatment program (or has one in place), or -
3. Is otherwise required by the permitting authority to provide the information.
E. Toxicity Testing Data. A treatment works that meets one or more of the following.criteri�tnd�4ri90
?'Part E 1T"OX fit e
Data): POINT SOUI_C�L BIRANC
1. Has a design flow rate greater than or equal to 1 MGD,-
2. Is required to have a pretreatment program (or has one in place), or -
3. Is otherwise required by the permitting authority to submit results of toxicity testing.
F. Industrial User Discharges and RCRAICERCLA Wastes. A treatment works that accepts process wastewater from any
significant industrial users(SIUs)or receives RCRA or CERCIA wastes must complete Part F(Industrial User Discharges
and RCRA/CERCLA Wastes), SIUs are defined as:
1. All industrial users subject to Categorical Pretreatment Standards under 40 Code of Federal Regulations(CFR)403.6 and
40 CFR Chapter 1, Subchapter N(see instructions);and
2. Any other industrial user that:
a. Discharges an average of 25,000 gallons per day or more of process wastewater to the treatment works(with certain
exclusions);or
b. Contributes a process wastestream that makes up 5 percent or more of the average dry weather hydraulic or organic
capacity of the treatment plant;or .
c.' Is designated as an 51U by the control authority.
G. Combined Sewer Systems. A treatment works that has a combined sewer system must complete Part G(Combined Sewer.
Systems).
r APPLICANTS MUSTCOMETE PARTCIICERTI�ICAT#ON)
- .. .ac � "ter^.•, _ -
NPDES FORM 2A Additional Information

FACILITY NAME AND PERMIT NUMBER: PERMIT ACTION REQUESTED: RIVER BASIN- ,
t�—
BASI APPLICATION INFORMieiTION - a
PART BASIC qP01115 N INA®RMA Ohl" R LL•A PLICANTS:
.rz �*.:w :�a�a:«setsaanrx3wxsw»*c�. xaiu�r.a.,,M,assv. i
All treatment works must complete questions A-1 through A.8 of this Basic Application Information Packet
A.I. Facility Information. _
Facility Name r I �� G �CA e t 1 l/l1
Mailing Address O ©Y.
�rn dP .� \1ra K) c a 8 l 01
Contact Person
Title
Telephone Number
Facility Address �1) G
(not P.O.Box)
A.2. Applicant Information. If the applicant is different from the above,provide the following:
Applicant Name
Mailing Address
E I
Contact Person
Title
Telephone Number
Is the applicant the owner or operator(or both)of the treatment works? p EN R 1 t `. �D(IJA +L� Y
Elowner B-Operator POINT J` ', _'• L:�t: A VCN
Indicate whether correspondence regarding this permit should be directed to the facility or the applicant.
❑ facility L7 applicant
A.3. Existing Environmental Permits. Provide the permit number of any existing environmental permits that have been issued to the treatment works
(include state-issued permits). h
NPDES A}C b �V PSD
UIC Other
RCRA Other
A.4. Collection System Information. Provide information on municipalities and areas served by the facility. Provide the name and population of each
entity and,if known,provide information an the type of collection system(combined vs.separate)and its ownership(municipal,private,etc.).
Name Population Served Type of Coll ction System Ownership
Totad population served
NPDES FORM 2A Additional Information

