WQ0031031_Regional Office Historical File Pre 2018

Mich.ae/ F. Easley, Governor
William Cr. Ross Jr,, Secretary
North Carohna Department of Environinent and Natural Resources
Alan W Klttnck,RE. Director
.Di vision of Water Quality
November 21, 2006
Mr, Wilmer Melton, Dir. Of Public Works
City of Kannapolis
1401 Bethpage Road
Kannapolis, NC 28081
Subject: Permit No, WQ0031031
Mallard Pointe Estates
City of Kannapolis
Wastewater Collection System Extension
Cabarrus County, North Carolina
Dear Mr, Melton,
In accordance with your application received on October 23, 2006, we are forwarding herewith
Permit No. WQ0031031, dated November 21, 2006, to the City of Kannapolis for the construction and
operation of the subject wastewater collection system extension, This permit shall be effective from the
date of issuance until rescinded, and shall be subject to the conditions and limitations as specified
therein. This cover letter shall be considered a part of this permit and is therefore incorporated therein
by reference.
Please pay particular attention to Permit Condition 3 which requires that the wastewater
collection facilities be properly operated and maintained in accordance with 15A NCAC 2T .0403 or any
individual system -wide collection system permit issued to the Permittee.
Permitting of this project does not constitute an acceptance of any part of the project that does
not meet 1) 15A NCAC 2T; 2) the Division of Water Quality's (Division) Gravity Sewer Minimum Design
Criteria adopted February 12, 1996, as applicable; 3) and the Division's Minimum Design Criteria for
the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000, as applicable,
unless specifically mentioned herein. Division approval is based on acceptance of the certification
provided by a North Carolina -licensed Professional Engineer in the application. It shall be the
Permittee's responsibility to ensure that the as -constructed project meets the appropriate design criteria
and rules. Failure to comply may result in penalties in accordance with North Carolina General Statute
§143-215.6A through §143-215.6C, construction of additional or replacement wastewater collection
facilities, and/or referral of the North Carolina -licensed Professional Engineer to the licensing board.
Mooresville kegronal Office 610 East Center Ave., Suite 301 Mooresville, NC 28115 Phone. [phone] Fax [phone]
Internet: vivirtv,ncrnwaterqual4.org Customer Service 1-877-623-6748
An Equal OpporlunitylAtfirmative Action Employer —50% Recyclod110% Post Consumer Paper
Qrc
NorthCaroima
Vahmil/

Mr. Melton
Page 2
November 21, 2006
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North
Carolina as amended, and other applicable Laws, Rules, and Regulations, permission is hereby
granted to the City of Kannapolis for the construction and operation of approximately 1,056 linear feet
of 15-inch gravity sewer and 276 linear feet of 16-inch gravity sewer, and the discharge of 0 gallons per
day of collected domestic wastewater into the City of Kannapolis existing sewerage system, pursuant to
the application received October 23, 2006, and in conformity with 15A NCAC 2T; the Division's Gravity
Sewer Minimum Design Criteria adopted February 12, 1996, as applicable; the Division's Minimum
Design Criteria for the Fast -Track Permitting of Pump Stations and Force Mains adopted June 1, 2000,
as applicable; and other supporting data subsequently filed and approved by the Department of
Environment and Natural Resources and considered a part of this permit.
The sewage and wastewater collected by this system shall be treated in the Water and Sewer
Authority of Cabarrus County VVVViP (Rocky River NPDES No, NC0036269) prior to being discharged
into the receiving stream.
If any parts, requirements, or limitations contained in this permit are unacceptable, you have the
right to request an adjudicatory hearing upon written request within 30 days following receipt of this
permit. This request must be in the form of a written petition, conforming to Chapter 150B of North
Carolina General Statutes, and filed with the Office of Administrative Hearings, 6714 Mail Service
Center, Raleigh, NC 27699-6714, Unless such demands are made, this permit shall be final and
binding,
If you need additional information concerning this matter, please contact Dee Browder at (704)
663-1699.
Sincerely,
cc: Mooresville Regional Office, Surface Water Protection (WVVTP Permit No. NC0036269)
William Cochran, W. Earl Cochran & Son, Inc.
Surface Water Protection Central Files
Tom Asenzo, PERCS

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
RALEIGH
WASTEWATER COLLECTION SYSTEM EXTENSION PERMIT
This permit shall be effective from the date of issuance until rescinded and shall be subject to the
following specified conditions and limitations:
1 This permit shall become voidable unless the wastewater collection facilities are constructed in
accordance with the conditions of this permit; 15A NCAC 2T; the Division of Water Quality's
(Division) Gravity Sewer Minimum Design Criteria adopted February 12, 1996, as applicable; the
Division's Minimum Design Criteria for the Fast -Track Permitting of Pump Stations and Force
Mains adopted June 1, 2000, as applicable; and other supporting materials unless specifically
mentioned herein.
2. This permit shall be effective only with respect to the nature and volume of wastes described in the
application and other supporting data.
3. The wastewater collection facilities shall be properly maintained and operated at all times. The
Permittee shall maintain compliance with an individual system -wide collection system permit for the
operation and maintenance of these facilities as required by 15A NCAC 2T .0403. If an individual
permit is not required, the following performance criteria shall be met as provided in 15A NCAC 2T
.0403:
a. The sewer system shall be effectively maintained and operated at all times to prevent
discharge to land or surface waters, and any contravention of the groundwater standards in
15A NCAC 2L .0200 or the surface water standards in 15A NCAC 2B .0200.
b. A map of the sewer system shall be developed and shall be actively maintained.
c. An operation and maintenance plan shall be developed and implemented,
d. Pump stations that are not connected to a telemetry system shall be inspected every day (i.e.
365 days per year). Pump stations that are connected to a telemetry system shall be
inspected at least once per week.
e. High -priority sewer lines shall be inspected at least once per every six-month period of time.
f. A general observation of the entire sewer system shall be conducted at least once per year.
g. Inspection and maintenance records shall be maintained for a period of at least three years.
h. Overflows and bypasses shall be reported to the appropriate Division regional office in
accordance with 15A NCAC 2B .0506(a), and public notice shall be provided as required by
North Carolina General Statute §143-215.1C.

4. This permit shall not be transferable, In the event there is a desire for the wastewater collection
facilities to change ownership, or there is a name change of the Permittee, a formal permit request
shall be submitted to the Division accompanied by documentation from the parties involved, and
other supporting materials as may be appropriate. The approval of this request shall be
considered on its merits and may or may not be approved.
5. Construction of the gravity sewers, pump stations, and force mains shall be scheduled so as not to
interrupt service by the existing utilities nor result in an overflow or bypass discharge of wastewater
to the surface waters of the State.
6. Per 15A NCAC 2T .0116, upon completion of construction and prior to operation of these
permitted facilities, the completed Engineering Certification form attached to this permit shall be
submitted with the required supporting documents to the address provided on the form. A complete
certification is one where the form is fully executed and the supporting documents are provided as
applicable,
7. A copy of the construction record drawings shall be maintained on file by the Permittee for the life
of the wastewater collection facilities
Failure to abide by the conditions and limitations contained in this permit: 15A NCAC 2T: the
Division's Gravity Sewer Design Criteria adopted February 12, 1996 as applicable; the Division's
Minimum Design Criteria for the Fast -Track Permitting of Pump Station and Force Mains adopted
June 1, 2000 as applicable; and other supporting materials may subject the Permittee to an
enforcement action by the Division, in accordance with North Carolina General Statutes §143-
215,6A through §143-215.6C.
9 In the event that the wastewater collection facilities fail to perform satisfactorily, including the
creation of nuisance conditions, the Permittee shall take immediate corrective action, including
those as may be required by this Division, such as the construction of additional or replacement
facilities.
10. The issuance of this permit shall not exempt the Permittee from complying with any and all
statutes, rules, regulations, or ordinances that may be imposed by other government agencies
(local, state and federal) which have jurisdiction, including but not limited to applicable river buffer
rules in 15A NCAC 2B .0200, erosion and sedimentation control requirements in 15A NCAC Ch. 4
and under the Division's General Permit NCG010000, and any requirements pertaining to wetlands
under 15A NCAC 2B .0200 and 15A NCAC 2H .0500.
11. Noncompliance Notification:
The Permittee shall verbally report to a Division of Water Quality employee at the Mooresville
Regional Office, telephone number [phone], as soon as possible, but in no case more than
24 hours or on the next working day, following the occurrence or first knowledge of the occurrence
of either of the following*
a. Any process unit failure, due to known or unknown reasons, that renders the facility incapable
of adequate wastewater transport, such as mechanical or electrical failures of pumps, line
blockage or breakage, etc.; or
b. Any failure of a pumping station or sewer line resulting in a by-pass directly to receiving waters
without treatment of all or any portion of the influent to such station or facility.