FACILITY NAME AND PERMIT NUMBER: P CTION REQUESTED: RIVER BASIN:
Z� 5 a �e-oeA-ja ��tea litR_
A.5. Indian Country.
a. Is the treatment works located in Indian Country?
❑ Yes No
b. Does the treatment works discharge to a receiving water that is either in Indian Country or that is upstream from(and eventually flows
through)Indian Country?
❑ Yes MIN.
A.6. Flow. Indicate the design flow rate of the treatment plant(i.e.,the wastewater flow rate that the plant was built to handle). Also provide the
average daily flow rate and maximum daily flow rate for each of the last three years. Each year's data must be based on a 12-month time period
with the 121°month of"this year"occurring no more than three months prior to this application submittal.
a. Design flow rate m 30 MGD
Two Y/eaar's}Apo Last Year This Year
r
b. Annual average daily flow rate Dr E ]l' • b� V y
C. Maximum daily flow rate
A.7. Collection System. Indicate the type(s)of collection system(s)used by the treatment plant..Check all that apply. Also estimate the percent
contribution(by miles)of each.
Mlgeprte sanitary sewer / Q %
❑ Combined storm and sanitary sewer %
A.8. Discharges and Other Disposal Methods.
a. Does lhe.treatment works discharge effluent to waters of the U.S.? Yes ❑ No
If yes,list how many of each of the following types of discharge points the treatment works uses:
i. Discharges of treated effluent
ii. Discharges of untreated or partially treated effluent _
iii. Combined sewer overflow points
iv. Constructed emergency overflows(prior to the headworks)
V. Other
b.; Does the treatment works discharge effluent to basins,ponds,or other surface impoundments
that do not have outlets for discharge to waters of the U.S.? ❑ Yes o
[(yes,provide the following for each surface impoundment:
Location:
Annual average daily volume discharge to surface impoundment(s) MGD
Is discharge ❑ continuous or ❑ intermittent? .
C. Does the treatment works land-apply treated wastewater"? ❑ Yes
If yes,provide the following for each land application site:
,Location:
Number of acres:
Annual average daily volume applied to site: MGD
Is land application ❑ continuous or ❑ intermittent?
d. Does the treatment works discharge or transport treated or untreated wastewater to another
treatment works? ❑ Yes Jo
i
NPIDES FORM 2A Additional Information

FACILITY NAME AND PERMIT NUMBER: , PERMIT ACTION REQUESTED: RIVER BASIN:
d ' I I e o e c Se�o t!3 Foe a ��
If yes,describe the mean(s)by which the wastewater from the treatment works is discharged or transported to the other treatment works
(e.g.,tank truck,pipe).
If transport is by a party other than the applicant,provide:
Transporter Name
Mailing Address
Contact Person
Title
Telephone Number
For each treatment works that receives this discharge,provide the following:
Name
Mailing Address
Contact Person
Title
Telephone Number i
If known,provide the NPDES permit number of the treatment works that receives this discharge
Provide the average daily flow rate from the treatment works into the receiving facility. MGD
e. Does the treatment works discharge or dispose of its wastewater in a manner not included
in A.8.through A,8.d above(e.g_underground percolation,well injection): ❑ Yes [�
If yes,provide the following for each disposal method:
Description of method(including location and size of site(s)if applicable):
Annual daily volume disposed by this method:
Is disposal through this method ❑ continuous or ❑ intermittent?
NPDES FORM 2A Additional Information

FACILITY NAME AND PERMIT NUMBER: PER"�MiT ACTION REQUESTED: RIVER BASiN:l 0.41e4 ar,
WASTEWATER DISCHARGES:
If you answered"Yes"to question A.8.a,complete questions A.9 through A.12 once for each outfall(including bypass points)through
which effluent is discharged. Do not include information on combined sewer overflows in this section. If you answered"No"to question
A.8.a.go to Part B,"Additional Application information for Applicants with a Design Flow Greater than or Equal to 0.1 MGD."
A.S. Description of Outfall.
a. Outfall number o 0 1
b. - Location -
(Cityortrnm,if applicable) (Zip Code)
(County) (State)
0 t J r- ) o /A 1.-r!
(Latitude) (Longitude)
C. Distance from shore.(if applicable) lJ ft.
d. Depth below surface(if applicable) ft,
e. Average daily flow rate cod MGD
f. Does this outfall have either an intermittent or a periodic discharge? ❑ Yes ILT rvo (go to A.B.g.)
if yes,provide the following information:
Number f times per year discharge occurs:
Average duration of each discharge:
Average flow per discharge-, MGD
Months in which discharge occurs:
g, Is outfall equipped with a diffuser? ❑ Yes t!S'No
A.10. Description of Receiving Waters.
a. Name of receiving water �GIZi ► (�p �� o Cn IGU3B A
b. Name of watershed(if known)
United States Soil Conservation Service 14-digit watershed code(if known):
c" Name of State Managemenl/River Basin(if known):
United States Geological Survey 8-digil hydrologic cataloging unit code(if known):
d. Critical low flow of receiving stream(f applicable)
acute cis chronic cis
e. Total hardness of receiving stream at critical low flow(if applicable): mgA of CaCO3
NPDES FORM 2A Additional information