Voice mail messages or faxed information is permissible, but shall not be considered as the
initial verbal report. Overflows and spills occurring outside normal business hours may also be
reported to the Division of Emergency Management at telephone number (800) 58 03 or
[phone], Persons reporting any of the above occurrences shall file a spill report by
completing Part! of Form C - O (or the most current Division approved form), within five days
following first knowledge of the occurrence, This report shall outline the actions taken or
proposed to ensure that the problem does not recur. Part 11 of Form C-O (or the most
current Division approved form) can also be completed to show that the SSO was beyond
control.
Permit issued this the 21st<day of November, 2006.
NORTH CA OLINA ENVIRONMENTAL MANAGE ENT COMMISSION'
b Alan" ' . Klimek, RE., Director
i i ion of Water Quality
y Authority of the Environmental
Permit Nturiber \%Q0031031
Bement Commission

Fast Track Engineerin
Permit No, WQ0031031
November 21, 2006
Wilmer Melton, Dir. Of PW
1401 Bethpage Rd
Kannapolis, NC 28081
Certification
Complete and submit this form to the permit issuing regional office with the following:
• One copy of the project record drawings (plan & profile views of sewer lines) of the wastewater collection
system extension
• Supporting design calculations (selected pumps, system curve, operating point, available storage if portable
generator(s) or storage greater than longest past three year outage reliability option selected) for any pump
stations permitted as part of this project
• Changes to the project should be clearly identified on the record drawings or in written summary form. Permit
modifications are required for any changes resulting in non-compliance with this permit, regulations or
minimum design criteria.
This project shall not be considered complete nor allowed to operate until this Engineer's Certification and all
required supporting documentation have been received by the Division, Therefore, it is highly recommended
that this certification be sent in a manner that provides proof of receipt by the Division.
ENGINEER'S CERTIFICATION
r Partial Final
as a duly registered Professional Engineer in the State of North Carolina, having been
authorized to observe (0 periodically, Ej weekly, Ej full time) the construction of Mallard Pointe Estates, a Cabarrus
County project for the Permittee, hereby state that, to the best of my abilities, due care and diligence was used in the
observation of the construction such that the construction was observed to be built within substantial compliance of
this permit; 15A NCAC 2T; the Division of Water Quality's (Division) Gravity Sewer Minimum Design Criteria adopted
February 12, 1996 as applicable; the Division's Minimum Design Criteria for the Fast -Track Permitting of Pump
Stations and Force Mains adopted June 1, 2000 as applicable; and other supporting materials.
North Carolina Professional Engineer's
seal, signature, and date:
SEND THIS FORM & SUPPORTING DOCUMENTATION
WITH REQUIRED ATTACHMENTS TO THE FOLLOWING ADDRESS
MOORESVILLE REGIONAL OFFICE
SURFACE WATER PROTECTION
610 EAST CENTER AVENUE, SUITE 301
MOORESVILLE NC 28115
The Permittee is responsible for tracking all partial certifications up until a final certification is received. Any
wastewater flow made tributary to the wastewater collection system extension prior to completion of this
Engineer's Certification shall be considered a violation of the permit and shall subject the Permittee to appropriate
enforcement actions.

CK APPLICATION for G
TT
Y SEWERS, PUMP STATIONS, AND FORCE MAINS PAGE 3
USE THE TAB KEY TO MOVE FROM FIELD TO FIELD!
Owner:
la. City of Kannapolis
Full Legal Name (company, municipality, HOA, utility, etc)
Application Number:
(to be completed by DWQ)
• lb, Wilmer Melton, ill - Director of Public Works
Signing Official Name and Title (Please review 1 A NCAC 2H ,0206(b) for authorized signing officials!
lc, The legal ent4. who will own this system is
4‘, LJ Individual Li Federal P Municipality D State/County LJ Private Partnership EJ Corporation El Other (specify):
ld. 1401 Bethpage Rd
O Mailing Address
Z if, NC
State
O 1 h. 704-920-4200
Telephone
IL 704-920-4244
Facsimile
2, Project (Facility) Information:
• 2a. Mallard Pointe Estates- 5" Sewer Relocation
a. lief Project Name (perinit will refer to this name
' 3, Contact Person:
▪ 3a, W. E. Cochran, Jr. PE
Name and Affiliation of Someone Who Can Answer Questions About this Application
3b, 704,782,1456 3c, bill [e-mail]
Phone Number E-mail
0
LL
th
1 e, Kannapolis
City
1g, 28081
Zip Code
. wmelton@ci,kannapolisric,u
E-mail
2b, Cabarrus
County Where Project is Located
1. Project is New El Modification (of an existing permit) If Modification, Permit No.:
For modifications, attach a separate sheet clearly explaining the reason for the modification i.e. adding another
phase, changing line size/length, etc.). Only include the modified information in this permit appHcaton - do not
duplicate project information in B(7) and B(10-11) that has already been included in the original permit.
2. Owner is Public (skip to Item 8(3)) EJ Private (go to Item 2(a))
2a If private, applicant will be: 2b. If sold, facilities owned by a (must choose one)
Ej Retaining Ownership (i.e. store, church, single office, etc.) or EJ Public Utility (Instruction III)
El Leasing units (lots, townhomes, etc - skip to Item 8(3)) E Homeowner Assoc/Developer (Instruction IV)
I] Selling units (lots, townhomes, etc. - go to item B(2b))
3. Water & Sewer Authority of Cabarrus County
Owner of Wastewater Treatment Facility (WWTF) Treating Wastewater From This Project
4a, Rocky River Regional Wastewater Treatment Plant 4b. NC0036269
Name of WWTF WWTF Permit No,
5a, Kannapolis 5b. 15 Z Gravity 5c.
Owner of Downstream Sewer Receiving Sewer Size D Force Main Permit Number of Downstream Sewer (if known)
The origin of this wastewater is (check all that apply): Relocation
Ej Residential Subdivision E] Car Wash
El Apartments/Condominiums 1:1] Institution
El Mobile Home Park LJ Hospital
LI School LJ Church
Restaurant El Nursing Home
ED Office E] Other (specify):
7. Volume of wastewater to be allocated for this particular project: 0 gallons per day
*Do not include previously permitted allocations
8. If the permitted flow is zero, indicate why:
El Interceptor Line - Flow will be permitted in subsequent permits that connect to this line
Flow has already been allocated in Permit No,
nr ronlanoment of oxistinn sowor with nn now flaw Ft xnactpd
% Domestic/Commercial
% Industrial
% Other (specify):