FACILITY NAME AND PERMIT NUMBER: PERMIT ACTION REQUESTED c RIVER BASIN:
��lx�Tl IOc L �Q lr?ul 1' 1
0
A.11. Description of Treatment
a. What level of treatment are provided? Check atf that apply.
❑ Primary &ed Secondary ~
❑ Advanced ❑ Other. Describe:
b. Indicate the following removal rates(as applicable):
Design BOD5 removal or Design CBOD5 removal %
Design SS removal 8S %
Design P removal %
Design N removal %
Other %
C. What type of disinfection is used for the effluent from this outfall? If disinfection varies by season,please describe:
If disinfection is by chlorination is dechlorination used for this outfall? 4o
Does the treatment plant have post aeration? ❑ Yes 01N,
A.12. Effluent Testing Information. All Applicants that discharge to waters of the US must provide effluent testing data for the following
parameters. Provide the indicated effluent testing required by the permitting authority for each outfall through which effluent is
discharged. Do not include information on combined sewer overflows in this section. All information reported must be based on data
collected through analysis conducted using 40 CFR Part 136 methods. In addition,this data must comply with QAIQC requirements of
40 CFR Part 136 and other appropriate QAlQC requirements for standard methods for analytes not addressed by 40 CFR Part 136. At a
minimum,effluent testing data must be based on at least three samples and must be no more than four and one-half years apart
Outfall number:
sAM
AVERAGE DAfLY HAL�UE
� ZAMa'ETER ,a aD YALULYE
�h•l~u m n ~ A'S, Unl All
OiA x � u
pH es
(Minimum) s.u. .rslrY � ,c
pH(Maximum) � - S.U. -
Flow Rate D• [`3 O {y) —I rn Yl�
Temperature(Winter) C t a)
Temperature(Summer) } G p9 L d at
For pH please report a minimum and a maximum daily value
r f POLLUT - ,
NE
AXINIUM U LAI Y
I�— AA
VERAGE°DAILY,DISCHARGE
fDIIA1,RGE�� IANALYTICAL
Number of MLIMDL
Ir<NT � M TH
• �` , Conc. Unfts_ once `Ui1tffi �
CONVENTIONAL AND NON CONVENTIONAL COMPOUNDS !� -
BIOCHEMICAL OXYGEN BODS 3a 5 �zi� 1J
DEMAND(Report one) CBOD5
FECAL COLIFORM �D b COL /UDrp S Q
TOTAL SUSPENDED SOLIDS(TSS) 30 rn m 25ujD E
ig
END O PAR A. _.
RE ERA. l WO -44—P CA #t N C�10VER1f1E i P CGE DETER#I I� E iVHIC ' �THER'PARTS
OP EQRM . lr ° U�MUS 'COMPLETE � " - .
NPDES FORM 2A Additional Information "