". APPLICATION for G
7
'ERS. PUMP STATIONS, ANO FORCE MAINS PAGE 4
Provide the wastewater flow calculations used in determining the pemiitted flow in accordance with 15A NCAC 2H
.0219(1) for Item B(7) or the design flow for line or pump station sizing if zero flow in the space below, Values other than
that in 15A NCAC 2H .0219(1)(1-2) must be supported with actual water or wastewater use data in accordance with 15A
NCAC 2H 0219(1)(3).
N/A
10. Surnmary of Sewer Lines to be Permitted (attach additional sheets if necessary)
Size (inches)
15'
16"
Length (feet)
1056,85
276,09
z
0 ENTER TOTAL LINE LENGTH IN MILES 0 0306
z
0
2
0
Summary of Pump Stations to be Permitted (attach additional sheets as necessary)
Gravity or Force Main
(use the pull down menu)
GRAVITY
GRAVITY
Location ID Power Reliability Option
(self chosen - as shown on Design Flow Operational Point (1- dual line feed; 2- permanent generator wIATS; 3-
plans for cross-reference) (MGD) GPM a TDH portable generator 1N/telemetry; 4-wet well storage)
2 12, Does the sewer system comply with the Minimum Design Criteria for the Fast Track Permitting of Pump Stations and Force
ce Mains (latest version), the Gravity Sewer Minimum Design Criteria (latest version) and 15A NCAC 2H ,0200 as applicable?
W Yes 0 No If no, please reference the pertinent minimum design criteria or regulation and indicate why a
0- variance is requested, SUBMIT TWO COPIES OF PLANS, SPECIFICATIONS OR CALCULATIONS
..,Z PERTINENT TO THE VARIANCE WITH YOUR APPLICATION
LIJ
13, Have the following permtsIcertifcations been submitted for approval?
Wetland/Stream Crossings - General Permit or 401 Certification? 0 Yes El No El N/A
Sedimentation and Erosion Control Plan? Ej Yes ED No El N/A
Stormwater? El Yes Ej No N/A
14, Does this project involve aerial lines or siphons? El
These lines will be considered high priority and must be checked once every six months

z
Ci
co
2
0
CK APPLICATION for G '
RS, P P STATIONS, AND FORCE MAINS PAGE ,,
1. Use the Division's guidance document entitled, "DETERMINING STREAM CLASSIFICATIONS FOR FORM FTA 02/03
(FAST -TRACK SEWER SYSTEMS)" to collect and record the stream classification data below (attac)i additional sheets as
necessary), This document is available from our web site or by contacting the appropriate Division of Water Quality
regional office (see instructions for addresses) OR indicate the following:
El A Stream Classification is not needed because all parts of the project are at least 100 feet away from any down slope
waterbody, AND,
A Stream Classification is not needed because the design does not depend on wet well storage as a power reliability
option for any pump station near a Class C down slope waterbody.
Location ID on Map
(self chosen - as shown on Name of Waterbody Stream Waterbody
map for cross-reference) Waterbody County River Basin Index Classification
SS Lake Concord Cabarrus Yadkin 13-17-9-4-2- WSlV
r9)
Submit the 8.5" x 11" COLOR topographic map as required in Instruction VI
regardless of whether a classification is provided!
1. Applicant's Certification
1, Wilmer Melton, Dir. Public Works, attest that this application for Mallard Point Estates — 15" Sewer Relocation
has been reviewed by me and is accurate and complete to the best of my knowledge I understand that if all required
pads of this application are not completed and that if all required supporting documentation and attachments are not
included, this application package is subject to being returned as incomplete. Note. In accordance with North Carolina
General Statutes 143-215.6A and 143-215,68, any person who knowingly makes any false statement, representation, or
certification in any application shall be guilty of a Class 2 misdemeanor which may include a fine not to exceed $10,000
as well as civil penalties up to $25, 000 per violation.
la
Signing Official Signature
2. Professional Engineer's Certification:
- 0 6
Date
I attest that this application for Mallard Pointe Estates-15" Sewer Relocation has been reviewed by me and is
accurate, complete and consistent with the information in the engineering plans, calculations, and all other supporting
documentation to the best of my ,knowledge, further attest that to the best of my knowledge the proposed design has
been prepared in accordance with the applicable regulations, Gravity Sewer Minimum Design Criteria for Gravity Sewers
adopted February 12, 1996, and the Minimum Design Criteria for the Fast -Track Permitting of Pump Stations and Force
Mains adopted June 1, 2000 and the watershed classification in accordance with Division guidance. Although certain
portions of this submittal package may have been developed by other prefessionals, inclusion of these materials under my
signature and seal signifies that 1 have reviewed this material and have judged it to be consistent with the proposed design.
Note In accordance with NC General Statutes 143-215 6A and 143-215,6B, any person who knowingly makes any false
statement, representation, or certification in any application shall be guilty of a Class 2 misdemeanor which may include a
fine not to exceed $10,000 as well as civil penalties up to $25,000 per violation.
2a. William E Cochran, Jr,,
Professional Engineer Name
2b. W. Earl Cochran & Son, Inc
Engineering Firrn
2c. 191 Eastover Dr. SE
Mailing Address
2d Concord
City
2e. NC 2f, 28025
State Zip
2g. 704,782.1456 2h. 704,782,1456 2i. bill_paitievolocorn
Telephone Facsimile E-mail
S E
Seal, Signature & Date