'FACILITY NAME AND PERMIT NUMBER: PE IT ACTION REQUESTED: RIVER BASIN:
OO�Zoc��
c
Y f S r d
r'BASIC� ATI13N INFORMATIONW- 1
APART B: A-D.:OO1N .e..xamP:f PIC.�Aahs O.r�s:�t1 I N_1.aOoMR �A:• TOI FORAPPLICANTS WITHDESIGNt� OWRGi?t EAt7ErvYR T HANOR
JILO M1T00EQiTgallortspe
f
All applicants with a design flow rate z 0.1 MGD must answer questions B.1 through B.B. All others go to Part C(Certification).
BA. Inflow and Infiltration. Estimate the average number of gallons per day that flow into the treatment works from inflow and/or infiltration.
GPD
Briefly explain any steps underway or planned to minimize inflow and infiltration.
B.2. ,Topographic Map. Attach to this application a topographic map of the area extending at least one mile beyond facility property boundaries. This
map must show the outline of the facility and the following information. (You.may submit more than one map if one map does not show-the entire
area.)
a. The area surrounding the treatment plant,including all unit processes.
b. The major pipes or other structures through which wastewater enters the treatment works and the pipes or other structures through which
treated wastewater is discharged from the treatment plant. Include outfalls from bypass piping,if applicable.
c. Each well where wastewater from the treatment plant is injected underground.
d. Wells,springs,other surface water bodies,and drinking water wells that are: 1)within%mile of the property boundaries of the treatment
works,and 2)listed in public record or otherwise known to the applicant.
e. Any areas where the sewage sludge produced by the treatment works is stored,treated,or disposed.
f. If the treatment works receives waste that is classified as hazardous under the Resource Conservation and Recovery Act(RCRA)by truck,rail,
or special pipe,show on the map where the hazardous waste enters the treatment works and where it is treated,stored,and/or disposed.
B.3. Process Flow Diagram or Schomatic. Provide a diagram showing the processes of the treatment plant,including all bypass piping and all
backup power sources or redunancy in the system. Also provide a water balance showing all treatment units,including disinfection(e.g.,
chlorination and dechlorination). The water balance must show daily average flow rates at influent and discharge points and approximate daily flow
rates between treatment units. Include a brief narrative description of the diagram.
13.4. Operation/Maintenance Performed by Contractor(s).
Are any operational or maintenance aspects(related to wastewater treatment and effluent quality)of the treatment works the responsibiRy of a
contractor? ❑ Yes ❑ No
if yes,list the name,address,telephone number,and status of each contractor and describe the contractors responsibilities(attach additional
pages if necessary).
Name:
Mailing Address:
Telephone Number. ( }
Responsibilities of Contractor.
B._5. Scheduled improvements and Schedules of Implementation. Provide information on any uncompleted implementation schedule or
uncompleted plans for improvements that will affect the wastewater treatment,effluent quality,or design capacity of the treatment works. If the
treatment works has several different implementation schedules or is planning several improvements,submit separate responses to question B.5
for each. (If none,_go to question B.6.)
a. List the outfall number(assigned in question A.9)for each outfall that is covered by this_implementation schedule.
b. Indicate whether the planned improvements or implementation schedule are required by local,State,or Federal agencies.
❑ Yes ❑ No
E
NPDES FORM 2A Additional Information

` FACILITY NAME AND PERMIT NUMBER: P T ACTION REQUESTED: RIVER BASIN:
C. If the answer to B.5.b is"Yes,'briefly describe,including new maximum daily inflow rate(if applicable).
d. Provide dates imposed by any compliance schedule or any actual dates of completion for the implementation steps listed below,as
applicable. For improvements planned independently of local,State,or Federal agencies,indicate planned or actual completion dates,as
applicable. Indicate dates as accurately as possible.
Schedule Actual Completion
Implementation Stage MMIDDNYYY MMIDDIYYYY
Begin Construction I I 1 I
End Construction 1 I 1
Begin Discharge 1 1 1 I
Attain Operational Level I I I 1
e. Have appropriate permits/clearances concerning other Federal/State requirements been obtained? ❑ Yes ❑ No
Describe briefly:
B.6. EFFLUENT TESTING DATA(GREATER THAN 0.1 MGD ONLY).
Applicants that discharge to waters of the US must provide effluent testing data for the following parameters. Provide the indicated
effluent testing required by the permitting authority for each outfall through which effluent is discoed. Do not include information
on combine sewer overflows in this section. All information reported must be based on data collected through analysis conducted
using 40 CFR Part 136 methods. In addition,this data must comply with QA/QC requirements of 40 CFR Part 136 and other appropriate
QAIQC requirements for standard methods for analytes not addressed by 40 CFR Part 136. At a minimum effluent testing data must be
based on at least three pollutant scans and must be no more than four and on-halt years old.
Outfall Number:
. z MAXIMUMS t.`EX0 CH' i
., DISCFlARGE ' ANALYTICAL 4
POLLUTANT � _ - iN111iVADL .
ME
rIg !fn tEA ME
C�nc Units t
CONVENTIONAL_AND NON CONVENTIONAL COMPOUNDS
AMMONIA(as N)
CHLORINE(TOTAL
RESIDUAL,TRC)
DISSOLVED OXYGEN
TOTAL KJELDAHL
NITROGEN(TKN)
NITRATE PLUS NITRITE
NITROGEN
OIL and GREASE
PHOSPHORUS(Total)
TOTAL DISSOLVED SOLIDS
(TDS)
OTHER
EU OF PART B;;
.;REFER TD THE APRL)CA_ ?lON�QYERVIEW j�A,GE �) DETERMINE�INHICH.O�HER�PARTS
- � OF;FQRM"2A�1l�U MUST'COMPLETE
NPDES FORM 2A Additional Information