RA

Permit Number
Central Files APS SWP
1 20/
Permf Tracking Sitp
Program Category Status Project Type
Non -discharge Active New Project
Permit Type t Track Version Permit Classification
Gravity Sewer Extension, Pump Stations, Pressure Sewer 1,00 individual'
Extensions
Primary Reviewer
dee
Permitted Flow
0
ity Name
Ballard Pointe Estates
Location Address
Owner
Owner Name
Dry of Kannapolis
Dates/Even'
Ong issrie
11 /20/06'
App Received Draf
10/23/06
Regulated Acttvltl s
ubrdivisioii
�rti"asteauak
Ott all NULL
rbody Name
rtita
Permit Con
et A t`iliahor
Region
nor Mooreville
County
abarrus
Facility Contact Affiliation
Owner Type
Government 4 Municipal
Owner Affiliation
Melvin
Scheduled
d issuance
PO Box1199
iannolts
Rape, PE
NC 28081119
Public Notice Effective Expiration
11/20/ 11/20/06
iieguested/Received Events
ditranal it formation requested
ddiiional information receive
Index Number Carri
Class
Subbasin

BOST PROPERTIES
PO. BOX 1111
CONCORD, NC 28026-1111
PAY TO THE
ORDER OF City of Kannapolis
CENTRAL CA.ROLINA BANK
CONCORD, NORTH CAROLINA 28025
66-46-531 9/25/2006
V400.00
2328
Four Hundred and 00100*****.***********************************.**.i,****************..****.m***********.*******
DOLLARS 1,j
MEMO
002326Hs 1:0 3 0 0 4 651: 28 I LB -7724o

Septem er 7,
006
NC Div of Environmental Management
agement
Department ment of Environment and Natural Re c urces —Di~ isiarn of Quality
610 East Center Drive, Suite 31
Mooresville, orth Carolina 28115
Re: IMallmd Pointe 1 Tinch sever relocati
City of Kannapolis _ Cabaimus County
Dear Sir r Madam:
l}3501
Please find attached for your revie v and approval lie original and one copy F of tl e permit
applicati as and a check for $400.00 for the processing fee for the above reference project. The
project is a relocation of existing main with no new flow expected.
The Water and Sea er Authority ,, of Caharrus County Stanl cations fcar Wastewater
eater
Collections Systems were approved by your office- and are being- maintained by the l i =asiara a
Environmental Management, This project 8\i11 be Installed in accordance with these Standard
Specifications.
Please call mat ti - -1 S l it you have y quest] arcs
er°el ,
Stephen A F is Inger. P
ssistan City Engineer
03501 231 -inch Sewer ^ r r i ()n. n
. A9;aiaa tit... Ka nap:o.i $C. ? CY#S1