Y5 ,
FACILITY NAME AND PERMIT NUMBER: P IT ACTION REQUESTED: RIVER BASIN:
k.
BASIC A.P.11ICA 10N 1N1"ORMATIDN
zr MIS M-11- '-E-1
PAR3C. CERTIFICATION j fi
.,- i1
All applicants must complete the Certification Section. Refer to instructions to determine who is an officer for the purposes of this
certification. All applicants must complete all applicable sections of Form 2A,as explained in the Application Overview. Indicate below which
parts of Form 2A you have completed and are submitting. By signing this certification statement,applicants confirm that they have reviewed
Form 2A and have completed all sections that apply to the facility for which this application is submitted.
;'BasicApplicatiDn
ic to which parts of Form 2A you have completed and are submitting:'
information packet Supplemental Application Information packet:
❑ Part D(Expanded Effluent Testing Data)
© Part E(Toxicity Testing: Biomonitoring Data)
El Part F(Industrial User Discharges and RCRAICERCLA Wastes)
❑ Part G(Combined Sewer Systems)
Air.App�tcAHrstusacaM>*ilrK.n c.cl:taTt> c�ir�oK
I certify under penalty of law that this document and al]attachments were prepared under my direction or supervision in accordance with a system
designed to assure that qualified personnel property gather and evaluate the information submitted. Based on my inquiry of the person or persons who
manage the system or those persons directly responsible for gathering the information,the information is,to the best of my knowledge and belief,true,
accurate,and complete. i am aware that there are significant penalties for submitting false information,including the possibility of fine and imprisonment
for knowing violations,
Name and officiaf title
Signatures u
Telephone number O
Date signed
Upon request of the permitting authority,you must submit any other information necessary to assure wastewater treatment practices at the treatment
works or identify appropriate permitting requirements.
SEND COMPLETED FORMS TO: `
NCDENRI DWQ
Attn: NPDES.Unit
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
NPDES FORM 2A Additional Information

FACT SHEET FOR EXPEDITED PERMIT RENEWALS
Basic Information to determine potential for expedited permit renewal
Reviewer/Date e fw- CA' Cl K Z-,vi a) July 9, 2009
Permit Number NC00 0052
Facility Name McAdenville WWTP
Basin-Name/Sub-basin number 30836
Receiving Stream S,zy� , rl z,
Stream Classification in Permit G— \A/L jL
Does permit need NH3 limits? YES / xNO
Does permit need TRC limits? YESX / NO
Does permit have toxicity testing? YES / `ANO
Does permit have Special Conditions? YES / NO
Does permit have instream monitoring? YES 1 XNO
Is the stream impaired (on-3 03(d) list)? YES / xN0
Any obvious compliance concerns? 29 cases, 4 NOVs
Any permit mods since lastpermit? YES /X NO
Existing expiration date 1/31/2010
New expiration date
New permit effective date
Miscellaneous Comments
Review-Compliance issues
YES _ This is a SIMPLE EXPEDITED permit renewal (administrative
renewal with no changes, or only-minor changes such as TRC, NH3,
name/ownership changes).
YES This is a MORE COMPLEX EXPEDITED permit renewal (includes
Special Conditions (such as EAA, Wastewater Management Plan), 303(d)
listed, toxicity testing, instream monitoring, compliance concerns, phased
limits). Basin Coordinator to make case-by-case decision.
YES This permit CANNOT BE EXPEDITED for one of the following reasons:
• Major Facility (municipal/industrial)
• Minor Municipals with pretreatment program
Minor Industrials subject to Fed Effluent Guidelines (lb/day limits for BOD, TSS,
etc)
• Limits based on reasonable potential analysis (metals, GW remediation organics)
• Permitted flow> 0.5 MGD (requires full Fact Sheet) 4
• Permits determined by Basin Coordinator to be outside expedited process
TB Version 8/18/2006 (NPDES Server/Current Versions/Expedited Fact Sheet)